Integralift user guide
Contents
1. 10 Technical Data Warranty 2 years Lifecycle 10 years with service agreement 10 000 lifting cycles Maximum load 230 kg Battery 24 V DC 4 5 Ah sealed lead battery 40 lifting cycles Battery charger 100 240 VAC 50 60 Hz max 1 300 mA Lifting speed 50 70 mm sec Lifting interval strap 1 8 m vertically adjustable Diameter of action 3m Radius of action 1 5m Soft start and soft stop Emergency stop Electrical Emergency lowering Electrical and mechanical Operating forces hand Control 4 5 N Sound level 69 dB Weight 95 kg Int op Protection class IP 20 Intermittent operation Int op 20 80 active operation max 1 min at SWL Integralift is quality certified in accordance with e ISO 10535 2006 E e IEC 60601 1 Ed 3 0 b 2005 e IEC 60601 1 2 Ed 3 0 b 2007 A Product for indoor use Type B in accordance with the electrical shock protection class Class I equipment in accordance with MDD 93 42 EEC e Temperature 10 grd C og 40grd C e Relative humidity 10 til 93 e Lightning level ambient luminance minimum 300 lux Integralift 230 User manual rev 2 6 17 Symptom The lift strap IS clearly worn The lifter does not work The lifter runs up but not down Beeps continuously The lifter beeps when raising the User The lifter makes unusual sounds EMC interference Integralift 230 User manual rev 2 6 11 Simple Troubleshooting Possible action Get the lift strap replaced immediately by contac2. and Assistant A special attention has been given to an easy placement of the sling under the To ensure the best function and comfort Integra recommends individual testing of slings Integra always recommends the use of the original Integra slings with Integralift TYPE OF SLINGS D0176 D0175 D0174 D0177 D0173 D0205 SIZES xS XL Integra Universal Integra Universal w headrest Integra Active low back Integra Bathroom Integra Shell Integra Amputation User weight 15 30 kg 25 50 kg 45 90 kg 75 150 kg 140 230 kg WASHING SLINGS The slings can be washed at 80 C With autoclave 85 C MAINTENANCE SLINGS Max load 230 kg 230 kg 230 kg 230 kg 230 kg Sizes XS S M L xL XS S M L xL XS S M L xL XS S M L xL XS S M L xL XS S M L xL Colour code Yellow Orange Red Green Violet Inspect the slings regularly and always after washing Check that fabric seams and loops are not worn Use only undamaged and unworn slings Worn and damaged slings shall be destroyed and recycled Integralift 230 User manual rev 2 6 9 Maintenance Cleaning Clean the outer surfaces occasionally with a cloth and warm water soapy water or disinfectant Don t use any detergents with phenol or chlorine Monthly maintenance e Check that the user manual is at hand in the cabinet e Check the lifter and make sure there are no damage e Check the lift strap for wear e Check the Lifting bar for damage e Run th
3. comfortable and safe lift plan it in advance Move any obstacles before the lifting starts Make sure that wheels on wheelchair bed etc are locked before the lifting starts Ensure that all four loops of the sling are securely fastened to the lifting bar o This has to be checked both before the lift strap is tensioned and before the User is lifted from the ground Make sure the User is sitting securely in the sling before the transfer The User should hang as low as possible during transfer facing the direction of the movement Never leave the User unattended in the sling Integralift 230 User manual rev 2 6 10 Movement from bed to chair 1 Open the vertical cabinet and find the proper sling for the User Place the sling under the User and stretch out the loops of the sling If the bed can be raised to a sitting position this will ease the strain for the User Alternative 1 sling from the side Alternative 2 sling from the back 2 Cross the leg support one loop through the other Integralift 230 User manual rev 2 6 11 3 Open the vertical cabinet You ll find the Lifting bar hanging on a dedicated handle The lifter is positioned by pulling the Lifting bar with both hands ll 31 E j RNA a Grab the Lifting bar swing the lifter forward and orient it above the User Unhook the Lifting bar from the handle Lower or raise the Lifting bar to the correct height just above the User Close th
4. d will stop the lifter immediately The emergency stop is activated by pulling the red string so that the socket comes off and you will hear three beeps In order to reset the emergency stop push the socket back in You will then hear two beeps Integralift 230 User manual rev 2 6 8 Electrical emergency lowering If the lifter should stop working use the electrical emergency lowering to get the User down safely Press the black emergency button until the User is safe on the bed or chair Mechanical emergency lowering If the electrical emergency lowering fails the User can be lowered mechanically Make sure the User will be lowered to a suitable location To start the procedures follow these two steps 1 Onthebackofthe top cabinet you will find a small window with a green switch stand on a footstool Flick the switch from green to black 2 Pull the black string intermittent some seconds at the time keeping the User at a secure speed Alternative if a bed with raising function is available raise the bed until the sling can be removed in a secure manner Warning If you have been forced to use the mechanical emergency lowering device contact your service partner see backside of this user manual before further use of the lifter Integralift 230 User manual rev 2 6 9 A 7 Lift and movement About lift and movement Make sure the User s weight is under max user weight for the lifter See the front page For a
5. e lift up and down to see that it operates normally and without any unusual noise e Check that all brackets are intact and that the wall ceiling and floor where the lift is mounted are undamaged e Check that the lifter can be moved to its extremes e Make sure that the remote control works e Make sure the electrical emergency lowering Is working e Check emergency stop by pulling it out and try to run the lifter up and down e Check that the battery charger with outlet are intact e Check that the lift is marked with a maximum user weight Contact your service partner if anything does not work properly Annual control The lifter must be controlled by authorized personnel at least once a year according to the service manual Any repairs must be done by authorized personnel using original spare parts The owner of the product must make sure that the annual inspection is carried out Contact your supplier or service partner for a service agreement Warranty Integralift has 2 years warranty Warranty information is obtained from the supplier Integralift 230 User manual rev 2 6 16 Shipping Transport and storage During shipping transport and storage we recommend to use the original packaging Store Integralift above 10 C and at a relative humidity of 30 to 93 Recycling All parts made of steel are recycled as steel or as mixed metals Screws and connections are recycled as mixed metals National regulations must be followed
6. e vertical cabinet Integralift 230 User manual rev 2 6 12 4 Hook the sling loops to the Lifting bar NOTE the Lifting bar must be oriented as shown Make sure the sling loops are properly fastened pull the loops and check visually B Raise the User partially from the bed Make sure the sling loops are properly fastened when the lift strap is tightened but before the User is off the bed Raise the User to the correct height for the transfer Warning If the lifter should stop and start beeping the lifter may be overburdened Make sure that the sling does not get stuck If the user weighs more than the safe working load abort the lift immediately V Integralift 230 User manual rev 2 6 18 6 Position the User over the chair wheelchair etc by gently moving the User If the chair has brakes make sure they are on Lower the User and make sure the User is well positioned in the chair Release the sling from the Lifting bar and then from under the User Open the vertical cabinet and hang the sling in place Place the remote control on the handle closest to the red string and the Lifting bar on the other handle Swing the lifter back in the cabinet HINT Do not raise the Lifting bar after use Then it will be in the correct height for the next lift Integralift 230 User manual rev 2 6 14 User 8 Sling Program Integra s own range of slings make the transfer secure and comfortable for both User
7. ealer Integralift 230 User manual rev 2 6 saraa EE I Jdvivddery Producer Integra Care Products AS Darres gate 22 0175 Oslo NO Phone 47 21 98 26 84 E mail info integralift net www integralift net 20
8. g is the correct type adapted to both User and lifting bar The sling is mounted correctly around the User The sling is fastened correctly to the Lifting bar before the User is lifted from the bed Integralift 230 User manual rev 2 6 3 2 Product description Integralift is a non intrusive patient lifter from Norway that offers a safe and efficient workplace Non intrusive Integralift creates a more attractive room for the User and gives a subtle expression Integralift appears as an elegant designed furniture which encloses the user s bed and becomes a natural part of the room s interior e Cabinets can be special ordered in different colours to fit its environments e Downlights Personalize the top cabinet with this option Safe amp efficient Integralift is designed to ease the whole transfer process e Everything in place always The Lifting bar sling and remote in dedicated places e No charging routines Connected to mains and always fully charged e Flexible dropping points Easy installing Integralift can be easily fitted in most homes or institutions Integralift 230 User manual rev 2 6 4 3 Main components Integralift consists of a vertical cabinet and a top cabinet where the lift is integrated The lifting bar and remote control have dedicated places in the vertical cabinet The person being lifted is hereby called the User and the one giving assistance is called Assistant Lifter activated Lifter ins
9. ide cabinet 1 Vertical cabinet 5 Front jib 8 Lifting bar 2 Top cabinet 6 Battery charger 24V 9 Remote control 3 Vertical structure BEE SE 10 Emergency stop 4 Back jib et Shae 11 Sling Integralift 230 User manual rev 2 6 5 4 Dimensions Model Capacity A B C D E WM 230 230 kg 220 226 124 89 35 FC 230 230kg 230 330 IW 230 230kg 230 500 All measurements A G in centimeters Integralift 230 User manual rev 2 6 5 Before first time use Remote control The remote control socket is mounted in the outlet on the underside of the front jib Push the socket till you hear a click Lifting bar The Lifting bar is correctly mounted to the swivel in the end of the lift strap Power The lifter s battery charger is always connected to the batteries and the charger should always be connected to a 100 240V AC electric socket Backup battery In case of a power cut the lifter has a backup battery that lasts until 40 lifts before recharging Integralift 230 User manual rev 2 6 7 6 Handling Remote control The remote control has two buttons one for raising and one for lowering the User The arrows on the buttons indicate the direction Raising or lowering starts when one of the buttons are pushed gently and stops when the button is released Hint To be able to lower the Lifting bar without a User the Lifting bar must hang freely Emergency stop The emergency stop should be used in emergency situations an
10. integra care products Integralift 230 SWL 230kg User manual English revision 2 6 Table of Contents ES RR A 3 gt PONNI 4 3 Main components ad ee en en ee nn ee ie nn 5 d DIMENT aea ee ee EE ee 6 5 Before first time USE ii 7 6 ACC REE 8 ENN 10 SO PN 15 EE AN aa 16 RE EEE EE 17 SEE 18 Explanation of symbols ce CE Warning Read User manual l Product for indoor use Integralift 230 User manual rev 2 6 2 A A 1 Safety Max user vveight Max user vveight SVVL for Integralift 230 is 230 kg IMPORTANT Integralift must only be operated by personnel with the proper training to do so Read this User manual before operating Integralift and please keep the manual at hand for everyone using Integralift This product must be installed by authorized personnel only Do not modify the equipment Only use parts delivered by Integra Do not leave the User suspended in the sling Before first time use make sure that Installation is correctly done tested and signed by authorized personnel The Lifting bar is correctly mounted User manual is read and completely understood The emergency lowering switch is working Before lifting always make sure that The Lifting bar is fastened correctly to the lift strap The lift strap is not twisted or worn The lifter can run up and down and power cable is connected to the mains There are no visible damages on Integralift or the sling The slin
11. ting your service partner see the last page for phone number 1 2 3 2 3 4 Check that the remote control is correctly connected Check that the emergency stop is correctly connected Pull the emergency stop out and plug it in again to reset the lifter Check that the battery charger is connected to an electric socket Try electrical emergency lowering Make sure that the switch for the mechanical emergency lowering is switched to green see emergency lowering procedure If the lifter still doesn t work contact your service partner See the last page for phone number Pull the lifting bar down while lowering some tension on the strap is needed for lowering Check that the remote control is correctly connected Use the electrical emergency lowering to lower the User Contact your service partner see last page Voltage on batteries too low 1 2 Check that charger is plugged in Observe that charger changes color when lifting and lowering with load Contact your service partner see last page Control that max user weight is not exceeded Pull the emergency stop out and plug it in again to reset the lifter Make sure that the sling is not stuck Contact your service partner See last page If experiencing interference with other products consult the dealer or an experienced radio TV technician for help integralift patient lift Integralift 230 User manual rev 2 6 integralift patient lift D
Download Pdf Manuals
Related Search