MINI-PASTEURMATICTM
Contents
1. OLYMPIC MINI PASTEURMATIC Fast turn around Low cost non toxic Timer Displays cycle Printout time remaining Printed record of l pasteurization cycle Water temperature 7 35 eo Push button to display amp PASTEURMATIC in either F or C Stainless steel tank and lid For long life and durability Perforated parts basket a IE Rotates to release trapped air e and drain water Convenient size Fits on any counter top Thermostatically controlled Heater maintains water temperature at desired pasteurization temperature from 160 to 170 F 71 1 to 76 7 C Laryngoscope blades And other very small Rust Proof parts protected in Aluminum exterior mesh bags Dimensions 26 W x 21 75 D x 18 H closed 28 open 66 cm W x 55 cm D x 46 cm H closed 71 cm open For high level disinfection combine pasteurization with bio clean drying OLYMPIC STERILE DRIERS Electrical Requirements 120V 60 Hz 8 5A 9 ft cord with hospital grade connector Model 44 Model 43 Electrical Safety CSA NRTL C certified to CSA 60601 1 and UL 2601 1 Manufactured to Olympic s strict safety standards Large capacity fast drying ae r B Servicing If required service is easily performed by hospital 1 Ong Ferg technicians Complete service manual furnished Parts available Uses HEPA aca on overnight express basis Toll free hotline to Olympic Medical filtered bio cl2. a minimum of 158 F for 30 minutes Pasteurization is a proven safe and effective method of reprocessing anesthesia and respiratory care parts Thousands of hospitals have been using Olympic Pasteurmatics for the past 25 years Counter top Convenience The new Mini Pasteurmatic is ready for quick reprocessing and fits on any convenient countertop It requires no floor space no plumbing no special ventilation and no electrical wiring just plug it in And your staff doesn t have to wear protective clothing as they must with glutaraldehyde Quick Turnaround The Mini Pasteurmatic is simple and easy to use Place the pre washed parts in the perforated basket attached to the lid Close the lid and the parts are completely submerged in hot water To remove air trapped in hollow parts rotate the basket a couple of times by turning the handle on the lid Then press the Start button to time the 30 minute pasteurization cycle At the end of the 30 minute cycle the Cycle Time Remaining display goes blank and an audible signal sounds Lift the lid and turn the basket handle to drain water from the parts Remove the parts from the basket and place them in a Sterile Drier for drying No rinsing required as with glutaraldehydes High level disinfection in just 30 minutes without toxic chemicals Costs only pennies per load uses only hot water A built in recorder prints out time and temperature at five minute intervals during
3. e Organizations CDC Centers for Disease Control and Prevention APIC Association for Professionals in Infection Control and Epidemiology CSA Canadian Standards Association 1 Loading Parts Lift lid until it locks in place with basket out of water Open basket and load parts N Submerging Basket Lower the lid and the parts basket is completely submerged in hot water 3 Vertical Rotation Turn handle to rotate basket and release trapped air inside hollow parts Ensures all surfaces are in complete contact with hot water 4 Start Timer Press start button to begin the 30 minute countdown The displays show time remaining and water temperature 5 End of Cycle Visual and audible signals indicate the end of 30 minute cycle Raise lid and unload basket 6 Cycle Validation Printout records time and temperature during the 30 minute pasteurization cycle
4. ean iue fu for technical assistance Factory servicing by Olympic Medical air for safer drying and packaging Ordering Information OLYMPIC MINI PASTEURMATICrm Complete with 2 mesh parts bags and 2 mesh laryngoscope bagS ceeeeeee Cat No 58210 n at U S For Information call 1 800 303 0306 Natus Medical Incorporated toll free in US Canada 1501 Industrial Road San Carlos CA 94070 USA 1 800 303 0306 1 650 802 0400 www natus com DOC 001554A Printed USA OLYMPIC MINI PASTEURMATIC Counter top Pasteurizer for high level disinfection of breathing circuits laryngoscope blades and other parts Nothing toxic no chemicals or fumes Quick reprocessing with 30 minute cycle Convenient size takes up no floor space e Pennies per cycle uses only hot water OLYMPIC MINI PASTEURMATIC Some respiratory care and anesthesia departments still use glutaraldehyde to disinfect patient breathing equipment such as circuits masks laryngoscope blades and other parts Glutaraldehyde however is toxic and can cause allergic reactions As a result OSHA requires special ventilation and protective clothing when using glutaraldehyde And local environmental regulations may make glutaraldehyde disposal difficult and expensive The new Olympic Mini Pasteurmatic eliminates glutaraldehyde It achieves high level disinfection with simple non toxic hot water pasteurization immersion in water at
5. the cycle giving you a record to validate that the pasteurization cycle has been successfully completed Pays for Itself The new Olympic Mini Pasteurmatic will soon pay for itself by saving time labor and money It processes small loads of parts quickly and with less labor than using glutaraldehyde You don t waste time putting on gloves and masks or cautiously transferring toxic chemicals to buckets The Mini Pasteurmatic is always at pasteurizing temperature ready for immediate use At the end of the pasteurization cycle there are no toxic chemicals to dispose of The Mini Pasteurmatic also saves money directly Instead of expensive chemical disinfectants with limited shelf life the machine uses hot water In addition pasteurization is easier on rubber and plastic than harsh chemical disinfectants prolonging the life of parts Most importantly you avoid exposing your staff to potential health hazards from glutaraldehyde fumes splashes and spills You ll soon discover that the Olympic Mini Pasteurmatic is one of your department s best investments High Level Disinfection with Hot Water Pasteurization Pasteurization kills pathogenic vegetative bacteria and viruses of concern by immersion in water at a minimum temperature of 158 F 70 C for 30 minutes Pasteuriza tion has been recognized as suitable for the high level disinfection of semi critical parts by JCAHO Joint Commission for the Accreditation of Healthcar
Download Pdf Manuals
Related Search
MINI PASTEURMATICTM