COLD SHOT - Cornelius
Contents
1. 15 NI H3MOd i 2 SNC PEEN 1 L pm YIOAYASAY ASSVHD LIDNaAO4Yd AN a T Ou wo THM j L L La es um LVLSOWYIHL m my Im TA TA m dl Bi Le Lre a i LI Teo un 95 eal in w5 Le In ax 000 HOLIMS 3905539 HOLIMS NV4 HOSS2HdNOD 1nO SLT0A 0L YASNAGNOD Gadd YM YNINLS 7 iP Sai ken m m m Iit i 3 Y3TIOYLNO E Le YAWYOASNVYL AA ne ne e m 1 ME E i 1 9 dOL AI1MOTIIA JOVLIOA 2006 IMI Cornelius Inc Publication Number 6210582010PR Gua Cold Shot Owner s Manual PARTS CHANGEOUT SIDE PANEL REMOVAL 1 Remove the screws on the side panel 2 Slide the panel back and then pull it out to remove Remove Screws 2006 IMI Cornelius Inc 5 Publica2. bottom of unit are firmly sitting on a level surface IMPORTANT Allow 4 inches of clearance on each side and rear of the unit for proper ventilation of the refrigeration system If proper clearance is not maintained the compressor will not be able to keep the product cold CAUTION To avoid damage to the compressor it must be in an upright position at lease 4 hours before plugging the unit in 2 Clean tank with soap solution Then flush out the tank with warm tap water Whenever emptying the tanks completely the unit needs to be tilted forward at a 45 degree angle to ensure all liquid is removed 3 Pour product into the unit reservoir tanks It will take about 1 5 liter of product to fill each tank for the first time Invert the last bottle vertically and let it sit upside down on the tank inlet 4 Plugunit into GFCI outlet for use Let the unit s refrigeration system cool down the reservoirs for approximately 2 3 hours After the appropriate cool down time has lapsed the compressor will continue to cycle on and off to keep product cool The product will then dispense between 5 F and 15 F OPERATING INSTRUCTIONS To operate depress lever of respective brand beverage and continuous dispense will occur As the level in the tank decreases the internal tank is automatically filled by evacuation of the bottle on top When a bottle on top of the unit is completely empty it must be replaced immediately with a full bottle of the same product
3. or performance will degrade To maintain proper cooling capacity and prevent freezing it is recommended to replace empty bottles immediately with full bottles Use the visual slots in bottle holders as a guide to determine volume remaining inside the top bottle The unit is supplied with single handed operation faucets This allows the bar staff serving the cold shots the capability of using one hand to hold the glass while simultaneously activating the lever to allow beverage to flow If the valve lever is raised forward and vertical it then allows free flow of the product from the respective faucet This mode is used for filling large glasses pitchers cleaning or emptying the tanks Do not tighten down on nut on valve as this will affect the tank to valve seal If the dispenser fails to dispense product see troubleshooting guide 2006 IMI Cornelius Inc 1 Publication Number 6210582010PR Cold Shot Owner s Manual Geha MAINTENANCE DAILY on as REQUIRED Clean faucets externally with clean wet towel Wipe down unit with damp cloth and rinse out drip tray with soap solution MONTHLY on as REQUIRED Make sure when cleaning the tanks that unit is unplugged Clean tank with soap solution Vacuum condenser coils in back of unit BRAND CHANGEOVER Clean and sanitize tank with proper cleaning procedure Follow the Cleaning Tanks procedure and step 2 of the Start up procedure for each flavor being changed CL
4. EANING INSTRUCTIONS Soap solution Use a mixture of mild detergent and warm 100 F potable water Sanitizing solution Use ounce of household bleach in 1 gallon of potable water Preparing the sanitizing solution to this ratio will create a solution of 200 PPM DisPENSER MAINTENANCE Cleaning Exterior Surfaces IMPORTANT Perform the following daily Remove cup rest from drip tray Wash the drip tray with soap solution Then rinse with clean water Wash cup rest with soap solution and rinse in clean water Install the cup rest into the drip tray Clean all exterior surfaces with soap solution and rinse in clean water Vacuum dust from grill on back of unit Qr Re occ Cleaning Tanks 1 Unplug unit Remove product from tanks Rinse out tanks with soap solution Rinse out tanks with potable water Open the faucet and tilt entire unit forward at a 45 degree angle to completely drain each tank otherwise the residual water and soap solution will remain inside the tanks Publication Number 6210582010PR 2 2006 IMI Cornelius Inc gt Cold Shot Owner s Manual TROUBLESHOOTING IMPORTANT Only qualified personnel should service internal components or electrical wiring Should your unit fail to operate properly check that there is power to the unit If the unit does not dispense check the following chart under the appropriate symptoms to aid in locating the defect Trouble Probabl
5. OU LLLA COLD SHOT Operator s Manual with Installation and Service Release Date April 20 2006 Publication Number 6210582010PR Revision Date NA Revision A Visit the IMI Cornelius web site at www cornelius com for all your Literature needs gt SERVICE MANUAL The products technical information and instructions contained in this manual are subject to change without notice These instructions are not intended to cover all details or varia tions of the equipment nor to provide for every possible contingency in the installation operation or maintenance of this equipment This manual assumes that the person s working on the equipment have been trained and are skilled in working with electrical plumbing pneumatic and mechanical equipment It is assumed that appropriate safety precautions are taken and that all local safety and construction requirements are being met in addition to the information contained in this manual To inquire about current revisions of this and other documentation or for assistance with any Cornelius product contact www cornelius com 1 800 468 4231 Trademarks and copyrights Aurora Cornelius FlavorFusion Hydro Boost Optifill Pinnacle and Vanguard are regis tered trademarks of IMI Cornelius Inc This document contains proprietary information and it may not be reproduced in any way without permission from Cornelius Printed in U S A Copyright 2006 All Rights R
6. e Cause TRIPPED CIRCUIT BREAKER Short circuit in wiring Circuit breaker overloaded Out of product Clog in valve body Lever not attached Thermostat setting incorrect Unit not plugged in Circuit breaker tripped Defective refrigerator deck Unit capacity exceeded No power Switch turned off Lights burnt out PRODUCT DOES NOT DISPENSE PLOW D gt wm gt PRODUCT WARM LIGHTS DO NOT TURN ON owWPmMODNMm SERVICE PARTS Cladding Panel RH Side 620052965 Cladding Panel LH Side 620052966 Drip Tray 620046271 Cup Rest sheet metal 620708546 Thermostat 620314421 Plug Silicone Thermowell 620519024 Valve Assembly includes Lever 620608787 Lever 620709345 O Ring 310784000 Window Clear Side 620052944 Guard Top Light qty 2 per unit 620047511 Screw long 10 32 x 7 8 Phillips functional 620720802 Screw short TF 8 16 x 1 4 Phillips decorative 620720596 Decal pack of two large side rectangular shape 620920157 Decal pack of six small front brands wedge shape 620920156 Label COLD SHOT side qty 2 per unit 620921118 Label caution front triangular shape 620921119 Label Drink Responsibly front drip tray 620921120 Lens clear Top Light 620518226 Lens red Top Light 620518227 2006 IMI Cornelius Inc 3 Publication Number 6210582010PR Cold Shot Owner s Manual WIRING DIAGRAM ZH 09 LIOA OZL
7. eserved IMI Cornelius Inc Guli TABLE OF CONTENTS Start up InstructiOnS s s v9 nk la Operating Instructions eee eee Maintenance sos Saunas a eww ee eon aa ee eu nate wee Daily or as required lt a tte es Monthly or as required aka Brand Changeover Cleaning Instructions uo a ven aah eet ee wot eee hans Dispenser Maintenance Cleaning Exterior Surfaces Cleaning ata su kb e i oce da Troubleshooting iu ax A RE a a p RR SONIC ak k A s Wiring a Parts ChangeoUt A Beate v Re a Side Panel Removal taea 3 it S Ss NAAA RR Thermostat Replacement Lever Replacement Valve Change Servicing TOP EIGN ke dan dee ote ee Gets gt Cold Shot Owner s Manual DRINK RESPONSIBLY If you do choose to drink please do so responsibly Alcohol use by persons under the age of 21 is illegal and is not condoned by IMI Cornelius START UP INSTRUCTIONS 1 Place unit on a sturdy countertop near a safe GFCI electrical outlet Ensure all four feet on
8. tion Number 6210582010PR Cold Shot Owner s Manual Cines gt THERMOSTAT REPLACEMENT 1 Remove silicone plug 2 Remove nut and then remove the thermostat Silicone Plug Nut and Thermostat LEvER REPLACEMENT 1 Push a blunt object up into the faucet opening 2 Pullthe lever forward to remove NX EN Faucet aN j Lever T ell Publication Number 6210582010PR 6 9 2006 IMI Cornelius Inc gt Cold Shot Owner s Manual VALVE CHANGE OVER 1 Unscrew the entire valve body 2 Replace the o ring and screw the valve back in place 3 Tighten the nut onto the o ring 2006 IMI Cornelius Inc 7 Publication Number 6210582010PR Cold Shot Owner s Manual Cines gt SERVICING LIGHT 1 Slightly twist and pull up on the top light 2 Unplug the harness and replace the LED board LED Board Publication Number 6210582010PR 8 2006 IMI Cornelius Inc IMI Cornelius Inc www cornelius com
Download Pdf Manuals
Related Search