Home

LIPPERTCOMPONENTS, INC. - Prime Time Manufacturing

image

Contents

1. extend the RETRACT light should be OFF NOTE By pushing RIGHT both passenger side Level Up jacks operate pushing LEFT both driver s side Level Up jacks operate and so on NOTE The side to side movement in manual mode is limited to 5o of tilt ZERO SETTING THE CONTROL 1 Turn ON OFF button OFF 2 Push FRONT button 10 times 3 Push REAR button 10 times 5 To memorize this level condition press ENTER 6 LCD says 7 The control will then turn off 8 Turn ON OFF on to commence operation REPLACEMENT COMPONENTS 242752 VERTICAL PUMP NEED PART NUMBER FOR THE VERTICAL PUMP 195861 LEVEL UP JACK 177094 CARTRIDGE VALVE 176954 SPADE COIL 194712 4 WAY MANIFOLD 241314 TOUCH PAD HARNESS 241318 9 PIN HARNESS 241317 CONTROLLER TO SATELLITE HARNESS 234802 TOUCH PAD 232201 SATELLITE LEVEL SENSOR 241129 LEVEL UP CONTROLLER 142927 PSI SWITCH 118246 TROMBETTA MOTOR SOLENOID 138421 RED RESTRICTED FLOW BLOCK Fig 5 Fig 4 Fig 6 WIRING DIRECTIONS 241314 3 position harness Con
2. FLUID RECOMMENDATION The Lippert Hydra Electric 5th Wheel Leveling System hydraulic unit PREVENTATIVE MAINTENANCE PROCEDURES RESERVOIR ONLY every 36 months retracted position Filling reservoir when retracted 3 Inspect and clean all Pump Unit electrical connections every 12 months If corrosion is evident spray unit with WD 40 or equivalent 4 Remove dirt and road debris from jacks as needed 5 If jacks are down for extended periods it is recommended to spray exposed leveling jack rods with a silicone lubricant every seven days for protection If your coach is located in a salty environment it is recommended to spray the rods every 2 to 3 days
3. LCI LEVEL UP WITH AUTOMATIC LEVELING OPERATION AND SERVICE MANUAL LIPPERTCOMPONENTS INC WARNING FAILURE TO ACT IN ACCORDANCE WITH THE FOLLOWING MAY RESULT IN SERIOUS PERSONAL INJURY OR DEATH THE USE OF THE LCI LEVEL UP WITH AUTOMATIC LEVELING SYSTEM TO SUPPORT THE UNIT FOR ANY REASON OTHER THAN WHICH IT IS INTENDED IS PROHIBITED BY LIPPERT S LIMITED WARRANTY THE LIPPERT LEVELING SYSTEM IS DESIGNED AS A LEVELING SYSTEM ONLY AND SHOULD NOT BE USED TO PROVIDE SERVICE FOR ANY REASON UNDER THE COACH SUCH AS CHANGING TIRES OR SERVICING THE LEVELING SYSTEM LIPPERT COMPONENTS INC RECOMMENDS THAT A TRAINED PROFESSIONAL BE EMPLOYED TO CHANGE THE TIRE ON THE UNIT ANY ATTEMPTS TO CHANGE TIRES OR PERFORM OTHER SERVICE WHILE UNIT IS SUPPORTED BY THE LCI LEVEL UP WITH AUTOMATIC LEVELING SYSTEM COULD RESULT IN DAMAGE TO THE 5TH WHEEL AND OR CAUSE SERIOUS INJURY OR DEATH WARNINGS gt BE SURE TO PARK THE UNIT ON SOLID LEVEL GROUND gt CLEAR ALL JACK LANDING LOCATIONS OF DEBRIS AND OBSTRUCTIONS LOCATIONS SHOULD ALSO BE FREE OF DEPRESSIONS gt WHEN PARKING THE
4. PERT AT 866 524 7821 031411 revB ERROR DISPLAY IN LCD 1 If an error occurs before or during operation the error will be displayed in the LCD and a buzzer will sound 2 The errors that will be displayed are a EXCESS ANGLE gt relocate the unit b BAD CALIBRATION gt bad zero point c FEATURE DISABLE d LOW VOLTAGE e OUT OF STROKE gt relocate the unit f EXTERNAL SENSOR gt bad connection to rear remote sensor g JACK TIME OUT gt system could not level in expected time check for obstructions leaks h AUTO LEVEL FAILURE gt retry i gt rear stabilizers ran too long bad motor or connections j NOT CONFIGURED gt unit was not zeroed properly k To clear error push ENTER gt if error remains it will appear again
5. RAULIC 1 Front jacks NOTE The front jacks will operate manually any time system is ON except AUTO MODE 1 Push ON OFF to turn system on 2 Push UP ARROW once or until screen reads MANUAL MODE 3 Push ENTER once while screen reads MANUAL MODE 4 Push FRONT to extend front landing gear legs 5 Push RETRACT and orange LED Fig 6 comes on 6 Push FRONT to retract front landing gear legs NOTE If orange LED is on legs will retract If orange LED is off legs will extend 7 Push ON OFF to turn system off 8 After 3 minutes system will turn off by itself 2 Level Up jacks EXTEND a Turn ON OFF button ON b Push scroll arrow to display MANUAL MODE see Fig 4 c Push ENTER see Fig 4 MANUAL MODE displayed Fig 5 Level Up jacks RETRACT e To retract push RETRACT orange LED lights up see Fig 6 f Push REAR to retract all Level Up jacks g To
6. UNIT ON EXTREMELY SOFT SURFACES UTILIZE LOAD DISTRIBUTION PADS UNDER EACH JACK gt PEOPLE AND PETS SHOULD BE CLEAR OF UNIT WHILE OPERATING LEVELING SYSTEM gt BE SURE TO KEEP HANDS AND OTHER BODY PARTS CLEAR OF FLUID LEAKS OIL LEAKS IN THE LIPPERT LEVELING SYSTEM MAY BE UNDER HIGH PRESSURE AND CAN CAUSE SERIOUS SKIN PENETRATING INJURIES BASIC JACK OPERATION 1 Front jacks or Landing gear jacks 2 Level Up jacks Landing gear jacks can be operated any time the system is ON but NOT in the AUTO MODE By pushing the FRONT button both front or landing gear jacks can be extended If the touch panel is put in the RETRACT mode indicated by the orange illuminated LED next to the RETRACT button the front jacks can be retracted together by pushing the FRONT button The Level Up jacks operate when the AUTO MODE is activated or the touch panel is in the MANUAL MODE Once system is in MANUAL MODE pressing the REAR button will extend all Level Up jacks at the same
7. e landing gear jacks close to level The driver side rear jack will then extend and touch the ground followed by the passenger side rear jack There may be several level checks from the system at this time 7 When auto level is complete LCD indicates READY Jacks Down and the green light in the middle of the jack buttons will light Fig 3 D 8 Push ON OFF button to turn system off or system will time out and shut off automatically Fig 2 Touch Panel B C A RECONNECTING THE UNIT TO A TOW VEHICLE 1 Be sure main power switch ON 2 LCD display will indicate READY JACKS DOWN 3 Push LEFT and RIGHT buttons at the same time 4 Unit will raise up to the point where the AUTO LEVEL was started normal starting point from where it was disconnected from the tow vehicle 5 Connect tow vehicle and make sure 5th wheel and pin are connected and locked 6 Push UP arrow until AUTO RETRACT appears in LCD screen 7 Push ENTER System will immediately retract all jacks MANUAL OPERATION HYD
8. time Press the LEFT or RIGHT buttons to operate Level Up jacks to move on the left or right side of the coach respectively PRIOR TO OPERATION The leveling system shall only be operated under the following conditions 1 The unit is parked on a reasonably level surface 2 Be sure all persons pets and property are clear of the coach while LCI Level Up Automatic System is in operation D Fig 3 Touch Panel Unit Level DROPPING OFF UNIT 1 Push touch panel ON OFF Fig 2 A to turn system on LCD Screen lights up Fig 2 B 2 LCD will display status NOT READY JACKS UP NOTE Orange arrow lights Fig 2 C may come on indication the current disposition of the unit in this case the FRONT and RIGHT sides of the unit are low 3 Push FRONT BUTTON to extend landing gear jacks and lift front of vehicle to take the weight of the 5th wheel off of the hitch 5 Pull tow vehicle away and park at a safe distance 6 Push AUTO LEVEL The unit will commence to auto level by setting th
9. troller to Satellite 241318 9 position harness Controller to Pump Connections Deutsch Connector to PSI Switch Grey Wire to Hydac Valve on Hydraulic Landing Leg Purple Wire to D S Level Up Hydac Valve Blue Wire to P S Level Up Hydac Valve Red Wire to Power White Wire to Ground Green to Retract Spade Connector on Pump Motor Solenoid Yellow to Extend Spade Connector on Pump Motor Solenoid 241316 4 position harness Controller to Touch Panel 241317 6 position harness Brain to Power Supply RED to Battery Power Blue Unused WARNING Your coach should be supported at both front and rear axles with jack stands before working underneath Failure to do so may result in personal injury or death 6 If jacks are down for extended periods it is recommended to spray exposed leveling jack rods with a silicone lubricant every seven days for protection If your coach is located in a salty environment it is recommended to spray the rods every 2 to 3 days IF YOU HAVE ANY PROBLEMS OR QUESTIONS CONSULT YOUR LOCAL AUTHORIZED DEALER OR CALL LIP

Download Pdf Manuals

image

Related Search

Related Contents

Shuttle Computer Group Server KD21 User's Manual  Indesit IWC 61451 ECO  商品保証について  Samsung Galaxy Tab 3 8.0 16GB Brown, Gold  VOLVERE i7  Blood Glucose Monitoring System  Manual de Instalação do Gateway Ethernet EGX100 PowerLogic  Menu de definição  JVC ShowView LPT1100-001A User's Manual    

Copyright © All rights reserved.
Failed to retrieve file