Nokia 6710 Navigator Service Manual L1&2
Contents
1. until the camera retaining clips are released Lift up the SS 100 and remove the CAMERA Wk yoke E 15 Use the charger plug to detach the DC jack including the light guide from C COVER ASSY Remove the DC jack with the tweezers w 17 Use the SS 93 to lift up the IHF SPEAKER Remove the IHF SPEAKER GASKET with the tweezers The speaker the speaker adhesive and the gasket cannot be reused 4 x ER I 23 18 Carefully lift up the ANTENNA ASSY with the dental tool The ANTENNA ASSY has always to be renewed 14 Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 6710 Navigator RM 491 Service Manual Level 1 amp 2 a Ps TANI rh y d s MORIS X EN f Ay vd 19 To detach the FUNCTION KEYMAT first release Use the S SRT 6 to mem lift up the FUNCTION these two clips with the SS 93 KEYMAT Make sure the keymat is completely detached car aes C e AY 2111 The FUNCTION KEYMAT can be removed I 22 Move the SLIDE to the opposite side 23 Unscrew the two TORX size 4 screws in the gt A I Insert the SS 93 between the A COVER ASSY m order shown Do not use them again the SLIDE ASSY Slide the SS 93 around the upper block to detach the SLIDE ASSY from A COVER ASSY 15 Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 6710 Navigator RM 491 Service2. Service Manual Level 1 amp 2 T Carefully release the two clips with the SS 93 8 Use the SS 93 to the MAIN FLEX from Insert the SS 93 between the upper and lower block the engine board While opening the connector be and lift the upper block slightly Be careful with the careful to not to damage it components underneath 9 The upper block can now be separated 10 Use the SS 93 to disconnect the CONNECTING FLEX from the engine board Be careful with the components around the connector Then separate HIS BOARD ASSEM BLY TEM 2 m 7 o gt M Ne 1 11 the CONNECTING FLEX first open 12 Detach the ALPHA DOMESHEET with the dental the locking mechanism of the connector with the tool Be aware of the sharp point of the dental tool SS 93 Then separate the flex Be careful not to be careful to not to injure yourself The ALPHA damage the connector KEYMAT ADHESIVE and the ALPHA DOMESHEET cannot be reused 13 Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 6710 Navigator RM 491 Service Manual Level 1 amp 2 6 e R 0 0 0 5 M e S 7 eeee eee ee ee ee ee rry ves 1111 4 1 11711 y 3 Sa Ww NY f 13 Lift up the LIGHT SWAP PWB
3. Manual Level 1 amp 2 25 Before the A n be WERE make sure 26 Remove the SLIDE ASSY in the direction shown that the CAPACITIVE FLEX is detached from the A Be careful with the hooks on the bottom side of the COVER A COVER 2T Protect the LCD with protective film B 28 Use the toolto open the four s holding the UI BOARD ASSEMBLY i MG OA 29 Turn the Ul BOARD ASSEMBLY as o to gain 30 Use the SS 93 to unlock the locking mechanism acces to the L D connector of the L D connector While opening the connector be careful to not to damage the connector 16 Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 6710 Navigator RM 491 Service Manual Level 1 amp 2 AS 44 14 5 32 lift the LCD with the 55 93 gap y 33 Use the 55 93 to carefully detach the MAIN FLEX 34 Use the dental tool to lever out the EARPIECE Do ASSY from the SLIDE MODULE The MAIN FLEX ASSY not use the EARPIECE again cannot be used again MAIN FLEX ADHESIVE UPPER LOWER have always to be renewed END OF DISASSEMBLY 35 Nokia 6710 Navigator disassembly is now complete 17 Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care 11 ASSEMBLY HINTS Nokia 6710 Navigator RM 491 Service Manual Level 1 amp 2 1 Tighten the two size 4 screws to the torque of 12Ncm in the or
4. watch always out for the newest version 3 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 2 COPYRIGHT Copyright 2009 Nokia All rights reserved Reproduction transfer distribution or storage of part or all of the contents in this document in any form without the prior written permission of Nokia is prohibited Nokia Nokia Connecting People and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation Other product and company names mentioned herein may be trademarks or tradenames of their respective owners Nokia operates a policy of continuous development Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice Under no circumstances shall Nokia be responsible for any loss of data or income or any special incidental consequential or indirect damages howsoever caused The contents of this document are provided as is Except as required by applicable law no warranties of any kind either express or implied including but not limited to the implied warranties of merchantability and fitness for a particular purpose are made in relation to the accuracy reliability or contents of this document Nokia reserves the right to revise this document or withdraw it at any time without prior notice The availability of particular products may v
5. 6 eW u uu uuu uu 9 DNE auci OVJ O 10 11 10 Disassembly instructions 12 11 18 17 Solder components 19 2 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 1 CHANGE HISTORY Status NersionNo _ Dae Comments Approved 10 10062009 ss The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products This Service Manual is to be used only by authorized NOKIA service suppliers and the content of it is confidential Please note that NOKIA provides also other guidance documents e g Service Bulletins for service suppliers follow these regularly and comply with the given instructions While every endeavor has been made to ensure the accuracy of this document some errors may exist If you find any errors or if you have further suggestions please notify NOKIA using the address below CMO Operation amp Logistics Training and Vendor Development Multimedia Creation amp Support mailto Service Manuals nokia com Please keep in mind also that this documentation is continuously being updated and modified so
6. Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 SERVICE MANUAL Level 1 amp 2 NOKIA e 710 Navigator RM 491 Transceiver characteristics Band WCDMA 900 1900 2100 GSM EDGE 850 900 1800 1900 Display 2 6 QVGA 320x240 16 M colours Keypad Alphanumeric keypad and Function keypad E No calendar entnes today JB Intermelpanu My content setup Camera 5MP Carl Zeiss Dual LED flash secondary camera CIF for video calling Operating System S60 3rd Edition Feature Pack 2 Connections Micro USB connector with charging capability 3 5 mm Nokia AV connector 2 mm DC jack connector Bluetooth 2 0 A GPS WLAN 802 11b g Transceiver with BL 5F battery pack Talk time Standby GSM Up to 380 hours Note Talk times are dependant on network parameters and phone settings 1 Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 Table of contents E o oap V uu 3 DOING RRRRRRRRK E 4 3 Warnings and 10110 D SN 5 22 11015 222005 0 5 4 ESD proleto 6 5 AUG IT VAN A E uuu uuu Omm T 0 i 01 8 T Explod
7. ary by region IMPORTANT This document is intended for use by qualified service personnel only 4 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 3 WARNINGS AND CAUTIONS Please refer to the phone s user guide for instructions relating to operation care and maintenance including important safety information Note also the following 31 Warnings 1 CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI SKID BRAKING SYSTEMS UNDER CERTAIN FAULT CONDITIONS EMITTED RF ENERGY CAN AFFECT THEIR OPERATION IF NECESSARY CONSULT THE VEHICLE DEALER MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY 2 THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES EG PETROL STATIONS SERVICE STATIONS BLASTING AREAS ETC 3 OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT INCLUDING CELLULAR TELEPHONES MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE 3 2 Cautions 1 Servicing and alignment must be undertaken by qualified personnel only 2 Ensure all work is carried out at an anti static workstation and that an anti static wrist s
8. ator 491 Service Manual Level 1 amp 2 FUNCTION KEYMAT 10002 ALPHA KEYMAT 10201 A3 UI ASSY 10202 10203 ALPHA KEYMAT ADHESIVE 10202 ALPHA DOMESHEET T 10203 UI BOARD 2 N CONNECTING FLEX ASSY 10204 FUNCTION KEYMAT ADHESIVE jij 278 3 10105 _ fF FUNCTION DOMESHEET rj lt 10104 WINDOW MAIN FLEX ADHESIVE LOWER jj 10102 SLIDE MODULE 10103 RAPUYAMA SHIELD LID 10205 LIGHT SWAP PWB 10207 TYPE LABEL 153 10208 SPEAKER 10210 SPEAKER GASKET 10211 P N CCOVER 10214 i n INTERNAL ANTENNA 10215 BATTERY COVER ASSY 10217 Only available as These parts can not be assembly reused after removal Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care 8 SERVICE DEVICES FLS 5 Flash Device BL 5F Battery 10 Nokia 6710 Navigator RM 491 Service Manual Level 1 amp 2 CA 101 Service Cable AC 8 Travel Charger NOKIA Standa Toolkit V2 NMP standard toolkit v2 For more information refer to the Service Bulletin SB 011 on NOKIA 55 100 Camera removal tool Online Supplier or manufacturer contacts for tool re order can be found in Recommended service equipment document on NOKIA Online Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 9 SW UPDATE Flas
9. cur when a metallic object coin clip or pen causes direct connection of the and terminals of the battery metal strips on the battery for example when you carry a spare battery in your pocket or purse Shortcircuiting the terminals may damage the battery or the connecting object Leaving the battery in hot or cold places such as in a closed car in summer or winter conditions will reduce the capacity and lifetime of the battery Always try to keep the battery between 15 C and 25 C 59 F and 77 F A phone with a hot or cold battery may temporarily not work even when the battery is fully charged Batteries performance is particularly limited in temperatures well below freezing Do not dispose batteries in a fire Dispose of batteries according to local regulations e g recycling Do not dispose as household waste 8 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care T EXPLODED VIEW WINDOW ASSY 10001 A1 A COVER ASSY 10003 10004 10003 10004 LCD AM TFT CGS 240 320 10005 A2 MAIN FLEX ASSY 10104 10107 MAIN FLEX 10106 MAIN FLEX im ADHESIVE UPPER 10101 SCREW M1 4X2 1 10006 A4 LIGHT SWAP PACKAGE 10205 10208 BTFM SHIELD LID 10206 CAMERA MOD 5MP 10209 A5 C COVER ASSY 10210 10214 19998 CONN CHR DIA 2 0mm W L G MEMORY DOOR 10213 SCREW 1 6X5 5 10216 1 Nokia 6710 Navig
10. der shown 3 When assemling the device and if the MAIN FLEX ASSY has not been disassembled remove WINDOW CAPASITIVE FLEX ADHESIVE and replace it always with a new one Be careful not to damage the Capasitive flex area 18 Confidential e Copyright 2009 NOKIA e All rights reserved 2 Tighten the four TORX size 6 screws to the torque of 17Ncm in the order shown O SUN 77 f AY 4 When placing the SLIDE ASSY make sure these hooks are correctly attached Version 1 0 ISSUE 1 NOKIA Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 12 SOLDER COMPONENTS X2401 X2420 7592 F2000 X2400 X2421 590 591 Co 4 lt F3300 XC ia Von VA407 S2500 VA402 52501 62200 V4404 V4401 Ver 10 19 Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1
11. eserved Version 1 0 ISSUE 1 NOKIA Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 5 CAREAND MAINTENANCE This product is of superior design and craftsmanship and should be treated with care The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years e Keep the phone and all its parts and accessories out of the reach of small children Keep the phone dry Precipitation humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits Do not use or store the phone in dusty dirty areas Its moving parts can be damaged Do not store the phone in hot areas High temperatures can shorten the life of electronic devices damage batteries and warp or melt certain plastics Do not store the phone in cold areas When it warms up to its normal temperature moisture can form inside which may damage electronic circuit boards e Do not drop knock or shake the phone Rough handling can break internal circuit boards Do not use harsh chemicals cleaning solvents or strong detergents to clean the phone Do not paint the phone Paint can clog the moving parts and prevent proper operation Use only the supplied or an approved replacement antenna Unauthorised antennas modifications or attachments could damage the phone and may violate regulations governing radio devices All of the above suggestions apply equal
12. h concept Point of Sales To use the FLS 5 Flash Dongle follow the user guide inside the sales package Please check always for the latest version of flash software wich is available on Nokia Online SERVICE e SOFTWARE 10 PRODUCT SPECIFIC ACHA BATTERY 11 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 6710 Navigator RM 491 NOKIA Ca re Service Manual Level 1 amp 2 10 DISASSEMBLY INSTRUCTIONS SS 100 2 You must use the Nokia Standard Toolkit version 2 and the 2 mm charger plug You will also need the SS 100 camera removal tool 1 fiw mu s n M NIMM 24 24 remove joa BATTERY COVER first use the Wer 4 Release the two clips in the middle of the cover groove to release the cover by pressing the cover lightly from both sides Then remove the BATTERY COVER If there is a battery inserted remove it also 7753 1 Y 11111 SBA 164460 188 victor BS MSS Fav A dut 4 Use the SRT 6 to release the ALPHA KEYMAT 6 Unscrew the four TORX size 6 screws the sure the keymat is completely detached and remove order shown Do not use them again it in the direction shown 12 Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 6710 Navigator RM 491
13. ly to the product battery charger or any accessory T Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 6 BATTERY INFORMATION Note A new battery s full performance is achieved only after two or three complete charge and discharge cycles The battery can be charged and discharged hundreds of times but it will eventually wear out When the operating time talk time and standby time is noticeably shorter than normal it is time to buy a new battery Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer Unplug the charger when not in use Do not leave the battery connected to a charger for longer than a week since overcharging may shorten its lifetime If left unused a fully charged battery will discharge itself over time Temperature extremes can affect the ability of your battery to charge For good operation times with Ni Cd NiMh batteries discharge the battery from time to time by leaving the product switched on until it turns itself off or by using the battery discharge facility of any approved accessory available for the product Do not attempt to discharge the battery by any other means Use the battery only for its intended purpose Never use any charger or battery which is damaged Do not short circuit the battery Accidental short circuiting can oc
14. trap is worn 3 Useonly approved components as specified in the parts list 4 Ensure all components modules screws and insulators are correctly re fitted after servicing and alignment 5 Ensure all cables and wires are repositioned correctly 5 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 6710 Navigator RM 491 Ca re Service Manual Level 1 amp 2 4 ESD PROTECTION Nokia requires that service points have sufficient ESD protection against static electricity when servicing the phone Any product of which the covers are removed must be handled with ESD protection The SIM card can be replaced without ESD protection if the product is otherwise ready for use To replace the covers ESD protection must be applied All electronic parts of the product are susceptible to ESD Resistors too can be damaged by static electricity discharge All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area EPA Every repair action involving opening the product or handling the product components must be done under ESD protection ESD protected spare part packages MUST NOT be opened closed out of an ESD Protected Area For more information and local requirements about ESD protection and ESD Protected Area contact your local Nokia After Market Services representative 6 Confidential e Copyright 2009 NOKIA e All rights r
Download Pdf Manuals
Related Search