Home

GASOLINE AIR COMPRESSOR - Mi-T

image

Contents

1. 15 SHUTDOMWN PETS 15 MAINTENANCE kisiya xaka rake kal ka ka n ka ero de ein n rs k ka E EE ERR ERO E RE RR RA 15 TROUBLESHOOTING Exo DI RR ERR ERI RARE ci 16 17 WARRANTY Ren S ue dk a Ea ke Cr OUR On RR PR dE EN o RT RR EU IRR 18 PITE PR 19 AWARNING This product contains one or more chemicals known to the State of California to cause The engine exhaust from this product contains chemicals known to the State of California to cause cancer birth defects or other reproductive harm cancer and birth defects or other reproductive harm Mi T M Gasoline Air Compressor Manual INTRODUCTION Congratulations on the purchase of your new Mi T M Air Compressor You can be assured your Air Compressor was constructed with the highest level of precision and accuracy Each component has been rigorously tested by technicians to ensure the quality endurance and performance of this air compressor This operator s manual was compiled for your benefit By reading and following the simple safety installation and operation maintenance and troubleshooting steps described in this manual you will receive years of troublefree operation from your new Mi T M Air Compressor The contents of this manual are based on the latest product information available at the time of publication Mi T M reserves the right to make changes in price color materials equipment specification
2. 14 GASOLINE ENGINE a N 9 Review Risk of Fire or Explosion pg 4 before fueling Read the engine manual accompanying this air compressor for correct engine start up maintenance procedures Read and understand the safety labels located on the air compressor A minimum of 86 octane fuel is recommended for use with this air compressor Do not mix oil with gasoline Use of clean fresh lead free gasoline is recommended Leaded gasoline may be used if lead free is not available Do not use gasoline containing methanol or alcohol Check the engine oil level before starting See engine manual Fill the fuel tank according to the engine manual instruction Refer to the engine manual for all necessary maintenance and adjustments PRE START CHECKLIST 1 2 Check oil level Add if necessary Remove any moisture in the air compressor air tank NEVER attempt to open the Air Tank Drain Valve when more than 10 PSI of air pressure is in the air tank Remove excessive pressure with an air tool then open the Air Tank Drain Valve in the bottom of the air tank Close tightly when drained Make sure the Engine Switch is in the OFF position Make sure the Safety Relief Valve is working correctly Make sure all guards and covers are in place and securely mounted Mi T M Gasoline Air Compressor Manual OPERATION accompanying this unit Valve drain any moisture Allow the air comp
3. gt 2 25 5 IAN NA 5 98 9 9 amp NN NAVA lt lt T lt gt aaco amp lt o lt 5 s ION N 1 1 O O La gt LO 1l o VN S S Ua Tu 8289209599208308 T Zi 3 YARO 6 2 lt o S 0 69 0 5 AN zen e LoD 20655500 55 D 7 ON 5 o 6 no E E EES 0 3 9 g EOS 23 E gt 5 e PNA I 9 eg 9 6 E 55 2 9g 9 8 5 3 gt E o 9 Q SE Z 35 2 53 gt ocr E 9 9 Q gt 5 e 2 2 3 0 E 202 0096 9 9 5 5 5 5 6 amp 5 O O O 0001 gt gt gt lt REFER O NA 16 60 N 9 9 6S S AN 10 Oo v lt N N N _ 17 18 ETAPA SENCILLA P CN ABS LBA SO 4 2 Mi T M COMPONENTES DE COMPRESOR DE AIRE GASOLINA a WE gt A 2 ISA J Nd F o o NYA 21 701 10 3 34 60 9 10 Y04 lt 10 34N1W33 02 60Ad 80Hd 20W 4 60810 341 1 33 8 60 Mi T M Manual de operador de compresor de aire gasolina 28 VISTA EXPLOTADA amp EXPLICACI N DE ELEMENTOS DE COMPRESOR DE AIRE EASY START POSITION TOGGLE OPERATING POSITION DISCHARGE M
4. S S T _ T T _ T T l gt S T NET p p a xp a xp __ T apo T El aceite de la bomba debe cambiarse despu s de 50 horas de trabajo y cada 200 horas 3 meses seg n la condici n que ocurra antes Se recomienda el uso de sustancias puras sin detergente Cada dos an s un t cnico autorizado de servicio debe inspeccionar la v lvula v lvulas de entrar y v lvulas de liberar 32 Mi T M Manual de operador de compresor de aire gasolina LOCALIZACI N DE AVER AS motor Funcionamiento ruidoso Var as problemos de motor Referir a manual de motor de su com presor de aire Nivel de aceite de motor bajo El motor se equipa de un sistema de alerta del aceite que no permita que el motor comience si el nivel de aceite es bajo Agregue el aceite si est necesitado Polea de motor o bomba de rueda polea y o rueda volado voldao es suelto Reponer la cantidad de aceite Falta aceite en la bomba necesaria Controlar que los cojinetes no se hayan da ado Residuos de carbono en los pis Desmontar e inspeccionar la tones o en las v lvulas culata del cilindro Limpiar y sustituir Aver a del cojinete pist n o biela PARAR EL COMPRESOR P ngase en contacto con la Asisten cia Clientes Abajo de presi n en tanque de Los accesorios no han sido apreta Aretar los accesorios donde se oye aire o abajo de p
5. Contact Mi T M Customer Service Oil has milky appearance Water in oil due to condensation Change oil and move air compressor to a less humid environment Mi T M Gasoline Air Compressor Manual 17 Mi T M CORPORATION Mi T M GASOLINE AIR COMPRESSOR STATEMENT OF WARRANTY Mi T M Corporation warrants all parts except those referred to below of your new air compressor to be free from defects in materials and workmanship during the following periods For Two 2 years from the date of original purchase Compressor Pump Plumbing Tank Assembly For Six 6 months from date of original purchase Pressure Switch Regulator Check Valve Pilot Valve Copper stainless steel line For Ninety 90 days from the date of original purchase Pressure Gauges Safety Relief Valves Drain Valves Defective parts not subject to normal wear and tear will be repaired or replaced at our option during the warranty period In any event reimbursement is limited to the purchase price paid EXCLUSIONS 1 Engine is covered under separate warranty by its respective manufacturer and is subject to the terms set forth therein 2 Normal wear parts Isolators Air Filter 3 This warranty does not cover parts damaged due to normal wear abnormal conditions misapplication misuse accidents operation at other than recommended speeds pressures or temperature improper storage or freight damage Parts damaged or worn by operation in dus
6. detergente Limpiar Reparar Ponerse en contacto con la Asisten cia Clientes Limpiar o sustituir Condensaci n en el aire de descarga 34 Condensaci n en el dep sito de aire debido a una elevada hume dad atmosf rica Opera el compresor de aire por una hora para impedir demasiado condensi n Vaciar el dep sito de aire despu s de cada empleo Vaciar el dep sito de aire m s fre cuentemente en climas h medos y usar un filtro en la l nea de aire Mi T M Manual de operador de compresor de aire gasolina Mi T M CORPORATION DECLARACI N DE GARANT A Mi T M garantiza que todas las piezas excepto aquellas a las que se hace referencia abajo de su nueva lavadora a presi n libres de defectos en materiales y mano de obra durante los periodos siguientes Por dos 2 a os a partir de la fecha original de compra Bomba de Compresor Ca erias Asamblea de Tanque Por seis 6 mes a partir de la fecha original de compra Interruptor de Presi n Reguladores Valvula de revisar V lvula de piloto Linea de cobre acero inoxidable Por noventa 90 d as a partir de la fecha original de compra Indicadores de presi n V lvula de alivio de seguridad v lvulas de desag e Las piezas defectuosas que no est n sujetas a deterioro causado por el uso ser n reparadas o reemplazadas a nuestra opci n durante el periodo de garant a En todo caso el reembolso est limitado al precio de compra pagado E
7. n No colocar jam s un compresor de aire en una zona donde hay fugas de aceite o gas donde puede haber vapores o materiales inflamables donde la temperatura del aire es inferior a 32 F o superior a 104 F donde aire sucio agua podria ser aspirado por el compresor de aire MOTOR DE GASOLINA a F NS g N 9 Revisar Riesgo de expolsi n o fuego antes de agregar fuel Leer manual de motor que acompando este compresor de aire para mantenimiento correcto de encender de motor Leer y comprender las etiquetas de seguridad que situado en el compresor de aire Recomendar usar fuel del minimo de 86 octano con este compresor de aire No mezclar aceite con gasolina Recomendar usar gasolina sin plomo y limpiado y fresco Puede usar gasolina con plomo si no tener gasolina sin plomo No usar gasolina con metano o alcohol Antes de empezar controlar el nivel del aceite ver manual de motor Llenar el tanque de fuel en accordancia de manual de instruccion Referir a manual de motor para mantenimiento necesario y ajustados AD 9S RIESGO DE EXPLOSION O MUERTE No tener contacto de motor y moefle con vapores flamables polvos combustiles o otras materiales combustibles Una chispa puede causar un fuego Cuando usando el compresor de aire para pintar poner el compresor de aire demasiado afuera de ambiente detrabajar Usar m s tubos de aire si necesitar PELIGRO A RIESGO DE EXPLOSION T No f
8. n de tanque de aire TANK DRAIN V LVULA DE DESCARGAR DEL TANQUE DE AIRE La v lvula de descargar sea usado para quitar la humedad de las tanques de aire despues de apagarse del com presor de aire NUNCA trate abrir la v lvula de descargar cuando m s de 10PSI de presi n de aire est en el tanque de aire Para abrir la v lvula de descargar gire la perilla en sentido contrario a las agujas Mi T M Manual de operador de compresor de aire gasolina 29 30 ADVERTENCIA LAS PAGINAS SIGUIENTES CONTIENEN INSTRUCCIONES DE OPERACION Y MANTENIMIENTO NO TRATE DE OPERAR ESTA LAVADORA A PRESION HASTA QUE HAYA LEIDO Y ENTENDIDO TODAS LAS PRECAUCIONES E INSTRUCCIONES DE SEGURIDAD LISTADAS EN ESTE MANUAL LA OPERACION INCORRECTA DE ESTA UNIDAD PUEDE CAUSAR LESIONES GRAVES DE NINGUNA MANERA ALTERE O MODIFIQUE ESTE EQUIPO Mi T M Manual de operador de compresor de aire gasolina INSTRUCCIONES DE PREPARACI N PREPARACI N 1 Lea las advertencias de seguridad antes de preparar el compresor del aire 2 Asegurar que el nivel del aceite en bomba de compresor de aire es adecuado Si bajo agregar SAE 30W aceite sin detergente COLOCACI N 1 2 Para evitar da os al compresor de aire ste no debe inclinarse transversalmente o longitudinalmente a m s de 10 Colocar el compresor de aire a una distancia m nima de 12 pulgadas de cualquier obst culo que impida una correcta ventilaci
9. SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE PELIGRO POSIBLE CONSECUENCIA PREVENCI N RIESGO DE NEGLIGENCIA Un uso negligente del compresor No permitir jam s que ni os o puede ocasionar lesiones adolescentes pongan en marcha el compresor de aire Prestar mucha atenci n a la operaci n que se est cumpliendo No se debe poner en marcha el compresor de aire en caso de cansancio o bajo la influencia de alcohol o drogas Es necesario saber apagar el compresor de aire Es preciso conocer bien todos los mandos RIESGO DE AVER AS DEL Riesgo de graves aver as No encender el compresor de aire sin el filtro de aire COMPRESOR DE AIRE No encender el compresor de aire sin el filtro de aire No encender el compresor de aire en un ambiente corrosivo El compresor de aire debe funcionar en una posici n estable y segura para prevenir que caiga Atenerse a las instrucciones de mantenimiento descritas en este manual GUARDE ESTAS INSTRUCCIONES Mi T M Manual de operador de compresor de aire gasolina 25 AC1 PH55 08 FEATURE 041205 DLG AC1 PH55 20M W THROTTLE CONTROL 041205 DLG 26 Mi T M COMPONENTES DE COMPRESOR DE AIRE GASOLINA ESTAPA SENCILLA RY 4 di N 00000006 TEO lO OY Ee Co 12 17 Calcoman a Peligro Advertencia Precauci n V lvula s de descargar del tanque de aire Calcoman a Advertencia Calientes Sumidero del aceite de bomba Cristal De la Vista Del Aceite
10. air compressor Do not move the air compressor while air tank is under pressure Do not attempt to move the air compressor by pulling on the hose Before performing maintenance always turn off air compressor Bleed pressure from the air hose and disconnect spark plug wire to prevent engine from starting unexpectedly All repairs to the air compressor should be made by an Authorized Service person Do not operate without protective covers guards Always turn off air compressor before removing any guard Replace damaged covers guards before using the air compressor Mi T M Gasoline Air Compressor Manual SAFETY WARNINGS HAZARD POTENTIAL CONSEQUENCE RISK FROM Risk of injury from negligent use NEGLIGENCE RISK Risk of major repair OF AIR COMPRESSOR DAMAGE Im READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR RA PREVENTION Never allow children or adolescents to operate this air compressor Stay alert watch what you are doing Do not operate the air compressor when fatigued or under the influence of alcohol or drugs Know how to stop the air compressor Be thoroughly familiar with controls Do not operate air compressor without an air filter Do not operate air compressor in a corrosive environment Always operate the air compressor in a stable secure position to prevent air compressor from falling Follow all maintenance instructions listed in this manual S
11. de fuel despacio para evitar derrames que puede causar riesgo de fuego No funcionar el unito si hay derrames de gasolina Limpiar el compresor de aire y mover afuera de derrame Evitar encendido o funcionar hasta gasolina ha evaporar No guardar el compresor de aire cerca de fuegos o m quinas como una estufa horno calentador de agua etc cual utilizar una luz pilota o dispositivo de chispas Necesitar tener arrestador de chispas en el moefle de este motor para usar con algo tierra que tener hierba o arboles Esta parte mantener efectuar por operador No poner objectos cerca o arriba de compresor de aire Funcionar compresor de aire m s de 12 pulgudos afuera de pared o obstruci n que limitar ventilaci n apropriado Mi T M Manual de operador de compresor de aire gasolina o ADVERTENCIAS IMPORTANTES DE SEGURIDAD ADVERTENCIA Al usar producto deben observarse ciertas precauciones b sicas como las siguientes LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE PELIGRO RIESGO DE ESTALLIDO RIESGOS A LA RESPIRACI N POSIBLE CONSECUENCIA Si no se respeta el mantenimiento adecuado el dep sito de aire podr a estallar y causar lesiones graves o la muerte El funcionamiento incorrecto del compresor o en el caso en que se empleen componentes o accesorios inadecuados el estallido de sus accesorios podr a causar lesion
12. for signs of obvious or concealed freight damage Be sure that all damaged parts are replaced and any mechanical problems are corrected prior to the operation of the air compressor SERIAL NUMBER If you have questions contact your Mi T M Customer Service Representative at 1 800 553 9053 Please have the following information available for all service calls 1 Model Number 2 Serial Number 3 Date and Place of Purchase Mi T M Corporation 8650 Enterprise Drive Peosta IA 52068 Mi T M Gasoline Air Compressor Manual 3 HAZARD SAFETY WARNINGS Im WARNING WHEN USING THIS PRODUCT BASIC PRECAUTIONS SHOULD ALWAYS BE OBSERVED INCLUDING RA THE FOLLOWING READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR POTENTIAL CONSEQUENCE PREVENTION RISK OF EXPLOSION OR FIRE Serious injury or death may occur from normal sparks in the engine ignition system or engine exhaust muffler Injury or death may occur as a result of improper fueling Serious injury may occur if any air compressor ventilation openings are restricted causing the air compressor to overheat and start a fire Always operate air compressor in a well ventilated area free of flammable vapors combustible dust gases or other combustible materials DO NOT SMOKE if spraying flammable material Locate the air compressor at least 20 feet away from the spray area An additional hose may be required Do not smoke while fill
13. su cuerpo y el moetle del motor o ambientes adyacentes Usar siempre las gafas de protecci n para proteger los ojos de las particulas volantes No dirigir jam s el chorro de aire a cualquier parte de su cuerpo o del cuerpo de otra persona o animal No dejar jam s un compresor de aire bajo presi n sin vigilancia Apagar el compresor y descargar la presi n antes de efectuar cualquier operaci n de mantenimiento conectar cualquier herramienta o accesorio Con el compresor de aire en marcha mantener siempre una distancia de seguridad de presonas y animales No debe moverse el compresor de aire cuando el dep sito de aire est bajo presi n No intentar mover el compresor de aire tirando del tubo Antes de hacer mantemiento siempre parar el compresor de aire Purgar presi n de tubo de aire y desmontar el cable de bomba de chispa para impedir el encendido de motor Todas reparaciones hacer de personas autorizadas de servicio No usar el compresor de aire sin las protecciones de seguridad Siempre remova el enchufe del compresor del aire antes de remover cualquier guarda Sustituir las protecciones da adas antes de encender le compresor de aire Mi T M Manual de operador de compresor de aire gasolina RA ADVERTENCIAS IMPORTANTES DE SEGURIDAD mm ADVERTENCIA Al usar este producto deben observarse ciertas precauciones b sicas como las siguientes LEA TODAS LAS ADVERTENCIAS DE
14. AVE THESE INSTRUCTIONS Mi T M Gasoline Air Compressor Manual AC1 PH55 08 FEATURE 041205 DLG AC1 PH55 20M W THROTTLE CONTROL 041205 DLG Mi T M GASOLINE AIR COMPRESSOR FEATURES SINGLE STAGE 12 00000006 E 23 24 g9 N 9S R amp N 2 Decal Danger Warning Caution Tank Drain Valves Decal Warning Hot Pump Oil Drain Oil Sight Glass Pilot Valve Engine Air Throttle Control Engine Switch Engine Decal Caution Risk of Fire Decal Warning Hot Surface Pump Discharge Line Beltguard Decal Warning Risk of Injury Decal Warning Beltguard Air Filter Oil Fill Port Pump Ventilation Openings Pressure Gauge Tank PSI Pressure Relief Valve Pressure Regulator Pressure Gauge Outlet PSI Outlet Fitting Mi T M Gasoline Air Compressor Manual EXPLODED VIEW amp EXPLANATION OF AIR COMPRESSOR FEATURES EASY START POSITION TOGGLE OPERATING POSITION DISCHARGE MUFFLER SAFETY RELIEF VALVE This valve is designed to prevent system failures by reliev ing pressure from the system when the compressed air reaches a predetermined level The valve is preset by the manufacturer and must not be modified in any way To verify the valve is working properly pull on the ring Air pressure should escape When the ring is released it will reseat PILOT VALVE When the toggle is in the upright position all air from
15. DAILY WEEKLY MONTHLY Check pump oil level Check engine oil level Oil leak inspection Check engine air filter Drain condensation in air tank s Inspect guards covers Check for unusual noise vibration Check for air leaks Clean exterior of compressor Inspect air filter Inspect belt x Check safety relief valve x Change pump oil Replace air filter Check engine spark plug EN E LC NEN GNI pem qo a ee O EN espesas I xx EIE ESTE ES a gt gt Bg LI ENT E C C Dar LL Lo n The pump oil must be changed after the first 50 hours of operation and every 200 hours or months whichever comes first The engine oil must be changed after the first 8 hours of operation and every 50 hours or 3 months whichever comes first Every 2 years an Authorized Service Technician should check the check valve intake valves and delivery valves Mi T M Gasoline Air Compressor Manual 15 TROUBLESHOOTING SYMPTOM PROBABLE CAUSE ________ Engine will not start Various engine problems Low engine oil level Refer to the engine manual accompanying your air compressor Engine is equipped with an Oil Alert System which will not allow the en gine to start if oil level is low Add oil if needed Noisy operation Loose engine pulley or pump flywheel Lack of oil in the pump Carbon deposits on pistons or valves Bearing piston or c
16. IESGODE EXPLOSI N suicidar 22 RIESGO netten Etienne en ds 23 RIESGOS A L A RESPIRACI N strain btt 23 RIESGO DE QUEMADUIRAS iis vic inire natn htt un ee nen 24 RIESGO DE OBJETOS 24 RIESGO DE PARTES EN 24 RIESGO DE NEGLIGENCIA ccs tenerte t tern da e Pre Der x ratte 25 RIESGO DE AVER AS DEL COMPRESOR 25 ILUSTRACIONES DE LOS ELEMENTOS Y COMPONENTES 26 amp 28 REPASO DE LOS ELEMENTOS Y COMPONENTES 27 amp 29 INSTRUCCIONES DE PREPARACI N 31 PREPARACION psa AS 31 COLOCACION aia 31 MOTOR DE GASOLINA ete en etn retten ana the 31 CONTROLES ANTES DEL ARRANQUE 31 INSTRUCCIONES DE OPERACI N ou 32 OPERACI N Q P 32 irte Serna teuer netter ai 32 MANTENIMIENTO cirios on d cr OG EOD I E EY HERE ERO E REIR RR 32 LOCALIZACI N AVER AS sonia 33 34 DECLARACI N DE GARANT A ta 35 A ADVERTENCIA Este producto contiene qu mica conocido por el estado de California a causar cancer A ADVERTENCIA Los gases del motor del este producto contiene qu mica conocido por el estado de Ca
17. Mi T M CORPORATION GASOLINE AIR COMPRESSOR OPERATOR S MANUAL A CAUTION RISK OF INJURY READ ENTIRE MANUAL BEFORE OPERATING THIS MANUAL IS AN IMPORTANT PART OF THE AIR COMPRESSOR AND MUST REMAIN WITH THIS UNIT WHEN YOU SELL OR RENT IT Copyright 2005 Mi T M Corporation Form 37 0484 E S 012109 TABLE OF CONTENTS INTRODUCTION nikani a D UD H KA d Re 3 IMPORTANT intus a no ein noni dex EO RR RED OR ak V ra D a bI EDO REOR RR 3 INSPECTION cipe id Ro Ep SEE kaka di 3 SAFETY WARNINGS enini iex RR Fon doo a FR naa EE EE ax u aa aka naa he 4 7 RISK OF EXPLOSION OR FIRE ttt nto ei ntes 4 RISK OE BURSTING oi ada 5 RISK TO BREATHING ici netu cre tenta daa keka a kk kabak n dank anit 5 RISKOF BURNS RM 6 RISK OFFLYING OBJECTS src listas anat 6 RISK FROM MOVING PAR S scientists 6 RISK EROM kanya T RISK OF AIR COMPRESSOR r FEATURES DRAWINGS Milane een nawa ha lsa annaia 8 amp 10 FEATURES REVIEW uan kak ae kla ka lawa aka na n nan a wak kanca kasen ku A ke 9 amp 11 PREPARATION racc tailandia Au aA RA dka Aa Rd e EE cR END RECEN DR RE E 14 INITIAL SETUP tst o cette ka e lr a n d tei nd 14 LOCATION mE 14 GASOLINE ENGINE tate eta 14 PRE START CHEGCHKL S Tocar 14 OPERATION da n dao 15 STARTUP M
18. UFFLER V LVULA DE ALIVIO DE SEGURIDAD Esta v lvula sea dise ado para prevenir falla de la sistema por aliviando alcance un nivel predeterminado La v lvula ha preprogramado por el fabricante y no puede modificar en ninguna manera Para verificar que la v lvula est trabajando correctamente tire en el anillo Presi n de aire debe escapar Cuando el anillo sea liberado lo volver a cero V LVULA DE PILOTO Cuando el muletilla est en posici n vertical todo el aire de compresor de aire descarg por el mofle de dep sito Este da un elemento de empezar f cil Para operaci n normal la muletilla est en posici n de 90 FILTRO DE LA ENTRADA DEL AIRE Este filtro sea dise ado para limpiar aire que veniendo en la bomba Para asegurar la bomba reciba continuamente un suministro de aire limpio fresco y seco el filtro tiene que ser limpio y el abierto de ventilaci n no tiene obstruci nes Reemplace el elemento del filtro cuando necesario PORTE 0 OIL SIGHT GLASS PUERTO DE RELLENO DEL ACEITE TIRO Tire el aceite en el puerto de relleno del aceite tiro cuando necesario VIDRIO DE VISTA DEL ACEITE El vidrio de vista del aceite expone el nivel del aceite en la bomba El nivel del aceite debe estar en el medio del vidrio de vista del aceite Si bajo agregue SAE30W aceite sin detergente BOMBA DE COMPRESOR DE AIRE Una bomba de compresor de dos estapas usa cilindros de dos tama os difer
19. V lvula de piloto Control de regulador de motor Interruptor de motor Motor Calcoman a Riesgo de Incendido Calcoman a Advertencia Superficies Calientes Cuerda de dep sito de bomba Guardia del cint ron Calcoman a Advertencia Riesgo de lesiones Calcoman a Advertencia Guardia del cint ron est en lugar Filtro de aire Puerto de relleno del aceite Bomba Abiertas de ventilaci n Indicador de presi n de tanque de aire Valvula de alivio de presi n Regulador de presi n Indicador de presi n de salida Instalaci nes de salida Mi T M Manual de operador de compresor de aire gasolina VISTA EXPLOTADA amp EXPLICACI N DE ELEMENTOS DE COMPRESOR DE AIRE EASY START POSITION TOGGLE gt OPERATING POSITION ES DISCHARGE MUFFLER V LVULA DE ALIVIO DE SEGURIDAD Esta v lvula sea disefiado para prevenir falla de la sistema por aliviando alcance un nivel predeterminado La v lvula ha pre programado por el fabricante y no puede modificar en ninguna manera Para verificar que la v lvula est trabajando correctamente tire en el anillo Presi n de aire debe escapar Cuando el anillo sea liberado lo volver a cero V LVULA DE PILOTO Cuando el muletilla est en posici n vertical todo el aire de compresor de aire descarg por el mofle de dep sito Este da una caracter stica de en cender f cil Para operaci n normal la muletilla est en posici n de noventa gra
20. XCLUSIONES El motor est cubierto bajo una garant a separada proporcionada por el fabricante respectivo y est sujeta a los t rminos en ella establecidos Partes de desgaste normal Aisladores filtro de aire Esta garant a no cubre las piezas da adas debido al deterioro normal causado por el uso mala aplicaci n mal uso operaci n a velocidades presiones o temperaturas diferentes a las recomendadas Las piezas da adas o gastadas a causa del uso de l quidos c usticos por la operaci n en medios ambientes abrasivos o corrosivos o bajo condiciones que causan cavitaci n de la bomba no est n garantizadas La falla en seguir los procedimientos recomendados de operaci n y mantenimiento tambi n cancela la garant a Cobras de trabajar peridio o da o resultando de operaci n mala mantenimiento otro de descarga de tanque de aire rutina y cambios de aceite si aplica o reparaciones hace por personas otro de Mi T M Centro de servicio autorizado El uso de piezas de repuesto diferentes a las genuinas Mi T M cancelar la garant a Las piezas devueltas con franqueo pagado a un Centro de Servicio Autorizado Mi T M ser n inspeccionadas y reemplazadas libre de cargos si se determina que est n defectuosas y sujetas a la garant a No existen garant as que se extiendan m s all de la descripci n contenida aqu Bajo ninguna circunstancia Mi T M Corporation ser responsable por la p rdida de uso de la unidad p rdida de tiempo incon
21. cionar este compresor de aire en ambientes cerrados fiempre tener ventilaci n adecuado Este prevenir la acumule de gases peligros que contener mon xido de carbono Ten ciudad de ambientes de mal ventilados El compresor de aire debe funcionar s lo en ambientes bien ventilados Atenerse a las instrucciones de seguridad indicadas para los materiales que se pulverizan Al pulverizar ciertos materiales podr a ser necesario usar un respirador 23 Ij ADVERTENCIAS IMPORTANTES DE SEGURIDAD Ii ADVERTENCIA Al usar este producto deben observarse ciertas precauciones b sicas como las siguientes LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE PELIGRO RIESGO DE QUEMADURAS RIESGO DE OBJETOS VOLANTES RIES GO DE MOVIMIENTO PARTES EN _ Kk 24 POSIBLE CONSECUENCIA El tocar partes met licas expuestas podr a causar lesiones graves La temperatura en estas zonas no baja inmediatamente al apagar el compresor de aire El chorro de aire comprimido podr a causar lesiones a los tejidos blandos La proyecci n de part culas del chorro de aire comprimido a velocidad elevada puede causar lesiones graves Riesgo de lesiones graves de partes en movimiento PREVENCI N Asegurarase que ninguna parte del cuerpo o de otros materiales entre en contacto con las partes met licas expuestas del compresor de aire Nunca tener contacto de
22. de regulaci n de presi n de las agujas del reloj para aumentar presi n descarga y en sentido contrario a las aguajas del reloj para disminuir la presi n descarga INDICADOR DE PRESI N SALIDA El indicador de presi n salida indica la presi n de aire disponsible en el lado de salida del regulador Esta presi n sea controlado por el regulador y siempre sea menos o igual a la presi n de tanque de aire N TANK DRAIN V LVULA DE DESCARGAR DEL TANQUE DE AIRE La v lvula de descargar sea usado para quitar la humedad de las tanques de aire despues de apagarse del com presor de aire NUNCA trate abrir la v lvula de descargar cuando m s de 10PSI de presi n de aire est en el tanque de aire Para abrir la v lvula de descargar gire la perilla en sentido contrario a las agujas Mi T M Manual de operador de compresor de aire gasolina 27 9714 70161 0 598 80179 80 60Ad 60Yd 80Hd 2SV o 22 5 n T 2 5 Y oo amp E E C o UU 5 o o T g Oc O 5 5 3 Q D m Ve O o O S D ce O nd CN go 55 o S AN AA ES E E E S AWA lt o c c To OO w D c c 52 6 oO O t 59 0 55900 tot 5 O 9 000 0220 Y W VA gt gt
23. discharge pressure and counterclockwise to decrease discharge pressure OUTLET PRESSURE GAUGE The outlet pressure gauge indicates the air pressure available at the outlet side of the regulator This pressure is controlled by the regulator and is always less or equal to the air tank pressure TANK DRAIN Mi T M Gasoline Air Compressor Manual AIR TANK DRAIN VALVE The drain valve is used to remove moisture from the air tank s after the air compressor is shut off NEVER attempt to open the drain valve when more than 10 PSI of air pressure is in the air tank To open the drain valve turn the knob counterclockwise Mi T M GASOLINE AIR COMPRESSOR FEATURES TWO STAGE 9 Id v02cV0 S34n 1V33 80 60Ad 60Yd 80Hd 2SV 910 404210 SIYN1V33 60Ad 80Hd ZOVW 5 o oo gc i 9 55 Oo P 9 E DD E E o EE S S505 SS MF 276650 LA 000 _ lt lt lt lt gt gt 6 8 t E 8 8 DODO O OC EC 3 5 00 O 0 B 5 V Id Ims O Y CN CO lt O ODT 9 10 402210 34N 1W33 02 60Ad 80Hd Z20W e Relief Valve ain Valves pus Pressu 12 13 14 15 os Tank D Outlet PSI e Gauge Tank PSI e Gauge coo Pressu Pressu Press ure Regulator 16 17 18 19 20 on Openings Air Compressor Pump Air Filter Decal Ventila Warning Be
24. dos FILTRO DE LA ENTRADA DEL AIRE Este filtro sea disefiado para limpiar aire que veniendo en la bomba Para asegurar la bomba reciba continuamente un suministro de aire limpio fresco y seco el filtro tiene que ser limpio y el abierto de ventilaci n no tiene obstruci nes Reemplace el elemento del filtro cuando necesario PUERTO DE RELLENO DEL ACEITE TIRO Tire el aceite en el puerto de relleno del aceite tiro cuando necesario VIDRIO DE VISTA DEL ACEITE El vidrio de vista del aceite expone el nivel del aceite en la bomba El nivel del aceite debe estar en el medio del vidrio de vista del aceite Si bajo agregue SAE30W aceite sin detergente BOMBA DE COMPRESOR DE AIRE Para comprimir aire los pistones mueven arriba y abajo en los cinlindros En el tiempo abajo aire sea retraido por las v lvulas entradas mientras las v lvulas de exhausto quedan cerrado En el tiempo arriba el aire sea com primido las v lvulas entradas cierran y aire comprimido sean forzados por las v lvulas de exhausto en la linea descarga por la v lvula pilota y en el tanque de aire TANK PRESSURE GAUGE DECREASE COUNTER CLOCKWISE PRESSURE REGULATOR INCREASE INDICADOR DE PRESI N DE TANQUE DE AIRE El indicador de presi n de tanque de aire indica la presi n de aire reserva en los tanques de aire REGULADOR DE PRESI N La presi n de aire veniendo de tanque de aire sea con trolado por la perilla de regulador Gire la perilla
25. entes con la v lvula entrada de el m s peque o y se gundo cilindro que unir cilindro En el tiempo abajo aire sea retraido por las v lvulas entradas mientras las v lvulas de exhausto quedan cerrado En el tiempo arriba el aire sea comprimido las v lvulas entradas cierran y aire comprimido sea forzados por las v lvulas de exhausto entre el entre frigerante y por la v lvula entrada de el m s pequeno y segundo cilindro en el tiempo abajo En el tiempo arriba del cilindro pequeno la v lvula entrada cierra y aire comprimido comprimir un tiempo segundo y forzad afuera de v lvula de exhausto entre la linea de deposito por v lvula de revisar de tanque y entre el tanque de aire TANK PRESSURE GAUGE DECREASE PRESSURE REGULATOR COUNTER CLOCKWISE AO INCREASE CLOCKWISE KA INDICADOR DE PRESI N DE TANQUE DE AIRE El indicador de presi n de tanque de aire indica la presi n de aire reserva en los tanques de aire REGULADOR DE PRESI N La presi n de aire veniendo de tanque de aire sea con trolado por la perilla de regulador Gire la perilla de regulaci n de presi n de las agujas del reloj para aumentar presi n descarga y en sentido contrario a las aguajas del reloj para disminuir la presi n descarga INDICADOR DE PRESI N SALIDA El indicador de presi n salida indica la presi n de aire disponsible en el lado de salida del regulador Esta presi n sea controlado por el regulador y siempre sea menos o igual a la presi
26. erta usadas en este manual son las siguientes PELIGRO Indica una situaci n inminente riesgosa la cual si no se evita RESULTARA en la muerte o en lesiones graves ADVERTENCIA Indica una situaci n potencialmente riesgosa la cual si no se PRECAUCION Indica una situaci n potencialmente riesgosa la cual si no se evita PUEDE resultar en lesiones menores o moderadas evita PODRIA resultar en la muerte o en lesiones graves El s mbolo indicado la izquierda de este p rrafo es el S mbolo de Alerta de Seguridad Este s mbolo se usa para alertarlo acerca de art culos o procedimientos que podr an ser peligrosos para usted u otras personas usando este equipo PROVEA SIEMPRE UNA COPIA DE ESTE MANUAL A CUALQUIER PERSONA QUE USE ESTE EQUIPO LEA TODAS LAS INSTRUCCIONES ANTES DE OPERAR ESTA LAVADORA A PRESION OBSERVANDO EN PARTICULAR LAS ADVERTENCIAS DE SEGURIDAD PARA EVITAR LA POSIBILIDAD DE LESIONES PERSONALES AL OPERADOR Escriba el n mero de serie de su unidad en el espacio provisto abajo una vez que la unidad haya sido desempacada NUMERO DE SERIE Inspeccione por da o el contenido de la caja Si algo parece da ado NO LA DEVUELVA AL LUGAR DE COMPRA Llame a su representante de servicio al cliente de al 800 553 9053 Por favor tenga disponible la informaci n siguiente para todas las llamadas de servicio 1 N mero de modelo 2 N mero de serie 3 Fecha y lugar de compra Mi T M Corporation 8650 En
27. es graves o la muerte La inhalaci n de aire comprimido puede causar lesiones graves e incluso la muerte El chorro de aire podr a contener mon xido de carbono vapores t xicos o part culas s lidas La inhalaci n de gases de motor puede causar lesiones graves y la muerte Materiales pulverizados como pinturas solventes para pinturas desbarnizadores insecticidas herbicidas etc contienen vapores da inos y venenos Mi T M Manual de operador de compresor de aire gasolina PREVENCI N Vaciar el dep sito de aire todos los d as o al final de cada uso para evitar que se acumule la condensaci n Si el dep sito de aire tiene una fuga sustituirlo inmediatamente No reparar soldar o modificar jam s el dep sito de aire o sus accesorios Usar s lo piezas originales para el compresor de aire No modificar jam s las presiones ajustadas en al f brica No superar jam s las presiones m ximas permitidas de los accesorios recomendadas por el fabricante Debido al excesivo calor no usar tubos de pl stico o uniones con soldaduras de plomo en la l nea de descarga No usar jam s un compresor de aire para inflar objetos pequefios o que requieren poca presi n como los juguetes No inhalar jam s el aire porcedente del compresor de aire ni a trav s de cualquier dispositivo de respricai n conectado al compresor de aire Este compresor de aire se disenado para funcionar en aire libre Nunca fun
28. ing engine fuel tank Never fill the engine fuel tank while the engine is running or hot Allow the engine to cool two minutes before refueling Do not refuel indoors or in a poorly ventilated area Always refuel slowly to avoid the possibility of spilled fuel which may cause a risk of fire Do not operate the unit if gasoline is spilled Wipe the air compressor clean and move it away from the spill Avoid creating any ignition until the gasoline has evaporated Do not store the air compressor near an open flame or any equipment such as a stove furnace water heater etc which utilizes a pilot light or sparking device A spark arrester must be added to the muffler of this engine if it is to be used on any forest covered brush covered or grass covered unimproved land The arrester must be maintained in effective working order by the operator Never place objects against or on top of air compressor Operate air compressor at least 12 inches away from any wall or obstruction that would restrict proper ventilation Mi T M Gasoline Air Compressor Manual SAFETY WARNINGS READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR Imi HAZARD POTENTIAL CONSEQUENCE PREVENTION RISK OF Serious injury or death may occur Drain air tank daily or after each BURSTING from an air tank explosion if air use to prevent moisture buildup in RISK TO BREATHING tanks are not properly maintained Serious in
29. ior de los dep sitos de aire es inferior a 10 libras abrir la v lvula de descarga debajo de cada dep sito de aire para eliminar la humedad Dejar enfriar el compresor de aire Limpiar el compresor de aire con un un lugar seguro donde no exista el riesgo de congelaci n MANTENIMIENTO Leer el manual de instrucci nes antes de efecturar cualquier operaci n de manten imiento Las operaci nes descritas a continuaci n deben ser llevadas a cabo cuando el compresor se apaga por mantenimiento o reparaci nes 1 Apagar el compresor de aire Desconectar el cable de la toma de corriente principal 3 Abrir todas las descargas 4 Esperar que de aire se haya enfriado antes de comenzar las operaci n es AC Gas Spanish Maintenance Chart TABLA DE MANTENIMIENTO OPERACI N DIARIA SEMANAL MENSUAL 200 HORAS Controlar el nivel del aceite de la bomba Controlar el nivel del aceite de motor Inspeccionar que no haya p rdidas de aceite Controlar el filtro de aire de motor Descargar la condensaci n del dep sito s de aire Controlar el cubierta tapa ntrolar que no hay ruidos viraciones an malos inspeccionar que no hay fugas de aire Limpiar el compresor de aire exteriormente Controlar el filtro del aire Controlar el correa Controlar la de seguridad Cambiar el aceite de la bomba Sustituir el filtro del aire ENEE EE pp _
30. jury may occur from an air compressor malfunction or exploding accessories if incorrect system components attachments or accessories are used Serious injury or death could occur from inhaling compressed air The air stream may contain carbon monoxide toxic vapors or solid particles Serious injury or death may occur from inhaling engine exhaust Sprayed materials such as paint paint solvents paint remover insecticides weed killers etc contain harmful vapors and poisons Mi T M Gasoline Air Compressor Manual the air tank If air tank develops a leak replace the air tank immediately Never repair weld or make modifications to the air tank or its attachments Use only genuine Mi T M repair parts for your air compressor Never make adjustments to the factory set pressures Never exceed manufacturers maximum allowable pressure rating of attachments Because of extreme heat do not use plastic pipe or lead tin soldered joints for a discharge line Never use air compressor to inflate small low pressure objects such as toys Never inhale air from the air compressor either directly or from a breathing device connected to the air compressor This air compressor was designed for outdoor use Never operate this air compressor in an enclosed area Always make certain there is adequate ventilation fresh outside air for breathing and combustion This will prevent the buildup of dangerous carbon mono
31. lief Valve Excessive air tank pressure Operate Safety Relief Valve manually by pulling on ring If it still leaks it should be replaced Clean reset or replace Pilot Valve Mi T M Gasoline Air Compressor Manual TROUBLESHOOTING SYMPTOM PROBABLE CAUSE Air leaks at pump Defective gaskets Torque head bolts Single Stage 17 ft Ibs Two Stage 33 ft Ibs Air blowing from Air Intake Filter Moisture in discharge air Defective inlet reed valve Condensation in air tank caused by high level of atmospheric humidity or air compressor is not run long enough Contact Mi T M Customer Service Run air compressor a minimum of one hour to prevent condensation buildup Drain air tank after every use Drain air tank more often in hu mid weather and use an air line filter Excessive oil consumption or oil in hose Restricted Air Intake Filter Air compressor on unlevel surface Crankcase overfilled with oil Wrong viscosity Plugged oil dipstick vent Plugged crankcase breather Oil leaks Worn piston rings or scored cylin der Clean or replace Do not incline the air compressor more than 10 in any direction while running Drain oil Refill to proper level with SAE 30W non detergent oil Drain oil Refill to proper level with SAE 30W non detergent oil Clean Clean or replace Torque head bolts Single Stage 17 ft bs Two Stage 33 ft Ibs
32. lifornia a causar cancer defectos de nacimiento y otros peligros reproductor defectos de nacimiento y otros peligros reproductor Mi T M Manual de operador de compresor de aire gasolina INTRODUCCION Felicitaciones por la compra de su nueva compresor de aire gasolina Puede estar seguro que su compresor de aire gasolina fue construida con el nivel m s Cada componente ha sido probado rigurosamente por t cnicos para asegurar la calidad la resistencia y el rendimiento de esta unidad Este manual del operador fue compilado para su beneficio Leyendo y siguiendo los pasos simples de seguridad instalaci n operaci n mantenimiento y localizaci n de fallas descritos en este manual ayudar a prolongar aun m s la operaci n libre de fallas que usted puede esperar de su compresor de aire gasolina El contenido de este manual est basado en la informaci n actualizada disponible al momento de la publicaci n Mi T M se reserva el derecho de efectuar cambios en precio color materiales equipo especificaciones o modelos en cualquier momento sin previo aviso A IMPORTANTE Estos p rrafos est n rodeados por una CASILLA DE ALERTA DE SEGURIDAD Esta casilla se usa par designar y enfatizar las Advertencias de Seguridad que deben seguirse al operar esta lavadora a presi n Acompa ando a las Advertencias de Seguridad est n las palabras de alerta que designan el grado o nivel de seriedad de riesgo Las palabras de al
33. ltguard Warning Injury Decal 21 Beltguard 22 MSMW 60SLL073801V33 8 60HS CINV Mi T M Gasoline Air Compressor Manual EXPLODED VIEW amp EXPLANATION OF AIR COMPRESSOR FEATURES SAFETY RELIEF VALVE This valve is designed to prevent system failures by re lieving pressure from the system when the compressed air reaches a predetermined i level The valve is preset by the manufacturer and must not be modified in any way To verify the valve is working properly pull on the ring Air pressure should escape When the ring is released it will reseat EASY START POSITION PILOT VALVE When the toggle is in the upright position all air from the air compres OPERATING POSITION sor is vented through the discharge muffler This gives an easy start feature For normal operation the toggle is in the 90 position DISCHARGE MUFFLER AIR INTAKE FILTER This filter is designed to clean air coming into the pump To ensure the pump continually receives a clean cool dry air supply this filter must al ways be clean and ventilation opening free from obstructions Replace filter element when necessary OIL FILL PORT VENT Pour oil into the Oil Fill Port Vent when required OIL SIGHT GLASS The Oil Sight Glass displays the oil level in the pump The oil level should be at the center of the Oil Sight Glass If low add SAE 30W non deter gent oil AIR COMPRESSOR PUMP A two stage compressor pump uses two differe
34. nt size cylinders with the intake valve of the second smaller cylinder linked to the exhaust valve of the first larger cylinder On the down stroke of the large cylinder air is drawn through the intake valve while the exhaust valve remains closed On the upstroke air is compressed the intake valve closes and compressed air is forced out through the exhaust valve into the inter cooler and through the intake valve of the second smaller cylinder on its down stroke On the upstroke of the smaller cylinder the intake valve closes and the compressed air is compressed a second time and forced outthe exhaust valve into the discharge line through the tank check valve and into the air tank AIR TANK PRESSURE GAUGE The air tank pressure gauge indicates the reserve TANK PRESSURE GAUGE DECREASE air pressure in the air tank s PRESSURE REGULATOR PRESSURE REGULATOR The air pressure coming from the air tank is controlled by lt the regulator knob Turn the pressure regulation knob clockwise to increase discharge pressure and counterclockwise to decrease discharge pressure amp OUTLET PRESSURE GAUGE The outlet pressure gauge indicates the air pressure OUTLET PRESSURE GAUGE lt available at the outlet side of the regulator This pressure is controlled by the regulator and is always less or equal to the air tank pressure AIR TANK DRAIN VALVE The drain valve is used to remove moisture from the air tank s after
35. onnecting rod failure Tighten pulley and or flywheel Add correct amount of oil Check for bearing damage Remove cylinder head and inspect Clean or replace STOP THE AIR COMPRESSOR Contact Mi T M Customer Service Pressure drop in air tank or rapid pressure loss when air compressor is shut off Air leaks at connections Air leak in air tank Defective Pilot Valve Allow air compressor to build pres sure to the maximum allowed Turn off and brush a soapy water solution onto all connections Check connec tions for air bubbles Tighten the con nections where leaks are present Air tank must be replaced Do not attempt to repair air tank Clean or replace Insufficient pressure at air tool or accessory Pressure Regulator not turned to high enough pressure or defec tive Restricted air intake Air leaks or restrictions Hose or hose connections are too small or long Slipping belt Air compressor is not large enough for air requirement Restriction in Pilot Valve Adjust Pressure Regulator to proper setting or replace Clean or replace Air Intake Filter Check for leaks and repair Replace with larger hose or connectors Tighten or replace Check the accessory air requirement If it is higher than the CFM or pres sure supply to the air compressor use a larger air compressor Clean or replace Air leaks from Safety Relief Valve 16 Possible defective Safety Re
36. r mon xido de carbono Esun gas inodoro venenoso y invisible Respiraci n de este gas puede causar lesiones raves enfermos y posible a muerte ADVERTENCIA RIESGO DE LESIONES AL Nunca abrir la v lvula de descargas del tanque de aire cuando hay m s de 10 PSI de presi n de aire en el tanque de aire 31 OPERACI N OPERACI N 1 Leer atentamente las advertencias de seguridad antes de efectuar esta operaci n 2 Colocar muletilla que estar en la arriba de v lvula pilota a posici n vertical Este dar una empezada sin descargar Este compresor de aire puede descargar y tener una empezada de motor m s facil 3 Encender el motor Referir a manual de este unito de motor 4 Despues de 1 2 minutos de funcionando poner muletilla en posici n orginal 5 Ajustar la presi n moviendo el regulador de presi n el sentido contrario a las manecillas del reloj para reducir la presi n y en el sentido de las manecillas del reloj para aumentaria 6 En caso de ruidos o vibraciones an malos detener el compresor de aire y consultar la secci n Localizaci n de Aver as APAGAMIENTO 1 2 Para parar el aire mover el boton motor posici n OFF Referir a manual de motor de este unito Descargar el aire de los dep sitos de aire por medio de una herramienta conectada o tirando los anillos de la v lvula de seguridad Una vez que le presi n en el inter
37. resi n rapida dos bien que el aire dale Controlar los ac mente cuando el compresor de aire est apagado cesorios con una soluci n de agua y jab n No apretar demasiado La v lvula de retenci n y la Desmontar limpiar o sustituir v lvula piloto es defectuose Fugas de aire del dep sito de Sustituir el dep sito de aire No in aire tentar reparar el dep sito Presi n insuficiente en la her Fugas de aire Localizar las fugas y reparar ramienta o en los accesorios mE m Filtro aspiraci n aire obstruido Limpiar o sustituir Los tubos o los empalmes de los Sustituir con tubos o empalmes m s tubos son demasiado peque os o grandes largos El compresor de aire no produce la Controlar el requisito de aire del ac capacidad de aire requerida cesorio Si es superior al CMF o a la presi n suministrada or el compresor de aire es necesario usar un com presor m s grande El regulador de presi n no ha sido Ajustar el regulador de presi n al ajustado a una presi n suficiente gt valor adecuado o sustituir mente alta o aver a del regulador de presi n Las resbalaban de correa Haga mas apretado o reemplace V lvula pilota restrica Limpie o reemplace El aire sale de la v lvula de La v lvula de seguridad probable gt Activar la v lvula de seguridad manu seguridad mente es defectuosa almente tirando del anillo La presi n de aire en el dep sito Si el aire sigue saliendo debe ser e
38. ressor at least 12 inches away from obstacles that may prevent proper ventilation Do not place air compressor in an area where there is evidence of oil or gas leaks where flammable gas vapors or materials may be present where air temperatures fall below 32 F exceed 104 F where extremely dirty air or water could be drawn into the air compressor DANGER AD RISKOF EXPLOSION OR FIRE CAUSING SERIOUS INJURY OR DEATH Do not smoke while fueling Do not fill fuel tank while air compressor is running or hot Allow air compressor and engine to cool down for two minutes before refueling _ Do not fill fuel tank to point of di AW aT Allow approximately 1 4 of tank space for fuel expansion d WARNING Ad RISK OF EXPLOSION OR FIRE CAUSING SERIOUS INJURY OR DEATH Do not place unit an area where flammable gas vapors may be present Aspark could cause an explosion or fire Always store fuel away from the air compressor while it is running or hot amp WARNING RISK OF ASPHYXIATION o not operate in an enclosed area Use this product only in well ventilated areas The exhaust from the engine contains carbon monoxide a poisonous odorless an invisible gas Breathing the gas can cause serious Injury illness and possible death WARNING RISK OF BODILY INJURY ever attempt to open the Air Tank Drain Valve when more than 10 PSI of air pressure is in the air tank
39. ressor to cool down Wipe air compressor clean and store in a safe non freezing area START UP 1 Read safety warnings before performing operation 2 Flip the toggle on top of the Pilot Valve to the upright position This provides a loadless start The air compressor will unload and allow easier engine start up 3 Start the engine Refer to the Engine Manual accompanying this unit 4 When the engine has run for 1 2 minutes flip toggle back to the original position 5 Set pressure by adjusting the Pressure Regulator counterclockwise for less pressure and clockwise for more pressure 6 If you notice any unusual noise or vibration stop the air compressor and refer to Troubleshooting SHUTDOWN 1 To stop the air compressor move the Engine Switch to the Off position Refer to the Engine Manual Drain air from the air tanks by releasing air with an attached air tool or by pulling on the Safety Relief Once the Air Tank Pressure Gauge registers under 10 pounds open the drain valve under each air tank to MAINTENANCE Read the instruction manual before performing maintenance The following procedures must be performed when stopping the air compressor for maintenance or service 1 Turn off air compressor 2 Disconnect spark plug wire from engine 3 Open all drains 4 Wait for the air compressor to cool before starting service MAINTENANCE CHART AC Gas Maintenance Chart MAINTENANCE CHART PROCEDURE
40. s excesiva sustituida Interruptor motor presi n defectuoso Sustituir Mi T M Manual de operador de compresor de aire gasolina 33 LOCALIZACI N DE AVER AS Fugas de aire en la bomba Juntas defectuosas Sustituir y apretar los pernos de la culata Soufflement d air provenant du filtre d admission d air Soupape reed d admission d fectuuese Sustituir Condensaci n en el aire de descarga Condensaci n en el dep sito de aire debido a una elevada hume dad atmosf rica o el compresor de aire no ha funcionado por un tiempo suficiente Opera el compresor de aire por una hora para impedir demasiado condensi n Vaciar el dep sito de aire despu s de cada empleo Vaciar el dep sito de aire m s frecuente mente en climas h medos y usar un filtro en la l nea de aire Excesivo consumo de aceite en la bomba Filtro aspiraci n aire obstrucido Compresor de aire sobre superficie no nivelada C rter demasiado lleno de aceite Viscocidad incorrecto Ventilaci n de la varilla indicadora de nivel aceite atascada P rdidas de aceite Anillos del pist n desgastados o cilindro rayado Respirado de c rter es taparo Limpiar o sustituir No inclinar el compresor de aire a un ngulo superior a 10 en ninguna direcci n mientras est en marcha Vaciar el aceite Reponer con aceite hasta el nivel apropiado Elimina el aceite Llene al nivel correcto con SAE 30W aceite sin
41. s or models at any time without notice A IMPORTANT A DANGER WARNING or CAUTION safety warning will be surrounded by a SAFETY ALERT BOX This box is used to designate and emphasize Safety Warnings that must be followed when operating this air compressor Accompanying the safety warnings are Signal Words which designate the degree or level of hazard seriousness The Signal Words used in this manual are as follows DANGER Indicates an imminently hazardous situation which if not avoided WILL result in death or serious injury WARNING Indicates a potentially hazardous situation which if not avoided COULD result in death or serious injury CAUTION Indicates a potentially hazardous situation which if not avoided MAY result in minor or moderate injury or damage to the air compressor A The symbols set to the left of this paragraph are Safety Alert Symbols These symbols are used to call attention to items or procedures that could be b dangerous to you or other persons using this equipment ALWAYS PROVIDE COPY OF THIS MANUAL TO ANYONE USING THIS EQUIPMENT READ ALL INSTRUCTIONS IN THIS MANUAL AND ANY INSTRUCTIONS SUPPLIED BY MANUFACTURERS OF SUPPORTING EQUIPMENT BEFORE OPERATING THIS AIR COMPRESSOR AND ESPECIALLY POINT OUT THE SAFETY WARNINGS TO PREVENT THE POSSIBILITY OF PERSONAL INJURY TO THE OPERATOR INSPECTION Unbox the air compressor and write in the serial number in the space provided below Inspect
42. terprise Drive Peosta lA 52068 0050 Mi T M Manual de operador de compresor de aire gasolina 21 ADVERTENCIAS IMPORTANTES DE SEGURIDAD ADVERTENCIA Al usar este producto deben observarse ciertas precauciones b sicas como las siguientes LEA TODAS LAS ADVERTENCIAS DE SEGURIDAD ANTES DE USAR LA COMPRESOR DE AIRE PELIGRO RIESGO DE EXPLOSI N O DE INCENDIO 22 POSIBLE CONSECUENCIA O fuego chipas normales de sistema de encendido del motor o de exhosto de motor mofle puede causar lesiones graves y la muerte Un resulto de abastecer de combustible incorrecto es lesiones graves y la muerte Abiertas limitados de ventilaci n de compresor de aire puded causar lesiones graves Necesitar ventilaci n para evitar excesivo calor y empieza del fuego PREVENCI N Siempre funcionar el compresor de aire en ambientes de bien ventilados sin vapores flamables polvos combusible gases o toras materiales combustibles No fumar si pulverizando materiales flamables Poner el compresor de aire m s de 20 pisos de ambiente de pulverizar Puede necesitar un otro tubo No fumar cuando llenar el tanque de motor con combustible fuel Nunca llenar el tanque del motor con fuel cuando motor es calor o funcionamiento Permitir el motor 2 dos minutos para enifriarse antes de m s fuel No dar m s fuel adentro o en ambientes con mal ventilados Siempre reabastecer
43. the air compressor is vented through the discharge muffler This gives an easy start feature For normal operation the toggle is in the 90 position AIR INTAKE FILTER This filter is designed to clean air coming into the pump To ensure the pump continually receives a clean cool dry air supply this filter must always be clean and ventilation opening free from obstructions Replace filter element when necessary OIL FILL PORT VENT Pour oil into the Oil Fill Port Vent when required OIL SIGHT GLASS The Oil Sight Glass displays the oil level in the pump The oil level should be at the center of the Oil Sight Glass If low add SAE 30W non deter gent oil AIR COMPRESSOR PUMP To compress air the pistons move up and down in the cylinders On the downstroke air is drawn in through the air intake valves while the exhaust valves remain closed On the upstroke air is compressed the intake valves close and compressed air is forced out through the exhaust valves into the discharge line through the pilot valve and into the air tank TANK PRESSURE GAUGE DECREASE PRESSURE REGULATOR COUNTER V INCREASE il y CLOCKWISE w OUTLET PRESSURE GAUGE 7 AIR TANK PRESSURE GAUGE The air tank pressure gauge indicates the reserve air pressure in the air tank s PRESSURE REGULATOR The air pressure coming from the air tank is controlled by the regulator knob Turn the pressure regulation knob clockwise to increase
44. the air compressor is shut off NEVER attempt to open the drain valve when more than 10 PSI of air pressure is in the air tank To open the drain valve turn the knob counterclockwise TANK DRAIN Mi T M Gasoline Air Compressor Manual 11 12 NOTES Mi T M Gasoline Air Compressor Manual WARNING THE FOLLOWING PAGES CONTAIN OPERATING AND MAINTENANCE INSTRUCTIONS DO NOT ATTEMPT TO OPERATE THIS AIR COMPRESSOR UNTIL YOU HAVE READ AND UNDERSTOOD ALL SAFETY PRECAUTIONS AND INSTRUCTIONS LISTED IN THIS MANUAL INCORRECT OPERATION OF THIS UNIT CAN CAUSE SERIOUS INJURY DO NOT ALTER OR MODIFY THIS EQUIPMENT IN ANY MATTER Mi T M Gasoline Air Compressor Manual 13 warning RISKOF EXPLOSION ORFIRE CAUSING SERIOUS INJURY OR DEATH Do not allow the engine or muffler to come in Contact with flammable vapors com bustible dust gases or other combustible materials A spark may cause a fire When using the air compres sor for spray painting place the air compressor as far away from the work area as possible usingextra airhoses If needed PREPARATION INITIAL SET UP 1 Read safety warnings before setting up air compressor 2 Ensure the oil level in the air compressor pump is adequate If low add SAE 30W non detergent oil LOCATION 1 In order to avoid damaging the air compressor do not incline the air compressor transversely or longitudinally more than 10 2 Place air comp
45. ty environments are not warranted Failure to follow recommended operating and maintenance procedures also voids warranty 4 Labor charges loss or damage resulting from improper operation maintenance other than routine air tank draining and oil changes if applicable or repairs made by persons other than a Mi T M Authorized Service Center 5 The use of other than Genuine Repair Parts will void warranty Parts returned prepaid to our factory or to an Authorized Service Center will be inspected and replaced free of charge if found to be defective and subject to warranty Under no circumstances shall the manufacturer bear any responsibility for loss of use of the unit loss of time or rental inconvenience commercial loss or consequential damages There are no warranties which extend beyond the description of the face hereof For Service or Warranty consideration contact Mi T M Corporation 8650 Enterprise Drive Peosta IA 52068 0050 563 556 7484 800 553 9053 Fax 563 556 1235 Monday Friday 8 00 a m 5 00 p m CST 18 Mi T M Gasoline Air Compressor Manual NOTES Mi T M Manual de operador de compresor de aire gasolina 19 TABLA DE MATERIAS INTRODUCCION m kune kekan ak R ka Rek RAE H NE 21 IMPORTANTE ciini a 21 INSPEGGIONE por Ere Rx io Ex EX EX OX cn UR S EK E DOO REX E Ah 21 ADVERTENCIAS IMPORTANTES DE SEGURIDAD eene 22 25 R
46. umar cuando dando fuel No llenar el tanque de fuel cuando compresor de aire encendido o calor Permitiar dos minutos para enfriar antes de m s fuel combustible Permitir 1 4 de espacio de tanque para expansi n de fuel No llenar el tanque completo ADVERTENCIA A RIESGO DE EXPLOSI N MUERTE No poner el unito en ambientes con vapores flamables Una chispa puede causar un explosi n o unfuego Siempre guardar el fuel afuera de compresor de aire cuando funcionando o calor CONTROLES ANTES DEL ARRANQUE 1 2 Controlar el nivel del aceite si es necesario Eliminar la condensaci n del dep sito del compresor de aire Peligro de lesiones alcuerpo NO INTENTE JAM S abrirla v lvula de descarga cuando hay m s de 10 PSI de presi n en el interior del dep sito Descargar la presi n excesiva con una herramienta de aire luego abrir la v lvula de descarga del dep sito de aire ubicada en la parte inferior del dep sito Cerrar bien una vez descargado Controlar el boton de motor es en posici n de OFF Controlar que la v lvula de seguridad funcionando correcto Controlar que todas tapas y cubiertas est n en posici n y montar seguriando Mi T M Manual de operador de compresor de aire gasolina ADVERTENCIA RIESGO DE ASFIXIA o funcionar en ambientes de mal ventilados usar este roducto en ambientes de uen ventilados s lo El exhusto del motor contene
47. venientes p rdida comercial o da os consecuentes PARA SERVICIO O CONSIDERACION DE LA GARANTIA CONSULTE CON Mi T M Corporation 8650 Enterprise Drive Box 50 Peosta IA 52068 0050 Telefono 563 556 7484 Telefone gratis en los EE UU 800 553 9053 Fax 563 556 1235 Lunes Viernes 8 00 a m 5 00 p m CST Mi T M Manual de operador de compresor de aire gasolina 35 36 Mi T M Manual de operador de compresor de aire gasolina
48. xide gases Beware of poorly ventilated areas or areas with inadequate exhaust fans Operate air compressor only in a well ventilated area Follow all safety instructions provided with the materials you are spraying Use of a respirator may be required when working with some materials HAZARD RISK OF BURNS RISK OF FLYING OBJECTS RISK FROM MOVING PARTS _ K SAFETY WARNINGS READ ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR POTENTIAL CONSEQUENCE Serious injury could occur from touching exposed metal parts These areas can remain hot for some time after the air compressor is shutdown Soft tissue damage can occur from the compressed air stream Serious injury can occur from loose debris being propelled at a high speed from the compressed air stream Risk of bodily injury from moving parts PREVENTION Never allow any part of your body or other materials to make contact with any exposed metal parts on the air compressor Never allow any part of your body to contact the engine muffler or adjacent areas Always wear safety glasses to shield the eyes from flying debris Never point the air stream at any part of your body anyone else or animals Never leave pressurized air in the air compressor Shut off air compressor and relieve pressure when storing or attempting maintenance Always maintain a safe distance from people and animals while operating the

Download Pdf Manuals

image

Related Search

Related Contents

  取扱説明書 [PDF形式]  EZ036 ES-U-2101-M _USB-COMi-SI-M_ Manual  General Information  LG N195WU User's Manual  PC_Operatingmanual_heater_en  IPG LES TPS Datasheet_m402RU  MTD 599 Trimmer User Manual  

Copyright © All rights reserved.
Failed to retrieve file