590, 890
Contents
1. 1 Disengage the canister latches located on opposite sides of the power unit 2 Remove the dirt canister 3 Dispose of canister contents in trash receptacle 4 Raise the empty dirt canister to the proper location under the power unit and engage the latches 5 Be certain the dirt canister and the cyclonic cone seal are seat ed properly to the body of the unit Follow these steps to replace the filter cartridge refer to Illustration 2 Make sure the Power Unit is OFF 1 Unlatch and remove the Dirt Can ister e Cyclonic Cone Seal may not be properly seated Follow instructions for replacing the dirt canister e Tube lines may be obstructed First check the 90 degree elbow located directly behind the inlet valves if an obstruction occurs it will usually not make it past this elbow If the obstruction is not visible at the elbow attempt to purge the tubing at each inlet valve To do this connect the 2 Remove the cyclonic cone by pulling down on it Place cone in dirt canister 3 Remove the pleated filter by turning the filter latch 90 counter clockwise to disengage the filter The filter latch is located at the bottom of the pleated filter 4 Insert new pleated filter p n 8106 01 and engage filter latch by rotating it 90 clockwise until you feel it snap in place 5 Raise the dirt canister with cone inside to the proper location under the power unit and engage the latches2. 6 Be certain the dirt canister and cyclonic cone seal are seated properly to the body of the unit Filter Cartridge a Ty NOLL LU Cyclonic SS Cone Seal Filter Latch turn 90 to disengage filter Cyclonic Cone ILLUS 2 hose and use your hand to stop airflow at the end of the hose for a couple seconds let airflow re sume Repeat if necessary e If necessary call a qualified service person to perform required main tenance Obtaining Service Under Warranty To obtain repair on warranted parts contact the seller of the system with the power unit serial number Dirt Devil Pro Series LIFETIME LIMITED WARRANTY FOR MODELS 390 590 amp 890 All Permanently installed components of the Dirt Devil Built In Central Vacuum System are warranted to be free from defects in material and workmanship under normal use and care as long as the original consumer purchaser owns the home of original installation or until the power unit is removed from its original installation whichever occurs first In the event of a defect in permanently installed components of the Dirt Devil System an authorized dealer should be contacted Repaired or replacement parts at our option will be provided to you for any items under warranty Filter cartridges are not covered under warranty and should be replaced yearly Attachments Dirt Devil cleaning attachments including turbine power brushes non electric hos
3. tricque ayant un conducteur et une fiche de mise la terre Cette fiche doit tre branch e dans une prise appropri e qui a t install e et mise la terre convenable ment en accord avec le code lectrique de votre r gion AVERTISSEMENT Un branchement incorrect de l quipement de mise la terre peut causer un risque d lectrocution Si vous avez un doute concernant la mise la terre de votre prise veuillez faire v rifier votre installation par un lectricien quali fi ou une personne du service apr s vente Ne pas modifier la fiche fournie avec l appareil si la fiche ne se branche pas la prise faites installer une prise ad quate par un lectricien qualifi M THODE DE MISE LA TERRE Les appareils Dirt Devil 390 590 amp 890 doivent tre employ s avec un circuit de 120 volts et avoir une prise qui ressemble la prise illustr e sur l image A V rifiez que votre appareil est branch sur une prise ayant la m me configu ration que la fiche lectrique Aucun adapteur ne devrait tre utilis avec cet appareil ATTENTION NE PAS UTILISER SUR TAPIS OU PLANCHER MOUILLE c US LISTED Dirt Devil branded central vacuums are manufactured under exclusive license from Royal Appliance Mfg Co by H P PRODUCTS INC Louisville Ohio 44641 1 800 822 8356 or 330 875 5556 Fax 330 875 7584 Dirt Devil Pro Series 390 590 amp 890 OPERATING INSTRUCTIONS IMPORT
4. ANT INFORMATION FOR CENTRAL VAC OWNERS IMPORTANT SAFETY INSTRUCTIONS READ ALL INSTRUCTIONS BEFORE USING THIS VACUUM SYSTEM When using an electrical appliance basic precautions should always be followed including the following WARNING To reduce the risk of fire electric shock or injury e Unplug and disconnect power Do not put any object into openings before servicing Do not use with any opening blocked Do not use on wet surfaces Keep openings free of Do not allow to be used as a toy dust lint hair and anything that Close attention is necessary may reduce air flow when used by or near children e Keep hair loose clothing fingers e Use only as described in this and all parts of body away from manual Use only manufacturer s openings and moving parts recommended attachments Do not pick up anything that is Do not use with damaged cord burning or smoking such as or plug If appliance is not cigarettes matches or hot ashes working as it should has been Connect to a properly grounded dropped damaged left outdoors outlet See grounding instructions or dropped into water return it Turn off all controls before to a service center unplugging Do not pull or carry by cord use Use extra care when cleaning on cord as a handle close a door on stairs cord or pull cord around sharp Do not use to pick up flammable edges or corners Do not run or combustible liquids such as appliance o
5. IMPORTANTES MESURES DE SECURITE LISEZ COMPLETEMENT LE MODE D EMPLOI AVANT D UTILISER CE SYSTEME D ASPIRATEUR En employant un appareil lectrique des pr cautions fon damentales devraient toujours tre prises y compris AVERTISSEMENT Pour r duire les dangers de feu d lectrocution ou de blessure D brancher et couper le courant avant de le r parer e Ne pas utiliser sur des surfaces orifices bouch s Ne pase employer avec des orifices bouches Eliminer poussi re cheveux et les autres mouill es choses qui peuvent rendre difficile la Ne pas utiliser comme jouet et circulation d air surtout faire attention quand on e Gardez cheveux v tements amples doigts et toutes autres parties du l emploie pr s des enfants l a corps loin des orifices et des pi ces Employer seulement tel que d crit dans ce manuel d emploi et qu avec mobiles _ les accessories du fabricant z Ne pas aspirer queique chose qui e Ne pas utiliser si la corde ou la prise br le ou fume comme des lectrique est endo ag e Si cigarettes des allumettes ou des cendres chaudes l appareil ne fonctionnne pas est p none ete pitteee e Brancher une prise de courant t laiss ass o T t i munie d une mise la terre Voir les Z a reseignements de mise la terre re dans l eau veuillez App ome e Eteindre tous les contr les avant de l appareil un centre de service ee d branche
6. VE WARRANTY FOR THIS PRODUCT ALL OTHER WAR RANTIES INCLUDING IMPLIED WARRANTIES OF MERCHANTABILITY OR WARRANTIES OF FITNESS FOR A PARTICULAR PURPOSE ARE SPECIFICALLY EXCLUDED THIS WARRANTY COVERS ONLY THE LI ABILITY AND RESPONSIBILITY DESCRIBED HEREIN WHICH IS REPAIR OR REPLACEMENT AND THERE IS NO LIABILITY FOR ANY CONSEQUENTIAL INCIDENTAL OR SPECIAL DAMAGES ARISING FROM THE USE OF THIS PRODUCT OR THE FAILURE OF THIS PRODUCT H P Products Inc 512 W Gorgas Street Louisville OH 44641 1 800 822 8356
7. amp 890 appliance is for use on a nominal 120 volt circuit and has a grounding plug that looks like the plug illustrated in Fig A WARNING ELECTRIC SHOCK COULD OCCUR IF USED ON WET SURFACES c US LISTED CAUTION DO NOT USE ON WET RUG OR FLOOR Make sure that the appliance is con nected to an outlet having the same configuration as the plug No adapter should be used with this appliance Manufactured by HP Products Louisville OH P N 8267 03 Dirt Devil Pro Series Central Vacuum System Dirt Devil Pro Series Filtered Cyclonic OPERATING INSTRUCTIONS MODELS 390 590 amp 890 General Information Do Not Store Objects on top of the power unit This will block the motor cooling ventilation Restricting the cooling airflow may shorten the motor life The central vacuum is designed to vacuum ordinary household dirt and dust The system is designed for dry pickup A Wetvac accessory is needed if the system will be used for liquid pickup The central vacuum system is a net work of inlet valves 2 PVC tubing and low voltage wiring installed in the walls of your home To operate the system simply plug the hose into an inlet valve attach the clean ing tool to the curved hose end and begin vacuuming The dirt is transported through the in wall tube system back to the dirt canister lo cated on the power unit Caution Do not allow the motor to remain turned on unless a hose is connected or an inl
8. canister is removed the Cyclonic Cone will be visible The cone is designed to stay attached to the body of the power unit when the dirt canister is removed The cone is removable to allow access to the replaceable pleated filter To replace the cone follow the steps listed under replacing the filter Troubleshooting the system Motor Fails to Turn On e Check the main fuse or circuit breaker at the main power supply panel of your home Reset breaker or replace fuses if necessary e Check the Power unit reset button located above the power cord Pressing the button should restore operation e If the circuit protector continues to trip off after a short period of time the motor brushes may be worn out Call a qualified service person for service Loss of Vacuum If the system shows a loss of vac uum power check the following e The dirt receptacle and filter may need cleaned follow instructions in this guide e The hose may be clogged To check if there is an obstruction unplug the hose and insert an object that is smaller then the diameter of the hose A butter knife works well Pass the object completely through the hose if it stops that will indicate where the obstruction is located A dry garden hose can be inserted into the hose to help push obstruction through E 2 M gt ILLUS 1 Follow these steps to empty the dirt canister refer to Illustration 1 Make sure the Power Unit is OFF
9. es wands tools and tool caddies are warranted to be free from defects in material and workmanship under normal use and care for three 3 years from original date of consumer purchase Electric power brushes and hoses are warranted to be free from defects in material and workmanship under normal use and care for one 1 year from original date of consumer purchase In the event of a defect in a Dirt Devil attachment a repaired or replacement at our option part will be provided to you for any item s under warranty There is no warranty for consumable items such as light bulbs belts and beater brushes Limitations of Warranty The lifetime warranty begins on the date of the original purchase of the unit This warranty specifically excludes and there is no warranty on original or replacement filter cartridges and further excludes any damage due to shipping and handling or damage due to installation or faulty installation In order to obtain coverage under this warranty an owner must provide proof of purchase or have reg istered the Dirt Devil Central Vacuum Power Unit at 1 800 822 8356 or online at cvacregistration com or by completing and mailing the warranty registration card In addition to recover under this warranty an owner must have provided normal care and maintenance for the unit including but not limited to replacing the filter cartridge as needed and recommended by the Instruction Manual THIS WARRANTY IS THE SOLEAND EXCLUSI
10. et valve is open If air is not permitted to pass through the fan blades damage may occur to the motor General Power Unit Maintenance The simple care and maintenance instructions included here will help ensure trouble free use of the central vacuum system e Do not place objects on top of the power unit The motor could overheat e Do not allow the motor to remain on unless a hose is connected or an inlet valve is open If airflow is not permitted to flow through fan blades motor damage may occur e Empty the dirt canister when it is 1 2 2 3 full e Change the filter cartridge once a year e The power unit does not require any lubrication e The exterior of the power unit can be wiped with a clean dry cloth Do not use liquid cleaners or water as an electrical shock may occur e For additional service contact a qualified service person Operating Instructions Using the Central Vacuum System is easy Simply raise the inlet valve lid insert the hose end and attach the desired cleaning tool to the hose wand The Power Unit is acti vated when the hose is inserted into the valve Emptying the Dirt Canister amp Replacing The Filter Cartridge The dirt canister where the vac uumed dirt is deposited is the removable lower portion of the power unit The canister needs to be removed and emptied when it is 1 2 2 3 full The filter cartridge should be replaced once a year When the dirt
11. r e Ne pas tirer sur le cordon el ctrique e Faire bien attention en nettoyant les Ne pas utiliser le cordon el ctrique escaliers comme poign e ni le coincer dans e Ne pas utiliser pour aspirer des une porte ou l appuyer sur des coins liquides infammables comme et boudures tranchants Ne pas l essence et ne pas employer dans passer l aspirateur sur le cordon des endroits o ces choses peuvent lectrique Eloigner le cordon se trouver lectrique de la chaleur e Ne rien placer ou entreposer sur Ne pas d brancher en tirant sur le le dessus de l appareil une cordon lectrique Pour le surchauffe du moteur pourrait d brancher saisir la prise de se produire courant et non le cordon lectrique e Ne pas utiliser l appareil si le sac e Ne pas utiliser avec les mains poussi re ou le filtre n est pas mouill es en place e Ne rien mettre dans les fentes et les CONSERVEZ CES INSTRUCITONS USAGE RESERVE POUR LA MAISON OU EMPLOI COMMERCIAL LEGER Ne pas ventiler dans un mur un plafond ou un espace dissimul d un b timent ou un difice Ne brancher l appareil qu une prise avec mise la terre MOD LE A INSTRUCTIONS DE MISE LA TERRE Cet appareil doit avoir une mise la terre Si une d fectuosit ou autre survenait la mise la terre offre une voie de moindre r sistance au courant lectrique d o un risque moins lev d lectrocution Cet appareil est quip d un cordon lec
12. ver cord Keep cord gasoline or use in areas where away from heated surfaces they may be present Do not unplug by pulling on e Do not place or store anything cord To unplug grasp the plug on top of power unit over not the cord heating of motor could occur Do not handle system or appliance e Do not use without filter in place with wet hands SAVE THESE INSTRUCTIONS INTENDED FOR HOUSEHOLD AND LIGHT COMMERCIAL USE Do not vent into a wall a ceiling or concealed space of a building or structure Connect to a properly grounded outlet only GROUNDING INSTRUCTIONS This appliance must be grounded If it should malfunction or break down grounding provides a path of least resis tance for electric current to reduce the risk of electric shock This appliance is equipped with a cord having an equip ment grounding conductor and ground ing plug The plug must be plugged into an appropriate outlet that is properly in stalled and grounded in accordance with all local codes and ordinances WARNING Improper connection of the equipment grounding conductor can result in a risk of electric shock Check with a qualified electrician or service person if you are in doubt as to whether the outlet is prop erly grounded Do not modify the plug provided with the appliance if it will not fit the outlet have a proper outlet installed by a qualified electrician GROUNDING METHOD The Dirt Devil 390 590
Download Pdf Manuals
Related Search