Samsung Built in, 4 Burner, Cooking Zones (GN643EFX) User Manual
Contents
1. Neutral Thinner Benzene Detergent Abrasive 2 Top Plate of the Product Dried and attached overflow substance may be too sticky to be wiped out Wipe the product right after using If too much contaminated wipe the product using a dried towel with a neutral detergent and then wipe it again using a dried cloth If you wipe the top plate with a metal brush it will be damaged 3 Burner Part Clean it wearing gloves Clean the flame hole of the burner from time to time If the burner is contaminated tis flame hole is clogged making incomplete ingition Caution Take off the burner head Clean the upper circumference of the burner body and burner head using a harsh brush Use a drill for cleaning of the flame holes m f the flame holes are not drilled or the burner head has become thinned down due to a long period of use replace it with new one and keep it clean all the time m After cleaning dry the parts completely or assemble them to their Original positions If the ignition plug or its ambient part is wet electricity is not normally discharged m The safety device for automatic block of gas should be cleaned without any hard brush and etc If any soup is flown over wipe it out immediately Otherwise the product performance will decline and its life will be reduced as well 4 Assembly of Burner Head sAssemble the burner head onto the burner body correctly A Burner Head O X Warning B2. SER MANUAL GN643EFX XSA DROP IN GAS COOK TOP This user s manual is based on GN643EFX XSA To use this product correctly and prevent any potential risk read this manual User Guide Book before use the product Keep this manual User Guide Book at the place where you can find it easily Features of the Product Y Thank you for using our product This manual is designed for you to prevent any loss and or accident that may occur while using the product Read this manual carefully and be happy with our Product all the time High Efficient Sealed Burner Continuous Discharge Direct Ignition Type Thermo Element Type Safety Device 4 Burner Gas Range burners in diamond arrangement Easy Installation Gas Cook Top Range Suitable for System Kitchen Contents Table Safety Warning i The following marks are made to be easily understood so that you can prevent any safety related accident caused by misuse in advance and use the product more conveniently Completely understand the following contents before read the manual If this mark is neglected the user may be dead or seriously injured If this mark is neglected the user may be seriously injured A N Caution If this mark is neglected the user may be injured or damaged in property Whe following marks mean as follow General Danger Warning and Caution No Touch No Access amp Caution Inflammable Q Must Do L Wif gas seems to leak
3. and wall e There should be at least 15cm or longer gap from the product to the side of it Do not spill much water on the product Be careful not to spill much water on the top plate and etc Water causes short circuit electric shock and fire e lf much water is spilled stop using the product and consult with our service center Prohibited For gas connection and product installation consult with a gas supply agency or installation agency Gas connection or product installation by unqualified staff may cause product damage and fire In this case we do not take any responsibility Must Do Make sure that the power cord is not contaminated with any alien substance and then push the power cord to the end of the outlet e f the wiring contact part is contaminated with dust water and etc or the power cord is not completely inserted into the outlet electric shock fire may occur The product must not be disassembled repaired modified by anyone other than our service engineers e Disassembly repair modification by any unqualified staff may influence on the product safety If you think that the product has problems see this manual or contact our service ian Prohibited Troubleshooting When an earthquake or fire occurs or if you feel any abnormal combustion abnormal sound abnormal Do not plug too much stuff in It could cause overheating and fire smell immediately stop using the
4. and you may be injured S Do not disassemble repair modify the product e The product must not be disassembled repaired modified by other than our service engineers Otherwise the relevant person may be injured by abnormal combustion or malfunction Must Do Prohibited Do not spray water on the product Do not spray water on the product including its top plate and etc Otherwise electric shock and fire may occur due to short circuit Wipe the product without using any inflammable substance such as thinner benzene and etc Prohibited Such inflammable substances such as thinner and benzene may cause fire Wear gloves for maintenance work e Otherwise you may be injured Daily Checkout Are the burner head and trivet correctly assembled m Is the flame hole of the burner head clogged by overflowed soup Are the heat sensor hem of the safety device for automatic block of gas and or the ignition plug contaminated with any alien substance or soup dreg due to overflow Must Do Read this section carefully for correct maintenance A N Warn in g Maintain and clean the product wearing gloves 1 Surface of the Product Wipe it well with a soft cloth Wiping it with any metal or nylon brush may damage it Wipe overflowed part with neutral detergent i S Brush i i idi i and dry it fully panan rush Edible Oil een e Alkali detergent may damage the coated face of product p Cae CD Up
5. ct to dry cloth ignite other e It may be abnormally overheated by incomplete inflammable objects and etc may cause fire and combustion causing fire product damage or carbon monoxide poisoning In this case we do not take any responsibility to any product damage and accident product damage Z Prohibited l PIGCN _ Prohibited m Make sure connection between gas connector and gas hose is firm Otherwise gas may leak and cause fire Make sure of using the gas as specified on the nameplate LN gas e The gas connection work should be carried out by a qualified ee gas supply agency or gas piping facility agency i After completing pipe connection you must apply gas Seal Packing leakage test Use product after you make sure of no gas leakage Gas hose Must do Ventilate frequently while using e While using ventilate the room by using a range hood or by opening the window Otherwise you may be poisoned by carbon monoxide Also when you use a humidifier flame might be unusually red This is a result of the interaction between flame and water vapor Turn off the humidifier and ventilate the room then flame will turn to normal conditions Must Do m Adjust the fire power properly for the kettle or pot size The flame wider than the pot makes the pot handle overheated Then you may be burned Prohibited alnstall the product on even and stable place Otherwise the pot on the
6. e burner head Yellow Flame Different gas is used Check the gas used Unstable Flame The burner head is badly assembled Assemble the burner head correctly The gas hose is not well connected Connect the hose firmly Gas Smell The gas hose has crack or some hole Replace the hose with new one For any other problems please consult with the distributor which you have purchased the product or our service center Product Specification Ale Jr YTY YC Dimension 478 Unit mm Hyl Produce Name Gas Range 4 Holes Ignition Type Continuous Ignition Type Weight 9 5 kg 8k Product Weight 9 8ko Dimension 590mm W x 505mm D x 87mm H Gas Connection G 1 2 Powe 240V 50 p Safety Device Thermo Element Type Safety Device S V User s Manual Installation Manual Big Burner Head 1 EA Parts Middle Burner Head 1 EA Small Burner Head 2 EA Firepower Adjustor Handle 4 EA Gas Used Big Burner Middle Burner Small Burner 2EA R LN Gas KW 4 53 3 50 1 61 Installation and Construction Manual Construction work must be done by a licensed builder In particular for A N gas connection you must consult with a gas supply agency or licensed installation agency lo use this product correctly and prevent any potential risk read constuction manual then follow instructions YOU must wear gloves when installing product Drawing of compl
7. erwise safety related incident might occur For example pot could fall down Name and Function of each Part ___General Low Calorie Burner Small Burner Low Calorie Burner Small Burner High Calorie Burner Big Burner Standard Calorie Burner Middle Burner Top Plate Firepower Adjustor Handle Right Burner Big Burner Firepower Adjustor Handle Left Burner Middle Firepower Adjustor Handle Center Front Da e nee nean Burner Small Burner Checkout m This figure shows the product with every component part attached on their right positions Check the component parts and attach them on their right positions as specified in Guide Book for Installation and Construction Work m This product is for 240V only Check the voltage at home 13 Component Parts Trivet Small Burner Head Middle Burner Head Big Burner Head Body Cover Vinyl Checkout m This figure shows the product with its package opened e Check whether every component part is exactly at their positions Their positions may affect the product performance Remove all tape styrofoam paper and etc They are all for the product protection only during transportation Does the product meet the gas specification at your home Check the nameplate under the product Q Reference If you want to purchase a component part separately e Contact any of our distributors or service centers nearby How to Use the Burner 1 Make
8. ete installation Production Dimension Caution 590 A Ty AOS LORO IY ALA LE SIV TE 505 Upper Front Countertop 30 40 58 5 e Cutout Dimension ol Q A fo g Q Fi o Q S 3 R20 or Less x z 5 58 T las oO 1 oe A 285 H 600 or More O ja 4 7 n 600 or More p les 480 2 j 2 560 S T E E ra Y i 9 Air Vent Air Vent 80 or More Make an air hole with 560 W X 80 D in size needed for combustion in the upper rear plate If you don t have this air hole it could have negative effect on the performance of product e Safe Distance 0 0 2 5 P 5 15cm 15mm 15cm or longer or longer or longer lt gt S oO C LCR E a Che Fo SS al f M 7 7 oy 5 Tov 8 zZ F iy L L e If you install another appliances under this product i e dish washer and etc have a distance at least 3c of more from product e There should be enough space between product and wall There should be at least 15cm or longer gap from the product to the side of it Drawing of complete installation User s Manual Installation Manual Warranty Card O e The depth of countertop requires at least 60cm or more e The top plate of countertop should be made of HPM high pressure melamine sheet or the e
9. he efficiency of product will decrease and it may cause fire Must Do While after using be careful not to be burned e The product is hot while after using Be careful not to be burned No Touch a Install the middle vale at the spot where you can control it conveniently Do not have the middle valve and its hose pass on through any furniture within 50cm or shorter near such furniture If the middle valve has a fuse cock check whether such a fuse cock has bigger capacity than the product SY Prohibited lf you have any mechanical substances such as artificial heart and etc in your body consult with a doctor before using the product e Such mechanical substances may be influenced by the product while using Must Do m Check the burner handle to be used before ignition e If an undesired burner is ignited it causes unnecessary gas loss and a burn lf you close the door to cabinet too fast flame might turn off due to convection current e If flame is turned off safety device automatically stops gas supply safely In this case ignite again m Must Do Wear gloves to wipe any sharp things such as trivet and etc Otherwise you may be injured Do not ignite the product without any pots on it Any item above the product such as a range hood may be heated and deformed damaged Prohibited Must Do a Make sure trivet is in the right position Oth
10. ment position and then ignite again lf not used for a long time the product will not be well ignited because the gas tube has full of air 3 Firepower Adjustment Adjust the flame by slowly turning the firepower adjustor handle Extinguishment Q within the range between the extinguishment and ignition If the flame is extremely reduced or adjusted too fast it may be MUSEO extinguished Becareful J Extinguishment Turn the firepower adjustor handle clockwise to the extinguishment position When the burner is extinguished it may sound Puck which is the sound made when the flame is off and this does not show any abnormality Right after extinguishment the product is still hot Be careful not to be burned Close the middle valve e Turn the handle as shown by the arrow e The figure shows the closing status of the middle valve Extinguishment Must Do Closing Status of Middle Valve A N e To prevent any fire accident or gas leakage caused by children close S Caution the middle valve when the product is not used Prohibited Maintenance Maintenance work should be done with the middle valve closed wearing gloves Q Otherwise you may be injured Electric Shock Fire and etc After maintenance work make sure that there are no unnecessary items such as tools and etc inside the product If there is some remove it Otherwise the product may be damaged fire may occur
11. mpany It should be grounded e Any work for AC 240V power power ground and cabling should be done in accordance with the Q relevant rules as follow Relevant Rule Electric Facility Standard Electric Appliance Using Method Electric Work Law Inner Wiring Rule and etc Must Do j Drop in gas cook top Sam 4 Burner 240V e Even at any place where 240V is used the power consent should be grounded if it is not grounded at its side Power a Do not be away from the product while leaving the fire on Do not go out nor sleep e Otherwise the product will be overheated causing the product damage or fire Especially if you leave the product for a long time while cooking fries fish food and etc fire may occur S If you have to make a phone call or have a guest stop using the product Prohibited Do not place any flammable object near the product Do not use any inflammable gas product such as a Spray near the product Keep any flammable object such as curtain and any inflammable objects such as a spray gasoline and benzene away from the product Such objects may cause fire Prohibited mm A N Warning J0 7 15cm or longer 100cm or longer 15mm or longer ES Must Do If you install another appliances under this product i e dish washer and etc have a distance at least 3cm or more from product There should be enough space between product
12. ous that product or handle may deform S Prohibited Do not install the product under any plastic lighting device e The heat emission from product could deform the lampshade It could cause fire Prohibited Do not place any objects in front of the product while using Such objects may be overheated and damaged and cause fire Must Do Standard pot size for each burner Diameter of standard pot diameter xFor gas consumption refer to specification Unit cm Safety Caution Do not use the product at windy place due to fan and etc or where wind blows from the behind of the product The product inner part may be damaged the safety device may be malfunctioned the product may be badly ignited and etc Use any home appliances with a fan far away from the product Install the product on the sink with a dept of 60cm or longer e Otherwise the rear side may be discolored and deformed rear side er Do not install the product where water may splash e Splashed water may cause electric shock and short circuit Prohibited Do not repeatedly ignite the product If the product has not been ignited and needs be ignited again ignite it again after the live gas disappears 3 4 seconds later e During the monsoon season or on a humid day the product may not be well ignited due to the high humidity in the ignition part If you repeatedly ignite the produc
13. product and close the middle valve to ventilate and then plug out the power cord from the outlet Must Do Do not touch the product while using or for a certain period after using While after using the product top plate and nearby of the product is very hot If you touch it you may be burned No Touch After using the product turn the ignition handle to the Extinguishment position e Otherwise gas may leak e Close the middle valve before go to bed or go out Must Do Middle Valve Closed Use an outlet for AC 240V only ith Prohibited Keep children away from the product Do not let children close to the product Otherwise she he may be burned and or electrically shocked No Touch Do not use product when power cord is defective or power cord and metal part are loosed e It could cause electric shock or fire Call for our after sales service agency 9 Prohibited Do not scratch process extend the power Do not have the gas hose and power cord pass cord Do not force it to be bent or bound on the top or the bottom of the product e Otherwise it may be broken causing fire and electric shock e It may be fused by contacting the hot part so that gas may leak and fire may occur Prohibited Prohibited Do not use any supportive tools or a big iron plate Do not use the product other than cooking and pottery that may cover the whole gas range Using the produ
14. product may fall down causing a burn and injuries Do not use the product on moveable place such as vehicle boat and etc 9 Prohibited Do not use any neutralized bottom narrowed or bottom slippery unstable pot Take a special care while using a pot with long handle A neutralized or bottom narrowed pot may be unstably placed on the trivet A pot with long handle may fall down due to the weight of its handle or due to touching the handle while using Then you may be burned Prohibited Do not remove any part out of the product nor any separate supportive items Do not use any supportive tools purchased in the market aluminum foil or other supportive tools e You may be poisoned by carbon monoxide due to incomplete combustion Fire may occur or the product may be damaged by abnormal overheating 9 Prohibited m When you plug out do not pull wire out harshly e Power cord could be damaged or it might cause an electric shock or fire e Hold the power cord then plug out Prohibited Make gas pipe as short as possible Prohibited Do not use the product under something that can easily fall down e Such things may fall down and cause product damage and fire Prohibited When you use product choose the size of pots according to the table If you use an excessively big pot product may get deformed or damage Also it may cause abnormal operation e It s danger
15. quivalent of it e The countertop cutout must be prepared within the tolerance limits of dimension e Allow 65mm horizontal clearance between from the edge of front countertop to product Drawing of complete installation e Make sure of using the gas as specified on the nameplate LN gas e The gas connection work should be carried out by a qualified gas supply agency or gas piping facility agency Gas Connector G e After completing pipe connection you Seal Packing must apply a gas leakage test Use product ofter you make sure of no gas Gas hose l leakage Assemble product into the countertop e Place burner head onto corresponding burner body according to burner location correctly Make sure that the burner head is not lifted up nor tilted e f burner head is not correctly assembled ignition may fail Service Information ELECTRONICS If you have any questions or comments relating to Samsung products please contact the SAMSUNG customer care centre Tel 1300 362 603 WWW Samsung com au Memo
16. sure that the gas is conformable and the gas hose has any problems Q 2 Make sure that the firepower adjustor handle is on Extinguishment position Must Do before opening the middle valve 3 a Check the burner to be used and the firepower adjustor handle Choose the bumer propery for usage Middle Burner Small Burner General Cook e Warming of Coffee Large Volume of Cook e Fine Heat Control e Strong Firepower Needed Cook Needed Cook e Heating of Frozen Food oUse the big burner for fried food Q oUse the big burner to heat frozen food or cook curry that is frozen in a pot ii O A pot with round bottom may fall down Be careful not to be burned Put the pot stably at the center of the burner to use A Preparation Make sure that the power plug is inserted into the outlet Q Make sure that the firepower adjustor handle is on Extinguishment position Then open the middle valve Must Do Open Status of Middle Valve Ignition Pressing the firepower adjustor handle turn it toward the ignition counterclockwise Q direction completely If you release the handle while turning the Extinguishment product will not be ignited MustDo Release the handle after confirming that the product has been ignited 4 burners will all discharge electricity but only the burner for ignition will be ignited lf not ignited turn the firepower adjustor handle to the extinguish
17. t in this case some live gas may be accumulated around the product and may be exploded and fired Must Do Do not let water or soup overflowed while using e If the top plate of the product is contaminated with overflowed liquid and continuously heated bad odor may be detected and the pot may be damaged e lf the top plate of the product is contaminated with any alien substance wipe it out clearly Otherwise the plate may be stained Prohibited m Keep your body and clothes away from the flame while using The clothes may catch fire and you may be burned amp Prohibited Keep your face away from the burner while igniting e You may be burned and injured by the heat of fire or explosion Prohibited Do not heat any unpeeled fruit or capped bottle e Heat it after peeling off Never heat any bottles Otherwise it may be exploded and then the product will be damaged and you will be injured Prohibited Do not install the product near TV or a radio TV or radio may make some noise TV screen may have poor quality pictures To prevent these keep the product more than 4 meters away from the TV or radio Must Do m After washing the burner head dry it completely e If it is incompletely dried it will not be well ignited or will be incompletely combusted Must Do The bottom of pot should be clean e If you heat the pot contaminated with alien substance or with soot t
18. take action as follow It should be grounded If gas seems to leak take action as follow Do not turn on the light Do not switch on off any electrical appliance and do not touch any electric plug Do not use a telephone In this event take action as follow Stop using the product and close the middle valve Open the window to ventilate Contact our service center by using a phone outside Caution Inflammable Must Do Use a phone outside x The fuel gas contains mercaptan so that you can feel that the gas leaks even where only 1 1000 of the gas exists in the air with specific smell smell of rotten garlic or egg m Use the specified gas only e Make sure that you should use the gas as specified on the product nameplate e Otherwise the gas may be incompletely combusted and cause you to be poisoned by carbon monoxide or to be burned by explosive ignition In addition it may not be ignited The product nameplate is on the bottom of the product If you don t know which gas you should use contact our service center Make sure that the power voltage is the same as specified This product is used at 240V only e Otherwise the product will be damaged and cause firing and electric shock e In case of moving out make sure that you should use the gas as specified on the nameplate This product needs AC 240V power For more information about electric wiring consult with a qualified electric facility co
19. urner Body Big middle Good assembly Bad assembly small burner Place the trivet on its exact position e Otherwise some problems like falling down of a pot may occur Q m After washing the burner head dry it completely Otherwise the product may not be ignited or it may be ignited explosively Must Do 5 Component Parts m After the cooked food is cooled wash the component parts including burner head trivet and etc with a neutral detergent After washing them with a neutral detergent dry them completely You must wear gloves when washing component parts Troubleshooting In case there is any problem in Gas Cook Top Range check the followings before you apply for A S The burner head is badly assembled Assemble the head correctly The middle valve is closed Open the middle valve completely Open the middle valve completely supply is not enough Change gas container in case of LPG Badly ignited The burner head is badly assembled Assemble the head correctly i Mae E a Wipe such alien substance with a dried cloth e The gas tube has some air Tum the ignition fireoower adjustor handle repeatedly The burner head flame hole is clogged Clean the burner head ihe eee e The burner head is badly assembled Assemble the burner head correctly Fire off while using e The safety device is contaminated with alien substance Clean the safety device The burner head hole is clogged Clean th
Download Pdf Manuals
Related Search