Assembly and User's Manual - E-Ride
Contents
1. rye FF 22 Warranty Service Options amp EXcluSiONS ccsssessssssesecssssssssssssesesssssesecsssesescssssseesees 23 RUM an 24 FEATURES amp SPECIFICATIONS FEATURES AND SPECIFICATIONS Motor Specs Bbrushless DC Motor Rotated Pick Power 500W Speed 400r min Recharge Time for the Battery 4 6 Hours Battery Holds 4 6 Hours of ride Time One Full Charge Lasts up to 50 km with single battery and 80 km with dual Regeneration models can go up to 100 km Speeds up to 32km h on level pavement with 75 kg rider Weight of MOTORINO 55 kg CONTENTS OF THE BOX MOTORINO with 48V battery installed charging required Left and right pedals to be attached no tool required MOTORINO 48V charger for 110V AC outlet User s manual Two Ignition Keys also used for under seat storage and main battery compartment Two Storage Box Keys GENERAL USAGE RESTRICTIONS AND GENERAL SAFETY INSTRUCTIONS This Manual contains many A WARNING notes concerning the consequences of failure to maintain or inspect your MOTORINO A AWARNING means that failure to follow the instructions following it may result in injury to the rider or others during use which may include loosing control and falling Because any fall can result in serious injury or even death we do not repeat the warning of possible injury or death whenever the risk of falling is mentioned A on the other hand means that failure to follow the instructio2. TUBE AND THE MOTORINO IT MAY ALSO CAUSE YOU TO LOSE CONTROL AND FALL Make sure that the air pressure for all tires is correct The proper inflation amount is listed on the sidewall of the tire If the tires have less that the recommended amount of pressure this will decrease the battery usage time and may cause the unit to handle poorly or cause damage to the tires Use an air pressure gauge to check for the air pressure of the tire DO NOT USE GAS STATION AIR FILLING STATIONS AS THE PRESSURE IS USUALLY TOO HIGH AND THE GAUGES ARE INACCURATE OVER INFLATION OF THE TIRE COULD CAUSE A BLOW OUT AND CRASH BRAKE MAINTENANCE Take a look at the brake pads before every ride If when the brake lever is engaged approximately one 1 inch of brake lever movement and the brake pads are not firmly against the wheel rim do NOT ride the MOTORINO Call Greenwit Customer Service at 1 888 331 0555 Thu Sun 11am 6pm PST or visit your local bicycle dealership and have them adjusted or replaced Check the control cables and cable housings Any rust Kinks Fraying If so do NOT ride the MOTORINO Call Greenwit Customer Service at 1 888 331 0555 Thu Sun 11am 6pm PST or visit your local bicycle dealership and have them adjusted or replaced Adjusting the brake cables at the brake lever can be accomplished by most people however brake pad adjustment or cable replacement should only be performed by people with expertise in performing such adju
3. and make sure to remove the wheel retention clips on the front wheel Be sure to remember where all the spacers and washers belong For rear tire removal you will also need to slip the chain off the rear sprocket to remove the wheel The chain must be properly reinstalled and re tensioned when reinstalling the rear wheel Make certain the chain is properly positioned on both front and rear sprockets before re tightening rear wheel 3 Remove one bead of the tire from the rim by grasping it at a point opposite the valve stem with both hands and at the same time lifting and peeling one side of the tire off the rim If the bead is on too tight for you to unseat it with your hands use tire levers to lift the bead carefully over the tire rim Tire levers can be purchased at any local bike shop Push the valve stem through the wheel rim Remove the inner tube 4 Carefully check the outside and inside of the tire for the cause of the puncture and remove any debris or damaging material from the inside or outside of the tire VAWABNING F THE TIRE IS CUT YOU MUST REPLACE THE TIRE TO PREVENT ANY SUDDEN AND CATASTROPHIC FAILURE CAUSING LOSS OF CONTROL SERIOUS INJURY OR DEATH Replacement parts are able to be purchased by calling the Greenwit Customer Service at 1 800 331 0555 M F 10am 9pm PST or by visiting Greenwits s web site at www greenwit com WARNING PATCHING TUBE IS AN EMERGENCY REPAIR CARELESS PATCHING OR APPLYING SEVERAL PATCHES C
4. drive chain in an upward direction approximately 1 If there is greater than approximately 1 of movement the drive chain must be adjusted before use to avoid unseating falling off Before adjusting the chain please make sure the key is in the position and disconnect the battery power to prevent any injuries or damage To disconnect the main battery power lift the foot mat and unlock the lock located on the left side of the MOTORINO using the ignition key Proceed to pull the battery out utilizing the handle Disconnect the battery cable Loosen both rear axle nuts until the wheel will move freely in the behind the rear axle until the proper tension is achieved The screws must 4 be turned clockwise to tighten and counter clockwise to loosen the chain Check the tension by rotating the wheel by hand Be sure that the drive chain is not too tight if so the chain will break Tighten the rear axle nuts and re check the tension Make sure that the rear wheel is installed straight and that the tension adjustment screws have not caused the rear wheel to sit crooked once the axle nuts are tightened The chain should be cleaned and lubricated with bicycle chain lubricant available at local bike shops after every 100 miles of riding or every three rides or after riding the MOTORINO in wet road conditions MAINTENANCE TIRE MAINTENANCE Make sure that the air pressure for all tires is correct The proper infla
5. please call Greenwit Customer Service Technical Support Toll Free at 1 888 331 0555 Thu Sun 11 am 6pm PST 330 BATTERY BEFORE OPERATING YOUR NEW MOTORINO FORTHE FIRST TIME CHARGE THE BATTERY FOR 14 16 HOURS BUT UNDER NO CIRCUMSTANCES IN EXCESS OF 18 HOURS Be sure to charge the MOTORINO after each use Keeping the battery properly charged will help extend the battery life Do not use the MOTORINO while the power indicator on the instrument panel shows low energy If the MOTORINO 15 over used the battery s life will be reduced The MOTORINO uses 48V volt battery pack To charge the battery connect the 3 pin plug into the charging receptacle located directly below the front of seat The battery must be charged while installed in the MOTORINO If you notice anything unusual about the battery such as a cracked or leaking battery case a battery that gets hot while being used or charged a battery case that appears puffy or bloated etc or there are any other problems with the battery please contact Greenwit Customer Service Technical Support Toll Free at 1 888 331 0555 Thu Sun 11am 6pm PST The battery is 568160 and is NOT user serviceable Do not attempt to repair remove adjust or in any way alter any internal or electrical components controls or wiring without first speaking with a customer service representative The main battery weighs approximately twenty eight 37 pounds There i
6. power is connected to the charger If the light does not come on check all connections If it still does not come on after checking all connections fuses and that your AC plug is working unplug the charger and call Greenwit Customer Service Technical Support Toll Free at 1 888 331 0555 Thu Sun 11am 6pm PST 9 BATTERY 6 A WARNING DO NOT KEEP THE MOTORINO CONNECTED TO THE CHARGER FOR LONGER THAN 18 HOURS UNDER ANY CIRCUMSTANCES DOING SO COULD CAUSE THE BATTERY OR CHARGER TO OVERHEAT AND CAUSE A FIRE 7 When the light on the 36V charger is blinking the MOTORINO battery is being properly charged When the MOTORINO battery is fully charged the light will remain lit without blinking see 48V charger for example If this does not occur after approximately 16 hours of charging unplug the charger and call Greenwit Customer Service Technical Support Normal recharge time for the main battery is 4 6 hours assuming it is not 10090 discharged 8 Disconnect the Input Cord from the Charging Receptacle 9 Disconnect the charger from the 110V Power Source 10 A WARNING NEVER LEAVE THE BATTERY CHARGER CONNECTED TO THE 110V POWER SOURCE OR THE MOTORINO WHEN NOT CHARGING THE BATTERY KEEPING THE CHARGER PLUGGED INTO THE 110V POWER SOURCE AND NOT THE BATTERY COULD CAUSE THE CHARGER TO OVERHEAT AND OR CAUSE A FIRE 11 When storing your MOTORINO for lengthy periods of time the battery should be charged at least once a month to a
7. threads They are not interchangeable The left pedal goes into the threaded hole on the left crank arm on the left side of the MOTORINO your left side as if seated on the MOTORINO The inside surface of the crank arms are labeled L and like the pedals The Left pedal has reverse threading meaning it tightens by turning it to the left counter clockwise The Right pedal has normal threading and tightens by turning it to the right clockwise After threading the pedals into the crank arms as far as possible with your fingers to avoid cross threading tighten them snugly with an adjustable wrench REARVIEW MIRRORS _ Locate the chrome mirrors included with your Pal 80008 ney These have threaded ends and include a nut With the Hexagonal Allen or Hex wrench remove screw and i nut as shown in the pictures Once the nut is removed from i the threaded end of each mirror insert the threaded end of the mirror as shown on picture at left Then screw the nut onto mM the mirror s threaded end as shown on picture below The mirror needs to be Mi Irror tightened fully for assembly 3 to safe Repeat the x process for the other mirror ha Once mirrors are installed they should look like the picture on left Make sure to adjust the mirrors before use so that you can see behind you as you ride You have now successfully assembled your MOTORINO If you have any questions about assembly
8. AN SERIOUSLY WEAKEN THE TUBE RESULTING IN POSSIBLE TUBE FAILURE WHICH COULD CAUSE YOU TO LOOSE CONTROL AND FALL REPLACE A PATCHED TUBE AS SOON AS POSSIBLE 5 Reinstall the tire and tube Slip one tire bead over the rim Inset the tube valve through its hold in the rim Feed the tube carefully into the cavity of the tire Inflate the tube just enough to give it some shape Starting at the valve stem and working around both sides of the rim to the side opposite the valve stem use your thumbs to push and seat the other bead of the tire inside the rim Be careful not to pinch the tube between the tire bead and the wheel rim If you have trouble getting the last few inches of bead over the edge of the rim with thumb pressure use a tire lever and be careful not to pinch the tube CAUTION F YOU USE A SCREWDRIVER OR ANY TOOL OTHER THAN TIRE LEVER YOU ARE LIKELY TO PUNCTURE THE TUBE 6 Check to make sure that the tire is evenly seated around both sides of the rim and that the tube is inside the tire beads Push the valve stem into the tire to make sure that its base is seated within the tire s beads Inflate the tube slowly to the recommended pressure on the tire sidewall all the while checking to make sure that the tire beads stay seated in the rim Replace the valve cap Replace the wheel in the MOTORINO MAINTENANCE VA WARNING RIDING YOUR MOTORINO WITH A FLAT OR UNDER INFLATED TIRE CAN SERIOUSLY DAMAGE THE TIRE RIM WHEEL
9. DITION OF THE MOTORINO OR ANY OF ITS PARTS DONT USE IT CALL GREENWIT CUSTOMER SERVICE AT 1 888 331 0555 Thu Sun 11AM 6PM PST AND THEY WILL ASSIST YOU IN PERFORMING A THOROUGH CHECK MAINTENANCE Technological breakthroughs have made components more complex than ever before and the pace of innovation is increasing This on going revolution makes it impossible for this manual to provide all the information reguired to properly repair and or maintain your MOTORINO In order to help minimize the chances of an accident and possible injury it is critical that you have all repair and maintenance work performed regularly For more detailed maintenance instructions or for ordering replacement parts please contact Greenwit Customer Service Technical Support Toll Free at 1 888 331 0555 Thu Sun 11am 6pm PST Local bicycle retail stores which have service facilities in your area can also assist you with certain non electrical repairs or adjustments that you are not qualified to make or for which you do not have the specific or specialized tools needed for repair DRIVE CHAIN MAINTENANCE Periodic adjustments of the drive chain will be necessary to maintain proper tension If the drive chain is loose it may make popping noise which indicates a need for immediate adjustment To manually check the drive chain tension make sure the drive chain is properly seated on both the front and rear sprockets Move the top portion of the
10. N THE CURRENT WARRANTY IS AVAILABLE ON THE INTERNET BY VISITING WWW E RIDE CA OR BY CALLING THE GREENWIT TOLL FREE CUSTOMER SUPPORT NUMBER AT 1 888 331 0555 GREENWIT OR THE RETAIL STORE MAY REFUSE ANY RETURN OR EXCHANGE IF THE PRODUCT IN QUESTION APPEARS TO HAVE BEEN NEGLECTED BY THE OWNER OR IF THE PRODUCT HAS BEEN DAMAGED OR IF THE CONSUMER FAILED TO COMPLY WITH THE WRITTEN INSTRUCTION MANUAL THIS 10 DAY RETURN POLICY OR THE GREENWIT WARRANTY TERMS RETAILERS AND SELLERS OF GREENWIT PRODUCTS ARE NOT AUTHORIZED TO MODIFY THIS RETURN EXCHANGE POLICY OR WARRANTY IN ANY WAY NOTES NOTES oo
11. READ THIS MANUAL BEFORE OPERATING YOUR MOTORINO GREENWIT Ltd STRONGLY SUGGESTS THE OPERATOR OF THIS PRODUCT BE 16 YEARS OF AGE OR OLDER Assembly and User s Manual Model XT ST VT For the most recent version of this user s manual and for all updated product information please visit www greenwit com or call Customer Service Technical Support at 604 331 0555 Tus Sun 11am 6pm PST GREENWIT 405 201 Alvin Narod Mews Vancouver BC V6B 8P5 website www greenwit com YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS INVOLVING THE USE OF THE MOTORINO TO DETERMINE IF COVERAGE IS PROVIDED YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR AGENT TABLE OF CONTENTS Table of 609 FC NN 2 Features and 5 0206 6 1107500 3 Contents ofthe OD 2 MOTORINO General Usage Restrictions and General Safety Instructions 3 RH 7 away 9 General Usage Ot YC YN HOOD CF Sd iene 11 Drive Chain Mantiene 12 RHYW FFF EFE FEARN 13 2 13 Far Y iv O REAR 13 Brake O THU YN 15 F se FRO ACSI SUE casi 16 Key and Throttle 17 MOTORINO Parts 18 MOTORINO 19 20 7 21 Warranty 210 9 1
12. Respect their rights and be tolerant if they infringe on yours 2 Ride defensively 3 Look ahead of where you re going and be ready to avoid Vehicles slowing or turning in front of you entering the road or your lane ahead of you or coming up behind you Parked car doors opening in front of you Pedestrians stepping out in front of you Children or dogs playing near the road Pot holes sewer grating railroad tracks expansion joints road or sidewalk construction debris and other obstructions that could cause you to swerve into traffic catch your wheel or otherwise cause you to lose control and have an accident The many other hazards and distractions which can occur while using the MOTORINO during a ride 4 Ride on the right side of the road in the same direction as vehicle traffic and as close to the edge of the road as possible 5 Stop at stop signs and traffic lights slow down and look both ways at street intersections Remember that the MOTORINO will always lose in a collision with a motor vehicle so be prepared to yield even if you have the right of way 6 Use hand signals for turning and stopping Learn the local vehicle code for the correct signal Q0 GENERAL SAFETY GUIDELINES amp RESTRICTIONS 8 Don t weave through traffic or make any moves that may surprise people with whom you are sharing the road 9 Never carry anything which obstructs your vision or your complete control of th
13. Tail Light RED cea 4817 18 Carpeted Foot Mat uu duu Su a ud GAD Ca Uu SAU UAN Y CU n 4818 19 Clelia 4819 20 Control ModUle cl uu CY aaa 4820 21 Fork Bearing Race Front Set of 2 4821 22 Fork Bearings 4822 23 Fuse 20 Amp 6 per Package pe 4823 24 Handie Grp celiaca 4824 25 Hardware Assorted Screws Nuts amp Bolts ee 4825 26 Head 4826 27 Head Light Assembly Upper Steering 4827 28 Horn amp Light Switch Assembly 4828 29 Horn oe uu bl dad 4829 30 Ignition Cylinder W Key ps 4830 31 Instruction IAG 4831 32 Key Ignition OND sanada a ED 4832 33 Key Luggage Rack 28 4833 34 NIRIO a TD HN HY YN RT ua 4834 35 Rini 4835 36 Kickstand 4836 97 Rella ON RF FT FFF 4837 38 Right in 4838 39 Pedal Crank Arm Left 4839 40 Pedal Crank Arm Right LL LL 4840 41 Rearview Mirrors SOLD SEPARATELY 4841 42 Reflector Red Rear 4842 43 Reflectors Amber Front Left amp Front 4843 dd ROD uccise 4844 45 Pda 4845 46 Shocks Rear Left amp Rear Right Set of 2 4846 47 Side Skirt Left Red ee 4847 47 Side Skirt Left Dark BR 4847 47 Side Skirt Left SilVer 4847 47 Sid
14. ask traffic sounds and emergency vehicle sirens distract you from concentrating on what s going on around you and their wires can tangle in the moving parts of the MOTORINO causing you to lose control 13 to carry more than 10 Ibs of cargo in the cargo compartment in addition to the rider 14 in excess of 20 mph with or without the motor activated 15 by barefoot riders or those wearing sandals open toed high heeled platform or slip on footwear 16 on steep inclines or on uneven terrain 17 by any person who has ingested any alcohol or drug that could impair their ability to operate the MOTORINO 18 without 2 hands on the handle bar 19 while not seated on the seat 20 to jump ramps curbs or objects or attempt any stunts 21 with excessive speed for the terrain circumstances or maneuver with clothing or extremities in close proximity to the drive chain or any moving parts 22 beyond your ability or prior experience 23 by stopping with only the front brake Use both brakes simultaneously 24 Do not try to accelerate and have the brake s on at the same time This may cause damage to the motor or drive train or cause the motor or drive train to overheat TA WRRN NG BEFORE EACH RIDE CAUTION 1 Make sure you properly wear a helmet 2 Wear protective clothing and gloves 3 Wear eye protection that does not interfere with your peripheral vision 4 Check local and state laws before operating the MOTORINO in an
15. e MOTORINO or which could become entangled in the moving parts of the MOTORINO 10 Never hitch a ride by holding on to another vehicle TM NEITHER GREENWIT Ltd NOR THE RETAIL SELLER OF THE MOTORINO IS RESPONSIBLE FOR THE CONSEOUENCES OF FAILURE TO COMPLY WITH FEDERAL AND PROVINCIAL ORDINANCES RELATING TO THE USE OF THE TM MOTORINO This product contains lead and lead compounds chemicals known to cause cancer and reproductive harm Wash hands after handling HELMET USE WHILE RIDING THE CMVSRA requires that you use a helmet like those used by human powered bike riders while riding the MOTORINO MOTORINO should not be used under any circumstances without properly wearing a helmet TM IN ADDITION TO THE REQUIREMENTS ABOVE THE MOTORINO IS NOT TO BE RIDDEN USED 1 on any roadways where the speed limit is in excess 2 on any sidewalks or pedestrian walkways 3 on any bumpy rough or unpaved surfaces 4 in darkness 5 on sandy wet or gravel covered surfaces 6 by any person weighing more than 225 5 7 by any person shorter than 60 8 by any person with an inseam of less than 22 22 inch GENERAL SAFETY GUIDELINES amp RESTRICTIONS 9 by more than one rider at a time no passengers 10 by any physically or mentally challenged person 11 by any person with vision balance hearing or coordination impairments 12 by any person using headphones or a cellular phone They m
16. e Skirt Left White Aa 4847 47 Side Skirt Left Blue ee 4847 48 Side Skirt Right RE AA 4848 48 Side Skirt Right Dark BANG 4848 Side Skirt Right Silver crei 4848 48 Side Skirt Right 8 4848 48 Side Skirt Right Blue uu ue ee eddwl eI EA OUD AGO GRO DON Cd 4848 49 Sprocket Shaft Assembly risul 4849 50 Tail Light Assembly 12 Volt LLALL LLALL LILI LLI 4850 51 Throttle with Cable Grip 4556 4851 52 Tire Tube Front Bean da lai i 4852 53 Tires Front RH RR Y 4853 A Rice 4854 55 RR E ieeae a Sal 4855 56 Wheel Bearings FOR saias ia sad PO 4856 57 Wheel w Motor Assembly Rear eeuu LLALL LL LLI siereerenionionionee 4857 58 Wiring Harness 12 4858 64 WARRANTY INFO o Warranty Greenwit Ltd warrants to the original retail purchaser you that the Greenwit Motorino scooters for which this warranty has been issued is free from defects in material and workmanship as follows Frame 2 years warranty Electric Motor one year warranty Controller and electrict circuits 6 monts warranty Battery 3 monts warranty This warranty is not transferable to a subsequent purchaser Greenwit s sole obligation under this warranty is t
17. he brakes and chain be checked every 30 days and adjusted if necessary TM The MOTORINO is intended to be used without the installation of the pedals Pedaling the MOTORINO upon starting will save battery life and will make it easier to balance The MOTORINO also be pedaled in situation where the battery power is too low due to a failure to charge the MOTORINO or exceeding its distance range The rider can also rest his or her feet on the pedals while riding the MOTORINO under electrical power It is a good idea to keep a tool kit with you when you ride You should also carry 2 spare inner tubes that fit the wheel and tire size as well as a manual air pump with gauge to re inflate the tire if you have a flat or it becomes low during use If your MOTORINO sustains an impact AWARNING CRASH OR OTHER IMPACT CAN PUT EXTRAORDINARY STRESS ON COMPONENTS CAUSING THEM TO FATIGUE PREMATURELY COMPONENTS SUFFERING FROM STRESS FATIGUE CAN FAIL SUDDENLY AND CATASTROPHICALLY CAUSING LOSS OF CONTROL SERIOUS INJURY OR DEATH First check yourself for injuries and take care of them as best you can Seek medical help if necessary Next if your MOTORINO is damaged perform the checks described in this manual If you are unable to fix any or all damage problems or if you find any bent scored or discolored parts please call Greenwit Service at 1 888 331 0555 M F 11am 9pm PST DANWARNING r YOU HAVE ANY DOUBT ABOUT THE CON
18. hose set forth herein or by law If any portion of this warranty is held to be invalid unenforceable for any reason such finding will not invalidate any other provision For products purchased in countries other than Canada please contact Greenwit s authorized distributor in that respective country 6 gt 5 5 WARRANTY INFO Warranty Service Options To obtain service under this warranty you must Call our Toll Free Number at 1 888 331 0555 M F 11am 6pm PST for Customer Service Technical Support on your Greenwit Product BEFORE returning your Greenwit Product back to the place of purchase If you return your Greenwit Product for warranty service you must obtain a return authorization number b calling Greenwit at 604 782 8567 M F 10am 6pm PST Send your Greenwit product wit the return authorization number on the outside of the shipping container and affixed to the product with the retail seller s original receipt or other satisfactory proof the date of purchase to Greenwit Trading Ltd E Ride 1703 W 4th Ave Vancouver BC V6B 8P5 www e ride ca CustomerService greenwit com THE GREENWIT PRODUCT MUST BE RETURNED IN ITS ORIGINAL BOX ALONG WITH ALL KEYS CHARGER MIRRORS amp LOCKS FLOOR MATS AND ANY OTHER ACCESSORIES THAT CAME WITH YOUR UNIT DUE TO TRANSPORTATION AND RECLAMATION ISSUES IF THE GREENWIT PRODUCT IS NOT IN THE ORIGINAL PACKAGE IT MAY NOT BE RETURNED UNDER ANY CIRCUMSTANCES Any p
19. le grip It is on the right side of the handlebar Rotate the throttle grip toward the seat to accelerate and rotate forward away from the seat to slow down Front Brake Rear Brake a Throttle Signals _ 4 Throttle Off Position Lights On off PARTS MOTORINO PARTS ST430 ST480 XT480 MOTORINO PARTS ST430 ST480 XT480 PARTS DIAGRAM MOTORINO PARTS ST430 ST480 XT480 41 9 28 10 i 24 7 5 43 4 a 3 55 a 4 57 PARTS LIST No Description Part No 1 4801 2 AS Volt Lead Acid Battery PacCk 4802 3 48Volt Lead Acid Battery 5 4803 4 Front Hu GU iW RR Y sien aes ios NR 4804 5 Axle Inner Axle Spacer ii i HN nica cicloni AB AUAN CA8 4805 6 Battery Charging Port Female Connector 4806 7 Brake Assembly Front pe 4807 8 Brake sr 4808 9 Brake Cable w Lever Front pe 4809 10 Brake Cable w Lever Rear 4810 11 Brake Pads Front 7 4811 12 Bulbs Headlight amp Instrument Cluster CLEAR Set Of 2 4812 13 Bulbs Headlight LARGE CLEAR Set of 2 4813 14 Bulbs Steering Headlight amp Instrument Cluster AMBER Set of 2 4814 15 Bulbs Steering Headlight CLEAR Set Of 2 4815 16 Bulbs Tail Light CLEAR 12 4816 17 Bulbs
20. ment This compartment can be used for storage if no spare battery is being used To access this spare battery locate the seat lock on the left side of the Raise the seat to expose the spare battery Remove the power cable from the socket on the battery Using the handle lift the battery out of the battery compartment It weighs approximately twenty eight 28 pounds so be careful not to drop it use caution The fuse holder is located next to the power socket on battery Replace this fuse with the same type and amperage SING THE WRONG FUSE WILL RESULT IN DAMAGE TO THE MOTORINO MAKE SURE THE REPLACEMENT FUSE IS A STANDARD 20 AMP FUSE THAT PROPERLY FITS INTO THE FUSE HOLDER IF YOU USE THE WRONG SIZE OR AMPERAGE FUSE IT COULD RESULT IN A FIRE OR DAMAGE TO THE 9 OPERATING INSTRUCTIONS KEY AND THROTTLE OPERATION ON OFF Switch ignition 1 OFF Position MOTORINO is OFF 2 center ON Position MOTORINO is ON utilizes the primary battery 3 ON Position MOTORINO is ON utilizes power from the optional spare battery under the seat BEFORE OPERATING YOUR MOTORINO MAKE SURE THAT THE THROTTLE GRIP IS NOT ROTATED TO THE ON POSITION MAKE ALSO SURE THAT YOUR THROTTLE IS NOT STICKY AND ROTATES FREELY BACK TO THE INITIAL POSSITION SEE PICTURE FOR CORRECT PLACEMENT OF LEVER BEFORE USAGE THROTTLE CONTROL The MOTORINO uses a speed changing thrott
21. ns following it may result in damage to the MOTORINO or component during installation or use l e risk of property product damage only Thank you for purchasing the low speed electrically powered MOTORINO The MOTORINO complies with the Canadian Motor Vehicle Safety Regulation Act CMVSRA It is classified as Power Assisted Bicycle in section 1 2 1 in the above mentioned act GENERAL SAFETY GUIDELINES amp RESTRICTIONS Your province motor vehicle branch or the city or county where it will be used may regulate the TM use of devices like the MOTORINO Some provinces may require a driver s license or TM i minimum age to use the MOTORINO In some provinces it may be referred to as an power assisted bicycle or restricted use motorcycle Please check with your local motor vehicle branch or insurance company on requirements for using the MOTORINO If your province or municipality allows the MOTORINO to be used on vehicle roadways please make sure you are familiar with all traffic laws such as yielding to pedestrians and other motorists signaling riding as far to the right edge of the roadway as possible obeying traffic signs etc Your province MVB can provide you with materials related to these traffic laws In addition to those traffic laws abide by the following general principals 1 You are sharing the road or the path with others motorists pedestrians and other cyclists
22. o repair or replace the product at Greenwit s option Greenwit must be notified in writing of any claim under this warranty within 15 days of any claimed lack of conformity of the product Warranty Limitations The duration of any implied warranty or condition of merchantability for a particular purpose or otherwise on this product shall be limited to the duration of the express warranty set forth above In no event shall Greenwit be liable for any loss inconvenience or damage whether direct incidental consequential or otherwise resulting from breach of any express or implied warranty or condition of merchantability for a particular purpose or otherwise with respect to this product except as set forth herein Some provinces or countries do not allow limitation on how long an implied warranty lasts and some do not allow exclusions or limitations of incidental or consequential damages so the above limitations or exclusions may not apply to you This warranty gives you specific legal rights and you may also have other rights which may vary from location to location This warranty will be interpreted pursuant to the laws of Canada The original English language version meaning of this warranty controls over all translations and Greenwit is not responsible for any errors in translation of this warranty or any product instructions This warranty is not intended to confer any additional legal jurisdictional or warranty rights to other that t
23. ostage insurance or other shipping costs incurred in sending your Greenwit product for service under either option above is your responsibility Greenwit Ltd will not be responsible for products lost or damaged in shipping For products purchased in countries other than Canada please contact Greenwit s authorized distributor or E Ride shop in the country where the product was purchased They can be found on our website at www greenwit com Warranty Exclusions are listed below Retailers and sellers of Greenwit products are not authorized to modify this warranty in any way It is your responsibility to regularly examine the product to determine the need for normal service or replacement This warranty does not cover the following Products that have been modified neglected or poorly maintained used for commercial purposes misused or abused or involved in accidents Damage occurring during shipment of the products such claims must be presented directly to the shipper Damage to products resulting from improper assembly or repair the use or installation of parts or accessories not compatible with the original intended use of the product or the failure to follow the product warnings and usage instructions Damage or deterioration to the surface finish aesthetics or appearance of the product The labor required to remove and or re fit and re adjust the item covered by this warranty Normal wear to the product Light bulbs and tubes o prod
24. s no need to remove it from the MOTORINO unless you are replacing it Use caution on removal To replace the main battery pack lift the foot mat and unlock the lock located on the left side of the MOTORINO using the ignition key Proceed to pull the battery out utilizing the handle Disconnect the battery cable The MOTORINO is equipped with a 48V battery charger that will interrupt the charging process once the battery has received a sufficient charge Greeenwit Ltd strongly suggests that the charger not be used in excess of 18 hours to prevent any unnecessary wear on the battery or charger itself Charging for periods greater than 18 hours may reduce the overall life expectancy and efficiency of these items BATTERY DO NOT DROP THE MOTORINO BATTERY CHARGING THE MOTORINO BATTERY CAUTION TO AVOID DAMAGE TO THE BATTERY WHEN CHARGING USE ONLY THE CHARGER PROVIDED WITH YOUR 1 WARNING DO NOT CHARGE STORE THE MOTORINO CLOSER THAN 20 FEET FROM ANY FLAME E G FURNACE FIREPLACE WATER HEATER SPACE HEATER 2 Be sure to only use 110V AC with the MOTORINO charger Also make sure the plug is inserted into a three prong grounded AC outlet 3 PLUG the POWER INPUT CORD into the MOTORINO charging receptacle located below the front of the seat See picture above 4 Plug the MOTORINO 48V battery charger into a 110V AC power source 5 The CHARGER INDICATOR LIGHT will illuminate confirming that
25. s not left fully discharged or close to fully discharged 3 Make sure the throttle is rotated to the off position 4 Ensure that the kickstand i is used so the MOTORINO Will not fall over and get damaged 5 Ensure the MOTORINO is not kept outdoors or where moisture can damage it 6 Do not charge or store the MOTORINO closer than 20 feet from any flame e g furnace fireplace water heater space heater 7 Do not allow children under 16 to play on or near the unattended MOTORINO VAWARNING FAILURE TO FOLLOW THESE OPERATION INSTRUCTIONS CAN RESULT IN SERIOUS INJURY OR DEATH OR COULD RESULT IN AN ELECTRICAL SHORT AND OR FIRE AWARNING DO NOT MAKE ANY ALTERATIONS OR MODIFICATIONS TO THE OR ADD ANY PARTS NOT AUTHORIZED BY GREENWIT Ltd EXCEPT THOSE DISCUSSED IN THIS MANUAL OR THOSE REOUIRED BY LAW DO NOT REMOVE ANY REFLECTORS LIGHTS OR OTHER STANDARD EOUIPMENT All authorized replacement parts are listed on the parts list enclosed or available at www greenwit com or www e ride ca or by calling Greenwit customer service at 1 888 331 0555 Thu Sun 11am 6pm PST _ _ _ _ _ _ _ _ _ ASSEMBLY INSTRUCTIONS After unpacking your MOTORINO there is minimal assembly to be completed Assembly consists of attaching the pedals to the MOTORINO and attaching the rearview mirrors PEDALS Pedal Crank Arm Pedal 0 Locate Pedals Set of 2 The pedals are labeled left and right near the
26. stments or repairs Call the Greenwit Customer Service Technical Support Toll Free Number at 1 888 331 0555 Thu Sun 11am 6pm PST for additional information about brake repairs or adjustments MAINTENANCE MAIN BATTERY FUSE REPLACEMENT The MOTORINO has one 20 Amp fuse located on the main battery pack Replacement fuses are supplied in the user s manual bag replace the fuse from the main battery pack lift the foot mat Unlock the lock located on the left side of the MOTORINO using the longer in length ignition key Proceed to pull the battery out utilizing the handle Disconnect the battery cable Once the battery has been pulled out of the compartment locate the fuse holder located next to the plug on the bottom of battery Replace this fuse with same type and amperage Using the wrong fuse will result in damage to the MOTORINO Replacement fuses are supplied in the user s manual bag Contact Greenwit Customer Service Technical Support Toll Free at 1 888 331 0555 Thu Sun 6pm PST to purchase additional spare fuses OPTIONAL SPARE BATTERY FUSE REPLACEMENT The spare battery pack is optional and is not shipped with the MOTORINO One can be purchased from Greenwit Customer Service Technical Support Toll Free at 1 888 331 0555 Thu Sun 11am 6pm PST The spare battery is used to extend the riding range of the MOTORINO The spare battery is located in the under seat storage compart
27. tion amount is listed on the sidewall of the tire If the tires have less than the recommended amount of pressure this will decrease the battery usage time and may cause the unit to handle poorly or cause damage to the tires Use an air pressure gauge to check for the air pressure of the tire FAWARNING DO NOT USE GAS STATION AIR FILLING STATIONS AS THE PRESSURE IS USUALLY TOO HIGH AND THE GAUGES ARE INACCURATE OVER INFLATION OF THE TIRE COULD CAUSE A BLOW OUT AND CRASH FRONT WHEEL REMOVAL The MOTORINO front forks utilize a secondary wheel retention device to keep the wheel from disengaging if the axle nut is insufficiently tightened Secondary retention devices are not a substitute for correct axle nut tightening Call Greenwit Customer Service Technical Support Toll Free at 1 888 331 0555 Thu Sun 11am 6pm PST to explain the particular secondary retention device on your MOTORINO or if you do not understand how to properly remove and replace the front wheel properly with the secondary retention device A WARNING Permanent removal or disabling the secondary retention device is extremely dangerous and may lead to serious injury or death It also will void the warranty MAINTENANCE FLAT TIRE REPAIR continued 1 Depress the tire valve to let all the air out of the tube which will assist in removing the wheel from the 2 Remove the wheel from the MOTORINO using a wrench Loosen the nuts counterclockwise
28. ucts for which the consumer does not follow the warranty procedures outlined above For the current version of this warranty please visit our website at www greenwit com 22 04 2005 Greenwit Ltd RETURN POLICY 7 DAY RETURN EXCHANGE POLICY THIS WRITTEN POLICY SUPERCEDES ANY OTHER PREVIOUS POLICY WRITTEN OR IMPLIED THIS WARRANTY IS TO BE POSTED AT THE STORE LEVEL IN PLAIN SIGHT OF THE CONSUMER ALL GREENWIT PRODUCTS PURCHASED AT RETAIL STORES IN CANADA ARE COVERED UNDER THIS 7 DAY RETURN POLICY ALL GREENWIT PRODUCTS ARE EXCHANGEABLE OR RETURNABLE FOR ANY REASON TO THE RETAIL POINT OF PURCHASE IF ACCOMPANIED BY A STORE RECEIPT FOR A PERIOD OF SEVEN 7 DAYS FROM THE DATE OF PURCHASE TO BE ELIGIBLE FOR RETURN OR EXCHANGE ALLGREENWIT PRODUCTS MUST BE IN LIKE NEW CONDITION IN THE ORIGINAL BOX ALONG WITH ALL ACCESSORIES THAT INCLUDE BUT IS NOT LIMITED TO KEYS MIRRORS TOOL KITS LOCKS MANUALS FUSES CHARGERS ETC ALL PRODUCTS MUST HAVE THE KEYS REMOVED FROM THE KEY SLOT AND ATTACHED WITH A ZIP TIE TO THE HANDLE BARS THE FUSE REMOVED AND THE BATTERY DISCONNECTED EITHER BY THE QUICK DISCONNECT OR BY REMOVING THE BATTERY LEADS AND COVERING THE TERMINALS WITH TAPE IN COMPLIANCE WITH FEDERAL REGULATIONS DURING THE SEVEN 7 DAY RETURN EXCHANGE PERIOD ALL GREENWIT PRODUCTS ARE ALSO COVERED BY THE SPECIFIED WARRANTY TERMS ON PAGE 23 ON PARTS THE WARRANTY DOES NOT COVER THE COST OF LABOR ON ANY PRODUCT FOR ANY REASO
29. void full depletion VA WARNING FAILURE TO KEEP THE MOTORINO BATTERY CHARGED WILL CAUSE TOTAL BATTERY FAILURE DO NOT ALLOW BATTERY TO BECOME FULLY DISCHARGED ALWAYS RECHARGE THE BATTERY BEFORE THE POWER INDICATOR ON THE INSTRUMENT PANEL SHOWS NO POWER ALLOWING THE BATTERY TO FULLY DISCHARGE WILL REDUCE BATTERY LIFE AND MAY RUIN THE BATTERY OR COULD CAUSE THE BATTERY OR CHARGER TO OVERHEAT AND CAUSE A FIRE THE NEXT TIME THE MOTORINO IS CHARGED BATTERY POSTS TERMINALS POWER CORDS AND BRAKE CABLES MAY CONTAIN LEAD AND LEAD COMPOUNDS CHEMICALS KNOWN TO CAUSE CANCER AND REPRODUCTIVE HARM WASH HANDS AFTER HANDLING 2 BATTERY GN MW 3 BATTERY RECYCLING 3 When maintained and used properly by following charging and storage guidelines the Lead Acid Battery Pack used in this product has a normal lifespan of many miles When the battery pack no longer holds a charge or is unable to be charged properly it should be removed from the MOTORINO delivered to a recycling facility Fedral Laws prohibit disposal of lead acid batteries in everyday trash Please contact your local solid waste or recycling authority for recycling information in your area GENERAL USAGE NOTES Break in Period Your MOTORINO will last longer and work better when it is broken in properly Brake control cables and chains may stretch or seat when a new 15 first used and may require an adjustment We suggest that t
30. y area 5 Make sure all tail brake lights turn signals and headlight are operational 6 Make sure the horn is operational 7 Make sure the brakes are properly adjusted and working correctly see page 15 8 Make sure you understand how the brakes work right lever for rear brake and that your hands can reach and sgueeze the levers comfortably and hard enough to stop the MOTORINO safely 9 Make sure the chain is properly adjusted see page 12 OG GENERAL SAFETY GUIDELINES amp RESTRICTIONS 10 Make sure all parts of the MOTORIN o are properly and securely fastened and adjusted including but not limited to pedals crank arms wheels all controls and cargo Please refer to Assembly Instructions 11 Make sure the tires are not excessively worn do not have tears or cuts and are properly seated on the rim and inflated to the proper pressure on the sidewall DO NOT USE GAS STATION PUMPS FOR INFLATION 12 Make sure the wheels spin straight and that the rims are not bent or damaged front wheel must be undamaged for front brake to work properly 13 Make sure the throttle is in the OFF position before turning MOTORI NO key on This will prevent the MOTORI NO from moving forward without notice once the ignition key is turned DANNARNING AFTER EACH RIDE 1 Make sure that the ignition key is turned OFF and that all keys are removed and kept in a safe place 2 Make sure that the battery i
Download Pdf Manuals
Related Search