Home

TEKNOWASH SHAMPOO SYSTEM USER MANUAL

1. The product shall also bear the certification mark CHARACTERISTICS Fittings may include lavatory sink bath amp shower lawn and sediment faucets To be installed in accordance with the manufacturer s instructions and the recuirementa of the latest edition af the Uniform Plumbing Code Producta comply with the applicable sections of the latest edition of the Uniform Plumbing Code Models liated to the National Plumbing Code of Canada and Relevant Canadian Standard e shall bear the cUPC mark of conformity Manufactured in compliance with ASME A112 18 1 2005 0754A B125 1 05 This kung fo the persad indicated heroin nnd in void oher tho date shown above Ang change in material mmulszturing process mering ce designa withsut having Erat obbaingd Pw of the Prodect Leilicalise Commies of am avedunca of nor compliscg with cades and standards ar of interes workmanship mary ba daamard sutticio mi cause far reveceten af this listing Aoprodecbon of ar rafaranca to thes form dor Beer sing per peces impp be men only Dy spicibe ganmasion of Fceearzh and Inc Aeg aa nation of fis catina be greun s far parecer ation of tha DOR COS LA GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual Washbasin Vitreous China Composition Manufacturer s Declaration of Conformity olimpiadue PORCE
2. Adjustability Adjustable with built in trim pot 25 Temp Coalficient Bi 0 05 40 05 9 Protection Circuit Parameter Conditlons Description Overload Current limiting starts at 105 of the rated output current and recovers automatically _ Output Over voltage Output voltage is limited to 115 by TVS clamping _ Short Circuit _ Protected Long term short circuit may reduce reliability General and Safet Parameter Conditlons Description Min Max Units Operating temp See derating curves n 0 50 dt Storage temp MEM 20 85 dt Operaling humid Non condensing 20 80 RH Storage humid Mon condensing 20 95 RH Operating altitude a 3 000 m 10 000 tt Storage altitude m 30 000 ft EMi Conducted emissions comply with FCC class B 55022 class BAA Safety Approved to TUV EN60950 CE CB UL cUL 60850 1 RoHS 2002 95 EC papa Leakage Current Per 60950 264 VAC 1 5 m Isolation Voltage UG Applied for 1 minuta int ma HI POT Primary to secondary 3000 VAC Primary to transformer core 1500 VAC Primary to earth ground 1500 Insulation Resistance Measured at 500 VDC at room temp 50 _ 25 MIL HDBK 217F BOK hours Warranty Standard Warranty Length 2 a V INFINITY LLC 9615 SW Allan Blvd Suite 103 Beaverton OR 97005 1 BBB 3 2 1258 www v inliniby com HI FI Audio Amplifier am
3. F TRANSFORMER FOR ALIMENTAZIONE MASSAGGIO MASSAGE POWER SUPPLY DA 240Vac 50 60Hz A 220Vac per U K FROM 240Vac 50 60Hz TO 220Vac for U K FROM 110Vac 50 60Hz TO 220 for U S A DA 110Vac 50 60Hz A 220Vac per U S A CONNETTORE A8 PIN RJ45 8 PINS PLUG H SCATOLA DI DERIVAZIONE SHUNT BOX connettore connector porta Li gt plug RJ45 pin GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual 5 2 SOUND SYSTEM SCHEMA TECNICO ALIMENTATORE AMPLIFICATORE alimentazione in ingresso 85 264Vac frequenza in ingresso 47 63HZ assorbimento massimo 80W MAX potenza audio in uscita 10W RMS dinamica 102 dB DIFFUSORI 8 cm impermeabili con protezione e fissaggio ad incasso impedenza 8 Ohm C INTERRUTTORE A CONTATTO SINGOLO C D CONNETTORE STEREO 3 2 mm E lettore Mp3 l POD SHUFFLE F SCATOLA DI DERIVAZIONE TECHNICAL SCHEME AMPLIFIER POWER SUPPLY input voltage 85 264Vac input frequency 47 63Hz output power 80W MAX output audio power 10W RMS dynamic 102 dB SPEAKERS 4 waterproof anti magnetic marine speakers with cover grill amp built in housing impedence 8 Ohm SINGLE POLE SWITCH STEREO PLUG 3 2 mm Mp3 player l POD SHUFFLE SHUNT BOX IMPIANTO MOVIMENTAZIONE E MASSAGGIO L IMPIANTO CROMOTERAPIA GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE
4. Manolo Karea De a A Electronics Shanghai Co Lid eet Pr fbaricht Nr Teel Report No 70 401 00 564 07 Projektleiter Project manager LA GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual Aufbau bersicht f r Elektroger te und Maschinen E Data form for electrical equipment and machinery j Au traggeber Applicant Fertigungestatte Production fadiliy GorSteart Type cf equipment PRODUCT SERVICE Seite von Page 1 of 3 Shanghal Jiugong Industry No 68 Lane 3100 Guda Rd 201120 Shenghai P China Same ss above Mastaga mattress Typenbezelehnung Type mocel JGM1006 JGM2000 JGM2000 Serlennr Serlzi no na Nennapannung Fracuanz Rele voltace irequancy AC 230V 5042 Nannaufnahma Nennstrom Rated Input power current AN anechiubdatentHydrauiik Connection to hycraulio power na Anschludaten Pneumstlk Cornecton to pneumatic power na Anschlu amp daten Wassor Connection to waler installadoni na Gewicht weigh 58kg 65kg 9 0kg Liirmemission emmission dB A na Ausf hrung Construction Ortsfest Stationary Ortsver nderich Portabla Handger Hand held Finbaugerat Openframea Schutzklasse Protection class Sehu zkesse Schutzlotteranschlufi PE connection Schutzklasse Schutzissilert Double insulation Schutzklasselll Schutzigaina pannung SELV internally ne Stenfversomung powersd Sehutzart De
5. 68 Lane 3100 Gudai Road Shanghai 201100 China has established and applies a quality management system for medical devices for the fallowing scope Manufacturing and Sales of Massagers Proof has been furnished that the requirements specified in EN ISO 13485 2003 are fulfilled The quality management system is subject to Certificate Registration No SX 60014045 0001 An audit was performed Report No 15015061 001 This Certificate is valid until 2011 03 08 Certification Body gt aL TS x picis Akkreditiert dureh CNN der Lander faro VA LE for G sundheksscnutz AS HOT 7 xx 71020 09800 01 46 lan FA r T Cologne 2008 03 09 Dipl Ing D Meier der T V Rheinland Product Safety GmbH Am Grauen Stein D 51105 K in Tel edna 06 1171 SRE II rw dun woww Du cami ta ety GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual t _ Aa a T V Rheinland eV Product Safety GmbH Am Grauen Stein D 51105 K ln CERTIFICATE for a Ouality Management System according to EN ISO 9001 2000 T V Rheinland Product Safety GmbH hereby certifies thai D Organization EUM Co Gudai Road Wed me 201100 gt has established and maintains a quality management system Conformance with the requirements of the standards has been audited The organizatio
6. 73 23 CEE del 19 febbraio 1973 93 68 CEE del 22 luglio 1993 Low Voltage Directive 73 23 EEC February the 19 1973 93 38 EEC July the 22th 1993 Norme applicate EN 60335 1 1982 Applicable norms EN 60335 2 60 1994 Direttiva di compatibilit elettromagnetica EMC 89 336 del 3 maggio 1989 Electromagnetic Compatibility directive EMC 89 336 EEC May the 3 1989 Norme applicate EN 55014 1 1993 EN 55014 2 1993 Applicable norms EN 61000 3 2 1995 EN 61000 3 3 1995 Il sottoscritto dichiara che il materiale di cui sopra interamente conforme alle direttive CEE 73 23 93 68 89 336 The undersigned hereby declares that the above mentioned goods are entirely in conformity to the ECC rule 73 23 93 68 89 336 S Lucia di Piave 27 10 2008 WA la Sa Il Date F2 Firma Signature d Miotto Ladis Cognome nome Sumame name lanaging i iI PE ne Position Funzio MATREX S R L Via Mareno 79 31025 S LUCIA di P TV ITALY TEL 390438460544 FAX 390438468252 HI FI Audio Amplifier amp Power Supply RoHS Declaration of Conformity TEKNOWASH User Manual NAINEA www idrocontrol com DICHIARAZIONE DI CONFORMITA ROHS direttiva 2002 95 CE e successive Il fabbricante MATREX S r l Via Mareno 79 31025 S Lucia di Piave TV Italy Prodotto Amplificatore audio Audio amplifier Modello 01502313 Il sottoscritto dichiara che il materiale di cui sopra
7. At the first connection of electricity it is necessary to wait 7 minutes before activating any command while the microprocessor resets This procedure takes place after every electrical breakdown The massage cycle program is pre setted to last 15 minutes At the end of the cycle the air massage switch off automatically Push the red button of the remote control to restart the massage Pic H Seat motion amp massage control list Button A switch on and off the massage Button B the air flow inflates the air chambers in order Button C the air flow inflates the air chambers with a random sequence Button D Increases the intensity of the massage by decreasing the flow speed Button E Decrease the intensity of the massage Button F Lift up the the seat amp the leg rest in relax position Button G Bring down the seat amp the leg rest Power on lights indicate the increase and decrease of the massage intensity Picture H WARNING when turning off the massage function wait a few seconds before bringing the chair into the sitting position to allow the mattress to totally deflate GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 15 TEKNOWASH User Manual 4 4 Mp3 MUSIC PLAYER FOR TEKNOWASH SOUND PLUS The sound system master switch is on the rear of the bodywork on the right side Pic 1 interruttore generale cromoterapia chromotherapy system master switch interruttore
8. STIVIERE MN 19 5 3 CHROMOTHERAPY SYSTEM SCHEMA TECNICO A ALIMENTATORE CONTROLLER Alimentazione 230 110 V Frequenza 50 60 Hz assorbimento 40W SORGENTI LUMINOSE CROMOTERAPIA Arco inferiore N 12 LED Arco superiore N 12 LED TELECOMANDO SEQUENZE CROMOTERAPIA SENSORE INFRAROSSO DEL TELECOMANDO INTERRUTTORE A CONTATTO SINGOLO CONNETTORE SCATOLA DI DERIVAZIONE TEKNOWASH User Manual TECHNICAL SCHEME POWER SUPPLY CONTROLLER Input voltage 230 110 V Input frequency 50 60 Hz power consumption 40W LIGHTING SOURCE FOR CHROMOTERAPY Lower arch N 12 LED Upper arch N 12 LED REMOTE CONTROL FOR CHROMOTERAPY SEQUENCE SETTING INFRARED SENSOR SINGLE POLE SWITCH CONNECTOR SHUNT BOX IMPIANTO AUDIO E d IMPIANTO MOVIMENTAZIONE E MASSAGGIO GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 20 SUPPORTO DOCCIA FORCELLA ACQUA STOP GAMOY SUPPORT WITH FORK ACQUA STOP Istruzioni di installazione Instruction for installation TEKNOWASH User Manual CHAPTER 6 CLEANING AND MAINTENANCE 6 1 PLANNED MAINTENANCE To guarantee efficiency of the Celebritywash over time and its correct functioning it is necessary to follow the instructions outlined below The cleaning of the ceramic sink plastic base and taps must be performed regularly with water and suitable commercial products containi
9. Steu Safety relevenl components switch MEE pe RATA dii meli molara and olha companants wih windinge eg cole 2hand contoldevices interlock ernergancy of deviess switches CEU IU Duis adig loon prgn vinctronle controllers PLC hydraulic cenirolers priaumatio coniro an m MHerstaller Angaben Ibar Typ Lelstang Profze chen von Kind ef component Manufacturer Transformatora peziffiortionenummet Test mark from lsolatonsidasse VDE ASI UL ete mumbar Insulting dass 15 Massaging motor Bun Micra Motor Technology 144 52808 1233048RSIBNFZTVI 08 DC 12V Ne Test with appliance 48 Intarconnaziion ZHENJIANG HUAVIN INSTRUMENT sur UL E199812 cond for ELECTRICAL EQUIPMENT CO LTD massaging motor 7 Messaging Shengte dlugong Induaty Con Lidi YG 1000 No with appliance mattress 2 50x50 JGN3COX 16006 20x80 18 Nemaplece Massa saga mattress Medel 28M 1000 230V B0Hz 40W Shanghai Jiugong Industry Co Ltd C es 0 Pr foericht Nr Teei Report No 70 0108 58400 Projektiehar menegan A GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual i d ef aos T V e TE E Certificate The Certification Body of T V Rhelnland Product Safety GmbH hereby certifies that the organization Shanghai Jiugong Industry Co Ltd No
10. generale audio sound system master switch The sound system is managed by the supplied I POD SHUFFLE Mp3 player Connect the Mp3 player with the proper stereo plug on the right side of the shampoo unit In order to avoid noises at the loudspeakers we suggest to plug in or disconnect the Mp3 player when it is turned off The sound system allows the use of any other Mp3 player Follow the Mp3 player genuine user s manual by the authorized manufactures and dealers Warning Set the volume to a safe level Permanent hearing loss may occur if the music player is set at too high volume Don t turn up volume suddendly once the client is seated GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 16 TEKNOWASH User Manual 4 5 CHROMOTHERAPY REMOTE CONTROL FOR TEKNOWASH PLUS The chromotherapy system master switch is on the rear of the bodywork on the left side Pic 1 Once the device is lit up the LED lighting system starts to operate at the last setup mode Is it possible to set several operating mode just using the remote control Pic M Picture M Chromotherapy control list Button 4 BLACK color switch on and off the system keep it pressed 1 second or more Button 4 BLACK color press it slightly to select 3 different chromatic cycles 1 Fading cycle of all the spectrum colors 2 Fading cycle of the warm hues 3 Fading cycle of the cold hues Button 4 BLACK color press it slightly to
11. restore the pre sets mode Button 1 RED color press it slightly to keep the light red costantly Button 2 GREEN color press it slightly to keep the light green costantly Button 3 BLUE color press it slightly to keep the light blue costantly Keep the buttons pressed continuously to adjust the color intensity to the maximum level Keep the buttons pressed continuously once again to decrease the color intensity until the related color is completely turned off Mixing the 3 primary colors it is possible to get endless colors shading GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 17 TEKNOWASH User Manual CHAPTER 5 TECHNICAL SCHEME 5 1 ELECTRICAL SYSTEM SEAT MOTION amp MASSAGE SCHEMA ELETTRICO MOVIMENTO DELLA SEDUTA E MASSAGGIO ELECTRICAL SCHEME SEAT LIFTING amp MASSAGE SCHEMA TECNICO TECHNICAL SCHEME SISTEMA PER IL MOVIMENTO MOVEMENT SYSTEM CENTRALINA PER ATTUATORE CONTROL DEVICE FOR ACTUATOR 230V 50Hz 130W 230V 50Hz 130W ciclo di lavoro 2 min 2 min WORK ciclo di pausa 5 min 5 min PAUSE B ATTUATORE B ACTUATOR ciclo di lavoro 2 min 2 min WORK ciclo di pausa 5 min 5 min PAUSE motore 24V 4 2A motor 24V 4 2A SISTEMA RELAX SHIATSU SHIATSU RELAX SYSTEM COMPRESSORE MASSAGGIO MASSAGE COMPRESSOR Compressore ad aria Air compressor 13V 2 5A 13V 2 5A D STUOIA MASSAGGIANTE D MASSAGE MAT E PULSANTIERA 6 TASTI E 6 BUTTONS CONTROL REMOTE TRASFORMATORE PER
12. warranty and those described in the supply contract If the counter parties do not intend to undergo judicial arbitration for the resolution of any controversies resulting from a supply contract or in the case that a decision is requested by an ordinary Court the Court of Mantova is the competent judicial body 1 3 WARRANTY EXCLUSIONS At the moment of delivery it is necessary to verify that the equipment was not damaged during transport and that the provided accessories are integral and complete Possible claims must be presented within 8 days of the delivery date of the TEKNOWASH In addition to the cases described in the supply contract the warranty becomes null and void e When an error in usage can be attributed to an operator e When the instructions described in the instructions booklet are not fully respected e When the TEKNOWASH has undergone modifications following repair interventions executed by third parties without the consent of GAMMA amp BROSS GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 4 TEKNOWASH User Manual 1 4 PRODUCT OVERVIEW TEKNOWASH is manufactured in four models TEKNOWASH BASIC TEKNOWASH 5 TEKNOWASH SOUND TEKNOWASH PLUS TEKNOWASH BASIC this model consists of a painted fibreglass body work a chair in polyurethane foam covered with a vinyl upholstery with a vitreous china sink It is equipped with a system that permits the positioning of the sink at the
13. 10656402 GS Mark valid until 2012 01 31 Data 2007 01 31 Page 1 of 1 ni HERE t SI Li p C di me si E 41 TOV S D Product Service GmbH Zercifizieratalie Ridlerstrassa 65 80339 M nchen Germany GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual Aufbau bersicht f r Elektroger te und Maschinen Data form for electrical equipment and machinery Baka von Page 2 of 3 S cherheltsralovante Bauteile Schalter Tamperaturtegier HelzkBrpet Stecker Fassungen Leitungen ween eae eco tesine it si S et Aus Gaite 2 fandsteen Elcherhelta Llextschi arken Sicherhetsven rammierbare erungen SP hyereutische Steverungen dae da Stauerungen s sedia i Safety mievant exmponanis switch temperature regulaicr heating element plug social wiring malore nar rec irren paran fedora colla emergency off devices cas niprioc mulichea t barriera safety valves programmable elec reni controtiers FLC hydraulic orma controller atai Bautell Rereteller Angaben Uber Tyo Stromstirka Leistung Pritesichenvon Kind of corr conan Trantformatorap Iscladc mr VDE BSI UL etc Informaben about type current power transformer specication number cam _ Power plug Zhenjian
14. 28h Gross weight Chart N 2 Unit TEKNOWASH S di misura Width Net weight Height Lenght kg OT mm 106 mm 131041770 mm 72 Installed electric power O WwW VIE k m m m W Electrical supply tension frequency V Hz 3 bar water capacity Operating pressure Package dimensions Gross weight Unit TEKNOWASH SOUND di misura 00 1400 1310 1770 g m m m a Net weight Height m Lenght m m Electrical supply tension frequency V Hz 3 bar water capacity litri Operating pressure B Package dimensions C Gross weight kg m m idth m Installed electric power W ar m Kg GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 6 TEKNOWASH User Manual Chart N 4 Unit TEKNOWASH PLUS di ini Net weight 90 lent _ mm 1310770 Gross weight CHAPTER 2 SAFETY REGULATIONS AND ACCIDENT PREVENTION 2 1 DANGER LEVELS The operator s safety is the manufacturer s main concern and therefore all possibility dangerous situations and risks connected with use are to be avoided by adopting the opportune precautions to render usage safer It is recommended to carefully read this booklet and this section in particular to avoid inopportune behavior that conflicts with the instructions contained in this booklet DANGER Carefully read the following regulations Those who do not apply the follo
15. 3 CASTIGLIONE DELLE STIVIERE MN 10 TEKNOWASH User Manual Picture C Picture D 4 Lean forward the chair backrest separate the steel frame from the fibreglass body work unscrewing the two pic A rear screws near the sink and the two pic B handles under the seat on the side of the fibreglass bodywork 5 Take out the whole seat from the body work and remove the partition screen that close off the hollow under the sink pic E Picture E Picture F 6 Unscrew the fiberglass body work from the base panel pic F 7 Lay down the shampoo unit in the place set in advance and verify that the hydraulic and electrical attachments are inserted correctly 8 Firmly mount the structure to the floor with the appropriate anchoring blocks or if the floor is not sufficiently compact with a chemical anchoring agent not provided GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 11 TEKNOWASH User Manual WARNING Before attaching the taps it is mandatory to clean out the hydraulic implant to avoid that residual sand and impurities clog the taps and damage the sophisticated ceramic mixers 9 Proceed with the hydraulic connections making sure to verify the easy movement of the sink with its maximum range of tilting and sliding 10 Fix up the electric connection cable in the hollow under the seat inserting it in the upper slot 11 Place again the seat and the partition screen into the body
16. E STIVIERE MN TEKNOWASH User Manual Plumbing Fixture Fittings IAPMO Declaration of Conformity IAPMO RESEARCH AND TESTING INC 5001 East Philadelphia Street Ontario California 91761 2816 909 472 4100 Fax 909 472 4244 www lapmo org IAPMD Research and Tewing Inc i a product carilficaiion body mhich twin and inepecie compiles lahan tram ihe gappllars stock ze trom ihe reris crc a Coeli titi df ih Te siriy Shipa Lo tha nequi e of dpe de ossis and blinders Tha activily di Soup wilh patie uri liana of Lhe supnpllars ticio and wal az the possenti of the supgliars Quality Agmuranzes Syrian This being Is subject da ihe zanditiana mat forth in OPT LA d s Hg notte Die carte di ary MOTTE EST dr OF quara bp APO Tasting Ine sf me produtti accspianca by Aurihortina Hsing Effective Date February 2009 Bev 7 6 2009 Vaid After February 2010 Product Plumbing Fixture Fittings File No 5526 Issued Tor Gamox Rubinetterie Srl Via Dell impresa 21 23 Castigilone Delle Stiviere Mantova 46043 Italy IDENTIFICATION Bach fitting shall bear permanent legible markings to identify the manufacturer This marking shall be the trade name trademark or other mark known to identify the manufacturer The product shall also bear all other markings required by the standard The marking shall be located where it can be readily seen after installation is complete
17. EGUENTI 2004 108 CE E SUCCESSIVE MODIFICHE DISPOSIZIONE DI LEGGE DEL PARLAMENTO EUROPEO PER L ALLINEAMENTO DELLE LEGGI DEGLI STATI MEMBRI PROPOSITO DELLA TOLLERABILIT ELETTROMAGNETICA PER TALE KIT SONO RISPETTATE LE SEGUENTI NORME EN 55014 1 2008 45014 2 19888 Z20D0B ONCE E SUCCESSIVE MODIFICHE DISPOSIZIONE LEGGE DEL PARLAMENTO X EUROPEO PER L ALLINEAMENTO DELLE LEGGI DEGLI STATI MEMBRI A PROPOSITO DELLA BASSA TENSIONE PER TALE KIT STATA RISPETTATA LA NORMA EN 60335 1 2002 CEI EN 60335 2 12 2004 PESARO 03705710 ING ANREA ROSATI QUESTA DICHIARAZIONE CONFERMA LA CORRISPONDENZA DEL MATERIALE ALLE SOPRACITATE NORME MON GARANTISCE LA CORRISPONDENZA DEL MATERIALE ALLE LEGGI DI CONFORMIT DEL VOSTRO PRODOTTO DEL QUALE LA NOSTRA FORNITURA PARTE INTEGRANTE Clar Sp 6170 Poms Italy Via T Loc Bongo S Maria bai 24 0721 20015D 0721 203089 Wob alba weer it oll infediciar ii Cod Fisc a Part NA 008801710419 Cod ibentific 190 IT 00440110419 REA Pesara UvEsmo PS d1070 Cap Bac 1 295 021 Ears Az Cammie LUNI EM HO 3001 2000 Control device for actuator type SU15 M1 UL Declaration of Conformity GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual PGXX2 E194186 Massage and Exercise Machines Component Page l of PGXX2 E194186 Massage and Exercise Machines Component Page Bottom Massage and Ex
18. F MECHANISM To plan amp run a periodic lubrication process of the overall metal frame To use only TEFLON PTFE based lubrication spray To lift up the chair to reach the relax setting with footrest fully stretched out The area showed in the picture is easy to approach even if you don t remove the aluminium front covering 4 To oil the eight 8 pins of the lifting couplings both on the outer and on the inner side see the green arrows in the picture 5 To oil the pivoting hinges of the lifting arms the cross pin and its edge insertions on the frame Due to the spacers you have to oil these parts carefully in order to let the lubricant go deep in this areas see the yellow arrows 6 the ball bearings that are in the slides You can reach the upper ones in head on position under the chair You can reach the lower ball bearings from the inside just knock down the backrest of the chair see the blue arrow eos GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 21 TEKNOWASH User Manual GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 22 TEKNOWASH User Manual 6 3 EXTRAORDINARY MAINTENANCE Extraordinary maintenance operations component repairs cleaning of the internal parts can only be performed by specialized personnel that are authorized by the Manufacturer Interventions on the electrical implant are considered to be extraordinary as
19. L Mark should be considered to be Listed and covered under LIL s Follow Up Service Always look for the Mark on the product UL permits the reproduction of the material contained in the Online Certification Directory subject to the following conditions 1 The Guide Information Designs and or Listings files must be presented in their entirety and in a non misleading manner without any manipulation of the data or drawings 2 The statement Reprinted from the Online Certifications Directory with parmission from Underwriters Laboratories Inc must appear adjacent to the extracted material In addition the reprinted material must include a copyright notice in the following format Copyright 2010 Underwriters Laboratories Inc An indapaendenti organization working lor e alat world with integtity Precision and kawida http database ul com cgi bin XYV template LISEXT IFRAME showpage html amp na 07 05 2010 GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN Massage compressor JGM 1000 2000 3000 CEI EN Declaration of Conformity b AMM REBA TOO VIA CERATEc LI 2 46043 CASTIGLI ONE DELLE STIVIERE MN ITALY PH 39 0376 632630 FAX 39 0376 636683 Cap Soc 750 000 www gammabross com REA 158093 Cod Fisc e Part IVA IT 01431270204 DICHIARAZIONE DI CONFORMITA Produttore Via Ceratelli 2 46043 Castiglione d S MN Prodotto AIR MASSAGE Modello GAMMA Dati Tecnic
20. LLANE OLIMPIA DUE arl PROGETTAZIONE PRODUZ ONE LAVATESTA PER PARRUCCHIERI Sede legalo Via Statale Ma ccchla 52 47827 Villa Varucchio RN Tel 9341 7 842 Fax 0541 6 9814 s mail cl mpiaduedinterfrac lt The undersigned Marco Lazzari as director and owner of the company Porcellane Olimpia Due s r l with head office in Verucchio Fraz Villa Verucchio Via Statale Marecchia n 53 VAT number IT02386900407 DECLARES that the washbasins that we produce are comparable in composition to washbasins for bathrooms and toilette that they are made of vitreous china enamels porcelain that the baking process reaches 1 280 degrees Celsius and that they are no toxic products November 05 2009 Porcellane Oli id Due s r l GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN
21. TEKNOWASH SHAMPOO SYSTEM TEKNOWASH BASIC S SOUND PLUS USER MANUAL Carefully read the instructions outlined in this handbook before operating the shampoo system GANMASTONRE GAMMA amp BROSS Via Ceratelli 2 46043 Castiglione delle Stiviere MANTOVA ITALIA RESERVES THE PROPERTY RIGHTS OF THE FOLLOWING BOOKLET AND PROHIBITS ITS REPRODUCTION OR ITS COMMUNICATION TO THIRD PARTIES BY ANYONE WITHOUT THE AUTHORIZATION OF THE OWNER AND RESERVES THE RIGHT TO PROTECT ITS TO THE FULL EXTENT OF THE LAW TEKNOWASH User Manual INDEX CHAPTER PARAGRAFO CHAPTER 1 OVERVIEW AND MAIN FEATURES 1 1 INTRODUCTION 1 2 WARRANTY 1 3 WARRANTY EXCLUSIONS 1 4 PRODUCT OVERVIEW 1 5 TECHNICAL DATA CHAPTER 2 SAFETY REGULATIONS AND ACCIDENT PREVENTION 2 1 DANGER LEVELS 2 2 SAFETY IN USE 2 3 PRESERVATION OF SAFETY CHAPTER 3 TRANSPORT UNLOADING ASSEMBLY AND SETTING UP 3 1 PACKAGING TRANSPORT AND UNLOADING OF THE EGUIPMENT 3 2 UNPACKING 3 3 INSTALLATION 3 4 CONTROLS BEFORE CONNECTION amp LAYING 3 5 TEKNOWASH BASIC MODEL CONNECTION amp LAYING 3 6 TEKNOWASH S MODEL CONNECTION amp LAYING 3 7 TEKNOWASH SOUND MODEL CONNECTION amp LAYING 3 8 TEKNOWASH PLUS MODEL CONNECTION amp LAYING CHAPTER 4 INSTRUCTION FOR USE 4 1 WARNINGS BEFORE USE 4 2 USING THE WASH FUNCTION 4 3 SEAT MOTION amp MASSAGE REMOTE CONTROL FOR TEKNOWASH 5 SOUND PLUS 4 4 MP3 MUSIC PLAYER FOR TEKNOWASH SOUND PLUS 4 5 CHROMO
22. THERAPY REMOTE CONTROL FOR TEKNOWASH PLUS CHAPTER 5 TECHNICAL SCHEME 5 1 ELECTRICAL SYSTEM SEAT MOTION amp MASSAGE 5 2 SOUND SYSTEM 5 3 CHROMOTHERAPY SYSTEM CHAPTER 6 CLEANING AND MAINTENANCE 6 1 PLANNED MAINTENANCE 6 2 INSTRUCTIONS FOR RECURRING LUBRICATION OF MECHANISM 6 3 EXTRAORDINAY MAINTENANCE 6 4 TECHNICAL ASSISTANCE CHAPTER 7 HINTS FOR WASTE DISPOSAL DECLARATION OF CONFORMITY GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN Pag 03 03 04 04 05 06 07 07 07 08 08 08 08 08 09 09 10 13 13 14 14 14 15 16 17 18 18 19 20 21 21 21 23 23 24 TEKNOWASH User Manual CHAPTER 1 OVERVIEW AND MAIN FEATURES 1 1 INTRODUCTION This handbook contains the instructions for the installation knowledge correct use and planned maintenance of the TEKNOWASH SHAMPOO SYSTEM manufactured by GAMMA amp BROSS SpA in Castiglione delle Stiviere Mantova Italy The end user can find in this handbook all the information concerning the safe use and good maintenance of the TEKNOWASH This handbook is an integral part of the product and must be carefully safeguarded to ensure the possibility to consult it over the life span of the equipment Extra copies of this instructions handbook are available on request from GAMMA amp BROSS Via Ceratelli 2 46043 Castiglione delle Stiviere MANTOVA ITALIA The safety of the operator regular functioning ru
23. Teknowash is manufactured on a robust zinc coated tropicalized steel frame which provides the structure with the strength to carry the total weight necessary In addition this model is equipped with mechanical devices that are able to raise the seat and leg rest recline the backrest and place the client in an excellent position for relaxation A massaging air mat is placed inside the chair which provides a delicate pneumatic massage for the entire length of the legs and back By means of the AIR SHIATSU system it is possible to choose the sequential massage mode or the random one Moreover it is possible to adjust the massage intensity level The shampoo unit is equipped with a stereo sound system with built in amplifier and loudspeakers Gamma amp Bross S p A provides the sound system with an IPOD SHUFFLE 9 device but is it possible to use any other MP3 player A clear plastic canopy gently closes the user off the outer environment helping relaxation and music enjoyment TEKNOWASH PLUS this model consists of a painted fibreglass body work a chair in polyurethane foam covered with a vinyl upholstery with a vitreous china sink It is equipped with a system that permits the positioning of the sink at the nape of the client s neck through a tilting movement and an adjustable forward and backward sliding movement The Teknowash is manufactured on a robust zinc coated tropicalized steel frame which provides the structure with the stre
24. a Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 24 DECLARATION OF CONFORMITY GSANMNASTONRE MANUFACTURER GAMMA amp BROSS spa Via Ceratelli 2 46043 Castiglione delle Stiviere MANTOVA ITALIA ITEM TEKNOWAS BASIC codice GKR0040LA GKR0040LAB TEKNOWASH S codice GKR0046LA GKR0046LAB TEKNOWASH SOUND codice GKR0044LA GKR0044LAB TECNOWASH PLUS codice GKR0048LA GKR0048LAB Herewith we state that the summentioned items are in compliance with the following current laws 89 336 CEE EN55014 1 EN55014 2 73 23 CEE EN60335 1 SEAT MOTION EN60335 2 32 2003 EN60335 1 A11 2004 EN50366 A1 2006 MASSAGE EN55014 1 1993 EN55014 2 1993 EN61000 3 2 1995 EN61000 3 3 1995 AUDIO As per documentation filed at the registered office of the manufacturer DATE18 09 2009 SIGNATURE n Control device for actuator type SU15 M1 actuator LM40 CEI EN Declaration of Conformity TEKNOWASH User Manual SPETT LE GAMMA amp BROSS S P A V CERATELLI 2 46043 CASTIGLIONE DELLE STIV RE DICHIARAZIONE DI CIAR SPA VIA MOLARONI 3 61100 BORGO 5 MARIA PESARO ITALY LMAQ UL C 85 CH 237 V3P 24V1P 4000N 4 2A cod Ciar 4051200014 ALIM SU15 M1 120v USA2P C5BR 4 2A 9004BK QMFZ2 cod Ciar 2151100690 PULS HCV 13T M1 V5 496 SPBPT TELBP N390010046 cod Clar N500040161 CON LA PRESENTE CONFERMIAMO CHE IL SOPRA CITATO PRODOTTO CONFORME ALLE DISPOSIZIONI DI LEGGE EUROPEE S
25. ating Curves 1 Output Power vs Ambient temperature a 3 3 V and 5 V models b All other models gt 100 gt 100 9 80 80 3 60 1 Convection 3 60 PI 3 s 40 2 Forced air 0 5m min 40 18 CFM S 20 S 20 0 0 0 20 30 40 50 60 0 20 30 40 50 60 Ambient temperature c Ambient temperature c 2 Output Power vs Input Voltage All Models gt 100 80 60 o 40 8 20 0 0 85 90 264 Input Voltage VAC V INFINITY LLC 9615 SW Allen Blvd Suite 103 Beaverton OR 97005 1 866 372 1258 www v infinity com GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual HI FI Audio Amplifier amp Power Supply Features amp Safety Approvals 2 4 gt QF IN N ITY VOF 25 Switching Power Supply Rev 07 2007 Input Parameter Conditions Description Min Nom Max Units _ Input Frequency __ 63 Hz _ Input Voltage Output power derated from 85 90 VAC 85 tt YA Input Current AC Input of 110 VAC s mE 700 mA AC Input of 210 VAC 350 mA Inrush Current Measured at 110 VAC at full load cold start 20 Maasurad at 220 VAC at full load cold start 40 A Input fuse Built in non user serviceable g Output Parameter Conditions Description Min Nom Max Units Efficiency See table above Typical values measured at 11 5 VAC full load Hold up time At 115 VAC full load 46 mS
26. contains the following information e Manufacturer s address e Recipient s address When receiving TEKNOWASH make sure that the equipment has not been damaged during transport that the packaging has not been tampered with and that nothing has been removed from the package In case there is damage to the equipment or missing parts immediately inform the carrier and the manufacturer and provide for photographic documentation Two people are necessary to lift the parts of the TEKNOWASH that are contained the package If lifting machinery is used it is necessary to verify the correct balancing of the package until it is entirely lifted up proceeding with continuity and without any jerks or stops Keep the load as low as possible during movement both for better stability of the load and for better visibility The manufacturer is not responsible for any damages during transport of the TEKNOWASH 3 2 UNPACKING Place the packaged equipment as close as possible to the desired installation area and remove the parts from the package If the packaging is in paper it is necessary to recycle it as required by local waste disposal regulations If the package is made of plastic material nylon airball do not burn it or throw it away but dispose of it in the appropriate waste collection location in accordance with local regulations The packaging elements can be dangerous and must not be left within children s reach 3 3 INSTALLATION The operations for t
27. ercise Machines Component See General Information for Massage and Exercise Machines Component CIARSPA E194186 VIA MOLARONI 3 LOC BORGO SANTA MARIA 61100 PESARO PU ITALY Motor operated massage and exercise machines Model MF400 Models SU40 M2 SU40 M1 Models SU40 M1 C12 SU40 M2 C12 Model MF80 MF30 2 MF40 2 MFADO 2 Model SU15 M1 SU15 M2 Models SUO3 SUOMI SUO4M2 SUSOMI SUS3OMZ2 SUSOM3 Marking Company name and model designation Last Updated on 2009 04 30 Questions Print this page Notice of Disclaimer Page Top Copyright 2010 Underwriters Laboratories Inc The appearance of a company s name or product in this database does not in itself assure that products so identified have been manufactured under UL s Follow Up Service Only those products bearing the UL Mark should be considered to be Listed and covered under UL s Follow Up Service Always look for the Mark on the product UL permits the reproduction of the material contained in the Online Certification Directory subject to the following conditions 1 The Guide Information Designs and or Listings files must be presented in their entirety and in a non misleading manner without any manipulation of the data or drawings 2 The statement Reprinted from the Online Certifications Directory with permission from Underwriters Laboratories Inc must appear adjacent to the extracted material In addition the reprinted material must include a copyright no
28. g Huayin instrument 15A Equipment So Lid Power card Zherjiano Heay n instrument erd E HOSVV E 2x 0 75 mm VDE Co Lid 3 Power swiich Srenzhan Backathen Eecirorizs Co Lic 50755 AC 250V BINA 1053 735 VDE 4 Cartridge usen Waller Besironie Co FED AC 250W 24 5 1 20 mm F ype quick actng VDE 5 Varistor Centra Science Cor ENR14D371K AC 60 20 OC 865 495 VDE Ciusa current SOA Max pork arant ABOCA 6 Opigenupiar Samicondudor MOC3081 3504 TIO VDE 7 PTC Svangha Kater Polymer Material Co Lid KTED 25003 60082 25007 TUV SUD a Fluercepeciior Shenzhen Shengdn Capacilor Co Lid MEXA AC 280V 0 1 pF 4219021 VCE eca ZHAOYJAN JINZAO ELECTRONICS COLTS 2D 88 G UL 54 UL E441640 E 0 Transformer Jangyin Runyang Electronic Ca Lid Moda 5 577 50T1 8 No Tesi with appliance input AC ZIV Quas 1 Yedow Y low AC 5V 6 54 Output 2 Bise Blua AC 18 5V 1 04 Pri Winding 20 18 15207 Sse Winding 20 50 1427 and 20 38 SET 11 Temah Nighe Eimeirenies Co Ud RIA4 AZ 250V ZA ent CT C TUV Ribeletane verdamer 12 A r Pump Guangdong Mall Group Lid aes ac aw BW Cass E Na with sppllanze Output air une 2050T 12 12 Tremmalfirk in Arzen Co Lid HAP 2007 Teo 127 C VDE BI pump 14
29. gras of protection against liquide IP 20 4 Anschlubart Supp y connection Foste Anschlufileltung Non detachable cord Fester Arschlu Permenent connection Gerdtesteckvorrichtung Appilance Inlet Netzbetriebsast Rated cperalloni Dauerbatrieb Continuous operation Aussetzbetrieb intermittent operation Kurzzeitbetrieb Short time operation Material a Gehfusa Enciosura Control box PP b Laltarplatton p at XPC Zusdtzliche Angaben fUr Laser Kiseel zierung nach EN 60825 Additonal Information for Laser equipment classificsion scanrding to EN 60825 Klssne Ciasa na Wellaniinge Wavelangi na Pulsdauer P iso duratlen na Pr fbericht Nr Test Report No 70 401 08 554 02 Ort pinco Bhenghal palmi Projektielter Project manager LA Stempel und Unterschrift ua A v Saa and signare v Li i e A GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN OOW ORO AUM bar 20 2006 TEKNOWASH User Manual Aufbau bersicht f r Elektroger te und Maschinen Data form for electrical equipment and machinery PRODUCT SERVICE Seite ven Page3 of 3 Sicherhaiterakevante Schalter Temperaturregler HelzkSrper Stacker Fassungen Leltungen Kondantastoran Motoren und sonetiga Wicklungan z B Trensformatoran Magnetspulan Not Aus Gerite 2 Hardsteverungen bill ca Sichorhotte Lichtechrancen Sicherheftsventila Programmiarbare Steverurger SP6 hycraullsche Stavarvngen praumatiache
30. hall be determined 3 Vibrator assemblies shall be provided with a suitable enclosure 4 The performance of vibrator assemblies shall be determined in the end use application 5 The electrical spacings maintained within a pendant control or vibrator assembly shall be determined to be acceptable for the application Additional Conditions of Acceptability may be found in the Recognition Report available from the manufacturer REQUIREMENTS The basic standard used to investigate products in this category is ANSI UL 1647 Motor Operated Massage and Exercise Machines UL MARKING Components Recognized under UL s Component Recognition Program are identified by markings consisting of the Recognized company s identification and catalog model or other product designation In addition components produced under the UL Component Recognition Program will also bear the Recognized Component Mark The Listing or Classification Mark of Underwriters Laboratories Inc is not authorized for use on or in connection with Recognized Components Only those components that actually bear the Marking should be considered as being covered under the Component Recognition Program Last Updated on 2004 12 13 Questions Print this page Notice of Disclaimer Page Top Tha appearance of a company s name or product in this database does not in itself assure that products so identified have been manufactured under UL s Follow Up Service Only those products bearing the U
31. he installation of TEKNOWASH are described below Before installation control the integrity and completeness of the equipment The installation and regulation of TEKNOWASH includes dangerous operations these operations must be performed by qualified and responsible personnel Carefully read the instructions outlined in this handbook GAMMA amp BROSS declines any and all responsibility for damages caused by the disregard for these instructions 3 4 CONTROLS BEFORE CONNECTION amp LAYING Before assembling TEKNOWASH it is better to control and eventually adjust implants in the installation location and to observe the following rules e Control the operating tension and frequency these must correspond to the tension and frequency of the existing supply network in the location The electrical equipment normally operates at a tension of 230 volts 50 hertz frequency GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN g TEKNOWASH User Manual e Check the status of the supply cable conductors and the ground conductor e Control that an automatic interruption device against overloads with a cutout switch is installed e Connect the equipment s cable to the electrical socket with maximum care and in accordance with current regulations e The presence of power surges and equipment that creates electro magnetic interference could damage the electronic parts of TEKNOWASH It is prohibited to connect the electr
32. i 220 230V 50Hz 30W Con la presente conformiamo che il suddetto prodotto conforme alle disposizioni di legge europee seguenti EN 60335 2 32 2003 EN 60335 1 A11 2004 EN 50366 A1 2006 Data 12 04 07 Rappresentante egale GAMMA amp BROSS S P A Via Ceratelli n 2 Tel 0376 632630 Fax 0376 636683 46043 Castiglione delle Stiviere MN Partita IVA 01431270204 Massage compressor JGM 1000 2000 3000 TUV Declaration of Conformity TEKNOWASH User Manual CERTIFICATE seu No 21 06 12 61657 003 Holder of Certificate Shanghai Jiugong Industry Co Ltd No 88 Lane 3100 Gudai Rd 201100 Shanghai PEOPLES REPUBLIC CF CHINA Factory ies 84857 Certification Mark CERTIFICADO CERTIFICAT L ET 5 4 Lm Product Massage appliances Massage mattress iod ni Model s JGM1000 JGM2000 JGM3000 Parameters Rated voltage 230V AC Rated frequency SOHz iE Rated input power 40w Protection class I Degree of protection ordinary Tested according to N60335 2 32 2003 EN 60335 1 A11 2004 EN 50368 A1 2008 The product meets the requirements cf the German Equipment and Product Safety Act The Certification marks shown above can be affixed on the product The certification marks must not be altered in any way The use of the GS Mark is permitted until the jistec date the use of the TOV Maerk is unlirrited unless R is canceled See also notes overient Test report no 70407
33. ical equipment directly to conductors of the location s power supply system a breakdown in the power supply system could cause irreparable damage to the Teknowash and grave injuries to anyone who is in contact with the shampoo system 3 5 TEKNOWASH BASIC MODEL CONNECTION amp LAYING 1 Remove the TEKNOWASH and any packaging with maximum care and proceed to position the sink in the desired location 2 Lean forward the chair backrest separate the steel frame from the fibreglass body work unscrewing the two pic A rear screws near the sink and the two pic B handles under the seat on the side of the fibreglass bodywork Picture A Picture B 3 Take out the whole seat from the body work WATCH OUT pay attention to slightly widen the armrests so that the steel frame doesn t scratch the painted surface of the body work 4 Position the sink into its seat and verify that the hydraulic and electrical attachments are inserted correctly 5 Firmly mount the structure to the floor with the appropriate anchoring blocks or if the floor is not sufficiently compact with a chemical anchoring agent not provided GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 9 TEKNOWASH User Manual WARNING Before attaching the taps it is mandatory to clean out the hydraulic implant to avoid that residual sand and impurities clog the taps and damage the sophisticated ceramic mixers 6 Proceed with the h
34. in Plated Copper Alloy GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual Dimensions inches mm CHERRY RA SERIES 10A 125VAC TAN 250VAC 12A 125VAG 4 10A 250VAC Examples of Common Part Numbers and Descriptions inches mm Panel Thickness inches mm 0 039 to 0 078 1 0 to 2 0 Actuator Part Number Circultry Switch Function Terminal Type Housing Color Legend Marking RRA22H3BBBNN On Off 0 187 4 8 Black up Quick Connect Black Q RRA32H3FBBNN On Off 0 187 4 8 Black ofo Quick Connect Black Q RRA22H3BWWNN On Off 0 187 4 8 White QI Nini Quick Connect White Q RRA22H3FBRNN On Off 0 187 4 8 Red B oA Quick Connect Black RRA22H3BBRLN 2x1 On Off Lighted 0 187 4 8 Red aS Quick Connect Black O RRA32H3BBRLN Off Lighted 0 187 4 8 Red D Quick Connect Black Q 4 3 Housing Color Housing Color White Brown 10A 125VAC BA 250VAC 1 4HP 125 250VAC UL 12A 125VAC 10A 250VAC 1 4HP 125 250VAC CSA 10 4 250V 1125 55 VDE PC Thru Hole Straight Actuator Color 3 Code OA Code LB si LE Ha Ka Actuator Color Gron Amber LU pu White o Qu Brown Charcoal Grey Charcoa Gre Specifications subject to change without notice GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELL
35. interamente conforme alle direttive RHOS direttiva 2002 95 CE e successive aL MS T EN Firma Signature S Lucia di Piave 27 10 2008 Il Date Miotto Ladis Cognome nome Sumame name Amministratore unico Funzione Position MATREX S R L Via Mareno 79 31025 S LUCIA di P TV ITALY TEL 390438460544 FAX 1390438468252 HI FI Audio Amplifier amp Power Supply Features amp Safety Approvals GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual KA 1 3 WA VOF 25 Switching Power Supply 2 Rev 07 2007 Features RoHS RoHS Compliant x Universal input 85 264 Vac Output over current protected Output over voltage protected Industry standard foot print Efficiency up to 82 Safety approved to TUV CE UL cUL Conducted EMI meets EN55022 class B and FCC class B Current Total 1 2 Ripple amp Noise Efficiency Model A Regulation mVp p max 96 VOF 25 3 3 i 4 4 5 50 70 VOF 25 5 4 4 5 50 73 VOF 25 7 5 i 3 0 5 75 73 VOF 25 9 2 7 5 90 77 VOF 25 12 2 0 5 80 VOF 25 15 1 6 5 80 VOF 25 24 1 0 5 82 Notes 1 Measured from High Line to Low Line at Full load 2 Measured from Full load to 10 load at 110 VAC Ripple amp Noise measured at 20 MHz BW with a 0 1 uF ceramic cap and a 10 pF electrolytic cap on the output and two earth ground pads are connected to input earth ground Der
36. n is subject to a yearly surveillance audit Registration No SY 60014191 0001 Report No 15015061 001 Date of expiry 08 03 2011 Scope of expiry p ANA F e Cologne 09 03 2006 Dipl Ing D Meier GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN Attachment to Registration No Report No Organization Scope Cologne 09 03 2006 TEKNOWASH User Manual TUV Rheinland Product Safety GmbH Am Grauen Steln D 51105 K ln SY 60014191 0001 15015061 001 No 68 Lane 3100 Shanghai 201100 gt ching Manufacturina and Sales of Shanghai Jiugong Industry Co Ltd peu Rm re ae ee Doc 1 1 r i L Ler TUV Rev 0 Massagers and toilet assisting Chai oe ia i pe uec t Kr i J i Mu rr GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN VIA INCA www idrocontrol com DICHIARAZIONE DI CONFORMITA DECLARATION OF CONFORMITY Il fabbricante MATREX S r l Manufacter Name Via Mareno 79 31025 S Lucia di Piave TV Italy Prodotto Amplificatore audio Product Audio amplifier Modello 01502313 Model Il modello sopra indicato in conformit con i seguenti standards o altre normative To which this declaration relates is in conformity with the following standards or other normative documents Direttiva di bassa tensione
37. nape of the client s neck through a tilting movement and an adjustable forward and backward sliding movement TEKNOWASH S this model consists of a painted fibreglass body work a chair in polyurethane foam covered with a vinyl upholstery with a vitreous china sink It is equipped with a system that permits the positioning of the sink at the nape of the client s neck through a tilting movement and an adjustable forward and backward sliding movement The Teknowash is manufactured on a robust zinc coated tropicalized steel frame which provides the structure with the strength to carry the total weight necessary In addition this model is equipped with mechanical devices that are able to raise the seat and leg rest recline the backrest and place the client in an excellent position for relaxation A massaging air mat is placed inside the chair which provides a delicate pneumatic massage for the entire length of the legs and back By means of the AIR SHIATSU system it is possible to choose the sequential massage mode or the random one Moreover it is possible to adjust the massage intensity level TEKNOWASH SOUND this model consists of a painted fibreglass body work a chair in polyurethane foam covered with a vinyl upholstery with a vitreous china sink It is equipped with a system that permits the positioning of the sink at the nape of the client s neck through a tilting movement and an adjustable forward and backward sliding movement The
38. ng neutral detergents The use of solvents acids and abrasive detergents is strictly prohibited The use of metallic scrubbers or other abrasive sponges is strictly prohibited Hair color stains must be immediately removed to avoid that they permanently stain the surface of the sink Immediately remove hair and residual material to avoid the drain trap and drain Periodically clean the drainpipe of the plumbing implant not provided Periodically clean the showerhead aerator by unscrewing it from its seat Replace it if it is too clogged or encrusted with hard water deposits WARNING Commercial hard water deposit removal products contain solvents and acids that corrode chrome plated surfaces and are hazardous to your health through inhalation and contact The surface of the chair must be regularly cleaned with a soft cloth or sponge water and neutral detergent The use of solvents acids detergents or abrasive materials is strictly prohibited These substances would harm the superficial protection of the eco leather compromising its resistance to stains Strict avoid staining the chair with hair color it is impossible to remove hair color stains In case of accidental staining remove the material as soon as possible to avoid further damage WARNING THE USE OF ALCOHOL BASED CLEANERS IS HARMFUL FOR THE METHACRYLATE CANOPY never use them to avoid irretrievable damages 6 2 INSTRUCTION FOR RECURRING LUBRICATION O
39. ngth to carry the total weight necessary In addition this model is equipped with mechanical devices that are able to raise the seat and leg rest recline the backrest and place the client in an excellent position for relaxation A massaging air mat is placed inside the chair which provides a delicate pneumatic massage for the entire length of the legs and back By means of the AIR SHIATSU system it is possible to choose the sequential massage mode or the random one Moreover it is possible to adjust the massage intensity level GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 5 TEKNOWASH User Manual The shampoo unit is equipped with a stereo sound system with built in amplifier and loudspeakers Gamma amp Bross S p A provides the sound system with an IPOD SHUFFLE device but is it possible to use any other MP3 player A double shell plastic canopy gently closes the user off the outer environment helping relaxation and music enjoyment Moreover the canopy is enlighten with a LED RGB light system that gives pleasant visual sensations trough a chromotherapy program The LED RGB light system is managed with a remote control that creates graduates shading and mixes fading polychrome effects 1 5 TECHNICAL DATA Unit TEKNOWASH BASIC of measure ment su Height Lenght Ba cm Chart N 1 Net weight 3 bar water capacity liters Operating pressure Package dimensions cm 90x140x1
40. nning costs and duration of tte TEKNOWASH depend on the observation of the instructions described in this handbook It is mandatory to follow the instructions described in this booklet GAMMA amp BROSS declines any and all responsibility for direct or indirect damages caused to people animals or things provoked by negligence or disregard of the use instructions GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 3 TEKNOWASH User Manual 1 2 WARRANTY GAMMA amp BROSS warranties the TEKNOWASH and its accessories for a period of 12 months from the date of purchase This warranty covers repairs or replacement parts free of charge that have resulted as defected following a careful inspection by the Manufacturer s Technical Service excluding electrical parts The warranty is limited to material defects and becomes null and void should the parts result as having been manipulated or disassembled by unauthorized personnel The warranty does not cover responsibility for direct or indirect damages to people animals or things provoked by breakdown or malfunctioning of the machine The costs for transport IVA and any other costs that are not contained in the supply contract are the buyer s responsibility The replacement or repair of materials under warranty does not in any case extend the terms of that same warranty The buyer can claim his rights covered by the warranty only if he has respected the conditions of the
41. nual Verify the exact position to make sure that the levers do not touch the covering during movement The aluminum cover and the metallic parts of the levers and frame can be sharp use protective gloves 3 7 TEKNOWASH SOUND model CONNECTION amp LAYING execute all the process from step 1 to step 13 as per TEKNOWASH S 14 Place the clear plastic canopy inserting the lower edges in the proper clamps then tighten the blocking screws 3 8 TEKNOWASH PLUS model CONNECTION amp LAYING Handle with care the LED lighting canopy to avoid damages to the high value components Please return it to the manufacturer for any repair service execute all the process from step 1 to step 13 as per TEKNOWASH S SOUND 14 Unscrew the 4 screws that fix the canopy to the metal side plates pic G 15 Place the canopy and connect the LED lighting system to the power supply 16 Fasten the canopy and replace the screws that were previously removed Picture G GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 13 TEKNOWASH User Manual CHAPTER 4 INSTRUCTION FOR USE 4 1 WARNINGS BEFORE USE e Donotsiton the leg rest for any reason when the leg rest is lifted up and the chair is in relax position e The shiatsu massage must be switched on only and exclusively when the chair is in the relax position e The electronic switchboard of the shampoo system might be affected by malfunctions if
42. p LED System Switch Features amp Ratings GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN ROUND ROCKER SWITCH Features Single pole and double pole configurations e Lighted and non lighted options Available in a wide variety of colors High current switching in a compact round package Self locking tabs to fit industry standard panel cut outs Mechanical life min 100 000 operations Electrical Ratings Switch Series EN61058 Rating RR 10 4 250V u T125 55 RR Seres TEKNOWASH User Manual Crisp detent activation Round sien button with attractive matte finish non lighted versions Self locking tolerance compensation ribs for tight fit Durable silver alloy contacts for long life at heavy loads Rugged press fit terminals 4 8mm wide x 031 0 inn tk to mate with standard Quick Connect connectors Electrical Life at Rated Load According to VDE According to UL UL1054 Rating Min Operations Min Operations 10A 125VAC 8A 250VAC 1 4 HP 125 250VAC 10 000 6 000 Specifications Electrical Dielectric Strength 1000VAC for 1 minute Insulation Resistance 10 ohms min at 500VDC Initial Contact Resistance 020 ohms max Temperature Range 20 C to 85 C Materials Actuator non lighted Nylon 66 94V 2 Actuator lighted Polycarbonate Base Nylon 66 94V 2 Contacts Silver Alloy Movable Arm Copper Alloy Terminals T
43. se of malfunctioning to always contact the Manufacturer avoiding unauthorized interventions The use of accessories provided by the Manufacturer is permitted 2 3 PRESERVATION OF SAFETY To guarantee safety over the life span of TEKNOWASH it is indispensable to respect the following rules e tis prohibited to remove or tamper with the safety devices e 15 prohibited to leave the TEKNOWASH with its protections disassembled e t is prohibited to clean TEKNOWASH with petrol or any other solvent Use only authorized cleaning fluids non flammable and non toxic e lt is mandatory to disconnect the electric feeding before cleaning or maintenance operations e lt is mandatory to execute TEKNOWASH maintenance operations only by qualified personnel GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 7 TEKNOWASH User Manual CHAPTER 3 TRANSPORT UNLOADING ASSEMBLY AND SETTING UP 3 1 PACKAGING TRANSPORT AND UNLOADING OF THE EQUIPMENT All the material is carefully inspected by the manufacturer before shipping The packaging method is defined with the client in relation to the distance and chosen shipping method TEKNOWASH is transported inside a package protected by a sack made of plastic nylon airball to avoid any direct contact with humidity and or dust and is inserted into a box or crate of a size that impedes any horizontal or vertical movement The label attached to the outside of the package
44. there are power surges or electro magnetic interference which can be caused by hair dryers or other equipment that is not adequately protected Warning the remote control must never come into contact with water Never use the remote control with wet hands Warning do not come near to or touch the washing mechanisms placed under the chair in any way when the washing is not operating Inform the personnel and the clients to be sure that no person or animal comes near to or in contact with the movement mechanisms positioned under the chair Disregard for these warnings may cause grave injuries and permanent mutilations 4 2 USING THE WASH FUNCTION Before operating the TEKNOWASH check the efficiency of the equipment and train yourself with the command devices The sink can be positioned manually with precision at the nape of the client s neck by using the two regulation systems An original sliding system permits the movement of the sink in forward and backward directions A classic friction tipping system permits the raising and lowering of the sink s neckrest The chairs movements and massage are activated and controlled through the remote control The instructions for use of the various commands provided with the different models are listed below GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 14 TEKNOWASH User Manual 4 3 SEAT MOTION 8 MASSAGE REMOTE CONTROL FOR TEKNOWASH S SOUND PLUS
45. they require specialized personnel It is mandatory to remove the plug from the electrical socket before attempting any extraordinary maintenance operation 6 4 TECHNICAL ASSISTANCE Maintenance must be performed in accordance with the instructions contained in this manual For all cases not described herein and for any type of assistance contact the Manufacturer directly and provide the following information Model Client reference Order number or D D T The date of delivery The correct information guarantees rapid and precise response If the maintenance operations on theTeknowash are not performed in accordance with the provided instructions with non original spare parts or without the written authorization of the Manufacturer or in any way compromises its integrity or modifies its characteristics GAMMA amp BROSS will not be held responsible for the safety of persons and the malfunctioning of the Teknowash Any unauthorized intervention renders the warranty conditions null and void GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 23 TEKNOWASH User Manual CHAPTER 7 HINTS FOR WASTE DISPOSAL At the end of the product life cycle please dispose of it following all the environmental conservation rules Waste disposal is to be done in the official rubbish dumps We recommend to follow strictly the current laws about the separate waste collection for recycling GAMMA amp BROSS sp
46. tice in the following format Copyright 2010 Underwriters Laboratories Inc http database ul com cgi bin XY V template LISEXT 1FRAME showpage html nam 07 05 2010 GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN TEKNOWASH User Manual PGXX2 Guidelnfo Massage and Exercise Machines Component Page of PGXX2 GuideInfo Massage and Exercise Machines Component View Listings Page Bottom Massage and Exercise Machines Component The devices covered under this category are incomplete in certain constructional features or restricted in performance capabilities and are intended for use as components of complete equipment submitted for investigation rather than for direct separate installation in the field THE FINAL ACCEPTANCE OF THE COMPONENT 15 DEPENDENT UPON ITS INSTALLATION AND USE IN COMPLETE EQUIPMENT SUBMITTED TO UNDERWRITERS LABORATORIES INC USE This category covers components intended for use in motor operated massage and exercise machines such as pendant controls and vibrator assemblies CONDITIONS OF ACCEPTABILITY Unless specified otherwise in the individual Recognitions consideration is to be given to the following Conditions af Acceptability when these components are employed in the end use equipment 1 The electrical rating of pendant controls shall be suitable for the load controlled 2 The suitability of any cords and cord connectors provided with a pendant control s
47. wing regulations may be subject to damages or may cause damages to people animals or things GAMMA amp BROSS declines any and all responsibility for direct or indirect damages caused by the disregard for the safety regulations and accident prevention procedures described below 2 2 SAFETY IN USE When the TEKNOWASH is in use it is mandatory to follow the instructions described below e t is prohibited to operate the TEKNOWASH by anyone who has not completely read understood and perfectly assimilated the information contained in this booklet e lt is prohibited to operate the TEKNOWASH by persons that are not adequately trained or that are not in good health e t is prohibited to operate the TEKNOWASH when the safety devices are not inserted and the fixed protections are removed e Before using it is mandatory to control the perfect integrity of all the safety devices on the TEKNOWASH e It is mandatory that the installation and mounting of the TEKNOWASH be executed in accordance with the instructions outlined in this booklet e It is mandatory to position the TEKNOWASH inside a place that is closed covered clean sufficiently lighted temperature regulated and not exposed to dust humidity and is free of the danger of explosion or fire e lt is mandatory to verify that the support surface beneath the TEKNOWASH is flat and solid e It is recommended to become familiar with the command devices before using e t is recommended in ca
48. work Pay attention to slightly widen the armrests so that the steel frame doesn t scratch the painted surface of the body work Replace the screws and the handles that were previously removed 12 Connect the electric socket to the plug and fix it to the body work Pay attention to keep the electric cables clear of the lifting mechanism The electric connection must be strictly done in the hollow under the seat Never do the electric connection in the hollow under the sink Never lay the electric connections on the floor Carefully check that all the electrical cables are perfectly fasten to the steel structure and that they do not interfere with any of the chair s movements which could cause them to be jerked or damaged provoking grave injuries to persons and irreparable damages 777 A B Warning Avoid any electrical connection or clamping in the hatched area Wet or moist area 30 wash basin electrification VIBRO V 220 W 150 i 40242 2 exit cable 100 cm electrification provided socket small 10 AIR MASSAGE V 220 W 150 exit cables 100 cm electrification provided sockets small 10A ONLY USA exit cables V 110 13 Carefully re assemble the front aluminium panel pic C in order to avoid scratches on the painted surface of the body work replace the screws and the handles that were previously removed GAMMA amp BROSS spa Via Ceratelli 2 46043 CASTIGLIONE DELLE STIVIERE MN 12 TEKNOWASH User Ma
49. ydraulic connections making sure to verify the easy movement of the sink with its maximum range of tilting and sliding 7 Place again the seat into the bodywork pay attention to slightly widen the armrests so that the steel frame doesn t scratch the painted surface of the body work replace the screws and the handles that were previously removed 3 6 TEKNOWASH S MODEL CONNECTION amp LAYING In the Shiatsu version do not ever force the opening of the backrest to avoid the misplacement of the pneumatic equipment s tubes and never pull the ribbon on the tubes to avoid removing them from the compressor or even worse from the internal massaging panel in the seat It is extremely dangerous to move the chair during assembly operations It is prohibited to activate the chair with any person in proximity of the mechanical parts It is mandatory to disconnect electricity as soon as the chair is extended at its maximum range Disregard for these rules may result in grave injuries and permanent disability 1 Remove the TEKNOWASH and any packaging with maximum care and proceed to position the sink in the desired location 2 Operate a temporary electric connexion lean the backrest forward and lift the legrest with the remote control 3 Disassemble the front aluminium panel pic C and if necessary the crossbeam pic D paying attention to avoid scratches on the painted body work GAMMA amp BROSS spa Via Ceratelli 2 4604

TEKNOWASH SHAMPOO SYSTEM USER MANUAL

Contents

Download Pdf Manuals

Related Search

Related Contents