Home

AIRCRAFT OPERATING INSTRUCTIONS Light

1. O WWD vvv NN oa October 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 9 Aircraft Operating Instructions Edge XT 582 SUPPLEMENTS 9 TRAINING SUPPLEMENT 9 1 XT582 Flight Training Supplement This supplement is intended to outline the unique characteristics of the XT 582 weight shift control WSC airplane It is not intended to outline all aspects of a WSC aircraft The supplement is intended to be used by a pilot operator who already has extensive knowledge of WSC aircraft operation The performance procedures and unique features of the XT are summarized here and the details are referenced to the appropriate section within the AOI Normal Procedures found in Section 4 of the Aircraft Operating Instructions AOI covers all the Normal Procedures in detail 9 2 Assembly and Break Down Sections 4 2 to 4 4 and 4 11 to 4 41 outline wing assembly and break down procedures for the aircraft Airborne suggests assembling the wing on the control frame as this method keeps the sail off the ground resulting in less chance of the wing being soiled or damaged The wing can be assembled and installed on the base by one person The mast has a gas assist strut to help lift the wing into place above the base unit It should be noted that the batten tips utilise a unique hinged catch system to secure the battens to the trailing edge This system allows easy installation and provides extraordinary f
2. March 2011 Issue 2 3 Page 15 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 5 Complete Trike Pre Flight Inspection Ensure that the ignition switches are off prior to inspection Daily inspections as outlined in the Rotax Operator s Manual should be carried out in conjunction with the following inspections Trike Base Pre Flight Inspection No leaks from fuel system and engine fuel lines secure No leaks from oil system and engine Fuel On Off valve in the ON position Fuel filter clean and operational Fuel drain valve check for any water in tank sump by draining a small quantity into a container Sufficient fuel for flight Oil level for oil injection OK See Photo Below Fig 22 Coolant level Between max and min level on coolant bottle Rotary valve oil level OK Radiator hoses secure and operational Propeller free of splitting denting delamination nicks Blade tape condition Propeller hub assembly secure and tie wired No cracking in tyre treads or evidence of cracking around the rim Rear end and wheel spats secure No bolts bent fractured or evidence of corrosion Electrical amp instrumentation system secure and operational Throttle operation both foot and hand throttle Verify free and full movement Seat belt attachments secure Steering damper adjust to desired setting engine components secure air filter muffler
3. AirBorne WindSports Pty Ltd SECTION 0 Aircraft Operating Instructions Edge XT 582 This page left blank intentionally October 2011 Issue 2 3 Page 8 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL CONTENTS OF GENERAL SECTION 1 CONTENTS OF GENERAL SECTION 1 1 GENERAL 1 4 Introduction NOTE 1 1 4 Warning Notice 1 1 2 Definitions 1 2 General Description 1 1 3 Two View Photos 1 1 4 General Dimensions 1 1 5 General Description 12 Symbols Abbreviations and Terminology OUR 13 Use of metric imperial units October 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL 1 GENERAL This document Aircraft Operating Instructions AOI has various sections to comply with the General Aviation Manufacturers Association GAMA handbook specification The GAMA format has been adopted and used where applicable for this weight shift controlled microlight The AOI contains information for the XT 582 base coupled with various wings 1 1 Introduction This microlight series has been designed and manufactured in accordance with the ASTM designation 2317 04 Standard Specification for Design of Weight Shift Control Aircraft The aircraft has also been designed to the higher level of certification requirements for weight shift controlled aircraft The design standard of BCAR Secti
4. 0 8 1235 mm 20mm MERLIN WING 50 2 inch 0 98 0 8 1275 mm 25 20mm Streak Cruze Middle U bracket hole only Merlin rear U Bracket permitted for aerotow MTOW Table 7 Section 2 Centre of Gravity Limits NOTE The rear hole on the wing suspension bracket on the Cruze wing has been blanked off so that it cannot be used Using the rear hole was found to show non compliance to the minimum required trim speed of 1 3 Vs 2 6 2 Manoeuvring Limits All aerobatic manoeuvres including spinning is prohibited Aerobatic manoeuvres including whipstalls stalled spiral descents and negative G manoeuvres are not permitted It must be emphasised that a whipstall spiral descent or negative G manoeuvre can never be conducted safely These manoeuvres put the aircraft outside the pilots control and put both the aircraft and its occupants in extreme danger Do not pitch nose up or nose down more than 45 degrees from the horizontal The front support tube of the trike and the pilot s chest limits the fore and aft movement of the control bar respectively 2 6 3 Bank Angle Do not exceed 60 degrees of bank angle In roll there is no stop for the control movement For the purpose of pre flight freedom check by lowering each wing to within 10 cm of the ground on ground level 2 6 4 Flight Load Factor Limits Max positive manoeuvring load factor 4 0G Negative load factors Prohibited Load factors below 1 0 G To be avoided Table 8 Section 2 Flight
5. 1 Remove pin and bolt from channel 2 Rotate seat back forward and replace bolt in channel one hole further forward 3 Replace safety pin through bolt October 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Operating Instructions Edge XT 582 AIRCRAFT amp SYSTEMS To move backrest rearward the bolt should be moved one hole back 7 9 Occupant restraint Harness Both front and rear seats are fitted with a 3 point restraint harness system The shoulder inertia reel system is fitted to the mast and requires attachment on the male section of the lap belt during lap belt fastening see photo When flying the trike solo it is important to fasten the rear seat belt to prevent contact with hot engine components in flight Figure 2 Section 7 Fastening Seat Belt with Shoulder Sash 7 10 Engine The power unit is a Rotax 582 UL DCDI mod 99 65hp 2 stroke engine designed and built in Austria The Rotax engine is fitted with a gearbox which delivers smooth thrust via a reduction drive This power unit is complemented with a ground adjustable propeller giving the ultimate in performance and reliability The engine is fitted with Bing carburettors with an external dry filter 7 11 Propeller The aircraft is equipped with a 3 blade composite propeller with ground adjustable pitch The hub is anodised alloy Two alternate propeller hub configurations are available for use on the XT582 these include
6. PERFORMANCE 5 2 4 Landing 582 Streak 2B Performance at MTOW Metric Imperial Landing Distance from 15 m 50 ft 315m 1033 ft Table 4 Section 5 Cruze Landing 5 2 5 Landing XT 582 Cruze Performance at MTOW Metric Imperial Landing Distance from 15 m 50 ft 306 m 1004 ft Table 5 Section 5 Cruze Landing 5 2 6 Landing XT 582 Merlin Performance at MTOW Metric Imperial Landing Distance from 15 m 50 ft 306 m 1004 ft Table 6 Section 5 Merlin Landing Landing distances are specified for Sea Level with A level dry runway With short grass Still wind And temperature of 15 deg C The following factors will increase landing distance Lower drag runway surfaces such as tarmac Tail wind Down hill landing OAT above 15 deg C Runway altitude above sea level The pilot is required to take into account the effect of the above when determining landing distance Crosswind components of up to 12 knots at maximum AUW are within aircraft operating limitations Always exercise judgement when selecting locations for take off and landing Leave adequate margin for appropriate control action in the event of sudden engine failure or turbulence being encountered CAUTION TAKE OFF AND LANDING DISTANCES MUST BE INCREASED BY 20 FOR EACH 1000 FEET OF ALTITUDE ABOVE SEA LEVEL October 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 5 Aircraft Operating Instructions Edge XT 582 PERFORMANCE
7. En228 Premium Regular Super grade gasoline lead free min RON 90 Optional Fuel Type AVGAS see note Preferred Fuel Type Table 5 Section 2 Fuel Specification NOTE Due to higher lead content in AVGAS deposits in the combustion chamber will increase Therefore use AVGAS only if you encounter problems with vapour lock or if the other fuel type is not available Use of AVGAS requires higher frequency maintenance intervals Refer to the maintenance manual Refer to section 2 6 7 for fuel capacities and limitations Engine Lubricating Oil Engine lubrication is supplied via the oil injection system which is gravity fed The oil quantity is defined by engine rpm and the lever position The lever is actuated via a Bowden cable connected to the throttle cable The oil injection tank has a capacity of 2 litres Oil Specifications Oil used is Super two stroke ASTM CEC standards API TC classification consult your Rotax dealer for a recommended oil to suit your operating environment 2 4 4 Rotary Valve Lubrication Rotary valve lubrication is supplied via a small tank mounted on the top right hand side of the engine The tank has a maximum fill level with a capacity of 60 mL of oil The oil has the same specifications as the oil injection system Oil Specifications Oil used is Super two stroke ASTM CEC standards API TC classification consult your Rotax dealer for a recommended oil to suit your operating environment 2 4 5 Gearbox Lub
8. Propeller Clear Depress Start Button Push When engine fires Release Choke Off Engine Running Adjust Idle to 2000 rpm Q mins Table 8 Section 4 Starting Engine Check March 2011 Issue 2 3 19 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 9 3 Before Take Off Park Brake On Choke Off Warm Up Adjust Idle to 2500 rpm temp to reach 65 deg C Ignition Check 3000 rpm Speed drop with only one ignition must not exceed 300 rpm Trimmer Set Fast Increase trim speed Fuel Quantity Instruments Circuit Breaker Harnesses Helmets Throttle Response Controls Check Sufficient for task Check Check Secure Secure Full On Q seconds Pitch and Roll Full and free movement completed before engine start as well as just prior to take off Table 9 Section 4 Before Take Off Check 4 9 4 Pitch Control Hand Throttle Foot Throttle Directional Control Airspeed Take Off and Initial Climb Neutral Off Full On Reduce for minimum TOW Nose Wheel Steering Straight CRUZE amp MERLIN STREAK 2B 45 KIAS 49 KIAS Table 10 Section 4 Take Off and Initial Climb Check 4 9 5 Climb Foot Throttle Full On Reduce for minimum TOW RPM 5000 RPM Reduce to 5000 rpm once climb established No change if using a reduced power take off Airspeed STREAK 2B CRUZE amp 45 50 KIAS MERLIN Table 11 Section 4 Climb Check March 2011 Issue 2 3 Page
9. The XT 582 has a pull start mechanism on the front of the engine The pull start should not be used for in flight starting The pull start is intended as a back up in the case of a low battery and should only be operated when the aircraft is on the ground with the park brake activated October 2011 Issue 2 3 Page 9 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 Placards The placards on the aircraft are designed to provide information regarding general aircraft limitations and other details for the safe operation of the aircraft Listed on the following pages are details of the placards fitted to the aircraft 2 7 1 Flight Limitations Placard 62mm ROTAX 582 UL ENGINE LIMITATJON MIN MAX ENGINE RPM WATER rune TEMPERATURE TEMPERATURE ROTAX 582 UL ENGINE LIMITATIONS MIN MAX ENGINE RPM 6800 rpm WATER TEMPERATURE 150 Deg F 175 Deg F EXHAUST GAS TEMPERATURE 930 Deg F 1200 Deg F CYLINDER HEAD TEMPERATURE 230 Deg F 300 Deg F FUEL TANK CAPACITY 18 5 USGal z FUEL TANK CAPACITY aea amp E LOADING LIMITATIONS SEE AIRCRAFT OPERATING LOADING LIMITATIONS N INSTRUCTIONS SECT 6 3 4 FOR FURL LOAD INSTRUCTIONS SECT 6 3 3 FOR FUEL LOAD LIMITATIONS EMPTY WEIGHT mpg EMPTY WEIGHT MAX TAKEOFF WEIGHT MAX TAKEOFF WEIGHT WEIGHT OF MIN MAX WEIGHT OF 55kg m OCCUPANTS 12116 4401 OCCUPANTS 55kg 200ko FLY SOLO FROM FRONT SEAT ONLY F
10. k Pound Ib Pound per sq inch psi Inch in Foot ft k Statute mile Nautical mile NM k Millibar mb Millibar mb k Imperial gallon US gallon US quart Cubic foot ft Degree Fahrenheit F k Inch Pound in Ib Foot Pound ft Ib Table 1 Section 1 Metric Imperial Conversion Factors 0 4536 Kilogram kg 6 895 Kilopascal kPa 25 4 Millimetres mm 0 3048 Metre m 1 609 Kilometres km 1 852 Kilometres km 1 Hectopascal hPa 0 1 Kilopascal kPa 4 546 Litres 1 3 785 Litres 1 0 946 Litre 1 28 317 Litres 1 1 8 X C 32 0 113 Newton Metres Nm 1 356 Newton Metres Nm October 2011 Issue 2 3 Page 9 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL This page left blank intentionally October 2011 Issue 2 3 Page 10 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS LIMITATIONS LIMITATIONS 2 LIMITATIONS 2 1 General 2 2 Airspeed Limitations 2 3 Airspeed Indicator markings 2 4 Power Plant Limitations 2 4 1 Engine 2 4 2 Engine Limitations 2 4 3 Fuel Grades Engine Lubricating Oil 244 Rotary Valve Lubrication 2 4 5 Gearbox Lubrication 2 4 6 Cooling System 2 4 7 Propeller 2 4 8 Engine Instrument Markings 2 5 Weight limits 2 6 Operational Limits 2 6
11. 3 2 Airspeeds for Emergency Operations 3 2 1 XT 582 Streak 2B Speed IAS Maximum Manoeuvring 70 knots Speed Va Best Glide 50 knots Table 2 Section 3 Airspeeds for Emergency Operations 3 2 2 XT 582 Cruze Speed IAS Maximum Manoeuvring 66 knots Speed Va Best Glide 45 knots Table 2 Section 3 Airspeeds for Emergency Operations 32 3 XT 582 Merlin Speed IAS Maximum Manoeuvring 66 knots Speed Va Best Glide 44 knots Table 3 Section 3 Airspeeds for Emergency Operations October 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 3 Aircraft Operating Instructions Edge XT 582 EMERGENCY 3 3 Emergency Procedures Check List 3 3 1 Engine Failure on Climb Out If your engine fails on climb out maintain airspeed reduce angle of attack and land straight ahead if possible Proceed as follows Maintain Control A Maintain Airspeed take off safety speed L Forced Landing straight ahead if possible 3 3 2 Engine Failure at Height If the engine stops while operating at cruise or full power when the aircraft is well clear of the ground check Fuel Contents F Fuel tap on I Ignition on If your engine fails in flight do not attempt to restart the engine unless one of these items is found to be incorrect and is able to be rectified Relax and maintain control whilst concentrating on correct forced landing techniques 3 3 3 Full Power Engine Shutdown In Flight If the throttle should jam fu
12. Pilot 200 Ib 20 Ib additional equipment Passenger 190 Ib 19 1 gallons of fuel maximum Table 7 Section 6 Imperial Fuel Calculator October 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 6 Aircraft Operating Instructions Edge XT 582 WEIGHT BALANCE amp EQUIPMENT This page left blank intentionally October 2011 Issue 2 3 Page 6 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Operating Instructions Edge XT 582 AIRCRAFT amp SYSTEMS AIRCRAFT amp SYSTEMS DESCRIPTION AIRCRAFT amp SYSTEMS DESCRIPTION 7 AIRCRAFT amp SYSTEMS DESCRIPTION 7 4 General 7 2 Airframe 7 3 Flight Controls 7 4 Ground Flight Control 7 5 Trimmer operation 7 6 Instrument panel 77 Undercarriage System 7 8 Seat Adjustment 7 9 Occupant restraint Harness 7 10 Engine 7 11 Propeller 7 12 Brake System 7 13 Electrical System 7 13 1 XT 582 Electrical Schematic 7 14 Pitot Static System and Instruments 7 15 GX2 Instrument Function 7 15 1 Description of Features 7 15 2 System Turn On 7 16 Emergency Parachute Optional Equipment ONN NOU Oo FP A A O WWW oua 7 17 Ignition Switches October 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Operating Instructions Edge XT 582 AIRCRAFT amp SYSTEMS 7 AIRCRAFT amp SYSTEMS DESCRIPTION 7 1 General This section provides descriptions of the aircraft and its systems as well as me
13. is considered comfortable for a minimum weight takeoff Take off distance will be extended at reduced power 2 6 10 Other Limitations Maximum Cross Wind 12 knots 13 mph Maximum Wind Strength 20 knots 23 mph Maximum Ambient Operating Temperature Table 10 Section2 Other Limitations No person who is untrained or unqualified in weight shift controlled flight or who is unfamiliar with the wing and base combination should ever attempt to pilot the aircraft unless under professional instruction The effect of light rain on the aircraft can increase the stall speed It is extremely important to maintain speeds in excess of the take off and landing safety speeds when the wing is wet If the aircraft has been left out in the rain or heavy dew it is necessary to wipe the wing down prior to take off It is also recommended that the aircraft be flown solo first to ensure all excess moisture is removed A chamois or sponge is recommended to remove the water October 2011 Issue 2 3 Page 8 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS Continued operation in heavy rain is not recommended due to the abrasive effect of CAUTION raindrops on the propeller Do not use MOISTURE ON THE WING CAN INCREASE waterproofing agents on the wing as the STALL SPEED AND SHOULD BE REMOVED consequent beading of water droplets can PRIOR TO TAKE OFF significantly increase the stall speed
14. 10 3 Taxiing Taxiing in normal conditions is fairly straight forward With the engine idling the brake lever should be depressed which will disengage the park brake The control frame should be positioned so that it is in the approximate position for normal trim speed The pilot s feet actuate steering on the ground Left turn occurs when the right footrest is pushed forward Right turn occurs when the left footrest is pushed forward NOTE Control sense for turning is opposite to that of a conventional three axis aircraft When taxiing in strong wind conditions the following procedures apply e Head Wind conditions requires the nose of the wing to be lowered just below the trim position Down Wind conditions requires the nose of the wing to be raised just above the trim position e Cross wind conditions requires the upwind tip to be lowered 4 10 4 Before take off Before flight a full throttle check is to be carried out During this operation the pilot must be seated in the cockpit CAUTION BEWARE OF LOOSE STONES IN THE RUN UP AREA LOOSE STONES CAN BE SUCKED UP BY THE PROPELLER AND CAUSE SEVERE PROPELLER DAMAGE IN A VERY SHORT TIME RUN UPS ARE BEST CONDUCTED ON A CLEAR SEALED SURFACE OR ON GRASS NEVER ON GRAVEL and prepared to switch off the ignition at very short notice if an emergency should arise The two ignition circuits should be tested with the engine running at 3000 rpm Ignition one should be switched off and the RPM d
15. 2 1 Aircraft Weighing Information Typical wing weight Cruze 51 kg Streak 2B 50kg and Merlin 49 kg Aircraft Type AirBorne WindSports EDGE XT 582 Serial No Issue Date Empty Weight kg Trike Base XT 582 1 kg Unusable Fuel 3 Litres 1 2 kg Wing 1 kg Training Bars 1 4 kg If applicable 1 Issue 1 Aircraft Empty Weight kg Trike Base XT 582 2 Unusable Fuel 3 Litres 2 2 kg Wing 2 kg Training Bars 1 4 kg 2 If applicable Issue 2 Aircraft Empty Weight kg Table 1 Section 6 Aircraft Weight Empty Weight for the aircraft comprises of e Standard equipment as per section 6 2 2 e Optional equipment as per section 6 2 3 e Full coolant full engine oil and unusable fuel The keel extension and pack up gear are not included in the empty weight October 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 6 Aircraft Operating Instructions Edge XT 582 WEIGHT BALANCE amp EQUIPMENT 6 2 2 Standard Equipment STANDARD EQUIPMENT Fitted Engine Type ROTAX 582 UL DCDI mod 99 Engine Serial Number Gear Box Type E Type 3 47 1 Airspeed Indicator Knots Std GX2 Instrument Std Tool Kit amp Mast Strap Hold Down Strap Std Table 2 Section 6 Aircraft Weight Standard Equipment 6 2 3 Alternate Equipment Fitted ALTERNATE EQUIPMENT Yes No Propeller Type BOLLY BOS 68 INCH with BOS 3 hub Propeller Type Warp Drive 3 67 7 INCH Blade with Warp Drive hub Table 3 Section 6 Aircraft Weight Sta
16. 20 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 9 6 Cruise Speeds Hand Throttle Adjust for Level Flight Airspeed CRUZE amp MERLIN 50 55 KIAS STREAK 2B 55 60 KIAS Table 12 Section 4 Cruise Check 4 9 7 Descent Foot Throttle Reduce Hand Throttle Off Airspeed STREAK 2B CRUZE amp 45 50 KIAS MERLIN Table 13 Section 4 Decent Check 4 9 8 Landing Hand Throttle Off Airspeed CRUZE amp MERLIN 45 KIAS STREAK 2B 49 KIAS Directional Control Nose Wheel Steering Straight Brakin g Off Then as required Table 14 Section 4 Landing Check 4 9 9 After Landing Parking Brake On As required Ignition Switch Off Electrical Switch Off Radio Equipment Off Controls Secure Parachute if fitted Insert Safety Pin Table 15 Section 4 After Landing Check March 2011 Issue 2 3 Page21 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 10 Amplified Procedures 4 10 1 Before Starting Safety is everyone s business Included are only some important safety tips Keep a good lookout be thoughtful and always show your intentions prior to starting Prior to flight a thorough pre flight inspection of the aircraft should be carried out Details of the pre flight inspection are shown earlier in this section Make sure all engine controls are operative and you understand the on off positions of the thr
17. 5 3 Climb 53 1 XT 582 Streak 2B Performance at MTOW Climb rate 45 kts Best Climb Speed Sea Level Gradient of Climb Table 7 Section 5 Cruze Climb 5 3 2 XT 582 Cruze Performance at MTOW Climb rate 45 kts Best Climb Speed Sea Level Gradient of Climb Table 8 Section 5 Cruze Climb 5 3 3 XT 582 Merlin Performance at MTOW Climb rate 45 kts Best Climb Speed Sea Level Gradient of Climb Table 9 Section 5 Merlin Climb Metric 3 7 m sec 45 kts 16 7 Metric 3 7 m sec 45 kts 16 7 Metric 3 2 m sec 45 kts 13 7 Climb data is for ISA conditions Sea Level at 15 deg C 5 4 Airspeed Calibration Imperial 721 ft min 45 kts 16 7 Imperial 721 ft min 45 kts 16 7 Imperial 621 ft min 45 kts 13 7 All Air Speeds in this AOI are expressed as Knots Indicated Air Speeds KIAS unless otherwise noted Below is a table showing the relationship between Indicated Air Speed and Calibrated Airspeed The table assumes zero instrument error Indicated Air Calibrated Air Calibrated Air Speed Speed Speed KIAS KCAS KCAS Standard Windscreen Windscreen Extension Fitted 35 34 32 40 39 36 45 43 41 50 47 45 60 56 52 70 65 61 80 74 70 85 79 74 Table 10 Section 5 Airspeed Calibration October 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 5 Aircraft Operating Instructions Edge XT 582 PERFORMANCE 5 5 Stall Speeds 5 5 1 582 Streak 2B Performance
18. Figure 1 Section 1 Aircraft Front View Figure 2 Section 1 Aircraft Side View October 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL 1 1 4 General Dimensions 1 1 4 1 XT 582 Streak 2B DIMENSIONS Australian European USA Wing Span 9 97m 9 97 32 7 ft Wing Area 13 5 sq m 13 5 sq m 146 sq ft Aspect Ratio 7 4 Wing Weight 50 kg 50 kg 110 lbs Overall Height Control Bar Fwd 3 65m 3 65m 11 9 ft Trike Width 1 91m 1 91 6 3 ft Trike Length 2 85m 2 85m 9 3 ft Wheel Track 1 7m 1 7m 5 6 ft Wheel Base 1 89m 1 89m 6 2 ft Trike Height 2 53m 2 53 8 3 ft Cockpit Width 0 7m 0 7m 2 3 ft Wing Packed Length 5 6 5 6 18 4 ft Wing Length Short Packed 4 2m 4 2m 13 8 ft 1 1 4 2 XT 582 Cruze DIMENSIONS Australian European USA Wing Span 9 97 m 9 97 m 32 7 ft Wing Area 14 4sq m 14 4 sq m 155 sq ft Aspect Ratio 6 9 Wing Weight 51kg 51kg 112 Ibs Overall Height Control Bar Fwd 3 65 3 65 11 9 ft Trike Width 1 91m 1 91m 6 3 ft Trike Length 2 85m 2 85 9 3 ft Wheel Track 1 7m 1 7m 5 6 ft Wheel Base 1 89 m 1 89 m 6 2 ft Trike Height 2 53m 2 53 8 3 ft Cockpit Width 0 7m 0 7m 2 3 ft Wing Packed Length 5 6m 5 6m 18 4 ft Wing Length Short Packed 4 2m 4 2m 13 8 ft October 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL 1 1 4 3 XT 582 Merlin DIMENSI
19. Issue 2 3 Oct 2011 3 3 Issue 2 3 Oct 2011 5 1 Oct 2011 Issue 2 3 0 6 Issue 2 3 Oct 2011 3 4 Issue 2 3 Oct 2011 5 2 Oct 2011 Issue 2 3 0 7 Issue 2 3 Oct 2011 3 5 Issue 2 3 Oct 2011 5 3 Oct 2011 Issue 2 3 0 8 Issue 2 3 Oct 2011 3 6 Issue 2 3 Oct 2011 5 4 Oct 2011 Issue 2 3 1 1 Issue 2 3 Oct 2011 3 7 Issue 2 3 Oct 2011 5 5 Oct 2011 Issue 2 3 1 2 Issue 2 3 Oct 2011 3 8 Issue 2 3 Oct 2011 5 6 Oct 2011 Issue 2 3 1 3 Issue 2 3 Oct 2011 4 1 Issue 2 3 Oct 2011 6 1 Oct 2011 Issue 2 3 1 4 Issue 2 3 Oct 2011 4 2 Issue 2 3 Oct 2011 6 2 Oct 2011 Issue 2 3 1 5 Issue 2 3 Oct 2011 4 3 Issue 2 3 Oct 2011 6 3 Oct 2011 Issue 2 3 1 6 Issue 2 3 Oct 2011 4 4 Issue 2 3 Oct 2011 6 4 Oct 2011 Issue 2 3 1 7 Issue 2 3 Oct 2011 4 5 Issue 2 3 Oct 2011 6 5 Oct 2011 Issue 2 3 1 8 Issue 2 3 Oct 2011 4 6 Issue 2 3 Oct 2011 6 6 Oct 2011 Issue 2 3 1 9 Issue 2 3 Oct 2011 4 7 Issue 2 3 Oct 2011 7 1 Oct 2011 Issue 2 3 1 10 Issue 2 3 Oct 2011 4 8 Issue 2 3 Oct 2011 7 2 Oct 2011 Issue 2 3 2 1 Issue 2 3 Oct 2011 4 9 Issue 2 3 Oct 2011 7 3 Oct 2011 Issue 2 3 2 2 Issue 2 3 Oct 2011 4 10 Issue 2 3 Oct 2011 7 4 Oct 2011 Issue 2 3 2 3 Issue 2 3 Oct 2011 4 11 Issue 2 3 Oct 2011 7 5 Oct 2011 Issue 2 3 2 4 Issue 2 3 Oct 2011 4 12 Issue 2 3 Oct 2011 7 6 Oct 2011 Issue 2 3 2 5 Issue 2 3 Oct 2011 4 13 Issue 2 3 Oct 2011 7 7 Oct 2011 Issue 2 3 2 6 Issue 2 3 Oct 2011 4 14 Issue 2 3 Oct 2011 7 8 Oct 2011 Issue 2 3 2 7 Issue 2 3 Oct 2011 4 15 Issue 2 3 Oct 2011 7 9 Oct 2011 Issue 2 3 2 8 Issue 2 3 Oct 2011 4 1
20. PROCEDURES 4 2 Wing Assembly Procedure The following instructions apply to the Cruze and Streak and Merlin wings The sequence of procedures assumes that the wing is packed up If the wing and base were already assembled this section is not required 4 2 1 Wing Assembly Procedure Your instructor should demonstrate the correct assembly and disassembly procedures for your microlight This section is intended as a reference only and assumes prior knowledge of assembly AirBorne trike wings should be assembled standing on the control frame Assembling the wing on the control frame keeps the sail off the ground and therefore less prone to being soiled or damaged The suggested assembly procedure is as follows UNZIP THE BAG Lay the wing down with the zip up and the nose facing approximately 120 degrees from the wind direction Unzip the bag but do not completely remove it from the wing Undo centre 2 clips 4 2 2 Assemble Control Frame Remove control bar and down tube padding Spread the control bar down tubes out and insert the base bar onto the alloy knuckle The pip pin is then inserted from front to back Ensure that the pip pin end cap is secure It should not be possible to remove the cap without depressing the pip pin button Check that all the rigging wires are outside the control frame Figure 1 Section 4 Assemble Control Frame Optional If training bars are to be fitted to the control frame follow this procedure The left h
21. Performance at MTOW Australian European USA Cruise Speed 55 kts 101 km hr 63 mph Typical Fuel Burn 9 Cruise See Note 15 It hr 15 It hr 4 0 gal hr Range Cruise 444 km 444 km 275 miles Table 17 Section 5 Cruze Cruise Performance 5 7 2 XT 582 Cruze Performance at MTOW Australian European USA Cruise Speed 50 kts 92 km hr 57 mph Typical Fuel Burn Cruise See Note 14 It hr 14 It hr 3 7 gal hr Range Cruise 433 km 433 km 269 miles Table 18 Section 5 Cruze Cruise Performance 5 7 3 XT 582 Merlin Performance at MTOW Australian European USA Cruise Speed 47 kts 87 km hr 54 mph Typical Fuel Burn 9 Cruise See Note 14 It hr 14 It hr 3 7 gal hr Range 9 Cruise 407 km 407 km 253 miles Table 19 Section 5 Merlin Cruise Performance NOTE Fuel consumption figures are included as a guide only The consumption figures should not be used for planning purposes Changes in aircraft configuration load altitude wind strength and direction as well as climatic conditions will cause significant variation in fuel consumption October 2011 Issue 2 3 Page 6 AirBorne WindSports Pty Ltd SECTION 6 Aircraft Operating Instructions Edge XT 582 WEIGHT BALANCE amp EQUIPMENT WEIGHT BALANCE AND EQUIPMENT WEIGHT BALANCE AND EQUIPMENT 6 WEIGHT BALANCE AND EQUIPMENT 6 4 General 6 2 Aircraft Weight 6 2 1 Aircraft Weighing Information 6 2 2 Standard Equipment 6 2 3 Alternate Equipment 6 2 4 Optional Equipment 6 3 Typical Aircra
22. Stall Speed MTOW Stall Speed 320 kg TOW Table 11 Section 5 Cruze Stall Speeds 5 5 2 XT 582 Cruze Performance Stall Soeed MTOW Stall Soeed 320 kg TOW Table 12 Section 5 Cruze Stall Speeds 5 5 3 XT 582 Merlin Performance Stall Speed MTOW Stall Speed 320 kg TOW Table 13 Section 5 Merlin Stall Speeds 5 6 Glide Metric 35 kt 29 kt Metric 34 kt 28 kt Metric 34 kt 28 kt Glide figures have been determined with the engine off at maximum take off weight with the trimmer set in the fast configuration 5 6 1 XT 582 Streak 2B Performance 45 kts at MTOW Descent Rate Descent Gradient Glide Distance from 1000ft AGL Table 14 Section 5 Cruze Glide 5 6 2 XT 582 Cruze Performance 45 kts at MTOW Descent Rate Descent Gradient Glide Distance from 1000ft AGL Table 15 Section 5 Cruze Glide Metric Imperial 3 15 m s 621 ft m 14 4 14 4 2 1 km 1 3 miles Metric Imperial 3 0 m s 597 ft m 1496 1496 2 2 km 1 4 miles October 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 5 Aircraft Operating Instructions Edge XT 582 PERFORMANCE 5 6 3 XT 582 Merlin Performance 45 kts at MTOW Metric Imperial Descent Rate 3 15 m s 621 ft m Descent Gradient 14 496 14 496 Glide Distance from 1000ft AGL 2 1 km 1 3 miles Table 16 Section 5 Merlin Glide Glide data is for ISA conditions Sea Level at 15 deg C 5 7 Cruise Performance 5 7 1 XT 582 Streak 2B
23. The XT Tundra version has a cockpit with the inclusion of the larger Tundra tyres The tundra version allows the comfort of the cockpit design with the added advantage of unprepared ground landing ability Larger rear wheel spats are included to improve base yaw stability at higher speeds October 2011 Issue 2 3 Page 6 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL Outback Model The XT Outback has a spacious instrument housing with windscreen for the comfort of the pilot The reduced lateral area of the instrument housing and windscreen with the absence of cockpit allows the use of large open wheels with no fins and tundra tyres for use on unprepared ground 1 1 5 2 Wing The wings are fairly typical of an established class of swept tapered flexible fabric wings with enclosed crossbars and a relatively high aspect ratio The Cruze and Streak sail has several cloth and velcro shear ribs which combined with an excellent sail fit produces a wing that has light handling with impressive feel in turbulence The battens ends are a unique design which can be adjusted to vary tension for tuning the wing The batten mechanism allows easy installation and removal of the battens Clever engineering features fittings that look smart and are positioned to achieve minimum drag The Merlin wing is a state of the art open cross bar design that has been designed to have an unprecedented combina
24. The oil consumption is defined by engine rpm and the lever position The lever is actuated via a Bowden cable connected to the throttle cable The oil injection system has a capacity of 2 litres The nominal oil usage is 50 1 2 which would require 1 4 litres for a full tank of fuel The photo opposite gives an indication of oil levels required for the nominated fuel level The oil tank has a low oil level switch Alarm Level which actuates the alarm on the Skydat instrument However if the oil tank is filled when the fuel tank is filled the low level alarm should never come on The remaining quantity of oil at Alarm Level is 5 00mL when the alarm is actuated which leaves enough oil to find a suitable landing area Figure 25 Oil Level March 2011 Issue 2 3 Page 17 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES WARNING THE OIL INJECTION TANK HOLDS ENOUGH OIL TO LUBRICATE 100 LITRES OF FUEL THE OIL INJECTION TANK SHOULD BE FILLED EVERY TIME THE FUEL TANK IS FILLED Oil Specifications Oil used is Super two stroke ASTM CEC standards API TC classification consult your Rotax dealer for the recommended oil to suit your operating conditions 4 8 Helmet Recommendation The open cockpit of the Edge XT exposes the occupants to the elements during flight and exposes them to objects outside of the aircraft in an emergency situation Helmets and eye prote
25. Warp Drive 3 Blade with Warp Drive hub 67 7 inches 1720 mm diameter Bolly BOS3 68 x 58 Right hand version with BOS 3 hub 68 inches 172 7 cm diameter Engine Propeller Reduction Tip Angle Drive Ratio to plane of rotation 582 UL Bolly 3 47 14 582 UL Warp Drive 3 47 14 Table 1 Propeller pitch and gearbox ratio table The propeller pitch setting and checking procedure is outlined in the Base Maintenance Manual The pitch setting is determined as a part of certification of the aircraft Settings outside this specification have an unknown effect on aircraft performance and are not approved Propeller pitch setting effects engine rpm If the engine exceeds its rpm limits check to see that the propeller pitch is set correctly October 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Operating Instructions Edge XT 582 AIRCRAFT amp SYSTEMS 7 12 Brake System A front wheel drum brake system or an optional rear wheel disk brake system is used on the aircraft Depressing the brake lever on the left hand side of the front footrest actuates the brake on aerotow equipped trikes the aerotow release is the lever on the top left painted yellow A brake lever lock is provided To engage depress foot lever and raise locking lever by hand disengage depress the foot lever Use wheel chocks when leaving the disk brake equipped aircraft unattended for a period of time Worki
26. casa gov au October 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 0 Aircraft Operating Instructions Edge XT 582 AMENDMENT RECORD SHEET Amendment Date Affected Sections Affected Pages Date Inserted Signature Manuals will be revised from time to time and reissue of amended pages will be achieved by sending the pages to the current owner registered on AirBorne s database Amendments will also be available on the Airborne Website http www airborne com au The amended pages should be printed and the prior page replaced in the manual s folder as soon as possible The amendment table should at that time be updated with the appropriate details and date Table 3 Section 0 Amendment Record Sheet October 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 0 Aircraft Operating Instructions Edge XT 582 LOG OF EFFECTIVE PAGES Page Issue Date Page Issue Date Page Issue Date 0 1 Issue 2 3 Oct 2011 2 23 Issue 2 3 Oct 2011 4 31 Oct 2011 Issue 2 3 0 2 Issue 2 3 Oct 2011 2 24 Issue 2 3 Oct 2011 4 32 Oct 2011 Issue 2 3 0 3 Issue 2 3 Oct 2011 3 1 Issue 2 3 Oct 2011 4 33 Oct 2011 Issue 2 3 0 4 Issue 2 3 Oct 2011 3 2 Issue 2 3 Oct 2011 4 34 Oct 2011 Issue 2 3 0 5
27. or pressure limitations are reached the red light will start to flash Standard instrumentation includes the AMPtronics GX2 Digital Flight Instrument see description below and an analogue airspeed indicator in knots WARNING IT IS PROHIBITED TO FLY THIS AIRCRAFT WITH THE AMPTRONIC SKYDAT GX2 ALARM THRESHOLDS SET OUTSIDE THE ENGINE MANUFACTURER S LIMITS 7 15 1 Description of Features The GX2 is a combined avionic instrument with programmable functions The system consists of two parts the display module which is mounted in the dash and the capture module which is located on the engine tie rod The photo shows the layout of the display when set up for the 582 Rotax engine 77703104131 GL OUR WATER TEMPERATURE _ Table 3 Section 7 GX2 Display October 2011 Issue 2 3 Page 7 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Operating Instructions Edge XT 582 AIRCRAFT amp SYSTEMS GX2 Features ASI mph knots or kilometres ALT altimeter in feet or metres RPM engine revolutions per minute VSI vertical speed indicator in m s or ft min Flight duration in hours minutes seconds Air Temperature Battery voltage Water temperature in Celsius or Fahrenheit Engine hours in hours minutes 2X EGT exhaust gas temperature Celsius or Fahrenheit Accumulative fuel in litres or gallons Fuel Flow in litres or gallons Table 4 Section 7 GX2 Features 7 15 2 System Turn On Turn key clockwise to th
28. plug leads locking wires Mast brace PIP pins secure Windscreen XT 880mm secured if fitted Mast over centre latch loaded and secure Vents oil tank fuel tank Pitot entry Mechanical components Rotate propeller clockwise and observe for noise or excessive resistance General inspection of complete trike NEM lt NEM MEM NEM NEM Wing amp base universal bracket secure Back up webbing strap secure Table 6 Section 4 Complete Trike Pre Flight Inspection March 2011 Issue 2 3 Pagel6 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 6 Fuelling Fuel flow is from a single fuel tank fitted with a self venting tube The fuel system is fitted with a shut off valve located on the rear left hand side of the seat frame Be sure this valve is in the ON position before starting engine Never refuel if fuel could be spilled on hot engine components Use only safety approved fuel containers and never transport fuel in an unsafe manner The fuel tank has a water drain mounted at the base and to the rear of the tank The fuel system has an in line fuel WARNING filter which is mounted at the front of the tank This ENSURE THE AIRCRAFT IS EARTHED TO filter can be easily disassembled for cleaning and AVOID STATIC DISCHARGE IGNITING FUEL inspection see base maintenance manual DURING THE
29. recognising a situation where the aircraft is approaching these pitch angles proceed as outlined below 3 3 12 1 Nose High Attitude To recover from the situation where the nose of the aircraft is pitched up more than 45 degrees from the horizontal proceed as follows H Hold attitude Do not attempt to pull control bar in P Reduce Power As energy dissipates the aircraft will rotate nose down keep control bar Out P once the attitude lowers level the wings and increase Power to prevent over pitching R Recover from dive and Resume desired flight path October 2011 Issue 2 3 Page 6 AirBorne WindSports Pty Ltd SECTION 3 Aircraft Operating Instructions Edge XT 582 EMERGENCY 3 3 12 2 Nose Down Attitude To recover from the situation where the nose of the aircraft is pitched down more than 45 degrees from the horizontal proceed as follows Raise attitude push Out P Apply Power R Recover from dive and Resume desired flight path 3 3 13 Instrument Failure Instrument failure may occur through an electrical fault or through exposure to High Intensity Radio Fields HIRF The aircraft is equipped with an analogue ASI as well as a digital engine management system The analogue ASI will not be effected by either an electrical fault or HIRF If there is a problem with the digital system the correct procedure is to fly to the nearest safe landing area and investigate the cause of the malfunction October 2
30. side compression struts Series Edge XT Series Table 24 Section 2 Clear Prop Placard 2 7 21 Shock Absorber Pressure Placard 18mm CAUTION 18mm P No 106397 Location The shock placard is located on the main block near the top of the shock Series Edge XT Series Table 25 Section 2 Shock Absorber Pressure Placard 2 7 22 Right Hand Suspension Strut Placards Figure 6 Section 2 Clear Prop and Fuel Spec Placards October 2011 Issue 2 3 Page 20 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 23 King Post Placard 40MM CHECK ONE WIRE ON EACH SIDE OF KING POST 54 104622 Location The king post placard 1 located on the rear of the keel tube of the wing Series Wings Table 26 Section 2 King Post Placard 2 7 24 Wing and Base Data Plates AIRBORNE WINDSPORTS PTY LTD REDHEAD NSW AUSTRALIA XX XXX ASTM S LIGHT SPORT AIRCRAFT DATE OF MANUFACTURE MM Y Y o MODEL EDGE XT 582 L e SERIAL NO XT 582 NNNN No 107567 WING PLATE PART NO 102358 Location The wing data plate 102358 is located on the negative block of the universal bracket The base data plate 107567 1 located on the seat mast block on the left side of the aircraft Series XT base and applicable wing Table 27 Section 2 Data Plates October 2011 Issue 2 3 Page 21 AirBorne WindSports Pty Lt
31. supply The fuse holder is marked with the correct Current rating for the fuse 3 The battery charging circuit is protected with a 20A fuse which also terminates at the right hand side of the mast block The fuse holder is marked with the correct Current rating for the fuse 10 A circuit breaker 1 located on the right hand side of the dash The circuit breaker protects the dash instrumentation and the DC socket October 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 8 Aircraft Operating Instructions Edge XT 582 HANDLING amp MAINTENANCE 9 1 Parking and Ground Handling Parking and ground handling information can be located in section 4 October 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 8 Aircraft Operating Instructions Edge XT 582 HANDLING amp MAINTENANCE This page left blank intentionally October 2011 Issue 2 3 Page 6 AirBorne WindSports Pty Ltd SECTION 9 Aircraft Operating Instructions Edge XT 582 SUPPLEMENTS SUPPLEMENTS SUPPLEMENTS 9 TRAINING SUPPLEMENT 9 1 582 Flight Training Supplement 9 2 Assembly and Break Down 9 3 Aircraft Operation 9 4 Startup 9 5 Take off 9 6 Cruise and Stalls 9 7 Landing 9 8 Emergency Procedures 9 9 Control Locations amp Operation 9 9 Flight Controls 9 9 2 Engine Controls 9 9 3 Digital Instrument Panel SkyDat GX2 9 10 Aircraft Performance Data 9 11 Training Recommendations 9 11 1 Landing
32. that the front Velcro tabs are folded back and secured to the top of the cover Figure 7 Section 4 Install Pull Back Cover Attach Nose Catch The nose catch should now be attached so that the pip pin is inserted through both the nose catch and channel Ensure the pip pin cap is secure Figure 8 Section 4 Attach Nose Catch March 2011 Issue 2 3 Page 7 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 2 9 Locate Nose Battens Insert both nose battens tail end first Locate the front of the batten on the alloy stubs on the front of the keel tube Figure 9 Section 4 Locate Nose Battens 4 2 10 Install Nose Fairing Attach the nose fairing by applying the top Velcro first then gently tension over the nose plates and attach the Velcro to the undersurface Figure 10 Section 4 Install Nose Fairing 4 2 11 Insert Remaining Main Sail Battens Insert remaining main sail battens at the tips 4 2 12 Insert Undersurface Battens Cruze and Streak 2B wings The undersurface battens should be inserted as far as possible without forcing them The batten should then be pushed with your thumb so that the end is inside the pocket Use the string to pull the batten back to the rear of the pocket Figure 11 Section 4 Insert Remaining Sail Battens March 2011 Issue 2 3 Page 8 AirBorne WindSports Pty Ltd SECTION 4 Aircraft O
33. trike above the receptacle and depress the draincock Ensure that there are no ignition sources and that the fuel is disposed of correctly 8 6 Engine Lubricating Oil Engine lubrication is supplied via the oil injection system which is gravity fed The oil consumption is defined by engine rpm and the lever position The lever is actuated via a Bowden cable connected to the throttle cable The oil injection system has a capacity of 2 litres The nominal oil usage is 50 1 296 which would require 1 4 litres for a full tank of fuel The oil tank has a low oil level switch which actuates the alarm on the SkyDAT instrument However if the oil tank is filled when the fuel tank is filled the low level alarm should never come on The remaining quantity of oil is 500mL when the alarm is actuated which leaves enough oil to find a suitable landing area Oil Specifications WARNING THE OIL INJECTION TANK HOLDS ENOUGH OIL TO LUBRICATE 100 LITRES OF FUEL THE OIL INJECTION TANK SHOULD BE FILLED EVERY TIME THE FUEL TANK IS FILLED Oil used is Super two stroke ASTM CEC standards API TC classification consult your Rotax dealer for a recommended oil to suit your operating environment 6 7 Rotary Valve Lubrication Rotary valve lubrication is supplied via a small tank mounted on the top right hand side of the engine Oil quantity on a new installation is approximately 310mL Before every flight check the oil level approximately mid height of the bottle I
34. 011 Issue 2 3 Page 7 AirBorne WindSports Pty Ltd SECTION 3 Aircraft Operating Instructions Edge XT 582 EMERGENCY This page left blank intentionally October 2011 Issue 2 3 Page 8 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES NORMAL PROCEDURES NORMAL PROCEDURES 4 NORMAL PROCEDURES 4 1 General 4 1 1 XT 582 Streak 2B Speeds for Normal Operation 4 1 2 XT 582 Cruze Speeds for Normal Operation 4 1 3 XT 582 Merlin Speeds for Normal Operation 4 1 4 Normal procedures Check List 42 Wing Assembly Procedure 4 2 1 Wing Assembly Procedure 4 2 2 Assemble Control Frame 4 2 3 Stand The Wing Up 4 2 4 Spread Leading Edges 4 2 5 Insert King Post 4 2 6 Insert Main Sail Battens 4 27 Tension Cross Bars 4 2 8 Install Pull Back Cover 4 2 9 Locate Nose Battens 4 2 10 Install Nose Fairing 4 2 11 Insert Remaining Main Sail Battens 4 2 12 Insert Undersurface Battens 4 2 13 Load Tip Strut Clip Type 4 2 14 Load Tip Strut 32000000 43 Wing Pre flight inspection 10 4 4 Attaching Wing to Base 11 4 4 1 Attach Mast Retaining Strap 11 4 4 2 Position The Trike And Wing 12 4 4 3 Attach Mast To Wing U Bracket 12 444 Position Heart Bolt Retainer in U Bracket 12 4 4 5 Attach Back Up Loop 12 4 4 6 Remove Keel Extension 1 4 4 Rotate Wing 13 4 4 8 Insert Mast Lever 13 4 4 9 Attach Mast Brace 14 4 4 10 Load Mast Lever 1 4 4 11 Instal
35. 1 Centre of Gravity limits 2 6 2 Manoeuvring Limits 2 6 3 Bank Angle 2 6 4 Flight Load Factor Limits 2 6 5 Flight Crew Limits 2 6 6 Kinds of Operation Limits 2 6 7 Fuel Limitations 2 6 8 Maximum Passenger Seating Limits 2 6 9 Minimum Pilot Weight 2 6 10 Other Limitations ONNNNNN DONAAAAAKRHKR HR A 00 Q s 2 7 Placards 10 271 Flight Limitations Placard 10 2 7 2 Dash Placard Locations 11 2 7 3 Aircraft Operating Instructions Placard 11 2 7 4 Wing Vne ASI Placard 12 27 5 Cruze Wing Trimmer Operation Placard 12 2 7 6 Trimmer Placard Location 13 277 Fuel Capacity Placard 14 27 8 Fuel Tap Placard 14 2 7 9 Throttle and Ignition Placard 14 2 7 10 Pilots Right Seat frame Placard 15 2 7 11 Choke Placard 1 2 7 12 Mast Block Placard Locations 16 2 7 13 Pilots Left Seat frame Placards 16 2 7 14 Earth Placard 1 2 7 15 Circuit Breaker and Power Socket Placard 17 2 7 16 Oil Tank Capacity Placard 18 2 7 17 No Step Placard 18 2 7 18 Step Placard 19 2 7 19 Step and No Step Placards 19 2 7 20 Clear Prop Placard 20 October 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 21 Shock Absorber Pressure Placard 1 2 122 Right Hand Suspension Strut Placards 20 2 7 23 King Post Placard 21 2 7 24 Wing and Base Data Plates 21 2 7 25 Emergency Parachute 22 2 7 26 Emergency Parachute Placard Location 22 2 7 27 Emergency Parachute
36. 2 12 Remove Main Sail Battens 1 4 12 13 Remove King Post 31 4 12 14 Fold Leading Edges 1 4 12 15 Attach Straps 32 4 12 16 Fit Wing Bag 32 4 12 17 Roll Wing 32 4 12 18 Disconnect Base Bar 32 4 12 19 Fit Padding 32 4 12 20 Fold Control Frame 33 4 12 21 Position Battens 33 4 13 Transportation and Storage 33 4 14 Noise Characteristics 33 March 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 NORMAL PROCEDURES 4 1 General This section of the AOI describes procedures for normal operations of this aircraft WARNING NO ATTEMPT SHOULD BE MADE TO FLY THE AIRCRAFT WITHOUT APPROPRIATE WEIGHT SHIFT AIRCRAFT FLIGHT TRAINING WITH AN APPROVED INSTRUCTOR 4 1 1 XT 582 Streak 2B Speeds for Normal Operation Trim Speed 49 54 knots Stall Speed at Maximum Take Off Weight 35 knots Take Off Safety Speed amp 49 knots Nominated Approach Speed at MTOW Maximum Speed in Turbulence V 70 knots Maximum Level Speed 80 knots Max wind operating conditions at ground 20 knots level Cross winds of up to 12 knots Table 1 Section 4 Cruze Speeds for Normal Operation 4 1 2 XT 582 Cruze Speeds for Normal Operation Trim Speed 45 50 knots Stall Speed at Maximum Take Off Weight 34 knots Take Off Safety Speed amp 45 knots Nominated Approach Speed at MTOW Maximum Speed in Turbulence V 66 knots Maximum Level Speed 70 knots Max wind operating co
37. 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 3 Aircraft Operating Instructions Edge XT 582 EMERGENCY 3 3 6 On Ground Engine Fire For fire occurring whilst in motion on the ground proceed as follows Maintain Control Use remaining Speed to clear people aircraft and buildings Throttle closed Ignition Off After stopping release seat Belt Release Passenger seat belt Fuel tap off HO Evacuate aircraft 3 3 7 Propeller Damage The indication of propeller damage is usually felt by extreme vibration and lack of thrust WARNING is AT FULL ENGINE REVS THE TIP OF THE C Maintain Control PROPELLER IS SPINNING AT SPEEDS IN T Throttle closed EXCESS OF 650 KILOMETRES PER HOUR EVEN SMALL OBJECTS CAN CAUSE F Fuel tap off SIGNIFICANT DAMAGE TO THE PROPELLER I Ignition off L Forced Landing This problem may be avoided if precautions are taken prior to take off Inspect the strip or ground you are to use as your take off area for sticks rocks or any debris that may be flicked up by the tyres and sucked through the propeller Ensure that all items carried by occupants such as cameras and sunglasses are secured so they are not able to come loose and pass through the propeller 3 3 8 Sail Damage If you encounter damage to the sailcloth during flight the first procedure is to maintain control of the aircraft If the sail damage is not impairing the flight characteristics of the aircraft land at the nea
38. 3 PagelO AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES If the wing has been left fully set up for any period then the following additional checks should be performed Extended set up Wing pre flight inspection The symmetry of the wing batten profile check tubes straight undamaged and without cracks cables undamaged no fraying with secure thimbles swages nuts and bolts secure and locked appropriately All quick release fittings secure Universal bracket undamaged heart bolt and back up strap secure Sail tension settings correctly aligned and symmetrical Battens undistorted and in good condition All sail seams intact with no frayed stitching No tears or nicks in the sail NEM lt Trimmer functional and wires not damaged Table 5 Section 4 Extended Wing Pre flight 4 4 Attaching Wing to Base WARNING THE TRIKE MAST IS FITTED WITH A GAS STRUT TO ASSIST LIFTING THE WING NEVER ALLOW THE MAST TO BE UNLOADED TOO QUICKLY HANDS OR OTHER FOREIGN OBJECTS WILL BE SEVERELY DAMAGED IF CAUGHT BETWEEN THE MAST AND SEAT ENGINE BLOCK The mast has a gas assist strut to assist lifting the wing when the mast is raised To hold the mast in position for wing attachment the mast retaining strap should be routed around the rear steering bracket and over the mast The strap can be adjusted to pull the mast down to the correct heig
39. 5mm PART No 105711 The hand choke placard is located on the left side seat frame adjacent to the hand choke lever Edge XT Series Location Series Table 18 Section 2 Choke Placard October 2011 Issue 2 3 Page 15 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 12 Mast Block Placard Locations Figure 3 Section 2 Fuel Tap Shock Absorber Pressure and Earth Placard Locations 2 7 13 Pilots Left Seat frame Placards Figure 4 Section 2 Choke Placard Location Under Seat Bag Placard in Background October 2011 Issue 2 3 Page 16 AirBorne WindSports Pty Ltd SECTION 2 LIMITATIONS Aircraft Operating Instructions Edge XT 582 2 7 14 Earth Placard 18mm P No 105710 The engine earth placard is located on the rear of the seat mast block on the left side Edge XT Series Location Series Table 19 Section 2 Earth Placard 2 7 15 Circuit Breaker and Power Socket Placard 72mm MASTER SWITCH CIRCUIT BREAKER PUSH TO RESET 72mm P No 105715 The master switch circuit breaker placard is located on the right side dash Edge XT Series Location Series Table 20 Section 2 Circuit Breaker and Power Socket Placard October 2011 Issue 2 3 Page 17 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 16 Oil Tank Capacity Placard 55mm OI
40. 6 Issue 2 3 Oct 2011 7 10 Oct 2011 Issue 2 3 2 9 Issue 2 3 Oct 2011 4 17 Issue 2 3 Oct 2011 8 1 Oct 2011 Issue 2 3 2 10 Issue 2 3 Oct 2011 4 18 Issue 2 3 Oct 2011 8 2 Oct 2011 Issue 2 3 2 11 Issue 2 3 Oct 2011 4 19 Issue 2 3 Oct 2011 8 3 Oct 2011 Issue 2 3 2 12 Issue 2 3 Oct 2011 4 20 Issue 2 3 Oct 2011 8 4 Oct 2011 Issue 2 3 2 13 Issue 2 3 Oct 2011 4 21 Issue 2 3 Oct 2011 8 5 Oct 2011 Issue 2 3 2 14 Issue 2 3 Oct 2011 4 22 Issue 2 3 Oct 2011 8 6 Oct 2011 Issue 2 3 2 15 Issue 2 3 Oct 2011 4 23 Issue 2 3 Oct 2011 9 1 Oct 2011 Issue 2 3 2 16 Issue 2 3 Oct 2011 4 24 Issue 2 3 Oct 2011 9 2 Oct 2011 Issue 2 3 2 17 Issue 2 3 Oct 2011 4 25 Issue 2 3 Oct 2011 9 3 Oct 2011 Issue 2 3 2 18 Issue 2 3 Oct 2011 4 26 Issue 2 3 Oct 2011 9 4 Oct 2011 Issue 2 3 2 19 Issue 2 3 Oct 2011 4 27 Issue 2 3 Oct 2011 9 5 Oct 2011 Issue 2 3 2 20 Issue 2 3 Oct 2011 4 28 Issue 2 3 Oct 2011 9 6 Oct 2011 Issue 2 3 2 21 Issue 2 3 Oct 2011 4 29 Issue 2 3 Oct 2011 2 22 Issue 2 3 Oct 2011 4 30 Issue 2 3 Oct 2011 Table 4 Section 0 Log Of Effective Pages October 2011 Issue 2 3 Page 6 AirBorne WindSports Pty Ltd SECTION 0 Aircraft Operating Instructions Edge XT 582 CONTENTS 1 GENERAL 2 LIMITATIONS 3 EMERGENCY PROCEDURES 4 NORMAL PROCEDURES 5 PERFORMANCE 6 WEIGHT BALANCE AND EQUIPMENT 7 AIRCRAFT amp SYSTEMS DESCRIPTION 8 HANDLING SERVICE AND MAINTENANCE 9 SUPPLEMENTS October 2011 Issue 2 3 Page 7
41. 674 Location The under seat placard is located under the front seat one placard per side beside the start of the zip Series Edge XT Series Table 30 Section 2 Under Seat Placard October 2011 Issue 2 3 Page 23 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS This page left blank intentionally October 2011 Issue 2 3 Page 24 AirBorne WindSports Pty Ltd SECTION 3 Aircraft Operating Instructions Edge XT 582 EMERGENCY EMERGENCY PROCEDURES EMERGENCY PROCEDURES 3 EMERGENCY PROCEDURES 3 General 3 2 Airspeeds for Emergency Operations 32 XT 582 Cruze 3 22 582 Merlin 3 3 Emergency Procedures Check List 3 3 1 Engine Failure on Climb Out 3 3 2 Engine Failure at Height 3 3 3 Power Engine Shutdown In Flight 3 3 4 Forced Landings 3 3 5 In Air Engine Fire 3 3 6 Ground Engine Fire 3 3 7 Propeller Damage 3 3 8 Sail Damage 3 3 9 Emergency Parachute 3 3 10 Ignition Circuit Failure 3 3 11 Spins and Spiral Descents 3 3 12 Unusual Attitudes 3 3 13 Instrument Failure amp NNN N N N October 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 3 Aircraft Operating Instructions Edge XT 582 EMERGENCY 3 EMERGENCY PROCEDURES 3 1 General This section of the AOI describes the procedures to be adopted in the event of an e
42. AIRCRAFT OPERATING INSTRUCTIONS Light Sport Aircraft EDGE XT 582 L CRUZE MICROLIGHT EDGE XT 582 L MERLIN MICROLIGHT EDGE XT 582 L STREAK 2B MICROLIGHT Zt Approved Date 6 October 201 1 Delegate of AirBorne WindSports Pty Ltd Serial No Base Serial No Wing Registration No XT 582 This manual is compliant with the ASTM designation f2457 05 Standard Specification for Required Product Information To Be Provided With Weight Shift Control Aircraft AirBorne WindSports Pty Ltd UNIT 22 30 KALAROO ROAD REDHEAD NSW 2290 AUSTRALIA Phone 02 4944 9199 International 61 2 4944 9199 Fax 02 4944 9395 International 61 2 4944 9395 Email fly airborne com au www airborne com au Copyright AirBorne WindSports Pty Ltd 2007 Part 107630 October 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 0 Aircraft Operating Instructions Edge XT 582 This page left blank intentionally October 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 0 Aircraft Operating Instructions Edge XT 582 AIRCRAFT OPERATING INSTRUCTIONS DETAILS Aircraft Operating Instructions Issued By Date For AirBorne WindSports Pty Ltd Table 1 Section 0 Aircraft Operating Instructions MANDATORY SERVICE BULLETINS AS THE SERVICE HISTORY OF THE AIRFRAME EVOLVES AIRBORNE WILL FROM TIME TO TIME ISSUE MANDATORY SERVICE BULLETI
43. ERFORMANCE 5 PERFORMANCE 5 1 General The performance data in the following section has been computed from actual flight tests with the aircraft and power plant in good condition and using average piloting techniques It should be noted that piloting techniques climatic conditions and aircraft condition will cause significant variation to these performance figures 5 2 Take Off and Landing 5 2 1 Take Off XT 582 Streak 2b Performance at MTOW Metric Imperial Take off Distance to 15 m 50 ft 290m 951 ft Table 1 Section 5 Cruze Take Off 5 2 2 Take Off XT 582 Cruze Performance at MTOW Metric Imperial Take off Distance to 15 m 50 ft 280m 918 ft Table 2 Section 5 Cruze Take Off 5 2 3 Take Off XT 582 Merlin Performance at MTOW Metric Imperial Take off Distance to 15 m 50 ft 235m 770 ft Table 3 Section 5 Merlin Take Off Takeoff distances are specified for Sea Level with Max Take Off Power A level dry runway With short grass Still wind And temperature of 15 deg C The following factors will increase takeoff distance Reduced Power Take Off Higher drag runway surfaces such as wet or long grass Tail wind Uphill takeoff OAT above 15 deg C Runway altitude above sea level The pilot is required to take into account the effect of the above when determining takeoff distance October 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 5 Aircraft Operating Instructions Edge XT 582
44. FELY RECOVERING THE AEROPLANE The BRS emergency parachute system has a double acting firing mechanism The parachute operating handle is fitted with a safety pin and 1 located on the left side of the seat frame This pin should be removed before each flight and the safety pin must be replaced before the pilot alights from the aircraft A force of approximately 15 20 kg pull on the actuating handle is required to activate the BRS rocket motor Emergency procedures for use of the BRS can be found in section 3 3 9 of this manual Additional information including service and maintenance requirements can be found in the BRS manual 7 17 Ignition Switches The ignition switches are located on the lower right side of the seat frame Operation is forward for on and rearward for off When the switches are in the off position the switch shorts the engine coils to earth causing the engine to stop October 2011 Issue 2 3 Page 9 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Operating Instructions Edge XT 582 AIRCRAFT amp SYSTEMS This page left blank intentionally October 2011 Issue 2 3 Page 10 AirBorne WindSports Pty Ltd SECTION 8 Aircraft Operating Instructions Edge XT 582 HANDLING amp MAINTENANCE HANDLING SERVICE AND MAINTENANCE HANDLING SERVICE AND MAINTENANCE 6 HANDLING SERVICE AND MAINTENANCE 8 1 Introduction 8 2 Identification Plate 8 3 Aircraft Documents 8 4 Aircraft Inspection Maintenance and re
45. Generally trim speed allows an adequate margin for landing Set the wing trimmer in the fast trim position 9 8 Emergency Procedures See AOI Section 3 for emergency procedures 9 9 Control Locations amp Operation 9 9 1 Flight Controls The XT 582 has standard WSC flight controls See Section 7 for a complete description of the aircraft and its systems 9 9 2 Engine Controls Control Location and Operation Master Switch turn on for starter and SkyDat Lower right instrument panel Use key to turn instrument panel on See AOI Section 7 6 Starter Button Lower right instrument panel below Master Switch Push button to engage starter See AOI Section 7 6 Choke Lever Left side of pilot mounted to seat frame Push lever down to turn choke on Foot Throttle Right foot above the nose wheel steering bar Ignition Switches Right side of pilot mounted to seat frame Switches moved forward to turn ignition on Hand Throttle Right side of pilot mounted to seat frame above ignition switches Push throttle up and forward to increase power October 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 9 Aircraft Operating Instructions Edge XT 582 SUPPLEMENTS 9 9 3 Digital Instrument Panel SkyDat GX2 See AOI Section 7 16 1 for a complete description fier L FLON A 1057 00 0 9 RECU 018 0 1 JAIR fo GL R EE WATER TEMPERRTURE _ Fi
46. L TANK CAPACITY 0 5 US GALLON 55mm OIL TANK CAPACITY 2 LITRES 32mm SUPER TWO STORE OIL TO ASTM CEC STANDARDS APLTC CLASSIFICATION SUPER TWO STOKE OIL TO ASTM CEC STANDARDS API TC CLASSIFICATION PART 107240 Location The oil tank capacity placard is located on the oil tank on the top left side of the engine Series Edge XT582 Series Table 21 Section 2 Tank Oil Capacity Placard 2 7 17 No Step Placard 55mm 42 TE P No 105718 Location The no step placards are located on the floor of the cockpit either side of the base tube Series Edge XT Series Table 22 Section 2 No Step Placard October 2011 Issue 2 3 Page 18 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 18 Step Placard 30mm 30mm STEP P No 105712 Location The step placard is on the trike base tube at the hinge point for the rear foot rest Series Edge XT Series Table 23 Section 2 Step Placard 2 7 19 Step and No Step Placards Figure 5 Section 2 Step and No Step Placards NOTE There is a symmetrical no step placard on the other side of the pod October 2011 Issue 2 3 Page 19 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 20 Clear Prop Placard 120mm 18mm CLEAR PROP PART No 105716 Location The clear prop placard is located on the right and left
47. LY SOLO FROM FRONT SEAT ONLY PART 107601 PART No 107602 PLACARD ENGINE LIMITS PLACARD ENGINE LIMITS XT582 LSA IMPERIAL XT582 LSA METRIC 62mm AIRBORNE WINDSPORTS Pty Ltd Nawcastio NSW Australia www airborme com au 72mm PART No 107596 Location The flight limitation placards are located on the dash either side of the mast brace Engine limitations placard option of metric 107602 or imperial 107601 Series Edge XT Series Table 11 Section 2 Flight Limitations Placards October 2011 Issue 2 3 Page 10 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 2 Dash Placard Locations Figure 1 Section 2 Flight Limitations Airspeed Circuit Breaker Power Socket and Aircraft Operating Instructions Placard Locations 2 7 3 Aircraft Operating Instructions Placard 110mm THE AIRCRAFT OPERATING INSTRUCTIONS SHALL BE CARRIED WITH THE AIRCRAFT OCCUPANTS MUST BE FAMILIAR WITH INFORMATION NECESSARY FOR SAFE OPERATION PART No 107592 20mm 110mm THIS AIRCRAFT WAS MANUFACTURED IN ACCORDANCE WITH THE LIGHT SPORT AIRCRAFT AIRWORTHINESS STANDARDS AND DOES NOT CONFORM TO STANDARD CATEGORY AIRWORTHINESS REQUIREMENTS PART 109519 PLACARD LSA WARNING AUSTRALIA 20mm Location The hand book placard 107592 is located on the trike dash below the GX2 Instrument The airworthiness placard 109519 is used on Australian LSA and is located below the i
48. Load Factor Limits 2 6 5 Flight Crew Limits Minimum flight crew is person Front Seat October 2011 Issue 2 3 Page 7 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 6 6 Kinds of Operation Limits The aircraft is only to be flown under visual flight rules VFR and the minimum equipment required to operate under VFR conditions are an air speed indicator altimeter and instruments required by the engine manufacturer In Australia when operated at a public aerodrome or on a cross country flight a compass and reliable time piece are required Additional equipment may be required for some overseas operations 2 6 7 Fuel Limitations Maximum Usable Fuel 67 litre 17 7 US Gal Unusable Fuel capacity 3 litre 0 8 US Gal Sump Capacity 500 mL 0 13 US Gal Table 9 Section 2 Fuel Limitations CAUTION SIGHT GAUGE 10 LITRE GRADUATIONS INDICATE TOTAL FUEL NOT USABLE FUEL ZERO USABLE FUEL IS INDICATED WHEN THE FUEL IS LEVEL WITH THE BOTTOM OF THE SIGHT GAUGE 2 6 8 Maximum Passenger Seating Limits One passenger maximum allowed 2 6 9 Minimum Pilot Weight The microlight aircraft must only be flown solo from the front seat Minimum pilot weight flown solo shall not be below 55 kg Maximum power at minimum TOW can cause an abrupt climb rate that if uncorrected may cause a wing attitude of greater than the placarded maximum of 45 degrees Approximately 2 3 of maximum take off power
49. NS WHICH DETAIL ANY CHANGES TO THE MAINTENANCE MANUALS AIRCRAFT OPERATING INSTRUCTIONS OR ANY OTHER DETAILS THAT AIRBORNE DEEMS NECESSARY FOR OWNERS TO BE NOTIFIED OF THE WEB ADDRESS FOR SERVICE BULLETINS IS HTTP WWW AIRBORNE COM AU IT IS THE RESPONSIBILITY OF THE OPERATOR TO KEEP UP TO DATE WITH ANY ROTAX DIRECTIVES THROUGH THE ROTAX WEBSITE October 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 0 Aircraft Operating Instructions Edge XT 582 DATA PACKAGE This issue of the Aircraft Operating Instructions constitutes one part of the complete data package that accompanies the aircraft Following is a list of each of the components which are required e Aircraft Operating Instructions e XT 582 Maintenance Manual e XT 582 Illustrated Parts Catalogue e Wing Maintenance Manual e Wing Illustrated Parts Catalogue Rotax Owners Manual Rotax Maintenance Compact Disk e Radio Manual If Installed e BRS Parachute Manual If Installed Table 2 Section 0 XT 582 Cruze Data Package Certification documentation is held by the aircraft manufacturer Contact Information Airborne WindSports Pty Ltd PO Box 7042 Redhead NSW 2290 Australia Telephone 61 2 49449199 Web address http www airborne com au Or for recovery of the certification documentation should the above contact not be available contact the Civil Aviation Safety Authority of Australia Website http www
50. OCEDURES 4 3 Wing Pre flight inspection The design of the wing is such that junctions not open to view may be reached from zipped inspection panels Start at the nose and move around the wing making the following condition inspections check for damage wear and security Wing pre flight inspection Nose catch nose bolts sail tangs on nose bolts y nose battens Nose cone aligned Leading edge tubing Cross bar hinge junction amp cross bar tubing Centre undersurface zip Sail tip secure and webbing Tip struts Battens secure and pockets free from damage Reflex bridle lines Cross bar tensioner routing and catch Velcro pull back cover Hang point universal bracket amp bolts Control frame tubes hinges knuckles connections Trimmer operation routing pulleys twists Control frame cables fittings amp terminations both ends Junction cross bar amp leading edge Top rigging kingpost located inspection zips gt ee Sail condition inspection tears abrasion stitching amp attachment Sail free from water accumulation General inspection of complete wing Full free movement of the wing when attached to the trike base to be completed before flight see section 4 8 1 Inspect all cables inspect for kinks fraying corrosion y particularly around the NICO press fittings Table 4 Section 4 Wing Pre Flight Inspection March 2011 Issue 2
51. ONS Australian European USA Wing Span 9 97 m 9 97 m 32 7 ft Wing Area 13 4sq m 13 4 sqm 145 sq ft Aspect Ratio 7 4 Wing Weight 49 kg 49 kg 108 lbs Overall Height Control Bar Fwd 3 65m 3 65m 11 9 ft Trike Width 1 91m 1 91 6 3 ft Trike Length 2 8m 2 8m 9 2 ft Wheel Track 1 7m 1 7m 5 6 ft Wheel Base 1 89 m 1 89 m 6 2 ft Trike Height 2 53m 2 53 8 3 ft Cockpit Width 0 7m 0 7m 2 3ft Wing Packed Length 5 6 5 6 18 4 ft Wing Length Short Packed 4 2m 4 2m 13 8 ft 1 1 4 4 XT 582 Outback DIMENSIONS Australian European USA Trike Length 2 76 2 76 9 1 ft Height Trike Base propeller 1 62m 1 62m 5 3 ft Height Minimum Trike Base 1 450 m 1 450 m 4 8 ft Table 1 Section 1 General Dimensions 1 1 5 General Description 1 1 5 1 Base Tourer Model The XT 582 trike base is a two seat in line weight shift controlled aircraft A Rotax 582 two stroke engine producing 65 HP powers the base The layout is typical of this class of two seat trike design with the pilot passenger pod being suspended by a triangular frame hinged from the mast head about the pitch and roll axes to provide for weight shift control The cockpit has a tall windscreen for improved wind deflection and is cut away at the sides to allow for easier pilot access The wide rear 6 inch wheels remain a feature of the XT base but the wheel pants spats have been redesigned and include integrated aerodynamic fins to improve base yaw stability Tundra Model
52. REFUELLING OPERATION The Edge XT series fuel levels are marked on the right side of the fuel tank The fuel levels are marked at 10 litres 20 litres 30 litres 40 litres 50 litres and 60 litres 4 6 1 Fuel Tank Capacity The properties of the fuel tank material cause an increase in capacity after the first 2 to 3 tanks of fuel Initial capacity is 64 litres with the aged capacity 70 litres The fuel level markings have been positioned for the fuel tank capacity at 70 litres 4 6 2 Fuel Quantity A sight gauge is provided on the starboard side of the aircraft visible through the soft side Its purpose is to provide fuel volume measurement for calculation of aircraft weight during fuelling of the aircraft and to provide the pilot with a visual indication of the quantity of the remaining fuel The calibration is valid for the aircraft sitting on level ground and indicates total fuel not usable fuel The trike base assumes various flight attitudes according to weight flight speed and power effecting the indicated value of fuel quantity in flight The useable fuel quantity is selected for the worst case condition of aircraft attitude Zero useable fuel is indicated by the fuel level reaching the bottom of the sight gauge during level flight When the level indicates zero useable fuel the tank contains 3 litres of unusable fuel 4 7 Engine Lubricating Oil Engine lubrication is supplied via the oil injection system which is gravity fed
53. SAFELY YOU MUST MATURELY PRACTICE AIRMANSHIP OPERATIONS OUTSIDE THE RECOMMENDED FLIGHT ENVELOPE SUCH AS AEROBATIC MANOEUVRES OR ERRATIC PILOT TECHNIQUE MAY ULTIMATELY PRODUCE EQUIPMENT FAILURE YOU ARE REFERRED TO THE OPERATING LIMITATIONS IN SECTION 2 OF THIS MANUAL THE SETTING UP AND BREAKING DOWN OF A MICROLIGHT ULTRALIGHT TRIKE POWERED HANG GLIDER TRANSPORTATION AND FLYING WILL HAVE AN EFFECT OVER TIME ON ITS STRUCTURAL INTEGRITY THE AIRCRAFT WILL REQUIRE MAINTENANCE AS OUTLINED IN THE APPLICABLE MAINTENANCE MANUALS LIKE ANY AIRCRAFT SAFETY DEPENDS ON A COMBINATION OF CAREFUL MAINTENANCE AND YOUR ABILITY TO FLY INTELLIGENTLY AND CONSERVATIVELY WE HOPE THAT YOUR AIRCRAFT WILL PROVIDE YOU WITH MANY HOURS OF SAFE AND ENJOYABLE FLYING 1 1 2 Definitions Definitions used in these Aircraft Operating Instructions such as WARNING CAUTION and NOTE are employed in the following context WARNING OPERATING PROCEDURES TECHNIQUES ETC WHICH IF NOT FOLLOWED CORRECTLY MAY RESULT IN PERSONAL INJURY OR DEATH CAUTION OPERATING PROCEDURES TECHNIQUES ETC WHICH IF NOT STRICTLY OBSERVED MAY RESULT IN DAMAGE TO THE AIRCRAFT OR ITS INSTALLED EQUIPMENT NOTE Operating procedures techniques etc which it is considered essential to highlight October 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL 1 2 General Description 11 3 Two View Photos
54. Warning Placard 23 2 7 28 Under Seat Placard 23 October 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 LIMITATIONS 2 1 General The limitations section of this AOI outlines the various operating limitations instrument function and placards necessary for the safe operation of this aircraft engine and standard equipment 2 2 Airspeed Limitations 2 2 0 1 XT 582 Streak 2B Speed KIAS Never Exceed 85 knots Speed Vne Maximum 80 knots Manoeuvring Speed Table 1 Section 2 Airspeed Limitations 2 2 0 2 XT 582 Cruze Speed KIAS Never Exceed 73 knots Speed Vne Maximum 73 knots Manoeuvring Speed Table 2 Section 2 Airspeed Limitations 2 2 0 3 XT 582 Merlin Speed KIAS Never Exceed 66 knots Speed Vne Maximum 66 knots Manoeuvring Speed Va KCAS 74 knots 70 knots KCAS 65 knots 65 knots KCAS 59 knots 59 knots Comments Do not exceed this speed in any operation Do not make full or abrupt control movements above this speed Comments Do not exceed this speed in any operation Do not make full or abrupt control movements above this speed Comments Do not exceed this speed in any operation Limited by Vne Vne is limited by the maximum speed capable of being demonstrated in a dive this results in a Vne less than the nominal Va for nominal 4g loading It is difficult to attain sp
55. all at 450kg MTOW 35 kt 40mph 34 kt 39mph 33 5 kt 38 5mph MTOW 27 7 kt 312kg Glide Ratio 7 2 1 45kt 15 7 1 1 45kt 14 7 2 1 45kt 15 Average Fuel Burn at 15 It hr 4 0 gph 14 It hr 3 7 gph 14 It hr 3 7 gph Cruise Take off from a level grass surface at 1 4 x stall speed and climb to 50 ft with a 1 3 safety factor Landing with front drum brake only 9 11 Training Recommendations The XT 582 handles predictably in all flight regimes so there are no unique training requirements in any area except landing Like all WSC aircraft aerobatic maneuvers are strictly prohibited 9 11 1 Landing Most WSC pilots are unprepared for the speed of the XT 582 s approach to landing As previously stated it is not necessary to pull the control bar in past the trim position unless a considerable amount of turbulence is encountered Fly the final approach at trim speed and flare normally You will notice that the approach is also flatter than most WSC aircraft allowing for a smoother less abrupt flare out to land Merlin approach speeds may be made at trim speed where trim speed is 45 kt and greater October 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 9 Aircraft Operating Instructions Edge XT 582 SUPPLEMENTS End of Aircraft Operating Instructions October 2011 Issue 2 3 Page 6
56. and side training bar attachment is shown in figure 2 illustrating the correct attachment of the bar on the inside of the control frame The detail view shows the sequence of components 1 Bolt head to the inside of the control frame 2 Tube 3 Nylon Washer 4 Down Tube Clamp Both Sides 5 Wing Nut turned until both side of the down tube clamp contact Ensure the training bars are held securely 6 Safety Pin Figure 2 Section 4 LHS Training Bar Attachment Note The attachment to the base bar a PIP pin or bolt secures the training bar to the base bar and also secures the control frame knuckle A longer Pip Pin is necessary for the larger diameter tube of the training bar The welded base bar attachment has been made to be slightly loose for ease of fitment March 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 2 3 Stand The Wing Up Rotate the control frame to the vertical position so that the wing is resting on the control bar Do not attempt to connect the nose catch now Remove the glider bag and unclip all the wing straps Figure 3 Section 4 Stand the Wing Up 4 2 4 Spread Leading Edges Carefully spread both leading edges out half way then spread them both out to the approximate flying position It is essential that the keel and the leading edges are kept in the same plane or damage will result Each wing should b
57. as a reference only and assumes prior knowledge of the break down procedure Further reference for cover positioning can be found in the wing Illustrated Parts Catalogue IPC 4 12 1 Unload Tip Struts Clip Type Push the Tip Strut so that it opens the clip Remove the hook from the sail eyelet Remove the strut Figure 26 Section 4 Detension Tip Strut 4 12 2 Detension Tip Struts Fold the tip struts pushing the hinge joint towards the center of the wing Once the sail end of the strut is inside the undersurface fold the strut forward and towards the tip of the wing and locate on top of leading edge Figure 27 Section 4 Detension Tip Strut March 2011 Issue 2 3 Page 27 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 12 3 Remove Tip Battens Remove outermost three tip battens Unclip pivot beak from threaded end Rotate pivot beak and remove from sail as shown To adjust batten load tension release pivot beak from sail and rotate batten clip See maintenance manual for adjustment details Figure 28 Section 4 Remove Tip Battens 4 12 4 Remove Undersurface Battens Insert finger through string loop and pull batten forward Once the batten is forward pull string down to remove from oval pocket Slide batten rearward until all the way out Figure 29 Section 4 Remove Undersurface Battens 4 12 5 Fit Tip Bags R
58. ates quickly on the main wheels As the aircraft leaves the ground the control bar must be eased back to maintain take off safety speed Maintain your engine in top condition and assume it s going to stop running at any time Leave yourself a way out for an unexpected engine failure CAUTION HIGH ANGLE CLIMB OUTS NEAR THE GROUND SHOULD BE AVOIDED Never fly your aircraft at locations airspeeds altitudes or under any circumstances from which a successful engine off landing cannot be attempted 4 10 6 Climb Initial climb out should be made on full power for maximum take off weight Approximately 2 3 of maximum take off power is considered comfortable for a minimum weight takeoff Take off distance will be WARNING AT LOW ALL UP WEIGHTS THE TAKE OFF CLIMB OUT AT THE TAKE OFF SAFETY SPEED CAN RESULT IN HORIZONTAL PITCH INCLINATIONS IN EXCESS OF THE extended at reduced power Once climb is established power should be reduced to below maximum continuous power of 6800 rpm A PLACARDED 45 DEGREES MAXIMUM THE PILOT MUST BE AWARE OF THIS AND SHOULD KEEP WITHIN THE PLACARDED LIMITATIONS BY LOWERING THE ATTITUDE OR REDUCING ENGINE POWER minimum of take off safety speed should be used At this speed the aircraft would round out nicely into a glide should the engine fail Avoid pitching the nose of the wing up more than 45 degrees to the horizon Very steep climbs are dangerous and can result in a stall followed by a sever
59. ction are recommended for occupants for protection from precipitation strike by insects and birds Helmets are also recommended for risk reduction during an emergency landing of the aircraft The helmets recommended for use in the aircraft are those certified to the EN 966 standard that is applicable to helmets for air sports The standard prescribes tests for penetration resistance shock absorbing properties field of vision and head mobility 4 9 Normal Procedures Check List The following checklists should be used as a reference More detailed procedures are found in the Amplified Procedures section which follows Prior to flight a thorough pre flight inspection of the aircraft should be carried out Details of the pre flight inspection are shown earlier in this section March 2011 Issue 2 3 Page 18 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 9 1 Before Starting Engine Pre Flight Inspection Completed Full free movement of Completed the wing when attached to the trike base Passenger Briefing Completed Safety Belts Secure Helmets Secure Intercom Connection Secure Brakes On Park Intercom Connection Secure Parachute If fitted Remove Safety Pin Table 7 Section 4 Before Starting Engine Check 4 9 2 Starting Engine Park Brake On Fuel Cock Open Hand and Foot Throttle Off Idle Position Key On Instrument On Ignition On Choke On
60. ction in trim speed of 10 15 knots The swage on the trimmer wire is used as a pointer on the trimmer placard During take off and landing the recommended trimmer setting is in the fast trim position It is acceptable to set the trim as far as mid trim position for take off and landing The decal on the control frame upright adjacent to the trimmer knob indicates the trim position There is a slight increase in roll pressures as the trimmer is used to decrease trim speed The aircraft is designed to be stable at trim under all loads with a small increase in trim airspeed as AUW is increased 7 6 Instrument panel The instrument panel consists of an analogue airspeed indicator knots on the left side with the digital GX2 instrument mounted centrally in the dash A power circuit breaker power switch 12V DC outlet and starter button can be found on the right side of the dash a Figure 1 Section 7 Instrument Panel 7 7 Undercarriage System The microlight uses a tricycle undercarriage with a braking system via a nose wheel drum brake unit Oil dampened front shock absorbers are used The rear suspension is a swinging wish bone design in conjunction with a 45mm compression strut which houses an oil pneumatic shock absorber 7 8 Seat Adjustment The front seat backrest on the Edge XT trike has a simple for and aft adjuster on the base tube To adjust the seat backrest forward the following procedure should be adopted
61. d SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 25 Emergency Parachute WARNING EMERGENCY PARACHUTE TO OPERATE 1 KILL THE ENGINE 2 JERK THE ACTVATING HANDLE hard 44mm 3 PROTECT BODY Cover Face Keep Limbs Close SEE AIRCRAFT OPERATING INSTRUCTIONS P No 107603 Location The emergency parachute when installed placard is located on the inside left rear of the cockpit when the optional emergency parachute is fitted When the Outback option is fitted the placard is located on base tube aft of instrument binnacle Series Edge XT Series Table 28 Section 2 Emergency Parachute 2 7 26 Emergency Parachute Placard Location RGENCY PARACH UTE Figure 7 Section 2 Parachute Placard Location Pilots Left on Pod near to Seat Frame October 2011 Issue 2 3 Page 22 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 27 Emergency Parachute Warning Placard NEVER POINT ROCKET TOWARD ANYONE AT ANY TIME ACCIDENTAL ACTIVATION MAY CAUSE DEATH OR SERIOUS INJURY TREAT LIKE A LOADED GUN _ 825 Location The emergency parachute warning placard is located on the parachute rocket at the rear of the aircraft Series Edge XT Series optional fitment Table 29 Emergency Parachute Warning 2 7 28 Under Seat Placard Under Seat Bag 35mm Maximum Load 2 AirBorne Australia P No 106
62. d kinking the flying wires 4 12 21 Position Battens Stow the battens with the curve down at the rear of the glider bag Reattach wing straps so that the control frame and battens are within the leading edge pockets Zip up the wing bag Figure 42 Section 4 Position Battens 4 13 Transportation and Storage The wing must always be transported inside its bag and the bag zip should face downwards to prevent the entry of rainwater During transportation or when stored on slings the wing must be supported at its centre and at two points not more than one metre from each end The padding supplied with the wing must be used to prevent chaffing during transport Supports should be softly padded and any support systems used for transport such as roof racks must use attachment straps that are sufficiently secure to eliminate the possibility of damage from vibration and movement Avoid damage to your wing by using well padded racks As the wing is quite heavy a strong set of racks are required Flat straps should be used for tie downs to avoid damage to leading edge Mylar When transporting the trike base the use of trike and prop covers to protect your aircraft from road grime and idle fingers is recommended Tie the propeller to the trike to stop it from rotating at speed Check that the back of the wing is well clear of the front mast with the trike on the trailer Remember that you have an overhanging load when manoeuvring in tigh
63. e displayed units system will change and be memorized One of these unit systems can be changed from 1 Metric e Altitude in metres with QNH in mbar ASI in km h VSI in m s e Temperatures in Celsius e Fuel consumption in litres h October 2011 Issue 2 3 Page 8 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Operating Instructions Edge XT 582 AIRCRAFT amp SYSTEMS 2 Imperial US e Altitude in ft with QNH in inches of Hg ASI in mi h statute VSI in ft min Temperatures in Fahrenheit Fuel consumption in gal US h 3 Imperial UK e Altitude in ft with QNH in mbar ASI in mi h statute or knots VSI in ft min Temperatures in Celsius Fuel consumption in litres hour The sequence of change is Metric Imperial UK Imperial US Imperial UK ASI in knots NOTE For Australian operations CASA requires the units to be set to Imperial UK with ASI in knots 7 16 Emergency Parachute Optional Equipment NOTE The parachute is optional unless governing body of the country where the aircraft is to be flown requires a parachute WARNING THE BRS EMERGENCY PARACHUTE RECOVERY SYSTEM INSTALLATION HAS BEEN APPROVED BY CASA ON THE BASIS THAT WHILST NOT DEPLOYED IT WILL NOT CAUSE HAZARD TO THE AEROPLANE ITS OCCUPANTS OR GROUND PERSONNEL CASA HAS NOT APPROVED THE SYSTEM ITSELF OR CONSIDERED IN WHAT CIRCUMSTANCES IF ANY IT MIGHT BE USEFULLY DEPLOYED THE SYSTEM HAS NOT BEEN DEMONSTRATED TO BE EFFECTIVE IN SA
64. e kept low to the ground whilst moving forward 4 2 5 Insert King Post Remove king post base padding and plug the kingpost into the socket on the rear most hole of the keel Make sure that the cross bar wires are not twisted and are on either side of the king post Figure 4 Section 4 Insert King Post 4 2 6 Insert Main Sail Battens Remove the battens from the bag Lay out the top surface battens curved in order of descending length toward the tip Place the red battens in the left wing curve forwards and the green battens in the right Insert the top surface battens except for the last three battens Start with the battens closest to the keel The battens are inserted into the pocket with gentle pressure until they meet resistance When securing the battens lift trailing edge push fitting in to sail pocket and rotate fitting downward to lock hinge Figure 5 Section 4 Insert Main Sail Battens March 2011 Issue 2 3 Page 6 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 2 7 Tension Cross Bars Figure 6 Section 4 Tensioning Cross Bar and Shackle Located in Block Pull the webbing handle to tension the crossbars The handle pull back system gives a mechanical advantage of 2 1 Tension until the cross bar wire shackle is located in the quick clip block behind the safety button 4 2 8 Install Pull Back Cover Ensure
65. e on position Press the ON OFF push button of the panel The alarm lamp will flash briefly If the lamp does not flash it should be rectified prior to flight as the flashing lamp indicates an over temperature situation The display will light up prompting you to reset the flight duration to zero by pressing If the fuel flow option is installed to reset the accumulated fuel consumed press After few seconds the different engine measurement indications will be displayed The green LED on the capture module should be continually flashing The preset engine limits can be checked against the limits outlined in section 2 4 2 by noting the position of the larger square bars on the LCD display for the particular gauge Altimeter Adjustment You can adjust the barometric pressure as follows QNE Depress both buttons TJ on the left of the instrument simultaneously to set at 1013mb QNH Depress T to increase altitude pressure Depress J to decrease altitude pressure The pressure display is right under ALT in the center of the altimeter The readout below pressure display is a digital altimeter reading The preset limits can be checked against the limits outlined in section 2 4 2 by noting the position of the larger square bars on the LCD display for the particular gauge Changing System Units At any time with the instrument turned on press and hold simultaneously the two QNH push buttons After a few seconds th
66. e pitching of the nose forward Professional training is required for the correct procedures of unusual attitude recovery WARNING REDUCED POWER TAKE OFFS WILL EXTEND TAKE OFF DISTANCE IT IS THE PILOT S RESPONSIBILITY TO ENSURE THAT THERE IS SUFFICIENT RUNWAY AVAILIABLE TO CLEAR ALL OBSTACLES WHEN CONDUCTING REDUCED POWER TAKE OFFS 4 10 7 Cruise When the desired flight altitude is reached the aircraft may be levelled out and throttle reduced to that required to maintain level flight The hand operated throttle on the right side of the seat frame can be used to set engine rpm Once the hand throttle is adjusted the pressure on the foot pedal may be removed When the hand throttle is actuated increase power can still be achieved with the use of the foot throttle The rpm will always return to the cruise setting when foot pressure is removed If the hand throttle is set a reduction in RPM is not achievable using the foot throttle The hand throttle must be in the off position to achieve low RPM March 2011 Issue 2 3 Page24 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 10 8 Stalls In practice it is only possible to induce a nose down stall of the aircraft in level flight at high take off weights The onset of stall is indicated by a significant increase in control bar loads Recovery from a mild stall is very gentle whether power is on or off Recovery is quick with
67. eeds high enough to reach 4 g loadings in smooth air in these aircraft Table 3 Section 2 Airspeed Limitations October 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 3 Airspeed Indicator markings The standard pressure airspeed indicator on the left side of the dash has multiple red radial markings indicating Vne for the wing base combinations The pilot should be aware of the combination of wing and base and be familiar with the appropriate marking 2 4 Power Plant Limitations 2 4 1 Engine Manufacturer Rotax Bombardier Model Rotax 582 UL DCDI mod 99 2 Stroke Gearbox ratio 3 47 1 2 4 2 Engine Limitations ENGINE LIMITATIONS Metric Imperial ENGINE SPEED Take Off Max 5 mins 6800 rpm 6800 rpm Maximum Continuous 6500 rpm 6500 rpm PERFORMANCE Performance 6500rpm 48 kW 64 4 hp COOLANT TEMPERATURE Maximum 80 deg C 175 deg F Minimum 65 deg C 150 deg F CYLINDER HEAD TEMPERATURE Maximum 150 deg C 300 deg F Minimum 110 deg C 230 deg F EXHAUST GAS TEMPERATURE Maximum 650 Deg C 1200 deg F Maximum 500 Deg C 930 deg F AMBIENT START amp OPERATING TEMPERATURE Maximum 44 deg C 111 deg F Minimum 25 deg C 13 deg F Table 4 Section 2 Engine Limitations October 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 4 3 Fuel Grades FUEL
68. etails Owners registered on AirBorne s database will be notified of any changes to data and directed to the AirBorne web site http www airborne com au for the applicable pages The amended pages should be printed and the replacement pages inserted in the folder as soon as possible The amendment table should at that time be updated with the appropriate details and date Revised pages will be sent by mail if requested from AirBorne WindSports the contact details are at the front of this manual October 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL 1 1 1 Warning Notice WARNING THERE ARE INHERENT RISKS IN THE PARTICIPATION OF RECREATIONAL AVIATION AIRCRAFT OPERATORS AND PASSENGERS OF RECREATIONAL AVIATION AIRCRAFT BY PARTICIPATION ACCEPT THE RISKS INHERENT IN SUCH PARTICIPATION OF WHICH THE ORDINARY PRUDENT PERSON IS OR SHOULD BE AWARE PILOTS AND PASSENGERS HAVE A DUTY TO EXERCISE GOOD JUDGMENT AND TO OBEY ALL ORAL OR WRITTEN WARNINGS OR BOTH PRIOR TO OR DURING USE OF THE AIRCRAFT OR BOTH THE OWNER AND OPERATOR MUST UNDERSTAND THAT DUE TO THE INHERENT RISK INVOLVED IN FLYING A MICROLIGHT ULTRALIGHT TRIKE POWERED HANG GLIDER NO WARRANTY IS MADE OR IMPLIED OF ANY KIND AGAINST ACCIDENTS BODILY INJURY OR DEATH OTHER THAN THOSE WHICH CANNOT BY LAW BE EXCLUDED THE SAFE OPERATION OF THIS AIRCRAFT RESTS WITH YOU THE PILOT WE BELIEVE THAT IN ORDER TO FLY
69. evation of the runway used until the aircraft makes a complete stop An approach to the airstrip may be made with or without power but in either case the airspeed should be maintained above the nominated approach speed During take off and landing the recommended trimmer setting is in the fast trim position It is acceptable to set the trim as far as mid trim position for take off and landing The decal on the control frame upright adjacent to the trimmer knob indicates the trim position The aircraft should be flown on final approach at or above the nominated safety speed The additional airspeed allows for wind gradient and to provide greater controllability in the rough air that may lie close to the ground Maintaining airspeed on final is very important for engine off landings allowing a margin for round out before touchdown The trike is designed to land with the rear wheels touching down slightly before the nose wheel Once firmly on the ground aerodynamic braking may be achieved by pulling in the control bar then applying the front nose wheel brake NOTE In the case of a heavy landing the maintenance manuals for both the wing and the base should be referenced It must be noted that after a hard landing your aircraft must be completely checked 4 10 10 Cross Wind Landing and Take Off Pilots with less experience should avoid landing or taking off in conditions with high crosswind components as skills do not always match the capabil
70. f there is a notable consumption of oil in excess of 1 ccm hr look for a leak If a leak cannot be found consult the Rotax Maintenance Manual Oil Specifications Oil used is Super two stroke ASTM CEC standards API TC classification consult your Rotax dealer for a recommended oil to suit your operating environment 8 8 Gearbox Lubrication The gearbox on the XT582 is inverted and in this configuration requires 400 mL of oil See maintenance manual for further details Oil Specifications Gear oil API GL5 or GL6 SAE 140 EP 85W 140 EP October 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 8 Aircraft Operating Instructions Edge XT 582 HANDLING amp MAINTENANCE 6 9 Cooling System WARNING DO NOT OPEN THE COOLING SYSTEM WHEN THE ENGINE IS HOT SEVERE SCALDING AND OTHER INJURIES MAY RESULT The water level in the overflow bottle should be checked prior to flight The level should be between the low and high mark on the overflow bottle Water cooling system capacity is 4 0 L See maintenance manual for further details Coolant Specification Rotax specifies use of 50 antifreeze concentrate with additives against corrosion and 50 pure water or use of an equivalent premixed coolant AirBorne has had satisfactory results using the brand Nulon Red which is silicate free and is a Mono Ethylene Glycol product containing 1040 gm glycol per litre 8 10 Tyre Inflation The recommended tyre inflation pre
71. ft Weights 6 3 1 Weighing Procedure 6 3 2 Weight Calculator 6 3 3 Metric Fuel Calculator 6 3 4 Imperial Fuel Calculator N N S October 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 6 Aircraft Operating Instructions Edge XT 582 WEIGHT BALANCE amp EQUIPMENT 6 WEIGHT BALANCE AND EQUIPMENT 6 1 General This aircraft must only be flown solo from the front seat aircraft operations may be carried out whilst solo as when the aircraft is flown dual The fuel capacity must always be considered when measuring the AUW of the aircraft Remember that fuel is measured at 0 7 kg per litre and fuel quantity will alter the aircraft s performance during take off and landing fuel volume calculator can be found in section 6 3 2 6 2 Aircraft Weight The table in section 6 2 1 shows the weight of the aircraft as weighed during final Quality Assurance at the factory The following page shows if applicable the options that were included when the aircraft was weighed The empty weight shown below can also be found on the limitations placard on the aircraft dash panel A second issue section is included which allows the weight to be revised if any additional equipment is installed or if the empty weight of the aircraft changes for any reason If the empty weight has changed then revised placards are available from Airborne The weight calculators allow for additional weight to be accounted for 6
72. gnition switch Series Edge XT Series Table 12 Section 2 Hand Book and Airworthiness Placards October 2011 Issue 2 3 Page 11 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 4 Wing Vne ASI Placard AIRSPEED X KNOTS WING 1 STREAK3 85 CRUZE 73 Lex MERLIN 66 80mm AUSTRALIA AirBorne 6536 CDR REV2 29 07 08 PART NO 109310 80mm PART NO 109310 Location The Vne Placard is located on the air speed indicator on the left side of dash Series Edge XT Series Table 13 Section 2 Wing Vne ASI Placard 2 7 5 Cruze Wing Trimmer Operation Placard 180MM 2 INCREASE LILII FL REDUCE 4 CONES Es TRIM SPEED ef nm 4 TRIM SPEED PART NO 107241 Location The wing trimmer operation placard 1 located on the right side control frame down tube adjacent to the trimmer knob The placard is installed so that the Increase trim speed arrow faces downward on the down tube Series Cruze Table 14 Section 2 Wing Trimmer Operation Placard October 2011 Issue 2 3 Page 12 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 6 Trimmer Placard Location Reduce Trim Speed Increase Trim Speed NOTE Ensure that the placard is the correct orientation as shown by the text boxes beside the photograph Streak placard shown in pho
73. gure 2 Section 9 GX2 Display The initial display provides Timer and Cumulative Fuel reset options To reset these counters press the corresponding QNH button After a few seconds the display will change to that depicted above The following primary instruments are provided Instrument Location ASI Top left corner Altimeter Top right corner use up down QNH buttons to adjust barometric pressure RPM engine the propeller is spinning at Lower left slightly less than half this value VSI Lower right Voltmeter Center left between ASI and RPM Hour Meter Center right between ALT and VSI Water Temperature Middle center EGT Exhaust Gas Temp Bottom center October 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 9 Aircraft Operating Instructions Edge XT 582 SUPPLEMENTS 9 10 Aircraft Performance Data See AOI Section 5 for detailed discussion on performance The information provided below is based on standard atmospheric conditions at sea level at Maximum Take Off Weight MTOW Distances are specified for Sea Level with Max Take Off Power A level dry runway With short grass Still wind And temperature of 15 deg C 582 STREAK 2B XT 582 CRUZE XT 582 MERLIN Take off 290m 951 and 280m 918 and 235m 770 and Landing distance over 315m 10337 306m 1004 306m 1004 50 obstacle respectively respectively respectively St
74. he lever down 180 degrees until it is securely loaded Fold the seat back up into position Figure 21 Section 4 Load Mast Lever 4 4 11 Install Windscreen XT 880mm Optional fitment of accessory windscreen extension Remove windscreen from protective cover Press the clip Part 108917 onto the trike mast brace and wrap the hook and loop around the clip and the mast brace Figure 22 Section 4 Secure Windscreen XT 880mm Top March 2011 Issue 2 3 Page 14 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES Locate bottom centre hole of the windscreen on the middle tip and fasten by placing the o ring then the washer then the retaining pin Repeat for the bottom sides note the sides may be a tight fit Below is a photo showing clip side of windscreen o ring washer and retaining clip correctly mounted and attached Inspect the windscreen now and regularly to make sure it is secure Figure 23 Section 4 Secure Windscreen XT 880mm Bottom Clean the windscreen using a soft clean cloth and mild detergent as necessary Wiping the windscreen in one direction only for the life of the windscreen is good practice Nominaly verticaly 4 4 12 Park The Aircraft The aircraft should be parked in a crosswind position with the wings base tube secured to the mast brace with the bungie supplied NOTE The wingtip facing the wind should be lowered
75. height loss of less WARNING NEVER STALL THE AIRCRAFT WITH THE NOSE PITCHED UP BEYOND 45 DEGREES MANOEUVRES BEYOND THIS ARE DANGEROUS AND CAN RESULT IN A TAIL than 50 ft with no tendency to break away suddenly A SLIDE FOLLOWED BY A SEVERE TUMBLE stall would have to be forced violently to induce a danger REFER TO SECTION 3 3 12 OF THIS FLIGHT MANUAL FOR DETAILS OF THE When practising stalls make sure you have sufficient PROCEDURES FOR RECOVERY FROM altitude Push the control bar out so that the airspeed 15 UNUSUAL ATTITUDES reduced at a maximum of 1 knot per second and the aircraft will reach a minimum steady flight speed without dropping a wing The sink rate will increase in this minimum speed mode more than two fold If the airspeed is decreased by rapidly raising the nose the wing will stall Rapid decrease of airspeed in the order of 2 3 knots per second will see an altitude loss of up to 100ft See section 3 3 12 for recovery procedures Never stall with the nose pitched up too high This is a dangerous manoeuvre and can result in a tail slide followed by a severe tumble As a guideline the nose up angle at which the aircraft stalls is about the nose down angle it will recover at 4 10 9 Descent Approach and Landing Landing should always be into wind with a long straight approach The landing distance specified in section 5 is the measured ground distance covered from an approach at 50 feet above the average el
76. ht Figure 14 Section 4 Attach Mast Retaining Strap March 2011 Issue 2 3 Pagell AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 4 2 Position The Trike And Wing Position the wing on its control frame facing into the wind with the nose on the ground The mast tube of the trike should be held down using the strap as described above Check the ignition switches are off Wheel the trike behind the wing rolling the front wheel over the control bar Apply the trike park brake Figure 15 Section 4 Position the Trike and Wing 4 4 3 Attach Mast To Wing U Bracket Allow the main tube to rise by loosening the strap until high enough to connect the universal junction to the wing Insert the bolt with bolt head retaining unit Tighten wing nut firmly and secure safety pin The wing should only be attached using the central hole on the U bracket as shown Remove mast retaining strap Figure 16 Section 4 Attach Wing to Wing U Bracket 4 4 4 Position Heart Bolt Retainer in U Bracket The standard position for the heart bolt in the U bracket is in the centre hole which is the only available point for attachment The heart bolt retainer is positioned in rear open hole to prevent rotation of the bolt Figure 17 Section 4 Heart Bolt Retainer Position 4 4 5 Attach Back Up Loop Connect back up loop so that it passes over the keel and back to the ma
77. ities of the aircraft Crosswind landings or take off with low wind components up to 8 knots are quite safe and controllable even to the inexperienced pilot The nominated approach speed should be increased by 5 knots when landing in cross wind conditions of 10 knots or more March 2011 Issue 2 3 Page25 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES After touchdown in cross wind conditions the relative airflow over the wing will become increasingly span wise from tip to tip as the aircraft slows down The upwind wing tip should be lowered slightly the amount depends on the wind strength and the undercarriage wheels will retain firm contact with the ground Take off procedure is unchanged for the nominated crosswind limit The upward wing may need to be lowered at the start of the take off procedure in higher cross winds 4 10 41 Baulked Landing During a situation where a baulked landing go around is required normal take off power and procedures should be used 4 10 12 Stopping the Engine To stop the engine after a period of running the ignitions should be switched off at idle Switching off at high RPM floods the engine and makes restarting difficult If the engine has been running under full power allow the engine to cool at idle before switching off 4 11 After Landing Securing After landing and when in the parking area apply parking brake and lock Switch
78. l Windscreen XT 880mm 14 4 4 12 Park The Aircraft 15 4 5 Complete Trike Pre Flight Inspection 16 4 6 Fuelling 17 4 6 1 Fuel Tank Capacity 17 4 6 2 Fuel Quantity 17 47 Engine Lubricating Oil 1 4 8 Helmet Recommendation 18 4 9 Normal Procedures Check List 18 4 9 1 Before Starting Engine 19 4 9 2 Starting Engine 19 4 9 3 Before Take Off 20 4 9 4 Off and Initial Climb 20 March 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 9 5 Climb 20 4 9 6 Cruise Speeds 21 4 97 Descent 21 4 9 8 Landing 21 4 9 9 After Landing 21 4 10 Amplified Procedures 22 4 10 1 Before Starting 22 4 10 2 Starting the engine 22 4 10 3 Taxiing 23 4 10 4 Before take off 23 4 10 5 Take Off 24 4 10 6 Climb 24 4 10 7 Cruise 24 4 10 8 Stalls 25 4 10 9 Descent Approach and Landing 25 4 10 10 Cross Wind Landing and Take Off 25 4 10 11 Baulked Landing 26 4 10 12 Stopping the Engine 26 4 11 After Landing Securing 26 4 11 1 De Rigging Procedure 26 4 12 Wing Break Down Procedure 27 4 12 1 Unload Tip Struts Clip Type 27 4 12 2 Detension Tip Struts 27 4 12 3 Remove Tip Battens 28 4 12 4 Remove Undersurface Battens 28 4 12 5 Fit Tip Bags 28 4 12 6 Fit U Bracket Cover 29 4 12 7 Velcro U Bracket Face Cover 29 4 12 8 Trimmer Cover 29 4 12 9 Disconnect Nose Catch and Remove Nose Cone 30 4 12 10 Remove Sail Cowling 30 4 12 11 De Tension Pull Back Cable 30 4 1
79. lexibility in wing tuning see wing Maintenance Manual for tuning instructions IT IS EXTREMELY IMPORTANT THAT THE MAST LEVER IS LOADED CORRECTLY ONCE THE MAST IS RAISED WITH THE WING INSTALLED SEE 4 4 10 FOR FURTHER DETAILS SEE PHOTO OPPOSITE AOI Section 4 3 contains the wing pre flight inspection checklist while AOI Section 4 5 contains the base and engine pre flight checklist Figure 1 Section 9 Mast Cam Lever 9 3 Aircraft Operation Aircraft operation information is contained in AOI Sections 4 8 to 4 10 Section 4 9 covers normal flight operations in checklist form while 4 10 amplify those procedures in detail 9 4 Startup See AOI Sections 4 8 and 4 9 1 2 for engine start up details The master switch should be turned on keyed switch on the panel then depress the SkyDAT on off switch for 3 seconds The instrument display will now power up Ensure that the fuel tap is in the on position and both ignition switches are on Once satisfied that all other checks as outlined in section 4 9 1 2 are complete the starter button on the right side of the dash can be depressed Warm up the engine Minimum temperature should be reached before take off Operate for 2 min at 2000 rpm continue at 2500 rpm until minimum temperature of 50 deg C 140 F is reached 9 5 Take off See AOI Section 4 9 3 5 and 4 10 3 6 Amplified Procedures for take off and climb procedures Many WSC instructors recommend pulling the control bar in to
80. ll open in flight proceed as follows Maintain Control H Get Height With engine at full power adjust height and ground position to improve the outcome of a forced landing A Increase Airspeed to keep the climb angle less than 30 degrees above the horizontal I Switch off Ignition L Prepare for forced Landing 3 3 4 Forced Landings Proceed as follows Helmets tight Limbs arms and hands inside seat frame Maintain Control and airspeed nominated approach speed T Throttle Closed I Ignition off F Fuel tap off 5 Seat belts tight H L L Carry out final approach and Landing as closely as possible to normal power off landing procedure October 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 3 Aircraft Operating Instructions Edge XT 582 EMERGENCY 3 3 5 In Air Engine Fire For fire occurring whilst in flight the initial procedure would be to maintain control of the aircraft and evaluate the extent of the fire This emergency is unlikely to occur but to avoid any further problems use common sense and land the aircraft safely Proceed as follows Maintain Control F Fuel tap off T Full Throttle exhaust engine system fuel as soon as possible and maximise slipstream to clear flames from passengers and airframe When fuel is exhausted then I Ignition off L Forced Landing B After landing release seat Belt P Release Passenger seat belt E Evacuate aircraft October
81. mergency or abnormal situation occurring in this aircraft These procedures are arranged in the sequence considered to be the most desirable in the majority of cases Steps should be performed in the order listed unless a suitable reason to deviate exists This section contains operating procedures for flight and system emergency conditions that are essential for the continued safe operation of the aircraft Always maintain correct airspeed and altitudes in the circuit area Never fly in uncertain weather conditions and always fly within your proven ability Be sure only to extend your capabilities under planned training situations Carry out safe airmanship whilst flying and be aware of possible emergency landing areas along your flight path If possible check these areas from the ground as you enter the airfield or flying site This technique is for safety reasons as engines are susceptible to stopping no matter how reliably manufactured or maintained Keep a good lookout for other aircraft always be thoughtful and show your intentions Demonstrate good airmanship always It should be remembered that the manufacturer cannot foresee all conceivable circumstances Particular circumstances such as multiple or unanticipated emergencies adverse weather etc may require modification to these procedures A thorough knowledge of the aircraft and its systems 15 required to analyze the situation correctly and to determine the best course of action
82. ndard Equipment 6 2 4 Optional Equipment FITTED OPTIONAL EQUIPMENT Yes No BRS Emergency Parachute Radio Intercom Training Bars Disk Brakes Windscreen XT 880mm Table 4 Section 6 Aircraft Weight Optional Equipment 6 3 Typical Aircraft Weights Empty Weight 172 kg crew 403 kg 888 Ib 1 hr Fuel 26 5 litres 19 kg Empty Weight 86 kg pilot 347 kg 765 Ib full fuel 70 litres 49kg Table 5 Section 6 Typical Aircraft Weights October 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 6 Aircraft Operating Instructions Edge XT 582 WEIGHT BALANCE amp EQUIPMENT 6 3 1 Weighing Procedure The wing should be lifted when assembled by routing a webbing strap around the king post top The trike base should be lifted by the suspension point on the top of the mast Prior to weighing ensure that all fuel is drained and all baggage is removed from the aircraft The weight if changed due to option fitment should be recorded as a new issue and dated accordingly in section 6 2 6 3 2 Weight Calculator The weight calculator has been designed to assist in the calculation of maximum allowable fuel so that MTOW does not exceed 450kg The calculator uses the typical empty weight of the microlight as stated above Adjustments must be made if the microlight is not the typical weight i e if additional options are included Instructions Find the intersection of the pilots weight versus the passenger weight pl
83. nditions at ground 20 knots level Cross winds of up to 12 knots Table 2 Section 4 Cruze Speeds for Normal Operation 4 1 3 XT 582 Merlin Speeds for Normal Operation Trim Speed 45 50 knots Stall Speed at Maximum Take Off Weight 33 knots Take Off Safety Speed amp 44 knots Nominated Approach Speed at MTOW Maximum Speed in Turbulence V 66 knots Maximum Level Speed 66 knots Max wind operating conditions at ground 20 knots level Cross winds of up to 12 knots Table 3 Section 4 Merlin Speeds for Normal Operation March 2011 Issue 2 3 Page 3 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 1 4 Normal procedures Check List This section is provided to supply the pilot with more comprehensive information of the normal procedures required to operate this aircraft and is written assuming the pilot has been trained in the assembly and use of a weight shift controlled microlight The ultimate responsibility for determining whether the aircraft is in a safe condition to be flown is with YOU the pilot in command Pre flight inspections are outlined in the following sections and are your responsibility if you are the pilot in command Unlike the highway there is no place to pull over and remedy an unsafe problem once you are airborne March 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL
84. ng Fluid for the Hydraulic Actuated Brake Power transmission fluid Similar to factory supplied fluid Castrol TQ DEXRON III Automatic transmission fluid Fluid quantity see 50 mL Fill level eee 10 mm from top of housing Table 2 Brake Fluid Specifications 7 13 Electrical System An electrical schematic for the aircraft is shown in the diagram on the following page The Electrical circuits comprise e instrumentation circuit The 12 V DC supply is protected by a 15 amp fuse at the battery and a 10 amp circuit breaker mounted on the dash The master switch on the dash when in the off position disables the DC power socket flight instrument and the electric start push button e an engine management circuit and e an ignition circuit It should be noted that the ignition circuit is a fail safe system whereby the engine will run in the event of the ignition circuit becoming disconnected Switching the coil to ground stops the engine When stopping the engine both switches on the side of the seat should be switched off The master switch on the dash should then be turned to the off position to remove supply to the accessories If necessary the motor can be stopped using the chokes as detailed in section 3 3 10 of this issue of operating instructions Refer to the Rotax manual for more details for the engine electrical system October 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Opera
85. ng both leading edges back at the same time or in small steps side to side Roll the sail inwards parallel to the leading edge Attach a strap around one wing Repeat for the other side Fit the keel end pouch Figure 39 Section 4 Fold Leading Edges 4 12 15 Attach Straps Once the leading edges are together apply slight pressure downwards on the keel to raise the leading edges above the down tubes and attach strap around both wings and keel Attach remaining straps so that they are evenly spaced 4 12 16 Fit Wing Bag Position the wing bag to the nose of the wing Stretch bag down the wing to enclose the tips 4 12 17 Roll Wing Hold the wing and down tube and roll the wing onto its back with the control frame to the side 4 12 18 Disconnect Base Bar Depress pip pin button and remove pip pin from base bar Fold down tubes together with base bar folded out Re insert the pip pin Figure 40 Section 4 Disconnect Base Bar 4 12 19 Fit Padding Fit the base bar and down tube covers Velcro the base bar cover in whilst holding the base bar in position Figure 41 Section 4 Fit Padding March 2011 Issue 2 3 Page32 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 12 20 Fold Control Frame Undo centre two wing straps Route flying wires between the down tube and lower the control frame into the wing whilst holding tension on wires Avoi
86. oll sail at the tips inwards and parallel to the leading edge Slide the tip bag over the end of the leading edge The barrel lock unit can be used to tension the bag bungee Figure 30 Section 4 Fit Tip Bags March 2011 Issue 2 3 Page28 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 12 6 Fit U Bracket Cover Unzip undersurface approximately 1 meter to allow better access to fit the U bracket cover Pass the cover up over the keel with the webbing strap facing to the rear of the wing Velcro around each down tube photo shown is a rear view Figure 31 Section 4 Fit U Bracket Cover 4 12 7 Velcro U Bracket Face Cover Position the face cover so that it is facing forward The cover is designed to protect the wing bag when packed photo shown is a front view Figure 32 Section 4 Velcro U Bracket Face Cover 4 12 8 Trimmer Cover Position the trimmer handle so that the handle is at 90 degrees to the down tube with the knob facing forward Fit the trimmer cover Figure 33 Section 4 Trimmer Cover March 2011 Issue 2 3 Page 29 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 12 9 Disconnect Nose Catch and Remove Nose Cone P B Remove the nose cone Disconnect nose catch by removing the pip pin The pip pin button should be depressed with the th
87. on S has been used for certification as a primary category aircraft As an Australian Company we are proud of our range of microlight aircraft Our microlights have been developed to provide the economy and durability required to meet the exacting demands of our Australian conditions The success of our microlights is based upon a high standard of product quality innovative design engineering and exceptional standards of reliability and performance that have been established since 1983 Regular maintenance is required to keep your microlight in a safe condition Detailed maintenance requirements are outlined in the Wing and Base maintenance manuals Please reference these manuals to ensure your microlight is maintained correctly In the USA the FAA registers and administers Light Sport Aircraft The AirBorne Team has developed from the long standing friendship of a group of enthusiasts who share conviction in the intrinsic advantages of weight shift controlled aircraft The AirBorne Team is confident your new microlight will provide you with many years of enjoyable flying and we wish you and your family safe and happy flying for the future The operating procedures outlined in these Aircraft Operating Instructions are the result of AirBorne s knowledge and experience gained since 1983 NOTE AirBorne data packages will be revised from time to time It is therefore important that owners promptly notify Airborne of any changes to their contact d
88. or aerotowing hang gliders or towing advertising banners The Merlin has a high camber sail with higher aspect ratio and reduced sail area in comparison to the Cruze and Streak It is a highly manoeuvrable wing with a slow gentle stall The Merlin has a steady feel in turbulent air expanding the range of conditions that it is comfortable to fly in October 2011 Issue 2 3 Page 7 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL 1 2 Symbols Abbreviations and Terminology In these Aircraft Operating Instructions AOT means Aircraft Operating Instructions Airfield Pressure Altitude or QNE means the altitude of the airfield as indicated on an altimeter with the subscale adjusted to 1013 2 millibars or hectopascals AUW Up Weight means the weight of the aircraft including occupants fuel quantity engine fluids and removable and disposable equipment means the Centre of Gravity Empty Weight Refer to the note at Section 6 2 for the defined empty weight FAA United Stated Federal Aviation Administration fpm means feet per minute HGFA means the Hang Gliding Federation of Australia KCAS means Knots Calibrated Airspeed KIAS means Knots Indicated Airspeed as displayed on the cockpit mounted airspeed indicator kg means weight in kilograms Landing Approach Speed means the airspeed that allows control in turbulence wind gradient o
89. ottle and ignition These controls are readily accessible and you must be able to operate them instinctively without hesitation The primary throttle control is foot operated and complemented by the hand throttle forward for full power and rearward for power off The ignition switches are on the right hand side of the seat frame forward for on and rearward for off Never run the engine on the ground with the propeller turning unless you are doing so in a run up area and can observe anyone or anything entering the danger area It is recommended that the engine not be run for any long periods whilst stationary on the ground Possible WARNING damage to the engine may occur due to overheating of LOCK THE WHEEL BRAKE TO REDUCE ANY the engine fluid POSSIBILITY OF DANGER TO ANY PERSON S DURING ENGINE STARTING Before starting your engine you should read and be familiar with the engine manual Run through the following checklist pronounced twimpfish prior to starting the engine for each and every flight T Throttle full and free movement Tyres inflated and serviceable W Wind check direction and strength Wires secure and airworthy Mixture chokes off Pins fitted and secured Fuel On and sufficient Instruments check set and operational Switches ignition check all switches on Aan at Controls pitch and roll full and free movement Chocks removed secured in aircraft H Harness and Helmet in place and
90. pair 8 5 FuelSystem 8 5 1 Filling Fuel Tanks 8 5 2 Fuel Specification 8 5 3 Fuel Sampling 8 5 4 Checking Fuel 8 5 5 Draining the Fuel 8 6 Engine Lubricating Oil 8 7 Rotary Valve Lubrication 8 8 Gearbox Lubrication 8 9 Cooling System 8 10 Tyre Inflation 8 11 Shock Struts 8 11 1 Rear Shocks 8 11 2 Front Shocks 8 12 Brakes 9 Circuit Breaker and Fuses 9 1 Parking and Ground Handling a R A PRB FP WWW NY NY NH October 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 8 Aircraft Operating Instructions Edge XT 582 HANDLING amp MAINTENANCE 8 HANDLING SERVICE AND MAINTENANCE 8 1 Introduction This section contains factory recommended procedures for proper ground handling and routine care for your aircraft Included in this section is relevant information required by the operator WARNING IT IS THE PILOT S RESPONSIBILITY TO ENSURE THAT ALL AIRWORTHINESS DIRECTIVES HAVE BEEN ADDRESSED IT IS ALSO THE PILOTS RESPONSIBILITY TO ENSURE SERVICING AND MAINTENANCE HAS BEEN PERFORMED AS OUTLINED IN THE APPROPRIATE MAINTENANCE MANUAL AND IN ACCORDANCE WITH THE APPLICABLE AVIATION REGULATIONS 8 2 Identification Plate The aircraft has two identification plates The wing identification plate can be found on the negative plate of the universal bracket The base identification plate can be found on the seat mast block on the left side of the aircraft The Serial number should be quoted
91. perating Instructions Edge XT 582 NORMAL PROCEDURES 4 2 13 Load Tip Strut Clip Type Insert the tip strut into the batten pocket There is a strut each for the left side and right side When holding the strut with the clip end toward you and with the clip hook facing up the white clip should be outboard and then rotate toward the keel to tighten The left hand side is pictured as a guide The struts are floating and do not locate at the front other than by sliding them into their pockets Locate the hook in the sail eyelet by moving the trailing edge onto the batten hook Close the clip along the shaft gently but firmly Figure 12 Section 4 Load Tip Strut 4 2 14 Load Tip Strut Reach in through the tip and feed the end of the strut out through the undersurface and locate on red webbing Pull on the bracket in the center of the strut until the strut over centers Position hand so that it will not get caught in lever mechanism Note that the photo shows the undersurface undone for improved clarity of operation Figure 13 Section 4 Load Tip Strut You are ready for the wing pre flight inspection It is imperative that you carry out this inspection every time you rig and before you fly CAUTION ONCE THE WING HAS BEEN PRE FLIGHTED CHECK THAT ALL INSPECTION ZIPS ARE FULLY CLOSED March 2011 Issue 2 3 Page 9 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PR
92. plant and cockpit The engine is mounted to the engine platform at the base of the engine A long range fuel tank is mounted beneath the engine platform The pilot cockpit is designed to allow for various size pilots The standard instruments used on the XT are a Skydat GX2 and additional analogue airspeed indicator in knots The cockpit has soft sides attached to the pod and encloses the trike base tube and most of the fuel tank The maximum tyre pressure is 30 psi 205 kPa and optimum pressure for general operations is 15 psi 103 kPa 7 3 Flight Controls Flight controls are as follows o Control bar move right Left turn o Control bar push out Pitch up o Push right toe Throttle open o Hand throttle forward Throttle open o Tighten trim cable Slow trim October 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Operating Instructions Edge XT 582 AIRCRAFT amp SYSTEMS 7 4 Ground Flight Control Ground Controls are as follows o Push left pedal Taxi steering right o Push Left Toe Brakes on o Ignition switch forward Switch on o Choke forward Choke on o Fuel Tap Aligned with tap body Fuel on 7 5 Trimmer operation The Cruze trimmer system if applicable allows in flight trim adjustment by rotating the trimmer wheel on the right downtube Rotation of the trimmer wheel clockwise raises the reflex bridles causing extra reflex in the root section of the wing This causes a redu
93. r sudden engine failure during landing Manoeuvring Speed means the indicated airspeed above which the pilot may not make full or abrupt control movements QNH means the pressure setting that if set on the subscale of a sensitive altimeter will cause the altimeter to indicate the correct local altitude above mean sea level RAA means the Recreational Aviation Australia Stall Speed means the indicated airspeed at which an uncontrolled downward pitching motion of the aircraft occurs or the forward control bar limit is reached Take Off Safety Speed means the airspeed that allows control in turbulence wind gradient or sudden engine failure during the climb following take off Trim Speed means the indicated airspeed at which the aircraft remains in a stabilised condition without pilot input V4 means the aircraft design diving speed means maximum level speed Vye means the indicated airspeed that the aircraft is never to exceed October 2011 Issue 2 3 Page 8 AirBorne WindSports Pty Ltd SECTION 1 Aircraft Operating Instructions Edge XT 582 GENERAL 1 3 Use of metric imperial units This AOI uses the metric unit system as the basic system of measurement Where common usage or available instrumentation refer to the Imperial system both units are quoted The following conversion factors are presented as a ready reference to the conversion factors that have been used in this manual
94. removed 5 n eH Deploy parachute L Forced Landing 3 3 10 Ignition Circuit Failure The Rotax engine requires a short circuit on the ignition circuit to stop the engine If the ignition circuit is broken using full choke to flood the engine should stop the engine It is possible to starve the engine by switching the fuel tap off This method is not as quick as using the chokes Do not restart the engine until the fault has been fixed 3 3 11 Spins and Spiral Descents Deliberate spinning is prohibited A spiral dive may develop after a stall if the bar is maintained at the forward limit and a large roll rate is allowed to develop If this condition is not corrected it will lead to large and increasing roll attitudes beyond the 60 degree limit Increasing attitude increasing speeds and large control bar feed back forces will occur Incipient spiral dives can be terminated at any time by rolling wings level If the spiral dive is allowed to develop to extreme roll attitudes recovery is expedited by relieving control bar forces before rolling wings level and recovering from high speed condition 3 3 12 Unusual Attitudes WARNING DO NOT ATTEMPT TO SPIN THE AIRCRAFT SPIRAL DIVES SHOULD NOT BE ATTEMPTED DURING DESCENDING TURNS AIRCRAFT ATTITUDE MUST BE KEPT WITHIN PLACARDED PITCH ROLL AND AIRSPEED LIMITS Unusual attitudes where the nose is raised or lowered more than 45 degrees from the horizontal are to be avoided On
95. rest landing field to inspect the damage 3 3 9 Emergency Parachute The emergency ballistic parachute can be fitted as an option The parachute operating handle is fitted with a safety pin This pin should be removed before each flight and the safety pin must be replaced before the pilot alights from the aircraft A force of approximately 15 20 kg pull on the actuating handle is required to activate the BRS rocket motor The parachute is only to be used in emergency situations WARNING as a last resort and when you are certain that IT IS IMPORTANT TO REALISE THAT WHILST THE PARACHUTE CONTROLS THE RATE OF e the aircraft has suffered structural damage to DESCENT THE PILOT WILL HAVE NO extent that control is not possible or CONTROL OVER THE PLACE THE AIRCRAFT e if the aircraft is in an irrecoverable situation WILL LAND where structural damage is likely to occur To operate the parachute pull the handle at least twenty centimetres for the parachute rocket projectile to be activated The parachute will allow the complete aircraft to be lowered to the ground The aeroplane will descend with a steep nose down attitude and tilted to the left Further information can be found in section 7 16 October 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 3 Aircraft Operating Instructions Edge XT 582 EMERGENCY Proceed as follows Throttle closed Ignition off Seat belts tight Check parachute Pin
96. rication The gearbox on the XT 582 is inverted and in this configuration requires 400 mL of oil See maintenance manual for further details Oil Specifications Gear oil API GL5 or GL6 SAE 140 EP or 85W 140 EP 2 4 6 Cooling System WARNING DO NOT OPEN THE COOLING SYSTEM WHEN THE ENGINE IS HOT SEVERE SCALDING AND OTHER INJURIES MAY RESULT Water cooling system capacity is 4 0L See maintenance manual for further details October 2011 Issue 2 3 Page 5 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS Coolant Specification Rotax specifies use of 50 antifreeze concentrate with additives against corrosion and 50 pure water or use of an equivalent premixed coolant AirBorne has had satisfactory results using the brand Nulon Red which is silicate free and is a Mono Ethylene Glycol product containing 1040 gm glycol per litre 2 4 7 Propeller Manufacturer Bolly Propellers Model BOS3 68 x 58 SR Type 3 Blade Composite ground adjustable Diameter 1727mm 5mm Pitch Standard pitch is an angle of 19 0 5 degrees at a radius of 24 inches The maximum propeller speed of 1960 RPM has been determined by test The maximum propeller speed occurs when the engine RPM reaches 6800 RPM 2 4 8 Engine Instrument Markings The GX2 instrument has preset alarm limit thresholds If any of these temperature or pressure limitations are reached the red light on the ins
97. rop should not exceed 300 rpm Both ignitions should be in the on position and ignition two should be turned off and the RPM drop should not exceed 300 rpm Ensure both switches are in the on position after ignition circuit testing During take off and landing for the Cruze wing the recommended trimmer setting is in the fast trim position It is acceptable to set the trim as far as mid trim position for take off and landing The trimmer decal on the control frame upright adjacent to the trimmer knob indicates the trim position March 2011 Issue 2 3 Page23 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 10 5 Take Off AirBorne trike wings have a neutral static balance allowing a safe take off that is controllable under all suitable flying conditions Take off should be made on full power with only the foot activated throttle used during take off The take off run is the measured ground distance covered until the aircraft reaches a height of 50 feet above the average elevation of the runway used Refer to Section 5 for details of takeoff performance During the takeoff run the wing should be held in the trim position with the wings level Accelerate smoothly to the take off safety speed If the aircraft is fully loaded you will require full power When the aircraft reaches the take off safety speed the control bar should be pushed steadily forward until the trike lifts and rot
98. secure Remember that the pilot in command has the ultimate responsibility for the airworthiness of the aircraft in which they fly 4 10 2 Starting the engine All controls should be checked with the ignition OFF Passengers should have seat belts secure and be briefed for the flight The engine should be started with the pilot in the front seat The following procedure should be Ne CAUTION e Park brake is locked in the on position REMEMBER CLEAR PROP e Fuel cock open March 2011 Issue 2 3 Page22 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES e Hand and foot throttle off e Turn key switch and power up instrument e Switch both ignitions ON e Apply full choke unless the engine is hot e Check visually that the propeller area is clear and call Clear Prop out loud e Depress start button If the engine refuses to start switch off the ignition before investigation e When the engine starts increase the engine RPM to a little above idle and release the chokes e Warm up the engine Minimum Temperature should be reached before take off Operate for 2 min at 2000 rpm continue at 2500 rpm until minimum temperature of 65 deg C is reached WARNING NEVER LEAVE YOUR AIRCRAFT UNATTENDED WHILE THE ENGINE IS RUNNING Keep an aircraft log and enter any unusual engine behaviour Do not fly unless you have corrected a given problem and recorded the correction in the log 4
99. soline lead free min RON 90 Optional Fuel Type AVGAS see note Table 1 Section 8 Fuel Specification NOTE Due to higher lead content in AVGAS deposits in the combustion chamber will increase Therefore use AVGAS only if you encounter problems with vapour lock or if the other fuel type is not available Use of AVGAS requires higher frequency maintenance intervals If AVGAS is used the Rotax web site should be referenced for maintenance requirements Refer to section 2 12 for fuel capacities and limitations October 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 8 Aircraft Operating Instructions Edge XT 582 HANDLING amp MAINTENANCE 8 5 3 Fuel Sampling There is a draincock on the base of the fuel tank at the left hand side which may be used to check the quality of the fuel and to drain fuel if necessary it is especially important to remove any water that may have been introduced from the system 8 5 4 Checking Fuel The fuel is checked for water and contaminants by draining a sample of the fuel into a clear glass container Once a sample has been taken the quality of the fuel can be checked by looking for any water at the bottom of the glass and checking for any other visual contaminants If the fuel has been sitting for an extended period without use it is advisable to replace it with fresh fuel 8 5 5 Draining the Fuel Ensure that a suitable receptacle is found for the fuel that 1s to be drained position the
100. ssures are 13 to 17 PSI 19 to 117kPa for both the front and rear tyres When checking the tyre pressures the opportunity should be taken to examine the tyres for wear cuts bruises slippage and other defects 8 11 Shock Struts 8 11 1 Rear Shocks WARNING SPECIALISED PUMPS MUST BE USED FOR THE AIR SHOCKS PRESSURES UP TO 600 PSI EXIST The rear shocks are pressurised to 580 psi using a schrader valve system A special pump will be necessary to repressurise the rear shocks to the correct setting There should be no reason why the rear shock would need to be reinflated and if they do then a proper investigation of the cause should be undertaken 8 11 2 Front Shocks The front shocks should be inflated to 50 psi for each reservoir The top should be inflated first Turn the rebound damper fully clockwise and then anticlockwise for twelve clicks 8 12 Brakes Details of brake bleeding and other required maintenance of the braking system can be found in section 32 40 00 in the maintenance manual 9 Circuit Breaker and Fuses The fuses for the electrical equipment are located in two positions 1 The Lynx intercom system has a 1 5A fuse screwed into the side of the box where the headsets and push to talk cables are plugged in 2 The power supply cables for the radio are protected at the rear of the aircraft with inline fuses which terminate at the right hand side of the mast block A 5A fuse is to be used for the radio and intercom power
101. st Ensure safety pin is installed March 2011 Issue 2 3 Pagel2 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 4 4 6 Remove Keel Extension Disengage the brake of the trike lift the nose of the wing to allow the front wheel to be rolled rearward over the control frame so that the base bar is forward of the cockpit Re engage the brake Remove the keel extension by removing safety ring and pulling out the clevis pin Remove keel extension Store with pack up gear Figure 18 Section 4 Remove Keel Extension 4 4 7 Rotate Wing Figure 19 Section 4 Rotating Wing 4 4 8 Insert Mast Lever NORMAL PROCEDURES Go to the nose of the wing and with the mast brace tube in one hand and the control bar in the other lift the base bar Rotate the wing until the rear of the keel rests on the mast In strong winds maintain a firm grip on the wing Insert the lever so that the flat section is facing toward the mast March 2011 Issue 2 3 Page 13 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 4 9 Attach Mast Brace Bring mast brace into position and allow the outer sleeve to slide into position Install the top pip pin and cap Install lower pip pin and cap Figure 20 Section 4 Insert Mast Lever 4 4 10 Load Mast Lever Once the lever is located correctly rotate t
102. t places Store the wing in a dry room off the ground air the wing out regularly to avoid mildew and never store wet See your Rotax Manual for precautions to be observed if you intend to store the aircraft without use for extended periods 4 14 Noise Characteristics Noise levels to be advised March 2011 Issue 2 3 Page33 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES This Page Intentionally Left Blank March 2011 Issue 2 3 Page34 AirBorne WindSports Pty Ltd SECTION 5 Aircraft Operating Instructions Edge XT 582 PERFORMANCE PERFORMANCE PERFORMANCE 5 PERFORMANCE 5 General 5 2 Off and Landing 5 2 1 Take Off XT 582 Streak 2b 5 2 2 Off XT 582 Cruze 5 2 3 Take Off XT 582 Merlin 5 2 4 Landing XT 582 Streak 2B 5 2 5 Landing XT 582 Cruze 5 2 6 Landing XT 582 Merlin 5 3 Climb 5 3 1 XT 582 Cruze 5 3 2 XT582 Cruze 5 33 XT 582 Merlin 5 4 Airspeed Calibration 5 5 Stall Speeds 5 5 1 XT 582 Streak 2B 5 5 2 582 Cruze 5 5 3 XT 582 Merlin 5 6 Glide 5 6 1 XT 582 Streak 2B 5 62 582 Cruze 5 6 3 XT 582 Merlin 5 7 Cruise Performance 5 7 1 XTS582 Streak 2B 5 7 2 XT 582 Cruze 5 7 3 XT 582 Merlin DODD OOC10101 ana A AAAA N N October 2011 Issue 2 3 Page 1 AirBorne WindSports Pty Ltd SECTION 5 Aircraft Operating Instructions Edge XT 582 P
103. the ignition electrical switch and radio equipment off The aircraft should be parked in a crosswind position with the base tube secured to the mast brace with the bungie supplied The emergency parachute safety pin should be inserted before leaving the aircraft 4 11 1 De Rigging Procedure Careful attention to the recommended rigging and de rigging sequences will protect the aircraft from the risk of unnecessary damage The de rigging procedure is a direct reversal of the rigging procedure A summary of the procedure follows 4 11 1 1 Remove Wing from Base See section 4 Attaching Wing to Base and use reverse procedure e Apply park brake e Remove pip pins from the front support compression tube Slide outer mast brace up and insert pip pin through lower hole this will secure the inner and outer tubes for the lowering phase e Unload and remove over centre latch e Lower the wing until the control bar is on the ground e Secure mast with strap to base tube e Unbolt the trike from the U bracket remove safety loop and wheel out the trike unit e Reinstall keel extension tube March 2011 Issue 2 3 Page26 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 12 Wing Break Down Procedure This section assumes that the wing has been removed from the base The wing should have the keel extension fitted with the clevis pin and ring installed This section is intended
104. thods of operation where appropriate Information on the aircraft flight controls is detailed in this section but it is mandatory that you receive professional training prior to any solo flight It is illegal to operate this aircraft in Australia without a licence issued by the HGFA or RAA 7 2 Airframe Wing The wings are high performance wire braced weight shift controlled microlight wings The airframe 1 constructed from 6061 T6 multi sleeved aluminium tubing The multi sleeved leading edge construction is 63 5 60 0 and 57 0 mm tube This large diameter construction designed along with the sail luff curve acts to preload the leading edge and maximise trailing edge tension throughout the speed range The sail is constructed using latest technology from the sail making industry The leading edge is constructed using a PX 20 Mylar cloth The main sail cloth is 6 oz Dacron with a Mylar insert in leading edge pocket A trailing edge band provides minimum stretch when loaded that not only gives long sail life but also improves the top speed by controlling twist AirBorne wings are load tested in excess of 2450 kg Excellent engineering contributes to the relatively lightweight of 50 kg Base Attached to the wing by way of a universal joint is the trike base The universal joint allows the free movement of the trike base in pitch and roll by which control is effected The trike base includes the characteristic tricycle undercarriage power
105. ting Instructions Edge XT 582 AIRCRAFT amp SYSTEMS 7 13 1 XT 582 Electrical Schematic BLUE BLUE WIRING LOOM GREEN BLACK WHITE BLACK BLACK BLACK WHITE BLACK BLACK WHITE GREEN WIRING LOOM GX2 DISPLAY MODULE SEE SECT 3 5 FOR DETAILS TEST 2 5 TEST 3 4 jo a3 RECTIFIER B 8 REGULATOR OUTPUT INTERCOM SYSTEM TEST 10 11 1 XOVIS MOTIBA GREEN YELLOW CIRCUIT 289 uo 10N MOTISA BLACK O gt lt D LC PUSEABLE TEST 1 1 FUSE TEST 13 14 BROWN TEST6 YELLOW YELLOW RED WIRING LOOM TEST 1 FUSE WHE WHITE J vine WHITE WIRING LOOM STARTER E MOTOR SOLENOID BROWN BROWN pie BROWN e 8 E BROWN WIRING LOOM 8 2 2 2 a TEST 7 8 POWER 6811 T0W Figure 3 Section 7 Electrical Schematic October 2011 Issue 2 3 Page 6 AirBorne WindSports Pty Ltd SECTION 7 Aircraft Operating Instructions Edge XT 582 AIRCRAFT amp SYSTEMS 7 14 Pitot Static System and Instruments The pitot static system supplies ram air pressure to the air speed indicator from the nose of the cockpit The static pick up is at the rear of the instrument under the dash 7 15 GX2 Instrument Function The GX2 instrument has preset alarm limit thresholds If any of the temperature
106. tion of stability in turbulence and manoeuvrability at low speeds The Merlin retains many of the features of the Streak and Cruze series wings with further emphasis on simplicity 1 1 5 3 XT 582 Cruze The Streak 2 B wing is a continued refinement of the Streak series It was developed from the Streak 3 wing with trim speeds reduced to suit the smaller Rotax 582 engine 1 1 5 4 XT 582 Cruze The Cruze wing was developed as an intermediate wing with lower stall speed and lower top speed Additional sail area has been added to the tip of the wing with a reduction in the sail luff curve The result of the XT 582 coupled with the Cruze is a very stable wing with a softer feel than that of the Streak wing The Cruze wing is a good all round wing with lower top speed than the Streak 3 The stall speed is also lower with shorter take off and landing distance required 1 1 5 5 XT 582 Merlin The Merlin wing was developed to expand the low speed performance capability of the XT microlight At high wing loadings the take off landing and stall speed performance is improved over that of the Cruze wing however at lighter wing loadings the Merlin truly excels The Merlin is a superb slow speed wing with wide speed range a lower top speed than the Cruze wing and maintains cross country flying capability The slow speed allows for landing the Tundra and Outback version trikes on soft sandy terrain or unprepared landing fields The Merlin wing is ideal f
107. to Figure 2 Section 2 Trimmer Placard Location October 2011 Issue 2 3 Page 13 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 7 Fuel Capacity Placard 55mm 57mm FUEL TANK CAPACITY FUEL TANK CAPACITY 70 LITRES 18 5 US GALLON E RECOMMENDED FUEL MES RECOMMENDED FUEL j SUPER GRADE SUPER GRADE LEAD FREE MIN RON 90 LEAD FREE MIN RON 90 P No 105709 P No 107597 Location The fuel capacity placard is located on the right side shock absorber Series Edge XT Series Table 15 Section 2 Fuel Capacity Placard 2 7 8 Fuel Tap Placard 55mm FUEL n JN P No 105713 Location The fuel tap placard is adjacent to the fuel tap on seat mast block on the left side of the aircraft Series Edge XT Series Table 16 Section 2 Fuel Tap Placard 2 7 9 Hand Throttle and Ignition Placard 32mm HAND THROTTLE IGNITION PN 55mm OFF DUAL IGNITION CHECK BOTH CIRCUITS P No 105714 Location The hand throttle placard is located on the right side seat frame adjacent to the hand throttle lever Series Edge XT Series Table 17Section 2 Hand Throttle and Ignition Placard October 2011 Issue 2 3 Page 14 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 7 10 Pilots Right Seat frame Placard Figure 2 Section 2 Hand Throttle and Ignition Placard 2 7 11 Choke Placard 25mm 5
108. trument panel will start to flash Limitations can be found in section 2 4 2 A low level oil condition will also cause the alarm to be activated see section 4 7 2 5 Weight limits Metric Imperial Max take off weight 450 kg 992 Ib Typical empty weight 212 kg 467 lb Maximum empty weight 257 kg 567 Ib Permitted range of pilot weights Front seat 55 100 kg 121 220 Ib Rear seat 0 100 kg 0 220 Ib Total maximum crew weight 200 kg 440 Ib Maximum under seat storage load per bag 2kg 4 b Table 6 Section 2 Weight Limits Includes 3 litres 2kg unusable fuel Empty weight is defined in section 6 2 October 2011 Issue 2 3 Page 6 AirBorne WindSports Pty Ltd SECTION 2 Aircraft Operating Instructions Edge XT 582 LIMITATIONS 2 6 Operational Limits 2 6 1 Centre of Gravity limits Centre of gravity limits are not critical on the base of a flex wing microlight Having the trike unit attached to the wing from a single universal bracket variations of cockpit loading and fuel loading cannot influence the aircraft s balance The Edge XT is therefore not critical in regards to centre of gravity although the distribution of load in the trike base has a minor affect on the in flight attitude of the trike base Base Suspension Range Dimension Dimension Measured from the line joining the leading edge Imperial Metric nose bolts to the suspension point STREAK 2B WING 49 4 inch 0 8 1255 mm 20mm CRUZE WING 48 6 inch
109. umb while simultaneously pulling the pip pin out Re insert pip pin in nose channel Figure 34 Section 4 Disconnect Nose Catch and Remove Nose Cone 4 12 10 Remove Sail Cowling Undo the securing Velcro tabs at the front of the cowl Remove the sail cowling from the top of sail Figure 35 Section 4 Remove Sail Cowling 4 12 11 De Tension Pull Back Cable Depress quick clip with left thumb Use right hand to pull on the webbing handle Remove the shackle from the quick clip block and allow webbing handle to move forward Figure 36 Section 4 De tension Pull Back Cable March 2011 Issue 2 3 Page30 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 12 12 Remove Main Sail Battens Pull the leading edges together approximately 1 2 metre Remove the remaining main sail battens Insert battens in the batten bag NOTE The straight battens are inserted in separate pockets Figure 37 Section 4 Remove Main Sail Battens 4 12 13 Remove King Post Remove the king post by lifting upward Fit the quick clip king post base cover around the quick clip Insert the king post in to pouch Figure 38 Section 4 Remove King Post March 2011 Issue 2 3 Page 31 AirBorne WindSports Pty Ltd SECTION 4 Aircraft Operating Instructions Edge XT 582 NORMAL PROCEDURES 4 12 14 Fold Leading Edges Fold both wings in symmetrically bringi
110. us additional weight this gives the maximum amount of fuel to be used without exceeding the MTOW 6 3 3 Metric Fuel Calculator Airborne XT Series Aircraft Fuel Volume Calculator Metric Imperial Metric Rear Occupant 10 kg Additional Rear Occupant kg Front Occupant kg UNIT CONVERSION 60 65 70 85 Gallons US 0 2642 14 5 15 9 17 7 18 5 Fuel capacity 70L subject to MTOW kg 450 Payload kg 223 Empty weight kg 212 Gallons US 0 2642 66 145 159 MT 18 5 Additional equipment eg BRS of 10kg 67 60 53 46 25 32L 88 minutes useable fuel full power 264 6 Example Pilot 80kg 10kg additional equipment Passenger 100kg 67L fuel Table 6 Section 6 Metric Fuel Calculator October 2011 Issue 2 3 Page 4 AirBorne WindSports Pty Ltd SECTION 6 Aircraft Operating Instructions Edge XT 582 WEIGHT BALANCE amp EQUIPMENT 6 3 4 Imperial Fuel Calculator Airborne XT 912 Series Aircraft Fuel Volume Calculator Imperial US Metric Imperial Rear Occupant 20 Ib Additional Equipment Rear Occupant Front Occupant UNIT CONVERSION 120 130 140 150 160 170 180 190 200 210 220 Litres 10 38 54 7 8 8 1 38 144 204 269 333 10 4 39 4 45 8 52 2 58 3 64 7 10 O 38 54 BH Fuel capacity 18 5 gal US subject to MTOW Ib 992 Payload Ib 492 Empty weight Ib 467 Additional equipment eg BRS of 20 7 Ib Fuel consumption at full power 7 0 gal hr Example
111. wards the pilot past the wings trim position after lift off As the wing design has the trim speed equal to or greater than 1 3 V stall speed it is not October 2011 Issue 2 3 Page 2 AirBorne WindSports Pty Ltd SECTION 9 Aircraft Operating Instructions Edge XT 582 SUPPLEMENTS necessary to pull the control bar back The wing will return to the trim speed and achieve take off safety speed if the controls are relaxed Initial climb out should be made on full power for maximum take off weight Approximately 2 3 of maximum take off power is considered comfortable for a minimum weight takeoff Take off distance will be extended at reduced power Once climb is established power should be reduced to below maximum continuous power of 5500 rpm A minimum of takeoff safety soeed should be used At this speed the aircraft would round out nicely into a glide should the engine fail Finally the Cruze wing trimmer located on the lower right down tube should be in the fast trim position see AOI Section 7 5 9 6 Cruise and Stalls Cruise and stalls are covered in AOI Sections 4 10 7 and 4 10 8 respectively Stalls are very mild and in fact very difficult to do unless the aircraft is heavily loaded Recovery is the same as in other WSC aircraft 9 7 Landing See AOI Section 4 9 7 8 for descent and landing procedures It is not necessary to approach at a higher speed than trim speed unless conditions are extremely turbulent
112. when corresponding with the factory 6 3 Aircraft Documents The Aircraft Operating Instructions are one of a series of documents required to safely operate this aircraft A document list can be found in section 0 of this manual under DATA PACKAGE 8 4 Aircraft Inspection Maintenance and repair Maintainer qualifications vary from country to country The operator maintainer should be familiar with the local requirements Maintenance requirements are outlined in the base maintenance manual for the base unit and in the wing maintenance manual for the wing The following sections have been included because it is considered that the information may be required on a more regular basis 8 5 Fuel System 8 5 1 Filling Fuel Tanks The properties of the fuel tank material cause an increase in capacity after the first 2 to 3 tanks of fuel Initial capacity is 64 litres with the aged capacity 70 litres The fuel level markings have been positioned for the fuel tank capacity at 70 litres The XT has a single fuel tank When the tank is being filled there may be a slight pressure differential between the sides of the tank causing the fuel cap side to fill slightly faster than the other side Allow time for the breather valves to equalise the pressure to allow complete filling and check that both sides are sufficiently full Fill to the neck of the fuel entrance 8 5 2 Fuel Specification FUEL Preferred Fuel Type En228 Premium Regular Super grade ga

AIRCRAFT OPERATING INSTRUCTIONS Light

Contents

Download Pdf Manuals

Related Search

Related Contents