Home

SERVICE MANUAL

1. temperature sensor Freezer storage temperature sensor CONTROL AND DISPLAY SYSTEM 5 2 3 Malfunction display Malfunction display and meaning Malfunction display Display the 1 Normal temperature No setting Freezer storage temperature sensor F SNR short or open circuit malfunction Ambient temperature 3 5 RT SNR short or open circuit sensor malfunction Fridge storage temperature sensor R1 SNR short or open circuit malfunction 5 Defrosting DEES D SNR short or open circuit sensor malfunction m Freezer fan malfunction E1 No signal for more than 30s WE No communication between malfunction power board for 2 minutes SYSTEM FLOW CHART 6 1 Refrigeration System Flow Chart Refrigeration principle of the refrigerator 1 Principle diagram and description of the refrigeration cycle The refrigerant is compressed in the compressor from there it enters the dry filter de dewing tube and the condenser and goes into the evaporator after being throttled and decompressed in the capillary tube Finally it returns to the compressor through the air return tube Principle diagram of the refrigeration cycle SYSTEM FLOW CHART 6 2 Perspective of the Refrigeration System Condenser P A
2. Super cooling Fridge storage Power Freezer Super button temperature setup indicator storage freezing knob temperature button setup knob cms dign Wo il as ort Br Ls Jer gar F E d Ta c H Initial powering on Upon initial powering on the power indicator will illuminate There will be alarm due to high temperature in the freezer storage compartment You can cancel the alarm by pressing any key B Fridge storage temperature setup The temperature in the fridge storage compartment can be set by turning the fridge storage temperature setup knob There are three temperature positions for refrigerating Holiday Moderate and Super Cool H Freezer storage temperature setup The temperature in the freezer storage compartment can be set by turning the freezer storage temperature setup knob There are three temperature positions for freezing Weak Moderate and Super Freeze H Super cooling Select this function after you have put fresh food in the fridge storage compartment Press the super cooling button the refrigerator activates this function and corresponding indicator illuminates This function will automatically deactivate when the temperature decreases to the required level You can also deactivate it by pressing the super cooling button again B Super freezing Select this function after you have put large amount of food in the freezer storage compartment Press the super freezing button the refrigera
3. CFE 633 CW AFD 631 CB AFL 631 CS CFL 633 CS AFD 631 CS LH TBD to be defined without x with Product description Refrigerator F reezer Refrigerator NE AA A A e T TTE TT Tl VDE After VDE After VDE After VDE After Mar 2008 Mar 2008 Mar 2008 Mar 2008 CE ISO 9001 CE ISO 9001 CE ISO 9001 CE ISO 9001 336 310 Refrigerator Refrigerator Type of appliance FS freestanding Bl built in Type of cooling system NF no frost S static Energy efficiency class Climate class Freezer compartment Star rating ra pu Approvals VDE TUV IMQ NF OVE DEMKO etc Net capacity freezer compartment X ice cube compartment 336 310 Defrost water outlet Air circulating ventilator Kind of coolant R134a R 600a R600a 55g R600a 55g R600a 52g R600a 52g Foaming components R141b R134a C P PU echnical data WA 100 00 Energy consumption EN 153 per I 100 net year Max noise level d Aesthetics 220 240 50 100 DC 220 240 50 100 DC 220 240 50 100 DC 1 8 C OC 0 10 C 16 25 C 1 8 C OC 0 10 C 16 25 C 1 8 C OC 0 10 C 16 25 C 1 8 C 3 10 C 0 10 C 16 25 C 0 87 0 co SJ 0 co HJ 0 co HJ o o white G silver gray B Obsidian ss stainless SS Obsidian G Obsidian G Obsidian G B B B B G G G G B B B B G G G G B ss B B B B G G G G w w w w
4. If the temperature is still rising or dropping within 10 minutes after opening or closing of the air door it will open or close once again 8 4 Control Principle of the Fan The freezer fan is controlled by the control panel according to the following conditions The DC fan s rotation speed is regulated with PWM mode and the AC fan operates directly 1 ON OFF condition of the freezer fan The control mode of the DC fan is listed in the table below The AC fan runs under condition ON and stops running under condition OFF 2 When the fridge storage compartment door is opened the freezer fan will run and the refrigeration air door will open After 2 minutes the refrigeration air door will close 3 When the freezer storage compartment door is open the freezer fan will not run 4 Conditions for judging LOCK of the freezer fan If the rotation speed of the fan is less than 300RPM or the fan does not run and the state has persisted for over 30 seconds a freezer fan malfunction will be displayed Normal display will be recovered after it becomes normal Otherwise the freezer fan malfunction will persist 8 5 Defrosting Control Principle A defrosting cycle will be started once the compressor has operated for 8 hours accumulatively It will stop defrosting when the defrosting sensor detects a temperature over 10 C The compressor stops and the refrigeration air door is closed during defrosting After initial powering on or resetting of
5. only on models with an icemaker H Press key A2 until icon J flashes Then press key A5 to confirm the ice making function Icon J will illuminate solid You can deactivate the ice making function with the same operation B Icemaker s water injection time adjustment only on models with an icemaker H Press key A2 until icon K flashes Then press key A5 to confirm the icemaker s water injection time adjustment Icon K will illuminate solid The water injection time will be indicated with icon H and icon D For example if the time is 4 0s icon H will be 4 and D will be O Press key A3 or A4 to set the time in an increment of 0 5s It cycles from 2s to 7s After you have set it to the desired value press key A5 to confirm Icon K will go off You can exit the icemaker s water injection time adjustment with the same operation H Note this operation can be performed only when the ice making function is selected H Display control B The display screen will dim 1 minute after an operation is finished It will recover to normal brightness when you open the door or press any key Alarm does not light up the display screen H Door open alarming B When the fridge storage compartment door is open for more than 3 minutes icon G will flash and the buzzer will give out 3 beeps every 30 seconds If you close the door the alarm will be silenced and icon G will go off You can also silence the buzzer by pressing key A5 H Over temperature alarming H Whe
6. 24 hours storage compartment is too for the temperature of the refrigerator to become high while the temperature in stable the fridge storage compartment is OK The temperature in the fridge The temperature is set too high Set the fridge temperature lower It takes 24 hours for storage compartment is too the temperature of the refrigerator to become stable high while the temperature in the freezer storage compartment is OK Bad odors in the refrigerator The inside of the refrigerator The inside of the refrigerator Clean the internal of the refrigerator is dirty needs cleaning Food with strong odor is Wrap the food tightly stored in the refrigerator If you hear Beeps The fridge storage Close the door or silence the alarm manually compartment door is open The temperature in the freezer The alarm is normal when it is first started due to storage compartment is too relatively higher temperature high Abnormal sound The refrigerator is not located Adjust the feet to level the refrigerator on a level surface The refrigerator touches some Remove objects around it object around it flowing water refrigerating system Heating of cabinet The de dew tube is de dewing It is a process to prevent dewing It is a normal phenomenon Sincere Forever Haier Group Tel 86 532 88938356 Web site http www haier com
7. Avantgarde line T TV Screen 35 345 354 It o Side by Side traditional 36 355 364 It 3 doors SBS Z 4 doors SBS F Chest Freezer U Upright Freezer Wine Cooler PARTS IDENTIFICATIONS 3 1 Product Dimensions Three Door Refrigerator Dimensions Refrigerator height H 1880mm Refrigerator width W 595mm Refrigerator depth D 730mm Cabinet depth D1 576mm Door depth D2 78mm Two Door Refrigerator Dimensions Refrigerator height H 1880mm Refrigerator width W 595mm Refrigerator depth D 670mm Cabinet depth D1 576mm Door depth D2 78mm PARTS IDENTIFICATIONS 3 2 Three Door Refrigerator Structure Fridge storage compartment Display panel Lem J K Z urnover box include egg box Turnover box rack Shelf ee Butter box Wire wine holder iddle bottl k Fresh keeping box cover ladie bottle rac Fresh keeping box Crisper cover Crisper TTTT arge bottle rack i sss Se s S n mall bottle rack Middle door drawer Bottom door drawer Freezer Drawer Structure Middle door d
8. Container load 40 HC Container load ecycling symbols dl NJ L I RJ en L dl NJ u NJ Li E dl NJ u r N L 1 dl NJ L 1 NJ E I Packing materials Recycling simbols RS Polyethylene foil weight in gr Wood weight in kg 0 000 0 000 0 000 0 000 Seve wy TS RM anes D F I GB E P D F I GB E PD F I GB E PD F I GB E P NL NL NL NL SPECIFICATIONS 2 2 Main Functions and Features Removable automatic icemaker only in some models The freezer door has been replaced by two drawers This can better facilitate food access featuring both energy saving and convenience only in some models Half shelf structure Innovative long efficiency lighting system Foldaway wine holder Large crisper with humidity adjustment Holiday function Power ON OFF function is set on the display panel only in some models Fridge storage compartment can be set on off separately Intelligent alarm function automatic alarm at over temperature malfunction door en Touch keys only in some models Deodorizer only in some models Zero degree fresh keeping se 99 2 3 Explanation of The Models PRODUCT FAMILY REF SYSTEM USER INTERFACE VOLUME T Table Top S Static M Mechanical 05 45 54 It O One Door 14 135 144 It D Double Door F Full No Frost L Led inside 21 195 204 It C Combi traditional D LCD Display 32 315 324 It A Combi with Drawers
9. Reinstall it correctly if not so Turn on the fridge storage compartment manually In this case it is normal for the refrigerator to run longer Normally it takes 8 to 12 hours for the refrigerator to totally cool down Icemaking process makes the refrigerator to run longer Warm air enters the refrigerator and causes it to start frequently Please do not open the door so frequently Make sure the refrigerator is level place and there is no food or container interfering with the door Set the temperature higher until satisfactory refrigerator temperature is obtained It takes 24 hours for the refrigerator temperature to become stable Clean or replace the door gasket Leakage gap of door gasket can cause longer running time of the refrigerator in order to maintain desired temperature Clean the condenser Too high temperature TROUBLE SHOOTING Too high temperature in the The door is opened too Warm air will enter the refrigerator whenever the fridge freezer storage frequently or for too long door is opened Try to open the door as infrequently compartment periods of time as possible Temperature is set too high Reset the temperature The door is not closed tightly Make sure the refrigerator is on a level surface and there is no food or container interfering with the door The condenser is dirty Clean the condenser The temperature in the freezer The temperature is set too high Set the freezer temperature lower It takes
10. be turned off while the freezer storage compartment operates normally B Turning off the refrigerator Set the freezer storage temperature to OFF The refrigerator will stop operating This function is not equivalent to turning off the power 5 1 2 Models CFL633 AFL631 H Control panel Fridge storage compartment temperature Freezer storage compartment temperature Stant by Holiday SuperGadl Supar Fieeze Alarm ki A1 A2 A3 A4 A5 AG A A8 A9 A10 H Initial powering on When the refrigerator is powered on for the first time the power indicator and the fridge storage compartment indicator will light The fridge storage temperature will be displayed as due to the high temperature inside The freezer storage temperature will be displayed as due to high temperature inside The buzzer will beep Press key A9 and the buzzer will be silenced After the temperature decreases to certain level the displayed temperatures of the fridge storage compartment and the freezer storage compartment will become the ex factory settings 5 and 18 respectively H Fridge storage temperature setup Press key A4 or A5 to set the fridge storage temperature The fridge storage temperature cycles from 1 to 8 The setting is confirmed automatically 5 seconds after the operation is finished or by pressing any other key B Freezing storage temperature setup Press key A6 or A7 to set the freezer storage temperature The freezer storage temperature
11. cycles from 14 to 26 C It will be confirmed automatically 5 seconds after the operation is finished or by pressing any other key H Super cooling Select this function after you have put fresh food in the fridge storage compartment Press key A3 and this function is activated and the corresponding indicator illuminates This function will automatically CONTROL AND DISPLAY SYSTEM deactivate when the temperature decreases to the required level You can also deactivate it by pressing key A3 again B Super freezing Select this function after you have put large amount of food in the freezer storage compartment Press key A8 this function is activated and the corresponding indicator illuminates This function will become inactive automatically after 24 hours You can also deactivate it by pressing key A8 again H Holiday function Press key A2 corresponding indicator illuminates and the holiday function of the fridge storage compartment is activated It will operate at a relatively high temperature in Holiday mode The fridge Please take out the fresh food in the refrigerator and close 66 39 storage temperature will be indicated as the door before activating this function Press key A2 again and the corresponding indicator goes off and the refrigerator comes into normal control B Display control The display screen will turn off automatically 1 minute after an operation is finished It can be lit up by opening the door or
12. else the leaked refrigerant may pollute the atmosphere 9 The refrigerator use AC of220 240V with a frequency of 50Hz 10 A big fluctuation of voltage exceed the range220 240V may cause a start failure of the refrigerator a burn out of the control panel and compressor or an abnormal sound from the compressor in operation In this condition an automatic voltage regulator over 750W should be added 11 Take care not to damage the supply line Don t yank at the line pull the plug out gently from the receptacle Don t press the line under the cabinet or step on it Take care not to roll on or damage the supply line when moves the machine from the wall 12 Don t use the supply line any more when there is damage to the line or an abrasion to the plug Go to the authorized service center for a replacement 13 In the case of leakage of inflammable gases like carbon monoxide open the door and windows Don t pull out or insert the plugs of the appliance 14 This product is designed only for household use Any put of medicine dangerous flammable explosive articles and highly corrosive acid or base is forbidden 15 It is recommended not to put any receptacles stabilized power supply or appliances like microwave oven on the board of the refrigerator Don t use appliance within the SAFETY PRECAUTIONS refrigerator except recommended type else there may be electromagnetic interference or other accidents 16 Don t store or use gaso
13. gt LJ VU e LJ me B ss w w eo le Shelves 00000000 Colour w white b blue g green t transpar Drewes S Colour of drawer w white t transp g green Equipment amp accessories Control panel gt lt r gt lt gt lt gt lt cv 4 e E c wit wit Chiller t Chiller t Chiller t Chiller t i E s helen O Eme mw teror Thermometer meriorjexterior Exterior Interior mer Display type EXTRA HIGH LED LED LED Control lamps green yellow white g amp y g amp y g amp y Over temperature alarm LED acoustic Adjustable thermostat Fast freeze switch function Deodorizing Interior light LED light Freeze pack s ice maker Manual Automatic Ice cube tray s Butter holder E gg trays Adjustable feet front rear Castors front rear X X X X Wall spacer grid distance holder Lenght of cable incl plug Condenser Backwall Integrated oduct dimensions 188 60 67 188 60 67 188 60 67 188 60 67 Unit dimensions H W D Depth Without handle epth with open door e HJ e HJ e SJ e HJ U 1188 lt 135 1188 lt 135 1188 lt 135 1188 Door open angle lt 135 dl e dl e Net weight T Packing dimensions amp loadability Packing dimensions H W D Gross weight 194 7 66 4 72 5 194 7 66 4 72 5 194 7 66 4 72 5 194 7 66 4 72 5 40
14. pressing any key Alarm does not light up the display screen H Door open alarming When the refrigerator door is open for more than 3 minutes the alarm indicator will flash and the buzzer will sound 3 beeps every 30 seconds The buzzer can be silenced by closing the door or pressing key A9 H Over temperature alarm When the temperature in the freezer storage compartment rises to a certain value the alarm indicator will illuminate solid and the buzzer will sound 1 beep every second The buzzer can be silenced when the temperature in the freezer storage compartment drops to a specified level or key A9 is pressed H Turning off the fridge storage compartment Press and hold key A1 for 3 seconds and the corresponding indicator will turn off and the fridge storage compartment will be turned off while the freezer storage compartment operates normally The fridge storage temperature indication icon will also go off Press and hold key A1 for 3 seconds again the corresponding indicator will illuminate the fridge storage compartment will be turned on and the fridge storage temperature indication icon will recover B Turning off the refrigerator Press and hold key A10 for 3 seconds corresponding indicator will go off the display panel will go off and the refrigerator will stop operating Press and hold key A10 for 3 seconds again corresponding indicator will light up the display panel will light up and the refrigerator will start operating normal
15. the control panel it will start the first defrosting cycle after the compressor has operated for 6 hours accumulatively It may enter the defrosting state when the defrosting sensor is malfunctiony short circuit or open circuit In this case it will exit the defrosting state after 30 minutes 8 6 Refrigerator Test Mode TEST1 Press the TEST key on the power board to enter the PULL DOWN MODE the door display panel displays T1 T1 and the refrigerator enters forced refrigeration state the compressor operates normally the fan runs at high speed and the defrosting heating wire is disconnected This can be used to test the refrigeration performance TEST2 Press TEST key again in TEST1 MODE to enter the FORCED DEFROSTING MODE It will act depending on the temperature sensed by the defrosting sensor When the temperature sensed by the defrosting sensor is over 10 C the heating wire will exit the FORCED DEFROSTING MODE after 20s heating When the temperature sensed by the defrosting sensor is below 10 C the heating wire will heat continuously until the temperature sensed by the sensor reaches 7 C In the FORCED DEFROSTING MODE the door display panel displays T2 T2 the refrigerator conducts forced defrosting the compressor and the fan are turned off and the defrosting heating wire is turned on At this moment you can test the power of the defrosting heating wire and it should be 153 15W TROUBLE SHOOTING Trouble Shooting S
16. the upper hinge by placing the axis into the door axis hole after turning 180 degrees 6 Remove the stop block on the bottom of the door and then reatacht on the other side of the door after turning 180 degrees 7 Turn the middle hinge by 180 degrees and then fit it on the other side of the cabinet 89 Hang the door on the middle hinge and secure the hinge s screws Connect the two connectors together Tuck the cables for the door into the conduit on the other side of the door and the cables for the cabinet into the upper hinge conduit 9 Tuck the connected connectors into the conduit on the upper decoration strip and joint the upper decoration strip on the door 0 Turn the decoration piece by 180 degrees and insert it between the door and the upper decoration strip at the other side of the cabinet D Note for the models with cabinet display the above operation concerning cables is not needed Part 3 Directions on how to dismantle and install the middle and lower hinges 1 Detach the 3 screws affixed to the middle hinge and remove the hinge Unscrew the hinge axis and then screw it from the reversed direction 2 Remove the upper and lower doors separately Dismantle the stop blocks on the bottom of the doors Turn them by 180 degrees and refit them on the other side DISASSEMBLY 3 Tilt the refrigerator to the required angle Detach the screws fixing the lower hinge and remove the hinge 4 Fix the lower hinge to th
17. CAUTION READ THIS MANUAL CAREFULLY TO a e f DIAGNOSE TROUBLE CORRECTLY BEFORE OFFERING SERVICE Refrigerator SERVICE MANUAL MODEL AFD631 AFL631 CFL633 CFE633 Haier Group CONTENTS eenggz geld a 1 SAFETY PRECAUTION Si Laser 2 SPEGIFICANONS ee 4 DDC 0 et EE TE I ITI IT 4 Main FURCIONS and FealUOSmsestensenen oe Esso een ea daer aa aids 7 Exblanatiomor NE Model wawt nekeer entente uee a 7 PARTS IDENTIFICATIONS Ludde 8 PIO USE DIMENSIONS see 8 Three Door Refrigerator SIIUGtUfe ui sicuro smeden a Son en a EE 9 Two Door Helrgelalor 9ullelUl Gasa puni Fa ass as 10 DISASSEMBLY Luske 11 Positioning the Refrigerator ever 11 Precautions During Dismantling and Installation of the Door 11 Installing the Freezer Drawer Handle reser eese 11 Iristalling ara Removing DOON aar 11 Removing the Freezer Drawer rarannnunnnnnnunnnnnevnnnnennnnnnuvnnnneevnnnnevnnnnevnnnnnunne 14 Removing the Cabinet Display Panel e eese eee eere eee enne 15 ROMOVNO Ue ANT DD e 15 CONTROL AND DISPLAY SYSTEM 222annaaaaaaaannn novgngnunnnanunnnnnunnnnunnnnnnnnnnnnnnnnnnnnn 17 Control Panel and Display Panel smaa ERE LEE a ANEN 17 Sensor Distribution and Malfunction Codes e cesse eere eene 22 SYSTEM FLOW CHART iuceuepuxicxst sucus tinpbE Esc getekend ein MER FED UPETMMla d
18. ctory settings 5 and 18 respectively The brightness of icon will decrease to half automatically when the refrigerator is not being operated B Fridge storage temperature setup Press key A2 until icon D flashes Then press key A3 or A4 to set the temperature The refrigerating storage temperature cycles from 2 to 8 After you have set it to the desired value press key A5 to confirm Note Flashing of icon D is accompanied by flashing of icon E H Freezer storage temperature setup Press key A2 until icon H flashes Then press key A3 or A4 to set the temperature The freezing storage temperature cycles from 14 to 24 After you ve set it to the desired value press key A5 to confirm Note Flashing of icon H is accompanied by flashing of icon F 20 CONTROL AND DISPLAY SYSTEM B Supper cooling H Press key A2 until icon B flashes Then press key A5 to confirm the super cooling function Icon B will illuminate solid You can deactivate the super cooling function with the same operation H Holiday function H Press key A2 until icon C flashes Then press key A5 to confirm the holiday function Icon C will illuminate solid You can deactivate the holiday function with the same operation H Supper freezing H Press key A2 until icon flashes Then press key A5 to confirm the super freezing function Icon will illuminate solid You can deactivate the super freezing function with the same operation B Ice making function
19. e 5 Turn over the upper hinge and fix it on the other side Then install the front decoration strip of the table board in the reversed direction 6 Secure the 2 screws on the top 7 Install the 2 decoration covers on the front decoration strip of the table board with their positions exchanged 8 Note for the models with cabinet display the front decoration strip of the table board is different from the one shown in the figure The dismantling and installation methods are the same Part 2 Directions on how to dismantle and install the upper decoration strip and cables 1 Remove the decoration covers from the door and retain amp 0 2 Remove the upper decoration strip from the door Insert a screwdriver into the decoration strip at the position shown by the arrow and lightly pull the screwdriver handle in the arrow direction while pulling the decoration strip upward with another hand In this way the decoration strip will detach away from the door The operation methods on the right side and the left side are the same 3 Disconnect the connectors and pull out the cables in the door conduit and the cables in the upper hinge conduit respectively 4 Loosen the screws affixed to the upper hinge to remove the hinge At the same time the refrigerating compartment door can be lifted up and separated from the middle hinge 5 Pull the axis from the upper hinge Then insert it from the other end of the upper hinge Insert
20. e bottom of the other side of the cabinet Then mount the lower door on the lower hinge 5 Take out the 3 hole plugs on the other side of the cabinet Turn the middle hinge by 180 degrees and install it on the other side of the cabinet Attach the 3 screws removed in step 1 Mount the 3 hole plugs into the holes where the hinge is seated originally Note For 3 door refrigerators the operation concerning the lower hinge is not needed 4 5 Removing the Freezer Drawer 1 Open the freezer storage compartment door of the 3 door refrigerator 2 Take out the drawer 3 Detach the screw connecting the rail and the support iron the screw may be on the inner side of the support iron due to the rail 4 Remove the door DISASSEMBLY 1 Detach the screw in the left hinge cover of the cabinet fig D 2 Remove the left hinge cover of the cabinet fig 3 Detach the screw in the right hinge cover of the cabinet fig 3 4 Remove the right hinge cover of the cabinet fig 4 5 Detach the 4 screws in the front decoration strip of the cabinet fig DOG 6 Pull out the connector and remove the front decoration strip of the table board fig JO 4 7 Removing the Air Duct m Removal of the refrigeration air duct unplug the refrigerator before removing the air duct D 1 Take out the accessories in the fridge storage compartment which may interfere with the removal of the air duct including shelves
21. esistance in normal operation is between 10 9 and 25 19kQ correspond to 10 C 25 C The resistance at normal temperature is between 2 49 and 1 61kQ correspond to 20 C 30 C 10 11 Connected to the freezer storage temperature sensor Resistance test is the same as the defrosting temperature sensor 12 Null CN2 is the connector for the LED lamps and display panel 1 GND 2 5V 3 Com 4 Com 5 6 Null 7 12V 8 GND CN3 is the connector for the power cables 1 Zero line 2 Live line 3 Compressor between it and the zero line 4 Null 5 Heating tube for defrosting The resistance between it and the zero is 3450 10 6 Null CN4 is the connector for the air door and fan 1 Feedback signal from the fan 2 GND of the fan 3 12V of the fan 4 fan 12V 5 6 Null 7 9 Motor of the refrigeration air door 28 ELECTRICAL CONTROL PRINCIPLE 8 3 Control Principle of the Air Escaper 1 The refrigeration air door is controlled with the fridge storage temperature sensor R SNR 2 The air door is closed from the beginning of defrosting until 15 minutes after the defrosting is finished 3 Upon initial powering on or resetting of the control panel the air door conducts a close and open cycle before acting according to the control conditions in item 1 4 The air door will be forced to conduct an open and close cycle if it has been closed for 1 hour After that its closing opening will be controlled by R SNR 5
22. freezer storage compartment check if the fan base is firmly fixed if the fan vanes are installed properly and if they intervene with the wires If any of these problems is found please remove the fan and reinstall it properly 2 If the fan connector is not installed properly disconnect the terminals and reinstall the connector 3 If the main control panel or the fan is malfunctioning replace the malfunctioning one with a good spare part TROUBLE SHOOTING Examination And Solutions For Other Common Problems Water moisture frost in the refrigerator Moisture accumulates on the refrigerators inner walls Hot and moist climate The door is not closed tightly The door is opened too Accumulation of frost and moisture accelerate in such climate Make sure the refrigerator is level and there is no food or container interfering with the door frequently or for too long time Do not open the door so frequently Water moisture frost on outside surface of the refrigerator Moisture accumulates on the refrigerator s outside surface or between two doors Damp climate The refrigerator door is not closed tightly This causes mixing of the cold air in the refrigerator with the warm air outside it It is normal in damp climate The moisture will decrease when the humidity drops Make sure the refrigerator is level and there is no food or container interfering with the door Refrigerator operat
23. g 3 Check if the connector of the freezer door hinge is connected properly 4 Verify the display panel to see if the refrigerator is in OFF state If so press and hold the button on the power board for 3s to turn it on Solutions 1 If there is dry soldering or open soldering on the control panel resolder it with an electrical iron 30 TROUBLE SHOOTING 2 If any connector is not connected properly replug it firmly 3 Press and hold the button on the power board for 3s to turn the refrigerator on Symptom poor freezing effect accompanied by loud noise Check 1 Check if there is apparent abnormal sound in the freezer storage compartment Remove the fan cover plate close the refrigeration air door and the icemaker air door and check if the freezer fan is operating normally The fan does not operate when the refrigeration air door is open Please first eliminate the possibility of improper installation of the door on off 2 If the freezer fan does not run remove it and check if its connector and the cabinet connector are connected properly Test if there is approximately 12VDC voltage across pin2 and pin 3 of CN4 If there is no 12VDC voltage the main control panel can generally be determined to be malfunctioning If there is 12VDC voltage the freezer fan can generally be determined to be malfunctioning 3 If the fan rotates abnormally the fan is malfunctioning Solutions 1 If there is apparent abnormal sound in the
24. ienend 24 Helrigerauoh System FIOW GAAR zessen bsusasEuEU E usStessEeEa a 24 Perspective of the Refrigeration Syst lMa aaaaaaaaaannnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnna 25 ATOM CA sarte 26 CIRCUIT DIAGRAM Von aitwetaddvemeiteunndewonseeesins 27 ELECTRICAL CONTROL PRINCIPLE eese eere e een en nenne 28 ONE m Qe 28 MEN Gontol PCB RR T 28 Control Principle or the Al ESP ananasen aa M 29 GonttokPrinGiple of the Feen 29 DEtrosting Control PANGIPISnsainsssersearrt M 29 Remgerator Test Model reme 29 TROUBLE SHOOTING ges 30 SAFETY PRECAUTIONS 1 Check if there is any leak of current 2 Cut out the power supply before the repair to avoid an electrical shock hazard 3 In the case of a live line test insulating gloves should be worn to avoid potential electrical shock 4 Confirm the rated current voltage and capacity before testing with any kinds of instruments 5 Watch if the upper door is open when you check something at a lower position 6 Take out every part in the cabinet before moving the machine especially things like panels e g glass shelf 7 Please wear intact cotton gloves when repair any parts of the evaporator so that scratches by the sharp fins can be avoided 8 If there is a breakdown with the refrigeration system please surrender the machine to the service center
25. ion The compressor does not work e The fridge storage compartment does not work The refrigerator runs frequently or runs for too long period The refrigerator is in defrosting cycle The refrigerator is not plugged into a power outlet The refrigerator is in OFF state The air door cable is not connected properly The fan does not work The fridge storage compartment 1s turned off The indoor or outdoor temperature is high The refrigerator has been powered off for a period of time The automatic icemaker is operating The door is opened too frequently or for long periods The door of the fridge freezer storage compartment is not tightly closed The temperature setting for the freezer storage compartment is too low The door gasket of the fridge freezer storage compartment is dirty worn cracked or mismatched The condenser is dirty It is normal for an automatic defrosting refrigerator Verify the plug is plugged in the socket firmly Press the Power button for 3 second or more to restart the refrigerator or turn the knob from OFF to temperature selection position Check if the air door cable is not connected properly and install it correctly if not so Verify that the air door acts normally with the Fridge ON OFF key on the display panel The fan does not work while the refrigeration air door is open Please check if the door on off behind the front decoration strip is installed properly
26. ir return tube du 1j S8 OQ X X SX X S X S AA Y vas dd allin Evaporator mm a i li rie I Ng mr Aq re V EUR Tb KAU TG rA AM Dry filter De dewing tube Compressor SYSTEM FLOW CHART 6 3 Air Flow Chart Schematic drawing and description of air circulation in the refrigerator air duct Fridge air inlet oo sms M j Fridge air inlet Fridge air outlet Freezer air inlet Freezer air inlet Freezer air outlet CIRCUIT DIAGRAM Brief principle diagram Power board L OUR LALU JI WOU UU PA LED Lamp AAR ANNIE 4 0064000554 V WL ANINI ADRA 7 hi Display panel NLC HT CON4 CON1 Ej 12 l WG ZOO TN IVV KI AJAUX LUN Blue Brown Red Switch ADO 14 Q U4 O Air escaper connecting cable _ Black dii ii Fridge storage temperature sensor per connecting cable ge storage temp 006040066 3 TL LI LL lan Jed Defrosting temperature sensor Fan motor connecting cable Eleetricairescaper gt ANROANNR TR 0064001513 ed es storage temperature sensor Fan motor 0064001312 Fuse Heating tube 0064000353 Black gt ss Blue FE n ss Blue Brown Yellow Green Po
27. l as soon as possible 5 2 Sensor Distribution and Malfunction Codes 5 2 1 Sensor location description Malfunction description Sign Display Display Sensor location poo Malfunction of the ambient The ambient temperature sensor is H SNR Display panel panel temperature sensor located on the display panel The fridge storage temperature NN R SNR Display panel sensor is located on the right side of storage temperature sensor the fridge storage compartment EE EE The freezer storage temperature F SNR F4 Display panel sensor is located on the left side of storage temperature sensor the freezing air duct cover Malfunction of the defrosting D SNR Display panel The defrosting temperature sensor is temperature sensor located on the fin evaporator Malfunction of communication between the Display panel display panel and the power board Malfunction of the fan E1 Display panel 5 2 2 Graphic display of the sensor location Ambient temperature SENSOT Fridge storage temperature sensor Defrosting
28. large and small crispers air duct decoration strips fig D 2 Detach the 2 screws in the upper part of the air duct fig D 3 Tilt the refrigeration air duct forward entirely around its upper side until you can see the connector on its lower side Pull out the connector and you can remove the refrigeration air duct fig DOO DISASSEMBLY m Removal of freezing air duct unplug the refrigerator before removing the air duct 1 Take out the accessories in the freezer storage compartment which may interfere with the removal of the freezing air duct drawers of 2 door models middle bottom doors and drawers of 3 door models fig D 2 Detach the screw in the harness cover over the freezing air duct fig D 3 Remove the harness cover There is a small indentation on both upper side and bottom side of the harness cover to facilitate the removal fig 3 4 Pull out the wires under the harness cover and pull out the connector fig 5 Detach the 2 screws in the freezing air duct onto the freezer chamber fig 6 Tilt the freezing air duct forward from top to bottom and you can remove the air duct fig 6 7 Take out the freezing air duct and the fin evaporator is just behind it fig When reinstalling please connect the connector first and then mount and fix the freezing air duct CONTROL AND DISPLAY SYSTEM 5 1 Control Panel and Display System 5 1 1 Models CFE633 H Control panel
29. line and other flammable articles near the refrigerator which may lead to a fire accident 17 Don t hook on the door else the door may be slanted or the machine may be tipped over and injure people 18 Don t place unstable articles on the refrigerator e g weights and containers with water else the weights may hit people and the leaked water may cause leak of current 19 Don t touch the refrigeration surface of the freezing compartment when the refrigerator is in operation especially when your hand is wet else you may be glued to the surface 20 Don t spray at the refrigerator or locate it at a damp place else the insulation of the refrigerator may be impaired 21 Any disassembly or alternation to the refrigerator is strictly forbidden Damage to the refrigeration pipeline is prohibited Service to the refrigerator must be carried out by professionals 22 Don put bottles of bear and other drinks into the refrigerator else the bottles may be cracked with cold 23 Pull out the plug of power supply during clearance or power outage Wait at least five minutes to resume the power supply in order to prevent damage to the compressor caused by continuous restart 24 Remove the door and the door seal when the refrigerator is out of use in case that accident may happen to children coming in to play SPECIFICATIONS 2 1 Specifications FRIEND 60CM COMBI RANGE uer Avantgarde Avantgarde 3 AFD 631 CX AFL 631 CB CFL633CB
30. ly This function is not equivalent to turning off the power B Fault indication When E or F is displayed due to fault the refrigerator can still refrigerate Please contact professional after sales service personnel as soon as possible 5 1 3 Model AFD631 HM Control panel CONTROL AND DISPLAY SYSTEM BC D F E G H JK TY Super Cool D Super Froaze rar ime oma N Yel ko Makar FT Hobday E L Stand by Set Switch on off the fridge storage compartment Fridge compartment indicating icon Menu key Freezer compartment indicating icon Temperature up Alarm icon Temperature down Freezer storage temperature display Confirmation key Supper freezing icon Power ON OFF Icemaker icon only on models with an Supper cooling icon icemaker Holiday function icon Water injection time adjustment icon only on Fridge storage temperature display models with an icemaker H Initial powering on When the refrigerator is powered on for the first time icon G will light The fridge storage temperature will be displayed as due to high temperature inside The freezer storage temperature will be displayed as due to high temperature The buzzer will beep Press key A5 the buzzer will be silenced and icon G will remain lit After the temperature decreases to certain level icon G will turn off and the displayed temperatures of the fridge storage compartment and the freezer storage compartment will become the ex fa
31. n 4 3 Installing the Freezer Drawer Handle 1 Take the handle from the packing bag and align it with the handle seat on the door note the screw hole on the handle should be facing downward 2 Secure it with the screw from the bottom 4 4 Installing and Removing Door PART 1 Before change After change Front decoration strip of the table board LA Upper hinge eN ga a 3 os D EE Ty wr 3 Sag Cover 2 Before change After change Upper decoration strip k i E i nn Decoration cover Ss nm Connector Cables for the cabinet Cables for the cabinet DPE il eS After change Middle hinge Screws affixed to the middle hinge UE Middle hinge axis lower hinge Screws affixed to the lower hinge Changing the door opening direction Part 1 Directions on how to dismantle and install the front decoration strip of the table board and the upper hinge 1 Pull decoration covers 1 and 2 downward to remove them and retain e DISASSEMBLY 2 Detach the 2 screws fixing the front decoration strip of the table board 3 Lift the front decoration strip of the table board outward and upward At this time there are wires connecting it Please do not disconnect the wires Gently put the front decoration strip on the top of the refrigerator 4 Detach the screws affixed to the upper hinge and remove the hing
32. n the temperature in the freezer storage compartment rises to a certain value icon G will illuminate solid and the buzzer will sound 1 beep every second When the temperature in the freezer storage compartment drops to a specified level the alarm will silence and icon G will go off You can also silence the buzzer by pressing key A5 H Switching off the fridge storage compartment H Press and hold key A1 for 3 seconds the fridge storage compartment will be turned off while the freezer storage compartment is operating normally At this time icon D will go off and icon E will become dim H Press and hold key A1 for 3 seconds again the fridge storage compartment will be turned on icon D will recover and icon E will recover its normal brightness H Note if super cooling or holiday function is selected previously the function will be deactivated and corresponding icon will turn off when the fridge storage compartment is turned off H Switching off the refrigerator H Press and hold key A6 for 3 seconds the display panel will go off and the refrigerator will stop operating Press and hold key A6 for 3 seconds again the display panel will light up and the 21 CONTROL AND DISPLAY SYSTEM refrigerator will start operating normally This function is not equivalent to turning off the power B Error indication B When E or F is displayed due to fault the refrigerator can still refrigerate Please contact professional after sales service personne
33. rawer Transparent tray Bottom door drawer PARTS IDENTIFICATIONS 3 3 Two Door Refrigerator Structure Turnover box include egg box Turnover box rack Butter box Middle bottle rack Wire wine holder Fresh keeping box cover Fresh keeping box 1 large bottle rack Crisper cover Crisper risp Small bottle rack Freezer storage ompartment drawer DISASSEMBLY 4 1 Positioning the Refrigerator The refrigerator should be placed on a flat and solid surface If the refrigerator is placed on a plinth flat strong and fire resistant material must be used Never use the foam plinth for packaging If the refrigerator is slightly unstable you can adjust the black adjustable feet at the front of the refrigerator 4 2 Precautions During Dismantling and Installation of The Door 1 Before removing the doors please remove food from the shelves and the bottle guards Then unplug the refrigerator power cord to avoid personal injury product damage or property loss 2 During dismantling of the door in order to avoid possible personal injury product damage or property loss at least two adults are needed to perform the following operations 3 While lifting the hinges to separate it from the door please take care to prevent the door from falling forward 4 Do not allow children or pets to play in the drawers There is the risk of suffocation if they are locked i
34. tor activates this function and corresponding indicator illuminates This function will become automatically deactivate after 24 hours You can also deactivate it by pressing the super freezing button again H Holiday function Turning the fridge storage temperature setup knob to Holiday will activate the holiday function of the fridge storage compartment It will operate at a relatively high temperature Please remove any fresh food from the fridge storage compartment and close the door before activating this function H Display control The display screen will turn off automatically 1 minute after an operation is finished It will be lit up by opening the door or pressing any key Alarm does not light up the display screen H Door open alarming When the refrigerator door is open for more than 3 minutes the super cooling indicator will flash and the buzzer will sound 3 beeps every 30 seconds The buzzer can be silenced by closing the door or D CONTROL AND DISPLAY SYSTEM pressing any key H Over temperature alarm When the temperature in the freezer storage compartment rises to a certain value the Super Freeze indicator will flash and the buzzer will sound 1 beep every second The buzzer may be silenced when the temperature in the freezer storage compartment drops to a specified level or by pressing any key H Turning off the fridge storage compartment Set the fridge storage temperature to OFF The fridge storage compartment will
35. verse polarity please reconnect it correctly 5 If the air door is malfunctioning please replace it with a new one Symptom the buzzer beeps to alarm 1 Test across pin 1 and pin 3 of CN1 on the main control panel The 2 pins should be switched to conduction when the door is closed and disconnected when the door is open 2 If pin 1 and pin 3 of CN1 are disconnected in both cases please remove the front decoration strip to see if the door switch is still in the slot Symptom no defrosting Check 1 Activate the forced defrosting function by double pressing the button on the main control panel Then check if the temperature of the defrosting heating wire is rising If the temperature of the heating wire does not change remove the fan cover plate to check if all the connectors are connected properly and test if there is 220V voltage output across the terminals of the heating wire 2 Measure the resistance of the heating wire with a multimeter It should be around 3450 3 Measure the resistance of the defrosting fuse If it is zero the fuse is OK If it is infinite the fuse is malfunctioning 4 If no malfunction is found in the above checks please test the defrosting temperature sensor with a multimeter Symptom neither displaying nor starting when powering on Check 1 Check if the power supply is connected properly 2 Remove the main control panel and examine its back side carefully to see if there are solder skips or open solderin
36. wer cable E PS UUDU 61 104 IANEAONNNOAN LAN C4 GANNOA SVOR ee ALLI MV SE HE JUL UA UVV VPI ZU fF GU ELECTRICAL CONTROL PRINCIPLE Electrical control principles of the refrigerator 8 1 Overview Electrical control principle of CFE AFL AFD refrigerators 1 Fully air cooling design controlled with a fixed frequency compressor 2 The temperature in the fridge storage compartment is controlled by controlling the air door with the fridge storage temperature sensor R 3 The temperature in the freezer storage compartment is controlled by controlling the power of the compressor with the freezer storage temperature sensor F 8 2 Main Control PCB of the Refrigerator There are 4 connectors on the main control panel of CFE AFL AFD refrigerators Let s describe these connectors CN1 is the connector for the sensors and the door switch Its pins from the left to right are 1 GND 2 12V 3 Door switch signal When the door is opened GND and the signal wires are switch to conduction When the door is open the wires are disconnected 4 6 Null 7 8 Connected to the fridge storage temperature sensor We can test the sensor with these two wires Its resistance in normal operation is between 6 35 and 3 88kQ correspond to OC 10 C The resistance at normal temperature is between 2 45 and 1 58kQ correspond to 20 C 30 C 7 9 Connected to defrosting temperature sensor We can test the sensor with these two wires Its r
37. ymptom food in the fridge storage compartment is frozen Check 1 Verify that the temperature in the fridge storage compartment is too low and the food is frozen there 2 Remove the decoration piece of the refrigeration air duct Detach the 2 screws and take out the air door foam assembly Press the Refrigeration OFF button to see if the air door closes automatically If the air door closes tightly continue to next step If the air door does not close normally continue to step 6 3 Disconnect the connection wires of the air door and the LED lamps Take out the air door foam assembly Tear the adhesive tape wrapped around the foam and separate the foam Check if the seal between the air door and the foam is tight 4 If the seal is tight check if the fridge storage temperature sensor R1 is OK 5 lf the sensor R1 is OK then the main control panel is probably malfunctioning 6 If the wiring of the air door is OK check the circuit from the connector of the main control panel to the connector in the cabinet If there is no problem in this circuit the air door is malfunctioning oolutions 1 If the seal between the air door and the foam is found to be not tight please affix seal strip on the interface between the air door and the foam 2 If the sensor R1 is malfunctioning please replace it with a new one 3 If the main control panel is malfunctioning please replace it with a new one 4 If the connector of the air door is connected with re

SERVICE MANUAL

Contents

Download Pdf Manuals

Related Search

Related Contents