Nokia 2710 navigation RM-586 Service Manual
Contents
1. ASSY Be careful not to damage the LCD Version 1 0 ISSUE 1 Nokia 2710 Navigation Edition RM 586 Ta Academy Service Manual Level 1 amp 2 26 Lift up the UI FLEX ASSY from the UI SHIELDING ASSY with the SS 93 27 Remove the UI FLEX assy The UI flex cannot be 28 Use the SS 93 to release the ANTENNA MODULE used again Discard it ASSY 29 Remove the ANTENNA MODULE ASSY 0 Use the SS 93 to detach the GPS BT ANTENNA ASSY 16 Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA a re Nokia 2710 Navigation Edition RM 586 Academy Service Manual Level 1 amp 2 T L LX L HL E an Ay IEY 4 P D LA 32 Slide the SRT 6 to detach the two clips of the B COVER DECO as shown XL d K 35 Remove the SD DOOR 36 Nokia 2710 Navigation Edition disassembly is now complete END OF DISASSEMBLY 17 Confidential s Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA a re Nokia 2710 Magan Aon Academy Service Manual Level 1 amp 2 10 ASSEMBLY HINTS 1 Tighten the four TORX size 4 screws to the 2 Tighten the two TORX size 4 screws to the torque of 15 Ncm in the order shown torque of 15 Ncm in the order shown 18 Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A Ca re Nokia 2710 Navigation G Academy Service Manual Level 1 amp 2 11 SOLDER COMPONENTS T2. H l e lt B ai q ae f Hi oe 3 RORA xs iei i ra aga Eir hel Bm mmm 7 13 Release the two clips on the other side 14 Press out the KEYMAT ASSY from ihe A COVER ASSY 15 Remove the KEYMAT ASSY 16 Unscrew the four TORX size 4 screws in the order shown 17 To separate the engine board first open the USB 18 Release the two clips holding the D COVER ASSY DOOR with the SS 93 as shown 14 Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 t Tape ges H A Du Te e ee E B N hA Siete ti H 5 ate lla 2 hap D a w S l T V YG AE G DA 19 Remove the D COVER ASSY w D 21 Use the SS 34 to carefully open the LCD CONNECTOR Be careful not to damage the connector or the components nearby 23 Remove the engine board 15 Confidential e Copyright 2010 NOKIA e All rights reserved Nokia 2710 Navigation Edition RM 586 Service Manual Level 1 amp 2 sn hal p 20 Use the SS 93 to carefully open the UI SHIELDING ASSY CONNECTOR Be careful not to damage the connector or the components nearby venu R A 7 78 ba bd ees Rare W R A Aa WRP ee N W ANIN inh rat eee a 2o LLL seco c i A ee 7 PAI asin 2 G A d E Ce T 4 K vat F DS 22 Detach the two clips holding the engine board with the SS 93 fo Dt Uy 4 E were 24 Press out the LCD from the UI SHIELDING
3. all its parts and accessories out of the reach of small children Keep the phone dry Precipitation humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits Do not use or store the phone in dusty dirty areas Its moving parts can be damaged Do not store the phone in hot areas High temperatures can shorten the life of electronic devices damage batteries and warp or melt certain plastics Do not store the phone in cold areas When it warms up to its normal temperature moisture can form inside which may damage electronic circuit boards Do not drop knock or shake the phone Rough handling can break internal circuit boards Do not use harsh chemicals cleaning solvents or strong detergents to clean the phone Do not paint the phone Paint can clog the moving parts and prevent proper operation Use only the supplied or an approved replacement antenna Unauthorised antennas modifications or attachments could damage the phone and may violate regulations governing radio devices All of the above suggestions apply equally to the product battery charger or any accessory T Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A a re Nokia 2710 Navigation G Academy Service Manual Level 1 amp 2 5 BATTERY INFORMATION Note A new battery s full performance is achieved only after two or three complete charge and d
4. written permission of Nokia is prohibited Nokia Nokia Connecting People and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation Other product and company names mentioned herein may be trademarks or tradenames of their respective owners Nokia operates a policy of continuous development Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice Under no circumstances shall Nokia be responsible for any loss of data or income or any special incidental consequential or indirect damages howsoever caused The contents of this document are provided as is Except as required by applicable law no warranties of any kind either express or implied including but not limited to the implied warranties of merchantability and fitness for a particular purpose are made in relation to the accuracy reliability or contents of this document Nokia reserves the right to revise this document or withdraw it at any time without prior notice The availability of particular products may vary by region IMPORTANT This document is intended for use by qualified service personnel only 4 Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A a re Nokia 2710 Navigation G Academy Service Manual Level 1 amp 2 2 WARNINGS AND CAUTIONS Please refer to the phone s user guide for instructions relating to operation care an
5. 0151 04 NNUS a vr a On A NEEE Aa EAOa n SE PE EAE AA 18 N odar ONONE 7 19 2 Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A a re Nokia 2710 Navigation G Academy Service Manual Level 1 amp 2 Change history Approved 08 03 2010 First approved version The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to Carry out service to NOKIA products This Service Manual is to be used only by authorized NOKIA service suppliers and the content of it is confidential Please note that NOKIA provides also other guidance documents e g Service Bulletins for service suppliers follow these regularly and comply with the given instructions While every endeavor has been made to ensure the accuracy of this document some errors may exist If you find any errors or if you have further suggestions please notify NOKIA using the address below Nokia Care Academy mailto Service Manuals nokia com Please keep in mind also that this documentation is continuously being updated and modified so watch always out for the newest version 3 Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A a re Nokia 2710 Navigation G Academy Service Manual Level 1 amp 2 1 COPYRIGHT Copyright 2010 Nokia All rights reserved Reproduction transfer distribution or storage of part or all of the contents in this document in any form without the prior
6. NOKI A Care Nokia 2710 Navigation a Academy Service Manual Level 1 amp 2 SERVICE MANUAL Level 1 amp 2 NOKIA e 7 10 Navigation Edition RM 586 Transceiver characteristics Band GSM 850 900 1800 1900 EDGE Display QVGA 240 320 pixels 2 2 screen up to 262k colors Camera 2 Mpix camera with zoom up to 4 x digital Operating System Symbian OS ver 9 1 Series40 6th Edition Connections Bluetooth 2 1 EDR High Speed Micro USB Interface to PC 3 5mm AV connector 2 0mm DC charger plug USE with BL 5C e pack Standby GSM Up to 12 5 hours Up to 490 hours Note Talk times are dependant on network parameters and phone settings 1 Confidential s Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A 2 re Nokia 2710 Navigation G Academy Service Manual Level 1 amp 2 Table of contents L COON eea Ce OO On ee eS eC Pe 4 2 Warnings and CAUTIONS sss 5 2k WaN Gam ne or RO SOO TNE OP OnE E ee 5 LE NUON neers rte Pn rene eters rn Pere rr ee nar Teer E E een ne eee Seer arr 5 3 25 D8 6 1121 e a nn nero E ve er 6 4 Care AM Cl Bs Tisane n e ccc ects acca ei EEEE aE Reseeseitesceetetts T S Battery TUM ON MOON sessen aerisire aeia ner aiae eai eoe e aE aeee eari Eedeni aiara iaa aieiai 8 i 219 fT I A N E E E AEE A A A E A AS 9 Te SC ON CS n ER E E A E E E E E A E RE decease tet 10 S SWOI EAE EEEE EENE EAEE A AE E EEEE A 11 9 Disassembly instructions sss 12 10 G 21
7. OP BOTTOM Tiel gy n tgp k L 4 ET Pir 19 Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1
8. ation a Academy 3 ESD PROTECTION Service Manual Level 1 amp 2 Nokia requires that service points have sufficient ESD protection against static electricity when servicing the phone Any product of which the covers are removed must be handled with ESD protection The SIM card can be replaced without ESD protection if the product is otherwise ready for use To replace the covers ESD protection must be applied All electronic parts of the product are susceptible to ESD Resistors too can be damaged by static electricity discharge All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area EPA Every repair action involving opening the product or handling the product components must be done under ESD protection ESD protected spare part packages MUST NOT be opened closed out of an ESD Protected Area For more information and local requirements about ESD protection and ESD Protected Area contact your local Nokia After Market Services representative Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A a re Nokia 2710 Navigation G Academy Service Manual Level 1 amp 2 4 CARE AND MAINTENANCE This product is of superior design and craftsmanship and should be treated with care The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years Keep the phone and
9. d maintenance including important safety information Note also the following 2 1 Warnings 1 CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI SKID BRAKING SYSTEMS UNDER CERTAIN FAULT CONDITIONS EMITTED RF ENERGY CAN AFFECT THEIR OPERATION IF NECESSARY CONSULT THE VEHICLE DEALER MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY 2 THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES EG PETROL STATIONS SERVICE STATIONS BLASTING AREAS ETC 3 OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT INCLUDING CELLULAR TELEPHONES MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE 2 2 Cautions 1 Servicing and alignment must be undertaken by qualified personnel only 2 Ensure all work is carried out at an anti static workstation and that an anti static wrist Strap is worn 3 Use only approved components as specified in the parts list 4 Ensure all components modules screws and insulators are correctly re fitted after servicing and alignment 5 Ensure all cables and wires are repositioned correctly 5 Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A a re Nokia 2710 Navig
10. g it in the 4 Unscrew the two TORX size 4 screws in the order direction shown Remove the BATTERY COVER If shown there is a battery inserted remove it also a A e oe Teele ee e two clips on the other side of the 5 Start detaching the A COVER by inserting the SRT 6 Release th 6 between the A COVER and D COVER Slide the SRT 6 phone by sliding the SRT 6 to direction shown to shown direction and release the first two clips Continue to the top side of the phone and release the shown clip 12 Confidential s Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Nokia 2710 ne Academy Service Manual Level 1 amp 2 d U L A x kN T C iae k FERH MESS CS EE A 7 Slide the SRT 6 towards the bottom end to 8 Carefully lift up the A COVER from the left side to release the clip on the side of the phone Then release the shown clip Remove the A COVER ASSY release the two shown clips on the bottom end by and check that the clips remained unharmed Sliding the SRT 6 to the direction shown 10 To remove the KEYMAT ASSY release all seven clips shown 7 MT TITL 11 First release the clips at the bottom end with 12 Then release the three clips on the side the sharp end of the SS 93 13 Confidential s Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Nokia 2710 Vornanen Ain Academy Service Manual Level 1 amp 2 Wy TSN V FT
11. ischarge cycles The battery can be charged and discharged hundreds of times but it will eventually wear out When the operating time talk time and standby time is noticeably shorter than normal it is time to buy a new battery Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer Unplug the charger when not in use Do not leave the battery connected to a charger for longer than a week since overcharging may shorten its lifetime If left unused a fully charged battery will discharge itself over time Temperature extremes can affect the ability of your battery to charge For good operation times with Ni Cd NiMh batteries discharge the battery from time to time by leaving the product switched on until it turns itself off or by using the battery discharge facility of any approved accessory available for the product Do not attempt to discharge the battery by any other means Use the battery only for its intended purpose Never use any charger or battery which is damaged Do not short circuit the battery Accidental short circuiting can occur when a metallic object coin clip or pen causes direct connection of the and terminals of the battery metal strips on the battery for example when you carry a spare battery in your pocket or purse Shortcircuiting the terminals may damage the battery or the connecting object Leaving the battery in hot or cold places s
12. it of Only available as These parts can not be assembly reused after removal 9 Confidential s Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care Academy T SERVICE DEVICES FLS 5 Flash Device BL 5C Battery CA 101 Service Cable SS 34 Connector Removal tool Nokia 2710 Navigation Edition RM 586 Service Manual Level 1 amp 2 NMP standard toolkit v2 For more information refer to the Service Bulletin SB 011 on NOKIA Online Supplier or manufacturer contacts for tool re order can be found in Recommended service equipment document on NOKIA Online 10 Confidential s Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A Ca re Nokia 2710 Navigation G Academy Service Manual Level 1 amp 2 8 SW UPDATE Flash concept Point of Sales To use the FLS 5 Flash Dongle follow the user guide inside the sales package Please check always for the latest version of flash software wich is available on Nokia Online SERVICE le SOFTWARE PRODUCT SPECIFIC ACHIA BATTERY 11 Confidential s Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKI A Ca re Nokia 2710 Navigation G gaai Service Manual Level 1 amp 2 9 DISASSEMBLY INSTRUCTIONS 1 Nokia 2710 Navigation Edition disassembly 2 You must use the Nokia Standard Toolkit version 2 You will also need the SS 34 connector removal tool 3 Release the BATTERY COVER by slidin
13. uch as in a closed car in summer or winter conditions will reduce the capacity and lifetime of the battery Always try to keep the battery between 15 C and 25 C 59 F and 77 F A phone with a hot or cold battery may temporarily not work even when the battery is fully charged Batteries performance is particularly limited in temperatures well below freezing Do not dispose batteries in a fire Dispose of batteries according to local regulations e g recycling Do not dispose as household waste 8 Confidential e Copyright 2010 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA a re Nokia 2710 Aon Academy Service Manual Level 1 amp 2 6 EXPLODED VIEW KEYMAT ASSY x s 10002 A COVER ASSY AN 4 10001 N UI FLEX ASSY Nou 10004 i NUI SHIELDING ASSY 10005 LCD MODULE 10006 bii ee A T OEN SCREWS RF1 4 X 5 0 10003 Al LIGHT SWAP PACKAGE 10007 10009 s LIGHT SWAP PWB 10007 4 N BB SHIELDING LID 10008 GPS SHIELDING CAN 10010 T0010 NL LE CPS BT ANTENNA ASSY LE ANTENNA MODULE ASSY 10013 10015 10011 10012 she EARPIECE _ 10014 IHF SPEAKER ASSY D GPS BT ANTENNA _ 10011 10015 she DC JACK Nae ANTENNA MODULE she 10013 10012 D COVER ASSY A4 10016 10018 4 D COVER ge 10018 lt a SD DOOR amp T0017 USB DOOR 10016 TYPE LABEL 10009 Il SCREWS RF1 4 X 5 0 10020 ERA N B COVER ASSY 10021 B COVER DECO i 10019 l ba
Download Pdf Manuals
Related Search