DuraVent 6DVL-ADT Instructions / Assembly
Contents
1. inspection and cleaning 2 The connector and chimney should be inspected at least once every month during the heating season to determine if a creosote or soot has built up If creosote or soot has accumulated it should be removed to reduce the risk of chimney fire 3 Have your connector and chimney cleaned by a professional chimney sweep if you have doubts about your ability to clean it Use a plastic wood or flexible steel brush 4 When burning Coal clean the chimney thoroughly within 48 hours of shutting down the stove for the season Check the chimney lining for sulfuric acid corrosion regularly 5 Do not use chemical chimney cleaners Their use does not eliminate the need for mechanical cleaning and they may be highly corrosive 6 If a flue fire occurs close all appliance draft openings and call your Fire Department Do not use the chimney again until it is inspected for possible damage M amp G DURAVENT WARRANTY M amp G DuraVent Inc DuraVe smoke damage or damage ca materials provided with the p uraVent provides the followi ercent 100 for five years All warranty obligations of value The terms and condi or in writing except upon tl VENTINOX WARRA ins and 3 documente and continuing throughou subject to compliance with th must not be used wl con appliance or fireplace In case inspection maintenance and chimney liner annua LIMITATIONS ON INTERI otwithstanding any2. or call 800 835 4429 IONS AND ation instructions see www DuraVent A member of M amp G Group 510 Vacaville CA 95696 1510 anufactured in Vacaville CA and Albany NY ifetime warranty for all of its products to t DuraBlack five years and all Termination Caps five years Subject to the limi substantial defects in material or manufacturing if properly installed maintained and used which is transferable from the original homeowner to the buyer of the home for a period of ten 1 5 of God or any produc or distributor 2 modified or altered 3 improperly serviced inspected or cleaned 4 subject to negligence or uraVent This limited li ucts One Hundred Percent 100 o thereafter exce red Percent 10096 for er uraVent shall be limited to repair or replacement of roduct line These remedies shall constitute DuraVent s sole ions of this limited lifetime warran e express written authority of an executive officer of DuraVent ligation and sole remedy un y may not be modified altered or waived by any ac ations set for that was 1 purd etime warran t for the following he lifetime of the defective pro e original purchaser wit below DuraVent warrants t his Warranty is non transferal he purchase price or uct pursuant to t er this limited warran the exception of Ve rom an authorized DuraVen actured by DuraVent
3. DuraBlack are warranted a e terms and conditions ion inaction or represen at its products will be free from le with the exception of Ventinox years This warranty does not cover normal wear and tear ased other than SRP at time of purchase limitations Ventinox liner and com he original homeowner Ven Termination Caps an ntinox lifetime dealer retailer any use not in accordance with the printed y applies only to parts manu ichever is lower onents in wood oil wood inox 316 liner and components for One Hundred icable to each y This warranty provides no cash surrender ation whether oral 0 the following conditions 1 The Liner and Components must be installed according to DV s Liner and Components are used only to line or reline chimneys venting residential appliances for which the ection of the Liner and Components and maintenance as deemed necessary beginning one year after the date of installation y Certified Chimney Sweep or VENTINOX installer The Liner and Components warranty is further e following requirements throughout the warranty period The chimney must have a chimney cap and chemical chimney cleaners en cleaning the Liner or Components Plastic bristle cleaning brushes are recommended Corn biofuels driftwoo aining salt preservative treated lumber plastic and household trash or garbage or wood pellets containing such materials must not be burned in the of
4. EA Pe RR REOR ud ibi 4 MOBILE HOMES 4 INSTALLATION ii vue yk pR REX E Crea Yn acies tds 5 CONNECTING TO CHIMNEY sssleeeeeen nnn n nn 5 ADJUSTABLE PIPE icc ia cate rro pe RR eR RR en 5 TELESCOPING PIPE d eia 6 CONNECTION 6 CLEANING ccc ek Ga bed 6 DuraVent A member of amp M amp G Group LISTING UL and cUL listed by UL file 4 14089 For installation in the United States and Canada PERMITS Contact local Building or Fire Officials about permits restrictions and installation inspection in your area CLEARANCE 6 clearance to walls 8 clearance to ceiling Clearances are measured at a 90 degree angle to the pipe APPLICATION Used to connect an appliance that burns wood coal oil or gas to a DuraVent Factory Built chimney system tested and listed to UL103HT Can be used anywhere single wall stove pipe is allowed Stove pipe installation should be as short and straight as reasonably possible DVL stove pipe is required for use with a solid fuel burning appliances installed in a mobile home NOTES Use only authorized DuraVent DVL parts Do not mix with single wall stove pipe Do not mix with other products or improvise solutions Do not install damaged parts All wood burning appliances require their own separate connector
5. ECIAL DAMAGES OR DIRECT 0 RY DuraVent S ENTIRE LIABILITY IS LIMITED TO THE ES OR THE EXCLUSION OR LIMITATION OF INCI HIS LIMITED WARRANTY GIVES YOU SPECIFIC 25 ENTAL LEGAL L114 09 2012
6. Installation Instructions Double Wall Close Clearance Connectors DuraVent A member of amp M amp G Groi A MAJOR CAUSE OF VENT RELATED FIRES IS FAILURE TO MAINTAIN REQUIRED CLEARANCES AIR SPACES TO COMBUSTIBLE MATERIALS IT IS OF THE UTMOST IMPORTANCE THAT DVL CLOSE CLEARANCE CONNECTOR BE INSTALLED ONLY IN ACCORDANCE WITH THESE INSTRUCTIONS NOTE Dear Customer Installer or End User Read through all of these instructions before We welcome any comments ideas input or beginning your installation Failure to install complaints regarding matters pertaining to our as described in this instruction will void the DuraVent products manufacturer s warranty and may have an effect on your homeowner s insurance and UL If you are searching for tech support or product listing status Keep these instructions for future information please phone us at 800 835 4429 reference This booklet also contains instruc Or email us at tions for installing a venting system within an techsupport duravent com existing masonry chimney and for installations passing through a cathedral ceiling c UL us LISTED MH14089 DOUBLE WALL CLOSE CLEARANCE STOVEPIPE For the most up to date installation instructions see www duravent com CONTENTS LISTING io dice tata eee ieee 4 PERMITS ee nen eae en 4 CLEARANCE pace sa Res 4 APPLICATION dde a R
7. a chimney fire the chimney must be inspected and approved by a certified Chimney Sweep before reuse A cleaning the certified Chimney Sweep must fill out and date the appropriate section of the warranty card provided with the iner was intended or other wood er each annual lifetime warranty DuraVent provides no warranty for the following specific products if such Du Professionals ermine ES INCL LIABLE BUT NOT LIMITED TO PROPE LOW LI EXCL FROM 5 raFlex 304 DuraFlex 316 Dura ollowing licensed contractors wi if it qualifies for replacement un ion costs are not covered under t UDING BUT NOT LIMITED TO IMPLI FOR INCIDENTAL CONSEQUENTIAL RTY DAMAGE AND PERSONAL IN ith er ITATIONS ON IMPLIED WARRA SIONS MAY NOT APPLY TO YO ATETO STATE com b not installed by qualified professional installer Durafech DuraPlus PelletVen Flex Pro DuraFlex SW and Ventinox For pur rior chimney installation experience CSIA Certified he terms of this limited lifetime warranty Al is warranty To obtain warranty service contact DuraVent Customer Service Support 800 835 4429 707 446 4740 FAX www duravent com DVL isa registered trademark of the M amp G DuraVent Inc All rights reserved Made in the USA M amp G DuraVent is a member of M amp G Group 2012 Pro oses of warranty ED WARRANTIES OF MERCHANTABILITY AND FITNESS PUNITIVE OR SP
8. e into outer sleeve if applicable Slide Ring over lower portion of adapter Insert large end of adapter s inner sleeve over the chimney s inner sleeve in the support box or wall thimble Screw the Trim Plate to the support box or wall thimble Slip top piece of DVL pipe over adapter and screw together you may need to pre drill the hole in through the piece of pipe S Figure 3 Clip designed adapter Figure 3 Insert larger diameter of adapter around sleeve in the support box or wall thimble until clips are seated locked Slip top piece of DVL pipe over adapter until clips are seated locked DVL Pipe Finishing Length Collar _ 0 ojx Figure 4 2 Attaching DVL to a Finishing Collar Figure 4 Slide first piece of DVL pipe over the inner sleeve of the Finishing Collar and secure with screws you may need to pre drill the hole through the piece of pipe 3 Pipe Overlap sections Pipe section overlap 74 3 screws at each connection 8 x 3 8 screw equally spaced Adjustable DVL Pipe Figure 5 4 Adjustable Pipe Figure 5 Slide Adjustable Pipe over a straight length of pipe Screw Adjustable pipe to mating pipe to lock pipe to desired length Figure 6 5 Telescoping Pipe Figure 6 Slide upper section of pipe onto lower section of pipe until desired length is obtained Screw Telescoping pipe to lock pipe to desired length 6 Elbows Elbows can be used anywhere
9. in line Elbows are adjustable Figure 7 7T Connection to stove Round outlets Figure 7 If the inner sleeve of the pipe fits into the stove collar no adapter is needed If the inner sleeve of the pipe almost fits into the stove collar then crimp the inner sleeve enough to fit into the stove collar If the stove collar is too small for the inner sleeve of the pipe to fit into then use the DVL adapter to connect to stove collar Adapter comes with or without damper section On rear exiting stoves it is recommended to use a Tee not a 90 degree elbow p Figure 8 e Oval outlets Figure 8 Use a piece of string to measure the distance around the stove collar Circumference If the string measures 19 or a little more then use 6 stove pipe If the string measures 22 or a little more then use 7 stove pipe If the string measures 25 or a little more then use 8 stove pipe Use the DVL 12 adjustable section and field ovalize it to match the shape of the oval outlet on the stove MAINTENANCE When wood is burned slowly it produces tar and other organic vapors which combine with expelled moisture to form creosote The creosote vapors condense in the relatively cool flues of a slow burning fire As a result creosote residue accumulates on the flue lining When ignited this creosote makes an extremely hot fire CLEANING 1i Double wall connector pipe must be installed so that access is provided for
10. o roducts are both a purd FasnSeal and is warranty a traine Chimney Sweeps NF her te Ss uraVent reserves the right to claims must be submitted wi romptly at DuraVent Warran WHERE LAWFUL DuraVent D FOR A PARTICULAR PURPOSE NDIRECT LOSS OF ANY KIND URCHASE PRICE OF THIS PRO OR CONSEQUENTIAL IGHTS AND YOU MAY ALSO For the most up to date insta amp G DuraVent Inc Box TY CONDI Liner and Component warranties contained herein are subject allation instructions 2 The ins he warranty period by a National ased from an Internet seller and uraVent s relining products including DuraLiner professional installer is defined as one of the Certified Specialists or WETT Cer AMAGES 50 THE ABOVE LIMITA nt provides this limited used by chimney fires ac roduct as determined by ng warranties for its pro or 15 years from the date of purchase and Fifty Percent 5096 ellet and gas installations are warranted at One Hun coal burning installations which are warranted One Hundred Percent 100 for ten years a therea and at Ten Percent 10 IONS ET SALES rms or conditions of this limite ified inspect defective product to de h proof of purchase Labor an y Service 902 Aldridge Rd Vac SCLAIMS ALL OTHER WARRAN NO EVENT WILL DuraVent B NCLUDING DUCT SOME STATES DO NOT A HAVE OTHER RIGHTS THAT VARY installa aville CA 95688
11. pipe and chimney system DO NOT ENCLOSE DOUBLE WALL CONNECTOR PIPE or fittings and or pass through walls ceilings attics or closets DVL Pipe cannot be cut DVL Close Clearance Connector pipe will exhibit a moderate paint like odor and smoke during the first few uses This is the normal 4 curing of the finish and will disappear after a few uses of the appliance Chimney Adapter S O Elbow e T ppe f en ing pipe 4 Adjustable 2 JS e S Pipe Tee Stove M Rear exiting stove to a through the wall Chimney Top exiting stove to a through the ceiling Chimney Figure 1 MOBILE HOMES Solid fuel appliances installed in mobile homes must be listed and bear the label of a testing agency approved by the Department of Housing and Urban Development HUD and must be installed exactly in accordance with the manufacturer s installation instructions DuraVent s DVL stovepipe complies with the requirements for mobile home use on HUD approved appliances Refer to stove manufacturer s installation instructions Those instructions will also clearly state all clearance requirements and approved installation configurations DO NOT USE THIS PRODUCT IN A MOBILE HOME IF the stove to be installed is not listed for use in a mobile home oe 29 es 1 2 INSTALLATION 1 Attaching DVL to a DuraVent Chimney Trim Ring Adapters Figure 2 Insert inner sleev
Download Pdf Manuals
Related Search