Fire Sense 60523 Instructions / Assembly
Contents
1. AK Yi i W t NVVVV AAA NK vyeeyyeeee NYY yee or s st s s s s s G a 5 s r s s s a os G s s s E PE s s s s hT IN sAn aa AYU 12 Screw the handle 18 onto the front panel 16 attach the panel Completed by inserting its two hooks into the holes on the bottom plate 3 Hook the chain 19 to the hole in the control box then close the panel to the middle plate the panel is attached by the magnets Tips the chain can hold the panel while operating the control i OPERATION PREPERATION You will need to purchase a standard 20 Ib LPG cylinder designed to be used with the regulator purchased or supplied For correct operation of the gas system follow the instructions supplide with the regulator supplied Connect the hose to the hose connector in the control box Warning Always test the hose and connections for leaks with soapy water at the end of all connections WARNING e Never use the heater while it is raining The glass tube will break when it comes in contact with water e Never splash any liquid on the glass tube when the heater is working e The glass tube will be extremely hot when it is working Never try to touch it and do not allow children to try to touch the glass tube e Always ensure the heater is on firm level ground The glass tube will break if the heater falls and hits objects or the ground e Never use the h2. Model SPO1 SP02 40000BTU Item 60523 Pyramid Heater ww 1 N VYR 4 WARNING FIRE OR EXPLOSION MAY RESULT A IF INSTRUCTIONS ARE IGNORED 2 It is the consumer s responsibility to see that the patio heater is i properly assembled installed and taken care of Failure to follow p j instructions in this manual could result in bodily injury and or p l property damage Cs PRECAUTIONS e Leak test all connections after each tank refill e Never check for leaks with a match or open flame e Do not store or use gasoline or other flammable substances in the vicinity of this or any other appliance Any LP cylinder not connected for use should not be stored in the vicinity of this or any other appliance vy CALLI MAAAXYYKYY A WW veut vy Ler AA YYYY NYY y A N A aun vtt 1 ener y t AKIT XA Ni 3 f J Uh FAINI y y A FOR YOUR SAFETY IF YOU SMELL GAS 1 Turn off the gas supply at cylinder 2 Extinguish all flames 3 Do not operate any electrical appliances 4 Ventilate the area 5 Check for leaks as detailed in this manual 6 If odor persists contact your dealer or gas supplier immediately Conforms to ANSI n STD Z83 26a 2008 Certified to CSA C US STD 2 37a 2008 LISTED Intertek 4006932 FOR OUTDOOR USE ONLY USES LPG ONLY PLEASE READ INSTRUCTIONS CAREFULLY BEFORE ASSEMBLY RETAIN THIS MANUAL
3. FOR REFERENCE IMPORTANT NOTICE Do NOT return to place of purchase For customer service and warranty issues contact our Toll Free Hotline at 866 985 7877 OR Email cservice welltraveled net Hotline hours Mon Fri 9 00 am 6 00 pm EST CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide which has no odour Using it in an enclosed space can kill you Never use this appliance in an enclosed space Such as a camper tent car or home Keep electrical supply cord away from the heated surfaces WARNING Improper installation Tools NERCEC adjustment alteration service or main e Open end wrench 10 amp 13mm tenance can cause injury or property included damage Read the installation operating i and maintenance instructions thoroughly NOT included before installing or servicing this equip e Adjustable opening wrench 8 long ment e Philips screwdrive rw medium blade e Spray bottle of soapy solution for leak WARNING cesung For Outdoor Use Only LPG Cylinders to be used must be con structed and marked in accordance with US DOT specifications Storage of the heater indoors is permis sible only if the gas cylinder is turned off and removed NOTE Use only 20lb LP Gas tank with size of 18 1in 46cm Height 12 5in 32cm Width Do not use if the environment temperature is below 40 degrees F 4 4 degrees C The LP gas cylinder to be used must be provided with a listed ove
4. POSSIBILITY OF SUCH LOSSES COSTS OR DAMAGES OR IF SUCH LOSSES COSTS OR DAMAGES ARE FORESEEABLE IN NO EVENT WILL WELL TRAVELED LIVING OR ITS OFFICERS DIRECTORS OR AGENTS BE LIABLE FOR ANY DIRECT LOSSES COSTS OR DAMAGES THAT EXCEED THE PURCHASE PRICE OF THE PRODUCT SOME JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO THE PURCHASER This limited warranty gives you specific legal rights and you may also have other rights which vary from jurisdiction to jurisdiction The provisions of the United Nations Convention on Contracts for the Sales of Goods shall not apply to this limited warranty or the sale of products covered by this limited warranty IMPORTANT NOTICE Do NOT return to place of purchase For customer service and warranty issues contact our Customer Service Center at 866 985 7877 OR Email cservice welltraveled net Customer Service Hours Mon Fri 9 00 a m 6 00 p m EST Fire Sense Mojave Sun and Well Traveled Living are registered trademarks of Well Traveled Imports Inc All assembly instruction presentations are the property of Well Traveled Imports Inc and are protected by U S copyrights and trademarks All rights reserved
5. alling All warranty service will be coordinated by the Well Traveled Living s Amelia Island Florida service center This warranty is extended only to the original purchaser Proof of purchase will be required before warranty service is rendered The sales receipt is the only valid proof of purchase This warranty only covers failures due to defects in materials or workmanship which occur during normal use Failures and or damage which result from accident negligence misuse abuse neglect mishandling alteration or modification failure to maintain improper assembly or maintenance service by unauthorized agency or use of unauthorized components or damage that is attributable to acts of God are NOT covered THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED ABOVE PURCHASER ASSUMES ALL RISKS IN THE ASSEMBLY AND OPERATION OF THIS UNIT FAILURE TO FOLLOW WARNINGS AND OPERATIONAL INSTRUCTIONS CONTAINED IN THIS MANUAL CAN RESULT IN SEVERE PROPERTY DAMAGE AND OR PERSONAL INJURY IN NO EVENT WILL WELL TRAVELED LIVING OR ITS DIRECTORS OFFICERS OR AGENTS BE LIABLE TO THE PURCHASER OR ANY THIRD PARTY WHETHER IN CONTRACT IN TORT OR ON ANY OTHER BASIS FOR ANY INDIRECT SPECIAL PUNITIVE EXEMPLARY CONSEQUENTIAL OR INCIDENTAL LOSS COST OR DAMAGE ARISING OUT OF OR IN CONNECTION WITH THE SALE MAINTENANCE USE OR INABILITY TO USE THE PRODUCT EVEN IF WELL TRAVELED LIVING OR ITS DIRECTORS OFFICERS OR AGENTS HAVE BEEN ADVISED OF THE
6. eater if the glass tube has a crack or chip LIGHTING INSTRUCTIONS Check and ensure that a AA battery is inside the ignition chamber The anode side of the battery must face out 1 Ensure that the control knob is OFF and slowly open the gas cylinder valve 2 Press and turn the control knob to PILOT 3 Check for the pilot flame through the glass tube If the pilot does not light turn the control knob to the lt lt OFF gt gt position and try again from the beginning Several attempts may be necessary With the pilot light lit keep the control knob depressed pushed down for 15 seconds then turn the control knob to lt lt LOW gt gt For maximum heat turn the control knob to lt lt HIGH gt gt 6 To turn the heater off turn the control knob to lt lt OFF gt gt Close the valve on your LP cylinder to conserve gas wn when not in use 10 MAINTENANCE STORAGE CLEANING amp MAINTENANCE To enjoy years of outstanding performance from your heater make sure you perform the following maintenance routines on a regular basis e Keep exterior surfaces clean Use warm soapy water for cleaning Never use flammable corrosive or abrasive cleaners While washing your unit be sure to keep the area around the burner and pilot assembly dry at all times If the gas control is exposed to water in any way do NOT try and use it It must be replaced At least once a year the unit should be inspected for spiders spide
7. en fix the upper plate with screws 17 6 to the 4 upper supports 5 with screws 17 oF 7 Install a AA battery 20 into the control box then fix the control box 2 underneath the middle plate 1 with screws 17 a 10 9 Fix the reflector 10 onto the damper 9 with screws 17 Rubber ring 22 8 Carefully put the glass tube 8 up through the center of the hole in the upper plate 6 Make sure the rubber ring 22 is attached on the lower end of the glass tube Move and sit the glass tube through the hole of the plate cover 7 on the middle plate 1 check and ensure that the glass tube covers the center hole of the middle plate WhbhbsWibhiA ban 10 Attach the protection guards 11 onto the upper frame by putting its hooks into the holes of the frame Fix the guards by fixing the brackets 14 i mil wl Ferta PPT regres Te ti tt ie wlll i TT i lit prea are iili 13 Connect gas hose to 20 Ib LPG cylinder not included Attach regulator to cylinder Tighten securely Move cylinder to the plate of base assembly Attach the cylinder to the base with 3pcs M amp 8x12 bolts and tighten it in order to prevent the cylin 11 Fix three side panels 15 with the screws 17 der from moving on the base Note Note Do not cover the side where the control knob is The regulator with gas hose is supplied an WAYS Y NYX NAAS y AYYY AY
8. isted Straigten hose and perform leak test on hose Blockage in burner injector Clean or replace burner injector Burner flame goes off l Low gas pressure Let the pilot flame stay light for 10 minutes before setting immediately after ignition variable knob to LO Thick black smoke Blockage in burner Turn off the heater and let it cool Remove blockage and clear burner inside and out Carbon buid up Dirt or film on reflector and flame screen Clean reflector and flame screen AD Distributed By Well Traveled Living 716 S 8 Street Amelia Island FL 32034 Toll Free 866 WTL SUPP Web www wtliving com Email cservice welltraveled net 1 YEAR LIMITED WARRANTY Customers in the Continental US All components are warranted for a period of 1 year after date of purchase by the original owner against defects in materials and workmanship under normal use This warranty does NOT cover normal wear and weathering assembly and or maintenance OR use in a commercial application At Well Traveled Living s sole discretion products under warranty will be repaired and or replaced at no charge to the customer Any returns sent back to Well Traveled Living must be sent via prepaid freight and in the original retail packaging For warranty service contact Well Traveled Living at the address phone numbers or internet site and email listed in this owners manual Be sure to have your sales receipt date of purchase and catalogue model numbers available when c
9. le hose must be changed within the prescribed intervals e Use only the type of gas and the type of cylinder specified by the manufacturer e In case of violent wind particular attention must be taken against tilting of the heater e Storage of the heater indoors is permitted only if the cylinder is disconnected and removed from the appliance e Do not store a spare LPG cylinder under or near this heater e Never fill the cylinder beyond 80 percent full HEATER PLACEMENT AND LOCATION e The heater is for outdoor use only e Do not use it indoors or in enclosed areas e Always ensure that adequate fresh air ventilation is provided e Always maintain proper clearance from combustible materials i e top 32 top 26 side e Heater must be placed on level firm ground e Never operate heater in an explosive atmosphere like in areas where gasoline or other flammable liquids or vapors are stored Open side at least 30 or more in total of 25 of total wall area remaining wall area is open and unrestricted 30 or more in total of remaining wall area is open and unrestricted Cilia WARNING DO NOT SMOKE LEAK TESTING WHILE LEAK TESTING Gas connections on the heater are leak tested at the factory prior to shipment Possible mishandling of the heater during the shipment might contribute to product integrity as a whole A complete gas leakage test must be performed again at the installation site Please follow the
10. ne by a qualified person The heater must be inspected before use and at least annually by a qualifed person More frequent cleaning may be required as necessary It is imperative that control compartments burners and circulating air passages of the heater and light be kept clean and free from insect spider infestation I MS Oe E ee PARTS LIST PartNumber__ Part Name D Oom an Lower support Damper 1 Pre assembled in the upper plate Lower protection i guard ALU Br Pre assembled under the bottom plate Fixing bracket 2 side panel with alge panel round holes 1 without hole Screw All pre assembled 3 16 in relative parts hande a een cylinder EC i 1 fixed parts e aea O Ls J Ys Ls HEATER ASSEMBLY Tools Required NOT INCLUDED 1 Phillips head screwdriver 1 adjustable cresent wrench 1 Attach wheel 12 assembly to bottom _ 2 Disassemble the water box 13 connect the LPG plate 3 cylinder fixed parts 21 on the bottom plate 3 then connect the water box under the bottom plate 3 3 Take the control box 2 and the plate cover 7 off the middle plate 1 by unscrewing the screws 17 4 Connect and fix the 4 lower supports 4 to the bottom plate 3 and middle plate 1 with screws 17 5 Connect 4 upper supports 5 to the lower supports 6 Fix the plate cover 7 onto the middle plate 1 4 with screws 17 th
11. procedure below for leakage test 1 Make a soapy solution of one part liquid detergent and one part water The soapy solution can be applied with a spray bottle brush or rag Soap bubbles will appear where the leak is present 2 Make sure the control tap is in the lt lt OFF gt gt position full disk on the control panel 3 Turn on the gas supply and check for bubbles on the hoses and connections If the solution starts to bubble that means that a leak is present 4 If a leak is present turn OFF the gas supply immediately tighten any leaking fittings carefully and recheck to see if it still continues to leak 5 Never leak test while smoking INSTALLATION Important Safety Rules This heater is for OUTDOOR USE ONLY This heater shall not be installed or used indoors in buildings garages or any other enclosed area DO NOT place articles on or against this heater DO NOT use or store flammable materials near this heater Children and adults should be aware of the high surface temperature hazard and should keep a safe distance away to avoid clothes burning or igniting Children should be carefully supervised when they are in the area of the heater NEVER hang anything including clothes or other flammable items on the heater DO NOT operate this heater unless it is fully assembled with the reflector in place DO NOT SPRAY AEROSOLS IN THE VICINITY OF THIS HEATER WHILE IT IS IN OPERATION Installation and repair should be do
12. r webs or other insects air flow might be obstructed e Keep controls burner and circulating air passageways clean Signs of possible blockage include Gas odour with extreme yellow tipping of flame Heater does not reach the desired temperature Heater glow is excessively uneven Heater makes popping noises e Spiders and insects can nest in burners or orifices This dangerous condition can damage the heater and render it unsafe for use Clean burner holes by using a heavy duty pipe cleaner Compressed air may help clear away smaller particles e Carbon deposits may create a fire hazard Clean reflector and glass tube with soapy water if any carbon deposits develop Always be careful when cleaning the glass tube STORAGE Between Uses e Turn the control knob to lt lt OFF gt gt position e Turn the LP cylinder to the lt lt OFF gt gt position e Store the heater upright in an area sheltered away from weather conditions such as rain sleet hail and snow If desired cover heater to protect exterior surfaces and to help prevent dust and debris collecting in air passages Do not apply cover until heater has completely cooled DURING PERIODS OF EXTENDED INACTIVITY OR WHEN TRANSPORTING e Turn the control knob to lt lt OFF gt gt position e Disconnect LP cylinder and move to a secure well ventilated location outdoors Do NOT store in a location that will exceed 120 degrees farenheit e Store heater upright in an area sheltered a
13. rfilling prevention device Do not store a spare LP gas cylinder under or near this appliance Never fill the cylinder beyond 80 percent full The gas pressure regulator provided with this appliance must be used This regulator is set for an outlet pressure of 11 inches water column PRECAUTIONS PLEASE READ THE FOLLOWING SAFETY RULES WARNING This heater must only be used outdoors Using this product in an enclosed area may cause injury death or property damage Read instructions before use This heater must be used in accordance with your local area s regulations and bylaws Installation and service should be done by a qualified person Do not use the heater in an explosive atmosphere i e areas where gasoline or other flammable liquids or vapors are stored e Before use check the regulator e Disconnect LPG cylinder before moving the heater Do not attempt to alter any part of heater Example Using the heater without reflector or protection guard e The heater should not be used in basements or below ground level e The heater must always be placed on a solid and level surface e Never replace or substitute the regulator with a regulator that does not meet the specifications on page 2 Do not clean the heater with cleaners that are combustible or corrosive Do not paint any part of the heater The LPG cylinder valve should be turned off and disconnected when the heater is not in use e Do not use heater
14. way from weather conditions such as rain sleet hail and snow If desired cover heater to protect exterior surfaces and to help prevent dust and debris collecting in air passages DO not apply cover until heater has completely cooled WARNING FOR YOUR SAFETY e DO NOT touch or move heater for at least 45 minutes after each use Allow all burner elements to cool before touching NOTE e In a salt air environment such as near an ocean corrosion occurs more quickly than normal e Frequently check for corroded areas and repair them promptly e Wait until heater is cool before covering 11 TROUBLE SHOOTING PROBLEM PROBABLE CAUSE SOLUTION Pilot will not light Gas valve may be OFF Turn the gas valve ON Fuel tank is empty Refill LPG cylinder Orifice blocked Clean or replace orifice Air in supply system Purge air from lines Loose connection Check all fittings Pilot will not stay on Debris around pilot Clean dirty area Loose connection Tighten connections Thermocouple bad Replace thermocouple Gas leak in line Check connections using leak test Lack of fuel pressure Fuel tank is near empty Refill Burner will not light Pressure is low Fuel tank is near empty Orifice blocked Remove clean and replace Control Valve not ON Turn valve ON Thermocouple bad Replace thermocouple Pilot light assembly bent or not in correct location Place pilot light in correct position and retry Burner flame is low Supply hose is bent or tw
15. when it is raining and do not let any liquid splash on the glass tube when the heater is working Keep children away from the heater Always be careful not to knock over the heater as this could cause breakage of the glass tube and cause injury Do not move the heater when in operation After a long break of operation the gas parts in the control box of the heater and the hose should be inspected for spiders spider webs or other insects Check the heater immediately if any of the following exists 1 There is smell of gas 2 The heater is not burning properly 3 The burner makes popping noise during use a slight popping noise is normal when the burner is extinguished after use If you smell gas turn off the valve immediately If smell persists contact your dealer or gas supplier immediately The hose with regulator assembly should be stored in a safe place to avoid accidental damage e Children and adults should be aware of the hight surface temperature hazard of the heater and should keep a safe distance away to avoid clothes burning or igniting e Young children should be carefully supervised when they are in the working area of the heater e Clothing or other flammable material should not be hung from the heater or placed on or near the heater co Bie e Do not obstruct the ventilation holes of the cylinder housing e Shut off the valve of gas cylinder or the regulator before moving the appliance e The tubing or the flexib
Download Pdf Manuals
Related Search