DECOLAV 1679-MBE Installation Guide
Contents
1. be aginst the wall o Apply a bead of silicone to the bottom edge of the backsplash and to the back of the backsplash Apply backsplash to the back of the vanity top and the wall o Let Silicone Cure per manufactures specification before using Backsplash vanity lop Use Silicone on the Bottom and the Back Edge of the Backsplash Apply a Small Amount of Silicone to the areas shown INSTALLING THE TOP ON THE VANITY CONSOLE VANITY DRAWER o Apply a small amount of Silicone to the areas shown Figure I o Because of the decorative moulding that is directlly below the Vanity top the Drawer Console top and the Vanity drawer top must be slid in from the front See Figure o The back edge of the Vanity drawer and Drawer Console should be flush with the back of the Vanity Drawer chassis and the back of the Drawer console Chassis Apply a Small Amount of Silcone pply a Small Amount of Silcone to the areas shown o the areas shown O J Peer conso Vanity Drawer Top 1 Drawer Console Top Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS DECOLAV JORDAN MODULAR SERIES Adjusting the Hinges ADJUSTING THE HINGES o The rear screw will move the door closer to the end panel or away from the end panel If the door is rubbing the end panel use this adjustment screw Remem2. DECOLAV JORDAN MODULAR SERIES ATTACHING UNITS 5361 Vanity 5332 Vanity with 5233 Vanity with with 1666 Top 1667 Top 1668 Top l 5235 Drawer Console 5336 Vanity Drawer with 1669 Top with 1670 Top a Note Tops are to be purchased separately the are not included with base unit Tops Shown on items for illustration purposes only TABLE OF CONTENTS Installation Instructions Page O Product Configurations 2 o Installing the Vanity 4 O Installing the Drawer Console with the Vanity and Support leg 5 amp 6 o Installing the Vanity Drawer with the Vanity and the Support Leg 6 amp 7 o Installing the Sink to the Vanity Top 8 0 Installing the top to the Vanity 9 o Hinge Adjustment and Care and Cleaning 10 O Limited Lifetime Warranty 11 Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS Ta aa LLI U o L Q O Zz L Q oc O a DECOLAV E BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS N Z e N N lt oO jaa gt SS ut lt Lu U N lt Lu jaa m a 5 gt Lu Note Products shown above with optional accessories Mirrors Sinks Vanity Tops and Vanity Stools avalible separately Customer Service 561 274 2110 PRODUCT CONFIGURATIONS www decolav com DECOLAV RUSTIC MODULAR SERIES THANK YOU Dear Valued Customer DEC
3. NOT COVER ANY LIABILITY FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES ALL OF WHICH ARE HEREBY EXPRESSLY DISCLAIMED OR THE EXTENSION BEYOND THE DURATION OF THIS LIMITED WARRANTY Some states do not allow the exclusion or limitation of incidental or consequential damages so the above limitation or exclusion may not apply to you THE WARRANTIES HEREIN e ARE EXCLUSIVE AND STATED IN LIEU OF ALL OTHER WARRANTIES WHETHER EXPRESS STATUTORY OR IMPLIED INCLUDING BUT NOT LIMITED TO THE WARRANTIES OF MERCHANTABILITY AND FITNESS FOR AN INTENDED PURPOSE ALL OF WHICH ARE HEREBY EXPRESSLY DISCLAIMED e NEITHER ASSUME NOR AUTHORIZE ORIGINAL END CONSUMER NOR ANY OTHER PARTY TO ASSUME ANY OTHER LIABILITIES IN CONNECTION WITH THE MANUFACTURE OR SALE OF THE PRODUCT e ARE SUBJECT TO THE LIMITATIONS ON DAMAGES AS SET FORTH ABOVE Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS
4. OLAV would like to take this opportunity to thank you for your purchase It is our sincere hope that you are completely satisfied with your new product We welcome and look forward to helping you create another unique look for your next bathroom project Prior to installation please take a moment to review all provided materials and hardware For assistance with your new product please contact our dedicated DECOLAV customer service staff Sincerely DECOLAV Robert H Mayer Chief Executive Officer and President CHANGING THE WAY YOU VIEW THE BATHROOM BEFORE YOU BEGIN 1 Prior to installation unpack your new DECOLAV product and inspect it Keep the product in its original package until you are ready to install it 2 The wall must be square plumb and level 3 Shut the water supply off when replacing an existing fixture Preparation of the floors and walls including all additional wall supports may be required 4 Observe all local plumbing and building codes 5 It is recommended that a professional contractor be retained for the installation of this product 6 Anchors and wall screws are not provided RECOMMENDED TOOLS D u oE oel Tape Measure Adjustable Wrench Pipe Clamp Channel Locks Drill Hack saw Level r GTA SS At Toe SEN W Prilips Pipe Wrench PESAT EIR UE Putty Knife ainean Scroll Saw Pipe Cutter Sc
5. W LH N EE E Figure C Customer Service 561 274 2110 LETYOURDREAMSCOMEALIVEYOURPASSIONS www decolav com BECOMEREALITYBETH NVYOFYOURNEIGHBORS DECOLAV JORDAN MODULAR SERIES 6 INSTALLING A DRAWER CONSOLE AND THE SUPPORT LEG TO THE VANITY Figure D INSTALLING THE VANITY DRAWER AND THE SUPPORT LEG TO THE VANITY O O O O O O O Unpack the Vanity Drawer Vanity and Support Leg Remove the door and drawers from the Vanity Drawer and the Vanity This will make installation a lot easier Look inside the Vanity you will see 2 holes near the top of the Vanity These holes are bored halfway through from the factory On the side that you wish to hook the Vanity Drawer to bore the holes all the way through using a 394 10 mm drill bit Lay Vanity and Vanity Drawer on the floor back down Slide the Vanity Drawer next to the Vanity lining up the holes at the top Using the connecting bolts and T nuts attach the drawer console to the Vanity The T nuts go on the Vanity Drawer side and the Connecting Bolts go on the Vanity side Tighten connecting bolts and insert three small wood screws into the holes in the T nut This will lock the T nut in place Figure E There will be 3 unused holes below the T nut holes on the Vanity Drawer These holes are for connecting screws Install the 3 screws through the Vanity Drawer and into the vanity using a cord
6. ber to adjust both hinges on the door for the desired clearance o To get the doors even across the top and bottom edges of the doors use the side to side adjustment screw Remember to adjust both hinges on the door for the correct position o Doors were adjusted at the factory prior to shipping but due to the variances in home walls the hinges may need slight adjustment E Side to Side Adjustment Front to Back Adjustment CARE AND CLEANING e DO NOT OVERTIGHTEN DRAIN Overtightening of the drain can damage your DECOLAV product e DO NOT clean the product with Detergents Acid Abrasives Harsh Cleaners or a cloth with a coarse surface S O S Pads Scotch Brite Pads This is good advice for any plumbing fixture regardless of material e DO NOT leave any cleaning agents other than water on your DECOLAV product e DO NOT allow your DECOLAV product to unnecessarily encounter other solid objects e DO clean your DECOLAV product Wipe with a damp cloth and dry with a soft cloth If necessary a general mild soap and water solution can be used Use a mild furniture polish to clean wood frame e DO clean underside of your DECOLAV product with mild soap and water ONLY Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS DECOLAV JORDAN MODULAR SERIES LIMITED LIFETIME WARRANTY Any Deco Lay Inc DECOLAV product s sold af
7. h o Drill 2 3 16 diameter holes in the vanity back rail These holes will be used to connect the vanity to the wall using wall anchors or screws not included o Carefully Position the vanity in the desired location o Level the vanity side to side and front to back using a carpenter s level and adjust the leg levelers The leg levelers are located at the bottom of each leg o Attach vanity to wall using wall anchors or screws not included Figure A O OOOO Customer to bore holes in the back rail for attching the vanity to the wall Notes Customer to make cutout o We recommend two people to install this vanity in vanity back panel Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS DECOLAV JORDAN MODULAR SERIES INSTALLING A DRAWER CONSOLE AND THE SUPPORT LEG TO THE VANITY o Unpack the Drawer Console Vanity and Support Leg o Remove the door and drawers from the Drawer console and the Vanity This will make installation a lot easier o Look inside the Vanity you will see 2 holes near the top of the Vanity These holes are bored halfway through from the factory On the side that you wish to hook the drawer console or the Vanity Drawer to bore the holes all the way through using a 394 10 mm drill bit Lay Vanity and Drawer Console on the floor back down Slide the Drawer Console
8. less screwdriver Figure E Place the support leg next to the Vanity Drawer Line up the the preinstalled insert nut holes with the holes in the end panel of the drawer console Figure E Using the connecting bolts attach the support leg to the Vanity Drawer Only 2 connecting bolts will be used At the bottom of the Vanity Drawer there are 3 screw holes below the T nut holes Install screws into the support leg using a cordless screwdriver Figure E Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS DECOLAV JORDAN MODULAR SERIES Factory installed Nut 4 total insert nuts mall Wooa Zs 12 total Zi S T T DN Q D E amp R OSA Q7 G Q Bolt 4 Total onnecting Bolt 4 Total Flat Washer 4 total Z Flat Washer 4 total here are 2 holes on each end panel of the vaity The holes are bored half way through the panel from the factory Customer will a bore holes all the way through Bore all both hole through the panel when hooking up the Drawer Console or the Vanity Drawer INSTALLING THE SINK TO THE VANITY TOP o The Sink and the Vanity Top o Lay the top upside down on the Floor o Using Epoxy not included glue the four brass inserts Figure F into their respective holes o Allow cure time per epoxy manufactures recommendations Apply Epox
9. local code compliance prior to installation If you believe that you have a valid warranty claim contact your Home Center Dealer Plumbing Contractor or E tailer Please be sure to provide all pertinent infor mation regarding your claim including a complete description of the problem the product model number the date the product was purchased from whom the product was purchased and the installation date and location Also be sure to provide a copy of your original purchase invoice For other questions please write to us at Deco Lav Inc Attn Returns Processing 314 S Chimney Rock Road Greensboro NC 27409 Upon satisfaction of each of the foregoing conditions and requirements DECOLAV shall at its option either repair or replace the defective product DECOLAV shall return any product repaired or replaced under this limited warranty to the original end consumer transportation prepaid All Closeout Discontinued product s at time of a valid warranty claim will either be repaired or replaced with a comparable item DECOLAV s option to repair or replace the product under this limited war ranty does not cover any cost of labor to remove or install the DECOLAV product usage and delay time or other costs of removal or installation whatsoever IN NO EVENT WILL DECOLAV BE LIABLE FOR THE COST OF REPAIR OR REPLACEMENT OF ANY INSTALLATION MATERIALS INCLUDING BUT NOT LIMITED TO COUNTERTOPS TILES MARBLE GRANITE ETC THIS LIMITED WARRANTY DOES
10. next to the Vanity lining up the holes at the top o Using the connecting bolts and T nuts attach the drawer console to the Vanity The connecting T nuts go on the Drawer console side and the Connecting Bolts go on the Vanity side Tighten connecting bolts and insert three small wood screws into the holes in the T nut This will lock the T nut in place Figure 3 o There will be 3 unused holes at the bottom of the Drawer console below bottom panel These holes are for connecting screws Install the 3 screws through the drawer console and into the vanity using a cordless screwdriver Figure D o Place the support leg next to the drawer console Line up the the preinstalled insert nut holes with the holes in the end panel of the drawer console Figure C o Using the connecting bolts attach the support leg to the Drawer console Only 2 connecting bolts will be used At the bottom of the drawer console there are 3 screw holes below the bottom panel Install screws into the support leg using a cordless screwdriver Figure D O O T Nut 4 Total Small Wood Screw There are 2 holes on each end panel of the vaity The 12 total holes are bored half way through the panel from the 2 total factory Customer will bore holes all the way through Bore all both hole through the panel when hooking up the Drawer Console or the Vanity Drawer Q Aa N W RN Connecting Bolt 4 Total Flat Washer 4 Total N Y Va W
11. rewdriver P or Caulking y Screwdriver ESA Pencil Square Ruler Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS DECOLAV JORDAN MODULAR SERIES Hookup Hardware Included with the Vanity Drawer and the Drawer Console Bf Flat Washer Included with Drawer Console and Vanity Drawer Connecting Wood Screw Included with Drawer console and Vanity eer D T nut Included with Drawer Console and Vanity Drawer Small T nut screw included with Drawer console and Vanity Drawer Insert Nut Factory installed on Support Leg Note Hookup Hardware is Only Provided with the Vanity Drawer and the Drawer Console No Hookup Hardware is Provided with the Vanities INSTALLING THE VANITY o Ifa Vanity drawer or a Drawer console is to be hooked to the vanity skip to the hook up sections on Page 5 and 6 Follow hook up steps Once Vanity hookup is complete follow Vanity installation instructions Carefully remove vanity from carton and place safely aside Turn off water supply to faucet Remove existing vanity Determine the location on the wall where the vanity will be installed Measure the vanity width and height and mark outline on wall o Measure and mark the locations of the plumbing pipes and lines o Make a cutout in the back panel of the vanity using a circular saw or saber saw allow enough room for the plumbing lines and pipes to pass throug
12. s limited warranty does not cover any mechanical pieces of any DECOLAV product These mechanical pieces will be covered under a One Year Warranty with all other terms of this warranty applying except duration This limited warranty does not cover the finish color or plating of any DECOLAV product The finish color or plating of any product will be covered under a One Year Warranty with all other terms of this warranty applying exception duration If this product is used commercially or installed outside of North America DECOLAV warrants the product to be free from defects in material and workmanship for one 1 year from the date of installation with all other terms of this warranty applying except duration THIS LIMITED WARRANTY DOES NOT COVER ANY DAMAGES CAUSED BY SHIPPING MISUSE ABUSE ACCIDENTS NEGLECT UNAUTHORIZED REPAIRS OR ALTERATIONS MODIFICATIONS USE OF OTHER THAN GENUINE DECOLAV REPLACEMENT PARTS DIRT LIME SCALE AND OTHER MINERALS SCUFFS AND SCRATCHES EXPOSURE TO MARINE AREAS ABNORMAL USAGE AND NORMAL WEAR AND TEAR ANY IMPROPER INSTALLATION IMPROPER MAINTENANCE IMPROPER HANDLING IMPROPER AND CONTRARY USES IMPROPER CARE AND CLEANING AND ALL ACTS BEYOND DECOLAV s CONTROL WILL VOID THIS LIMITED WARRANTY This limited warranty does not apply to local building code compliance Since local building codes vary considerably the original end consumer of the product s should check with a local building or plumbing contractor to ensure
13. ter December 1 2010 will be warranted to the original end consumer to be free of true defects in material and workmanship during normal residential use for as long as the consumer owns his or her home subject to the following e Proof of purchase original sales receipt from the original end consumer must be made available to DECOLAV for all warranty claims e The person claiming a warranty issue must be able to establish original purchase and installation of the product e Authorized DECOLAV personnel have inspected the product s and determined the product s to have true manufacturing defect s unless other arrange ments satisfactory to DECOLAV have been agreed upon e Such product s are returned to DECOLAV unless other arrangements satisfactory to DECOLAV have been agreed upon e The product must have been purchased directly or indirectly through an authorized DECOLAV reseller This limited warranty is non transferable and applies only to the original end consumer and to the original installation of the product This limited warranty is void if the product has been moved from its initial installation site or if ownership of the product has changed DECOLAV s product are produced from natural raw materials and there may be a slight color variance from product appearing in catalogs brochures web sites or product samples or prior production These are not examples of manufacturing defects and will not be covered under this warranty Thi
14. y to Each Hole Customer Service 561 274 2110 LETYOURDREAMSCOMEALIVEYOURPASSIONS www decolav com BECOMEREALITYBETH NVYOFYOURNEIGHBORS DECOLAV JORDAN MODULAR SERIES 8 Installing the Sink to the Vanity To o Place the sink on the bottom side of the top o Apply the mounting clips and snug them slightly o Center the sink in the cutout it may be necessary to look at counter from top side thats why the the clips are to be used in this step o When Sink is in the desired location using a magic marker make an outline around the sink on to the top o Loosen the clips and remove the sink apply silicone to the area inside the outline you just made o Place sink onto the under side of the top align sink with the outline o Tighten mounting clips and check for proper alignment o If alignment is satisfactory wipe up excess silicone and let cure per silicon manufacturers reccomendations Brass Insert Mounting Clip Vanity P Top Customer Service 561 274 2110 LET YOUR DREAMS COME ALIVE YOUR PASSIONS www decolav com BECOME REALITY BE THE ENVY OF YOUR NEIGHBORS DECOLAV JORDAN MODULAR SERIES 9 INSTALLING THE TOP TO THE VANITY o With the vanity in the desired location Place a small bead of silicone to the areas shown in Figure G o Carefully lower top into position There will be approximately 1 4 inch of top overhang on either side of the top Back of top should
Download Pdf Manuals
Related Search