Rohl A3608LMWSSTN-2 Instructions / Assembly
Contents
1. C7597 SPRING C7108 8 BLACK FACEPLATE C7108 7 RING DISASSEMBLING BUTTON Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com 17 ROHL Authentic Luxury for Kitchen and Bath www rohlhome com Installation Instructions LOW FLOW OR NO FLOW TROUBLESHOOTING INSTRUCTIONS ALL MODELS A3608 shown Current kitchen faucets have a flow rate of 1 5 GPM from the aerator and the hand spray If you are experiencing low flow from the spout Do not change the cartridge e Unscrew and clean the aerator 1 e Unscrew and clean the filters inside the supply connections 3 e Check the supply lines for kinks or obstructions 3 e Make sure the supply line stops are fully on Not shown If you faucet has a hand spray and your hand spray has obstructed flow or no flow e Check the hand spray hose for kinks 5 e Unscrew and clean the hand spray filter 4 e Clean the aerator in the hand spray 2 Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com 18 ROHL Authentic Luxury for Kitchen and Bath www rohlhome com Installation Instructions Care and use for finishes Country Both Products are all authentic finishes that have not been coated with any product After each use pat the fixture down to2. corrosive chemicals All connections with threads M10x1 male must be hand tighten Do not over tighten Over tightening may cause damage to the hose All faucets washers and o rings are designed and manufactured for use with water Do not expose to household cleaners chlorine cloride hydrochloric acid or other corrosive chemicals Faucets are designed for use with the tempratures and pressures listed below minimum cold water supply 50 F maximum hot water supply 145 F minimum pressure 15 psi maximum pressure 75 psi maximum fixing torque value 10 Ibf ft Please note The recommended best pressure for best performance is between 40 psi and 60 psi More pressure than 60 psi or less pressure than 40 psi may affect the diverting action in side spray faucets Do not use any Rohl Country Nicolazzi faucet with sulphorous water The minimum temperature for all faucets is 50 degrees F Below 50 degrees F will void the warranty When available filter systems must be placed between hot and cold supply lines and the faucet Improper use or non use of filters may make diverting faucets with hand sprays perform poorly Don t modify faucet and their components Use only original spare parts if there are replacements to be ordered Installation must be made by authorized plumbers or installers Improper installation or diagnosis of problems is not covered by the warranty Yearly maintenance of cleaning and flus
3. P Porcelain C7675M Metal C3608 C7546 C7575 C7585 10 C7555 il C7260 7 A5556CR Bs ASSS6CR NOT AVAILABLE AS SPARE PART Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com A3608WS Spare Parts ade ciii C7005KIT DIVERTER C7676P C7675M C7 85 10 C7555 C7282 C7260 7 A5556CR owed A5556CR C7585 wW C7585 z SINCE APRIL 2003 C3608 5KIT C5557 1 S557 1 SINCE NOVEMBER 2003 C7005KIT ASSEMBLING INSTRUCTION A SR Ry RLY RLR p ON THREADED PIVOT ZAAO COLD SPRAY L MEESI Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL A Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions ATTENTION READ THESE INSTRUCTIONS BEFORE INSTALLATION AND USE OF ALL FAUCETS AND WALL VALVES INSTALLATION and WARRANTY INSTRUCTIONS TECHNICAL INFORMATION All flexible hoses are designed and manufactured for use with water in exposed locations only Do not expose to household cleaners chlorine cloride hydrochloric acid or other
4. ROHL Authentic Luxury for Kitchen and Bath FEATURES e Ceramic disc single lever cartridge e 10 25 32 spout height e 9 spout reach e 3 8 cutout e 1 2 NPT flexible supplies e 2 11 64 max depth installation e 1 5GPM e 4 extension kit C7555EXT 4 17 32 4 3 4 MIN 2 33 64 44 ANANN SOELELELEEE sss 13 5 32 one ore 3 NAS ay ASS Bp IOI IIT III AS 2 23 64 MAX L 7 7 8 1 2 NPT FINISHES e Polished Chrome e Polished Nickel e Satin Nickel e Tuscan Brass e Inca Brass 2 21 64 1 11 32 2 1 8 MAX L 59 1 16 www rohlhome com Single Lever Column Spout Faucet Rohl Country Kitchen Collection A3608LPWS Porcelain Lever with Handspray A3608LMWS Metal Lever with Handspray A3608LP Porcelain Lever without Handspray A3608LM Metal Lever without Handspray WARRANTY o Limited Lifetime No Warranty on Tuscan Brass Finish TCB 8 55 64 4 1 16 LMN LULZ 6 49 64 2 23 64 1 1 32 e o pg etetett C i BOO ole ote OOO e FO AY Y gt FRAN RARE RALALG Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com A3608 Spare Parts C7446MC ji C7083 Spout Ring Set C7216 C 2955b C7281 C3009 C 76 76
5. ction is not always possible Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com 13 ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions INSTRUCTIONS FOR REPLACEMENT OF THE C7O05M DIVERTER MODELS AFFECTED A3608WS A3606WS Please note Only replace the diverter if no water is coming out the spout If the hand spray is leaking do not replace the diverter Service or replace the hand spray if there is a continous leak 1 Turn off the hot and cold supply lines to the faucet Remove the handle and dome 2 Remove the screw cover cap 1 3 Tip the lever and dome up to access the 3mm allen key Loosen but do not remove the 3mm allen key Note use only a 3mm wrench No other size will work Remove lever and dome 4 Remove the ring nut cover 3 Remove the cartridge nut with a smooth jawed wrench Remove cartridge Remove the diverter with a dental tool or needle nose pliers e Please note There are serveral types of diverters Verify the diverter being removed is the same as the diverter being installed They will be similar in appearance Improper installation will cause a malfuntion O1 DIVERTER 7 Clean the cavity and remove all debris e Liberally grease the cavity e Grease the new diverter and install e Install the cartridge as shown with the ports in t
6. he right alignment e Install the nut Correct torque on the nut is 16 Newton NM If no gauge is available Hand tighten the nut Tighten a 1 4 turn or until snug Do not over tighten e With the dome and lever off turn on the water and test for leaks e Then install the lever and dome and test the diverter by using the hand spray Please note If there is a 99 divert or small trickle of water out the spout when using the hand spray that is acceptable Due to water conditions a 100 diverting action is not always possible Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com 14 ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions A INSTRUCTIONS FOR SERVICING THE C7108N HAND SPRAY B Please note If the hand spray is dripping constantly when using the faucet the hand spray can be serviced by either stretching the spring or replacing the cartridge A small drip after use that stops is sometimes normal as there is a small space between the black aerator and the stop mechanism that holds a teaspoon of water A drip or two after use is normal C To stretch the spring a Unscrew ring c7108 7 b Remove c7108 8 black faceplate Push the button or remove with tool c Stretch the spring c7597 slightly d Reassemble and test D To change the cartridge in the hand spray c7108ki
7. hing is recommended LJ O CL OO OO Operation and use of any faucet or wall valve that do not conform to these technical instructions will void the warranty Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions INSTALLATION OF SINGLE HOLE FAUCET WITH SIDESPRAY MODELS INCLUDE DUAL LEVER MODELS A1679WS A1676WS SINGLE TOP LEVER MODELS A3606WS A3608 A3479 SINGLE LEVER SIDE LEVER MODELS A3650WS Model A3608WS shown Install the supply hoses into the body Note hand tighten only do not over tighten Install mounting stud securely or verify it is installed Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions Insert faucet into mounting hole Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions Under the sink stack the half ring rubber gasket 6 the half ring mouting plate 7 then the mounting nut 9 ont
8. local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com 1 ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions e Tip the lever and dome up to access the 3mm allen key Loosen but do not remove the 3mm allen key Note use only a 3mm wrench Not other size will work e Remove lever and dome e Remove the ring nut cover 3 Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com 12 ROHL Authentic Luxury for Kitchen and Bath www rohlhome com Installation Instructions MAINTENANCE Remove the cartridge nut with a smooth jawed wrench Remove the cartridge e Clean the cavity and remove all debris e Liberally grease the cavity e Install the cartridge as shown with the ports in the right alignment e Install the nut Correct torque on the nut is 16 Newton NM If no gauge is available Hand tighten the nut Tighten a 1 4 turn or until snug Do not over tighten e With the dome and lever off turn on the water and test for leaks e Then install the lever and dome and test the diverter by using the hand spray Please note If there is a 99 divert or small trickle of water out the spout when using the hand spray that is acceptable Due to water conditions a 100 diverting a
9. nstall the hand spray with the required flat washer with screen on top of the sink e Connect the supply lines to the hot and cold supplies securely Please note make sure the rubber washers with the screens are used These screens will prevent debris from entering the diverter Turn on the water for the hot and cold e Check the diverting action by operating the hand shower Please note If there is a 99 divert or small trickle of water out the spout when using the hand spray that is acceptable Due to water conditions a 100 diverting action is not always possible e Check for leaks Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com 10 ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions MAINTENANCE INSTRUCTIONS FOR REPLACEMENT OF THE C3009 CARTRIDGE MODELS AFFECTED A3608WS A3606WS Please note Only replace the cartridge if the lever is stiff on to off or from hot to cold Do not replace the cartridge if there is low flow or no flow Low flow or no flow is caused by obstruction or kinking of supply hoses If the hand spray is leaking do not replace the diverter Service or replace the hand spray if there is a continous leak e Turn off the hot and cold supply lines to the faucet e Remove the handle and dome Remove the screw cover cap 1 Consult your
10. o the stud Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions Check the position on the sink of the faucet then tighten the nut with a 13mm wrench Note the under deck mounting surface must be flat If the mounting surface is irregular the nut may not be secured and the faucet will be loose on the sink Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions e Insert the hand spray escutcheon into the sink hole Please note make sure the hand spray hole is a minimum of 4 3 4 away from the main body of the faucet e Install the rubber washer 13 the flat metal washer 14 then the nut 15 Secure on the deck but do not over tighten Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions e Install the black hand spray hose to the supply from the faucet under the sink Guide the 9mm male end up through the escutcheon I
11. remove any excess water This will prevent any water spotting or mineral build up Use only soft liquid soap and water to clean the surface Use a soft brush to clean any gaps Avoid any products that have ammonio or alcohol like Windex 409 or Fantastik These products can damage the finish leaving black or white spots Never use on abrasive product like Softscrub Comet Ajax or Bon Ami For deep polishing we recommend Bruno s Wax for all finishings Tuscon Brass is a living finish and has no warranty It will lighten with use To extend the life of the finish apply Bruno s Wax by patting it on letting it dry and patting it off Never rub or buff this finish WARNING the use of cleaning products not recommended might irreparably harm the surfaces of the faucets which in such case are not covered by our warranty The faucet is fitted with an aeration device in the Hot Cold water outlet This may need occasional cleaning especially in hard water areas This is accomplished by unscrewing the outlet in o counter clockwise direction dismantling and leaving the inner screen mesh immersed over night in vinegar or lemon juice Do not use chemical descaling liquids for this purpose Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com 19
12. t a Unscrew the spray head 2 b Unscrew the faceplate ring c Push the button into eject the cartridge from the head d Remove the decorative button from the old assembly JL e Put on the new assembly 2 f Insert in the metal head g Install the spring aerator i and ring e h Install back on the handle Z S i Test the unit for leaks Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com 15 ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions E Clean or replace the back flow preventer c7076 a Disconnect the flexible hose from the spray head b Remove the spray head from the handle 2 c Remove the nylon insert 3 4 d Remove the back flow preventer not shown i Refer to exploded drawing e Replace or clean the check valve f Insert new or serviced check valve back into the handle cy i Note make sure the flow restrictor is not backwards g Reverse steps and test Consult your local ROHL showroom for additional information and specifications For complete warranty details and a list of showrooms go to www rohlhome com ROHL Authentic Luxury for Kitchen and Bath WWW rohlhome com Installation Instructions Spare Parts DA ATTENTION THE O RING MUST BE ALWAYS PALACED BETWEEN THE HANDSPRAY AND HOSE VALVES
Download Pdf Manuals
Related Search