Glacier Bay HDGMBS4 Use and Care Manual
Contents
1. 1 Connecting the feed water supply fitting NOTICE Commonwealth of Massachusetts plumbing codes do not permit the use of saddle valves and require installation by a licensed plumber Comply with plumbing code 248 CMR for installations in the state of Massachusetts Please consult your local plumber Check and comply with local plumbing codes as you plan and install a cold feed supply water fitting The fitting must provide a leak tight connection to the water filter 3 8 in tubing D A typical connection using the water supply fitting B is shown in Figure A An optional connection using standard plumbing fittings not included is shown in Figure B Installation using the Fitting Figure A o Close the cold water shut off valve that is immediately upstream of where you will install the feed water supply fitting Open the faucet to drain water from the sink cold water pipe o Remove the nut that connects the cold water faucet to cold water plumbing o Thread the water supply fitting B onto the pipe and reconnect the nut to the bottom of the fitting Installation using Optional Pipe Fittings compression type shown Figure B o Close the cold water shut off valve that is immediately upstream of where you will install the feed water supply fitting Open the faucet to drain water from the sink cold water pipe o Install a fitting on the cold water pipe to adapt to the 3 8 in OD tubing o If threaded fitti2. Average Maximum EPA Average Maximum EPA Influent Effluent Percent MCL Influent Effluent Percent MCL Contaminant ug L ug L Removal ug L Contaminant ug L ug L Removal ug L Alachlor 50 1 0 gt 98 2 0 Haloketones HK Atrazine 100 3 0 gt 97 3 0 1 1 dichloro 2 propanone 7 2 0 1 99 NA Benzene 81 1 0 99 5 0 1 1 1 trichloro 2 propanone 8 2 0 3 96 NA Carbofuran 190 1 0 gt 99 40 Heptachlor 25 0 01 gt 99 0 4 Carbon Tetrachloride 78 1 8 98 5 0 Heptachlor Epoxide 10 7 0 2 98 0 2 Chlorobenzene 77 1 0 99 100 Hexachlorobutadiene 44 1 0 98 NA Chloropicrin 15 0 2 99 NA Hexachlorocyclopentadiene 60 0 002 gt 99 50 2 4 D 110 1 74 98 70 Lindane 55 0 013 gt 99 0 2 Dibromochloropropane DBCP 52 0 02 gt 99 0 2 Methoxychlor 50 0 1 gt 99 40 o Dichlorobenzene 80 1 0 99 600 Pentachlorophenol 96 1 0 99 1 0 p Dichlorobenzene 40 1 0 98 75 Simazine 120 4 0 97 4 0 1 2 Dichloroethane 88 4 8 95 5 0 Styrene 150 0 5 gt 99 100 1 1 Dichloroethylene 83 1 0 99 7 0 1 1 2 2 Tetrachloroethane 81 1 0 99 NA cis 1 2 Dichloroethylene 170 0 5 gt 99 70 Tetrachloroethylene 81 1 0 99 5 0 trans 1 2 Dichloroethylene 86 1 0 99 100 Toluene 78 1 0 99 1 000 1 2 Dichloropropane 80 1 0 99 5 0 2 4 5 TP silvex 270 1 6 99 50 cis 1 3 Dichloropropylene 79 1 0 99 NA Tribromoacetic acid 42 1 0 98 NA Dinoseb 170 0 24 99 7 0 1 2 4 Trichlorobenzene 160 0 5 gt 99 70 Endrin 53 0 594 99 2 0 1 1 1 Trichloroethane 84 4 64 95 200
3. General Information This system improves the taste and odor and reduces many chemical contaminants in drinking water This system has been tested according to NSF ANSI 42 and 53 for the reduction of the substances listed on the previous page The concentration of the indicated substances in water entering the system was reduced to a concentration less than or equal to the permissible limit for water leaving the system as specified in NSF ANSI 42 and 53 The testing was performed using spiked tap water at a flow rate of 0 74 GPM 2 8 L min pH of 7 5 0 5 pressure of 60 PSIG and temperature of 68 5 F Installation Requirements Pressure Range rreren arra 40 100 psig 276 689kPa Temperate RIN Caia 40 100 F 4 38 C Service Flow Rate maximum cceeece eee 0 74 GPM 2 8 LPM SOV ICC Criiiisa tire a EAE 350 Gallons 1325 Liters The filter element contains activated carbon After the new filter is installed flush water through to allow fine harmless carbon particles to purge from the filter until the fines in the filtered water are no longer visible or approximately 10 minutes Installation and Maintenance All plumbing should be done in accordance with local codes and requirements This system should be installed on a cold water supply only In Massachusetts plumbing codes CMR 248 3 00 and 10 00 shall be adhered to Consult with your licensed plumber Filter should be replaced every 350 gallons or six mo
4. This indicates that it is time to replace the battery and filters CHANGING THE FAUCET BATTERY To change the battery complete the following steps 1 Loosen the screw on the right side of the faucet base Press the battery housing upwards from the faucet base until it releases from the base Replace the battery CR 2032 or equivalent Place battery into the holder with the positive side facing the back of the holder 4 When the battery is first replaced the light in the base will flash six times and turn off This indicates the battery is fully charged After the six flashes the timer enters the 6 month time cycle If it repeatedly flashes two times the battery is weak and needs to be replaced 5 Re install the battery housing and firmly tighten the mounting screw Battery housing IS Battery negative side facing the front Screw 2 9 HOMEDEPOT COM GLACIERBAY Please contact 1 800 247 1087 for further assistance Troubleshooting Problem There is either no or a decreased water flow The water tastes bad and has an odor Faucet LED indicator light does not function after a battery change Water leaks at the push connect fittings Service Parts Part Number 119 8600048 1073 24 01 1073 23 05 24 1073 23 HC O4 7157280 ft white Probable Cause The prefilter is clogged Flow through the purifying filter will decrease and eventually clog when exposed to an excess of mic
5. your local plumber Warranty GLACIER BAY WATER FILTRATION SYSTEMS WARRANTY Glacier Bay Water Filtration Systems are manufactured under the highest standards of quality and workmanship Glacier Bay Water Filtration Systems warrants to the original purchaser that this system will be leak and drip free during normal domestic use for a period of one 1 year from date of purchase If this system should ever develop a leak or drip Glacier Bay Water Filtration Systems will free of charge provide the parts necessary to put the system back in good working condition A replacement for any defective part will be supplied free of charge for installation by the purchaser Defects or damage caused by use of other than authorized parts are not covered by this warranty This warranty shall be effective from date of purchase as shown on purchaser s receipt Glacier Bay Water Filtration Systems shall be installed per the manufacturer s installation instructions and specifications Some states do not allow limitations on how long a warranty lasts so the above limitation may not apply to you This warranty is valid for the original purchaser only and excludes industrial commercial or business use of the product product misuse and product damage due to installation error whether performed by a contractor service company or yourself Glacier Bay Water Filtration Systems will not be responsible for labor charges or for damage incurred during installation rep
6. Ethylbenzene 88 1 0 99 700 1 1 2 Trichloroethane 150 0 5 gt 99 5 0 Ethylene Dibromide EDB 44 0 02 gt 99 0 05 Trichloroethylene 180 1 0 gt 99 5 0 Haloacetonitriles HAN Trihalomethanes includes 300 15 95 80 Bromochloroacetonitrile 22 0 54 98 NA Chloroform surrogate chemical Dibromoacetonitrile 24 0 64 98 NA Bromoform Dichloroacetonitrile 9 6 0 24 98 NA Bromodichloromethane Trichloroacetonitrile 15 0 34 98 NA Chlorodibromomethane Xylenes total 70 1 0 99 10 000 Influent challenge levels are average influent concentrations determined in surrogate qualification testing 7 ug L means Micrograms per Liter 3 Maximum product water level was not observed but was set at the detection limit of the analysis Maximum product level is set at a value determined in surrogate qualification testing 5 Chemical reduction percent and maximum product water level calculated at chloroform 95 breakthrough point as determined in surrogate qualification testing The surrogate test results for heptachlor Epoxide demonstrated a 98 reduction These data were used to calculate an upper occurrence concentration which would produce a maximum product water level at the MCL Cyst virus and bacteria reduction tested by BioVir Labs in accordance with the EPA and State of California Department of Public Health test protocol Substance Log Reduction Reduction Cyst aD 99 95 Virus 4 99 99 Bacteria 6 99 9999 11 21 14 Rev 01 201 8401912
7. Item 1001 104 020 P GLACIER BAY Model HDGMBS4 USE AND CARE GUIDE ULTIMATE DEFENSE DRINKING WATER FILTRATION SYSTEM Questions problems missing parts Before returning to the store call Glacier Bay Customer Service 7 a m 6 p m CST Monday Friday 1 800 247 1087 HOMEDEPOT COM GLACIERBAY System tested and certified by NSF International against NSF ANSI Standards 42 amp 53 NSF See performance data sheet for details System tested and certified by WQA against NSF ANSI Standards 42 53 and USEPA microbiological guide for the reduction of the claims specified on the performance data sheet 201 8401420 rev 00 THANK YOU We appreciate the trust and confidence you have placed in Glacier Bay through the purchase of this drinking water filtration system We strive to continually create quality products designed to enhance your home Visit us online to see our full line of products available for your home improvement needs Thank you for choosing Glacier Bay Table of Contents Safety Information cccccssseesssesseeseees 2 Filter Cartridges sssssnnnnnnnnnnnnnnnnnnnnnnnnnn 8 Waranty sanina 2 Faucet Timer and Battery 0 5 9 Pre Installation cccssccsssseesseseeseeseesenes 3 Troubleshooting ceeseceeeeeeeneeeeenneesees 10 Installation ccccsceeeeseeeeeeeeeeseeeeeneeeeenees 6 Service Parts iicuciucnciawinstenseenssceseunredvans 10 Safety Information Read all i
8. air or replacement nor for incidental or consequential damages Some states provinces and nations do not allow the exclusion or limitation of incidental or consequential damages so the above exclusions or limitations may not apply to you Glacier Bay Water Filtration Systems will advise you of the procedure to follow in making warranty claims without adequate disinfection before or after the system Simply write to Glacier Bay Water Filtration Systems at the address below Explain the defect and include proof of purchase and you name address and telephone number or you can also call us at 1 800 247 1087 U S A Canada Glacier Bay Water Filtration Systems Glacier Bay Water Filtration Systems 2455 Paces Ferry Road N W 900 1 Concorde Gate Atlanta GA 30339 4024 Toronto ON M3C 4H9 Pre Installation ABOUT THIS FILTRATION SYSTEM The Ultimate Defense Drinking Water Filtration System uses a dual filter configuration to remove undesirable elements in your water These elements may include chlorine taste and odor particulates lead virus bacteria cysts and many organic compounds At the same time the system allows the minerals found in water to remain for great tasting water The filters in this system are designed to stop the flow of water when their capability to protect the user has been exhausted A performance data sheet is included listing what the system will reduce from the water supply See the performance data sheet for individ
9. er Service 7 a m 6 p m CST Monday Friday 1 800 247 1087 HOMEDEPOT COM GLACIERBAY Retain this manual for future use Manufactured by Ecodyne Water Systems 1890 Woodlane Drive Woodbury MN 55125 Performance Data Sheet Model HDGMBS4 Purification System IMPORTANT NOTICE Read this Performance Data Sheet and compare the capabilities of this unit with your actual water treatment needs It is recommended that before purchasing a water treatment unit you have your water supply tested to determine your actual water treatment needs This filter system is designed to be used for the reduction of the performance claims listed below Do not use for the treatment of water that is visually contaminated cloudy or has an obvious contamination source such as contamination by raw sewage Systems certified for cyst reduction may be used on disinfected water that may contain filterable cysts While testing was performed under standard laboratory conditions actual performance of the system may vary based on local water conditions Some or all of the contaminants reduced by this unit may not be in your water supply See Installation and Operation Manual for further instructions on filter cartridge replacement system installation operating procedures and warranty The maintenance instructions must be followed for the product to perform as indicated below Performance Claims Required NSF Max Average Avg Max Influent Permissible Influent Effluent Av
10. full 3 4 in engagement Installation continued 4 Installing the filter cartridges D Completing the installation o Remove the plastic cap from the filter cartridges E o Open the shutoff valve that you closed at the o Install the filter cartridges E into the two holes in beginning of this installation the filter body Note the filter cartridges are labeled o Open the filtered water faucet C to purge air Filter 1 and Filter 2 Turn clockwise to tighten Do from the system When the water runs smooth not over tighten with no bubbles or spurting close the faucet C and check the installation for leaks o Open the filtered water faucet C and let water run for 10 minutes to rinse system Filter Cartridges FILTER CARTRIDGE LIFE Lead Chlorine Taste and Odor and Purifying Filter Cartridges Lead chlorine taste and odor and purifying filter cartridges contain activated carbon When new open the filtered water faucet and allow fine carbon particles to purge from the cartridges Flush for 10 minutes It is recommended to replace filter cartridges every six months or 350 gallons of use There are several variables that determine how long a cartridge will last These include 1 How much water you use and 2 How much sediment taste and or odor or other unwanted substance is in the water Use the following information as a guide However no matter which type of filter cartridge you are using you will know it is time to rep
11. g Min EPA Level Eff Level Level Level Percent MCL Contaminant ug L ug L ug L ug L Removal ug L Lead pH 6 5 150 10 10 150 1 1 99 3 99 3 15 Lead pH 8 5 150 10 10 140 1 1 99 3 99 3 15 Substance Chlorine Taste and Odor 2000 10 50 1900 50 50 97 4 97 2 None Particulate Class I 0 5 to lt 1 micron 10 000 85 6 000 000 5 567 28 000 gt 99 9 99 6 None VOC Reduction Chloroform 300 10 95 300 0 5 0 5 99 8 99 7 15 EPA MCL means Environmental Protection Agency Maximum Contaminant Level as required under the Safe Drinking Water Act ug L means Micrograms Per Liter which is equivalent to parts per billion PPB gt NSF minimum percent reduction requirement Acceptance level for this substance is based on percent reduction rather than maximum effluent concentration The EPA has not determined an MCL for this chemical Particulate Class I reported in particles per milliliter or mL Chloroform was used as a surrogate for the reduction of chemicals specified in the Organic Chemicals Reduced by Chloroform Surrogate Testing table This system has been tested according to NSF ANSI 42 53 for reduction of the substances listed The concentration of the indicated substances in water entering the system was reduced to a concentration less than or equal to the permissible limit for water leaving the system as specified in NSF ANSI 42 53 Organic Chemicals Reduced by Chloroform Surrogate Testing
12. lace it when you first notice the return of the unwanted substance in your water Glacier Bay Ultimate Defense Water Filtration System model HDGMBS4 with replacement elements HDGMBF4 conforms to NSF ANSI 42 and 53 for the specific performance claims as verified and substantiated by test data The rated capacity for this system is 350 gallons 1325 liters at a rated service flow of 0 74 gallons per minute State of Wisconsin Required Statement Do not use in Wisconsin with water that is microbiologically unsafe or of unknown quality without adequate point of entry i e whole house disinfection before this device FILTER CARTRIDGE REPLACEMENT 1 Turn the filter cartridges counterclockwise to remove and dispose of them properly 2 Install the new filter cartridges by turning them clockwise 3 Remove and replace the timer battery See the Changing the Faucet Battery section for more information Lead Chlorine Taste and Odor and Purifying Filter Cartridges Lead chlorine taste and odor and purifying filter cartridges contain activated carbon When new open the filtered water faucet and allow fine carbon particles to purge from the cartridges Flush for 10 minutes Turn filter cartridge clockwise to install Faucet Timer and Battery FAUCET TIMER Inside the faucet base is a battery operated 6 month timer An amber LED indicator is also located in the front of the faucet base This LED flashes continuously after 6 months have passed
13. ngs are used be sure to use pipe joint compound or thread sealing tape on outside threads Cold water faucet stud Thread seal ing tape on threads Cold water pipe Figure A Cold water pipe Figure B Cold water shutoff Cold water shutoff Insert pl 3 8 in tubing to Water Filter inlet Ferrule Installation continued 2 Installing the faucet IMPORTANT To avoid damaging the sink consult a qualified plumber or installer for drilling procedures in porcelain or stainless steel Special drill bits are made for this Before you begin ensure there is room underneath C I the sink or countertop so you can make the needed connections If drilling is required in the sink top or countertop next to the sink make a 1 1 4 in dia minimum hole for the faucet C o Insert one end of the blue tube into the faucet C 1 4 turn to connect see Step 3 Connecting the tubes Feed the faucet to base gt other end of the blue tube through the mounting hole o Slide the toggle bolts through the mounting hole until the faucet C base is square against the mounting surface sink or countertop Tighten the toggle bolts to secure the base flat on the Hole in sink or counter J o Turn the faucet C 1 4 clockwise to attach the mounting surface Do not over tighten faucet C to the base 3 Connecting the tubes Remove and discard
14. nstructions before installing and using your WARNING Do not use for the treatment of water i that is visually contaminated cloudy or has an home water filtration system Follow all steps obvious contamination source such as exactly to correctly install Reading this manual will contamination by raw sewage also help you to get all the benefits from the filtration system CAUTION Do not install the filtration system outside or in extreme hot or cold temperatures All plumbing must be completed in accordance with Temperature of the water supply to the filtration system must be between 40 F and 100 F Do not install on a hot water line national state and local plumbing codes Local code information can be obtained at your local public works department In Massachusetts plumbing NOTICE This filtration system works on water pressures of 40 code 248 CMR 3 00 and 10 00 shall be adhered to psi minimum to 100 psi maximum If your house water pressure is over the maximum install a pressure reducing valve Consult with your licensed plumber in the water supply pipe to the filtration system WARNING Do not use with water that is Pare ee NOTICE Commonwealth of Massachusetts plumbing codes microbiologically unsafe or of unknown quality do not permit the use of saddle valves and require installation by a licensed plumber Comply with plumbing code 248 CMR for installations in the state of Massachusetts Please consult
15. nths whichever comes first For replacement elements call 1 800 247 1087 or contact your nearest The Home Depot s store Replacement filter prices will vary Current pricing for the replacement filters HDGMBF4 is approximately 50 to 75 Manufactured and warranted by Ecodyne Water Systems 1890 Woodlane Drive Woodbury MN 55125 FOR IOWA ONLY system tested and certified by NSF International against NSF ASNI Standard 42 and 53 for Chlorine Taste and Odor VOC Lead Class Particulate and for Material Requirements Tested and certified by WQA against NSF ANSI standard 42 53 and USEPA microbiological guide for the reduction of the claims specified in this document All sales in Iowa require the following signature before consummation of sale These signatures must be retained by seller renter for 2 years minimum Buyer Renter ___ a ee Seller Seller s Address Seller s Phone Date Cz ate Product GLACIER BAY Drinking Water Filter Model HDGMBS4 11 21 14 Rev 01 201 8401912
16. robiological loading materials in the water This failsafe feature reduces the chance of product use beyond its intended life and will shut down the filter when it is exposed to contaminated water The filters are expended The system is contaminated The battery is dead The battery is not installed correctly The tubing is not pushed in all the way The tubing is not cut square The tubing is nicked The outer tubing surface is not smooth Solution Replace the prefilter cartridge Replace all filter cartridges Replace the filter cartridges Sanitize the system Call 1 800 247 1087 for instructions Replace the battery Install the battery correctly paying attention to the polarity Push tubing in all the way into fittings Cut the tubing square Remove the nicked portion and reinsert the tubing into the fitting Remove the rough portion and reinsert the tubing into the fitting Tubing 3 8 in x 20 3 8 x 3 8 in coupler 1073 24 02 Cabinet right HDGMBF4 HCGMBF5 Replacement filter cartridge 2 pack 7228536 Tee feed adapter 1073 22 09 3 8 x 3 8 in union yellow Please purchase replacement cartridges from the retailer where you purchased this system This tubing is not included Tubing lengths for remote installation direct replacement for colored lengths of tubing 10 GLACIER BAY Questions problems missing parts Before returning to the store call Glacier Bay Custom
17. the protective foam plugs if F Push in fitting present before connecting tubes oamp S N o Allowing some slack measure and cut a length of ees a 3 8 in tubing D to connect between the supply fitting and the filter system inlet Cut the ends of the tubing square o Insert tubing all the way into the supply fitting Tubing correctly cut and connected and inlet fitting Pull on the tubing to be sure that it is securely set in the fittings o Repeat the first two bullets to connect the tubing from the faucet to the filter system outlet End of tubing round and smooth Tubing Connection all push in fittings with no cuts nicks or flat spots This system includes push in fittings for quick tubing connections If working with the fittings do the following o Cut the end of the tubing square Inspect the end about 1 in of the tubing to be sure there are no nicks scratches or other rough spots If needed cut the tubing again Incorrect partial engagement oO Push tubing through the collet and through the fitting Full engagement is 3 4 in length of tube into the fitting If tubing other than supplied with the system is used be sure it is of high quality exact size and roundness with a smooth surface To disconnect push the collet inward and hold with a finger while pushing the tubing out SE 7 HOMEDEPOT COM GLACIERBAY Please contact 1 800 247 1087 for further assistance Remove and discard foam plugs Correct
18. ual contaminants and microbial reduction performance INSTALLATION LOCATION The drinking water system fits under the kitchen or bathroom sink However you can install it where it is most convenient You need a COLD water supply pipe within a few feet 6 feet of tubing is included You can purchase longer lengths of tubing if needed to reach more distant points Be sure tubing is acceptable for use on potable water supplies Filtered water faucet D Blue tube e Supply Yellow tube fitting WATER IN Shutoff HOT COLD valve DIMENSIONS 17 5 8 in SPECIFICATIONS Minimum Maximum Supply Water Pressure 40 100 PSI 276 689 kPa Minimum Maximum Supply Water Temperature 40 100 F 5 38 C Inlet Outlet 3 8 in quick connect fittings and tubing included Maximum Supply Water Iron Manganese and Hydrogen 0 Sulfide 3 HOMEDEPOT COM GLACIERBAY Please contact 1 800 247 1087 for further assistance Pre Installation continued TOOLS REQUIRED Phillips Adjustable Tubing screwdriver wrench il cutter f Sealant tape Ao PACKAGE CONTENTS Description Filtration system Feed adapter water supply fitting Filtered water faucet for sink countertop mounting 3 8 in color coded tubing used for all connections Filter cartridge 1 1 2 2 Drill and 1 1 4 in drill bit HOMEDEPOT COM GLACIERBAY Please contact 1 800 247 1087 for further assistance Installation
Download Pdf Manuals
Related Search