American Standard 6156.100.020 Installation Guide
Contents
1. Hang the urinal Check for pitch and alignment to waste line pipe Adjust Wall Bracket up or down as needed for proper drain line pitch and alignment Perform a Water test for a good flow and verify there are no leaks Secure urinal on the bottom Perform set up following the set up instructions Finish installation by caulking around the bowl Carefully add High Grade 6 ABS glue to about 1 of the forward section of the HOUSING drain Grab drain tube with a plier or similar tool and put into housing until it hits the stop about 1 1 4 in depth CAUTION DO NOT use pipe dope or plumber s putty will cause housing failure Warranty is void if plumber s putty or pipe dope is used for the housing connection 6154 100 amp 6155 100 30140 100 t Using the key provided screw the 2 Pull upward on insert to remove 3 Rinse the open trap with water key into the key hole of the drain insert and fill with water 4 Replace the new insert press 5 Fill with 32 ounces of water 6 Pour into 1 10 ounce bottle of down until you feel and hear a slight odor barrier liquid popping sound American Standard Style That Works Better 7301407 100 Take a new Drain Insert and place it Press down on the Drain Insert until Pour about 30 oz of water over the in the waste trap you feel and hear a slight popping Drain Insert Then slowly pour the sound he insert must be tight entire contents of the Odor Barr2. INSTALLATION INSTRUCTIONS 6150 100 American Standard Not recommended to install on any copper plumbing 6154 100 CAUTION DO NOT use pipe dope or plumber s putty will cause housing failure Warranty is void if plumber s putty or 6155 100 pipe dope is used for the housing connection Drain Tube Flange Coupler Wall Bracket 7 6154 100 6155 100 6150 100 Wall Bracket 6150 100 Drain Insert Key Odor Barrier Rubber Gasket Screws wall anchors washers NEW CONSTRUCTION Drain Must Have Standard Urinal Flange Not Supplied Replacing a Urinal Shut off and cap water supply Remove existing hardware caulk and grout Remove all traps and conventional siphons Verify there is enough room for the new urinal Product names listed herein are trademarks of AS America Inc AS America Inc 2009 6154 100 amp 6155 100 IF TEMPLATE NOT AVAILABLE Hold the bracket flush with the back of the urinal Measure from the bottom of the bracket to the middle of the drain pipe on the Urinal Using this measurement measure from the middle of the drain pipe in the wall and mark the spot Remove old rubber gasket and clean flange and drain thoroghly Install New Flange Coupler rubber gasket with longer part towards the wall and tighten bolts Style That Works Better install the wall bracket Make sure the bracket Lubricate drain tube and insert into coupler Run in and out until this can be done easily
3. ier onto the Drain Insert Wipe clean The urinal is now ready to use Remove debris Spray and wipe down Wipe clean 7301407 100 American Standard Style That Works Better AS AMERICA INC ONE YEAR LIMITED WARRANTY If inspection of this AS America Inc American Standard plumbing product within one year after its initial purchase confirms that it is defective in materials or workmanship American Standard will repair or at its option exchange the product for a similar model This warranty does not apply lo local building code compliance Since local building codes vary considerably the purchaser of this product should check with a local building or plumbing contractor to insure local code compliance before installation This warranty shall be void if the product has been moved from its initial place of installation if it has been subjected to faulty maintenance abuse misuse accident or other damage if it was not installed in accordance with American Standard s instructions or if it has been modified in a manner inconsistent with the product as shipped by American Standard American Standard s option to repair or exchange the product under this warranty does not cover any labor or other costs of removal or installation nor shall American Standard be responsible for any other incidental or consequential damages attributable to a product defect or to the repair or exchange of a defective product all of which are expressly excl
4. uded from this warranty Some states or provinces do not allow the exclusion or limitation of implied warranties so this exclusion may not apply to you This warranty gives you specific legal rights You may have other statutory rights that vary from state to state or from province to province in which case this warranty does not affect such statutory rights For service under this warranty itis suggested that a claim be made through the contractor or dealer from or through whom the product was purchased or that a service request including a description of the product model and of the defect be sent to the following address In the United States In Canada In Mexico American Standard Brands AS Canada ULC Customer Service Manager P O Box 6820 2480 Stanfield Rd AS Maquila S A da C V Piscalaway New Jersey 08855 Mississauga Ontario Via Morelos amp 330 Attention Director o Consumer Affairs Canada L4Y 152 Gol Santa Clara Toll Free 800 387 0689 Ecatepec 55540 Edo Mexico Far residents of the United States warranty www arnaricansiandard ca www americanstandard com mx information may also be obtained by calling Ihe following tall free number 800 442 1902 WWW amencanstandard us Com 7301407 100
Download Pdf Manuals
Related Search