Moldex 5510 Use and Care Manual
Contents
1. For containers greater than 5 gallons Triple rinse as follows Fill container 1 4 full with water Tip container on its side and roll it back and forth ensuring at least one complete revolution for 30 seconds Stand the container on its end and tip it back and forth several times Turn the container over onto its other end and tip it back and forth several times Follow Pesticide Disposal instructions for rinsate disposal Repeat procedure two more times Then offer for recycling or reconditioning If not available puncture and dispose in a sanitary landfill Dispose in accordance with all applicable regulations The waste code should be assigned in discussion between the user the producer and the waste disposal company Dispose of in accordance with local regulations Empty containers or liners may retain some product residues This material and its container must be disposed of in a safe manner see Disposal instructions Empty containers should be taken to an approved waste handling site for recycling or disposal Since emptied containers may retain product residue follow label warnings even after container is emptied Note Shipper offeror is responsible for confirming appropriate proper shipping name hazard classification s packing group marking labeling placarding packaging and other regulatory requirements applicable to packages offered for transport These requirements may vary depending on the quantity of material packa2. SDS The receipt and use of this information constitutes consent to these terms and conditions Material name MOLDEX DISINFECTANT CONCENTRATE SDS US Version 00 Revision date 03 30 2015 Print date 05 17 2015 8 8
3. 1 Identification Product identifier Other means of identification EPA No Recommended use Recommended resirictions SAFETY DATA SHEET MOLDEX DISINFECTANT CONCENTRATE 1839 169 82480 Quaternary ammonium product blend for use as a disinfectant sanitizer For industrial use only Manufacturer Importer Supplier Distributor information Supplier Company name Address Telphone Fax E mail Emergency phone number 2 Hazard s identification Physical hazards Health hazards Environmental hazards OSHA defined hazards Label elements Signal word Hazard statement Prevention Response Storage Disposal Hazard s not otherwise classified HNOC Supplemental information Material name MOLDEX DISINFECTANT CONCENTRATE EnviroCare Corporation 10 Upton Dr 3 Wilmington MA 01887 978 658 0123 978 964 0444 info envirocarecorp com CHEMTREC US Canada 1 800 424 9300 Intl Maritime 1 703 527 3887 Not classified Acute toxicity oral Category 4 Acute toxicity dermal Category 3 Acute toxicity inhalation Category 4 Skin corrosion irritation Category 1 Serious eye damage eye irritation Category 1 Specific target organ toxicity single exposure Category 2 Hazardous to the aquatic environment acute Category 1 hazard Hazardous to the aquatic environment Category 2 long term hazard Not classified DOOD Danger Harmful if swallowed Toxic in contact with skin Causes severe skin burns
4. and eye damage Causes serious eye damage Harmful if inhaled May cause damage to organs Very toxic to aquatic life Toxic to aquatic life with long lasting effects Use only outdoors or in a well ventilated area Do not breathe mist or vapor Wash thoroughly after handling Do not eat drink or smoke when using this product Avoid release to the environment Wear protective gloves protective clothing eye protection face protection Collect spillage If swallowed Call a poison center doctor if you feel unwell If swallowed Rinse mouth Do NOT induce vomiting If on skin or hair Take off immediately all contaminated clothing Rinse skin with water shower If inhaled Remove person to fresh air and keep comfortable for breathing If in eyes Rinse cautiously with water for several minutes Remove contact lenses if present and easy to do Continue rinsing Immediately call a poison center doctor Specific treatment see this label Take off immediately all contaminated clothing and wash it before reuse Store locked up Dispose of contents container in accordance with local regional national international regulations None known Not applicable SDS US Version 00 Revision date 03 30 2015 Print date 05 17 2015 1 8 3 Composition information on ingredients Mixtures Chemical name Alkyl dimethyl benzyl ammonium chloride C12 16 Didecyl dimethyl ammonium chloride _Di C8 10 alkyl dimethyl ammonium chlorides _Dioctyldim
5. elease to the environment Do not empty into drains DO NOT CONTAMINATE WATER FOOD OR FEED BY STORAGE OR DISPOSAL PESTICIDE STORAGE Store in a dry place no lower in temperature than 50 F or higher than 120 F Store locked up Store in original tightly closed container Store in a well ventilated place Store away from incompatible materials see Section 10 of the SDS 8 Exposure controls personal protection Occupational exposure limits Biological limit values Appropriate engineering controls No exposure limits noted for ingredient s No biological exposure limits noted for the ingredient s Good general ventilation typically 10 air changes per hour should be used Ventilation rates should be matched to conditions If applicable use process enclosures local exhaust ventilation or other engineering controls to maintain airborne levels below recommended exposure limits If exposure limits have not been established maintain airborne levels to an acceptable level Eye wash facilities and emergency shower must be available when handling this product Individual protection measures such as personal protective equipment Eye face protection Hand protection Skin protection Other Respiratory protection Thermal hazards General hygiene considerations Wear eye face protection Wear safety glasses with side shields or goggles and a face shield Wear a full face respirator if needed Wear appropriate chemical resistant glo
6. ethylammonium chloride Other components below reportable levels 4 First aid measures Inhalation Skin contact Eye contact Ingestion Most important symptoms effects acute and delayed Indication of immediate medical attention and special treatment needed General information 5 Fire fighting measures Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire fighting equipment instructions Specific methods General fire hazards Common name and synonyms CAS number 68424 85 1 3 lt 5 7173 51 5 1 lt 3 68424 95 3 1 lt 3 5538 94 3 1 lt 3 90 100 Remove victim to fresh air and keep at rest in a position comfortable for breathing Oxygen or artificial respiration if needed Do not use mouth to mouth method if victim inhaled the substance Induce artificial respiration with the aid of a pocket mask equipped with a one way valve or other proper respiratory medical device Call a POISON CENTER or doctor physician if you feel unwell Take off immediately all contaminated clothing Rinse skin with water shower Call a physician or poison control center immediately Chemical burns must be treated by a physician Wash contaminated clothing before reuse Immediately flush eyes with plenty of water for at least 15 minutes Remove contact lenses if present and easy to do Continue rinsing Call a physician or
7. eye damage irritation Respiratory or skin sensitization Respiratory sensitization Not available Skin sensitization This product is not expected to cause skin sensitization Germ cell mutagenicity No data available to indicate product or any components present at greater than 0 1 are mutagenic or genotoxic Carcinogenicity This product is not considered to be a carcinogen by IARC ACGIH NTP or OSHA US OSHA Specifically Regulated Substances 29 CFR 1910 1001 1050 Not listed Reproductive toxicity This product is not expected to cause reproductive or developmental effects Specific target organ toxicity May cause damage to organs single exposure Specific target organ toxicity Not applicable repeated exposure Aspiration hazard Not likely due to the form of the product Material name MOLDEX DISINFECTANT CONCENTRATE SDS US Version 00 Revision date 03 30 2015 Print date 05 17 2015 4 8 12 Ecological information Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects Very toxic to aquatic life Toxic to aquatic life with long lasting effects No data is available on the degradability of this product No data available No data available No other adverse environmental effects e g ozone depletion photochemical ozone creation potential endocrine disruption global warming potential are expected from this component 13 Disposal considerations Disposal
8. ging mode of transportation and carrier UN1760 CORROSIVE LIQUID N O S QUATERNARY AMMONIUM CHLORIDE 8 lll Read safety instructions SDS and emergency procedures before handling UN1760 CORROSIVE LIQUID N O S QUATERNARY AMMONIUM CHLORIDE 8 III Yes Read safety instructions SDS and emergency procedures before handling UN1760 CORROSIVE LIQUID N O S QUATERNARY AMMONIUM CHLORIDE 8 Material name MOLDEX DISINFECTANT CONCENTRATE SDS US Version 00 Revision date 03 30 2015 Print date 05 17 2015 5 8 Subsidiary risk Packing group III Environmental hazards Marine pollutant Yes EmS Not available Special precautions for user Read safety instructions SDS and emergency procedures before handling Transport in bulk according to Not available Annex II of MARPOL 73 78 and the IBC Code DOT CORROSIVE IATA IMDG Marine pollutant 15 Regulatory information US federal regulations This product is a U S EPA registered pesticide This product is a Hazardous Chemical as defined by the OSHA Hazard Communication Standard 29 CFR 1910 1200 CERCLA Hazardous Substance List 40 CFR 302 4 Not listed US OSHA Specifically Regulated Substances 29 CFR 1910 1001 1050 Not listed Superfund Amendments and Reauthorization Act of 1986 SARA Hazard categories Immediate Hazard Yes Delayed Hazard No Fire Hazard No Pressure Hazard No Reactivity Hazard No SARA 302 Extremely No hazardous subs
9. instructions Local disposal regulations Hazardous waste code Waste from residues unused products Contaminated packaging 14 Transport information General DOT UN number UN proper shipping name Transport hazard class es Class Subsidiary risk Packing group Special precautions for user IATA UN number UN proper shipping name Transport hazard class es Class Subsidiary risk Packing group Environmental hazards Special precautions for user IMDG UN number UN proper shipping name Transport hazard class es Class PESTICIDE DISPOSAL Pesticide wastes are acutely hazardous Improper disposal of excess pesticide spray mixture or rinsate is a violation of Federal Law If these wastes cannot be disposed of by use according to label instructions contact your State Pesticide or Environmental Control Agency or the Hazardous Waste representative at the nearest EPA Regional Office for guidance CONTAINER DISPOSAL Nonrefillable container Do not reuse or refill this container Offer for recycling if available Triple rinse container promptly after emptying For containers 5 gallons or less Triple rinse as follows Fill container 1 4 full with water and recap Agitate vigorously Follow Pesticide Disposal instructions for rinsate disposal Drain for 10 seconds after the flow begins to drip Repeat procedure two more times Then offer for recycling or reconditioning If not available puncture and dispose in a sanitary landfill
10. lush area with water Small Spills Wipe up with absorbent material e g cloth fleece Clean surface thoroughly to remove residual contamination Never return spills to original containers for re use For waste disposal see section 13 of the SDS Do not discharge effluent containing this product into lakes streams ponds estuaries oceans or other waters unless in accordance with the requirements of a National Pollutant Discharge Elimination System NPDES permit and the permitting authority has been notified in writing prior to discharge Do not discharge effluent containing this product to sewer systems without previously notifying the local sewage treatment plant authority For guidance contact your State Water Board or Regional Office of the EPA Avoid release to the environment Contact local authorities in case of spillage to drain aquatic environment Prevent further leakage or spillage if safe to do so Do not contaminate water Avoid discharge into drains water courses or onto the ground Do not breathe mist or vapor Do not get this material in contact with eyes Do not get this material in contact with skin Do not taste or swallow Do not get this material on clothing Use only outdoors or in a well ventilated area Wear appropriate personal protective equipment Observe good industrial hygiene practices When using do not eat drink or smoke Wash hands thoroughly after handling Wash contaminated clothing before reuse Avoid r
11. on 65 Subregistrant does so at its own risk and liability and hereby agrees to indemnify and hold Stepan harmless for any claim cause of action or damages arising from such decision not to warn WARNING This product contains a chemical known to the State of California to cause birth defects or other reproductive harm US California Proposition 65 CRT Listed date Developmental toxin International Inventories Couniry s or region Australia Canada Canada China Europe Europe Japan Korea New Zealand Philippines United States amp Puerto Rico Methanol CAS 67 56 1 Listed March 16 2012 Inventory name On inventory yes no Australian Inventory of Chemical Substances AICS No Domestic Substances List DSL No Non Domestic Substances List NDSL No Inventory of Existing Chemical Substances in China IECSC No European Inventory of Existing Commercial Chemical No Substances EINECS European List of Notified Chemical Substances ELINCS No Inventory of Existing and New Chemical Substances ENCS No Existing Chemicals List ECL No New Zealand Inventory No Philippine Inventory of Chemicals and Chemical Substances No PICCS Toxic Substances Control Act TSCA Inventory No A Yes indicates that all components of this product comply with the inventory requirements administered by the governing country s A No indicates that one or more components of the product are not listed or exempt from listing on the inventor
12. poison control center immediately Call a physician or poison control center immediately Rinse mouth Do not induce vomiting If vomiting occurs keep head low so that stomach content doesn t get into the lungs Burning pain and severe corrosive skin damage Causes serious eye damage Symptoms may include stinging tearing redness swelling and blurred vision Permanent eye damage including blindness could result Provide general supportive measures and treat symptomatically Chemical burns Flush with water immediately While flushing remove clothes which do not adhere to affected area Call an ambulance Continue flushing during transport to hospital In case of shortness of breath give oxygen Keep victim warm Keep victim under observation Symptoms may be delayed Take off immediately all contaminated clothing In the case of accident or if you feel unwell seek medical advice immediately show the label where possible Ensure that medical personnel are aware of the material s involved and take precautions to protect themselves Wash contaminated clothing before reuse Water fog Foam Dry chemical powder Carbon dioxide CO2 Do not use water jet as an extinguisher as this will spread the fire During fire gases hazardous to health may be formed Self contained breathing apparatus and full protective clothing must be worn in case of fire Move containers from fire area if you can do so without risk Use standard firefighting
13. procedures and consider the hazards of other involved materials No unusual fire or explosion hazards noted 6 Accidental release measures Personal precautions protective equipment and emergency procedures Material name MOLDEX DISINFECTANT CONCENTRATE Version 00 Revision date 03 30 2015 Print date 05 17 2015 Immediately evacuate personnel to safe areas Keep unnecessary personnel away Keep people away from and upwind of spill eak Wear appropriate protective equipment and clothing during clean up Fully encapsulating vapor protective clothing should be worn for spills and leaks with no fire Do not breathe mist or vapor Do not touch damaged containers or spilled material unless wearing appropriate protective clothing Ventilate closed spaces before entering them Local authorities should be advised if significant spillages cannot be contained For personal protection see section 8 of the SDS SDS US 2 8 Methods and materials for containment and cleaning up Environmental precautions 7 Handling and storage Precautions for safe handling Conditions for safe storage including any incompatibilities Large Spills Stop the flow of material if this is without risk Dike the spilled material where this is possible Cover with plastic sheet to prevent spreading Absorb in vermiculite dry sand or earth and place into containers Prevent entry into waterways sewer basements or confined areas Following product recovery f
14. sition temperature Not available Viscosity Not available Other information Density 8 26 Ib gal 25C voc 1 2 10 Stability and reactivity Reactivity The product is stable and non reactive under normal conditions of use storage and transport Chemical stability Material is stable under normal conditions Possibility of hazardous No dangerous reaction known under conditions of normal use reactions Conditions to avoid Avoid temperatures exceeding the flash point Contact with incompatible materials Incompatible materials Strong oxidizing agents Hazardous decomposition No hazardous decomposition products are known products 11 Toxicological information Information on likely routes of exposure Ingestion Causes digestive tract burns Harmful if swallowed Inhalation Harmful if inhaled May cause damage to organs by inhalation Skin contact Toxic in contact with skin Causes severe skin burns Eye contact Causes serious eye damage Symptoms related to the Burning pain and severe corrosive skin damage Causes serious eye damage Symptoms may physical chemical and include stinging tearing redness swelling and blurred vision Permanent eye damage including toxicological characteristics blindness could result Information on toxicological effects Acute toxicity Toxic in contact with skin Harmful if inhaled Harmful if swallowed Skin corrosion irritation Causes severe skin burns and eye damage Serious eye damage eye Causes serious
15. tance SARA 311 312 Hazardous Yes chemical SARA 313 TRI reporting Not regulated Material name MOLDEX DISINFECTANT CONCENTRATE SDS US Version 00 Revision date 03 30 2015 Print date 05 17 2015 6 8 Other federal regulations Clean Air Act CAA Section 112 Hazardous Air Pollutants HAPs List Not regulated Clean Air Act CAA Section 112 r Accidental Release Prevention 40 CFR 68 130 Not regulated Safe Drinking Water Act SDWA FIFRA Information Signal word Hazard statement US state regulations Not regulated This chemical is a pesticide product registered by the Environmental Protection Agency and is subject to certain labeling requirements under federal pesticide law These requirements differ from the classification criteria and hazard information required for safety data sheets and for workplace labels of non pesticide chemicals Following is the hazard information as required on the pesticide label DANGER Corrosive Causes irreversible eye damage and skin burns May be fatal if absorbed through skin Harmful if swallowed Harmful if inhaled This product is toxic to fish US Massachusetts RTK Substance List Not regulated US Rhode Island RTK Not regulated US California Proposition 65 Subregistrant may elect not to use this warning if it conducts an assessment which determines such ingredient falls below the threshold action level requiring warning under California Propositi
16. ves Wear appropriate chemical resistant clothing In case of insufficient ventilation wear suitable respiratory equipment Wear appropriate thermal protective clothing when necessary When using do not eat drink or smoke Always observe good personal hygiene measures such as washing after handling the material and before eating drinking and or smoking Routinely wash work clothing and protective equipment to remove contaminants 9 Physical and chemical properties Appearance Physical state Form Color Odor Odor threshold pH Melting point freezing point Initial boiling point and boiling range Flash point Evaporation rate Material name MOLDEX DISINFECTANT CONCENTRATE Version 00 Revision date 03 30 2015 Print date 05 17 2015 Liquid Liquid Not available Not available Not available 6 0000 8 0000 as is Not available 200 F 93 3 C gt 201 F gt 93 9 C PMCC Estimated slower than ethyl ether SDS US 3 8 Flammability solid gas Not available Upper lower flammability or explosive limits Flammability limit lower Not available Flammability limit upper Not available Explosive limit lower Not available Explosive limit upper Not available Vapor pressure Not Determined or Unknown Vapor density Relative Density Estimated heavier than air Not Available Solubility ies Solubility water Not available Auto ignition temperature Not available Decompo
17. y administered by the governing country s 16 Other information including date of preparation or last revision Issue date 05 17 2015 Version 00 Material name MOLDEX DISINFECTANT CONCENTRATE SDS US Version 00 Revision date 03 30 2015 Print date 05 17 2015 7 8 NFPA ratings Disclaimer Terms and Conditions This SDS is designed only as guidance for the products to which it applies To the greatest extent permitted by applicable law nothing contained herein creates any legal obligation including contractual obligations expressed or implied warranties including any warranties of merchantibility or fitness for particular purpose or confers any intellectual property rights including rights to use trademarks or a license to use patents issued or pending The information contained herein is based on the manufacturer s own study and the work of others and is subject to change at any time without further notice There is no warranty expressed or implied as to the accuracy completeness or adequacy of the information contained herein and neither the provider nor the manufacturer nor the agents directors officers contractors or employees of either are liable to any party for any damages of any nature including direct special or consequential damages arising out of or in connection with the accuracy completeness adequacy or furnishing of any information in this SDS or in any other way related directly or indirectly to this
Download Pdf Manuals
Related Search