Moldex 5330 Use and Care Manual
Contents
1. PNEC Predicted No Effect Concentration REACH LC50 Lethal concentration 50 percent LD50 Lethal dose 50 percent Eye Dam 1 Serious eye damage eye irritation Hazard Category 1 Aquatic Acute 1 Hazardous to the aquatic environment Acute Hazard Category 1 Aquatic Chronic 3 Hazardous to the aquatic environment Chronic Hazard Category 3 Sources SDS Prepared by according to 1907 2006 EC REACH 1272 2008 EC CLP and OSHA GHS ChemTel Inc 1305 North Florida Avenue Tampa Florida USA 33602 2902 Toll Free North America 1 888 255 3924 Intl 01 813 248 0573 Website www chemtelinc com Version 1 Print Date 4 23 20152. by storerooms and receptacles No special requirements Information about storage in one common storage facility Store away from foodstuffs Do not store together with oxidizing and acidic materials Further information about storage conditions Keep container tightly sealed Protect from frost 7 3 Specific end use s No further relevant information available Page 4 9 Safety Data Sheet Trade name Moldex Deep Stain Remover HE 0 g o e n t 3 d o f p SECTION 8 Exposure controls personal protection Additional information about design of technical facilities No further data see item 7 8 1 Control parameters Ingredients with limit values that require monitoring at the workplace The product does not contain any relevant quantities of materials with critical values that have to be monitored at the workplace DNELs No further relevant information available PNECs No further relevant information available Additional information The lists valid during the making were used as basis 8 2 Exposure conirols Personal protective equipment General protective and hygienic measures The usual precautionary measures are to be adhered to when handling chemicals Keep away from foodstuffs beverages and feed Avoid contact with the eyes Avoid close or long term contact with the skin Respiratory protection Not required under normal conditions of use For large spills respiratory protection may be advisable P
3. information required by the Controlled Products Regulations Substances of very high concern SVHC according to REACH Article 57 None of the ingredients are listed 15 2 Chemical safety assessment A Chemical Safety Assessment has not been carried out Contd on page 9 Page 9 9 Safety Data Sheet Trade name Moldex Deep Stain Remover HE SECTION 16 Other information Contd of page 8 This information is based on our present knowledge However this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship Relevant phrases H318 Causes serious eye damage H400 Very toxic to aquatic life H412 Harmful to aquatic life with long lasting effects R41 Risk of serious damage to eyes R50 53 Very toxic to aquatic organisms may cause long term adverse effects in the aquatic environment Abbreviations and acronyms GHS Globally Harmonized System of Classification and Labelling of Chemicals ACGIH American Conference of Governmental Industrial Hygienists EINECS European Inventory of Existing Commercial Chemical Substances ELINCS European List of Notified Chemical Substances CAS Chemical Abstracts Service division of the American Chemical Society NFPA National Fire Protection Association USA HMIS Hazardous Materials Identification System USA WHMIS Workplace Hazardous Materials Information System Canada DNEL Derived No Effect Level REACH
4. on page 8 Page 8 9 Safety Data Sheet Trade name Moldex Deep Stain Remover HE Contd of page 7 Section 313 Specific toxic chemical listings None of the ingredients are listed TSCA Toxic Substances Control Act All ingredients are listed Proposition 65 California Chemicals known to cause cancer None of the ingredients is listed Chemicals known to cause reproductive toxicity for females None of the ingredients are listed Chemicals known to cause reproductive toxicity for males None of the ingredients are listed Chemicals known to cause developmental toxicity None of the ingredients are listed Carcinogenic Categories EPA Environmental Protection Agency None of the ingredients are listed IARC International Agency for Research on Cancer None of the ingredients are listed TLV Threshold Limit Value established by ACGIH None of the ingredients are listed NIOSH Ca National Institute for Occupational Safety and Health None of the ingredients are listed Canada Canadian Domestic Substances List DSL All ingredients are listed Canadian Ingredient Disclosure list limit 0 1 None of the ingredients are listed Canadian Ingredient Disclosure list limit 1 None of the ingredients are listed Other regulations limitations and prohibitive regulations This product has been classified in accordance with hazard criteria of the Controlled Products Regulations and the SDS contains all the
5. SAFETY DATA SHEET Moldex Deep Stain Remover Concentrate HE SECTION 1 Identification of the substance mixture and of the company undertaking 1 1 Product identifier Trade name Moldex Deep Stain Remover Concentrate HE Relevant identified uses of the substance or mixture and uses advised against No further relevant information available Application of the substance the mixture General alcohol cleaner 1 3 Details of the supplier of the Safety Data Sheet Supplier Envirocare Corporation 10 Upton Dr Wilmington MA 01887 1 4 Telephone numbers 24hr Emergency Assistance Chemtrec 1 800 424 9300 US Canada 1 703 527 3887 Int Maritime Product or Company Information 1 978 658 0123 Mon Fri SECTION 2 Hazards identification 2 1 Classification of the substance or mixture Classification according to Regulation EC No 1272 2008 The product is not classified as hazardous according to the Globally Harmonized System GHS The product is not classified as hazardous according to OSHA GHS regulations within the United States The product is not classified as hazardous according to the CLP regulation Classification according to Directive 67 548 EEC or Directive 1999 45 EC Not applicable Information concerning particular hazards for human and environment The product does not have to be labelled due to the calculation procedure of the General Classification guideline for preparations of the EU in the latest va
6. der or water spray Fight larger fires with water spray or alcohol resistant foam For safety reasons unsuitable extinguishing agents None 5 2 Special hazards arising from the substance or mixture No further relevant information available 5 3 Advice for firefighters Protective equipment Wear self contained respiratory protective device Wear fully protective suit Additional information No further relevant information available SECTION 6 Accidental release measures 6 1 Personal precautions protective equipment and emergency procedures Ensure adequate ventilation Particular danger of slipping on leaked spilled product 6 2 Environmental precautions Do not allow product to reach sewage system or any water course 6 3 Methods and material for containment and cleaning up Absorb with liquid binding material sand diatomite acid binders universal binders sawdust Pick up mechanically Dispose contaminated material as waste according to item 13 6 4 Reference to other sections See Section 7 for information on safe handling See Section 8 for information on personal protection equipment See Section 13 for disposal information SECTION 7 Handling and storage 7 1 Precautions for safe handling Wash hands before breaks and at the end of work Information about fire and explosion protection No special measures required 7 2 Conditions for safe storage including any incompatibilities Storage Requirements to be met
7. hange in condition Melting point Melting range Not Determined Boiling point Boiling range 101 C 214 F Flash point Not applicable Flammability solid gaseous Not applicable Auto Self ignition temperature Not determined Decomposition temperature Not determined Self igniting Product is not self igniting Danger of explosion Product does not present an explosion hazard Explosion limits Lower Not determined Upper Not determined Vapour pressure at 20 C 68 F 23 hPa 17 mm Hg Density at 20 C 68 F 0 91 g cm 7 594 Ibs gal Relative density Not determined Vapour density Not determined Evaporation rate Not determined Solubility in Miscibility with water Fully miscible VOC 0g Partition coefficient n octanol water Not determined Contd on page 6 Page 6 9 Safety Data Sheet Trade name Moldex Deep Stain Remover HE Contd of page 5 Viscosity Dynamic Not determined Kinematic Not determined 9 2 Other information No further relevant information available SECTION 10 Stability and reactivity 10 1 Reactivity 10 2 Chemical stability Thermal decomposition conditions to be avoided No decomposition if used and stored according to specifications 10 3 Possibility of hazardous reactions Reacts with strong acids and oxidizing agents 10 4 Conditions to avoid No further relevant information available 10 5 Incompatible materials No further relevan
8. lid version Classification system The classification is according to the latest editions of the EU lists and extended by company and literature data The classification is in accordance with the latest editions of international substances lists and is supplemented by information from technical literature and by information provided by the company Additional information There are no other hazards not otherwise classified that have been identified 0 percent of the mixture consists of component s of unknown toxicity 2 2 Label elements Labelling according to Regulation EC No 1272 2008 This product does not have a classification according to the CLP regulation The product is not classified as hazardous according to OSHA GHS regulations within the United States Hazard pictograms Not Regulated Signal word Not Regulated Hazard determining components of labelling None Hazard statements Not Regulated Contd on page 2 Page 2 9 Safety Data Sheet Trade name Moldex Deep Stain Remover HE Contd of page 1 Precautionary statements Not Regulated Hazard description WHMIS symbols Not hazardous under WHMIS NFPAratings scale 0 4 Po Health 0 Fire 0 Reactivity 0 0 ea 2 3 0 0 Other hazards Results of PBT and vPvB assessment PBT Not applicable vPvB Not applicable Health 0 Fire 0 Reactivity 0 HMIS ratings scale 0 4 SECTION 3 Composition information on ingredient
9. rotection of hands Protective gloves Wear protective gloves to handle contents of damaged or leaking units The glove material has to be impermeable and resistant to the product the substance the preparation Selection of the glove material on consideration of the penetration times rates of diffusion and the degradation Material of gloves The selection of the suitable gloves does not only depend on the material but also on further marks of quality and varies from manufacturer to manufacturer As the product is a O preparation of several substances the resistance of the glove material cannot be calculated in advance and has therefore to be checked prior to the application Penetration time of glove material The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed Contd on page 5 Page 5 9 Safety Data Sheet Trade name Moldex Deep Stain Remover HE Contd of page 4 Eye protection Safety gl afety glasses Body protection Not required under normal conditions of use Limitation and supervision of exposure into the environment No special requirements Risk management measures No special requirements SECTION 9 Physical and chemical properties 9 1 Information on basic physical and chemical properties General Information Appearance Form Liquid Colour White opaque Odour Characteristic Odour threshold Not determined pH value 10 10 5 C
10. s 3 2 Mixtures Description Mixture of substances listed below with nonhazardous additions Additional information For the listed ingredients the identity and exact percentages are being withheld as a trade secret For the wording of the listed risk phrases refer to section 16 0 0 0 HMIS Long Term Health Hazard Substances None of the ingredients are listed Danaerous components SECTION 4 First aid measures 4 1 Description of first aid measures General information No special measures required After inhalation Supply fresh air consult doctor in case of complaints After skin contact Immediately rinse with water If skin irritation is experienced consult a doctor After eye contact Rinse opened eye for several minutes under running water Contd on page 3 Page 3 9 Safety Data Sheet Trade name Moldex Deep Stain Remover HE Contd of page 2 Remove contact lenses if worn Seek medical treatment in case of complaints After swallowing Do not induce vomiting call for medical help immediately 4 2 Most important symptoms and effects both acute and delayed No further relevant information available Hazards No further relevant information available 4 3 Indication of any immediate medical attention and special treatment needed No further relevant information available SECTION 5 Firefighting measures 5 1 Extinguishing media Suitable extinguishing agents CO2 pow
11. t information available 10 6 Hazardous decomposition products No dangerous decomposition products known SECTION 11 Toxicological information 11 1 Information on toxicological effects Acute toxicity LD LC50 values relevant for classification None Primary irritant effect on the skin No irritant effect on the eye No irritating effect Sensitization No sensitizing effects known Subacute to chronic toxicity No further relevant information available Additional toxicological information The product is not subject to classification according to the calculation method of the General EU Classification Guidelines for Preparations as issued in the latest version When used and handled according to specifications the product does not have any harmful effects to our experience and the information provided to us Repeated dose toxicity No further relevant information available SECTION 12 Ecological information 12 1 Toxicity Aquatic toxicity No further relevant information available 12 2 Persistence and degradability No further relevant information available 12 3 Bio accumulative potential No further relevant information available 12 4 Mobility in soil No further relevant information available Additional ecological information General notes Water hazard class 1 German Regulation Self assessment slightly hazardous for water Contd on page 7 Safety Data Sheet Page 7 9 Trade name Moldex Deep Stain Remo
12. ver HE Contd of page 6 Do not allow undiluted product or large quantities of it to reach ground water water course or sewage system 12 5 Results of PBT and vPvB assessment PBT Not applicable vPvB Not applicable 12 6 Other adverse effects No further relevant information available SECTION 13 Disposal considerations 13 1 Waste treatment methods Recommendation Smaller quantities can be disposed of with household waste Small amounts may be diluted with plenty of water and washed away Dispose of larger amounts in accordance with Local Authority requirements Uncleaned packaging Recommendation Disposal must be made according to official regulations Recommended cleansing agents Water if necessary together with cleansing agents SECTION 14 Transport information 14 1 UN Number DOT ADR ADN IMDG IATA Not Regulated 14 2 UN proper shipping name DOT ADR ADN IMDG IATA Not Regulated 14 3 Transport hazard class es DOT ADR ADN IMDG IATA Class Not Regulated 14 4 Packing group DOT ADR IMDG IATA Not Regulated 14 5 Environmental hazards Marine pollutant No 14 6 Special precautions for user Not applicable 14 7 Transport in bulk according to Annex Il of MARPOL73 78 and the IBC Code Not applicable UN Model Regulation SECTION 15 Regulatory information 15 1 Safety health and environmental regulations legislation specific for the substance or mixture United States USA SARA Contd
Download Pdf Manuals
Related Search