Samsung DV4015J User's Manual
Contents
1. The appliances are stacked in space economizing manner in this arrangement the washing machine at the bottom and the dryer at the top SAMSUNG Clothes Dryers Owner s Instructions Installation Instructions SPECIAL INSTALLATION REQUIREMENTS ALCOVE OR CLOSET INSTALLATION WARNING To reduce the risk of fire this dryer MUST BE EXHAUSTED TO THE OUTDOORS See EXHAUST INFORMATION section Minimum clearances between dryer cabinet and adjacent walls or other surfaces are 0 either side 1 front and rear Minimum vertical space from floor to overhead cabinets ceilings etc is 52 132cm Closet door must be louvered or otherwise ventilated and must contain a minimum of 60 sq in of open area equally distributed If this closet contains both a washer and a dryer doors must contain a minimum of 120 sq in of open area equally distributed MINIMUM CLEARANCES OTHER THAN ALCOVE OR CLOSET INSTALLA TIONS e Minimum clearances to combustible surfaces O clearance both sides and 25 mm 1 rear MOBILE HOME INSTALLATION e The dryer must be exhausted to the outdoors with the termination securely fastened to the mobile home structure See EXHAUST INFORMATION section The exhaust MUST NOT be terminated beneath a mobile home Provisions must be made for the introduction of outside air into the dryer The free air open ing shall not be less than 80 cm 12 in The exhaust duct material MUST BE METAL The dryer must be attac2. QUESTIONS USE THIS PROBLEM SOLVER PROBLEM POSSIBLE CAUSE DRYER WON T Dryer unplugged Make sure power cord is plugged in START e No power to dryer Check fuses and circuit breakers to make sure dryer is getting current Most electric dryers use two Controls improperly set Make sure controls are and that the Start button is pressed Opening the door during operation stops the dryer To restart close the door and push the Start button Dryer door is open Close door securely dryer will not run with door open Circuit is overloaded Do not operate other appliances on the same electrical outlet or circuit while the dryer is operation CLOTHES TAKE TOO Controls improperly set Check all controls to make sure they are correctly set for the LONG TO DRY load you want to dry See the How to Operate Your Dryer section See the Care and Cleaning section Clogged lint filter Clean filter before every load Periodically remove lint filter and clean area under it with vacuum cleaner Improper ducting Make sure dryer is ducted in accordance with the Installation Instructions Obstruction in exhaust ducting Make sure ducting is clean and free of obstruction make sure damper in outside wall cap operates easily If flexible ducting is used be sure it is not kinked and is properly installed according to the Installation Instructions Blown fuses or tripped circuit breakers Check household fuses or circuit breakers Most electric dryers
3. and the content of water During the first phase of the drying cycle the display will indicate the total estimated time of the dry e During the drying cycle you will again be able to verify the degree of dryness of the clothing and then increase or decrease the remaining time according to the desired results Max DRY time is 3 hours SAMSUNG Clothes Dryers Owner s Instructions 8 Care and Cleaning CLEANING FILTER Clean the filter before every dryer use Slide the grid out as shown 00000 O Clean the lint filter Put your moistened fingers at one corner of the filter and wipe in a sideways motion all the PULL way across to the other corner CLEAN LINT FILTER AFTER EACH CYCLE Do not operate the dryer without the grid in place Do not operate the dryer without the filter in place Periodically remove the lint filter it snaps in and out and insert the suction hose adapter from your vacuum cleaner into the opening Do the same through the rectangular opening at top or bottom of the door and at the louvers on the cabinet front DRYER EXTERIOR Wipe off any spills or washing compounds Wipe or dust with a damp cloth Try not to strike the surface with sharp objects Dryer control panel and finishes may be damaged by some laundry pre treat ment soil and stain remover products if such products are sprayed on or have direct contact with the dryer Apply these pre treat
4. are used they must be equivalent to a 100 mm 4 dampered wall cap in regard to resistance to air flow prevention of back drafts and maintenance required to pre vent clogging SEPARATION OF TURNS Separate all turns by at least Im 3ft of straight duct including distance between last turn and dampered wall cap If two turns must be closer than 1 m 3 ft deduct 3 m 10 ft from the maximum lengths shown in the table for each occur rence TURNS OTHER THAN 90 One turn of 45 or less may be ignored e Two 45 turns should be treated as one 90 e Each turn over 45 should be treated as one 90 SEALING OF J OINTS e All joints should be tight to avoid leaks The male end of each section of duct must point away from the dryer Do not assemble the duct work with fas teners that extend into the duct They will serve as a collection point for lint e Duct joints can be made air and mois ture tight by wrapping the overlapped joints with duct tape n gt ULATION e Duct work which runs through an unheated area or is near an air condi tioning duct should be insulated to reduce condensation and lint build up and be sloped down toward outdoors NOTE Never install screen inside exhaust duct WARNING THE DRYER MUST EXHAUST TO THE OUTDOORS TO PREVENT LARGE AMOUNTS OF LINT AND MOISTURE FROM ACCU MULATING AND TO MAINTAIN DRY ING EFFICIENCY THIS MACHINE MUST BE EXHAUSTED OUTDOORS SAMSUNG Clothes Dry
5. gt Cotton Cupboard 7 FILTER lamp Turn the system ON to let FILTER lamp flicker 3 times When a drying cycle is fin ished FILTER lamp turns ON to display cleaning instruction of filter 8 CHILD LOCK lamp When the system turns ON push Wrinkle Free button and DELAY START button in order to turn CHILD LOCK lamp ON From this time all buttons do not operate To cancel the mode push DELAY START button and Winkle Free button in reverse order 9 START PAUSE button Press the button to start and pause the system 10 POWER button Press the button once to turn the system ON press it once more to turn the system OFF When the system turns ON for longer than 10 minutes without pressing any but tons it automatically turns OFF SAMSUNG Clothes Dryers Owner s Instructions Operating Instructions Tips HOW TO OPERATE YOUR DRYER TO DRY CLOTHES USING THE PROGRAMS 1 Open the door and put the laundry in the dryer 2 Press the power button 3 Turn the Dial to choose the program You will see the indications light up on the control panel Cotton Cupboard lt gt Cotton Light gt Cotton Iron lt gt Cotton Rotary Iron Airing lt gt Synthetic Extra lt S ynthetic Very lt Synthetict Cupboard lt S ynthetic Light lt gt Synthetic Iron gt Synthetic Rotary Iron Airing lt gt Cotton Extra gt Cotton Very lt gt Cotton Cupboard 4 You can control the temperature button Cotton course 5 Press the Start Pause button
6. in home or on site services minimum or maximum repair times exchanges or replacements accessories options upgrades or consumables For the location of a SAMSUNG Authorized Service Center please call toll free In the United States 1 800 SAMSUNG 1 800 726 7864 In Canada 1 800 SAMSUNG Or on line at WWW SAMSUNGUSA COM and WWW SAMSUNGCANADA COM SAMSUNG Clothes Dryers Owner s Instructions 12 Operating Instructions Tips 16 SAMSUNG Clothes Dryers Owner s Instructions
7. repairs commercial use or damage that occurs during shipping Customer adjustments which are explained in this owner s manual are not covered under the terms of this warranty This warranty will automatically be voided for any unit found with a missing or altered serial number This warranty is valid only on products purchased and used in the Canada SAMSUNG ELECTRONICS NORTH AMERICAN LIMITED WARRANTY STATEMENT Subject to the requirements conditions exclusions and limitations of the Original Limited Warranty supplied with Samsung Electronics SAMSUNG products and the requirements conditions exclusions and limitations contained herein SAMSUNG will additionally provide Warranty Repair Service in the United States on SAMSUNG products purchased in Canada and in Canada on SAMSUNG products purchased in the United States for the warranty period originally specified and to the Original Purchaser only The above described warranty repairs must be performed by a SAMSUNG Authorized Service Center Along with this Statement the Original Limited Warranty Statement and a dated Bill of Sale as Proof of Purchase must be presented to the Service Center Transportation to and from the Service Center is the responsibility of the purchaser Conditions covered are limited only to manufacturing defects in material or workmanship and only those encountered in normal use of the product Excluded but not limited to are any original specified provisions for
8. Clothes Dryers Owner s Instructions DV4015 ay Code No DC68 01576A 01 1 Table of Contents Safety Instructions sisas 2 Installation Instructions Installation Instructions Exhaust e 4 Exhaust length taleul tons nao conc 5 Exhaust directions menores 5 Special ACCESSOLY rsennssessnssennssenssssssnssesssssusnssenssssssnssensssessnssensssessnssensssenenesenn 5 Special installation requirements soaks Saks dete Sia aha RER 6 Electrical power supply o LEN ITS RUNTER DIE A 6 Operating Instructions Tips Control panel eRe eS SS 7 How to operate your dryer at pence anasto enge 8 Polyester Knits Permanent Press Drying Tips ee 8 Lodig Clothes erregen 8 Care and Cleaning Cleaning filter A A A A a 9 Dryer Exterl r nar AA A 9 Dryer EXhaust essen eres ne rt ee 10 Inside the dryer cabinet ee ee 10 Problem Solver isa 2 ait 11 Questions Use this problem COVE Finis da 11 Appendix ee Be ed rel EN dah eit 12 Warranty INTOrmaloNn aka nee 12 SAMSUNG Clothes Dryers Owner s Instructions Safety Instructions Read all instructions before using this appliance Waming It is extremely important that you read and adhere to the following instructions Failure to do so could cause bodily injuries and or property damage due to fire Use this appliance only for its intended purpose as described in this Owner s Manual This dryer must be properly installed and located in accordance with the Installation
9. Instructions 6 Operating Instructions Tips CONTROL PANEL nn TE CS wv During DRY cycle displayed remaining time may be increased or decreased Such a condition is not a system failure but aDRY function optimization process Load less than 8lb to get the best drying result Max DRY time is 3 hours 1 SIGNAL button Initial mode is set to OFF at the factory and no completion buzzer makes sound Push the SIGNAL button to turn the SIGNAL lamp ON and make the completion buzzer sound 2 TEMPERATURE button Initial mode is set to OFF at the factory Push TEMPERATURE button to select LOW temperrature and turn lamp ON 3 TIME button TIME button displays 1 30 minutes at its initial mode You can decrease each 10 minutes by pushing the button each one time 130 120 E00 Lee 30 gt 20 gt 1 30 4 DELAY START button DELAY START button is to be selected in order of 1 hour gt 2 hours gt 3 hours gt 24 hours gt Cancel 5 WRINKLE FREE button Push Wrinkle Free button to run COOL DOWN 10 minutes after adjusting temperature for 10 minutes 6 SELECTION OF CYCLE Turn Dial to indicate cycles in the following order Cotton Cupboard lt gt Cotton Light lt gt Cotton Iron lt gt Cotton Rotary Iron lt gt Airing lt gt Synthetic Extra gt Synthetic Very lt Synthetict Cupboard lt Synthetic Light Synthetic Iron lt gt Synthetic Rotary Iron lt gt Airing lt gt Cotton Extra lt gt Cotton Very lt
10. Instructions before it is used Properly ground to conform with Local Codes Follow details in Installation Instructions Locate where the temperature is above 50 F 10 C for satisfactory operation of the dryer control system Do not install or store the dryer where it will be exposed to the weather Connect to a properly rated protected and sized power supply circuit to avoid electrical overload Exhausting to the outside is STRONGLY RECOMMENDED to prevent large amounts of moisture and lint from being blown into the room Carefully follow the Exhausting Details in the Installation Instructions Do not repair or replace any part of the appliance or attempt any servicing unless specifically recommended in this Owner s Manual When disconnecting this appliance pull by the plug rather than the cord to avoid damage to the cord or junction of cord and plug Make sure that the cord is located so that it will not be stepped on tripped over or otherwise subjected to damage or stress To Minimize the Possibility of a Fire Hazard e Exhaust Duct See Installation Instructions Use only rigid metal or flexible metal 4 diameter ductwork for exhausting to the outside USE OF PLASTIC OR OTHER COMBUSTIBLE DUCTWORK CAN CAUSE A FIRE FOIL OR OTHER EASILY PUNCTURED DUCTWORK CAN CAUSE A FIRE IF IT COLLAPSES OR BECOMES OTHERWISE RESTRICTED IN USE OR DURING INSTALLATION Do not use heat to dry articles containing rubber plastic or similar m
11. OT be built into the dryer These factors MUST BE supplied by the person s installing maintain ing or operating the dryer Failure to install maintain and or operate this machine according to the manufacturer s instruc tions may result in conditions which can produce bodily injury and or property damage This dryer comes ready for top exhausting WARNINGS e DO NOT USE NON METALLIC FLEXIBLE DUCT Never use flexible duct inside the dryer Do not terminate exhaust in a chimney range hood gas vent floor or attic The combination of lint and grease could create a fire hazard or damages Provide an access for inspection and cleaning the exhaust system at least once a year EXHAUST LENGTH The MAXIMUM ALLOWABL E length of the exhaust system depends upon the type of duct number of turns the type of exhaust hood wall cap and all conditions noted below The maximum allowable length for both rigid and flexible metal duct is shown in the table 1 next page More than four 90 turns is not recom mended EXHAUST SYSTEM CHECK LIST HOOD or WALL CAP Terminate in a manner to prevent back drafts or entry of birds or other wildlife Termination should present minimal resistance to the exhaust air flow and should require little or no maintenance to prevent clogging Wall caps must be installed at least 300 mm 12 above ground level or any other obstruction with the opening pointed down If roof vents or louvered plenums
12. afety Instructions Clean the lint filter before each load to prevent lint accumulation inside the dryer or in the room DO NOT OPERATE THE DRYER WITHOUT THE LINT FIL TER IN PLACE Keep the area around the exhaust opening and around and underneath your appli ances free from the accumulation of combustible materials such as lint paper rags chemicals etc Regularly inspect the exhaust duct to be sure it has not been crushed or otherwise restricted The interior of the dryer cabinet and the exhaust duct connection inside the dryer should be cleaned every 2 to 3 years or more often if needed by a qualified ser vice person To Minimize the Possibility of Injury Never reach into the dryer while the drum is moving Before loading unloading or adding clothes wait until the drum has completely stopped Do not dry fiberglass articles in your dryer Skin irritation could result from the remaining glass particles that may be picked up by clothing during subsequent dryer uses The laundry process can reduce the flame retardance of fabrics To avoid such a result the garment manufacturer s care instructions should be followed very care fully Close supervision is necessary if this appliance is used by or near children Do not allow children to play inside on or with this appliance or any discarded appli ance Dispose of discarded appliances and shipping or packing materials properly Before discarding a dryer or removing for ser
13. and dry cycle will begin TO DRY CLOTHES MANUALLY 1 Open the door and put the laundry in the dryer 2 Press the power button 3 Press the Time button to set drying time and to make dry your laundry as you want You may select drying time 1 30 gt 1 20 1 10 1 00 gt 30 gt 20 gt 1 30 in order by pressing the button continuously 4 Press the Start Pause button and dry cycle will begin ESTE KNITS PERMANENT PRESS DRYING TIPS DO NOT OVERLOAD Garments being dried or dewrinkled should tumble freely e REMOVE CLOTHES PROMPTLY To help prevent wrinkling remove clothes from the dryer promptly at the end of the drying cycles e PLACE ON HANGERS Permanent press and polyester knit garments look best if placed on hangers after drying LOADING CLOTHES e Don t overload your dryer Crowded loads don t dry efficiently and clothes may be unnecessarily wrinkled e Asa general rule sort clothes by surface texture fabric colour and weight as you would for your washer Do not add fabric softener sheets once the load has become warm e Do not overload This wastes energy and caused wrinkling e Do not dry the following items fiberglass items woolens rubber coated items plastics items with plastic trim and foam filled items e Clothing with metallic components may damage the drum interior during drying Caution e The display indicates remaining time by automatically calculating the quantity of clothing
14. aterials such as padded bras tennis shoes galoshes bath mats rugs bibs pillows baby pants plastic bags etc as these materials may melt or burn Also some rubber materials when heat ed can under certain circumstances produce fire by spontaneous combustion Do not store items that may burn or melt such as clothing paper material plastics or plastic containers etc on top of the dryer during the operation Garments labeled Dry Away from Heat must not be put in your dryer Do not wash or dry articles that have been cleaned in washed in soaked in or spotted with combustible or explosive substances such as wax paint gasoline degreasers dry cleaning solvents kerosene etc which may ignite or explode Do not add these substances to the wash water Do not use these substances around your washer and or dryer during operation Any article on which you have used a cleaning solvent or which contains flammable materials such as cleaning cloths mops towels used in beauty salons restaurants or barber shops etc must not be placed in or near the dryer until all traces of these flam mable liquids or solids and their fumes have been removed There are many highly flammable items used in homes such as acetone denatured alcohol gasoline kerosene some household cleaners some spot removers turpentines waxes wax removers and products containing petroleum distillates SAMSUNG Clothes Dryers Owner s Instructions 2 S
15. e GIVE THE MODEL AND SERIAL NUMBERS AND DESCRIBE THE SYMPTOMS OF THE DRYER 11 SAMSUNG Clothes Dryers Owner s Instructions Appendix WARRANTY INFORMATION Limited Warranty for Original Purchaser This Samsung product is warranted by Samsung Electronics Canada Inc hereafter referred to as SECA against manufacturing defects in material or workmanship for the following periods Labor 1 year in home Parts 1 year SECA further warrants that if this product fails to operate properly within the specified warranty period and the failure is due to improper workmanship or defective material SECA will repair or replace the product at its option All warranty repairs or part replacements must be performed by a SECA Authorized Service Center To find the nearest SECA Service Center call 1 800 SAMSUNG or visit our web site at www samsungcanada com Obligation to the Original Owner The original dated sales receipt must be retained by the customer and is the only acceptable proof of purchase It must be presented to a SECA Authorized Service Center at the time service is requested before warranty ser vices are rendered On all carry in models transportation to and from the Authorized Service Center is the responsibility of the customer Exclusions of the Warranty This warranty does not cover damage due to accident fire flood and or other Acts of God misuse incorrect line voltage improper installation improper or unauthorized
16. ers Owner s Instructions 4 Installation Instructions EXHAUST LENGTH CALCULATION Table 1 RECOMMENDED MAXIMUM LENGTH ELECTRIC DRYERS Weather Hood Type Use only for short run installations PP 24 10 16cm 2 1 2 6 35cm Metallic Flexible Rigid Metallic Flexible 14m 46ft 9m 30ft 11m 37ft 7m 24ft 11m 38ft 7 5m 25ft 9m 30ft 6m 20ft 9m 31 ft 6m 20ft 6 5m 22ft 4m 14ft 7m 24ft 5m 16ft 4 5m 15ft 3m 10ft Do not use non metallic flexible duct EXHAUST DIRECTIONS All dryers shipped from the factory are set up for rear exhausting However exhausting can be on the right or left side of the cabinet or the bottom of the dryer e Remove access panel at back of dryer to gain access to internal ducts e Disconnect duct exhaust from blower housing e Remove desired knockout plate either right or left side e Attach a 90 elbow duct to blower housing and facing desired opening e Reinstall rear access panel 4 3 8 11cm 5 E Y Same as other side 5 S ay 3 3 4 Sem 5 1 8 sem 3 3 4 95cm 13 1 2 34cm EXHAUST DUCT LOCATING DIMENSIONS NOTE Non metallic ducts must never be used inside dryer cabinet Optio SPECIAL ACCESSORY Stacking kit Model no SK 2 You can obtain the stacking kit from your retailer With this kit you can combine your dryer with Samsung automatic washing machine to a washing and drying column
17. hed to the floor following instructions available from the dealer Installation must comply with the current CAN CSA Z240 MH series Mobile Home Installation Codes NOTE CONSIDERATION MUST BE GIVEN TO INSTALLING AND SERVICING THE APPLIANCE ELECTRICAL POWER SUPPLY CAUTION NEVER USE AN EXTENSION CORD WITH THIS APPLIANCE e This dryer must be connected to an individual circuit identical to the one specified on the rating plate of the loading port protected by fuses or circuit breaker conforming to local codes THIS APPLIANCE MUST BE PROPERLY GROUNDED e The power cord of this appliance is equipped with a three 3 or four 4 prong plug which mates with an appropriate dryer wall receptacle GROUNDING INSTRUCTIONS e This appliance must be grounded In the event of malfunction or breakdown grounding will reduce the risk of electric shock by providing a path of least resistance for electric current The plug must be plugged into an appropriate outlet that is properly installed and grounded in accordance with all local codes and ordinances WARNING e Improper connection of the equipment grounding conductor can result in a risk of electric shock Check with a qualified electrician or serviceman if you are in doubt as to whether the appliance is properly grounded e Do not modify the plug provided with the appliance if it will not fit the outlet have a proper outlet installed by a qualified electrician SAMSUNG Clothes Dryers Owner s
18. ment products away from the dryer The fabric may then be washed and dried normally Damage to your dryer caused by pre treatment prod ucts is not covered by your warranty SAMSUNG Clothes Dryers Owner s Instructions Care and Cleaning DRYER EXHAUST MAXIMIZE YOUR DRYER EFFICIENCY BY KEEPING THE EXHAUST DUCT CLEAN CONNECTED TO EXHAUST HOOD 1 Disconnect or Turn off electrical power DRYER 2 Disconnect duct from dryer 3 Clean exhaust duct from end where dryer is connected to the exhaust hood using Check turns in the exhaust duct for any collected lint e the hose attachment of your vacuum nn gt N cleaner EEE e a dust rag attached to a pole for straight JAN If stretches or to a drain cleaning wire U Ze for less accessible turns 4 Inspect exhaust hood To minimize resistance to the exhaust air flow e flap must move freely you may check with a mirror e flap should be fully open when dryer is on e ensure that no wildlife birds insects have nested inside the duct INSIDE THE DRYER CABINET CLEANING LINT FROM YOUR DRYER Combustible lint may collect on the inside of the dryer cabinet CLEAN EVERY 2 TO 3 YEARS OR MORE OFTEN DEPENDING ON USAGE Cleaning should be done by a qualified service person ALWAYS VERIFY PROPER OPERATION AFTER SERVICING SAMSUNG Clothes Dryers Owner s Instructions 10 PROBLEM SOLVER
19. use two It is possible for one to be blown or tripped and the dryer still tumble without heat Improper sorting Do not mix heavy hard to dry items with lightweight articles Large loads of moisture holding fabrics such as beach towels take a long time to remove moisture Too many items in dryer Dry only one washer load at a time Do not combine loads Too few items in dryer If drying only one article add two more similar articles even if dry to ensure proper tumbling SHRINKAGE GEN e Some fabrics will shrink whether machine washed and tumble dried or washed by ERAL hand and drip dried others may be safely washed but will shrink in a dryer Follow Garment Manufacturers Care Labels exactly If in doubt do not machine wash or tumble dry WRINKLING e Leaving clothes in dryer after tumbling stops Remove clothes promptly and hang them immediately Improper loads Avoid laundering heavy Permanent Press items such as work clothes with lighter Permanent Press items such as shirts or blouses Do not wash or dry Permanent Press with regular laundry e Failure to use fabric softener Proper use of fabric softener will minimize wrinkling TO REMOVE WRIN Try one or more of these suggestions KLES e If unsuccessful retumble on high heat for 10 12 minutes and hang immediately e Iron carefully e Send to dry cleaners for pressing e Some wrinkles may remain which cannot be removed IF DRYER STILL DOES NOT OPERATE call for Servic
20. vice remove the door of the dryer compartment Keep all laundry aids such as detergents bleaches fabric softeners etc out of the reach of children preferably in a locked cabinet Observe all warnings on con tainer labels to avoid personal injury Keep the floor around your appliances clean and dry to reduce the possibility of slipping To minimize the possibility of electric shock unplug this appliance from the power supply before attempting any maintenance or cleaning except the removal and cleaning of the lint filter Do not tamper with the controls Do not operate this appliance if it is damaged malfunctioning partially disassem bled or has missing or broken parts including a damaged cord or plug Never climb on or stand on the dryer top DO NOT place items exposed to cooking oils in your dryer Items contaminated with cooking oils may contribute to a chemical reaction that could cause a clothes load to catch fire SAVE THESE INSTRUCTIONS 3 SAMSUNG Clothes Dryers Owner s Instructions Installation Instructions INSTALLATION INSTRUCTIONS EXHAUST Installation and service must be performed by a qualified installer or service agency IMPORTANT Have your dryer installed properly NOTE The WARNING and IMPORTANT instructions appearing in this manual are not meant to cover all possible conditions and situations that may occur It must be under stood that common sense caution and carefulness are factors that CANN
Download Pdf Manuals
Related Search