Masterbuilt Propane Turkey Fryer 20020107 User's Manual
Contents
1. n S re i A m vio i oe TEE kia g Fha i koe E g A i i DANGER 1 Never operate this appliance unattended 2 Never operate this appliance within 10 ft 3m of any structure combustible material or other gas cylinder Model STQI Never operate this appliance within 25 ft 7 5 m of flammable liquid Steak Rack Do not fill cooking vessel beyond maximum fill line Never allow the oil or grease to get hotter than 400 F 200 C If the temperature exceeds 400 F 200 C or if oil begins to smoke immediately turn the burner or gas supply OFF Heated liquids remain at scalding temperatures long after the cooking process Never touch cooking appliance until liquids have cooled to 115 F 45 C or less If a fire should occur keep away from appliance and immediately call your fire department Do not attempt to extinguish an oil or grease fire with water Model 30BV Failure to follow these instructions could result in fire explosion or burn hazard which could 30 qt Turkey Pot with cause property damage personal injury or death valve Drain Hook Basket Lifting Hook Lid and Thermometer WARNING 1 Even when burner is set at a low flame never leave the appliance unattended Oil will heat up quickly and ignite at 550 F 287 C to 700 F 371 C 2 Tripping over the appliance hose may result in the tipping of the appliance and spilling of HOT oil or water causing personal i2. Send us your recipe Marketing Dept Masterbuilt Mfg Inc 1 Masterbuilt Court Columbus GA 31907 20 HOW TO DEEP FRY STEAKS e Choose steaks to your desired thickness e Season the outside of steaks with Southern Secrets Sizzlin Steak Dry Rub Seasoning e 2 gallons of oil in a 30 qt 28 4L pot STEP 1 Place steaks on steak rack STEP 2 Bring oil temperature to 350 F 177 C It is important to maintain a 350 F 177 C temperature while cooking Place rack in basket and slowly lower basket into oil Wear Protective Gloves Cook steaks for total amount of cooking time using the chart below Cooking Time for 1 to 4 Steaks Thickness Medium Rare Medium _ Well Done 112 3 Minutes 3 4 4 Minutes 5 Minutes 11 4 6 Minutes KA 7 Minutes STEP 3 When cooking is complete turn fryer OFF and remove food slowly HOW TO DEEP FRY CORNISH HENS e 1 to 4 completely thawed cornish hens e Inject each hen with Southern Secrets Marinade of you choice Season the outside of the hens with Southern Secrets Dry Rub Seasoning e 2 gallons of oil in a 30 qt 28 4L pot Cooking Time for 4 Cornish Hens 3 minutes per pound plus 5 minutes equals total cooking time Example Use the weight of the heaviest hen 1 hen 1 87 lbs 0 8kg 3 minutes x 1 87 5 61 5 61 minutes 5 10 61 Total cooking time 11 Minutes When cooking is complete turn burner OFF and remove food slowly WARNING Do not allow oil to get hott
3. 3 Clip thermometer to the side of the cooking pot as shown 20020107 20020209 ALL MODELS ALL MODELS ALL MODELS Note Do not allow thermometer to pierce into food This will f give a false reading See below for thermometer safety check A CAUTION Thermometer Safety Check e Before each use place the thermometer stem in boiling water and ensure that it registers approximately 212 F 20 F 100 C 10 C If it does not contact Masterbuilt to order a replacement e When thermometer is lowered into HOT oil do not allow it to pierce into the turkey or food This will give a false reading e When the thermometer is in place the dial will continue to rise Keep a constant check on the dial to ensure the dial indictor does not stop before reaching 350 F 177 C e If the oil starts to smoke and the thermometer dial stops before reaching 350 F 177 C turn burner off and STOP COOKING IMMEDIATELY A new thermometer is needed If the thermometer supplied with the appliance is lost or damaged call Masterbuilt to order a replacement at 1 800 489 1581 DO NOT RETURN TO RETAILER For Assembly Assistance Missing or Damaged Parts Call MASTERBUILT Customer Service at 1 800 489 1581 Model DF 12 12 Thermometer for 30at pots WARNING Extinguish all open flames before connecting the regulator to the gas cylinder Turn the gas OFF after each use 15 REGULATOR TO GAS CYLINDER VALVE CONNECTION TYPE 1 C
4. MASTERBUILT Distributed By Masterbuilt Manufacturing Inc 1 Masterbuilt Court Columbus Georgia 31907 Customer Service 1 800 489 1581 www masterbuilt com a STERBUILT M TURKEY FRYER WITH TIMER MODEL NUMBERS 20020107 20020109 20020209 20020407 20020507 ALL UNITS ARE FOR OUTDOOR USE ONLY MANUAL CODE 900000483 071211 02JH FOLLOWING THESE INSTRUCTIONS WILL ALLOW YOU TO HAVE A SAFE COOKING EXPERIENCE SEE PAGE 18 FOR INSTRUCTION ON HOW TO DEEP FRY A TURKEY POTS NOT INCLUDED ON ALL MODELS CHECK PACKAGING FOR DETAILS LP GAS CYLINDER NOT INCLUDED TOOLS NEEDED ADJUSTABLE WRENCH PHILLIPS HEAD SCREWDRIVER APPROXIMATE ASSEMBLY TIME 30 MINUTES WARNING THIS INSTRUCTION MANUAL CONTAINS IMPORTANT INFORMATION NECESSARY FOR THE PROPER ASSEMBLY AND SAFE USE OF THE APPLIANCE READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS BEFORE ASSEMBLING AND USING THE APPLIANCE FOLLOW ALL WARNINGS AND INSTRUCTIONS WHEN USING THE APPLIANCE KEEP THIS MANUAL FOR FUTURE REFERENCE OPTIONAL ACCESSORIES DANGER A Model IS35 Model DF12 Injecting 12 Thermometer If you smell gas Syringe 1 Shut off gas to the appliance 2 Extinguish any open flame 3 Open Lid 4 If odor continues keep away from the appliance and immediately call your fire department Failure to follow these instructions could result in fire or explosion which could cause property damage personal injury or death Te Ls
5. hook Wear Protective Gloves Stay away from hot steam 3 Cover with lid 4 When food is ready to remove turn the burner to OFF position Remove lid and use the lifting hook to pull basket up slowly Wear Protective Gloves Stay away from hot steam 5 Hook basket to the side of the pot with the drain hook allowing the food to drain and cool Lifting Hook O Drain Hook hy Ia rt Fill Line 17 Using the Pot with the Turkey Hook Do not overfill pot with oil or water A fill line is marked on the larger frying and boiling pots smaller fry pans may not be marked 1 Position turkey hook on side 2 Slowly slide turkey onto hook breast cavity first as shown below 3 Lower turkey hook into oil or water using lifting hook Wear Protective Gloves Stay away from hot steam 3 Cover with lid 4 When food is ready to remove turn the burner to OFF position Remove lid and use the lifting hook to pull turkey hook up slowly Wear Protective Gloves Stay away from hot steam 5 Allow the food to drain and cool TA n S ESA Lifting Hook Turkey Hook ASSEMBLY INSTRUCTIONS READ ALL INSTRUCTIONS AND WARNINGS CAREFULLY BEFORE ASSEMBLY OR OPERATION OF YOUR TURKEY FRYER PARTS LIST s n fwen 4 n o Reouaorana Hose sr Shutter 1 6 o o e Venturi HARDWARE LIS fas Sg AN 4 y A J Wo A B M6x13 Burn
6. elf burner does not light within 5 seconds turn regulator control valve OFF then turn gas cylinder valve OFF Wait 5 minutes for fumes to diminish turn timer knob clockwise until its stops before relighting elf the flame is blown out wait 5 minutes for fumes to diminish before resetting timer and relighting eAfter the burner is lit open the regulator valve until the flame increases Use the air shutter on the burner to adjust the flame until it turns blue Reduce flame Fill Pot with water or oil DO NOT fill pot more than 1 3 the pots full capacity This will help avoid dangerous boil overs Note DO NOT place your empty pot over the open flame This will damage pot Bring water or oil to the desired temperature by adjusting regulator control valve Oil should never exceed 400 F 204 C Oil will ignite at 550 F 287 C to 700 371 C eAlways use a thermometer when frying After each use first turn the regulator control valve OFF then turn the gas cylinder OFF Always allow fryer stand and pot with water or oil to cool completely before touching moving or storing FLAME VIEWING HOLE LIGHTING POSITION 10 BATTERY INSTALLATION Replace batteries when low battery light is on Disconnect regulator from tank before installation or replacement 1 Locate battery cover on timer 2 Press and slide battery cover off as shown 3 Install 2 AAA Alkaline batteries Check positive and negative symbols
7. free of any combustible material gasoline and other flammable vapors and liquid e Use this appliance only on a level stable non combustible surface such as brick concrete or dirt Do not use appliance on or around any surface that will burn or melt such as wood decks dry grass leaves wood rails vinyl or plastic An asphalt surface black top may not be acceptable e Never use this product for anything other than its intended purpose This appliance is not intended for commercial use e Keep children and pets away from appliance at all time Do not leave appliance unattended e This appliance is for outdoor use only e Never move appliance when in use Allow appliance to cool below 115 F 45 C before moving or storing it e Always wear shoes during operation of this appliance e Avoid touching hot surfaces This appliance will be hot during and after use Always wear insulated gloves or mitts when removing lid or basket from the cooking vessel e Accessory attachments and cookware not manufactured or supplied by Masterbuilt are not recommended for use e Never place an empty cooking vessel on the appliance while in operation This may damage the cooking vessel Use caution when placing anything in cooking vessel while appliance is in operation e Keep fuel supply hose away from the appliance while in operation Before you start to cook check wind direction amp place gas cylinder UPWIND and upright 20 50cm away from the tur
8. minutes later add corn 3 minutes later add shrimp and craw fish together 3 minutes later remove and serve For a Cajun flare pour on top of newspaper in the middle of your table and enjoy FRIED FISH HOT WINGS amp BOILED SEAFOOD CAJUN FRIED FISH 1 Gallon of Oil 4 catfish or red snapper fillets 1 2 to 3 4 inch thick 1 to 1 1 4 Ibs 1 4 cup all purpose flour 1 4 cup yellow cornmeal 1 teaspoon dried basil crushed 1 teaspoon onion powder 1 2 to 1 teaspoon ground red pepper 1 2 teaspoon garlic salt 1 2 teaspoon ground white pepper 1 2 teaspoon dried thyme crushed 1 4 to 1 2 teaspoon black pepper 1 4 teaspoon ground sage 1 4 cup margarine or butter Thaw fish if frozen In a mixing bowl combine flour cornmeal basil onion powder red pepper garlic salt white pepper thyme black pepper sage and butter Coat both sides of the fish with the flour mixture Bring 1 gallon of oil to 350 F 177 C and deep fry for 3 to 4 minutes DEEP FRIED ONION 4 Med Onions Cajun Seasoning 1 Gallon of Oil Peel the outer skin off the onions Next cut about a 1 4 off one end of the onions creating a flat top Cut from the flat part of the onion down but not all the way through 1 4 from the bottom Repeat this step 3 to 4 more times in a pie shape Loosen up the onion with your fingers and season the outside and inside of the onion Fry the onion for 3 to 4 minutes flat side down in 350 F 177 C cooking oil
9. 020407 20020507 5 1 iting Hook inside the burner venturi blocking air and gas flow Se 30 Qt Pot w Tap 20020209 20020507 Turkey Hook 20020107 20020209 KEEP AIR SHUTTER CLOSED AFTER EACH USE HOW TO CLEAN Venturi D 1 Remove the hose from the burner using a 7 16 wrench 2 Insert a small rod in the hole that the hose was removed from 3 Hold the burner up to a light looking into the hole that the hose was removed from to see any obstructions 4 If burner has not cleared flush with water 5 Once the burner has been cleared reassemble the burner air shutter spring hose See page 6 When a flame occurs inside the venturi this is caused by a blockage and could cause damage to the hose assembly REMEMBER TO ADD WASHERS WHEN REASSEMBLING THE BURNER 16 REPLACEMENT PARTS LIST A rx A WARNING A If oil starts to smoke TURN BURNER OFF This means the oil has exceeded 400 F 200 C and could catch fire Allow oil to cool to 350 F 175 C before relighting burner NOATEN OME ER j 1 Insert stem of thermometer through hole in lid as shown l When cooking with oil ALWAYS turn off burner before lowering food into oil Relight after food is submerged in the oil DO NOT TURN BURNER TO A LOW SETTING TO KEEP OIL GREASE HOT FOR LATER USE THE TEMPERATURE OF THE OIL GREASE WILL CONTINUE TO RISE AND CATCH FIRE 2 f lid is not being used slide clip onto thermometer stem
10. ING INSTRUCTIONS FOR VESSELS WITHOUT FILL LINES STEP 1 Place food product turkey on or in the holder basket e The use of alcohol prescription or non prescription drugs may impair the consumer s ability to properly STEP 2 Place food product and holder into the empty cooking vessel assemble or safely operate the appliance e Do not obstruct flow of combustion and ventilation Keep ventilation opening s of the cylinder STEP 3 Fill the cooking vessel with water just until the food product is completely submerged For large enclosure free and clear of debris pots only there must be 3 in 8cm between this level amp the top of the vessel e The installation of this appliance must conform with local codes or in the absence of local codes with STEP 4 Remove food product from the cooking vessel and either mark the water level on the side of the the National Fuel Gas Code ANSI Z223 1 NFPA 54 Storage and Handling of Liquefied Petroleum Gases ANSI NFPA 58 Natural Gas and Propane Installation Code CSA B149 1 Propane Storage and Handling CSA B149 2 or the Standard for Recreational Vehicles ANSI A119 2 NFPA 1192 and the cooking vessel or measure the amount of water in the cooking vessel STEP 5 Remove water and completely dry cooking vessel and food product Recreational Vehicle Code CSA Z240 RV Series STEP 6 This is the amount of cooking oil the cooking vessel needs to be filled with to cook your food e The LP gas cylinder be
11. ONNECTION A TO GAS CYLINDER AD COUNTER CLOCKWISE CLOCKWISE Inspect the hose before each use lf there are signs of wear cuts or leaks replace turkey fryer hose amp regulator with part 903070006 REGULATOR CONTROL VALVE OPERATIONS REGULATOR CONTROL FLAME ADJUSTMENT The regulator control valve is used ON OFF to adjust the burner flame Turning the control knob clockwise slowly COUNTER will increase the burner flame and CLOCKWISE CLOCKWISE counter clockwise to decrease and shut the burner flame off Adjust air shutter to the burner until the burner flame is as blue as possible YELLOW A orate o The Regulator Hook is used to keep the regulator FLAME 2 pena off the ground when removed from the LP cylinder Attach to appliance as shown Soapy Water Test Warning and Procedures e The Soapy Water Test must be performed each time gas cylinder is connected to appliance or each time the appliance is used e The Soapy Water Test must be performed outdoors in a well ventilated area When performing the Soapy Water Test always keep fryer away from open flames sparks or lit cigarettes This Outdoor Gas Turkey Fryer is designed to operate with propane gas only This product will not operate with natural gas Never use an open flame to test for gas leaks Always remove any cookware from turkey fryer stand when performing the Soapy Water Test Burner Hose Regulator and PROCEDURE Cylinder
12. Valve 1 Remove any cookware from your fryer stand 2 Turn regulator to OFF position and turn the gas cylinder valve to the OFF position 3 Prepare your soapy water solution by combining 1 one part dish washing liquid with 3 three parts water to test for the possibility of any gas leaks in the hose or connections to regulator and the regulator connection to gas cylinder Apply soapy water solution to the gas cylinder valve regulator and along the hose to the burner 4 Turn gas cylinder valve ON regulator control valve should be in the OFF position and observe gas cylinder valve for bubbles DO NOT LEAVE GAS ON FOR MORE THAN 12 SECONDS If bubbles appear stop turn gas cylinder Burner Hose and orifice OFF and retighten the fitting Repeat test 5 When the gas cylinder has been tested follow timer operation instructions on page 10 DO NOT LIGHT BURNER Open the regulator control valve one full turn and check for bubbles at regulator control valve along the entire length of hose and at the connection to the burner DO NOT LEAVE GAS ON FOR MORE THAN 12 SECONDS If soapy mixture starts bubbling gas is leaking through the connection or hose Turn the regulator valve OFF and then the gas cylinder OFF and retighten the connection that is leaking gas After test is complete and there are no leaks wait a minimum of 5 minutes for gas fumes to diminish before lighting fryer 6 Once testing is complete press power button o
13. age The cylinder may be hazardous and should be checked by a liquid propane supplier e When lighting your appliance remove all parts from fryer stand to prevent an explosion from gas build Up e If burner does not ignite turn off the regulator control valve and gas and wait 5 minutes before trying to light again If burner goes out during operation first turn regulator OFF then turn gas cylinder OFF e Do not allow anyone to conduct activities around your fryer during or following its use until the unit has cooled The fryer is hot during operation and remains hot for a period of time following its use e Always allow the hot water or oil in the pot to cool below 115 F 45 C before moving to avoid the possibility of severe burns e Never drop food or accessories into hot liquids Lower food and accessories into cooking liquid in order to prevent splashing or overflow Be careful when removing food from oil or water It is hot and could cause burns e When using this appliance use caution when removing the basket from the pot to avoid pulling the pot off of fryer stand e Never use glassware plastic or ceramic cookware on this appliance e When fryer use is complete always turn the regulator control valve OFF first then turn the gas cylinder valve OFF Do not use a cooking pot or vessel larger than 30 Quarts 28 4L Cooking Pot or vessel must fit inside the security ring of the fryer Incorrect Correct WARNING Ay COOK
14. cause leaks marinade of your choice Cover the outside of turkey with cajun dry rub reasoning Replace the turkey in basket with legs pointing up Ignite burner see page 9 and bring oil temperature to 350 F 177 C STEP 1 If a fill line is stamped on the pot then STEP 1 is not needed Fill the pot with oil to the fill line and go to STEP 2 If there is no stamped line place thawed turkey up to 18 Ibs 8kg MAX size into basket and lower turkey into empty pot Fill pot with water until the butt of the turkey is covered There STEP 2 Insure that turkey is completely thawed and free of excess water and ice Inject turkey with a Failure to follow these instructions could result in fire explosion or burn hazard which could cause Turn the burner off before placing the turkey into oil Wearing cooking gloves and being sure to stay property damage personal injury or death away from hot steam lower the turkey into the oil very slowly and cover with lid Re light the burner Using the thermometer keep the oil temperature at 350 F 177 C Cook turkey for 3 minutes per pound A and then add 5 minutes to total cooking time Turkey may float before cooking time is complete Continue AA For Your Safety Gas Cylinder Storage and Appliance Check e Cylinders must be stored outdoors out of reach of children and must not be stored in a building garage or any other enclosed area Example Cooking a 16 5 lb 7 48kq turkey Thawing a Turke
15. er Nut Phillips Flange Screw Qty 1 Qty 9 C M6 Hex Flange Nut Qty 9 STEP 1 Burner Assembly Remove nut B from bottom of burner Place burner onto burner mount bar with burner bolt sticking down through hole in center of burner mount bar STEP 2 Mounting Hose amp Regulator to the Burner NOTE Do not over tighten Threads should line up do not damage threads by forcing hose into burner Place air shutter 5 onto burner venturi as shown Slide small end of spring 6 onto end of hose Thread end of hose into burner turn clockwise to tighten by hand STEP 3 Mounting Legs NOTE Do not tighten hardware Place leg 2 inside windshield Attach leg to windshield using screw A and nut C as shown Repeat with other legs Secure lower ring 3 to each leg using screw A and nut C Tighten all hardware at this time Before each use check all screws and nuts to be sure that they are tight and secure COOKWARE PARTS LIST Our 1 Asked Question When the cast iron burner burns yellow or not at all what should I do ITEM NO QUANTITY DESCRIPTION FITS MODELS a ee ee ALL MODELS If your burner does not burn blows out burns yellow or there s a flame inside the venturi you need to 2 1 30QtPot 20020107 20020209 20020407 o 3 1 12 Thermometer w Clip ALL MODELS check the burner venturi for any obstructions Dirt dobbers spiders and other insects will build a nest o 4 tf Basket S 20020109 20
16. er than 400 F 200 C One gallon of oil can reach 350 F 175 C in 7 to 10 minutes Use thermometer to check temperature or if oil begins to smoke IMMEDIATELY turn burner OFF When in use do not leave fryer unattended Oil will heat up quickly and ignite at 550 F 287 C to 700 F 371 C Failure to completely thaw and dry foods may cause oil or grease to overflow When frying with oil or grease all food products MUST be completely thawed and towel dried to remove excess water If ice is present on food this means the thawing process is not complete and may cause a boil over when placed into HOT oil causing a fire Do not leave oil grease unattended while in use 19 WARNING e Always perform soapy water test every time you use this appliance e Avoid bumping or impact to the appliance to prevent spillage or splashing of hot liquid e Always disconnect gas cylinder from appliance when not in use e Keep hands hair and face away from burner flame Do not lean over the fryer stand when lighting burner This appliance has an open flame Be careful of loose hair and clothing during operation They could catch fire e Never attach a gas cylinder move or alter fittings when fryer is hot or in use e Do not attempt to disconnect any gas fitting while fryer is in operation e Never use a gas cylinder if it shows signs of dents gouges bulges fire damage erosion leakage excessive rust or other forms of visible external dam
17. food products MUST be completely thawed and towel dried to remove excess water If ice is present on the food it means the thawing process is not complete and may cause a boil over when placed into HOT oil causing a fire e Never overfill the cooking pot with oil grease or water Follow instructions in this manual for establishing proper oil grease or water levels e If oil temperature exceeds 400 F 200 C or if oil begins to smoke immediately turn the burner or gas supply OFF and wait for the temperature to decrease to less than 350 F 175 C before relighting burner If there is a lid cover do not remove the lid e When cooking with oil grease the thermometer provided must be used Follow instructions in this manual for proper installation and use of the thermometer e This is an ATTENDED appliance DO NOT leave appliance unattended while heating oil grease or water cooking food or after it s use The appliance remains at scalding temperatures long after cooking has ended Allow to cool below 115 F 45 C before cleaning and storing e Use caution when placing food in cooking vessel while appliance is in operation e When cooking with oil grease have a BC or ABC type fire extinguisher readily accessible e In the event of rain snow hail sleet or other form of precipitation while cooking with oil cover the cooking vessel amp Immediately turn off the burner and gas supply DO NOT MOVE turkey fryer stand or pot If a grease or oi
18. ing used must be constructed and marked in accordance with the specifications product x for LP gas cylinders of the U S Department of Transportation DOT CFR 49 or the National Standards y N DANGER of Canada CAN CSA B339 Cylinders Soheres and Tubes for the Transportation of Dangerous Goods IF THE INFORMATION IN ITEMS 1 6 ABOVE IS NOT FOLLOWED EXACTLY OIL OVERFLOW MAY OCCUR RESULTING IN DEATH SERIOUS INJURY OR PROPERTY DAMAGE FOR YOUR SAFETY FOLLOW THESE STEPS ON HOW TO PROPERLY DEEP FRY A TURKEY DANGER Gas Cylinder Storage Placement and Filling e Do not store a spare LP gas cylinder under or near appliance e Never fill the cylinder beyond 80 percent full Over filled cylinders can release gas The gas cylinder safety relief valve may overheat allowing gas to release causing an intense fire with risk of death or must be 3 in 8cm between this water level amp the top of the pot Remove the turkey from the pot allowing serious injury all water to drain from the turkey Once turkey has been removed mark the waterline Empty the water e If you smell hear or see gas escaping immediately get away from gas cylinder and call the fire from the pot and fill with oil up to the marked line department A fire causing death or serious injury may occur e Place a dust cap on cylinder valve outlet whenever the cylinder is not in use Only install dust cap on cylinder valve outlet that is provided with the cylinder Other caps or plugs may
19. key fryer stand Use only a 20lb 9kg cylinder with a protective collar on the cylinder SL Wind Flow Overhead Construction lt lt 10 ft 3m Never allow hose to touch any part 12 25 of the appliance while in operation Sot aotb 9kg Cylinder with Collar 1775 45cm approx SSS poe _ fo if 3m HOT WINGS 1 gallon vegetable oil 24 chicken wings 1 small bottle of hot sauce your choice 1 2 teaspoon of salt 1 4 teaspoon of pepper 1 4 cup butter or margarine melted 1 teaspoon white vinegar Pinch of garlic salt Celery sticks Optional Side Dishes Blue cheese dressing Thaw wings if frozen and place into basket Pour 1 gallon of oil into a 10 1 2 quart pot and bring temperature to 350 F 177 C Turn off burner Wearing protective gloves slowly place basket of wings into oil and re light burner Cook for 8 to 12 minutes Turn off burner Remove and drain wings pour into bowl Mix hot sauce with remaining ingredients Pour over wings mix well and serve LOW COUNTRY BOIL 1 Ib shrimp 1 Ib craw fish 1 Ib smoked sausage 8 pieces of short ear corn 2 bags of crab boil mix 2 lbs of whole new potatoes Use a 30qt pot and bailing basket Add 2 3 gallons and 2 bags of crab boil mix to the pot and bring water to a boil Allow water to boil for 15 minutes and add sausage cut Sausage in 1 4 inch thick slices After 3 minutes add potatoes 3
20. l fire occurs In the event of an oil grease fire do not attempt to extinguish with water Immediately call the Fire Department A Type BC or ABC dry chemical fire extinguisher may in some cases contain the fire lf a fire occurs inside the pot follow these steps 1 Turn off gas supply 2 Wearing a protective glove cover the pot with a lid If a fire occurs outside the pot follow these steps 1 Call the Fire Department 2 Attempt to extinguish using fire extinguisher specified 3 Turn off gas supply if possible WARNING COMBUSTION BY PRODUCT PRODUCED WHEN USING THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OTHER REPRODUCTIVE HARM OR CANCER CALIFORNIA PROP 65 WARNING THIS PRODUCT CONTAINS CHEMICALS INCLUDING LEAD KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM WASH HANDS AFTER HANDLING WARNING e This Outdoor Gas appliance is for outdoor use only and shall not be used in a building garage tent or any other enclosed area e Never use or operate this appliance on or under any overhead roof covering car port awning overhang apartment or condominium balcony or deck e Never use in or on recreational vehicles and or boats e This appliance is not intended for or should never be used as a heater e Keep a minimum clearance of 10 ft 8m from overhead construction walls rails structure or combustible material e Keep area clear and
21. n timer to stop gas flow DURING ANY PORTION OF THE SOAPY WATER TEST IF BUBBLES CONTINUE TO APPEAR STOP DO NOT USE THE APPLIANCE AND CONTACT YOUR LOCAL PROPANE DEALER OR MASTERBUILT AT 1 800 489 1581 NOTE USE A 20 LB 9KG CYLINDER WITH A PROTECTIVE COLLAR WITH THIS APPLIANCE ONLY CYLINDERS MARKED PROPANE MUST BE USED 14 TROUBLESHOOTING GUIDE SYMPTOM CAUSE Burner will not light Not enough gas flow from propane tank POSSIBLE SOLUTION Open propane tank all the way Low gas level in propane tank or Check gas level in propane tank Blockage in burner Clean and check burner for spiders insect nests or other debris Contact Masterbuilt at 1 800 489 1581 Check burner for moisture make Sure burner is dry Faulty burner Hissing or gurgling sounds coming Water in burner through gas train from tank to burner Damaged hose Perform soapy water test to check for cracks See page 14 Check all connections in gas train for possible leaks See page 14 Batteries are dead Timer does not work Replace batteries See page 11 Did not press power or start button Follow timer instructions See page Contact Masterbuilt at 1 800 489 1581 Faulty timer Timer stopped before time was up Batteries are dead Excessively yellow and irregular Blockage in burner flame Replace batteries See page 11 Clean and check burner for spiders insect nests and other debris O Air damper not adjus
22. njury and property damage 22 LIMITED WARRANTY INFORMATION Masterbuilt warrants its products to be free from defects in material and workmanship under proper assembly normal use and recommended care for 90 days from the date of original retail purchase Masterbuilt warranty does not cover paint finish as it may burn off during normal use Masterbuilt warranty does not cover rust of the unit Masterbuilt requires reasonable proof of purchase for warranty claims and suggests that you keep your receipt Upon the expiration of such warranty all such liability shall terminate Within the stated warranty period Masterbuilt at its discretion shall repair or replace defective components free of charge with owner being responsible for shipping Should Masterbuilt require return of component s in question for inspection Masterbuilt will be responsible for shipping charges to return requested item This warranty excludes property damage sustained due to misuse abuse accident damage arising out of transportation or damage incurred by commercial use of this product This expressed warranty is the sole warranty given by Masterbuilt and is in lieu of all other warranties expressed or implied including implied warranty merchantability or fitness for a particular purpose Neither Masterbuilt nor the retail establishment selling this product has authority to make any warranties or to promise remedies in addition to or inconsistent with tho
23. on the case and battery to insure proper installation 4 Replace the battery cover 5 For battery removal and replacement repeat this procedure A CAUTION M Keep batteries away from small children If battery is swallowed consult a physician immediately Be sure to insert batteries correctly Improper installation may result in leaks and or possible explosion Do not dispose of batteries in fire 11 SAFE STORAGE amp MAINTENANCE e Before each use of the appliance check and clean the burner venturi tubes for insects and insect nests A clogged tube can lead to a fire inside or behind the burner or beneath the appliance e Check the regulator hose and burner parts air shutter and venturi section carefully before and after each use for any sign of wear e ALWAYS turn gas OFF at the gas cylinder valve prior to inspecting parts e DO NOT obstruct flow of combustion and ventilation Keep the ventilation opening s of the cylinder enclosure clear of debris The cylinder supply system must be arranged for vapor withdrawal Keep the appliance area clear and free from combustible materials gasoline and other flammable vapors and liquids e Coat fryer stand with cooking oil after unit has cooled to prevent rust e ALWAYS allow your appliance to cool completely before handling e When appliance is not in use gas must be turned off at the supply cylinder e ALWAYS disconnect gas cylinder after using appliance e Clean appliance
24. se stated above Masterbuilt s maximum liability in any event shall not exceed the purchase price of the product paid by the original consumer purchaser Some states do not allow the exclusion or limitation of incidental or consequential damages In such a case the above limitations or exclusions may not be applicable California residents only Not withstanding this limitation of warranty the following specific restrictions apply if service repair or replacement of the product is not commercially practical the retailer selling the product or Masterbuilt will refund the purchase price paid for the product less the amount directly attributable to use by the original buyer prior to the discovery of the nonconformity Owner may take the product to the retail establishment selling this product in order to obtain performance under warranty This expressed warranty gives you specific legal rights and you may also have other rights which vary from state to state COMPLETE amp RETURN TO ATTN WARRANTY REGISTRATION Masterbuilt Outdoor Products 1 Masterbuilt Court Columbus GA 31907 COMPLETE RETURNTO O oOo O Name Address City State Province Postal Code Phone Number E Mail Address Model Number Serial Number Purchase Date Place of Purchase 21 WARNING Cooking with Oil or Grease e Failure to completely thaw and dry foods may cause oil or grease to overflow When frying with oil or grease all
25. ted correctly Adjust air shutter to the burner until the burner flame is as blue as possible See page 9 Flame has gone out Low gas level in propane tank or Check gas level in propane tank Check wind direction and set cooker away from windy areas See page 3 Too much wind Blockage in burner Clean and check burner for spiders insect nests and other debris Check burner for moisture make sure burner is dry Water in burner Contact Masterbuilt at 1 800 489 1581 Faulty burner of Q D gt Q gt N U N D D D D S D 3 3 O O F r lt lt 13 BURNER LIGHTING INSTRUCTIONS 1 Check the regulator to be certain it is in the OFF position before connecting to the gas cylinder Perform soapy water test before each use 2 Open tank cylinder valve LOW BATTERY GAS FLOW 3 To start timer operation push POWER button both lights will blink once Basse Batterie Flujo el gas Batteria Baja Ecoulement de gaz POWER ENERGIA PUISSANCE 4 Press START button green light will remain on allowing 15 minutes of gas flow oOZNJINWNO9 5 Turn regulator on 6 Place a lit match to the burner from under the wind shield as shown below 7 Slowly turn regulator control knob clockwise until the burner lights e imer will run 15 minutes before shutting gas flow off eAt 5 minutes remaining gas flow light will blink slowly At 2 minutes remaining gas flow light will blink quickly
26. with cleaning agents e ALWAYS cover and store appliance in a protected area e Cylinders must be stored outdoors out of the reach of children and must not be stored in a building garage or any other enclosed area e Always store gas cylinder upright and in areas where temperatures wont exceed 125 F 51 C and Do Not store a spare cylinder on or near fryer stand or place connected gas cylinder under fryer stand Always keep gas cylinder 20 inches 50cm away from fryer stand e Indoor storage of appliance is permissible only if the cylinder is disconnected and removed e If any rusting occurs use steel wool to clean or buff the affected area e The exterior of your appliance may be touched up by using a high temperature resistant paint 12
27. y in Cold Water cooking turkey for the total amount of time calculated When cooking is complete turn burner OFF and remove food slowly e Before each use check all nuts and bolts to be sure that they are tight and secure Snes ie Thawing Times l 49 5 minutes 5 54 5 8lb 3 6kg to 12lb 5 4kg 4 to 6 hours e Before each use inspect gas hose for any signs of damage Total cooking time 54 5 minutes 12lb 5 4kg to 16lb 7 3kg 6 to 8 hours Before each use preform soapy water test dy ee alc ae oben a remove 16lb 7 3kg to 18lb 8 2kg 8 to 10 hours Turkeys thawed by the cold water side of pot This is a safe and easy way method should be cooked immediately to allow turkey to drain and cool at the because conditions were not 5 same time temperature controlled 18 Using Pot with Drain Valve Units are sold with and without drain valves 1 Valve must be in the OFF position before adding oil or water 2 Secure valve cap onto drain valve 3 Oil or water must be below 100 F 37 C before draining oo CAUTION Do not drain oil or water until the temperature of the liquid is below 100 F 37 C Hot water or oil can cause serious burns and injury Using the Pot with the Drain Hook Basket Do not overfill pot with oil or water A fill line is marked on the larger frying and boiling pots Smaller fry pans may not be marked 1 Place seasoned food into basket 2 Slowly lower basket into oil or water using lifting
Download Pdf Manuals
Related Search