Lightolier EG1-5 User's Manual
Contents
1. 121 92cm gt 4 121 92cm Run 5 152 40cm OA je 96 243 84em 8 243 84cm Run 12 365 76cm Run 96 243 84cm 9 274 32cm OA 48 121 92cm 13 396 24cm OA je 96 243 84cm w t 96 243 84cm 4 121 92cm Run 8 243 84cm Run 12 365 76cm Run 16 487 68cm Run 20 609 60cm Run 24 731 52cm Run 16 487 68cm Run 48 121 92cm gt lt 96 243 84cm r T T 17 518 16cm 0A 96 243 84cm Lighting Systems EG1 5 Energos 2 Light T5 per 4 121 92cm Nominal Louver 4 121 92cm Module 1 20 609 60cm Run 21 640 08cm OA 96 243 84cm gt 96 243 84cm 8 243 84cm Module wW NN 96 243 84cm gt End Set 1 1 1 1 1 1 24 731 52cm Run 25 762 00cm OA Suspension and End Set Ordering Illustrations Power Feeds Consult Lamp and Ballast System data to determine input watt requirements for ballast used on project to determine loading for each run Multiply the total num ber of ballasts by the input wattage per ballast and to determine ampacity divide the total watts by the system voltage 10 Amps for 3 wire end sets 7 Amps for 4 wire and 5 wire end sets maximum Power Feed End Set White 3 Wire Cord White 4 Wire Cord White 5 Wire2. e 635 Lumens e 1100 Lumens e 1375 Lumens Emergency battery packs can be used for emergency egress lighting since all listed packs operate for a minimum of 90 minutes or can be used as momentary lighting for emergency circuit power transitions Smaller packs are recommended for this purpose Dimming T8 and T5HO lamps are dimmed with two wire ballasts T8 lamps can be dimmed down to 5 and T5HO lamps can be dimmed down to 1 T5 lamps require 5 wire dimming ballasts and can be dimmed down to 1 A 5 wire power feed will be required for T5 non HO dimming Factory installed ballast disconnect allows the ballast to be disconnected from and reconnected to incoming power under load without turning the entire circuit off Labels Included UL cUL and IBEW Lightolier is a Philips group brand Features 1 Housing 18 gauge steel 6 15 24cm cast aluminum end caps No exposed fasteners or hardware 2 Lamping 2 T5 fluorescent lamps per 4 121 92cm section Lamps by Lightolier as an option see ordering information 3 Reflector Precision die formed premium anti iridescent highly reflective alu minum 4 Louver Parabolic louver low iridescent semi specular anodized aluminum 25 degree shielding lengthwise Blades are spaced 2 3 5 84cm 0 C with a radius that matches the housing 1 2 54cm tall louver attaches to housing 5 Optional Slotted Top Reflector Precision die formed anti iridescent highly reflective al
3. www lightolier com 2008 Philips Group C0808 Lightolier is a Philips group brand PHILIPS LIGHTOLIER Ballast THD Lamp Rated Wattage Lamp Rated Output Lamp Color Kelvin IES Output Lumens Lighting Systems EG1 5 Energos 2 Light T5 per 4 121 92cm Nominal Louver System Input Watts System Efficiency lum watt System Lamp Life Hours Start Type lt 10 A SN oS AA A Bae A A A o o Bere 0 28 28 28 54 54 54 28 28 28 54 54 54 Page 5 of 5 Ballast and Lamp Ordering Combinations Lamp Type Ballast Desgn T8 or T5 Factor BF FM 15 1 FN 15 1 FO I5 1 GP HO 1 GQ HO 1 GR HO 1 IM T5 DIM 0 01 IN T5 DIM 0 01 10 T5 DIM 0 01 JP T5HO DIM 0 03 JO T5HO DIM 0 03 JR T5HO DIM 0 03 Notes 25 C Rating All data is per 1 lamp on a two amp system at 277 VAC Data is based When ordering no lamps provided by Lightolier use Lamp code Z Do not alter lumen values or ballast factor light losses when completi y been adjusted The lumen value for the lamp withi the IES Output value shown on this table Files have alread Lightolier is a Philips group brand 2600 2600 2600 4450 4450 4450 2600 2600 2600 4450 4450 4450 on Osram Sylvania Specifications 830 835 84 830 835 84 830 835 84 830 835 84 2600 2600 2600 4450 4450 4450 2600 26 2600 26 2600 26 4450 134 4450 13
4. 4 4450 134 ng calculations using Energos IES files n a Lighting Design program will be 31 0 31 0 31 0 58 5 58 5 58 5 33 5 8 33 5 8 33 5 8 63 12 5 63 12 5 63 12 5 83 9 83 9 83 9 76 1 76 1 76 1 71 6 71 6 7716 70 6 70 6 70 6 20000 20000 20000 20000 20000 20000 SP rrr Program Program Program Program Program Program Program Program Program Program Program Program Job information tee 631 Airport Road Fall River MA 02720 e 508 679 8131 e Fax 508 674 4710 We reserve the right to change details of design materials and finish www lightolier com 2008 Philips Group C0808 PHILIPS
5. 6 1066 1066 1066 Cat No EG12GQP 25 C Rating Performance Two Lamp Fixture With Optional Slotted Top Reflector Candlepower Curve Candlepower Coefficients Of Utilization 08 oy Zone 0 22 45 67 90 Effective Ceiling Cavity Reflectance SL ria 06 Degree 80 70 50 hi amp Candelas Wall Reflectance x 80 Ha a ya Jo Vo 50 30 10 50 30 10 50 30 10 75 382 360 375 354 356 Od 0 e A a wl A 65 a il 8 a oe 1 72 69 67 69 67 65 64 62 61 55 332 347 339 323 328 2 BAe 45 297 304 290 287 279 3 56 51 47 54 50 46 50 47 44 35 249 265 241 254 267 4 50 44 40 48 43 39 45 41 37 25 92 03 eee 56 S 5 45 39 35 43 38 34 40 36 32 15 146 137 176 163 152 5 En 05 79 97 66 32 27 7 36 30 26 35 30 26 33 28 25 95 21 17 30 42 45 S 2 23 32 2 ANA 2 2 90 1 6 7 8 6 9 30 25 2129 24 20 27 23 20 85 1 1 3 5 6 1023 22 Da 22 ie 2 2 e 79 9 11 8 11 8 20 Floor Cavity Reflectance 65 179 299 408 509 523 etal at 55 711 997 1147 1392 1485 Distuigution 45 1003 1341 1471 1605 1660 Zone Lumens Lamp Luminaire 35 1208 1534 1706 1808 1880 0 90 3336 58 82 ReportNo EG1 5D GO ies 25 1474 1618 1975 2018 2031 90 180 728 13 18 Lamps 2 FP54 835 HO 15 1636 1629 1695 1931 2051 0 180 4064 70 100 lariens 4450 5 1677 1713 1676 1664 1721 Efficiency 70 1 M ies e a E leks Cat No EG15GQP 25 C Rating Job information tee 631 Airport Road Fall River MA 02720 e 508 679 8131 e Fax 508 674 4710 We reserve the right to change details of design materials and finish
6. Cord Aluminum 3 Wire Cord Aluminum 4 Wire Cord Aluminum 5 Wire Cord Ceiling Grid Kit CGK Control Cable Joiner mem Consult appropriate ECS Energos Control Systems specification sheet for ordering product utilizing occupancy controls ECS specification sheet numbers directly cor relate to standard Energos specification sheet numbers Cable Cord Assembly EG1EC36W Single Cable amp Power Cord EG1EC36W4 Single Cable amp 4 Wire Power Cord EG1EC36W5 Single Cable amp 5 Wire Power Cord EG1EC36A EG1EC36A4 EG1EC36A5 EGCC36 EGCC36X4 EGCC36X5 Because most ceilings are white all canopies ship as white standard and slot T For mounting fixtures direct one CGK per non power suspension point and one CGKP per powered suspensi unless specifically ordered otherwise Both CGK and CGKP ship with two types of clips y to the T grid order on point The CGKP will include a special canopy with flex coupler grid clips and additi onal clips to mount the junction box to the top of the grid nearby J Box Lightolier is a Philips group brand and flex conduit provided by others Ceiling Grid Kit Power CGKP Cable Assembly Single Cable EGC36 Job information tee 631 Airport Road Fall River MA 02720 e 508 679 8131 e Fax 508 674 4710 We reserve the right to change details of design materials and finish www lightolier com 2008 Philips Group C0808 PHILIPS L
7. IGHTOLIEI Lighting Systems EG1 5 Page 4 of 5 Energos 2 Light T5 per 4 121 92cm Nominal Louver Performance Two Lamp Fixture With Open Top Candlepower Curve Candlepower Coefficients Of Utilization aca Zone 0 22 45 67 90 Effective Ceiling Cavity Reflectance 9 Degree 80 70 50 1 Candelas Wall Reflectance 80 1084 1084 1084 1084 1084 50 30 10 50 30 10 50 30 10 75 1082 1087 1089 1090 1094 0 98 98 98 88 88 88 69 69 69 65 1042 1064 1095 1122 1137 1 86 83 80 77 75 72 62 60 58 55 964 1009 1078 1140 1179 2 76 70 66 68 64 60 55 52 49 45 848 929 1072 1229 130 ce 3 67 60 55 60 55 5149 45 42 35 704 821 088 315 1412 A 4 59 52 47 54 48 43 48 39 36 25 532 718 094 412 1554 S 5 53 46 40 48 42 37 39 34 31 15 348 621 115 496 1655 aE 6 47 40 35 43 37 32 35 30 27 05 i Bet ike E 7 42 35 30 39 32 28 31 27 23 95 34 331 382 473 4384 se Si AN 2 2 a3 2h Zi 90 0 0 0 0 0 9 35 28 23 32 26 22 26 22 18 8 85 0 2 2 2 2 O82 25 Ae 2 ie at ie ie 1285 7 JIS 75 3 4 4 5 4 20 Floor Cavity Reflectance wg 65 54 70 56 97 16 a ETR 55 247 47 648 7733 733 Distribution uti 599 T22 iDO 73 905 Zone Lumens Lamp Luminaire 35 756 817 1061 104 955 0 50 2964 30 31 Report No EG1 5N GQ ies Z5 i BBD i923 aa 1116 1202 90 180 6466 65 69 Lamps 2 FP54 835 HO ee Ee eee 0 180 9430 94 100 Limeni 4450 5 1060 1061 1064 1061 1060 Efficiency 943 0 1066 106
8. LIGHTOLIER Page 1 of 5 Lighting Systems EG1 5 Energos 2 Light T5 per 4 121 92cm Nominal Louver a y 1 a I O IZU 11 27 94cm a 4 Feature Specifications Electrical Connections Wiring is via 18 gauge wire All electrical connections for standard configurations are plug and play via 6 wire cannon plug connections Connections are seated in end castings of fixtures allowing for simultaneous mechanical elec trical coupling Connectors are male female therefore modules must be installed male to female starting from the power feed end set Male Female All static ballasts have the following features e Electronic e High Power Factor e Class A sound rating e Metal can Emergency Battery Pack Emergency Battery packs are designed to operate when normal building power is interrupted The battery packs operate for a mini mum of 90 minutes without any power via a rechargeable battery source The pack does not utilize the standard static ballast for any of its operation since the pack carries its own pseudo ballast For this reason Lightolier does not recommend remote mounting EM Packs because all of the socket wiring would need to carry throughout the powerfeed end set The EM batteries even in their largest most expensive form operate the fluorescent lamps at only half the lamp rated output Emergency battery packs are available in the following outputs e 450 Lumens Standard
9. VAC A Aluminum 8 8ft 96 243 84cm 2 277VAC W White Wiring Options Blank Leave blank if ordering standard fixture 4 4 through wires 5 5 through wires 6 6 through wires Feature Options D Dual Switching AKA A B switching 2 Light Option 3 Light Option T Tandem Switching also available in 1 lamp configuration A B Both Dual Switch and Tandem Switch fixtures ship with a 4th wire Be sure to order the appropriate quantity of wires in the power feed Lightolier is a Philips group brand Feature Options continued E Emergency Battery Pack E Battery packs provide 90 minutes of opera tion Available lamp outputs 450 Lumens standard Optional 635 1100 and 1375 Lumens Standard Emergency wiring is to have Battery Pack operating a single lamp All EM fixtures are wired as switched and include 4th through wire for the wall switch see diagrams All fixtures and power feeds in that run should be ordered to include a dedicated 4th through wire to carry the hot power all the way through the run to the EM pack Wall Switch Switched Unswitched Job information tee 631 Airport Road Fall River MA 02720 e 508 679 8131 Fax 508 674 4710 We reserve the right to change details of design materials and finish www lightolier com 2008 Philips Group C0808 PHILIPS LIGHTOLIER Page 3 of 5 Fixture Lengths amp Mounting Locations j 48
10. g Information Family Series Lamping amp Ballast Lamp Shielding Length Voltage Finish Options Distribution Blank EG 1 P 2 2 Lamps See Ballast See Lamp P Parabolic 4 4 121 92cm 1 120V A Aluminum 4 4 through wires 5 2 Lamps Chart Below Chart Below Louver 8 8 243 84cm 2 277V W White 5 5 through wires Slotted Top 6 6 through wires Reflector D Dual Switch T Tandem Switch E Emergency Pack When ordering no lamps provided by Lightolier use Lamp code Z Module Ordering Specifications Lamping and Distribution 2 2 Lamp 5 2 Lamp Slotted Top Reflector Ballast Specifications Lamping Specifications Start 5 Rated Output Code Lamp Type Ballast Factor Type THD Code Lamp Type Wattage Lumens Color K F 15 1 00 Program lt 10 M 15 28 2600 830 G T5HO 1 00 Program lt 10 N 5 28 2600 835 Dim T5 1 00 01 Program lt 10 0 15 28 2600 841 J Dim T5HO 1 00 03 Program lt 10 P T5 54 4450 830 Q T5 54 4450 835 Dimming Advance Mark 10 standard no additional wires required for T8 and R T5 54 4450 841 T5HO fixtures 5 wire dimming required for T5 non HO fixtures Optional dimming 25 c Rating systems Lutron ECO 10 and Hi Lume by others require 4 wire modules and end sets Mark 7 ULT DALI and Lightolier HDF require 5 wire modules and end sets Energos can accept ballasts not to exceed 1 7 4 32cm wide by 1 2 3 05cm high Shielding P Parabolic Louver Length Voltage Finish 4 4ft 48 121 92cm 1 120
11. uminum Mountings Cable suspension is on 48 121 92cm and 96 243 84cm centers and consists of a 4 1 2 11 43cm diameter canopy finished white enamel A 1 16 0 16cm diam eter stainless steel aircraft cable accomplishes suspension and is adjustable from 12 30 48cm to 36 91 44cm Power feed is 18 gauge SJT silver braided cord with a clear jacket For special circuiting consult factory Finish Powder coated baked enamel white or aluminum as specified Custom colors available consult factory Ordering Instructions Individual Fixtures 1 Order number of MODULES required 2 Order one POWER FEED END SET per MODULE Continuous Rows Determine run length Order the appropriate number of MODULES for the complete run Order one POWER FEED END SET for each run Order one CABLE ASSEMBLY per MODULE minus one per run For runs that exceed conductor ampacity ratings order the appropriate number of SINGLE CABLE amp CORD SETS onrFPwoNnr Job Information Job Name Cat No Lamp s Notes 631 Airport Road Fall River MA 02720 508 679 8131 e Fax 508 674 4710 We reserve the right to change details of design materials and finish www lightolier com 2008 Philips Group C0808 PHILIPS LIGHTOLIER Lighting Systems EG1 5 Page 2 of 5 Energos 2 Light T5 per 4 121 92cm Nominal Louver Module Orderin
Download Pdf Manuals
Related Search