Lanier PSW-6 User's Manual
Contents
1. Lanier Worldwide Inc 2300 Parklake Dr N E Atlanta GA 30345 2979 Emergency Telephone 800 526 4371 MATERIAL SAFETY DATA SHEET Section 1 Chemical Product and Company Information Identity Toner for 9060 POD MSDS No CP 312 Product ID 117 0237 Issued 01 05 98 Supersedes none Synonyms Date 01 26 98 amp Common Toner Black Tonerer for Lanier Names 9060 POD Prepared by Lanier QA EH amp S Department Uses 9060 POD European Lanier Worldwide WSM Europe l Contact Walter Fricke Chemical Im Taubental D 41468 Neuss Formula Mixture Germany 49 2131 387 177 Section 2 Composition Information on Ingredients PERCENT CAS No EXPOSURE LIMITS SOURCE Carbon black 6 8 1333 86 4 3 5mg m 3 5mg m OSHA PEL ACGIH TLV Polyester resin 75214 60 7 not listed n a Polyester resin lt 94 TSCA Confidential Trade Secret No n a 80100252 5001 P Wax 9003 07 0 not listed n a Pigment 31714 55 3 not listed n a PEL as the product 15mg m total dust 5mg m respirable dust TLV as the product 10mg m total dust 5mg m respirable dust Section 3 Hazards Identification Hazard Rating FIRE 1 HEALTH 1 REACTIVITY 0 SPECIAL none Health Hazards Acute Chronic Immediate and Potential Minimum irritation to respiratory tract may occur as with exposure to any non toxic dust May cause gasping if inhaled Inhalation should be avoided May cause temporary eye discomfort Health Hazards of Long Term exposure Chronic A manufacture2. ation on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions
3. cial protective equipment for fire fighters wear self contained breathing apparatus UEL n a LEL 34 5 m Section 6 Accidental Release Measures Sweep up or clean up with an approved toner vacuum Section 7 Handling and Storage Special Handling Cleanse skin after contact before breaks or meals and end of work day Avoid inhalation Special Storage Keep out of reach of children Store in a cool dry place Section 8 Exposure Control and Personal Protection Information Respiratory Protection none required under normal use Hand Protection none required under normal use Eye Protection none required under normal use Skin Protection none required under normal use Section 9 Physical and Chemical Properties CHARACTERISTICS Appearance Black Melting point n a Form Fine powder Vapor pressure n a Odor Practically odorless Vapor density n a Solubility in Water Insoluble Evaporation rate n a Specific gravity 1 2 Boiling point n a Section 10 Stability and Reactivity Conditions to avoid Strong acid or alkaline Materials to avoid none Stability Stable Hazardous decomposition products CO phenol derivative at high temps Section 11 Toxicological Information Acute oral toxicity rat LDLo 5 0 g kg Ames Test result Negative Carcinogenicity In 1996 the IARC reevaluated carbon black as a GROUP 2B carcinogen possible human carcinogen This evaluation is given to carbon black for which there is inadequate human evidenc
4. e but sufficient animal evidence The latter is based upon the development of lung tumors in rats receiving chronic inhalation exposures to free carbon black at a level that induce particle overload of the lungs Studies performed in mice have not demonstrated an association between carbon black and lung tumors Moreover a two year cancer bioassay using a typical toner preparation containing carbon black demonstrated no association between toner and tumor development in rats Section 12 Environmental Ecological Information None Section 13 Disposal Consideration Waste material should be disposed of in accordance with all federal state and local environmental regulations Do not incinerate Section 14 Transportation Information None Section 15 Regulatory Information None Section 16 Miscellaneous Information On the basis of the data available to us this toner is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals Notice Judgments as to the suitability of information contained herein for purchaser s purposes are the purchaser s responsibility Therefore although reasonable care has been taken in the preparation of such information Lanier Worldwide Inc extends no warranties makes no representations and assumes no responsibility as to the accuracy or suitability of such information for application to purchaser s intended purposes or for consequences of its use Inform
5. r sponsored chronic inhalation study in rats using a special test toner revealed there were no lung changes at all in the lowest exposure level 1mg m the most relevant level to AE human exposures A very slight degree of fibrosis was noted in 25 of the animals at the middle exposure level 4mg m while a slight degree of fibrosis was observed at the highest exposure level 16mg m in all animals These findings are attributed to Lung Overloading a generic response to excessive amount of any dust retained in the lungs for a prolonged interval The special test toner was ten times more respirable than commercially available toner to comply with EPA testing protocol and would not function properly in Xerographic equipment Section 4 First Aid Measures Inhalation Remove to fresh air if effects occur Consult Eye Contact In case of contact immediately flush eyes with local medical personnel water for 5 minutes Skin Contact Wash with soap and water Ingestion Dilute stomach contents with water Call a physician Section 5 Fire Fighting Measures Suitable extinguishing media COs dry chemical foam or water Extinguishing media which may not be used for safety reasons none 1 MATERIAL SAFETY DATA SHEET Page 2 of CP 312 Flash point gt 150 C O C This material will burn in case of fire The decomposition products are CO and other decomposition products in case of incomplete combustion Avoid inhalation of smoke Spe
Download Pdf Manuals
Related Search