Lanier 5485 User's Manual
Contents
1. LANIER Lanier Worldwide Inc 2300 Parklake Dr N E Atlanta GA 30345 2979 Emergency Telephone 800 526 4371 MATERIAL SAFETY DATA SHEET Section 1 Chemical Product and Company Information Identity 5485 Toner MSDS No CP 339 Product ID 480 0034 Issued 04 20 2000 Supersedes None Synonyms Date 04 20 2000 amp Common Prepared by EH amp S Department 770 496 9500 Names Toner for Lanier 5485 Approved by Larry Choskey Manager CEH amp S European Walter Fricke Manager Safety amp Uses Lanier 5485 Contact Environment Lanier Worldwide Inc Chemical Im Taubental D 41468 Neuss Formula Mixture Germany 49 2131 387 177 Section 2 Composition Information on Ingredients PERCENT CAS No EXPOSURE LIMITS SOURCE Polyester resin 60 80 Confidential 8mg m ACGIH TWA Styrene acrylic polymer 10 30 25767 47 9 Not listed N a Carbon black 7 15 1333 86 4 3 5mg m 3 5mg m OSHA PEL ACGIH TWA Wax lt 5 8015 86 9 Not listed N a Dye lt 1 31714 55 3 Not listed N a PEL as the product 15mg n total dust 5mg m respirable dust TLV as the product 10mg m total dust 5mg m respirable dust Section 3 Hazards Identification HMIS Rating FLAMMABILITY 1 HEALTH 1 REACTIVITY 0 SPECIAL none Health Hazards Acute Chronic Immediate and Potential Minimum irritation to respiratory tract may occur as with exposure to any non toxic dust May cause gasping if inhaled Inhalation should be avoided May cause temporary e2. es makes no representations and assumes no responsibility as to the accuracy or suitability of such information for application to user s intended purposes or for Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals MATERIAL SAFETY DATA SHEET Page 3 of CP 339 consequences of its use All materials may present unknown hazards and should be used with caution Although certain hazards are described herein we do not guarantee that these are the only hazards that exist Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions On the basis of the data available to us this product is not a dangerous substance One should however observe the usual precautionary measures for dealing with chemicals
3. rance Black Melting point n a Form Powder Vapor pressure n a Odor Slight plastic odor Vapor density n a Solubility in Water Insoluble Evaporation rate n a Specific gravity N a Boiling point n a Bulk Density 1 2 g cn Section 10 Stability and Reactivity Conditions to avoid none Materials to avoid none Stability Stable Hazardous decomposition products CO and CO2 and other decomposition products when burned Section 11 Toxicological Information Ames test negative Acute oral toxicity gt 5000mg kg rat Section 12 Environmental Ecological Information Acute toxicity to fish gt 500 mg kg 96hr Section 13 Disposal Consideration Used Toner should be disposed of under conditions that meet all federal state and local environmental regulations Disposal regulations vary from locality to locality therefore consult your local Lanier office or the EPA to determine the proper method for disposal Do not incinerate loose or spilled Toner Section 14 Transportation Information None This is not a hazardous product Section 15 Regulatory Information WHMIS Legislation Canada This is not a controlled product UN No None allocated Section 16 Miscellaneous Information Judgment as to the suitability of information contained herein for user s purposes is the responsibility of the purchaser Therefore although reasonable care has been taken in the preparation of this information Lanier Worldwide Inc extends no warranti
4. several glasses of water Get medical attention Section 5 Fire Fighting Measures Suitable extinguishing media CO dry chemical foam or water Extinguishing media which may not be used for safety reasons none This material will burn in case of fire The decomposition products are CO CO and No Avoid inhalation of smoke Special protective equipment for fire fighters none UEL n a LEL n a MATERIAL SAFETY DATA SHEET Page 2 of CP 339 Section 6 Accidental Release Measures Spill leak Procedures If spilled sweep up using an approved toner vacuum with a 0 5 micron filter or smaller such as the Atrix AAA Toner Vacuum or 3M Toner Vacuum Use of a vacuum cleaner not rated for toner particles could result in a fire or personal injury Remove residue with soap and cold water Miscellaneous Keep product out of sewers and watercourses Personal protection Avoid inhalation of dust Section 7 Handling and Storage Special Handling Cleanse skin after contact before breaks or meals and end of workday Special Storage Avoid direct sunlight Keep out of reach of children Store in a cool dry place Section 8 Exposure Control and Personal Protection Information Respiratory Protection none required under normal use Hand Protection none required under normal use Eye Protection none required under normal use Skin Protection none required under normal use Section 9 Physical and Chemical Properties CHARACTERISTICS Appea
5. ye discomfort Health Hazards of Long Term exposure Chronic A manufacturer sponsored chronic inhalation study in rats using a special test toner revealed there were no lung changes at all in the lowest exposure level 1mg m the most relevant level to potential human exposures A very slight degree of fibrosis was noted in 25 of the animals at the middle exposure level 4mg m while a slight degree of fibrosis was observed at the highest exposure level 16mg m in all animals These findings are attributed to Lung Overloading a generic response to excessive amount of any dust retained n the lungs for a prolonged interval The special test toner was ten times more respirable than commercially available toner to comply with EPA testing protocol and would not function properly in Xerographic equipment Carbon Black is listed on the IARC Nbnograph and the Massachusetts Substance List The IARC has evaluated the evidence for the carcinogenicity of Carbon Black as inadequate to determine a carcinogenic risk for humans This product contains no known hazardous materials as defined by the OSHA Hazard Communication Standard 29 CFR 1910 1200 Section 4 First Aid Measures Remove to fresh air if effects occur Get medical In case of contact immediately flush eyes with Inhalation attention if needed Eye Contact water for 15 minutes Get medical attention if needed Skin Contact Wash with soap and water Ingestion Dilute stomach contents with
Download Pdf Manuals
Related Search