Honda EX3300S User's Manual
Contents
1. Know how to stop the generator quickly and understand the operation of all the controls Never permit anyone to operate the generator without proper instructions The generator is a potential source of electrical shock if misused Do not expose the generator to moisture rain or snow Do not let the generator get wet and do not operate it with wet hands Do not allow children to operate the generator Keep children and pets away from the area of operation Gasoline is extremely flammable and is explosive under certain condi tions Do not smoke or allow flames or sparks where the generator is refueled or where gasoline is stored Refuel in a well ventilated area with the engine stopped Exhaust gas contains poisonous carbon monoxide Avoid inhalation of exhaust gasses Never run the engine in a closed garage or confined area The muffler becomes very hot during operation and remains hot for a while after stopping the engine Be careful not to touch the muffler while it is hot Let the engine cool before storing the generator indoors Connections for standby power to a 5 electrical system must be made by a qualified electrician and must comply with all applicable laws and electrical codes Improper connections can allow electrical current from the generator to backfeed into the utility lines Such backfeed may electrocute utility company workers or others who con tact the lines during a power outage and when utility power is r2. Power Equipment mm Owner s Manual EX33008 45008 Dick or tee is manual to your computer ttt tt l SODA A A nl SEE HH HH generator is a potential source of electrical shock if misused Do not expose the generator to moisture rain or snow Do not let the generator get wet and do not operate it with wet hands Thank you for purchasing Honda generator This manual covers the operation and maintenance of EX3300S and EX4500S generators All information in this publication is based on the latest product information available at the time of printing The illustrations in this manual are based on the 4 5005 generator Honda Motor Co Ltd reserves the right to make changes at any time without notice and without incurring any obligation No part of this publication may be reproduced without written permission This manual should be considered a permanent part of the generator and should remain with the generator if it is resold This generator is equipped with a U S D A qualified spark arrester which requires periodic maintenance to ensure its effectiveness It is illegal in some areas to operate an engine without a Dax arrester check local laws and regulations Pay special attention to statements preceded by the following words NDANGER Indicates severe personal injury or death will result if in structions are not followed A WARNING Indicates a strong possibility of se
3. magneto Oil Capacity 1 14 1 16 US qt Fuel tank Capacity 197 5 02 US gal 2 Generator 120 240 Rated Frequency 60Hz 8 3kVA 4 5kVA Only for charging 12V automotive batteries Maximum charging output 8 3A 35 12 INSTALLATION OF OPTIONAL PARTS Remote Control Kit Installation 1 Remove the panel from the front cover 2 Disconnect the jumper coupler from the 9 coupler 3 Connect the 9 P coupler of the remote control panel to the 9 P coupler disconnected in step 2 4 Install the remote control panel with four screws JUMPER COUPLER 9 P COUPLER 9 P COUPLER REMOTE CONTROL PANEL 5 Connect the remote control cable coupler to the remote control panel coupler REMOTE CONTROL CABLE COUPLER REMOTE CONTROL PANEL COUPLER 36 STARTING WITH REMOTE CONTROL Make sure the engine switch is OFF Turn the auto throttle switch to OFF Remove the ignition switch key from the generator Turn the remote control switch to ON Flip the remote control engine switch knob up to ON Depress the starter button until the pilot lamp comes on HOokwn NOTE Turn the remote control switch to the OFF position if you wish to start the generator by using the engine switch on the generator control panel REMOTE CONTROL SWITCH REMOTE CONTROL ENGINE SWITCH PILOT LAMP STARTER BUTTON 7 To stop th
4. Connect both charging cables to the battery terminals and connect the positive cable to the generator s positive DC terminal 2 Start the generator 3 Carefully connect the negative charging cable to the generator s negative DC terminal A WARNING The battery gives off explosive gases keep sparks flames and cigaret tes away Provide adequate ventilation when charging or using batteries in an enclosed space The battery contains sulfuric acid electrolyte Contact with skin or eyes may cause severe burns Wear protective clothing and a face shield If electrolyte gets on your skin flush with water f electrolyte gets in your eyes flush with water for at least 15 minutes and call a physician immediately Electrolyte is poisonous If swallowed drink large quantities of water or milk and follow with milk of magnesia or vegetable oil and call a physician KEEP OUT OF REACH OF CHILDREN To prevent the possibility of creating a spark near the battery connect charging cables first to the battery then to the generator Disconnect cables first at the generator Before connecting charging cables to a battery that is installed in a vehi cle disconnect the vehicle s grounded battery cable Reconnect the vehicle s grounded battery cable after the charging cables are removed This procedure will prevent the possibility of a short circuit and sparks if you make accidental contact between a b
5. EA Engine oil cleaner Spark arrester Clean Fuel sediment cup Clean Valve clearance Check Readjust Fuel tank and filter Clean Check Replace I Fuel line _ if necessary Every 3 years 2 NOTE 1 Service more frequently when used in dusty areas g 2 These items should be serviced by an authorized Honda dealer unless the owner has the proper tools and is mechanically proficient See the Honda Shop Manual f 3 professional commercial use log hours of operation to determine proper maintenance intervals 20 Tool kit The tools supplied with the generator will help you to perform the owner maintenance procedures listed on page 20 Always keep this tool kit with the generator TOOL KIT a mS ey x M Ja PLUG WRENCH A N NI A wi I PLUG WRENCH HANDLE G FLAT SCREWDRIVER TOOL KIT REAR MAINTENANCE COVER TOOL BAG 21 Changing oil Drain the oil while the engine is still warm to assure rapid and complete draining 1 Open the front maintenance cover 2 Remove the drain bolt and filler cap and drain the oil Retighten the bolt securely 3 Refill with the recommended oil see page 8 and check the level 4 Close and latch the front maintenance cover OIL CAPACITY 1 17 1 16 US qt UPPER LEVEL OIL DRAIN BOLT CAUTION Used motor oil may cause skin cancer if repeatedly left in con tact with the skin f
6. Honda s Limited Warranty Occasionally you may experience light spark knock while operating under heavy loads This is no cause for concern it simply means your engine is operating efficiently Fuel tank capacity 19 5 02 US gal FUEL LEVEL GAUGE FUEL TANK CAP FUEL STRAINER AWARNING Gasoline is extremely flammable and is explosive under certain conditions Refuel in a well ventilated area with the engine stopped Do not smoke or allow flames or sparks in the area where the engine is refueled or where gasoline is stored Do not overfill the fuel tank there should be no fuel in the filler neck After refueling make sure the tank cap is closed properly and securely Be careful not to spill fuel when refueling Spilled fuel or fuel vapor may ig nite If any fuel is spilled make sure the area is dry before starting the engine l Avoid repeated or prolonged contact with skin or breathing of vapor KEEP OUT OF REACH OF CHILDREN GASOLINES CONTAINING ALCOHOL If you decide to use a gasoline containing alcohol gasohol be sure it s oc tane rating is at least as high as that recommended by Honda There are two types of gasohol one containing ethanol and the other containing methanol Do not use gasohol that contains more than 1096 ethanol Do not use gasoline containing methanol methyl or wood alcohol that does not also contain cosolvents and corrosion inhibitors for methanol Neve
7. NCE REPANDUE SUR L APPAREIL ARRETER LE MOTEUR AVANT DE REFAIRE LE PLEINE gt BINSPECCIONAR PARA COMBUSTIBLE DERRAMADO 0 ESCAPE PARAR MOTOR ANTES DE ECHAR f 2 COMPONENT IDENTIFICATION PILOT LAMP OIL ALERT LAMP AUTO THROTTLE SWITCH ENGINE SWITCH VOLTAGE SELECTOR Ac CIRCUIT BREAKER AC RECEPTACLES DC CIRCUIT PROTECTOR MUFFLER CAP FRONT MAINTENANCE COVER UPPER MAINTENANCE COVER FUEL TANK CAP AIR CLEANER REAR MAINTENANCE COVER 3 PRE OPERATION CAUTION Check the generator a level surface with the engine stopped 1 ENGINE OIL CAUTION Engine oil is a major factor affecting engine performance and service life Non detergent or 2 stroke engine oils are not recommended Use Honda 4 stroke oil or an equivalent high detergent premium quality motor oil certified to meet or exceed U S automobile manufacturers re quirements for Service Classification SG SF CC CD Motor oils classified SG SF CC CD will show this designation on the container SAE 10W 30 is recommended for general all temperature use Other viscosities shown in the chart may be used when the average temperature in your area is within the indicated range Remove the oil filler cap and wipe the dipstick with a clean rag Check the oil level by inserting the dipstick in the filler hole without screwing it in If the level is low fill to the top of the oil filler n
8. a dur ing this procedure DRAIN SCREW c Tighten the carburetor drain screw turn the engine switch to OFF and close the rear mainte nance cover d Drain the fuel sediment cup see page 26 3 Change the engine sil 4 Remove the spark plug and pour about a tablespoon of clean engine oil into the cylinder Crank the engine several revolutions to distribute the oil then reinstall the spark plug 5 Cover the generator to keep out dust 6 Once a month recharge the battery NOTE When starting the generator after adding fuel for the first time after long term storage or after running out of fuel turn the engine switch to the position then wait for 10 to 20 seconds before starting the engine 30 9 TROUBLESHOOTING When the engine will not start Is there fuel in the NO tank Refill the fuel tank YES in the engine The oil alert lamp goes on when mended oil cranking the engine YES from the spark plug spark plug to an authorized To check HONDA dealer 1 Remove the spark plug cap Be sure there is no and clean any dirt from spilled fuel around around the spark plug the spark plug Spill 2 Remove the spark plug and ed fuel may ignite install the spark plug in the I plug cap YES 3 Set the plug side electrode on the cylinder head 4 Crank the engine sparks should jump across the gap NO To check Is the f
9. attery ter minal and the vehicle s frame or body NEGATIVE DC TERMINAL BLACK POSITIVE TERMINAL RED 17 CAUTION e Be careful to connect the charging cables to the correct battery and generator terminals positive to positive and negative to negative If the charging cables are connected positive to negative it may cause serious battery or generator damage e Do not attempt to start an automobile engine with the generator still connected to the battery this may damage the generator NOTE The DC terminals may be used while the AC power is use e An overloaded DC circuit will trip the DC circuit protector green in dicator in the push button pops out If this happens wait a few minutes before pushing the circuit protector to resume operation High altitude operation At high altitude the standard carburetor air fuel mixture will be excesseve ly rich Performance will decrease and fuel consumption will increase High altitude performance can be improved by installing a smaller diameter main fuel jet in the carburetor and readjusting the pilot screw If you always operate the generator at altitudes higher than 6 000 feet above sea level have your authorized Honda Generator dealer perform these carburetor modifications Even with suitable carburetor jetting engine horsepower will decrease ap proximately 3 5 for each 1 000 foot increase in altitude The affect of altitude on horsepower will be greate
10. e engine flip the remote control engine switch to the OFF position 37 13 WARRANTY SERVICE Owner Satisfaction Your satisfaction and goodwill are important to your dealer and to us All Honda warranty details are explained in the Distributor s Limited Warranty Normally any problems concerning the product will be handled by your dealer s service department If you have a warranty problem that has not been handled to your satisfaction we suggest you take the following action Discuss your problem with a member of dealership management Often complaints can be quickly resolved at that level If the problem has already been reviewed with the Service Manager contact the owner of the dealership or the General Manager e f your problem still has not been resolved to your satisfaction contact the Power Equipment Customer Relations Department of American Honda Motor Co Inc American Honda Motor Co Inc Power Equipment Customer Relations Department Box 50 Gardena California 90247 0805 Telephone 213 604 2400 We will need the following information in order to assist you Your name address and telephone number Product model and serial number Date of purchase Dealer name and address Nature of the problem After reviewing all the facts involved you will be advised of what action be taken Please bear in mind that your problem will likely be resolved at the dealer
11. e quantities of water or milk and follow with milk of magnesia or vegetable oil and call a OF REACH OF CHILDREN CAUTION Use only distilled water in the battery Tap water will shorten the service life of the battery Filling the battery above the UPPER LEVEL line may cause the electrolyte to overflow resulting in corrosion to engine or nearby parts Immediate ly wash off any spilled electrolyte Check the battery terminals to be sure the cables are tightened and free of corrosion Remove any corrosion and coat the terminals and cable ends with grease UPPER LEVEL LOWER LEVEL 11 4 8 CAUTION When starting the generator after adding fuel for the first time after long term storage or after running out of fuel turn the engine switch to the position then wait for 10 to 20 seconds before starting the engine 1 Turn off the AC circuit breaker AC CIRCUIT BREAKER 2 Make sure the auto throttle switch is off or more time will be required for warm up AUTO THROTTLE SWITCH 12 3 Turn the engine switch to the START position and hold it there until the engine starts NOTE Do not use the electric starter for more than 5 seconds at a time If the engine fails to start release the switch and wait 10 seconds before operating the starter again When the engine starts allow the engine switch return to the ON
12. eck with the recommended oil NOTE The Oil Alert System will automatically stop the engine before the oil level falls below the safe limit However to avoid the inconvenience of an unexpected shutdown it is still advisable to visually inspect the oil level regularly l DIPSTICK 20 0 0 40 60 80 00 30 20 10 0 10 20 30 40 p UPPER LEVEL OIL FILLER CAP LOWER LEVEL 2 FUEL Check the fuel gauge and refill the tank if the fuel level is low Your engine is designed to use any gasoline that has a pump octane number 3 of 86 or higher or that has a research oc tane number of 91 or higher Gasoline pumps at service station normally display the pump octane number We recommend that you use unleaded fuel because it produces fewer engine and spark plug deposits and extends the life of exhaust system components Never use stale or contaminated gasoline or an oil gasoline mixture Avoid getting dirt dust or water in the fuel tank Use of a lower octane gasoline can cause persistent pinging or heavy spark knock a metallic rapping noise which if severe can lead to engine damage CAUTION If spark knock or occurs at a steady engine speed under normal load change brands of gasoline If spark knock or pinging persists consult your authorized Honda dealer Failure to do so is con sidered misuse and damage caused by misuse is not covered by
13. ester screen NOTE Inspect the spark arrester screen for holes or tears Replace if necessary 4 Reinstall the spark arrester right side cover and handle 28 Fuse replacement The fuse holder is located on the battery container 1 Turn the engine switch to the OFF position 2 Open the left side maintenance cover open the fuse holder cover and replace the fuse The specified fuses are 1A 5A 10A CAUTION e If frequent fuse failure occurs determine the cause and correct the pro blem before attempting to operate the generator further e Never use a fuse with a different rating from that specified Serious damage to the electrical system or fire may result FUSE HOLDER COVER 29 8 TRANSPORTING STORAGE When transporting the generator turn the engine switch OFF and keep the generator level to prevent fuel spillage Fuel vapor or spilled fuel may ignite Before storing the unit for an extended period 1 Be sure the storage area is free of excessive Lu and dust 2 Drain the fuel a Open the rear maintenance cov er b Turn the engine switch to ON and then loosen the carburetor drain screw Drain the gasoline from the carburetor and fuel tank into a suitable container Gasoline is ly flammable and is explosive under certain conditions Per form this task in a well ven tilated area with the engine stopped Do not smoke or allow flames or sparks i in the are
14. estored the generator may explode burn or cause fires in the building s elec trical system Read these labels before you operate the generator HOT EXHAUST ECHAPPEMENT CHAUD ELECTROCUTION OR PROPERTY DAMAGE CAN OCCUR DO NOT CONNECT THIS GENERATOR TO ANY BUILDING S ELECTRICAL SYSTEM UNLESS AN ISOLATION SWITCH HAS BEEN INSTALLED BY A LICENSED ELECTRICIAN READ OWNER S MANUAL CAREFULLY HONDA MOTOR CO LTD MADE IN JAPAN CAUTION SURE FILL CRANKCASE VOLTAGE 120 240 VOLTAGE 12V WITH RECOMMENDED OIL FREQUENCY 60Hz CURRENT 8 3A BEFORE USING RATED OUTPUT 4 0kVA FOR DETAILED EXPLANATION MAX OUTPUT 4 5kVA FUEL GASOLINE SEE THE OWNER S MANUAL PHASE 19 PETROL EX3300S HONDA MOTOR CO LTD MADE IN JAPAN O CAUTION D C BE SURE TO FILL CRANKCASE VOLTAGE 120 240V VOLTAGE 12V WITH RECOMMENDED OIL FREQUENCY 60Hz CURRENT 8 3A BEFORE USING RATED OUTPUT 3 0kVA FOR DETAILED EXPLANATION OUTPUT 3 3kVA FUEL GASOLINE SEE THE OWNER S MANUAL PHASE 12 PETROL DO NOT USE INDOORS EXHAUST GAS CONTAINS WARNING POISONOUS CARBON MONOXIDE ATTENTION NE PAS UTILISER DANS UN ENDROIT FERME A CAUSE DU RISQUE D EMPOISONNENT DU GAZ ATENCION NO LO USE EN LUGARES CERRADOS PORQUE EL MONOXIDE DE CARBONO ES VENENOSO FOR SPILLED FUEL OR FUEL LEAKS STOP ENGINE BEFORE REFUELING ECONTROLER QU IL N Y A NI FUITE NI ESSE
15. leaner element and the cover 6 Close and latch the rear main tenance cover 23 Spark plug service Recommended spark plug BPR5ES W16EPR U ND To ensure proper engine operation the spark plug must be properly gapped and free of deposits 1 Open the rear maintenance cover 2 Remove the spark plug cap 3 Clean any dirt from around the spark plug base 4 Use the wrench supplied in the tool kit to remove the spark plug 59 gt Ted N HO PLUG WRENCH ES 5 Visually inspect the spark plug Discard it if the insulator is cracked or chipped Clean the spark plug with a wire brush if it is to be reused 6 Measure the plug gap with a feeler gauge The gap should be 0 7 0 8 mm 0 028 0 031 in Correct as necessary by carefully bending the side electrode 0 7 0 8 mm 0 028 0 031 in 24 H 7 Check that the spark plug washer is in good condition and thread the spark plug in by hand to prevent cross threading 8 After the spark plug is seated tighten with a spark plug wrench to com press the washer NOTE If installing a new spark plug tighten 1 2 turn after the spark plug seats to compress the washer If reinstalling a used spark plug tighten 1 8 1 4 turn after the spark plug seats CAUTION The spark plug must be securely tightened An improperly tigh
16. n 1 Start the engine 2 Turn the voltage selector switch to either position as required NOTE With the voltage selector switch in the 120V 240V position you can use the 120V and 240V receptacles simultaneously If you are not us ing the 240V receptacle but you require more power from the 120 twist lock receptacle then turn the switch to the 120V position 3 Switch on the AC circuit breaker 4 Plug in the appliance CAUTION e Be sure that appliances do not exceed the generator s rated load ty for more than 30 minutes and that they never exceed the maximum load capacity Substantial overloading will switch off the circuit breaker Marginal overloading may not switch off the circuit breaker but it will shorten the service life of the generator e If an overloaded circuit causes the AC circuit breaker to switch off reduce the electrical load on the circuit and wait a few minutes before resetting the circuit breaker e Be sure that all appliances are in good working order before connecting them to the generator an appliance begins to operate abnormally becomes sluggish or stops suddenly turn off the circuit breaker and the generator engine switch immediately Then disconnect the appliance and examine if for signs of malfunction VOLTAGE SELECTOR AC CIRCUIT BREAKER PLUG 16 DC application The DC terminals may be used for charging 12 bolt automotive type bat teries only 1
17. or prolonged periods Although this is unlikely unless _ you handle used oil on a daily basis it is still adviseable to thoroughly wash your hands with soap and water as soon as possible after handling used oil NOTE Please dispose of used motor oil in a manner that is compatible with the environment We suggest you take it in a sealed container to your local service station for reclamation Do not throw it in the trash or pour it on the ground 22 Air cleaner service A dirty air cleaner will restrict air flow to the carburetor To prevent car buretor malfunction service the air cleaner regularly page 20 Service more frequently when operating the generator in extremely dusty areas Never use gasoline or low flash point solvents for cleaning the air cleaner element A fire or explosion could result CAUTION Never run the generator without the air cleaner Rapid engine wear will result 1 Open the rear maintenance cover AIR CLEANER COVER 2 Unlatch the air cleaner cover spr ing clips then remove the air cleaner cover and air cleaner element 3 Wash the element in a solution of household detergent and warm water then rinse thoroughly or wash in nonflammable or high flash point solvent Allow the ele ment to dry thoroughly 4 Soak the element in clean engine oil and squeeze out the excess oil The engine will smoke during in itial start up if too much oil is left in the element 5 Reinstall the air c
18. position ENGINE SWITCH 4 If auto throttle will be used turn the switch to after the engine has warmed up NOTE e AUTO is recommended to minimize fuel consumption The auto throttle system will not respond to electrical loads of less than 1 ampere e The system is not effective for use with appliance that requires only momentary power To avoid extended warm up periods keep the switch OFF until the engine reaches operating temperature 13 5 GENERATOR USE WARNING e To prevent electrical shock from faulty appliances the generator should be grounded Connect a length of heavy wire between the ground ter minal and an external ground source Connections for standby power to a building s electrical system must be made by a qualified electrician and must comply with all applicable laws and electrical codes Improper connections can allow electrical current from the generator to backfeed into the utility lines Such backfeed may electrocute utility company workers or others who contact the lines dur ing a power outage and when utility power is restored the generator may explode burn or cause fires in the building s electrical system 27 GROUND TERMINAL CAUTION Limit operation requiring maximum power 4 5 kVA for 45008 3 3 kVA for 5 to 30 minutes For continuous operation do not exceed the rated power of 4 0 kVA for EX4500S 3 0 kVA for EX3300S In eithe
19. r use gasoline containing more than 596 methanol even if it has cosolvents and corrosion inhibitors NOTE e Fuel system damage or engine performance problems resulting from the use of fuels that contain alcohol is not covered under the warranty Honda cannot endorse the use of fuels containing methanol since evidence of their suitability is as yet incomplete e Before buying fuel from an unfamiliar station try to find out if the fuel contains alcohol if it does confirm the type and percentage of alcohol used If you notice any undesirable operating symptoms while using a gasoline that contains alcohol or one that you think contains alcohol switch to a gasoline that you know does not contain alcohol 10 3 Check the battery The electrolyte level must be maintained between the UPPER and LOWER level marks If the electrolyte level is near the LOWER mark add distilled water WARNING The battery gives off explosive gases keep sparks flames and cigaret tes away Provide adequate ventilation when charging or using batteries in an enclosed space The battery contains sulfuric acid electrolyte Contact with skin or eyes may cause severe burns Wear protective clothing and a face shield If electrolyte gets on your skin flush with water If electrolyte gets in your eyes flush with water for at least 15 minutes and call a physician immediately Electrolyte is poisonous If swallowed drink larg
20. r case the total wattage of all appliances connected must be considered Most appliance motors require more than their rated wattage for start up Do not exceed the current limit specified for any one receptacle 14 Auto throttle System With the switch in the AUTO position engine speed is automatically reduc ed to an idle when all loads are turned off or disconnected When ap pliances are turned on or reconnected the engine resumes the rated speed At OFF the auto throttle system does not operate NOTE AUTO is recommended to minimize fuel consumption when no load is applied The auto throttle system will not respond to electrical loads of less than 1 ampere system is not effective for use with appliances that require only momentary power To avoid extended warm up periods keep the switch OFF until the engine reaches operating temperature AUTO THROTTLE SWITCH Oil Alert System The Oil Alert system is designed to prevent engine damege caused by an in sufficient amount of oil in the crankcase Before the oil level in the crankcase can fall below a safe limit the Oil Alert system will automatically shut down the engine the engine switch will remain in the ON position If the Oil Alert system shuts down the engine the Oil Alert lamp will flash when you operate the starter and the engine will not run If this occurs add engine oil p 8 OIL ALART LAMP 15 AC operatio
21. r than this if no carburetor modifica tion is made CAUTION Operation of the generator at an altitude lower than the car buretor is jetted for may result in reduced performance overheating and serious engine damage caused by an excessively lean air fuel mixture 18 6 STOPPING THE ENGINE NOTE To stop the engine in an emergency turn the engine switch to the OFF position In normal use 1 Move the AC circuit breaker to the OFF position Disconnect DC battery charging cables AC CIRCUIT BREAKER 2 Turn the engine switch to the OFF position ENGINE SWITCH 19 7 MAINTENANCE Periodic maintenance and adjustment is necessary to keep the generator in good operating condition Perform the service and inspection scheduled in the table on the following page AWARNING Shut off the engine before performing any maintenance the engine must be run make sure the area is well ventilated Exhaust gas con tains poisonous carbon monoxide CAUTION Use only genuine Honda parts or their equivalent for maintenance or repair Replacement parts which are not of equivalent quality may damage the generator Maintenance Schedule REGULAR SERVICE PERIOD Performed at every indicated month or operating hour interval whichever comes first Check level Change Check Clean Check level Battery electrolyte Check level and gravity oe pe N Spark plug Cem edat zo e
22. ship using the dealer s facilities equipment and personnel so it is very important that your initial contact be with the dealer Your purchase of a Honda product is greatly appreciated by both your dealer and American Honda Motor Co Inc We want to assist you in every way possible to assure your complete satisfaction with your purchase 38 MEMO 39 m 188 ra 287 6031 10008010 PRINTED IN JAPAN
23. tened spark plug can become very hot and could damage the engine e Never use spark plugs which have an improper heat range Use only the recommended spark plugs or equivalent 9 Close and latch the rear maintenance cover 25 Fuel sediment cup cleaning The sediment cup prevents dirt or water which may be in the fuel tank from entering the carburetor If the engine has not been run for a long time the sediment cup should be cleaned Open the left side maintenance cover Turn the engine switch to the OFF position Remove the sediment cup by turning it counterclockwise Clean the cup and O ring in nonflammable or high flashpoint Solent Reinstall the O ring and sediment cup Tighten securely Close and latch the left side maintenance cover of G N After installing the sediment cup check for fuel leaks and make sure the area is dry before Starting the engine SEDIMENT CUP 26 Spark arrester maintenance ENS If the generator has been running the muffler will be very hot Allow it to cool before proceeding CAUTION The spark arrester must be serviced every 100 hours to main tain its efficiency 1 Remove the nine 6 mm bolts the handle and right side cover RIGHT SIDE COVER HANDLE 6 mm BOLTS 2 Remove the two 5 mm pan screws and remove the spark arrester SPARK ARRESTER OF 6 mm PAN SCREW x 27 3 Use a brush to remove carbon deposits from the spark arr
24. uel reaching the carburetor 1 Turn off the engine switch YES and loosen the drain screw 2 Fuel should flow from the drain when the engine switch is turned on If the engine still does not start take the generator to an authorized HONDA dealer 31 No electricity at the AC receptacles Is the AC circuit breaker on Check the electrical appliance or equip ment for any defects Turn the AC circuit breaker on Take the generator to an authorized Honda dealer NO DEFECTS Replace the elect rical appliance or equipment e Take the electrical appliance or equipment to an electrical shop for repair DEFECTS 32 10 WIRING DIAGRAM EX3300S 4 1 lee SFM 55 2 a MT TI ES 0 3 33 S00StX3 OC TERMINAL 11 SPECIFICATIONS Dimensions MODEL Power product description code EX3300S 45005 2 910 x 530 x 695 mm 35 8 x 20 9 x 27 4 in 109 kg 240 3 Ib 122 kg 268 9 Ib Length x Width x Height Dry weight Engine Displacement 242 cc 14 8 cu in Bore x Stroke 73 x 58 mm 1 9 x 2 3 in Compression Ratio 2 GX340 337 cc 20 6 cu in 82 x 64 mm 3 2 x 2 5 in 8 0 1 Co Engine Speed 3600 r p m Cooling System Forced air
25. vere personal injury or loss of life if instructions are not followed CAUTION indicates a possibility of personal injury or equipment damage if instructions are not followed NOTE Gives helpful information If a problem should arise or if you any questions about the generator consult an authorized Honda dealer Honda generators are designed to give safe and dependable ser vice if operated according to instructions Read and understand this Owner s Manual before operating the generator Failure to do so could result in personal injury or equipment damage CONTENTS CONTENTS 3 6 PETA NER 8 P 12 GENERATOR USE 14 10 WIRING TIN 11 SPECIFICATIONS TO 35 12 INSTALLATION OF OPTIONAL PARTS 36 13 WARRANTY SERVICE 38 1 GENERATOR SAFETY AWARNING Place the generator on a firm level surface avoid loose sand or snow If the generator is tilted or overturned fuel spillage may result Also if the generator is overturned or sinks into a soft surface sand dirt or water may enter the generator To prevent fire hazards and to provide adequate ventilation keep the generator at least 1 meter 3 feet away from buildings and other equip ment during operation Do not place flammable objects close to the generator
Download Pdf Manuals
Related Search