Harbor Freight Tools 16 LED Hand Crank Spotlight Product manual
Contents
1. as shown in Figure 1 2 Grasp the Handle and crank it continuously clockwise The red LED will stay on while the Spotlight is charging For every 3 minutes of turning the handle you will get one minute of light The Green LED will come on when the Spotlight is fully charged 3 When finished fold the Handle back into its slot when done cranking Using the Cigarette Plug Adapter 1 Insert the plug end into the charge receptacle on the Spotlight 2 Plug the Cigarette Plug Adapter into the vehicle s cigarette lighter socket 3 Allow the Spotlight to charge until the green LED comes on 4 To prevent the vehicle s battery from running down charge the spotlight only when the vehicle s engine is running 5 The Green LED will come on when the Spotlight is fully charged SKU 96141 For technical questions please call 1 888 866 5797 Using the 120 V AC DC Adapter 1 Insert the plug end into the charge receptacle on the Spotlight 2 Plug the 120V AC DC Adapter into a 120V receptacle 3 Allow the Spotlight to charge until the green LED comes on 4 Remove the 120V AC DC Adapter electrical plug from the outlet and disconnect from the Spotlight Running the Spotlight 1 The Spotlight will run for approximately 28 hours on a fully charged battery while in LOW mode and approximately 12 hours on a fully charged battery while in HIGH mode 2 The LOW setting will run 6 LED s while the HIGH setting wi2. Owner s Manual amp Safety Instructions Save This Manual Keep this manual for the safety warnings and precautions assembly operating inspection maintenance and cleaning procedures Write the product s serial number in the back of the manual near the assembly diagram or month and year of purchase if product has no number Keep this manual and the receipt in a safe and dry place for future reference 16 LED SPOTLIGHT with HAND GRANK REV 14I When unpacking make sure that the product is intact and undamaged If any parts are missing or broken please call 1 888 866 5797 as soon as possible Copyright 2007 by Harbor Freight Tools All rights reserved No portion of this manual or any artwork contained herein may be reproduced in any shape or form without the express written consent of Harbor Freight Tools Diagrams within this manual may not be drawn proportionally Due to continuing improvements actual product may differ slightly from the product described herein Tools required for assembly and service may not be included ITEM 96141 Read this material before using this product Failure to do so can result in serious injury SAVE THIS MANUAL SPECIFICATIONS Light Source AC DC Adapter Input AC DC Adapter Output Rechargeable Battery 16 12000 MCD LED s 120 V 60 Hz 7 W 9 5 VDC 300 mA 3FM 2 8 constant voltage charge cycle use 7 2 7 5V standby use 6 75 6 9V Green charged Red chargi
3. ash off any spilled acid immediately with cool water Note The LED lights have a long lifetime and do not need replacement The Spotlight has no Protect the Spotlight from exposure to water or corrosive materials It should be kept clean and dry Occasional cleaning with a clean rag will extend its life and good appearance replacement parts Limited 90 Day Warranty Harbor Freight Tools Co makes every effort to assure that its products meet high quality and durability standards and warrants to the original purchaser that this product is free from defects in materials and workmanship for the period of 90 days from the date of purchase This warranty does not apply to damage due directly or indirectly to misuse abuse negligence or accidents repairs or alterations outside our facilities criminal activity improper installation normal wear and tear or to lack of maintenance We shall in no event be liable for death injuries to persons or property or for incidental contingent special or consequential damages arising from the use of our product Some states do not allow the exclusion or limitation of incidental or consequential damages so the above limitation of exclusion may not apply to you THIS WARRANTY IS EXPRESSLY IN LIEU OF ALL OTHER WARRANTIES EXPRESS OR IMPLIED INCLUDING THE WARRANTIES OF MERCHANTABILITY AND FITNESS To take advantage of this warranty the product or part must be returned to us with transportation charg
4. es prepaid Proof of purchase date and an explanation of the complaint must accompany the merchandise If our inspection verifies the defect we will either repair or replace the product at our election or we may elect to refund the purchase price if we cannot readily and quickly provide you with a replacement We will return repaired products at our expense but if we determine there is no defect or that the defect resulted from causes not within the scope of our warranty then you must bear the cost of returning the product This warranty gives you specific legal rights and you may also have other rights which vary from state to state 3491 Mission Oaks Blvd PO Box 6009 Camarillo CA 93011 1 888 866 5797
5. ll use all 16 LEDs 3 Select HIGH or LOW modes to run the Spotlight by moving the switch 4 Squeeze the Trigger to turn ON the Spotlight Trigger Figure 2 5 Slide the Trigger Lock Switch down see Figure 2 to lock the Trigger ON To release the Trigger from locked position lightly touch the Trigger 6 Remove finger away from the Trigger to turn the Spotlight OFF Page 3 INSPECTION MAINTENANCE AND CLEANING li warnine Make sure the Trigger is in its 5 OFF position before performing any inspection maintenance or cleaning procedures BEFORE EACH USE inspect the general condition of the Spotlight Check for cracked or broken parts and any other condition that may affect its safe operation If abnormal noise or vibration occurs have the problem corrected before further use Do not use damaged equipment Protect the Spotlight from rough use It is susceptible to damage from being dropped struck or other abuse Lock it up and store in a dry location to inhibit rust Keep out of the reach of children Before discarding this product remove the battery and dispose of it properly in accordance with local state and federal regulations and ordinances To access the battery remove the six small philip s head screws that secure the back and the front part of the housing Then remove 4 screws holding the two halves of the housing together Be careful with the battery it may leak acid W
6. ng 12 Hours High Intensity Mode 12 hours Low Intensity Mode 28 hours 8 5 8 L x 3 5 16 W x 9 H 69 2 5 Ib Low voltage and overcharging protection auto shut off when battery is fully charged Cigarette Plug Adapter LED Indicators Charging Time Approximate Run Time fully charged Overall Dimensions Wire Length Weight Special Features GENERAL SAFETY RULES WARNING READ AND UNDERSTAND ALL INSTRUCTIONS Failure to follow all instructions listed below may result in serious injury SAVE THESE INSTRUCTIONS 1 Keep your work area clean and well lit Cluttered benches and dark areas invite accidents 6 Maintain this product with care Do not use a damaged product Tag damaged products Do not use until repaired 2 Keep bystanders children and visitors F away while using this product Distractions can cause you to lose control Check for misalignment or binding of moving parts breakage of parts and any other condition that may affect the product s operation If damaged have the product 3 Stay alert Watch what you are doing and use serviced before using Many accidents are SKU 96141 common sense when operating the Spotlight Do not use this product while tired or under caused by poorly maintained products the influence of drugs alcohol or medication 8 Maintain labels and nameplates on the A moment of inattention while operating this product These car
7. ry important information product may result in serious personal injury If unreadable or missing contact Harbor Freight Tools for a replacement Do not force the product Use the correct product for your application The correct 9 Maintain a safe working environment Make product will do the job better and safer at the sure there is adequate surrounding workspace rate for which it is designed Do not force Do not use this product in a damp or wet location the product and do not use the product for a purpose for which it is not intended 10 WARNING The cord of this product contains Store idle products out of reach of children and other untrained persons This product is dangerous in the hands of untrained users Never point the light beam directly at people or animals For technical questions please call 1 888 866 5797 lead and or di 2 ethylhexyl phthalate DEHP chemicals known to the State of California to cause cancer and birth defects or other reproductive harm Wash hands after handling California Health amp Safety Code 25249 5 et seq Page 2 OPERATION 1 The Spotlight can be charged in three different ways by cranking the Handle using the 120 V Adapter or using the Cigarette Plug Adapter 2 The Green LED will indicate when the battery is fully charged Ared LED will indicate that the battery is charging Charging with the Cranking Handle Figure 1 Indicator LED s 1 Pull out the Handle
Download Pdf Manuals
Related Search