Emerson Fisher V500 Data Sheet
Contents
1. Figure 1 Sectional of Fisher V500 Control Valve RETAINER VALVE PLUG FACE SEALS SEAT RING PACKING BEARING VALVE SHAFT P di 333 a c M BEARING STOP O RINGS THRUST WASHER Ta VALVE BODY TAPER AND EXPANSION PINS W4170 3 C 4172 2 DETAIL OF SEALED BEARINGS END TAPPED VALVE BODY AND PIPE PLUG OPTIONAL LIMITED TO LESS THAN 232 C 450 F Product Bulletin V500 Valve 51 3 V500 0100054 012 2012 Figure 2 Detail of Seat Ring Design FACE SEAL SECTION FLOW DIRECTION m FLOW DIRECTION Uu Ud L 49A3685 C A3288 2 FORWARD FLOW SHUTOFF REVERSE FLOW SHUTOFF STANDARD Figure 3 Typical ENVIRO SEAL Packing Arrangements for Rotary Valves PACKING BOX STUD SPRINGS e VALVE PACKING ACTUATOR BODY VALVE FLANGE PACKING MOUNTING V YOKE VALVE EXTRUSION RINGS rere z YOKE BEARING PACKING PACKING FLANGE BOX RING SPRINGS GRAPHITE PACKING PACKING SET PTFE FOLLOWER PACKING FOLLOWER RINGS W5806 1 SHOWN SINGLE PTFE PACKING GRAPHITE PACKING Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 3 Maximum Allowable Shutoff Pressure Drops for Level 1 Trim Bar VALVE BODY BEARING2. V500 Valve D100054X012 Table 8 Material Temperature Capabilities Product Bulletin 51 3 V500 May 2012 PART NAME MATERIAL MINIMUM TO MAXIMUM TEMPERATURE 531600 retainer Steel body 531600 retainer with CoCr A bore 29 to 427 20 to 800 Valve body and retainer 531600 retainer with VTC bore NPS 1 and 1 1 2 531600 retainer CF8M body 31600 retainer with CoCr A bore 198 to 538 325 to 1000 531600 retainer with VTC bore 517400 retainer 29 to 427 20 to 800 Solid CoCr A retainer 29 to 427 20 to 800 WeCstee 531600 retainer 29 to 260 20 10 500 Valve body and retainer CoCr A retainer with VTC bore 29 to 427 20 to 800 NPS 2 through 8 531600 retainer 198 to 427 325 to 800 Solid CoCr A retainer 46 to 324 50 to 600 CESM body 531600 with bore 198 to 427 325 to 800 CoCr A retainer with VTC bore 46 to 427 50 to 800 531600 198 to 538 325 to 1000 Solid CoCr A 46 to 538 50 to 1000 Seat ring n 531600 with CoCr A seat 198 to 538 325 to 1000 Solid VTC 46 to 427 50 to 800 Chrome plated 531600 198 to 316 325 to 600 Solid CoCr A 46 to 538 50 to 1000 531600 with CoCr A face 3 Valve plug NPS 6 and 8 valves only 19810238 322101000 Solid VTC NPS 1 through 2 valves only 46 to 427 50 to 800 517400 62 0427 80 to 800
3. Valve Valve Rotation Degrees Linear Coefficients Size 5 10 20 30 40 50 60 70 80 90 1 90 3 80 4 85 5 82 5 90 5 90 5 90 5 90 5 90 1 63 3 27 4 17 5 01 5 07 5 07 5 07 5 07 5 07 1 0 54 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 56 0 67 0 68 0 69 0 73 0 75 0 75 0 75 0 75 XT 0 312 0 386 0 427 0 409 0 448 0 448 0 448 0 448 0 448 1 95 4 45 5 75 7 75 11 4 11 8 11 8 11 8 11 8 1 68 3 83 4 95 6 67 9 80 10 2 10 2 10 2 10 2 Fa 1 1 2 0 53 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 83 0 77 0 78 0 76 0 68 0 72 0 73 0 73 0 73 XT 0 395 0 415 0 527 0 519 0 421 0 459 0 459 0 459 0 459 2 70 4 65 6 30 11 1 18 3 19 8 20 2 20 4 21 0 Ky 2 32 4 00 5 42 9 55 15 7 17 0 17 4 17 5 18 1 Fa 2 0 54 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 91 0 89 0 84 0 71 0 58 0 61 0 62 0 62 0 60 XT 0 459 0 464 0 594 0 453 0 307 0 358 0 366 0 337 0 328 4 41 9 60 13 7 19 5 37 3 53 3 56 7 57 9 57 9 Ky 3 81 8 30 11 9 16 9 32 3 46 1 49 0 50 1 50 1 240 3 0 53 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 96 0 93 0 93 0 87 0 73 0 64 0 62 0 62 0 63 Xr 0 469 0 578 0 578 0 537 0 319 0 258 0 265 0 268 0 268 C 9 78 11 1 19 4 32 1 49 7 67 8 80 5 84 6 86 6 8 46 9 60 16 8 27 8 43 0 58 6 69 6 73 2 74 9 Fy 4 0 52 0 65 0 74 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 93 0 93 0 89 0 84 0 79 0 72 0 64 0 65 0 65 0 620 0 620 0 593 0 605 0 570 0 522 0 476 0 459 0 436 10 6 30 0 43 4 77 122 168 198 223 226 9 17 26 0 37 5 66 7 106 145 171 19
4. 520910 198 to 538 325 to 1000 10276 46 to 427 50 to 800 Taper and expansion pins VTC valve plug Other valve plugs 520910 198 to 538 325 to 1000 PTFE composition lined S31600 46 to 260 50 to 500 Bearings CoCr A 2 198 to 538 325to 1000 5440042 2910427 20 800 O ringsO for Alloy 6 or 440C SST Fluorocarbon 18to 204 0 to 400 sealed bearings Nitrile 29 to 93 20 to 200 Bearing stop 531600 198 0538 325101000 517700 for 517400 shaft 198 to 427 325 to 800 Thrustwasher R30016 for 520910 SST shaft 198 to 538 325 to 1000 Face seals N07718 NACE MR0175 2002 or PTFE N10276 198 to 538 325 to 1000 Retainer gasket 01 01 xj 198 to 538 325 to 1000 PTFE 46 to 260 50 to 500 Packing rings PTFE bound composition 73to 260 100 to 500 Graphite ribbon 198 to 538 325 to 1000 Packing follower 531600 198 to 538 325 to 1000 SA 193 B7 studs and SA 194 2H nuts 46 to 427 50 to 800 Studs and nuts SA 193 B7M studs and SA 194 2HM nuts 29 to 427 20 to 800 B8M studs and 8M nuts 198 to 538 325 to 1000 Packing box ring 531600 198 to 538 325 to 1000 1 VTC trim is incompatible with water and steam above 180 C 36092 2 Recommended for erosive applications 3 For sealed bearing constructions 11 Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 9 Material
5. 300 1455 1455 1455 1455 1300 800 3397 300 to 400 1410 1410 410 1410 1300 Sap 3200 7800 3400 400 to 450 1330 1330 1330 1330 1330 50 3150 50 to 400 1000 800 600 600 600 300 220 400 to 500 955 800 600 600 600 300 220 500 to 600 905 800 600 600 600 300 220 600 10 650 890 800 600 600 600 300 220 650 to 700 865 800 600 600 600 300 220 700 to 750 845 800 600 600 600 300 220 750 to 800 830 800 600 600 600 300 220 CF8M SST 3 50 to 100 1440 1440 1440 1440 1300 800 350 100 to 200 1240 1240 1240 1240 1240 800 350 3500 200 300 1120 1120 1120 1120 1120 770 3397 sm 300 to 400 1030 1030 1030 1030 1030 74007 3200 7800 3400 400 to 450 955 955 955 955 955 550 315 1 517400 shaft only 2 ASME SA 479 Grade 520910 SST shaft only Pressure gropi appropriate for both shaft materials 3 Level 3 trim is limited to a maximum temperature of 600 F Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 7 Maximum Allowable Shutoff Pressure Drops for Level 4 BAR nore TEMPERATURE VALVE SIZE NPS 1 1 1 2 2 3 4 6 8 2291093 103 4 103 4 70 3 103 4 78 6 52 4 24 1 93 to 149 100 3 100 3 70 3 100 3 78 6 52 4 241 14910204 97 2 97 2 70 3 97 2 78 6 51 0 23 8 544004 20410260 917 9
6. 107 1 85 5 09 8 8 11 9 13 6 14 0 14 0 15 3 093 1 60 4 40 7 61 10 3 11 8 12 1 12 1 13 2 1 0 49 0 64 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 88 0 65 0 60 0 54 0 54 0 60 0 62 0 61 0 334 0 526 0 426 0 360 0 334 0 345 0 372 0 384 0 334 988 3 37 7 66 13 5 19 3 23 5 25 3 25 3 26 1 Ky 854 2 92 6 63 11 7 16 7 20 3 21 9 21 9 22 6 1 1 2 0 48 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 98 0 92 0 75 0 73 0 62 0 58 0 59 0 61 0 61 0 473 0 585 0 563 0 487 0 432 0 403 0 400 0 426 0 429 1 42 4 92 11 8 20 9 29 8 36 7 40 9 42 7 43 0 Ky 1 23 4 26 10 2 18 1 25 8 31 7 35 4 36 9 37 2 2 0 49 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 97 0 93 0 86 0 77 0 72 0 62 0 64 0 63 0 66 0 403 0 718 0 616 0 518 0 473 0 452 0 452 0 446 0 439 7 64 20 6 413 62 4 80 5 94 8 105 109 111 Ky 6 61 17 8 34 9 54 0 69 6 82 0 90 8 94 3 96 0 3 0 46 0 62 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 93 0 91 0 89 0 81 0 73 0 72 0 71 0 74 0 76 XT 0 616 0 656 0 537 0 497 0 501 0 508 0 504 0 515 0 511 8 07 31 3 67 1 102 129 153 174 189 192 Ky 6 98 27 1 58 0 88 2 112 132 151 163 166 4 0 45 0 61 0 72 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 86 0 85 0 84 0 80 0 75 0 75 0 75 0 75 0 74 XT 0 456 0 664 0 533 0 490 0 515 0 526 0 522 0 504 0 515 10 5 58 6 134 218 294 356 406 445 461 9 08 50 7 116 189 254 308 351 385 399 6 0 44 0 60 0 72 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 80 0 76 0 72 0 70 0 68 0 69 0 69 0 69 0 69 XT 0 511 0 551 0 459 0
7. 0 448 0 519 0 624 0 612 0 543 0 444 0 439 0 484 4 12 9 50 13 1 19 8 29 6 39 0 45 3 48 0 48 0 Ky 3 56 8 22 11 3 17 1 25 6 33 7 39 2 41 5 41 5 240 3 0 53 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 80 0 80 0 88 0 86 0 84 0 82 0 81 0 79 0 77 0 469 0 551 0 605 0 522 0 518 0 551 0 515 0 466 0 466 2 26 11 2 20 1 33 3 50 8 69 1 83 0 89 3 90 1 Ky 1 95 9 69 17 4 28 8 43 9 59 8 71 8 77 2 77 9 Fy 4 0 52 0 65 0 74 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 96 0 95 0 85 0 86 0 86 0 83 0 80 0 77 0 74 0 779 0 779 0 632 0 620 0 612 0 589 0 537 0 466 0 452 13 6 37 9 49 8 82 9 122 159 184 194 196 11 8 32 8 43 1 71 7 106 138 159 168 170 6 0 52 0 65 0 74 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 97 0 69 0 72 0 74 0 77 0 81 0 81 0 77 0 77 0 518 0 280 0 381 0 357 0 397 0 452 0 476 0 452 0 442 19 7 63 6 134 228 334 438 526 587 605 17 0 55 0 116 197 289 379 455 508 523 8 0 48 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 93 0 83 0 76 0 77 0 77 0 77 0 75 0 75 0 72 0 597 0 473 0 422 0 394 0 378 0 381 0 400 0 429 0 436 1 Measured at 60 Port 2 Measured at 40 Port 21 Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 19 Fisher V500 Reverse Flow Level 4 Trim Reduced Port
8. 0 99 1 00 FL 0 81 0 81 0 79 0 76 0 68 0 66 0 66 0 66 0 66 XT 0 697 0 593 0 483 0 410 0 354 0 342 0 366 0 403 0 363 Product Bulletin V500 Valve 51 3 V500 D100054X012 May 2012 Table 14 Fisher V500 Forward Flow Level 1 2 and 3 Trims Reduced Port OS NUT Valve Rotation Degrees 5 10 20 30 40 50 60 70 80 90 Cy 0 777 2 09 3 02 3 62 4 53 4 90 4 93 4 96 5 01 Ky 0 672 1 81 2 61 3 13 3 92 4 24 4 26 4 29 4 33 1 0 54 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 89 0 89 0 88 0 85 0 82 0 79 0 75 0 74 0 74 XT 0 487 0 391 0 497 0 597 0 508 0 439 0 436 0 429 0 419 Cy 0 632 2 56 4 47 7 15 9 62 10 7 10 8 10 9 10 9 Ky 547 2 21 3 87 6 18 8 32 9 26 9 34 9 43 9 43 1 1 2 0 53 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 84 0 84 0 84 0 82 0 79 0 75 0 73 0 73 0 73 XT 0 559 0 397 0 522 0 574 0 585 0 508 0 497 0 490 0 490 1 30 3 49 5 31 9 64 15 1 17 3 17 3 17 3 17 3 1 12 3 02 4 59 8 34 13 1 15 0 15 0 15 0 15 0 2 0 54 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 85 0 85 0 84 0 84 0 82 0 79 0 79 0 79 0 79 0 391 0 336 0 452 0 563 0 529 0 462 0 462 0 462 0 462 6 78 11 5 16 0 26 7 40 2 47 7 48 4 48 4 48 4 5 86 9 95 13 8 23 1 34 8 41 3 41 9 41 9 41 9 Fg 3 0 53 0 66 0 75 0 82 0 88 0 92 0 96
9. 0 99 1 00 Fi 0 90 0 88 0 87 0 86 0 85 0 82 0 77 0 77 0 77 Xr 0 487 0 501 0 487 0 429 0 459 0 429 0 429 0 429 0 429 Cy 10 0 18 2 24 4 43 7 69 2 90 6 98 2 98 2 98 2 Ky 8 65 15 7 21 1 37 8 59 9 78 4 84 9 84 9 84 9 4 0 52 0 65 0 74 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 95 0 89 0 85 0 84 0 84 0 81 0 77 0 77 0 77 XT 0 426 0 459 0 570 0 504 0 487 0 462 0 426 0 426 0 426 9 50 26 6 41 8 76 0 129 170 200 200 200 8 22 23 0 36 2 65 7 112 147 173 173 173 6 0 52 0 65 0 74 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 97 0 96 0 92 0 86 0 80 0 76 0 74 0 74 0 74 XT 0 995 0 351 0 403 0 487 0 416 0 462 0 410 0 410 0 410 39 9 87 8 155 241 343 448 541 606 623 Ky 34 5 75 9 134 208 297 388 468 524 539 4 2 8 0 48 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 96 0 81 0 80 0 79 0 78 0 76 0 74 0 72 0 70 XT 0 400 0 446 0 459 0 449 0 429 0 413 0 413 0 413 0 391 1 Measured at 60 Port 2 Measured at 40 Port 17 Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 15 Fisher V500 Reverse Flow Level 1 2 and 3 Reduced Port Valve Valve Rotation Degrees Linear Coefficients Size Characteristic NPS 10 20 30 40 50 60 70 80 90 634 2 09 3 34 3 96 5 21 5 64 5 70 5 71 5 76 548 1 81 2
10. 1000 800 600 600 600 600 350 544004 300 to 400 1000 800 600 600 600 600 345 400 to 600 1000 800 600 600 600 600 335 20 to 400 1000 800 600 600 600 300 220 CoCr A 400 to 500 1000 800 600 600 600 300 220 500 to 600 1000 800 600 600 600 300 220 WCC steel 20 to 200 1000 800 600 600 600 600 350 3500 200 to 300 1000 800 600 600 600 600 PTFE 3350 composition 3450 lined 31600 300 to 400 1000 800 600 600 600 600 3290 3400 400 to 500 1000 800 600 600 600 600 3157 50 to 400 1000 800 600 600 600 300 220 CoCr A 400 to 500 955 800 600 600 600 300 220 500 to 600 905 800 600 600 600 300 220 50 to 200 1000 800 600 600 600 600 350 3500 55 Eon 200 to 300 1000 800 600 600 600 600 3357 composition 3450 lined 531600 300 to 400 1000 800 600 600 600 600 3290 3400 400 to 500 955 800 600 600 600 600 3152 1 517400 shaft only 2 ASME SA 479 Grade 520910 SST shaft only Pressure drops appropriate for both shaft materials Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 5 Maximum Allowable Shutoff Pressure Drops for Level 2 and 3 Trims Bar VALVE BODY BEARING TEMPERATURE VALVE BODY SIZE NPS MATERIAL MATERIAL 1 1 1 2 2 3 4 6 8 29 to 93 103 4 103 4 103 4 103 4 82 7 51 7 24 1 93 to 149 100 3 100 3 99 0 100 3 82 7 51 7 24 1 149 to 204 97 2 97 2 93 8
11. 3 0 46 0 62 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 86 0 84 0 83 0 83 0 83 0 82 0 78 0 77 0 77 XT 0 469 0 544 0 574 0 526 0 497 0 526 0 508 0 476 0 456 16 6 41 3 79 1 123 166 203 230 247 255 Ky 14 3 35 7 68 4 106 144 176 199 214 221 Fq 4 0 45 0 61 0 72 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 85 0 82 0 81 0 81 0 80 0 79 0 77 0 76 0 76 XT 0 439 0 555 0 501 0 466 0 473 0 490 0 480 0 459 0 442 17 5 79 1 155 270 363 434 492 540 565 Ky 15 1 68 4 134 234 314 375 426 467 489 Fq 6 0 44 0 60 0 72 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 97 0 93 0 88 0 82 0 76 0 73 0 72 0 71 0 71 XT 0 879 0 585 0 540 0 456 0 439 0 432 0 436 0 426 0 416 51 5 146 298 481 646 775 879 981 1050 44 5 126 258 416 559 670 760 849 908 8 0 43 0 59 0 72 0 80 0 87 0 92 0 96 0 99 1 00 FL 0 97 0 93 0 87 0 78 0 72 0 71 0 70 0 69 0 67 XT 0 456 0 605 0 533 0 449 0 413 0 403 0 391 0 372 0 360 15 Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 13 Fisher V500 Reverse Flow Level 1 2 and 3 Trims Full Port E sete TOE Valve Rotation Degrees Ve NPS 10 20 30 40 50 60 70 80 90 1 08 2 82 5 26 9 11 12 4 14 7 15 9 16 4 16 8 Ky 0 93 2 44 4 55 7 88 10 7 12 7 13 8 14 2 14 5 1 0 49 0 64 0 73 0 81 0 87 0 92 0 96 0 99 1 00 F
12. 406 0 391 0 397 0 410 0 416 0 429 25 4 136 266 413 554 686 818 895 897 Ky 22 0 118 230 357 479 593 708 774 776 8 0 43 0 59 0 72 0 80 0 87 0 92 0 96 0 99 1 00 FL 0 75 0 77 0 75 0 72 0 73 0 69 0 70 0 70 0 72 XT 0 731 0 439 0 483 0 469 0 439 0 397 0 360 0 375 0 426 20 Product Bulletin V500 Valve 51 3 V500 D100054X012 May 2012 Table 18 Fisher V500 Forward Flow Level 4 Trim Reduced Port Valve Valve Rotation Degrees Medica Linear Coefficients Size Characteristic NPS 10 20 30 40 50 60 70 80 90 C 2 14 3 70 4 65 5 25 5 50 5 57 5 66 5 66 5 66 1 84 3 18 4 00 4 52 4 73 4 79 4 87 4 87 4 87 1 0 54 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 64 0 75 0 75 0 79 0 75 0 74 0 73 0 73 0 73 XT 0 286 0 388 0 464 0 483 0 471 0 459 0 444 0 444 0 444 2 10 4 55 6 16 8 00 10 4 11 3 11 3 11 3 11 3 1 81 3 91 5 30 6 88 8 94 9 72 9 72 9 72 9 72 1 1 2 0 53 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 82 0 79 gt 0 79 0 79 0 79 0 72 0 72 0 72 0 72 XT 0 469 0 397 0 454 0 500 0 502 0 482 0 482 0 482 0 482 2 75 5 15 6 70 9 65 13 7 16 8 18 8 18 8 17 9 2 37 4 43 5 76 8 30 11 8 14 5 16 2 16 2 15 4 240 2 0 54 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 75 0 76 0 83 gt 0 86 0 87 0 85 0 77 0 77 0 81 XT 0 467
13. 89 3 43 4 51 4 88 4 93 4 94 4 98 1 0 54 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 70 0 70 0 70 0 70 0 70 0 70 0 70 0 70 0 70 XT 0 230 0 216 0 207 0 406 0 366 0 348 0 339 0 345 0 342 464 1 93 4 21 7 81 11 0 12 1 12 1 12 2 12 2 401 1 67 3 64 6 76 9 52 10 5 10 5 10 6 10 6 Fa 1 1 2 0 53 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 93 0 93 0 75 0 72 0 70 0 70 0 70 0 70 0 70 XT 0 970 0 416 0 501 0 467 0 416 0 416 0 416 0 413 0 416 965 2 68 4 82 12 0 17 7 18 7 18 8 18 9 18 9 Ky 835 2 31 4 17 10 4 15 3 16 2 16 3 16 3 16 3 Fa 2 0 54 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 96 0 96 0 77 0 67 0 62 0 62 0 62 0 62 0 62 XT 0 518 0 508 0 559 0 354 0 351 0 360 0 357 0 354 0 354 5 95 10 6 14 7 29 9 49 0 56 0 56 2 56 2 56 7 Ky 5 15 9 17 12 7 25 9 42 4 48 4 48 6 48 6 49 0 240 3 0 53 0 66 0 75 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 80 0 79 0 73 0 64 0 59 0 58 0 58 0 58 0 58 Xr 0 429 0 455 0 487 0 345 0 286 0 286 0 286 0 286 0 281 C 7 69 15 3 22 7 42 6 75 0 98 0 99 5 100 102 6 65 13 2 19 6 36 8 64 9 84 8 86 1 86 5 88 2 Fy 4 0 52 0 65 0 74 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 83 0 82 0 81 0 77 0 60 0 59 0 58 0 58 0 58 0 504 0 548 0 555 0 529 0 375 0 322 0 336 0 334 0 319 5 10 20 6 34 6 71 9 123 170 230 231 232 4 41 17 8 29 9 62 2 106 147 199 200 201 6 0 52 0 65 0 74 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 97 0 95 0 90 0 82 0 73 0 65 0 57 0 55 0 55 0 990 0 551 0 566 0 533 0 432 0 397 0 263 0 260 0 258 27 1 74 3 140
14. with 1061 Ac tuator and FIELDVUE DVC6200 Digital Valve Controller Operational Versatility Self centering seat ring and rugged plug allow forward or reverse flow with tight shutoff in either flow direction Reverse flow direction helps move downstream turbulence away from shutoff surfaces Full 90 degree rotation removes valve plug from flowstream helping to reduce plug wear Seat ring and retainer are available in full and restricted port constructions and can easily be changed if capacity requirements change continued on page 3 5 www Fisher com Process Management Product Bulletin 51 3 V500 May 2012 Specifications Available Configuration E Flanged or flangeless valve assembly NPS 3 through 8 only with reversible metal or VTC ceramic seat ring and splined valve shaft Valve Sizes E NPS W 1 1 2 E 2 E4 E 6 and E 3 DN sizes are also available see tables 1 and 2 End Connection Style and Rating Raised face flanges W ring type joint flanges ASME B16 5 Valves with EN PN10 through PN100 flanges also available Various flangeless valve sizes are available in certain ASME and EN ratings See tables 1 and 2 for ASME and EN availability by valve size Maximum Inlet 2 Consistent with applicable ASME or EN flange ratings Maximum Pressure Drops 2 See tables 3 4 5 6 and 7 Shutoff Classification Class IV per ANSI F
15. 0 570 0 585 0 585 Cy 7 6 23 2 44 0 62 6 82 5 102 115 119 124 Ky 6 57 20 1 38 1 54 1 71 4 88 2 99 5 103 107 3 0 46 0 62 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 88 0 87 0 85 0 84 0 83 0 82 0 80 0 80 0 80 XT 0 578 0 494 0 511 0 540 0 529 0 515 0 518 0 533 0 526 Cy 9 31 37 0 73 5 111 144 171 192 208 221 Ky 8 05 32 0 63 6 96 0 125 148 166 180 191 4 0 45 0 61 0 72 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 94 0 90 0 85 0 84 0 82 0 80 0 77 0 77 0 77 XT 0 526 0 476 0 449 0 452 0 480 0 504 0 511 0 501 0 487 9 71 64 3 141 222 299 368 426 469 499 8 40 55 6 122 192 259 318 368 406 432 6 0 44 0 60 0 72 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 95 0 88 0 82 0 80 0 78 0 78 0 77 0 77 0 76 XT 0 504 0 459 0 432 0 422 0 429 0 436 0 432 0 422 0 413 34 6 142 290 447 592 716 822 911 958 29 9 123 251 387 512 619 711 788 829 8 0 43 0 59 0 72 0 80 0 87 0 92 0 96 0 99 1 00 FL 0 92 0 76 0 78 0 79 0 77 0 76 0 73 0 71 0 73 XT 0 544 0 446 0 426 0 429 0 429 0 46 0 419 0 410 0 429 19 Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 17 Fisher V500 Reverse Flow Level 4 Trim Full Port Valve Valve Rotation Degrees Medis Linear Coefficients Size Characteristic NPS 10 20 30 40 50 60 70 80 90
16. 1 7 70 3 91 7 78 6 50 0 23 1 26010316 83 4 83 4 70 3 834 78 6 493 23 1 31610371 78 3 78 3 70 3 78 3 78 3 483 224 37110427 56 9 56 9 56 9 56 9 56 9 46 9 217 29 to 204 68 9 55 2 41 4 41 4 41 4 20 7 15 2 204 to 260 68 9 55 2 41 4 41 4 41 4 20 7 15 2 CoCr A 260 to 316 68 9 55 2 41 4 41 4 41 4 20 7 15 2 316 to 371 68 9 55 2 41 4 41 4 41 4 207 15 2 37110427 56 9 55 2 41 4 41 4 41 4 207 15 2 46 to 204 68 9 55 2 41 4 41 4 41 4 207 15 2 20410260 65 8 55 2 41 4 41 4 41 4 207 15 2 CF8M SST CoCr A 26010316 62 4 55 2 41 4 41 4 41 4 207 15 2 316 to 371 59 6 55 2 41 4 41 4 41 4 207 15 2 37110427 57 2 55 2 41 4 41 4 41 4 207 15 2 PSI Senet a z 3 4 7 8 20 to 200 1500 1500 1020 1500 1140 750 350 200 to 300 1455 1455 1020 1455 1140 760 350 300 to 400 1410 1410 1020 1410 1140 740 345 544004 40010500 1330 1330 1020 1330 1140 725 335 500 0 600 1210 1210 1020 1210 1140 715 335 60010700 1135 1135 1020 1135 1135 700 325 700 to 800 825 825 825 825 825 680 315 20 to 400 1000 800 600 600 600 300 220 40010500 1000 800 600 600 600 300 220 CoCr A 500 to 600 1000 800 600 600 600 300 220 600 to 700 1000 800 600 600 600 300 220 700 to 800 825 800 600 600 600 300 220 50 to 400 1000 800 600 600 600 300 220 400 to 500 955 800 600 600 600 300 220 CF8M SST CoCr A 500 to 600 905 800 600 600 600 300 220 60010700 855 800 600 600 600 300 220 700 to 800 830 800 600 600 600 300 220 1 VTC trim is incompatible with water and steam above 180 C 36092
17. 232 342 457 552 614 646 Ky 23 4 64 3 121 201 296 395 477 531 559 2 8 0 48 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 92 0 91 0 88 0 76 0 69 0 66 0 62 0 60 0 58 0 636 0 494 0 494 0 490 0 442 0 388 0 369 0 339 0 311 1 Measured at 60 Port 2 Measured at 40 Port Product Bulletin V500 Valve 51 3 V500 D100054X012 May 2012 Table 16 Fisher V500 Forward Flow Level 4 Trim Full Port Modified Linear MOS TTE TE Valve Rotation Degrees AA NPS 10 20 30 40 50 60 70 80 90 130 1 91 4 68 7 3 917 10 3 11 0 11 5 11 6 Ky 260 1 65 4 05 6 31 7 93 8 91 9 52 9 95 10 0 1 0 49 0 64 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 98 0 87 0 87 0 85 0 86 0 85 0 86 0 84 0 668 0 574 0 529 0 566 0 616 0 668 0 685 0 628 0 616 1 46 3 79 8 12 13 4 17 9 20 7 22 4 24 0 250 1 26 3 28 7 03 11 6 15 5 17 9 19 4 20 8 21 6 1 1 2 0 48 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 86 0 86 0 82 0 84 0 80 0 80 0 79 0 79 0 79 XT 0 566 0 605 0 55 0 544 0 551 0 574 0 589 0 585 0 597 1 76 6 0 13 8 22 6 29 5 35 2 38 4 38 4 38 4 1 52 5 19 11 9 19 5 25 5 30 4 33 2 33 2 33 2 2 0 49 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 95 0 96 0 94 0 83 0 81 0 80 0 77 0 77 0 78 XT 0 819 0 555 0 501 0 480 0 533 0 566
18. 3 195 6 0 52 0 65 0 74 0 82 0 88 0 92 0 96 0 99 1 00 FL 0 77 0 79 0 77 0 75 0 69 0 64 0 63 0 58 0 58 0 640 0 369 0 476 0 410 0 381 0 357 0 336 0 284 0 278 19 8 55 8 125 222 323 413 488 549 569 17 1 48 3 108 192 279 357 422 475 492 2 8 0 48 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 75 0 77 0 78 0 75 0 70 0 68 0 70 0 68 0 70 0 459 0 581 0 462 0 394 0 375 0 381 0 391 0 391 0 391 1 Measured at 60 Port 2 Measured at 40 Port 22 Product Bulletin V500 Valve 51 3 V500 D100054X012 May 2012 23 Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Neither Emerson Emerson Process Management nor any of their affiliated entities assumes responsibility for the selection use or maintenance of any product Responsibility for proper selection use and maintenance of any product remains solely with the purchaser and end user Fisher FIELDVUE and ENVIRO SEAL are marks owned by one of the companies in the Emerson Process Management business unit of Emerson Electric Co Emerson Process Management Emerson and the Emerson logo are trademarks and service marks of Emerson Electric Co All other marks are the property of their respective owners The contents of this publication are presented for informational purposes only and while every effort has been made to ensure their accuracy they are not to be construed as warranties or guarantees express or implied regarding the
19. 71 0 71 0 cum 53 80 23 40 204 to 232 65 8 65 8 65 8 65 8 65 8 50 02 5170 1 517400 shaft only 2 ASME SA 479 Grade 520910 SST shaft only Pressure grops app opriate for both shaft materials 3 Level 3 trim is limited to a maximum temperature of 316 C Product Bulletin V500 Valve 51 3 V500 D100054X012 May 2012 Table 6 Maximum Allowable Shutoff Pressure Drops for Level 2 and 3 Trims Psi VALVE BODY BEARING TEMPERATURE VALVE BODY SIZE NPS MATERIAL MATERIAL oF 1 1 1 2 2 3 4 6 8 20 to 200 1500 1500 1500 1500 1200 750 350 200 to 300 1455 1455 1435 1455 1200 750 350 300 to 400 1410 1410 1360 1410 1200 740 345 400 to 500 1330 1330 1325 1330 1200 725 335 544004 500 to 600 1210 1210 1210 1210 1200 715 335 600 to 650 1175 1175 1175 1175 1175 700 325 650 to 700 1135 1135 1135 1135 1135 700 325 700 to 750 1010 1010 1010 1010 1010 680 315 750 to 800 825 825 825 825 825 680 315 20 to 400 1000 800 600 600 600 300 220 400 to 500 1000 800 600 600 600 300 220 500 to 600 1000 800 600 600 600 300 220 WCC steel CoCr A 600 to 650 1000 800 600 600 600 300 220 650 to 700 1000 800 600 600 600 300 220 700 to 750 1000 800 600 600 600 300 220 750 to 800 825 800 600 600 600 300 220 20 to 100 1500 1500 1500 1500 1300 800 350 100 to 200 1500 1500 1500 1500 1300 800 350 3500 200
20. 97 2 82 7 51 0 23 8 204 to 260 91 7 91 7 91 4 91 7 82 7 50 0 23 1 544004 260 to 316 83 4 83 4 83 4 83 4 82 7 49 3 23 1 316 to 343 81 0 81 0 81 0 81 0 81 0 48 3 22 4 343 to 371 78 3 78 3 78 3 78 3 78 3 48 3 22 4 371 to 399 69 6 69 6 69 6 69 6 69 6 46 9 21 7 399 to 427 56 9 56 9 56 9 56 9 56 9 46 9 21 7 29 to 204 68 9 55 2 41 4 41 4 41 4 20 7 15 2 204 to 260 68 9 55 2 41 4 41 4 41 4 20 7 15 2 260 to 316 68 9 55 2 41 4 41 4 41 4 20 7 15 2 CoCr A 316to 343 68 9 55 2 414 414 414 207 15 2 343 to 371 68 9 55 2 41 4 41 4 41 4 20 7 15 2 371 to 399 68 9 55 2 41 4 41 4 41 4 20 7 15 2 399 to 427 56 9 55 2 41 4 41 4 41 4 20 7 15 2 29 to 38 103 4 103 4 103 4 103 4 89 6 55 2 24 1 38 to 93 103 4 103 4 103 4 103 4 89 6 55 2 24 1 24 10 93 to 149 100 3 100 3 100 3 100 3 89 6 55 2 3310 composition lined 531600 149 to 204 97 2 97 2 97 2 97 2 89 6 2 53 8 1 23 40 204 to 232 91 7 91 7 91 7 91 7 89 6 50 02 215 46 to 204 68 9 55 2 41 4 41 4 41 4 20 7 15 2 204 to 260 65 8 55 2 41 4 41 4 41 4 20 7 15 2 260 to 316 62 4 55 2 41 4 41 4 41 4 20 7 15 2 CoCr A 316to 343 61 4 55 2 414 41 4 41 4 20 7 15 2 343 to 371 59 6 55 2 41 4 41 4 41 4 20 7 15 2 371 to 399 58 3 55 2 41 4 41 4 41 4 20 7 15 2 399 to 427 57 2 55 2 41 4 41 4 41 4 20 7 15 2 ssTG 46 10 38 99 3 99 3 99 3 99 3 89 6 55 2 24 1 38 to 93 85 5 85 5 85 5 85 5 85 5 55 2 24 1 24 10 9310149 77 3 77 3 77 3 77 3 77 2 53 1 3310 composition lined 531600 149 to 204 71 0 71 0 71 0
21. ANGES MOUNTING MOUNTING MOUNTING A3289 1 NOTE FOR DIMENSIONS OF VALVES WITH DIN OR OTHER END CONNECTIONS CONSULT YOUR EMERSON PROCESS MANAGEMENT SALES OFFICE Product Bulletin V500 Valve 51 3 V500 D100054X012 May 2012 Coefficients Table 12 Fisher V500 Forward Flow Level 1 2 and 3 Trims Full Port Modified Linear 22 Valve Rotation Degrees Characteristic NPS 10 20 30 40 50 60 70 80 90 1 22 2 89 5 05 7 63 9 94 11 3 11 8 12 0 12 2 1 06 2 50 4 37 6 60 8 60 9 77 10 2 10 4 10 6 Fa 1 0 49 0 64 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 89 0 89 0 88 0 85 0 85 0 85 0 85 0 85 0 85 0 480 0 497 0 508 0 548 0 597 0 632 0 636 0 612 0 593 2 07 6 15 11 5 16 6 20 7 23 5 25 3 26 1 26 6 Ky 1 79 5 32 9 95 14 4 17 9 20 3 21 9 22 6 23 0 Fq 1 1 2 0 48 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 95 0 85 0 85 0 84 0 84 0 84 0 84 0 84 0 84 0 770 0 476 0 483 0 555 0 616 0 636 0 632 0 601 0 589 4 11 8 73 16 7 27 0 37 2 43 4 45 8 46 2 46 2 Ky 3 56 7 55 14 4 23 4 32 2 37 5 39 6 40 0 40 0 Fg 2 0 49 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 97 0 92 0 84 0 79 0 77 0 75 0 75 0 74 0 74 0 439 0 442 0 442 0 422 0 422 0 462 0 452 0 442 0 442 8 80 22 7 43 3 71 3 96 8 116 130 138 142 7 61 19 6 37 5 61 7 83 7 100 112 119 123
22. CI 70 2 and IEC 60534 4 0 01 of valve capacity at full travel for either flow direction Leak rates for full and restricted port valves are based on full port valve capacities Reduced port valves seat at the full port diameter Construction Materials See table 8 for individual parts and table 9 for trim combinations Material Temperature Capability 2 See table 8 Flow Characteristic Modified linear Flow Direction Reverse flow standard Past valve plug and through seat ring tends to close the valve recommended for V500 Valve D100054X012 erosive service Forward flow Through seat ring and past valve plug tends to open the valve Flow Coefficients See the section titled Coefficients in this bulletin or Catalog 12 Flow Coefficient Ratio 3 100 to 1 Actuator Mounting Bi Right hand ll left hand as viewed from the upstream side of the valve Mounting position depends on the desired open valve plug position and flow direction required by operating conditions For more information see the Installation section Valve Plug Rotation Counterclockwise to close when viewed from actuator side of valve through 90 degrees of plug rotation Valve Actuator Action With diaphragm or piston rotary actuator field reversible between E push down to close extending actuator rod closes valve and E push down to open extending actuator rod opens valve Packing Constructions PTFE V Ring With one car
23. Combinations Plug Seat Ring Retainer Valve Shaft Bearing O Ring Body PTFE composition lined e 517400 alee Both Chrome plated 531600 917400 socra 1 p 531600 WCC only 544004 WCC NPS 1 thru 8 valves or 531600 PTFE composition lined Grade 531600 Both 520910 oCr PTFE composition lined 531600 Both CoCr A Nitrile 517400 Solid CoCr A NPS 1 darin Solid CoCr A Ew NPS 1 thru 4 valves and thru 4 valves and 517400 ah 2 531600 with WCC only 544004 Nitrile WCC 531600 with CoCrAface seat NPS 6 531600 NPS 6 8 valves d 8 val Fluorocarbon and 8 valves PTFE composition lined 531600 Grade 520910 Nitrile Fluorocarbon PTFE composition lined 282 531600 55 Both CoCr A Nitrile 317490 Fluorocarbon 531600 with CoCr A sleeve bore 222 3 Solid CoCr A NPS 1 and 1 1 2 544004 Nitrile WCC NPS 1 thru 8 valves Solid CoCr A Fluorocarbon NPS 2 thru 6 PTFE composition lined ore 31600 Grade T 520910 Both CoCr A Nitrile Fluorocarbon PTFE composition lined 531600 Both 531600 with VTC Solid NPS 1 thru 2 bore 517400 valves NPS 1 and 1 1 2 Mareen VTC plug surface bolted to valves 5 40 CoCr A hub titanium Solid VTC Solid CoCr A 544004 Nitrile WCC grade 5 cap screw and retainer with Fluorocarbon 531600 gasket NPS 3 VTC bore PTFE composition lined through 8 valv
24. L 0 80 0 79 0 73 0 63 0 58 0 55 0 56 0 51 0 48 Xr 0 172 0 284 0 406 0 357 0 345 0 322 0 300 0 289 0 283 1 71 5 33 11 3 18 4 24 7 28 6 30 1 30 7 31 0 Ky 1 48 4 61 9 77 15 9 21 4 24 7 26 0 26 6 26 8 1 1 2 0 48 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 75 0 74 0 70 0 66 0 64 0 63 0 63 0 63 0 63 XT 0 357 0 442 0 432 0 397 0 369 0 360 0 360 0 357 0 357 2 98 7 40 15 6 27 6 41 9 52 9 56 4 57 2 57 4 2 58 6 40 13 5 23 9 36 2 45 8 48 8 49 5 49 7 2 0 49 0 63 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 92 0 89 0 81 0 67 0 60 0 58 0 58 0 58 0 58 XT 0 480 0 476 0 462 0 384 0 308 0 265 0 265 0 265 0 265 Cy 7 19 21 4 47 0 75 4 105 122 132 134 141 Ky 6 22 18 5 40 7 65 2 90 8 106 114 116 122 3 0 46 0 62 0 73 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 80 0 80 0 77 0 71 0 66 0 65 0 65 0 65 0 65 XT 0 357 0 476 0 487 0 436 0 372 0 378 0 384 0 376 0 357 Cy 12 2 39 0 79 9 124 171 202 222 232 235 10 6 33 7 69 1 107 148 175 192 201 203 4 0 45 0 61 0 72 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 90 0 89 0 81 0 73 0 71 0 70 0 69 0 69 0 69 XT 0 522 0 544 0 487 0 456 0 406 0 406 0 416 0 423 0 416 15 1 72 4 156 251 351 438 534 638 717 13 1 62 6 135 217 304 379 462 552 620 6 0 44 0 60 0 72 0 81 0 87 0 92 0 96 0 99 1 00 FL 0 85 0 85 0 82 0 77 0 70 0 66 0 61 0 57 0 51 XT 0 416 0 597 0 518 0 522 0 452 0 388 0 336 0 270 0 219 33 5 143 302 485 663 798 871 897 986 29 0 124 261 420 573 690 753 776 853 8 0 43 0 59 0 72 0 80 0 87 0 92 0 96
25. T pini A B 5 Flanged Flangeless Pressure Class Pressure Class NPS ey 5 y Hi DIA CL150 CL300 CL600 CL150 00 CL600 mm kg 1 102 108 51 57 187 126 12 7 118 11 5 4 5 9 5 9 1 1 2 114 122 57 63 187 135 15 9 118 14 8 6 9 5 10 2 124 124 62 62 187 151 15 9 118 14 9 5 11 13 25 4 3 165 165 83 83 213 200 25 4 191 152 32 14 19 24 26 16 16 16 4 194 194 97 97 208 216 31 8 235 46 18 36 42 50 34 34 34 38 1 5 8 Inch 6 229 229 114 114 208 270 38 1x31 8 235 46 11 UNC 54 69 93 50 50 8 243 243 121 121 208 318 38 1 235 46 ae 79 98 135 57 68 VALVE SIZE NPS Inches Pounds 1 4 00 4 25 2 00 2 25 7 38 4 97 1 2 4 62 0 45 12 13 13 1 1 2 4 50 4 75 2 25 2 50 7 38 5 31 5 8 4 62 0 56 19 21 23 2 4 88 4 88 2 44 2 44 7 38 5 94 5 8 4 62 0 56 21 25 28 3 6 50 6 50 3 25 3 25 8 44 7 88 1 6 00 1 25 0 56 42 52 57 35 35 35 4 7 62 7 62 3 81 3 81 8 19 8 50 1 1 4 9 25 1 81 0 69 79 93 111 75 75 75 1 1 2 5 8 Inch 6 9 00 9 00 4 50 4 50 8 19 10 6 14 2 x 1 1 4 9 25 1 81 11UNC 120 152 204 110 110 5 8 Inch 8 9 56 9 56 4 78 4 78 8 19 12 5 1 1 2 9 25 1 81 11 UNC 175 217 298 125 150 1 Shaft diameter versus spline diameter Figure 5 Fisher V500 Rotary Control Flanged and Flangeless Valve Dimensions refer to table 11 T CL150 CL300 5 OR CL600 FLANGELESS NPS1 1 1 2AND2 NPS3AND4 NPS6AND8 OR WITH RF OR BODY BODY BODY FL
26. TEMPERATURE VALVE BODY SIZE NPS MATERIAL MATERIAL 1 1 1 2 2 3 4 6 8 29 to 149 68 9 55 2 41 4 41 4 41 4 41 4 24 1 544004 14910204 68 9 55 2 41 4 41 4 41 4 41 4 23 8 20410 316 68 9 55 2 41 4 41 4 41 4 41 4 23 1 29 to 204 68 9 55 2 41 4 41 4 41 4 20 7 15 2 CoCr A 204 to 260 68 9 55 2 41 4 41 4 41 4 20 7 15 2 260 to 316 68 9 55 2 41 4 41 4 41 4 20 7 15 2 WCC steel 29 to 93 68 9 55 2 41 4 41 4 41 4 41 4 24 1 2410 93 to 149 68 9 55 2 41 4 41 4 41 4 41 4 53 10 composition 23 80 lined 531600 14910204 68 9 55 2 41 4 41 4 41 4 41 4 5510 23 40 20410 260 68 9 55 2 41 4 41 4 41 4 41 4 2172 46 to 20 68 9 55 2 41 4 41 4 41 4 20 7 15 2 CoCr A 204 to 260 65 8 55 2 41 4 41 4 41 4 20 7 15 2 260 to 316 62 4 55 2 41 4 41 4 41 4 20 7 15 2 46 to 93 68 9 55 2 41 4 41 4 41 4 41 4 24 1 24 10 CF8M SST 93 to 149 68 9 55 2 41 4 41 4 41 4 41 4 53 10 composition 23 80 lined 531600 149 to 204 68 9 55 2 41 4 41 4 41 4 41 4 55 10 23 40 204 to 260 65 8 55 2 41 4 41 4 41 4 41 4 2172 1 517400 shaft only 2 ASME SA 479 Grade 520910 SST shaft only Pressure drops appropriate for both shaft materials Product Bulletin V500 Valve 51 3 V500 D100054X012 May 2012 Table 4 Maximum Allowable Shutoff Pressure Drops for Level 1 Trim Psi VALVE BODY BEARING VALVE BODY SIZE NPS MATERIAL MATERIAL ib 1 1 1 2 2 3 4 6 8 20 to 300
27. V500 Valve D100054X012 Product Bulletin 51 3 V500 May 2012 Fisher V500 Rotary Control Valve The Fisher V500 eccentric plug rotary control valve controls erosive coking and other hard to handle fluids providing either throttling or on off operation The flanged and flangeless valves feature streamlined flow passages rugged metal trim components and a self centering seat ring figures 1 and 2 With these components the V500 rotary control valve combines globe valve ruggedness with the efficiency of a rotary valve Matched with a Fisher power or manual actuator the V500 rotary control valve dependably controls fluids in many process industries Unless otherwise noted all NACE references are to NACE 0175 2002 Features m Resists Damage from Erosive Flow Valve assembly is specifically designed to combat the process of erosion Streamlined flow passages rugged components and a wide choice of erosion resistant trim materials all promote long dependable service life in erosive applications Long Seat Life Path of eccentric plug figure 4 minimizes contact with seat ring when opening reducing seat wear and friction When the valve plug rotates into the seat ring a self lapping action occurs improving the fit between shut off surfaces Full port 531600 CoCr A or VTC seat ring has two shutoff surfaces and can be easily reversed reducing downtime W8380 2 Fisher V500 Flanged Rotary Control Valve
28. bon filled PTFE conductive packing ring in single double or leak off arrangements PTFE Bound Composition With one graphited composition conductive packing ring in single double or leak off arrangements Graphite Ribbon Packing Rings In single double or leak off arrangements continued V500 Valve D100054X012 Specifications continued Shaft Diameters See figure 5 Dimensions and Approximate Weights See figure 5 face to face dimensions conform to ISA 575 04 and IEC 60534 3 2 Product Bulletin 51 3 V500 May 2012 Options Wi Restricted trim retainer and seat ring for low flow applications sealed bearing constructions lil Line flange bolts for flangeless valves ll Purged bearings ENVIRO SEAL packing system see figure 3 and bulletin 59 3 041 ENVIRO SEAL Packing Systems for Rotary Valves D101638X012 for more information 1 The reversible seat is not available in every trim material Consult your Emerson Process Management sales office 2 The pressure or temperature limits in the referenced tables or figures and in any applicab 3 Ratio of maximum flow coefficient to minimum usable flow coefficient May also be called Features continued m Easy Installation Integral valve body flanges mate with many different classes of pipeline flanges satisfying a variety of piping requirements Flanges help to eliminate exposed line flange bolting shorten alignment and installation time and pro
29. es NPS 2 thru 8 531600 set valves Grade 520910 Bon CoCr A Nitrile Fluorocarbon 1 NACE 175 2002 trim constructions are available GU CU Emerson Process Management sales office 2 VIC trim is incompatible with water and steam above 180 C 360 F V500 Valve D100054X012 Table 10 Actuator Mounting Selections with Action and Open Plug Position Options OPEN PLUG POSITION MOUNTING ACTION Forward Flow Reverse Flow D PDTC Below shaft Above shaft PDTO Below shaft Above shaft einen PDTC Above shaft Below shaft PDTO Above shaft Below shaft 1 PDTC Push down to close extending actuator rod closes valve PDTO Push down to open extending actuator rod opens valve Installation The V500 control valve may be installed in any position However for best shutoff performance a position with the shaft horizontal is recommended The control valve may be installed in forward or reverse flow direction Forward flow through the seat ring and past the plug tends to open the valve reverse flow past the plug and through the seat ring tends to close the valve The reverse flow direction is recommended for erosive applications Specific operating conditions may require a specific combination of push down to close or open actuator motion and open valve plug position above or below the shaft To satisfy specific operating require
30. ments the complete control valve package valve and actuator can be assembled and installed in different ways providing eight options for actuator motion and open plug position Table 10 and the appropriate actuator bulletin describe possible assembly and installation options For assistance in selecting the appropriate combination of actuator action and open valve position consult your Emerson Process Management sales office Dimensions are shown in figure 5 Valve Information To determine the required valve ordering information refer to the Specifications table Review the information under each specification and in the referenced tables Product Bulletin 51 3 V500 May 2012 Actuator and Accessory Information Refer to the specific actuator and accessory bulletins for required ordering information Figure 4 Eccentric Rotation VALVE BODY CENTERLINE VALVE SHAFT CENTERLINE VALVE BODY CENTERLINE VALVE SHAFT CENTERLINE VALVE BODY CENTERLINE VALVE SHAFT CENTERLINE B1879 1 The Size 20 Fisher 1052 actuator is not available for use with V500 rotary control valves because the sizing of this combination is marginal Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 11 Fisher V500 Rotary Control Flanged and Flangeless Valve Dimensions DIMENSIONS APPROXIMATE WEIGH
31. mote secure valve installations and piping integrity Flangeless valves are automatically self centering on line bolting for easy installation Simple Assembly and Maintenance No special orientation precision clamping or repetitive centering of valve plug and seat ring is required when tightening the retainer promoting accurate alignment and easy assembly Improved Environmental Capabilities The optional ENVIRO SEAL packing systems are designed with very smooth shaft surfaces and live loading to provide improved sealing The seal of the ENVIRO SEAL system can restrict emissions to less Contents Features a sete hoe eis 1 Specifications 2 Installation 13 Coefficients 15 Tables Valve Size Pressure Ratings and Flange Compatibility 4 le code limitation should not be exceeded rangeability than the EPA Environmental Protection Agency limit of 100 ppm parts per million m Sour Service Capability Trim and bolting materials are available for applications handling sour service These materials comply with the requirements of NACE 175 2002 Rugged Construction Durable solid metal or VTC seat ring and valve plug shut off tightly without deforming plug arms or employing thin ball seals Oversized shaft diameters and rugged trim parts allow high
32. pressure drops Reliable Performance Seat ring design figure 2 self centers self laps and dynamically aligns with plug giving excellent cycle life Sealed metal bearings help prevent particle buildup and valve shaft seizure in erosive applications m Choice of Construction Materials Plug seat ring and retainer are available in four levels of hardness for selection of erosion resistance Maximum Allowable Shutoff Pressure Drops 6 Material Temperature Capabilities 11 Material Combinations 12 Actuator Mounting Selections 13 Dimensions 14 Product Bulletin 51 3 V500 V500 Valve May 2012 D100054X012 Table 1 Valve Size ASME Pressure Ratings and Flange Compatibility X indicates availability FLANGED FLANGELESS VALVE SIZE NPS CL300 CL600 CL150 CL300 CL600 1 X X X B 1 1 2 7s T 2 2 x x x E 2 3 x x x x 4 X x X X 6 x X X X 5 8 x x x x x Table 2 Valve Size EN Pressure Ratings and Flange Capability X indicates availability VALVE Flanged Flangeless SIZE DN PN 10 P PN 25 PN 40 PN 63 PN 100 PN 10 PN 16 PN25 PN 40 PN 63 PN 100 o z 25 40 50 80 100 150 200 x KK x lt x lt x OX
33. products or services described herein or their use or applicability All sales are governed by our terms and conditions which are available upon request We reserve the right to modify or improve the designs or specifications of such products at any time without notice Emerson Process Management Marshalltown lowa 50158 USA Sorocaba 18087 Brazil Chatham Kent ME4 4QZ UK Dubai United Arab Emirates Singapore 128461 Singapore www Fisher com EM ERSON Process Management 1984 2012 Fisher Controls International LLC All rights reserved Process Mana g ement
Download Pdf Manuals
Related Search