Delfield 48000 Series User's Manual
Contents
1. HEATER 3 S b tata ye E T y HEATER 5 8 HEATER 6 18 o MA HEATER 4 PILOT LIGHT yx 1 PILOT LIGHT MA pacis dal cC Sea 10 line wires 7 to additional food warmers H1 1000 W 120V SIP or 1000 1222 W T on 208 230 V En heating element infinite control with OFF position 208 240V 3 PHASE MODELS Li G L2 L3 INFINITE INFINITE CONTROL HEATER 1 CONTROL HEATER 3 yx Sa AL HEATER 4 HEATER 6 p ES YN HEATER 2 bm d MA 5 HET ILOT LIGHT xX For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com 9 Delfield WIRING DIAGRAMS Single Phase Three Phase TEMPERATURE CONTROL Delfield TEMPERATURE CONTROL LOW WATER LIGHT G F14 AND 48000 Series Service and Installation Manual FI4EW SERIES 120 208 OR 120 240 VOLT SINGLE PHASE SUPPLY WHITE NEUTRAL L2 BLACK L1 RED GREEN GROUND TO CASE pul BLACK WATER LEVEL CONTROL BOARD POWER RELAY 120VAC COIL PILOT LIGHT 219 4095 THERMAL OVERLOAD ON HEATER WATER FILL SOLENOID OPTIONAL 120 208 OR 120 240 VOLT THREE PHASE SUPPLY WHITE NEUTRAL GREEN GROUND TO CASE L2 BLACK Li RED L3 BLUE SW2. DANGER INSTALLATION 48300 SERIES ELECTRIC Installation should only be done by personnel Plumbing certified and licensed to install and maintain A waste connection is provided 26 5 67 3cm above the floor electrical appliances 5 25 13 3cm from the right end You must supply the required CAUTION 1 NPT connection Location Do not install the hot food table near any combustible objects or Electrical connection surfaces affected by heat or moisture Connections must be made in accordance with all applicable local codes and or the National Electrical Leveling Code Refer to the wiring diagrams on page 10 This unit must be level both front and back and left to right in DANGER order to maintain an equal water depth throughout the wells 9 C D l Fi e For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com 3 F14 AND 48000 Series Service and Installation Manual OPERATION F14El amp 48300 SERIES ELECTRIC Before the unit is used the first time for serving turn the temperature knob to 10 and heat the well for 20 to 30 minutes Do not be alarmed if smoke appears this preheat should burn off any residue or dust on the heating element When using thick sauces always operate the hot food well filled with water This will provide a more uniform temperature for the sauce Steam can cause serious burns Always wear some type of protective covering on your hands and arms
3. when removing lids or pans from the unit Lift the lid wear Or pan in a way that will direct escaping steam away from your face and body Never place food directly into the well Always use pans CAUTION Although these models may be operated either with or without water in the wells wet operation is recommended Always place covers on pans when not serving to prevent food from drying out and to reduce your operating cost For most efficient operation when empty keep covered insets in each well during preheating and when the well is not in use Do not put food down drain Wet operation 1 Fill food well with two inches of water For quicker pre heating use hot water to fill the well 2 Turn the control to HIGH and pre heat the warmer SIEPS for 30 minutes 3 After pre heating set the control to your desired serving temperature Dry operation 1 Pre heat the well on HIGH for approximately 15 minutes 2 After pre heating set the control to your desired STEPS serving temperature Only 6 15 2cm deep insets should be used with a dry food well When operated dry the bottom of the food well will discolor A mild abrasive cleaner is recommended to clean this discoloration Temperature Water in wells 160 F to 180 F Product iti pans b e s 140 F to 160 F OPERATION F14EW SERIES ELECTRIC These units must be operated with water in the well If operated dry a low water safety sw
4. Protection Plan and any applicable Delfield Service Labor Contract the Original Purchaser agrees and acknowledges that no other warranties are offered or provided in connection with or for the Motor Compressor or any part thereof In no event will Delfield be liable for special incidental or consequential damages or for damages in the nature of penalties Delfield F14 AND 48000 Series Service and Installation Manual NOTES 9 C D l Fi e For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com 1 5 AUTHORIZED PARTS DEPOTS NORTH AMERICA 1 The Delfield Company 980 South Isabella Road Mt Pleasant MI 48858 800 733 8829 989 773 7981 989 773 3210 FAX custom parts direct from Delfield 5 Contract Ice 2 A I S Commercial Parts amp Service 3 Appliance Installation Service 4 Pacific Coast Parts 1816 West 26th Street Erie PA 16508 1149 800 332 3732 814 456 3732 814 452 4843 FAX serves MD NJ OH PA VA WV 6 E M C 0 Sales amp Distributors 14450 Ewing Ave S 100 Burnsville MN 55306 800 422 2823 952 894 4427 952 894 2164 FAX serves IA MN MT ND SD WI 9 Global Parts and Supplies 3909 St Timothy Lane St Ann MO 63074 800 972 7670 314 427 7477 314 427 8190 FAX serves AR IA IL KS KY MO NE OK TX NM LA 10 Hawkins Commercial Appl Serv 1336 Main Street 15024 Staff Court Buffalo NY 14209 Ga
5. motor assembly This warranty does not cover labor charges incidental to the replacement of parts This warranty further does not include any equipment to which said condensing unit is connected such as cooling coils temperature controls or refrigerant metering devices This warranty shall be void if the Motor Compressor in Delfield s sole judgement has been subjected to misuse neglect alteration or accident operated contrary to the recommendations specified by the Unit manufacturer repaired or altered by anyone other than Delfield in any way so as in Delfield s sole judgment to affect its quality or efficiency or if the serial number has been altered defaced or removed This Warranty does not apply to a Motor Compressor in any Unit that has been moved from the location where it was originally installed The addition of methyl chloride to the condensing unit or refrigeration system shall void this warranty 14 For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com General Conditions Delfield shall not be liable in any manner for any default or delay in performance hereunder caused by or resulting from any contingency beyond Delfield s control including but not limited to war governmental restrictions or restraints strike lockouts injunctions fire flood acts of nature short or reduced supply of raw materials or discontinuance of any part or the Motor Compressor by the unit manufac
6. only NUMBER VOLTAGE AMPS WEIGHT F14EW232 2 21 0 24 0 316 105 143 kg Electric with individual wells wet or dry operation F14EW348 3 21 0 24 0 440 Ibs 199 kg 48334 120 208 17 0 11 0 179 Ibs 81 kg F14EW460 4 21 0 24 0 500 105 227 kg 48348 208 230 15 0 16 0 252 105 114 kg F14EW572 5 42 0 48 0 560 105 254 kg 48362 208 230 20 0 22 0 326 Ibs 148 kg F14EW688 6 42 0 48 0 660 105 299 kg 48376 208 230 24 0 27 0 400 Ibs 181 kg Electrical connections are 120 240 volt or optional 120 208 volt 120 volt circuit is required for the low water cutoff INSTALLATION F14El amp F14EW SERIES ELECTRIC Installation should only be done by personnel Plumbing certified and licensed to install and maintain Hot water supply connection is provided 36 91 4cm above the electrical appliances floor 3 12 7 9cm from the front left end at the rear of the unit CAUTION You must supply the required 1 2 NPT connection Location A waste connection is provided 25 63 5cm above the floor 7 5 Do not install the hot food table near any combustible objects or 19cm from the right end You must supply the required 1 NPT surfaces affected by heat or moisture connection Leveling Electrical connection This unit must be level both front and back and left to right in Connections must be made in accordance with all order to maintain an equal water depth throughout the wells applicable local codes and or the National Electrical Code Refer to the wiring diagrams on page 10
7. 2L Delfield F14 and 48000 SERIES Service and Installation Manual Please read this manual completely before attempting to install or operate this equipment Notify carrier of damage Inspect all components immediately See page 3 Hot Food Tables Effective May 2003 F14 AND 48000 Series Service and Installation Manual CONTENTS SERIAL 2 RECEIVING amp INSPECTING 2 SPECIFICATIONS ett eterne diay 3 INSTALLATION FI4EW amp F14EI electric esse 3 48300 Series 3 F14QW 0 5 eterne eta 5 OPERATION F14EI amp 48300 Series 4 F14EW electric sss 4 BEQUEM 5 MAINTENANCE eeeeeennet nnns 5 GAS BURNER ASSEMBLY F14GW Series 6 DELFIELD FOOD WARMER DFW ASSEMBLIES with thermostatic controls 7 WITH INNTE COMBO usce tco ectetuer tenes 8 REPLACEMENT PARTS LISTS 9 WIRING DIAGRAMS F14EI amp 48300 Series 10 PIAEW elactriC tne Aenea 11 STANDARD WARRANTY e 13 14 AUTHORIZED PARTS 5 back cover SERIAL NUMBER LOCATION The serial nu
8. DELFIELD AUTHORIZED REPRESENTATIVE TRAVELS TO THE INSTALLATION ADDRESS TO PERFORM WARRANTY SERVICE THE SERVICE REPRESENTATIVE WILL ADVISE CUSTOMER THE WARRANTY IS VOID SUCH SERVICE CALLS WILL BE BILLED TO CUSTOMER AT THE AUTHORIZED SERVICE CENTER S THEN APPLICABLE TIME AND MATERIALS RATES CONSIDER CUSTOMER MAY INITIATE A SERVICE AGREEMENT WITHOUT PARTS COVERAGE If shipment of a replacement part is requested prior to the arrival in the Delfield factory of the part claimed to be defective the Original Purchaser must accept delivery of the replacement part of a C O D basis with credit Delfield being issued after the part has been received and inspected at Delfield s plant and determined by Delfield to be within this warranty Under no condition does this warranty give the Original Purchaser the right to replace the defective Unit with a complete Unit of the same manufacturer or of another make Unless authorized by Delfield in writing this warranty does not permit the replacement of any part including the motor compressor to be made with the part of another make or manufacturer No claims can be made under this warranty for spoilage of any products for any reason including system failure The installation contractor shall be responsible for building access entrance and field conditions to insure sufficient clearance to allow any hood s vent s or Unit s if necessary to be brought into the building Delfiel
9. ITCH RED WATER LEVEL CONTROL BOARD POWER RELAY 120VAC COIL Xov 18 71 PILOT LIGHT 219 4095 WATER FILL SOLENOID THERMAL OVERLOAD ON HEATER THREE PHASE IMMERSION HEATER OPTIONAL 11 For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com F14 AND 48000 Series Service and Installation Manual STANDARD LABOR GUIDELINES TO REPAIR OR REPLACE PARTS ON DELFIELD EQUIPMENT Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage maximum of 1 hour is allowed to diagnose a defective component maximum of 1 hour is allowed for retrieval of parts not in stock maximum travel distance of 100 miles round trip and 2 hours will be reimbursed Overtime installation start up normal control adjustments general maintenance glass breakage freight damage and or correcting and end user installation error will not be reimbursed under warranty unless pre approved with a Service Work Authorization from Delfield You must submit the number with the service claim LABOR OF 1 HOUR IS ALLOWED TO REPLACE Thermostat Contactor Relay e Infinite Switch e Transformer Door Jamb Switch Evaporator Condenser Fan Motor and Blade e Solenoid Coil Circulating Fan Motor and Blade Hi limit Thermal Protector Switch Microprocessor Control e Fan Delay Defrost Termination Switch Wat
10. Iti Dafis coL kt bx ts 140 F to 160 F 9 Delfield F14 AND 48000 Series Service and Installation Manual OPERATION F14GW SERIES GAS Gas connection Only qualified and trained personnel should attempt to connect the gas Wear a face shield during this e procedure Delfield is not responsible for injuries DANGER resulting from attempts connect the gas gt You must supply the necessary connection A pressure regulated 1 2 FPT 20 000 BTU gas supply is required A gas regulator is supplied installed Be sure the connection is made to maintain flow through the safety valve in the direction indicated by the arrow stamped on the valve case See the gas burner assembly diagram on page 6 gt After installation check for leaks using a soap solution Mix some water with dish or other soap and supply a small amount to the connection If bubbles appear the connection is not correct and must be reinstalled before operating the unit The pilot valve supplied is sized for use with natural gas If LP gas is to be used the pilot fitting must be changed from the standard 021 orifice to a 011 orifice This orifice is supplied in a plastic pouch attached to the plate shelf gt Gas hot food tables must be operated with water in the well Dry operation of this unit will cause distortion of the well or other serious damage Steam can cause serious burns Always wear some type of protective coverin
11. MK00100 Complete assembly 115V thermostat w o drain XMK00101 Complete assembly 208V thermostat w drain XMK00102 Complete assembly 208V thermostat w o drain XMK00103 1 Deflector plate GMKO00061 2 Bottom cover GMKO00062 3 Food well with drain 016 0014 Food well without drain 016 0015 4 Screw 932 1353 5 Element 115V 219 4006 Element 208V 219 4007 6 Screws 6 932 1379 7 Insulation 343 4663 8 Thermostat control knob 323 4556 9 Thermostat 200 550F 219 4012 10 Pilot light red 115V 219 4190 DRAIN Pitot light amber 230V 219 4095 OPTIONAL 11 Drain cover GMK00063 12 Screws 2 932 1353 NOTE If you need four or more component parts you must buy a complete assembly Pe C D l Fi e For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com 7 F14 AND 48000 Series Service and Installation Manual DELFIELD FOOD WELL DFW ASSEMBLY wiTH INFINITE CONTROL INFINITE CONTROL KEY PART NAME DELFIELD PART Complete assembly 115V infinite w drain XMK00104 Complete assembly 115V infinite w o drain XMK001 05 Complete assembly 208V infinite w drain XMK00068 Complete assembly 208V infinite w o drain XMK001 06 1 Deflector plate GMKO00061 2 Bottom cover GMKO00062 3 Food well with drain 016 0014 Food well without drain 016 0015 4 Screw 932 1353 5 Element 115V 219 4006 Element 208V 219 4007 6 Screws 2 932 1379 7 Insulation 343 4663 8 Thermostat non adj
12. d will not be responsible for structural changes or damages incurred during installation of the Unit or any exhaust system Delfield shall not be liable in any manner for any default or delay in performance hereunder caused by or resulting from any contingency beyond Delfield s control including but not limited to war governmental restrictions or restraints strike lockouts injunctions fire flood acts of nature short or reduced supply of raw materials or discontinuance of the parts by the original part manufacturer Except as provided in any Additional Four Year Protection Plan if applicable and the Service Labor Contract if applicable the foregoing is exclusive and in lieu of all other warranties whether written or oral express or implied This warranty supersedes and excludes any prior oral or written representations or warranties Delfield expressly disclaims any implied warranties of merchantahility fitness for a particular purpose of compliance with any law treaty rule or regulation relating to the discharge of substances into the environment The sole and exclusive remedies of any person relating to the Unit and the full liability of Delfield for any breach of this warranty will be as provided in this warranty Other than this Delfield Standard One Year Limited Warranty any applicable Delfield Additional Four Year Protection Plan or applicable Delfield Service Labor Contract the Original Purchaser agrees and ackno
13. e above listed Delfield product the Unit The Delfield Company Delfield also agrees to repair or exchange with similar or interchangeable parts in design and capacity at Delfield s option the defective Motor Compressor contained in the Unit the Motor Compressor or any part thereof for the Original Purchaser only at any time during the four 4 years following the initial one 1 year period commencing on the date of installation for the Original Purchaser Failure of the Original Purchaser to register the registration card containing the Original Purchasers name address date of installation model number and serial number of the Unit containing the Motor Compressor within 30 days from the date of installation shall void this warranty This additional warranty is only available if the Motor Compressor is inoperative due to defects in material or factory workmanship as determined by Delfield in its sole judgement and discretion The Original Purchaser shall be responsible for returning the defective Motor Compressor to Delfield prepaid F O B at the address shown on the back cover of this manual The term Original Purchaser as used herein means that person firm association or corporation for whom the Unit was originally installed The term Motor Compressor as used herein does not include unit base air or water cooled condenser receiver electrical accessories such as relay capacitors refrigerant controls or condenser fan
14. er Level Sensor Probe Compressor Start Components and Overload Protector Door Hinges Locks and Gaskets e Defrost Timer e Condensate Element Thermometer Springs Lowerator e Gear Box LABOR OF 2 HOURS TO REPLACE Drawer Tracks Cartridges Pressure Control e Solenoid Valve Defrost Element Heating Element Locate Repair Leak LABOR OF 3 HOURS TO REPLACE EPR or CPR Valve Condenser or Evaporator Coil Expansion Valve LABOR OF 4 HOURS TO REPLACE e Compressor This includes recovery of refrigerant and leak check 35 00 maximum reimbursement for refrigerant recovery includes recovery machine pump torch oil flux minor fittings solder brazing rod nitrogen or similar fees REFRIGERANTS e R22 A maximum of 4 00 Ib or 25 oz will be reimbursed e R134A A maximum of 5 00 Ib or 31 oz will be reimbursed R404A A maximum of 12 00 Ib or 75 oz will be reimbursed 9 1 2 For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com D l Fi F14 AND 48000 Series Service and Installation Manual STANDARD ONE YEAR WARRANTY One year parts 90 days labor The Delfield Company Delfield warrants to the Original Purchaser of the Delfield product herein called the Unit that such Unit and all parts thereof will be free from defects in material and workmanship under normal use and service for a period of one 1 year from t
15. g on your hands and arms when removing lids or pans from the unit Lift the lid or pan in a way that will direct escaping steam away from your face and body Never place food directly into the empty well always use pans Never operate burners without water in the WEAR well o Always place covers on pans when not serving to prevent food from drying out and to reduce your operating cost For most efficient operation when empty keep covered insets in each well during preheating and when the well is not in use Lighting the pilot Only qualified and trained personnel should attempt to light the pilot Wear a face shield during this procedure DANGER Delfield is not responsible for injuries resulting from attempts to light the pilot WEAR 1 Open the gas valve supplying fuel to the hot food table 2 Push down the reset button on the pilot valve which is located behind the control panel and light the pilot 3 Continue to hold down the reset button for 30 to 45 seconds or until the pilot continues to burn when the button is released 4 During the reset cycle gas will flow to both the main and pilot burners 5 If the pilot is not lit after steps 1 4 have been completed close the gas valve and wait for at least 5 minutes before attempting to light the pilot again This should allow any excess gas in the air around the unit to dissipate If you are using LP gas wait at least 15 minutes any excess gas will fall
16. he date of shipment of the Unit to the Original Purchaser or if the Original Purchaser returns the warranty card completely filled out including the date of installation within thirty 30 days of receipt of the Unit one 1 year from the date of installation During this one year warranty period Delfield will repair or replace any defective part or portion there of returned to Delfield by the Original Purchaser which Delfield determines was defective due to faulty material or workmanship The Original purchaser will pay all labor crating freight and related costs incurred in the removal of the Unit of defective component and shipment to Delfield except that during a period of either ninety 90 days from the date of shipment of the Unit to the Original Purchaser or if the Original Purchaser returns the warranty card completely filled out including the date of installation within thirty 30 days of receipt of the Unit ninety 90 days from the date of installation Delfield will pay all related labor costs Delfield will pay the return costs if the Unit or part thereof was defective The term Original Purchaser as used herein means that person firm association or corporation for whom the Unit was originally installed This warranty does not apply to any Unit or part thereof that has been subjected to misuse neglect alteration or accident such as accidental damage to the exterior finish operated contrary to the recommendations s
17. itch will interrupt the electric supply to the heater to prevent heater failure If the low water safety switch shuts off power turn the control to the OFF position If the water level is below the heating element allow the well to cool completely then refill with water Reactivate the well by turning the control ON and resetting to the previous temperature Continuous interruption of power due to a low water level may disable the heater permanently Pouring water on a hot heating element will damage it Steam can cause serious burns Always wear some type of protective covering on your hands and arms when removing lids or pans from the unit Lift the lid or pan in a way that will direct escaping steam away from your face and body Never place food directly into the well Always use pans Always place covers on pans when not serving to WEAR __ Prevent food from drying out and to reduce your operating cost CAUTION For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com For most efficient operation when empty keep covered insets in each well during preheating and when the well is not in use Wet operation 1 Fill food well with four inches of water heater must be covered by water For quicker pre heating use hot water to fill the well STEPS 2 Set the control to your desired serving temperature Temperature Water in wells tatis 160 F to 180 F Product
18. mber on all 14 Series and 48000 Series hot food tables is printed on the tag located on the plate shelf Always have the serial number of your unit available when calling for parts or service A complete list of authorized Delfield parts depots is shown on the back cover of this manual 2003 The Delfield Company rights reserved Reproduction without written permission is prohibited Delfield is a registered trademark of The Delfield Company RECEIVING AND INSPECTING THE EQUIPMENT Even though most equipment is shipped crated care should be taken during unloading so the equipment is not damaged while being moved into the building 1 Visually inspect the exterior of the package and skid or container Any damage should be noted and reported to the delivering carrier immediately 2 If damaged open and inspect the contents with the carrier 3 In the event that the exterior is not damaged yet upon opening there is concealed damage to the equipment notify the carrier Notification should be made verbally as well as in written form 4 Requestan inspection by the shipping company of the damaged equipment This should be done within 10 days from receipt of the equipment 2 For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com 5 Check the lower portion of the unit to be sure legs or casters are not bent Also open the compressor compartment housing and visually inspect the refrigera
19. oari NABA iias didi Float switch nig T COSTNENE DOA MOE 40909 Gate Valve 1 Pier eeu at 354 7487 Knob thermostatic control 323 4556 Legs 6 w mounting plate 323 4645 Light pilot 250V 219 4095 Relay socket KU12 219 4133 Relay 8501 12 219 4132 Immersion heater 5KW 240V 12 0 amps 3 phase 219 3972 Immersion heater 5KW 208V 24 0 amps 1 phase 219 3973 Immersion heater 5KW 240V 20 8 amps 1 phase 219 3974 Immersion heater 5KW 208V 13 9 amps 3 phase 219 3975 Thermostat 22i oon ad 219 4202 Gas burner assembly see page 6 F14GW Series gas PART NAME DELFIELD PART PAU GOL fees e RO Hie ave 323 4075 Gate Valve 1 be been 354 7487 Legs 6 w mounting plate 323 4645 C D Fi e For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com 9 F14 AND 48000 Series Service and Installation Manual WIRING DIAGRAMS F14El AND 48300 SERIES 120 or 208 240V SINGLE PHASE MODELS NEUTRAL ON 120V MODELS LI G L2 INFINITE CONTROL HEATER 1 HEATER 2 BN AT PILOT LIGHT
20. pecified by Delfield or repaired or altered by anyone other than Delfield in any way so as to in Delfield s sole judgement affect its quality or efficiency This warranty does not apply to any Unit that has been moved from the location where it was originally installed This warranty also does not cover the refrigerator drier or the light bulbs used in the Unit The warranty is subject to the user s normal maintenance and care responsibility as set forth in the Service and Installation Manual such as cleaning the condenser coil and is in lieu of all other obligations of Delfield Delfield neither assumes nor authorizes any other person to assume for Delfield any other liability in connection with Delfield s products Removal or defacement of the original Serial Number or Model Number from any Unit shall be deemed to release Delfield from all obligations hereunder or any other obligations express or implied Parts furnished by suppliers to Delfield are guaranteed by Delfield only to the extent of the original manufacturer s express warranty to Delfield Failure of the Original Purchaser to receive such manufacturer s express warranty to Delfield Failure of the Original Purchaser to receive such manufacturers warranty shall in no way create any warranty expressed or implied or any other obligation or liability on Delfield s part in respect thereof IF THE CUSTOMER IS USING A PART THAT RESULTS IN A VOIDED WARRANTY AND A
21. rdena CA 90248 800 722 1252 1 800 531 1111 716 884 7425 1 800 782 5747 716 884 0410 FAX Email orders pacparts com serves CT DC DE MA MD ME wwwW pacparts com NH NJ NY PA RI VA VT WV serves AZ CA HI NV OR 7 Stove Parts Supply GCS Service 8 Garland Group 2120 Solona St 1177 Kamato Road PO Box 14009 Mississauga Ontario L4W1X4 Fort Worth TX 76117 0009 800 427 6668 1 800 433 1804 toll free 800 361 7745 FAX 1 800 272 7358 fax serves AR LA NM OK TX serves Canada 11 MicroDine Inc 12 Performance Refrigeration Parts 2920 N W 109th Avenue Miami FL 33172 305 994 9994 305 994 9992 FAX International parts depot 13 Southeastern Restaurant Services 3000 S Wyandot Englewood CO 80110 800 624 2117 303 7618861 FAX serves AZ CO KS NE NM OK UT WY 14 T M A 2200 Norcross Parkway Suite 210 Atlanta GA 30071 800 235 6516 770 446 6177 770 446 3157 FAX serves FL GA MS NC SC VA 980 S Isabella Rd Mt Pleasant MI 48804 0470 U S A 2916 Sidco Drive Nashville TN 37204 615 726 0351 800 737 0351 615 259 4100 FAX serves TN AL P 44792 Helm 9923 S W 178th St Plymouth MI 48170 Vashon WA 98070 808 828 4454 888 872 2465 734 451 2043 206 463 1772 734 451 3215 FAX 206 463 4431 FAX series ME IN WI OH serves AK HI ID MT OR WA Delfield has 14 conveniently located Parts Depots to ensure parts are handled promptly and accurately Delfield reserve
22. s the right to update or make changes to this list without prior notice Please call 1 800 733 8829 or check the web at www delfield com for a list of the current Parts Depots Delfield 989 773 7981 or 800 733 8821 Fax 800 669 0619 www delfield com Delfield reserves the tight to make changes in design or specifications without prior notice 2003 The Delfield Company All rights reserved Printed in the U S A DM14_48 04 03
23. tion package Be sure lines are secure and base is still intact 7 Freight carriers can supply the necessary damage forms upon request 8 Retain all crating material until an inspection has been made or waived Uncrating the Equipment First cut and remove the banding from around the crate Remove the front of the crate material use of some tools will be required If the unit is on legs remove the top of the crate and lift the unit off the skid If the unit is on casters it can be rolled off the skid Delfield F14 AND 48000 Series Service and Installation Manual SPECIFICATIONS WODEL NUMBEROF AMPS SHP MODEL NUMBEROF NUMBER OF SHIP NUMBER OPENINGS 208 230 WEIGHT NUMBER OPENINGS GASBURNERS BTU WEIGHT Electric with individual wells wet or dry operation Gas with single tank wet operation only F14E1232 2 10 0 11 0 216 Ibs 98kg 146 232 2 1 20000 256 105 116 kg 14 1348 3 15 0 16 0 296 Ibs 134kg F146W348 1 20000 326 105 148 kg 14 1460 4 20 0 22 0 376 Ibs 170kg F14GW460 4 1 20000 396 105 180 kg 14 1572 5 24 0 27 0 456 165 207 kg F14GW572 5 2 40000 456 Ibs 207 kg F14E1688 6 29 0 32 0 536 105 243 kg F14G6W688 6 2 40000 536 Ibs 243 kg Electrical connections are 208 230 volt 60 cycle single phase Each opening measures 11 87 x 19 87 30 2cm x 50 5cm Each opening measures 11 87 x 19 87 30 2cm x 50 5cm MODEL SHIP Electric with single tank wet operation
24. to the floor and will require more time to dissipate STEPS DANGER Filling the well and pre heating 1 With the drain cock closed fill the well until approximately a four inch depth is obtained More water may be required if shallow depth pans are used Always pour water in the well before pre STEPS heating For quicker pre heating use hot water to fill the well 2 Turn the gas control knob 1 4 turn counterclockwise and wait for the water to preheat Then set the control to your desired serving temperature Temperature Water in wells 160 F to 180 F Product in pans 140 F to 160 F MAINTENANCE The exterior can be cleaned using mild soap and warm water If this is not sufficient try ammonia and water or a non abrasive liquid cleaner When cleaning the exterior always rub with the grain of the stainless steel to avoid marring the finish Do not use an abrasive cleaner because it will scratch the stainless steel A stainless steel cleaner or polish may be used to eliminate water spotting and fingerprints and bring out the finish of the exterior The interior of the food wells should be cleaned daily with a 9 Delfield non abrasive cleaner and non abrasive pad If necessary a mild abrasive may be used on the interior of the pans only Hard water stains and lime scaling may require a special cleaning product Never use steel wool Do not use a hose or pressure washer on these units The water will damage the elec
25. trical and DANGER gas components For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com 5 F14 AND 48000 Series Service and Installation Manual GAS BURNER ASSEMBLY F14GW SERIES SINGLE SHOWN NOTE The same parts are used for the double burner assembly VRQ KEY QTY PART DESCRIPTION KEY QTY PART DESCRIPTION 3547413 elbow 1 2 NPT 3234023 device vent limiting gas reg 9321035 nut 1 4 20 3547406 nipple 1 2 x 6 5 3547411 manifold nipple 23 9321157 u bolt 1 4 20 3234205A gas burner assy 9321059 washer 1 4 3547409 nipple 3 4 x 12 3234343 valve safety 3234341 thermocouple 3234205B chamber air mixing 3234342 pilot assembly 3234205C plate air mixing 3547329 tubing copper 1 4 O D x 028 3547593 fitting inlet burner natural 3547407 pipe manifold valve 12 3234205D cock front handle 3547408 cap 1 2 NPT 3234205E handle valve 3547234 nipple 1 2 x 2 3547591 fitting inlet burner LP 3234022 regulator natural gas 3547412 nipple manifold 31 25 dbl bnr only O gt 9 6 For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com D Fi F14 AND 48000 Series Service and Installation Manual DELFIELD FOOD WELL DFW ASSEMBLY wiTH THERMOSTATIC CONTROL THERMOSTATIC CONTROL KEY PART NAME DELFIELD PART Complete assembly 115V thermostat w drain X
26. turer Replacement of a defective Motor Compressor is limited to one 1 Motor Compressor by us during the four 4 year period Delfield shall replace the Motor Compressor at no charge This warranty does not give the Original Purchaser of the Motor Compressor the right to purchase a complete replacement Motor Compressor of the same make or of another make It further does not permit the replacement to be made with a Motor Compressor of another kind unless authorized by Delfield In the event Delfield authorizes the Original Purchaser to purchase a replacement Motor Compressor locally only the wholesale cost of the Motor Compressor is refundable Expressly excluded from this warranty are damages resulting from spoilage of goods Except as provided in any applicable Standard One Year Limited Warranty or applicable Service Labor Contract the foregoing is exclusive and in lieu of all other warranties whether written or oral express or implied This Warranty supersedes and excludes any prior oral or written representations or warranties Delfield expressly disclaims any implied warranties of merchantability fitness for a particular purpose or compliance with any law treaty rule or regulation relating to the Motor Compressor and the full liability of Delfield for any breach of this warranty will be as provided in this warranty Other than any applicable Delfield Standard One year Limited Warranty this Delfield Additional Four Year
27. ustable 219 4335 9 Screw 932 1007 10 Drain cover GMKO00063 11 Screws 2 932 1007 OPTIONAL 12 control 120V 219 4107 Infinite control 230V 219 4110 13 Infinite control knob 323 4557 14 Pilot light red 115V 219 4190 Pilot light amber 230V 219 4095 NOTE If you need four or more component parts you must buy a complete assembly en C 8 For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com D Fi e MISCELLANEOUS PARTS LISTS F14EI Series electric 48300 Series electric PART NAME DELFIELD PART PART NAME DELFIELD PART 323 4075 Bullet feet 4 323 4224 Food well assembly see pgs 7 8 aC PPM 323 4406 Gate valve 1 2 354 7486 lE 323 4645 Legs 6 w mounting plate 323 4645 Cutting board pin cap 170 1000 Cutting board pin screw 932 1060 Brass cutting board hinge pin 323 4360 F14EW Series electric Food well see pgs 7 8 PART NAME DELFIELD PART 4 Gate valve 1 2 354 7486 Brass drain 2 Contactor relay 30 amp 120 219 4185 Polyethlene board model 48348 130 1397 Faucet isses eee adaa P
28. wledges that no other warranties are offered or provided in connection with or for the unit or any other part thereof In no event will Delfield be liable for special incidental or consequential damages or for damages in the nature of penalties IF DURING THE WARRANTY PERIOD CUSTOMER USES A PART FOR THIS DELFIELD EQUIPMENT OTHER THAN AN UNMODIFIED NEW OR RECYCLED PART PURCHASED DIRECTLY FROM DELFIELD OR ANY OF ITS AUTHORIZED SERVICE CENTERS AND OR THE PART BEING USED IS MODIFIED FROM ITS ORIGINAL CONFIGURATION THIS WARRANTY WILL BE VOID FURTHER DELFIELD AND ITS AFFILIATES WILL NOT BE LIABLE FOR ANY CLAIMS DAMAGES OR EXPENSES INCURRED BY THE CUSTOMER WHICH ARISE DIRECTLY OR INDIRECTLY IN WHOLE OR IN PART DUE TO THE INSTALLATION OF ANY MODIFIED PART AND OR PART RECEIVED FROM AN UNAUTHORIZED SERVICE CENTER If the warranty becomes void Customer may purchase from Delfield if available a Service Agreement or service at the then current time and materials rate For more information on Delfield warranty s log on and check out the service section of our web site at www delfield com For customer service call 800 733 8829 800 773 8821 Fax 989 773 3210 www delfield com 1 3 F14 AND 48000 Series Service and Installation Manual ADDITIONAL FOUR YEAR PROTECTION PLAN for Motor Compressor only Installation Delfield Model Serial Date gs In addition to the Standard One Year Warranty on the Motor Compressor contained in th
Download Pdf Manuals
Related Search