CFM UVCVR36 User's Manual
Contents
1. MANTEL TRIM TRIM NONCOMBUSTIBLE FACING MATERIAL Front leg FP1545 a Front Back Width Side Width A B Fig 4 Hearth dimensions UVSTR UVCVR Series Vent Free Fireboxes Installation In planning the installation for the firebox it is neces sary to determine where the unit is to be installed and whether optional accessories are desired Gas supply piping should also be planned These models may NOT be installed in a bedroom or bathroom Glass doors are NOT available for these fireboxes The firebox can be mounted on any of the following surfaces e Aflat hard combustible surface e Araised platform of combustible or noncombustible material A concrete block or other solid object placed be neath each of the four corners of the appliance If the firebox is installed directly on carpeting tile or other combustible material other than wood flooring it should be installed on a metal or wood panel extending the full width and depth of the unit At this point you should have decided what compo nents to include in your installation and where the firebox is to be located If this has not been done stop and consult your dealer for planning assistance Firebox framing can be built before or after the firebox is set in place Framing should be positioned to ac commodate wall covering and firebox facing material The firebox framing should be constructed of 2 x 4 or heavier lumber The framing headers may rest on2. STATE TO STATE All other warranties expressed or implied with respect to the product its components and accessories or any obligations liabilities on the part of the Company are hereby expressly excluded The Company neither assumes nor authorizes any third party to assume on its behalf any other liabilities with respect to the sale of this Vermont Castings or Majestic product The warranties as outlined within this document do not apply to chimney components or other non CFM Corporation accessories used in conjunction with the installation of this product Damage to the unit while in transit is not covered by this warranty but is subject to claim against the common carrier Contact the dealer from whom you purchased your fireplace stove do not operate the appliance as this might negate the ability to process the claim with the carrier The Company will not be responsible for a Down drafts or spillage caused by environmental conditions such as near by trees buildings roof tops hills or mountains b Inadequate ventilation or negative air pressure caused by mechanical systems such as furnaces fans clothes dryers etc This warranty is void if a The fireplace has been operated in atmospheres contaminated by chlorine fluorine or other damaging chemicals b The fireplace has been subjected to prolonged periods of dampness or condensation c Any damages to the fireplace combustion chamber heat exchanger or other
3. Lemon oil only Brass cleaners cannot be used Mortar mix and masonry cleaners may corrode the brass finish The Company will not be responsible for nor will it warrant any brass parts which are damaged by external chemicals or down draft conditions GAS VALVES Gas valves are covered for a period of one year ELECTRONIC AND MECHANICAL COMPONENTS Electronic and mechanical components of the burner assembly are covered for one year All steel tube burners are warranted for one year ACCESSORIES Unless otherwise noted all components and CFM Corporation company supplied accessories are covered for a period of one year CONDITIONS AND LIMITATIONS e This new Vermont Castings or Majestic product must be installed by a competent authorized service contractor A licensed technician as prescribed by the local jurisdiction must perform any installation service work It must be installed and operated at all times in accordance with the Installation and Operating instructions furnished with the product Any alteration willful abuse accident or misuse of the product shall nullify this warranty e This warranty is non transferable and is made to the original owner provided that the purchase was made through an authorized supplier of the Company e The customer must pay for any Authorized Dealer in home travel fees or service charges for in home repair work It is the dealers option whether the repair work will be done in the customer s home
4. another copy 7412960 UVSTR UVCVR Series Vent Free Fireboxes NOTE The gas line connection to the log set can be made with properly tinned 3 8 copper tubing 1 2 rigid pipe or an approved flex connector Because some mu nicipalities have additional local codes it is always best to consult your local authority U S INSTALLATIONS Follow local codes and the National Fuel Gas Code ANSI Z223 1 NFPA 54 Always check for gas leaks with a mild A soap and water solution Do not use an open flame for leak testing When using copper or flex connector use only approved fittings Always provide a union so that gas line can be easily disconnected for burner or fan servicing See gas specification for pressure details and ratings Cold Climate Insulation In cold climates insulation of the enclosure around the firebox is suggested to avoid problems with cold air Insulating the enclosure around the firebox is recom mended but not a requirement The following steps are suggested to minimize cold air problems Insulate the base of the firebox with a noncombustible insulation This step is particularly important for outside wall installations over concrete slab floor construction If a platform is used to raise the firebox the insulation should be placed onto the platform before the firebox is set Fig 7 Refer to Page 5 Figure 3 for minimum clearances to combustibles Inspect joints of the firebox as well as the poi
5. components due to water or weather damage which is the result of but not limited to improper chimney venting installation d Any alteration willful abuse accident or misuse of the product has occurred IF WARRANTY SERVICE IS NEEDED Contact your supplier Make sure you have your warranty your sales receipt and the model serial number of your CFM Corporation product DO NOT ATTEMPT TO DO ANY SERVICE WORK YOURSELF 15 NATIONAL We recommend that our gas FIREPLACE INSTITUTE hearth products be installed S 4 and serviced by profes sionals who are certified in the U S by the National Fireplace Institute NFI as CERTIFIED NFI Gas Specialists www nficertified org CFM Corporation 2695 Meadowvale Blvd Mississauga Ontario Canada L5N 8A3 800 668 5323 www cfmcorp com
6. or in the dealer s shop e If upon inspection the damage is found to be the fault of the manufacturer repairs will be authorized at no charge to the customer parts and or labor 7412960 Any part and or component replaced under the provisions of this warranty is covered for six months or the remainder of the original warranty whichever is longest This warranty is limited to the repair of or replacement of part s found to be defective in material or workmanship provided that such part s have been subjected to normal conditions of use and service after said defect is confirmed by the Company s inspection The company may at its discretion fully discharge all obligations with respect to this warranty by refunding the wholesale price of the defective part s Any installation labor construction transportation or other related costs expenses arising from defective part s repair replacement or otherwise of same will not be covered by this warranty nor shall the Company assume responsibility for same Further the Company will not be responsible for any incidental indirect or consequential damages except as provided by law SOME STATES DO NOT ALLOW FOR THE EXCLUSION OR LIMITATIONS OF INCIDENTAL AND CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE LIMITATIONS MAY NOT APPLY TO YOUR CIRCUMSTANCES THIS WARRANTY GIVES YOU SPECIFIC RIGHTS AND YOU MAY HAVE OTHER RIGHTS WHICH VARY FROM
7. the top of the firebox standoffs Refer to Figs 1 and 2 for firebox framing dimensions Anchor Firebox in Position To prevent shifting of the firebox and to maintain sealing described later anchor the firebox Two methods are possible for these fireboxes One method is to use the eight fastening tabs four with cove model provided with the firebox Fig 5 The firebox may be secured to the vertical framing members with these tabs and nails or other suitable fasteners The second method uses the standoffs at the front of the firebox A nail may be installed through the standoffs and into the header to stabilize the top of the firebox Fig 5 e gt Installing Outside Air Kit An outside air kit may be installed in all UVSTR CVR Series fireboxes If desired or if local codes man date the use of an air kit then an AKU2 is required to complete the installation from air kit to out of doors If the outside air kit is to be used the AKU2 MUST be installed BEFORE the fireplace is enclosed Refer to the AKU2 instructions for field installation Nail Top Standoffs i Nail Eight Side Nailing Flanges R SARIT RXX 7 RL RK Bi 6 UVSTR36 Nail Top Standoffs Nail Four Side Nailing Flanges UVCVR36 Fig 5 Adjustable drywall strip nailing flange 7412960 Connect the Gas Line Gas access holes are provided on both sides of the firebox Check gas valve type Use only the gas type indica
8. NDED LIFETIME WARRANTY The heat exchanger where applicable and combustion chamber of every Vermont Castings or Majestic gas product is warranted for life against through wall perforation All appliances equipped with an Insta Flame Ceramic Burner have limited lifetime coverage on the ceramic burner plaque Warrantees are made to the original owner subject to proof of purchase and the conditions and limitations listed on this Warranty Document COMPONENT WARRANTY CAST IRON All external and internal cast iron parts are warranted for a period of three years Note On porcelain enamel finished external parts and accessories The Company offers no Warranty on chipping of enamel surfaces Inspect all product prior to accepting it for any damage to the enamel The salt air environment of coastal areas or a high humidity environment can be corrosive to the porcelain enamel finish These conditions can cause rusting of the cast iron beneath the porcelain enamel finish which will cause the finish to flake off Dye lot variations with replacement parts and or accessories can occur and are not covered by warranty GLASS DOORS Glass doors are covered for a period of one year Glass doors are not warranted for breakage due to misuse or accident Glass doors are not covered for discoloration or burned in stains due to environmental issues or improper cleaning and maintenance BRASS PLATED PARTS AND ACCESSORIES Brass parts should be cleaned with
9. Vent Free Fireboxes Models UVSTR36 UVCVR36 MAJESTIC FIREPLACES INSTALLER CONSUMER SAFETY INFORMATION DO NOT INSTALL THE APPLIANCE IN THIS FIREBOX UNLESS THIS ve FIREBOX MEETS THE MINIMUM g how UVSTR36 DIMENSIONS REQUIRED FOR THE INSTALLATION WARNING If the information in this manual is not followed exactly a fire or explosion may result causing property damage personal injury or loss of life FOR USE ONLY WITH ALISTED GAS FIRED UNVENTED DECORATIVE ROOM HEATER NOT TO EXCEED 40 000 BTU H DO NOT BUILD A WOOD FIRE DUE TO HIGH TEMPERATURES THE APPLIANCE SHOULD BE LOCATED OUT OF TRAFFIC AND AWAY FROM FURNITURE AND DRAPERIES UVCVR36 Do not attempt to modify or alter the construction of the appliance or its components Any modification or Homeowner s Installation and alteration of construction may void the warranty of these units Operating Manual Do not store or use gasoline or other flammable vapors and liquids in the a vicinity of this or any other appliance These Ventless Fireboxes are design Improper maintenance or service can certified to ANSI 21 91 2001 and are for cause injury or property damage Refer use with any ANSI Z21 11 2 Unvented to this manual For additional infor Room Heaters mation consult a qualified installer service agency or the gas supplier Carefully review the instructions supplied with the decorative type unvented room heater for the minimum fireplace
10. da L5N 8A3 10 7412960 UVSTR UVCVR Series Vent Free Fireboxes CFM Corporation reserves the right to make changes in design materials specifications prices and discontinue colors and products at any time without notice UVCVR Vent Free Firebox Ref Description UVCVR 1 Brick Filler 3079148 2 Brick Side 3079147 3 Brick Hearth 3087102 4 Screen Assembly Screens and Rod 3036118 5 Brick Hearth End 3090102 6 Screen Assembly End 3080137 7 O S A Assy 20003212 7412960 11 UVSTR UVCVR Series Vent Free Fireboxes CFM Corporation reserves the right to make changes in design materials specifications prices and discontinue colors and products at any time without notice UVSTR Vent Free Firebox Ref YR YON 12 Description Brick Filler Brick Side Brick Hearth Screen Assembly Screens and Rod O S A Assy UVSTR 3079148 3079147 3087102 3049121 20003212 7412960 UVSTR UVCVR Series Vent Free Fireboxes Accessories The following accessories for these appliances are available from your local Majestic Fireplaces distributor Each ac cessory comes with a separate installation instruction for mounting to the particular firebox Be sure to read each instruction thoroughly before installing See your Majestic Fireplaces distributor or dealer for other finishing options such as marble and mantels available in a wide selection of styles Outside Air Com
11. ens to side rail from inside hood Use Top Slot Fig 14 Hood location UVSTR UVCVR Series Vent Free Fireboxes Maintenance Keep the control compartment logs and burner area A EA clean by carefully vacuuming or Firebox S OES a eer VEEP HOT ENDL ONLY Model and serial numbers are listed on the rat WHEN COOL ing plate located on right side of combustion chamber Always turn off the gas to the pilot before cleaning For relighting refer to the lighting instructions located on Record your model and serial numbers here for the Rating Plate of the gas log set future reference Never obstruct the flow of combustion and ventilation air Keep the front of the appliance clear of all obstacles Model and materials Leave at least a 36 clearance from the front of the Serial firebox to any room furnishings Contact CFM Corporation for questions concerning Vent free Log Heater prices and policies covering replacement parts Parts may be ordered through your Majestic Fireplaces dis tributor or dealer Record your model and serial numbers here for future reference You will need the following information when ordering Model replacement parts 1 The appliance model number Serial 2 The serial number 3 Adescription of the part Should you need additional information beyond what your dealer can furnish contact CFM Corporation 410 Admiral Meadowvale Blvd Mississauga Ontario Cana
12. ler any parts damaged in shipment This firebox is a highly engineered system Unless you use CFM Corporation components which have been designed for the system you may create a possible fire hazard CFM Corporation warranty will be voided by and CFM Corporation disclaims any responsibility for the following actions e Installation of any damaged firebox e Modification of the firebox or any of the compo nent parts thereof e Installation other than as instructed by CFM Cor poration e Installation and or use of any component part or accessory not manufactured or approved by CFM Corporation in combination or assembly with a Majestic Fireplaces firebox notwithstand ing any independent testing laboratory or other third party approval of such component part or accessory Any such action may create a possible fire hazard Consult your local building codes Proposition 65 Warning Fuels used in gas wood burning or oil fired appliances and the products of combustion of such fuels contain chemicals known to the State of California to cause cancer birth de fects and other reproductive harm California Health amp Safety Code Sec 25249 6 Fireplace Screen The fireplace screen must be in place when the firebox is operating and unless other provisions for combustion air are made the screen must have openings for the introduction for combustion air WARNING Be sure to read complete Vent A Free Gas Log Heater a
13. nd Vent Free Fire place Installation and Operating Instruc tions before installing this product UVSTR UVCVR Series Vent Free Fireboxes UVSTR36 Specifications 5 Recessed Nailing Flange Rough Opening Height_ 7 Gas Line Access 145 V4 Outside Air 22 Rough Opening Depth 5 Recessed Rough Nailing Opening Height y Outside Air 14 g Gas Line Access 40 2 Fig 2 UVCVR36 Series specification and framing dimensions 4 7412960 Front View CEILING 42 Min Side View Seal with noncombustible material Fig 3 Clearances to combustibles Minimum Clearances Sidewall Clearances The clearance from the side of the firebox to any com bustible wall should not be less than 11 Fig 3A Ceiling Clearances The ceiling height should not be less than 42 from the top of the fireplace opening Fig 3A Mantel Clearances If a combustible mantel is installed it must meet the clearance requirements detailed in Figure 3A A mantel breastplate can be installed at a minimum height of 8 with a maximum projection of 1 Grate Clearance The minimum clearance between the front legs of the grate and front edge of the fireplace is 3 Fig 3B 7412960 UVSTR UVCVR Series Vent Free Fireboxes 3B Top View COMBUSTIBLE ANTEL FINISHED WALL M
14. nts of seal ing between the firebox and the finishing materials When a firebox is installed in a chase or on an outside wall the enclosure should be insulated like any other outside wall of the home Plywood or hardboard may be placed on the standoffs and insulation placed on this surface Fig 8 UVSTR UVCVR Series Vent Free Fireboxes Hard Flat Surface A ZA LIGETI x Zs ZEN CELLED STG LS 2 AN 2 ZZ Z XE EAX LLL ZZ LE i 8 OS YZ 28 2S aa 2 a ee NOX FZ Insulation Platform Insulation Plywood Support Fig 8 Additional insulating methods UVSTR36 shown See Page 5 Figure 3 for allowable finishing materials and clearances to combustibles All joints top bottom and sides where the wall or decorative facing material meets the firebox surround must be completely sealed with terial Refer to Figures 9 12 a noncombustible ma Hearth Extension A hearth extension may be used but is not required for these fireboxes Top View Noncombustible Caulking Insulation 2x 4 Stud t Finishing Material Fireplace Front Fig 9 Seal spaces between firebox and finishing materials See mantel drawing for shelf to surround dimen sion Mantel Shelf Lt Seal with noncombus tible material ONLY Surround ___ Top View 1 2 FP684 Finished Wall Stud 2 x 4 Finished Header E Stand
15. off Fireplace Front Finished Wall Aa E May be sealed with noncombustible material Fireplace Front FP683 Fig 10 Surround flush with finished wall 7412960 Finished Wall 2 x 4 Finished 5 y PE Must be sealed with p Header noncombustible mate rial Standoff Noncombustible Decorative Fac ing Surround Fig 11 Appliance surround flush with finish wall 2 x 4 Finished Header Finished Wall Covered Wall a Must be sealed with non combustible material Noncombustible Decorative Fac ing Standoff Surround Fig 12 Facing on firebox flush with finished wall Install Hood A 2 or 4 Hood can be purchased for the UVSTR36 and the UVCVR36 A Hood must be installed if the mantel falls within the dimensions and location shown in Figure 3 Failure to do so may create a fire hazard WARNING When the black surround is covered by a brick surface Fig 13 use an extended hood The hood should extend out to the brick surface Refer to Figs 13 and 14 and be attached to the firebox The maximum brick to noncombustible sur face that may extend out past the black surround surface is 41 4 The size of the Hood required depends on BTU ratings and clearances See the Accessories section on Page 13 for details 7412960 UVSTR UVCVR Series Vent Free Fireboxes Brick Sur face l Extended Hood A Fi g 13 Side view of firebox with extended hood 4 Screw Fast
16. pletes connection from air kit to out of doors AKU2 Termination om Polished Brass 2 Hood For heater up to 40 000 BTU s with a mantel 8 wide by 28 high UV36BH2 UV36PH2 4 Hood For heater up to 40 000 BTU s with a eee mantel 8 wide by 12 high UV36BH4 UV36PH4 4 Hood Extended Hood for brick facings and heater up to P 40 000 BTUs and mantel 8 wide by 12 high UV36BH4E UV36PH4E 4 Hood Glass Hood for heater up to 40 000 BTUs and mantel 8 wide by 12 high UV36GH4 CAUTION This firebox is a highly engineered system and as such must be operated only with CFM Corporation approved components If you use an unapproved component to make any modifications you may create a possible fire hazard and will void CFM Corporation warranty In addition such action may void the coverage provided by the owner s insurance 7412960 13 UVSTR UVCVR Series Vent Free Fireboxes 14 7412960 LIMITED LIFETIME WARRANTY PRODUCT COVERED BY THIS WARRANTY All Vermont Castings gas stoves gas inserts and gas fireplaces and all Majestic brand gas fireplaces equipped with an Insta Flame Ceramic Burner or standard steel tube burner BASIC WARRANTY CFM Corporation hereinafter referred to collectively as the Company warrants that your new Vermont Castings or Majestic Gas Fireplace Stove is free from manufacturing and material defects for a period of one year from the date of purchase subject to the following conditions and limitations EXTE
17. size requirement 7412960 10 06 Rev 4 ZY PEPE POO Le LYE SELES EERE A Ze UVSTR UVCVR Series Vent Free Fireboxes Description The UVSTR36 and UVCVR36 models are ventless fireboxes designed for installation with any ventless gas log set for a see through application and certified to ANSI Z21 11 2 standards THESE UNITS ARE DESIGNED FOR A MAXIMUM OF 40 000 BTU Optional hoods are available Refer to page 13 For Your Safety Do not place clothing or other flammable material on or near the appliance Children and adults should be alerted to the hazards of high surface temperature and should stay away to avoid burns or clothing ignition Young children should be carefully supervised when they are in the same room as the appliance Ble Meym OI Description and Available Models General Information Specifications and Framing Clearances Installation Maintenance Replacement Parts Accessories Warranty 2 7412960 General Information DO NOT BURN WOOD OR OTHER MATERI ALS IN THESE FIREBOXES General Information The installation must conform with local building codes or in the absence of local codes with the National Fuel Gas Code ANSI Z223 1 NFPA 54 latest edition and with the National Electrical Code ANSI NFPA70 latest edition In the Commonwealth of Massachusetts all gas fitting and installation of this heater shall only be done by a licensed gas fitter or licensed plumber NOTE Ins
18. tallation and repair should be done by a qual ified service person The firebox should be inspected before use and at least annually by a qualified service person More frequent cleaning may be required due to excessive lint form carpeting bedding material etc It is imperative that control compartment burners and circulating air passageways of the firebox be kept clean Any safety screen or guard removed for servicing the firebox must be replaced prior to operating the firebox Provide adequate combustion and ventilation air The flow of combustion and ventilation air MUST NOT be obstructed Provide adequate clearance around air openings into the combustion chamber and adequate accessibility clearance for servicing and proper operation NEVER obstruct the opening of the firebox These models may NOT be installed in a bedroom or bathroom Glass doors are NOT available for these fireboxes WARNING Check with your electronics manufactur er before installing a television or other electronic device above this fireplace 7412960 UVSTR UVCVR Series Vent Free Fireboxes Installation Precautions This Majestic Fireplaces firebox and its components have been tested and will operate safely when installed in accordance with this installation manual Read all in structions before starting installation then follow these instructions carefully during installation to maximize firebox benefit and safety Report to your dea
19. ted on the gas log rating plate If the gas listed on the plate is not your type of gas supply DO NOT INSTALL Con tact your Dealer for the proper model Always use an external regulator for all LP fireboxes to reduce the supply tank pressure to a maximum 14 w c This is in addition to the regulator fitted to the vent free heater WARNING Connection directly to an un regulated LP tank can cause an explosion For final connection of the gas log heater to the gas line see Section 5 and Figure 6 1 2 Gas Supply w m x 3 8 Shut Off Valve p Nipple Gas Supply Line Fig 6 Typical gas supply installation Install Gas Log Heater 1 Connect the shutoff valve union and any required approved fittings See NOTE below between the valve and the gas line Access to the gas line on the UV Series firebox is made through the left or right side of the firebox Locate the appropriate gas line in the outer casing of the firebox and remove the insulation from the gas line tube From the inside of the firebox locate the knockout on the firebrick be sure you are on the appropriate or gas line side of the firebox Using a flat bladed screwdriver or small chisel and hammer carefully tap around the knockout until it loosens and falls out 2 Install the Vent Free Gas Log Heater exactly as described in the instructions for the heater If for any reason you do not have these instructions contact your dealer or manufacturer for
Download Pdf Manuals
Related Search