Bradley Smoker Indoor Furnishings User's Manual
Contents
1. ITEM PART NO DESCRIPTION 1 125 165 O Ring 118 307A Valve Body Manifolded 3 118 307 Valve Body Closed 4 269 983 Diaphragm 5 269 577 Armature Valve 6 269 578 Spring Valve 7 118 309 Cover AST4 Valve 8 107 538 Cover AST4 Valve Timer 9 S27 305 Timer ASM ASTA Valve 10 125 001BY O Ring 11 110 234 Compression Nut 1 8 12 S39 591 Magnet Diaphragm Assy 13 107 535 Cover AST4 Valve 14 110 233 Clamp Nut AST4 Valve 15 160 449 Screw 8 16 x 7 8 16 S65 261 Repair Kit AST4Valve 17 65 262 Repair Kit AST4 Valve Upper 18 65 260 Repair Kit AST4 Valve Complete Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 11 Terreon Multi Fount Washfountains Metering Air Valve Maintenance Adjust Air Valve Meter Time NOTE The air valve timer is located next to the tube connector on the air valve body The timer is capped with a filter to prevent dirt build up on the timer The air valve timing can be adjusting from 5 60 seconds 1 Remove filter cap and use a screwdriver to tighten or loosen the timer see illustration at right Turning the timer clockwise increases the time turning the timer coun terclockwise decreases the time 2 Continue to adjust until the timer is set at desired length 3 Replace filter cap over the timer Tube Connection Leaks 1 Push in the orange manual release button while pulling the tube out see illustration at right to2. REF QTY PART NO DESCRIPTION 1 1 118 307 VALVE BODY 1 4 CLOSED 1 1 118 307A VALVE BODY 1 4 THRU 2 1 269 983 DIAPHRAGM 3 1 269 577 ARMATURE 4 1 269 578 SPRING 5 1 269 1729 ARMATURE HOUSING 6 1 269 1730 CLAMP ARMATURE HOUSING 7 1 269 579 COIL SOLENOID VALVE 8 3 160 447 SCREW 8 X 5 8 9 1 125 165 O RING 42 013 10 1 125 160 FLOW RESTRICTOR 5 GPM 11 1 S65 113 REPAIR KIT Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 21 Terreon Multi Fount Washfountains Parts and Service Guide TouchTime TT Solenoid Valve Troubleshooting CAUTION Turn off water supplies to unit before troubleshooting 22 Problem An individual operating station fails to shut off and drips Cause There is debris trapped between the diaphragm and the valve seat Solution Remove debris between diaphragm and the valve seat 1 Remove the three 8 Phillips head screws that hold the solenoid valve assembly together Be careful not to lose the armature or spring see previous page 2 Remove the diaphragm Remove any particles that have been trapped between the diaphragm and the valve seat Rinse off the diaphragm and inspect for damage Make sure the center orifice and both small side orifices are open 3 Reassemble in reverse order being careful not to overtighten the Phillips head screws or you may crack the plastic valve body Tighten until the armature plate makes contact with the
3. Corner Tri Quad Item Part No Description Qty Qty Qty 1 269 1735 Flex Hose 1 2 NPT x 24 Supply to TMV 2 2 2 2 27 102 Check Stop 2 2 2 3 160 169 Screw 2 2 2 A Use Qty 1 for TL option all models 14 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Battery Infrared BIR3 Sprayhead Parts List Battery Infrared Sensor and Sprayhead Corner Tri Quad Item Part No Description Qty Qty Qty 1 251 019A Sensor Eye Leads 2 3 4 2 269 1190 Window 4 6 8 3 115 131 Sprayhead 2 3 4 4 176 119 Threaded Rod 4 6 8 5 140 748 Backplate 2 3 4 6 161 026 Nut 4 6 8 7 142 002BS Lockwasher 4 6 8 8 269 871 Fitting Straight front sprayhead 1 2 9 269 628 Fitting Swivel 90 side sprayheads 2 2 2 10 R68 60001 R Tubing 1 4 Red Specify Length in feet 10 R68 60001 G Tubing 1 4 Green Specify Length in feet 10 R68 60001 B Tubing 1 4 Black Specify Length in feet 10 R68 60001 Y Tubing 1 4 Yellow Specify Length in feet Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 15 Parts and Service Guide E on q gt 5 SAL ISS 1S NS i JF M P a d ud Tri Fount Shown Parts List Air Metering Valve Assembly Corner
4. Multi Fount Washfountains Terreon Models Parts amp Service Guide 215 t F EN 07 005A 2007 Bradley Corporation P O Box 309 M e Falls WI 53052 0309 Page 1 of 34 1 30 2008 TEL 1 800 Br adie an E 262 251 5817 http www bradleycorp c Terreon Multi Fount Washfountains Parts and Service Guide Table of Contents Washfountain Identification Page Identification Chart and Model Numbers 4 i 4 l9 Ie uy ceed ee RUE EE ETE rs 3 Terreon Multi Fount Washfountains Infrared IR Sprayhead 24V plug in transformer 0 0 00 c cee eee eee 4 Infrared IR Valves 24V plug in transformer 0 00 cece eee eee eee 5 6 Infrared IR Solenoid Valve Troubleshooting 0 0 ee eee eee eee 7 Air Metering Valve AST4 Pushbutton and Sprayhead 0 0 0 0 e ee eee eee 8 9 Air Metering Valve AST4 Assembly 20 0 eect eens 10 Air Metering Valve AST4 Repair Kits 0 0 0 eee eee eens 11 Metering Air Valve Maintenance and Troubleshooting llle 12 13 AST4 amp IR Supply and Mixing Valve Floor and Wall Mounted 000 5 14 Battery Infrared BIR3 Sprayhead 0 0 eee ee teen eee 15 Battery Infrared BIR3 Valves ioci R eee de came seb RR eee tad eae RS E 16 17 Troubleshooting BIR3 Components 0 0 0 2 eee II 18 TouchTime TT Sprayhead 24V plug in transformer 00 0 0 eee eee eee 19 21
5. 4 Reconnect the wiring per diagram Problem An individual operating station fails to turn on Cause A failed coil for the valve or loose electrical connection to the terminal Solution Test the station to determine cause 1 Disconnect the wires from the coil of an adjacent valve Disconnect the wires from the problem valve and reconnect to the adjacent valve 2 Turn on electrical and water supplies to the unit Place hands in front of sensor for the problem station the adjacent station should turn on If the adjacent station turns on and cycles normally replace the coil on the problem valve If the adjacent valve fails to turn on inspect the wires from the sensor cable and do the following make sure there are no breaks and that the fully insulated disconnect terminals are firmly crimped in place turn off the electrical and water supplies reconnect to the adjacent valve and turn on the water supplies to the unit place hands in front of sensor If the station still fails to turn on replace the sensor Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 7 Parts and Service Guide 8 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Parts List Terreon Multi Fount Washfountains Corner Tri Quad Item Part No Description Qty Qty Qty 1 S08 340 Pushbutton Assy In
6. QTY PART NO DESCRIPTION 1 1 118 307 VALVE BODY 1 4 CLOSED 1 1 118 307A VALVE BODY 1 4 THRU 2 1 269 983 DIAPHRAGM 3 1 269 577 ARMATURE 4 1 269 578 SPRING 5 1 269 1729 ARMATURE HOUSING 6 1 269 1730 CLAMP ARMATURE HOUSING 7 1 269 579 COIL SOLENOID VALVE 8 3 160 447 SCREW 8 X 5 8 9 1 125 165 O RING 2 013 1 1 125 160 FLOW RESTRICTOR 5 GPM 1 S65 113 REPAIR KIT 6 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Infrared IR Solenoid Valve Troubleshooting CAUTION Turn off water supplies to unit before troubleshooting Problem An individual operating station fails to shut off and drips Cause There is debris trapped between the diaphragm and the valve seat Solution Remove debris between diaphragm and the valve seat 1 Remove the three 8 Phillips head screws that hold the solenoid valve assembly together Be careful not to lose the armature or spring see previous page 2 Remove the diaphragm Remove any particles that have been trapped between the diaphragm and the valve seat Rinse off the diaphragm and inspect for damage Make sure the center orifice and both small side orifices are open 3 Reassemble in reverse order being careful not to overtighten the Phillips head screws or you may crack the plastic valve body Tighten until the armature plate makes contact with the plastic body
7. 21 269 1834 FERRULE 1 22 R68 600012 TUBE 23 50 409 COMPLETE SOAP SYSTEM incl items 1 22 1 SPECIFY LENGTH IN FEET 26 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Soap System Continued SOAP RECOMMENDATIONS Quality soap dispensers require good quality soap and periodic maintenance to properly operate Bradley soap dispensers will provide dependable consistent operation over the long term when soap with reasonable viscos ity and pH levels are used and when a minimal amount of periodic maintenance is performed on the valves Soap thickness is determined by a measurement called viscosity Soap viscosity should be between 100 cps centerpoise and 2500 cps for all Bradley soap dispensers Thinner soaps are perceived by the users as being watered down so users tend to take more than they need resulting in waste Thick soaps flow slower and inhibit the flushing action of the valves which allows the soap to congeal in the valve and cause clogs The pH acid level of the soap should be in the range of 6 5 to 8 5 More acidic soaps pH levels lower than 6 5 will corrode metal parts even stainless steel and degrade rubber and plastic components They will also cause skin irritation Most inexpensive soaps typically the pink lotion type fall into this acidic category and will eventually cause valve failure and metal corrosion Base soaps
8. TouchTime TT Solenoid Valve Troubleshooting 0 cece eee eee eee 22 Mixing Valve Vernatherm Thermostatic 801 520 Valve 0 0 00 ee eee eee 23 24 Cleaning the Strainer iei e keer te diab tase tagereGe oie teen TESTA APEX een Red 23 24 Uerum DL ak aed a E Karke es aoe okie hak eee 25 27 Drdin pud and Strainer 524 od pews ay Mea NOR Fired dead had vie tete FR had PEE 28 Floor Pedestal Assembly 1 2 rud Ds QUE VS V n sd aur EEE a Feu Liu auxi SE PP a 29 Wall Mount Pedestal Assembly 5 222 2 x l4 dc e yx Elke 4 YER 30 Sprayhead Cover Attaching Hardware 5 veste e ea sea EN Se ed eed ENEMY E 31 Sprayhead Covers Replacement Parts 2 ia coe tk peas hla as SSAA WEARS EN ES 31 32 Pedestal Panels icu odios PECORE hast ER bo eA ee OE ERA Bet qub AG doa SUR ee ayes 32 Terreon Care and Maintenance une eae ee proe SES Face ones Rp e RITE Ree a ae RT es 33 Bowl NsSemblLys gta ion ed wea dap ea ae od teo ad rd eas piden add ad Hee A 34 Part numbers are subject to change without formal notice 2 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Terreon Multi Fount Washfountains Unique Repairable Solid Surface Material Highly Vandal Resistant Saves Water Energy and Space Available with Air Metering Infrared or Battery Operated Infrared and TouchTime Control Models Available MF2922 Terre
9. caso lt Green Wires Z i T A Black Wires Ux i Elo ee i E m Terminal Block NEN mm ee x tous dn a Left Center Right 4 Button m Button 1 Button Z Parts List TouchTime Metering Valve Assembly Corner Tri Quad Item Part No Description Qty Qty Qty 1 45 2088 TT TMA Dual Valve Assembly Transformer not included 2 S45 2089 TT TL Dual Valve Assembly Transformer not included 3 845 2094 TT TMA Tri Valve Assembly Transformer not included 1 4 45 2095 TT TL Tri Valve Assembly Transformer not included 1 zx 5 S45 2164 TT TMA Quad Valve Assembly Transformer not included 1 6 845 2165 TT TL Quad Valve Assembly Transformer not included 1 7 S01 520 Vernatherm Valve 4 GP 1 1 1 8 140 928 Bracket Ganged Valve 1 1 1 9 P18 054 Screw 10 24 x 3 8 PN 2 2 2 10 S07 068A Solenoid Valve 24 VAC through 1 2 3 11 S07 068 Solenoid Valve 24 VAC closed 1 1 1 12 110 231 Compression Nut 1 4 2 3 4 13 160 447 Screw 8 16 x 5 8 PN 2 3 4 14 S 39 685 Adapter Valve Inlet 1 1 1 15 83 134 Transformer 1 1 1 20 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains TouchTime Valve TT Assembly Solenoid Valve S07 068 closed body and S07 068A thru body
10. includes washer amp nut 28 1 30 2008 Parts and Service Guide Note The rubber washer that comes with this kit is used for certain applications Discard this washer for this application as it is not used on Washfountains Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Floor Pedestal Assembly Parts List Floor Pedestal Corner Tri Quad Item Part No Description Qty Qty Qty 1 186 1589 Mounting Panel 2 2 1 186 1590 Mounting Panel 2 d 04 056 Upper Bracket Assembly 1 1 2 S04 057 Upper Bracket Assembly 1 3 140 1011 Lower Bracket 1 1 3 140 1012 Lower Bracket 1 4 160 389 Screw 4 20 x 1 2 8 8 8 5 142 002BJ Washer 4 4 4 6 146 055 Clip 1 1 1 7 S 04 100 Access Panel Standard Height 1 1 7 04 095 Access Panel Juvenile Height 1 1 7 S 04 101 Access Panel Standard Height 1 7 04 096 Access Panel Juvenile Height 1 8 132 031 Washer 1 1 1 9 147 019 Screw 1 1 1 Access panel Item 7 part numbers include the screw and washer Upper Bracket Assembly includes Item 6 Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 29 Parts and Service Guide Parts List Wall Mount Pedestal Corner Tri Quad Item Part No Description Qty Qty Qty 1 17 237 Pedestal Assy 1 1 17 280 Pe
11. 15 121AH 15 122AH 15 119AH 15 120AH Summer Sage S15 123AE S15 124AE 15 121AE 15 122AE 15 119AE 15 120AE White Sand 15 123W S15 124W 15 121W 15 122W 15 119W 15 120W 15 119 32 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Terreon Care and Maintenance Material Description Constructed of Terreon a NAHB Certified densified solid surface material composed of polyester resin Terreon is resistant to chemicals stains burns and impact Surface dam age can be easily repaired with everyday cleansers or fine grit abrasives Routine Cleaning Clean daily or as often as conditions require using a standard commercial or household cleaner such as Formula 409 or Windex Stubborn Stains Remove tough stains with Ajax Comet or Soft Scrub and a green Scotch Brite pad or lightly sand in a circular motion with 240 grit wet dry sandpaper The finish can be renewed with a maroon Scotch Brite pad Special Situations for Material Scratches Remove scratches with a green Scotch Brite pad The fin ish can then be renewed with a maroon Scotch Brite pad Hard Water Deposits Remove hard water deposits with a mild solution of vine gar and water Always rinse the unit thoroughly after cleaning Restoring the Surface Use Hope s Solid Surface cleaner and polish to refresh and protect the Terreon Solid Surface materia
12. Numbers Wall Wall Juvenile Juvenile Standard Standard Mounted Mounted Hight Height Height Height Color Left Panel Right Panel Left Panel Right Panel Left Panel Right Panel Arctic Chip S15 123AD S15 124AD S15 121AD S15 122AD S15 119AD 15 120AD S15 123 Bluesky 15 123AL 15 124AL 15 121AL 15 122AL 15 119AL 15 120AL Charcoal 15 123K S15 124K S15 121K 15 122K 15 119K 15 120K Cobblestone S15 123T S15 124T 15 121T 15 122T 15 119T S15 120T q Coffee Bean S15 123AJ S15 124AJ S15 121AJ S15 122AJ S15 119AJ S15 120AJ Cornfield 15 123AK 15 124AK 15 121AK 15 122AK 15 119Ad 15 120AK CE Empire Gray 15 123 15 124 15 121 15 122 15 119 15 120 Graphite 15 123P 15 124P 15 121P 15 122P S15 119P 15 120P c Hillside 15 123AM 15 124AM 15 121AM 15 122AM 15 119AM 15 120AM Jade S15 123N S15 124N S 15 121N 15 122N 15 119N 15 120N S15 121 Lannonstone 15 123S 15 124S 15 121S 15 122S 15 119S 15 120S London Gray 15 123AP 15 124AP 15 121AP 15 122AP 15 119AP 15 120AP Mountaintop S 15 123AN S15 124AN 15 121AN 15 122AN S15 119AN 815 120AN Mystic Moss 15 123AG S15 124AG 15 121AG 15 122AG S15 119AG S15 120AG Organic Taupe S15 123AR 15 124AR 15 121AR 15 122AR 15 119AR 15 120AR Peppered White 15 123E S15 124E 15 121E 15 122E 15 119E 15 120E Riverstone S15 123AF S15 124AF 15 121AF 15 122AF 15 119AF 15 120AF Stardust S15 123AH S15 124AH
13. Tri Quad Item Part No Description Qty Qty Qty 1 S08 432TMA TMA Dual Valve Assembly includes 7 13 2 S08 432TL TL Dual Valve Assembly includes 8 14 3 S08 433TMA TMA Tri Valve Assembly includes 7 13 1 4 S08 433TL TL Tri Valve Assembly includes 8 14 1 5 S08 434TMA TMA Quad Valve Assembly includes 7 13 1 6 S08 434TL TL Quad Valve Assembly includes 8 14 1 7 01 520 Vernatherm Valve 4 GP 1 1 1 8 140 928 Bracket Ganged Valve 1 1 1 9 P18 054 Screw 10 24 x 3 8 PN 2 2 2 10 S07 083 BIR3 Valve through includes 15 17 1 2 3 11 S07 083A BIR3 Valve closed includes 15 17 1 1 1 12 110 231 Compression Nut 1 4 2 3 4 13 160 447 Screw 8 16 x 5 8 PN 2 3 4 14 S39 685 Adapter Valve Inlet 1 1 1 16 S83 178 Circuit Board 2 3 4 17 160 451 Screw 6 19 x 3 4 2 3 4 18 883 177 Battery Holder 2 3 4 19 261 010 Lithium Battery Type DL223A or Equivalent 2 3 4 20 S45 2083 Battery Prepack includes 18 19 2 3 4 16 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Battery Infrared Valve BIR3 Assembly Solenoid Valve S07 073 closed body and S07 073A thru body REF QTY PART NO DESCRIPTION 1 1 118 307 VALVE BODY 1 4 CLOSED 1 1 118 307A VALVE BODY 1 4 THRU 2 1 269 983 DIAPHRAGM 3 1 192 017 ARMATURE 4 1 135 093 SPRING 5 1 2
14. disconnect the tube at the connector No tools are needed 2 To correct a leak press tubing firmly into the connector and make sure it is seated 3 If leak persists remove tubing from the fitting and trim the tubing end square with a razor sharp knife If leak con tinues replace the fitting or contact your Bradley represen tative for assistance Parts and Service Guide WATER TUBE CONNECTOR pn AIR VALVE ES FILTER CAP c CY AIR TUBE CONNECTOR manual release button A N N N S N N B S N VLU Li 12 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Metering Air Valve Troubleshooting Problem Valve will not shut off Cause Timing mechanism is clogged Solution Clean and inspect timing mechanism 1 If compressed air is available blow water and debris from timer cover of timing mechanism 2 Turn adjusting screw out all the way Clean and inspect screw and valve body 3 Turn adjusting screw in to desired cycle time Problem Valve will not turn on Cause Water is not being supplied to unit Solution Open all stops on mixing valve Cause Water pressure is over 80 PSI Solution Install a pressure reducing valve Cause Failed diaphragm magnet assembly Solution Unscrew the valve clamp nut on valve Remove valve cover Gently press the the diaphragm The valve should activate If not replac
15. plastic body 4 Reconnect the wiring per diagram Problem An individual operating station fails to turn on Cause A failed coil for the valve or loose electrical connection to the terminal Solution Test the station to determine cause 1 Disconnect the wires from the coil of an adjacent valve Disconnect the wires from the problem valve and reconnect to the adjacent valve 2 Turn on electrical and water supplies to the unit Depress the Touch Time pushbutton of the problem station the adjacent station should turn on If the adjacent station turns on and cycles normally replace the coil on the problem valve If the adjacent valve fails to turn on inspect the wires from the sensor cable and do the following make sure there are no breaks and that the fully insulated disconnect terminals are firmly crimped in place turn off the electrical and water supplies reconnect to the adjacent valve and turn on the water supplies to the unit depress the Touch Time pushbutton If the station still fails to turn on replace the sensor 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Thermostatic Mixing Valve Troubleshooting NOTE Before attempting to troubleshoot the valve or disassemble the components check for the fol lowing conditions If stop check valves are used make sure that they are fully open Make sure that the hot and cold inlet
16. 69 1729 ARMATURE HOUSING 6 1 269 1730 CLAMP ARMATURE HOUSING 7 1 269 1731 COIL SOLENOID VALVE 8 3 160 447 SCREW 8 X 5 8 9 1 125 165 O RING 42 013 10 1 125 160 FLOW RESTRICTOR 5 GPM Parts not sold separately Hand Tuned SOLENOID VALVE W CIRCUIT BOARD i ER CLOSED BODY S07 083 i THRU BODY S07 083A i CIRCUIT BOARD luni S83 178 BE i PAN HEAD SCREW 2 6 19 x 3 4 C 160 451 A a VALVE ASSEMBLY CLOSED BODY S07 073 THRU BODY S07 073A Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 Terreon Multi Fount Washfountains Parts and Service Guide Troubleshooting BIR3 Components CAUTION Turn off water supplies to unit before troubleshooting Problem An individual operating station drips and fails to shut off Cause There is debris trapped between the diaphragm and the valve seat Solution Remove debris between diaphragm and the valve seat Disconnect the plug from the battery to the circuit board of the problem valve Remove the three 8 Phillips head screws that hold the solenoid valve assembly together Be careful not to lose the armature or spring see previous page Remove the diaphragm Remove any particles that are trapped between the diaphragm and the valve seat Rinse off the diaphragm and inspect for damage Make sure the center orifice and both small side orifices are open Reassemble in reverse order being careful n
17. cludes Items 2 thru 4 2 3 4 2 128 090 Pushbutton only 2 3 4 3 179 104 Guide for pushbutton 2 3 4 4 147 034 Shoulder Screw for pushbutton 2 3 4 5 182 110 Spacer 2 3 4 6 140 743 Bracket 2 3 4 7 110 115 Nut 2 3 4 S65 168 Actuator Assy Includes items 9 thru 14 2 1 2 S65 168A Actuator Assy Includes itmes 9 thru 15 2 2 9 119 227A Piston 2 3 4 10 125 099 U Cup 2 3 4 11 135 065 Spring 2 3 4 12 118 279 Actuator Body 2 3 4 13 198 010 Duckbill Check 2 3 4 14 169 890 Tube Connector 1 8 straight 2 3 4 15t 269 1186 Fitting Adj J 2 2 16 160 165 Screw 4 6 8 17 R68 600008 R Tubing 1 8 OD Red specify length in feet 17 R68 600008 G Tubing 1 8 OD Green specify length in feet 17 R68 600008 B Tubing 1 8 OD Black specify length in feet 17 R68 600008 Y Tubing 1 8 OD Yellow specify length in feet 18 115 131 Sprayhead 2 3 4 19 176 119 Threaded Rod 4 6 8 20 269 1190 Window Hole Plug 4 6 8 21 140 748 Backplate 2 3 4 22 161 026 Nut 4 6 8 23 142 002BS Lockwasher 4 6 8 24 269 871 Fitting Straight front sprayhead 1 2 25 269 628 Fitting Swivel 90 side sprayheads 2 2 2 26 R68 600011 R Tubing 1 4 ID Red specify Length in feet 26 R68 600011 G Tubing 1 4 ID Green specify Length in feet 26 R68 600011 B Tubing 1 4 ID Black specify Length in feet 26 R68 600011 Y Tubing 1 4 ID Yellow specify Length in feet 27 130 023 Spanner Wr
18. cordance with package instructions 1 30 2008 33 Parts and Service Guide Parts List Bowl Assembly Corner Tri Quad Item Part No Description Qty Qty Qty 1 160 301 Bolt 2 2 2 2 142 002CG Washer 2 2 2 3 140 260 Bracket 2 2 2 4 200 015 Plate 2 2 2 5 142 002CH Lockwasher 2 2 2 6 161 065 Nut 2 2 2 34 Bradley Corporation 215 1447 Rev F EN 07 005A
19. destal Assy 1 2 160 169 Screw 4 20 6 6 8 P10 311 Screw 10 32 1 1 4 146 055 Clip 1 1 5 S04 102 Access Panel Standard Height 1 5 S04 107 Access Panel Standard Height 1 6 147 019 Screw 1 1 ST 132 031 Washer 1 1 Pedestal Assy Item 1 part numbers include the screws and clip Access panel Item 5 part numbers include the screw and washer 30 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Sprayhead Cover Attaching Hardware ain i Corner Fount Tri Fount Quadra Fount Parts List Sprayhead Cover Attaching Hardware Corner Tri Quad Item Part No Description Qty Qty Qty 1 159 367 Anchor Bar 1 2 330 144 Threaded Rod 14 20 x 11 2 2 2 3 161 076 Wing Nut 4 20 2 2 2 4 113 907 Guide Tube 2 5 113 966 Support Tube 1 6 159 377 Anchor Bar 1 Sprayhead Covers Replacement Parts Part Numbers MF2922 Corner Fount Color Covers Color Cover Arctic Chip S04 106AD Lannonstone S04 106S Bluesky S04 106AL London Gray S04 106AP Charcoal S04 106K Mountain Top S04 106AN Cobblestone S04 106T Mystic Moss S04 106AG Contact Bradley for bowl part numbers Coffee Bean S04 106AJ Organic Taupe S04 106AR Cornfield S04 106AK Peppered White S04 106E Empire Gray S04 106 Riverst
20. e piston must be replaced Contact your Bradley representative and ask for Repair Kit part number S65 259 Problem External leaks in the system Cause O rings have been damaged Solution Replace O rings where necessary For replacement of the O rings contact your Bradley representative and ask for Repair Kit part number S65 259 Problem Improper water temperature or temperature fluctuation Cause Thermostat is slowly failing or not working at all Solution Check the thermostat for proper operation 1 At room temperature 80 F or less remove cap and thermostat 2 Place thermostat into container with 115 F water The pushrod should pop out of the thermostat approximately 1 10 3 If thermostat pushrod does not pop out the thermostat must be replaced Contact your Bradley representative and ask for Repair Kit part number S65 259 Cause Valve temperature is not properly set Solution Adjust the temperature Using a blade screwdriver turn the adjustment stem counterclock wise to increase the temperature or clockwise to decrease the temperature Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 23 Terreon Multi Fount Washfountains Parts and Service Guide Vernatherm Thermostatic Mixing Valve S01 524 Repair Kit S65 259 Nut 3 8 24 Hex Jam D e Item Qty escription 5 5 1 Thermostat r 9 Cap o 7 1 O Ring 8 1 O Ring Spring ge 9 Seal Cup 7 Ed Valve Bod
21. e the diaphragm magnet assembly Problem Timing can not be adjusted for more than 5 seconds Cause There is an air leak Solution Check the valve assembly 1 Check all tubing and fittings for proper assembly 2 Tighten cap and nut on 1 8 tubing Problem Pushbutton does not work properly Cause Air volume may not be sufficient to operate valve Solution Check for leaks and lubricate U cup 1 Check all fittings for air leaks 2 Disassemble pushbutton and lubricate U cup seal see pushbutton assembly diagram on page 8 Problem Water is dripping from the streamformers Cause Debris has accumulated on valve seat or orifices Solution Clean and inspect valve seat 1 Remove screws and disassemble metering valve 2 Clean valve seat and inspect for deep gouges or scratches Replace valve body if necessary 3 Remove any debris clogging off center hole in rubber diaphragm Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 13 Terreon Multi Fount Washfountains Parts and Service Guide AST4 amp IR Supply and Mixing Valve Floor and Wall Mounted 3 Floor Mount E 1 UN ft c 2 6 Air Valve Assembly lon p Cold Supply Inlet Vernatherm TMV a pc v Tri Fount Shown o 17 Wall Mount Hot Supply Inlet gt Cold Supply Inlet 9 Air Valve Assembly Quadra Fount Shown Vernatherm TMV Parts List Supply
22. ench 1 1 1 Repair Kit S65 168 incl parts 9 10 11 12 13 t Repair Kit S65 168A incl parts 9 10 11 12 13 15 Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 Parts and Service Guide aoe S 9 a 12 A par USD i lr 11 herd O RS I o MENS LIS ey i j o PE AS S SEK SAAS qu N SS D i SE RO x ate H N Ie LOIN N UEAN P 4 C ey Tri Fount Shown Parts List Air Metering Valve Assembly Corner Tri Quad Item Part No Description Qty Qty Qty 1 S08 452TMA TMA Dual Valve Assembly includes 7 13 1 2 S08 452TL TL Dual Valve Assembly includes 8 14 1 3 S08 453TMA TMA Tri Valve Assembly includes 7 13 1 4 S08 453TL TL Tri Valve Assembly includes 8 14 1 5 S08 454TMA TMA Quad Valve Assmbly includes 7 13 1 6 S08 454TL TL Quad Valve Assmbly includes 8 14 1 7 01 520 Vernatherm Valve 4 GP 1 1 1 8 140 928 Bracket Ganged Valve 1 1 1 9 P18 054 Screw 10 24 x 3 8 PN 2 2 2 10 S07 078A AST4 Valve through 1 2 3 11 S07 078 ASTA Valve closed 1 1 1 12 110 231 Compression Nut 1 4 2 3 4 13 160 447 Screw 8 16 x 5 8 PN 2 3 4 14 S 39 685 Adapter Valve Inlet 1 1 1 10 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains AST4 Valve Repair Kits
23. in Transformer Black Supply Tube From Sprayhead Green Supply Tube From Sprayhead Red Supply Tube From Sprayhead 11 Red Spade Terminal Green Spade Terminal Pd z Black Spade Terminal n White Jumper Terminals Tri Fount Shown Parts List Solenoid Assembly and Valve Parts Corner Tri Quad Item Part No Description Qty Qty Qty 1 S45 2084 IR TMA Dual Valve Assembly includes 7 13 2 S45 2085 IR TL Dual Valve Assembly includes 8 14 3 S45 2090 IR TMA Tri Valve Assembly includes 7 13 1 4 45 2091 IR TL Tri Valve Assembly includes 8 14 1 5 45 2162 IR TMA Quad Valve Assembly includes 7 13 1 6 845 2163 IR TL Quad Valve Assembly includes 8 14 1 7 S01 520 Vernatherm Valve 4 GP 1 1 1 8 140 928 Bracket Ganged Valve 1 1 1 9 P18 054 Screw 10 24 x 3 8 PN 2 2 2 10 S07 068A Solenoid Valve 24 VAC through 1 2 3 11 S07 068 Solenoid Valve 24 VAC closed 1 1 1 12 110 231 Compression Nut 1 4 2 3 4 13 160 447 Screw 8 16 x 5 8 PN 2 3 4 14 39 685 Adapter Valve Inlet 1 1 1 15 S83 152 Transformer 1 1 1 Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 5 Terreon Multi Fount Washfountains Parts and Service Guide Infrared Valve IR Assembly Solenoid Valve S07 068 closed body and S07 068A thru body
24. l Bradley recommends additional care and maintenance for the darker colored Terreon for complete instructions on this additional maintenance see Bradley document 1505 DO NOT USE STRONG ACID OR ALKALINE CHEMICALS AND CLEANSERS TO CLEAN TERREON IF THESES CHEMICALS COME IN CONTACT WITH THE TERREON SURFACE WIPE THEM OFF IMMEDIATELY AND RINSE WITH SOAPY WATER AVOID CONTACT WITH HARSH CHEMICALS SUCH AS PAINT REMOVER BLEACH ACETONE ETC AVOID CONTACT WITH HOT PANS AND OBJECTS Bradley Corporation 215 1447 Rev F EN 07 005A Tip When cleaning units equipped with infrared electronic eye activation it is helpful to turn off the power to the unit or cover the windows to prevent accidental activation After the window is covered the water will run for approximately 30 seconds and then shut off Repair Kits Terreon repair kits are available contact your Bradley repre sentative or distributor for part numbers and pricing NOTE Repair kits are made to order and have a shelf life of 30 days Brand Names Use of brand names is intended only to indicate a type of cleaner This does not constitute an endorsement or does the omission of any brand name cleaner imply it s inadequa cy Many products named are regional in distribution and can be found in local supermarkets department and hard ware stores or through your cleaning service It is emphasized that all products should be used in strict ac
25. on Corner Fount MF2933 Terreon Tri Fount MF2939 Terreon Tri Fount Wall Hung MF2944 Terreon Quadra Fount MF2949 Terreon Quadra Fount Wall Hung MF2922 Air Valve MF2944 MF2933 Shown AST Air Valve Infrared Shown IR i 7 Shown AST MF2939 MF2949 Air Valve Infrared Shown IR Shown AST Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 3 Parts and Service Guide Parts List Infrared Sensor and Sprayhead Assembly Corner Tri Quad Item Part No Description Qty Qty Qty 1 269 1608 Sensor Adaptive 2 3 4 i P10 569 Hook and Loop Fastener Strip sensor mounting 2 3 4 2 269 1190 Window 4 6 8 3 115 131 Sprayhead 2 3 4 4 176 119 Threaded Rod 4 6 8 5 140 748 Backplate 2 3 4 6 161 026 Nut 4 6 8 7 142 002BS Lockwasher 4 6 8 8 269 871 Fitting Straight front sprayhead 1 2 9 269 628 Fitting Swivel 90 side sprayheads 2 2 2 10 R68 600011 R Tubing 1 4 Red Specify Length in feet 10 R68 600011 G Tubing 1 4 Green Specify Length in feet 10 R68 600011 B Tubing 1 4 Black Specify Length in feet 10 R68 600011 Y Tubing 1 4 Yellow Specify Length in feet Not Illustrated 4 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Infrared IR Valves 24V Plug
26. one S04 106AF Graphite S04 106P Stardust S04 106AH Hillside S04 106AM Summer Sage S04 106AE Jade S04 106N White Sand S04 106W Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 31 Terreon Multi Fount Washfountains Parts and Service Guide Sprayhead Cover Replacement Parts Continued Part Numbers MF2922 MF2939 Part Numbers MF2944 MF2949 Tri Fount Quadra Fount Color Covers Color Cover Color Covers Color Cover Arctic Chip S04 104AD Lannonstone S04 1048 Arctic Chip S04 105AD Lannonstone 04 105S Bluesky S04 104AL London Gray S04 104AP Bluesky S04 105AL London Gray S04 105AP Charcoal S04 104K Mountain Top S04 104AN Charcoal S04 105K Mountain Top S04 105AN Cobblestone S04 104T Mystic Moss S04 104AG Cobblestone S04 105T Mystic Moss S04 105AG Coffee Bean S04 104AJ Organic Taupe S04 104AR Coffee Bean S04 105AJ Organic Taupe S04 105AR Cornfield S04 104AK Peppered White S04 104E Cornfield S04 105AK Peppered White S04 105E Empire Gray S04 104 Riverstone S04 104AF Empire Gray S04 105 Riverstone S04 105AF Graphite S04 104P Stardust S04 104AH Graphite S04 105P Stardust S04 105AH Hillside S04 104AM Summer Sage S04 104AE Hillside S04 105AM Summer Sage S04 105AE Jade S04104N White Sand S04 104W Jade S04 105N White Sand S04 105W Pedestal Panels Lent Panels Shown Panel Part
27. ot to overtighten the Phillips head screws or you may crack the plastic valve body Tighten until the armature plate makes contact with the plastic body Reconnect the battery plug per dia gram Turn on water supplies to the unit Problem An individual operating station fails to turn on or off Cause Excessive line pressure Solution Install Pressure Reducing Valve Check the static line pressure If the pressure exceeds 80 psi install a pressure reducer valve at the street main Excessive line pressure over 60 psi will shorten the life of any valve Problem An individual operating station fails to turn on or off Cause A dead or faulty battery Solution Test the station to determine cause and replace battery if required Disconnect the plug from the battery to the circuit board of the problem valve Disconnect the plug from the battery to the circuit board of an adjacent valve Connect the battery plug from the adjacent working valve to the problem valve Wait for ten seconds Activate the problem station s sensor ten times The station should turn on If the station turns on and cycles normally replace the battery Cause Faulty sensor eyes Solution Test station to determine cause replace sensor eyes if required Disconnect the sensor cable from the circuit board of the problem valve Disconnect the sensor cable from the circuit board of an adjacent working valve Connect the sensor cable from the adjacen
28. pH levels higher than 8 5 will cause swelling or degradation of rubber and plastic parts and skin irritation Generally any quality soap meeting the viscosity and pH guidelines above will work well with Bradley soap dispensers PCMX or Isapropanol based antibacterial soaps within viscosity and pH limits will also work with Bradley dispensers Soaps satisfying these basic guidelines will provide consistent flow and reduce clogs Most soap dispenser problems are caused by soap that is too thick or corrosive or by a lack of maintenance Many soaps come in concentrate form which must be diluted with water Often the soap is improperly diluted or used straight out of the bottle which causes clogging and valve failure If proper soap is being used valves that have never been cleaned are usually the source of dispensing problems Bradley has entered into an agree ment with Champion Brand Products to provide additional customer service for purchasers of our dispensers regarding soap issues They are very helpful and can get to the bottom of almost any soap dispenser related problem They also sell an excellent Bradley approved soap Please see Soap Instruction Sheet 215 1286 for details about soap valve cleaning or how to contact Champion With proper maintenance and soap Bradley dispensers will provide long term trouble free operation SOAP DISPENSER MAINTENANCE INSTRUCTIONS Multi Fount Washfountains Bradley soap dispensers will provide de
29. pendable consistent operation over the long term when the proper soap is used and when a minimal amount of periodic maintenance is performed on the valves Valves must be maintained cleaned to function properly To ensure proper operation of your soap dispenser follow these instructions Once per month remove the cap from the soap tank and insert the draw tube below the cap into hot water and soak it for 30 minutes Push valve at least 20 times while it is soaking Flush soap reservoir with hot water while valve is soaking In cases of extreme clogging the valve should be disassembled and the parts should be soaked in hot water or cleaning solution to restore proper functioning Soap dispensers that will not be used for extended periods of time schools during summer break etc should be drained cleaned and left empty until put back into service Soap left on the outside of dispensers can cause discoloration and corrosion of the reservoir even on stainless steel units All soap should be wiped or scrubbed off daily then the outside of the dispenser should be rinsed with clear water and dried with a soft cloth Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 27 Spud Washer part of Item 3 1 Spud Locknut part of Item 3 Parts List Item Part No Qty Description 1 173 023 1 Dome Strainer 2 160 132 2 Screw 10 24 x 1 2 for strainer 3 112 029 1 Drain Spud
30. pipes are connected properly and that there are no cross connections or leaking stop check valves Check the hot water heater output to make sure that it is at least 20 F above the set tempera ture Be sure to close the appropriate shut off valves prior to disassembly of the valve and reopen the valves after inspection and repair is complete Problem Limited water flow Cause Dirt and debris have built up in the valve or strainer Remove and clean strainer see Figures on next page If strainer needs to be replaced order Bradley part no 173 028 2 Check the piston for smooth movement To check the valve s piston for free and smooth movement follow the procedures outlined below 1 Remove the valve s cap and thermostat see next Page 2 Push down on the piston with your finger the piston should move freely If the movement is not as it should be the piston needs to be cleaned Follow the method outlined below for clean ing the piston and valve body Remove the thermostat Lift the piston out with a needle nose pliers and remove the spring Any cleaner suitable for brass and stainless steel may be used if cleaning with suitable cleaner is not sufficient to remove debris a 400 grit sandpaper may be used to polish and hone the pis ton and valve body e Snap spring into piston will detent and reassemble into the valve body Retest the piston 3 If after a thorough cleaning the piston does not move freely th
31. stance 18 1 30 2008 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains TouchTime TT Sprayhead 24V Plug in Transformer Parts List TouchTime Switch and Sprayhead Corner Part No Description Qty 1 83 139B Switch Touchtime 2 3 4 2 269 1190 Window 4 6 8 3 115 131 Sprayhead 2 3 4 4 176 119 Threaded Rod 4 6 8 5 140 748 Backplate 2 3 4 6 161 026 Nut 4 6 8 7 142 002BS Lockwasher 4 6 8 8 269 871 Fitting Straight front sprayhead 1 2 9 269 628 Fitting Swivel 90 side sprayheads 2 2 2 10 R68 600011 R Tubing 1 4 Red Specify Length in feet 10 R68 600011 G Tubing 1 4 Green Specify Length in feet 10 R68 600011 B Tubing 1 4 Black Specify Length in feet 10 R68 600011 Y Tubing 1 4 Yellow Specify Length in feet 11 182 115 Spacer 2 3 4 12 110 115 Nut 1 2 14 2 3 4 13 130 023 Spanner Wrench 1 1 1 Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 19 Terreon Multi Fount Washfountains Parts and Service Guide TouchTime Metering Valve TT Assembly Black Supply Tube Green Supply Tube From Sprayhead From Sprayhead 10 gq Red Supply Tube RQ From Sprayhead ONA SN z 18 GG y aXsXe Eg S Gray Wires Cy sS 7 XS A Tri Fount Shown T Isl Es Supply Inlet j R LAU 8 2 EE Brown Wires
32. t working valve to the problem valve Activate the problem station s sensor The station should turn on If the station turns on and cycles normally replace the sensor eyes Cause Faulty solenoid valve Solution Test station to determine cause replace solenoid valve if required Remove the screw circuit board and standoff from the problem valve Remove the battery holder With a good working battery briefly contact the solenoid valve directly with the battery as shown in the Open Valve figure The contact should cause the valve to open With the battery holder removed briefly contact the sole noid valve with the battery in the position shown in the Closed Valve Figure This should cause the valve to close If the valve does not operate when directly contact ed with a good battery and the solenoid valve has already been cleaned as outlined BSED VALVE at the beginning of this troubleshooting section replace the solenoid valve If problems persist Pass your hand in front of the problem station while at the same time looking to see if the indicator light on the cir cuit board flashes the indicator light is located near the hole in the circuit board where the standoff is mounted If it does not flash and the battery and sensor eyes have already been tested as outlined above the problem may be with the circuit board Make a note of the numbers printed on the circuit board then contact your Bradley represen _tative for assi
33. y Strainer E CKE E 173 028 3 Tempered Line Adapter Assembly 839 685 Option Strainer 173 028 Ng 1 30 2008 24 Bradley Corporation 215 1447 Rev F EN 07 005A Parts and Service Guide Terreon Multi Fount Washfountains Soap System Parts List Soap Valve S09 083 Item Part No Qty Description S09 083 1 Soap Valve Complete 1 S64 096 1 Plunger Assy 2 110 227A 1 Collar 3 160 239 1 Set Screw 4 125 168 1 O Ring 5 198 013 2 Seat Assy 6 135 097 1 Spring 7 144 068M 1 Cylinder 8 R68 800002 1 Tube 3 8 ID Specify length in feet iE AE 72555 NNUS Avus m WARE OW NS NES NAVAN Sy pa Bradley Corporation 215 1447 Rev F EN 07 005A 1 30 2008 25 Parts and Service Guide Parts List Soap System ITEM PART NO DESCRIPTION QTY 1 240 001 SOAP TANK 1 2 169 989 HOSE 5 8 ID x 3 146 040 HOSE CLAMP 1 4 169 916 MALE FITTING 1 5 110 093 NUT 1 6 142 002CJ WASHER 1 7 153 174 FILLER 1 8 136 011 SOAP FILLER CAP 1 9 R68 600021 TUBE VENT 3 16 10 136 049 SOAP TANK CAP 1 11 269 1832 BULKHEAD FITTING 1 12 R68 800002 TUBE SUPPLY 1 2 13 269 1833 TEE 1 14 110 115 NUT 2 15 142 000CB WASHER 2 16 852 109 SOAP VALVE BODY ASSY 2 17 S09 083 SOAP VALVE 2 18 130 142 SOAP FILLER CAP WRENCH 1 19 161 026 NUT 2 20 142 002AV WASHER 2
Download Pdf Manuals
Related Search