American Standard Bordeaux Vanity and Mirror 9532.200 User's Manual
Contents
1. FINISHED FLOOR Product names listed herein are trademarks of American Standard Inc American Standard Inc 2002 22 3 4 578mm 24 3 4 629mm DOORS SWING approx 150 DEPTH WITH DOORS 1 2 OPEN 32 WIDTH WITH BOTH DOORS FULL OPEN 47 1 2 lt 3 Phillips Screwdriver gt Regular Screwdriver 21 1 4 __ 540mm ol oO B o o 730548 100 Rev B VANITY INSTALLATION Provide suitable reinforcement required for anchoring the vanity to the wall Centerline of reinforcement should be 32 3 4 up from the floor see Figure 1 The molding needs to be notched to seat the vanity flush against the wall see Figure 2 Rough in supply lines and waste per rough in dimensions NOTE If current supply lines are greater than 6 on center they may interfere with cutout in rear of vanity or vanity shelf Remove the wood top from the vanity The top is held in place from the underside by 4 screws 1 through each of the 4 angled corner braces Move the vanity into place and anchor it to the wall through at least 2 of the anchoring holes in the rear of the vanity see Figure 2 Continue with installation appropriate for top and sink options chosen 21 1 4 540mm C L of 2x6 N ent Reinforcem NCHORING HOLES 32 3 42. FIGURE 1 FIGURE 2 32 3 4 832mm Finished Floor MOLDING Wood Top with Recommended Sinks PAPER TEMPLATE Two people recommended for this installation o O Do O Determine which sink is being installed and follow the instructions printed on the appropriate template supplied with vanity NOTE American Standard is not responsible for cut out errors when the incorrect cut out template is used WOOD VANITY TOP If Installing Use Template Sebring 0573 730541 400 Coventry 0575 730542 400 t a IMPORTANT BE SURE TO CENTER SINK CUT OUT HORIZONTALLY ON VANITY TOP After top is replaced connect the trap to the drain assembly hand tight to check alignment It may be necessary to cut off part of the tailpiece area A or part horizontal leg of the trap area B Connect hot and cold supply lines to the shut off valves Tighten trap joints for watertight assembly _2 730548 100 Rev B Optional marble top 9532 495 with Ovalyn 0495 undermount sink Two people recommended for this installation NOTE Marble top comes pre cut for the Ovalyn under counter mount sink and 8 faucet spread Also it is strongly recommended to seal the marble top after installation and prior to use Remove wood top if not already done Mount the drain assembly not included on the sink Be certain to apply a bead of sealing putty
3. waxes Clean up excess water and spills immediately Use a blotting rather than a wiping action Water left over a long period of time will cause white spots in the finish NOTE Please note that some chemicals may damage the finish Take care to avoid the following iodine hair dye after shave lotion shaving cream alcohol perfume Lestoil Lysol Tub and Tile Cleaner Lysol Spray Disinfectant Dow Disinfectant acetone paint remover Formula 409 Tile X and Nair Care and Cleaning of the Marble Vanity Top Marble is porous and easily stained Wipe off anything spilled on it immediately It should be washed or cleaned regularly with fresh warm water and a non abrasive clean cloth Also using a non abrasive neutral pH balanced cleaner will help remove dirt and grime but it is recommended to first try warm water only Marble should be sealed regularly with a good quality marble sealer Marble sealers are available at most retail home supply stores Follow the instructions on the sealer container for proper application and frequency of use The sealer acts as a stain inhibitor and prevents most stains and soil from being absorbed into the porous surface but it is NOT a guarantee against staining All spills should be cleaned immediately Avoid contact with all oils and petroleum based products Also avoid contact with all acid or caustic products such as vinegar citrus or fruit juices soda chlorine and nail polish remover I
4. American Standard ASSEMBLY amp INSTALLATION INSTRUCTIONS Bordeaux 32 Vanity with Wood Top 9532 200 VANITY TOP RECOMMENDED SINKS SEBRING 0573 COVENTRY 0575 WOOD TOP SUPPLIED MARBLE TOP OPTIONAL 9532 495 OVALYN 0495 221 Thank you for selecting our products products which have been the benchmarks of fine quality for over 100 years To help insure that the installation process will proceed smoothly please read these instructions carefully before you begin Also review the recommended tools and materials list carefully unpack and examine your new plumbing fixture To maintain the beauty of the finish avoid placing the furniture in direct sunlight as sunlight causes fading Also avoid extreme changes in temperature by arranging furniture away from radiators heat and air vents and air conditioning units Avoid placing furniture directly under windows Recommended Tools amp Materials AW Adjustable Wrench Basin Wrench Tubing Cutter Channel Locks Al P Plumbers Putty or Caulking Roughing in Dimensions 32 3 8 6 152mm Hacksaw Pipe Wrench Putty Knife Tape al Saber Saw Me 822mm S 6 p asure ANCHORING HOLES 1 A 35 5 8 981mm for Wood top A 35 3 4 908mm for Marble top AS REC S
5. e of installation if it has been subjected to faulty maintenance abuse misuse accident or other damages if it was not installed in accordance with American Standard s instructions or if it has been modified in a manner inconsistent with the product as shipped by American Standard American Standard s option to repair or exchange the product under this warranty does not cover any labor or other costs of removal or installation nor shall American Standard be responsible for any other incidental or consequential damages attributable to a product defect or to the repair or exchange of a defective product all of which are expressly excluded from this warranty Some states or provinces do not allow the exclusion or limitation of implied warranties so this exclusion may not apply to you This warranty gives you specific legal rights You may have other statutory rights that vary from state to state or province to province in which case this warranty does not affect such statutory rights In the United States In Canada In Mexico American Standard Inc American Standard Customer Service Manager P O Box 6820 2480 Stanfield Rd Ideal Standard S A de C V Piscataway New Jersey 08855 Mississauga Ontario Via Morelos 330 Attention Director of Consumer Affairs Canada L4Y 1S2 Col Santa Clara Ecatepec 55540 Edo Mexico For residents of the United States warranty information Toll Free 800 387 0369 may also be obtained by calling the follow
6. f the marble is well sealed the warm water and non abrasive cloth should keep it clean we 730548 100 Rev B AMERICAN STANDARD GRANITE MARBLE TABLE TOP WARRANTY If inspection of this American Standard plumbing product within one year after its initial purchase confirms that it is defective in materials or workmanship American Standard will repair or at its option exchange the product for a similar model Variations in shading veining and texture which may result from natural characteristics of stone and as such are not defects and are not covered by this warranty This warranty applies only to the original purchaser and installation of these products This limited warranty does not apply to local building code compliance Since local building codes vary considerably the purchaser of this product should check with a local building or plumbing contractor to insure local code compliance before installation This warranty shall be void if the product has been moved from its initial place of installation if it has been subjected to faulty maintenance abuse misuse accident or other damages if it was not installed in accordance with American Standard s instructions or if it has been modified in a manner inconsistent with the product as shipped by American Standard American Standard s option to repair or exchange the product under this warranty does not cover any labor or other costs of removal or installation nor shall American Standa
7. ing toll free number 800 442 1902 REPAIR PART NO DESCRIPTION 738634 0070A DOOR ROLLER CATCH 1 PAIR 738635 0070A SHELF PINS 8 PER PACk 738641 0070A UPPER PANEL HARDWARE KNOB 1 PIECE 738644 0070A DOOR KEY PULL 1 PIECE 738642 0070A DOOR KEY BACK PLATE 1 PIECE 738639 0070A NAIL IN FOOT GLIDE 4 PER PACK 738778 0070A REPLACEMENT MOUNTING KIT 243 4 SCREWS M6 X 2 5 INSERTS AND WASHERS 738776 2550A FURNITURE TOUCH UP MARKER AGED CHESTNUT Ye 730548 100 Rev B
8. on the underside of the drain Part A in order to ensure a watertight seal between the sink and drain Remove excess putty after installing the drain on the sink Turn the marble top upside down and place it on a clean scratch resistant surface Apply a bead of silicone adhesive to the rim of the sink Center the sink over the cutout and secure it to the top using the mounting kit provided NOTE Brass inserts are preinstalled on the underside of the marble top Use the 4 brackets supplied with the sink mounting kit and the 4 screws supplied with the marble top Turn the top right side up and install the faucet per the manufacturer s instructions Apply a bead of silicone adhesive to the rim of the vanity Place the marble top centered left to right on the vanity and with the back edge of the top even with the rear of the vanity Clean up any excess silicone Connect the trap to the drain assembly hand tight to check alignment It may be necessary to cut off part of the tailpiece area A or part horizontal leg of the trap area B Connect hot and cold supply lines to the shut off valves Tighten trap joints for watertight assembly Care and Cleaning of Vanity Dust the vanity frequently with a clean soft dry lint free cloth as well as polish it on a regular basis Clean the surface by rubbing in the direction of the grain Use polishes that contain detergents emulsifiers and mineral oil Avoid using silicone cleaners and
9. rd be responsible for any other incidental or consequential damages attributable to a product defect or to the repair or exchange of a defective product all of which are expressly excluded from this warranty Some states or provinces do not allow the exclusion or limitation of implied warranties so this exclusion may not apply to you This warranty gives you specific legal rights You may have other statutory rights that vary from state to state or province to province in which case this warranty does not affect such statutory rights AMERICAN STANDARD WOOD FURNITURE WARRANTY If inspection of this American Standard plumbing product within one year after its initial purchase confirms that it is defective in materials or workmanship American Standard will repair or at its option exchange the product for a similar model Variations in actual wood color and finishes which may result from natural characteristics of the wood such as grain patterns mineral streaks and the like are not defects and are not covered by this warranty This warranty applies only to the original purchaser and installation of these products This limited warranty does not apply to local building code compliance Since local building codes vary considerably the purchaser of this product should check with a local building or plumbing contractor to insure local code compliance before installation This warranty shall be void if the product has been moved from its initial plac
Download Pdf Manuals
Related Search