Frigidaire FD27NKEC (NG) Grill
Contents
1. Keep your face as far away from the burner as possible and place a lit long stem match through the spaces in the grate to the ports of the burner Position the match near the burner ports and push and turn the control knob to the HIGH position 24 A Care amp Maintenance DRIP TRAY The drip tray located below the grill inside the cart should be cleaned periodically to prevent heavy buildup of debris NOTE Allow the drip tray to cool before attempting to clean Important Do not leave the grill outside during inclement weather unless it is covered cover sold separately Rain water can collect inside the grill the grill cart or the drip tray if left uncovered If the drip tray is not cleaned after use and the grill is left uncovered the drip tray will fill with water causing grease and water to spill into the grill cart We recommend cleaning and storing the drip tray after every use COOKING GRATES The cooking grates can be cleaned immediately after cooking is completed and after turning off the grill Wear a barbecue mitt and scrub the cooking grates with a damp cloth If the grill is allowed to cool down cleaning the grates will be easier if removed from the grill and cleaned with a mild detergent STAINLESS STEEL After initial usage areas of the grill may discolor from the intense heat given off by the burners This is normal Purchase a mild stainless steel cleaner and rub in the direction of the grain of the m2. Note Some flare ups may be inevitable if cooking greasy foods e Check the burner inlet for obstructions particularly at air inlets for each burner e Grill may be in an area that is too windy e Loosen the four 1 4 bolts under the grill hood that hold grill to cart Slide grill head left or right as needed until door is aligned properly Retighten bolts WARNING Move grill head gently to the left or right on the cart After the four bolts have been loosened the grill is not attached to the cart and could fall causing damage or physical injury Warranty LIMITED LIFETIME WARRANTY Frigidaire grills have a limited lifetime warranty on all stainless steel panels a limited 3 year warranty on stainless steel burners including labor within one year of the date of purchase and a limited 1 year warranty on all other parts labor included In the U S A your appliance is warranted by Electrolux Home Products North America We authorize no person to change or add to any of our obligations under this warranty Our obligations for service and parts under this warranty must be performed by an authorized Electrolux Home Products North America qualified service technician WARRANTY THROUGH OUR AUTHORIZED SERVICERS WE WILL THE CONSUMER WILL BE RESPONSIBLE FOR PERIOD LIMITED ONE YEAR One year from Pay all costs for repairing or replacing any parts of this Costs of service calls that are listed under NORMAL WARRANTY Original purchase a
3. electrodes e Check to see if debris is blocking the electrodes e If the igniter is not working can you light the grill with a match 26 PROBLEM Grill will not light with a match or low heat with dial set to High position Flame is erratic Flare ups Burner flame is mostly yellow or orange possibly in conjunction with smell of gas Cart door does not align properly with cart 27 Troubleshooting Your Grill SOLUTION e Is your gas supply fully turned on e If this is an L P grill is there gas in your tank Check your gas level e f this is an L P grill shut off gas supply disconnect gas line at tank reconnect the line to the tank e Make sure all the knobs are in the off position Open the gas supply valve on the L P tank very slowly 1 4 turn then open fully at least two full turns Check flame height again e Ensure the gas supply line or hose is not kinked e If only one burner appears low check and clean the burner ports if clogged or dirty e Check for leaks Note Pre Heating time can take from 5 to 10 minutes e Check gas connection Look for kinked hose Make sure gas supply valve is fully open e Gas level may be low e Grill may be in need of cleaning e Check flavor grids and cooking grates for excess food or grease build up e Ensure grill is not placed directly in the path of wind e Be sure drip tray is clean do not use aluminum foil on drip tray
4. fitting not included See Fig 7 16 Gas Requirements L P GAS INSTALLATION Frigidaire Gas Grills that are set to operate with L P gas come with a high capacity hose and regulator assembly Note Only use the pressure regulator and hose assembly supplied with the grill or a replacement pressure regulator and hose assemblies specified by Frigidaire This assembly is designed to connect directly to a standard 20 Ib L P cylinder L P cylinders are not included with the grill L P cylinders can be purchased separately at an independent dealer Shutoff regulator supplied with grill Type 1 connector Ensure that the black plastic grommets on the L P cylinder valve are in place and that the hose does not come into contact with the grease tray or the grill head L P TANK INFORMATION Never use a dented or rusted L P tank or cylinder with a damaged valve The cylinder used must include a collar to protect the cylinder valve L P cylinders are equipped with an O P D Overfilling Prevention Device The device shuts off the flow of gas to a cylinder after 80 capacity is reached This limits the potential for release of gas when the cylinder is heated averting a fire or possible injury The L P cylinder must have a shut off valve terminating in an L P gas supply cylinder outlet specified as applicable for connection No 510 in the standard for compressed gas cyl
5. smell gas 1 Shut off gas to the appliance 2 Extinguish any open flames 3 Open grill hood 4 If odor continues immediately call your gas supplier CALIFORNIA PROPOSITION 65 WARNING The burning of gas efoto dare fuels generates some FOR YOUR SAFETY byproducts which are on the list of substances which are known by the State of California to DO NOT store or use gasoline or other flammable cause cancer or reproductive harm California law vapors and liquids in the vicinity of this or any other requires businesses to warn customers of potential appliance exposure to such substances To minimize exposure to these substances always operate this unit according to the Use and Care Manual Provide good ventilation when cooking with gas An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance WARNING This appliance is not intended to be DO NOT try lighting this appliance without reading installed in or on recreational the LIGHTING THE GRILL section of this manual vehicles or boats FOR OUTDOOR USE ONLY Grill Features FD27 FD27LKEC Control knob Main burner Control knob Rear infrared burner Control knob Main burner Electronic igniter Main and rear infrared burner Control panel Control knob Main burner Hood handle Warming shelf Co 10 11 12 13 9 Rear infrared burner 10 Tool bar 11 Electronic ignit
6. LE SHOOTING You should inspect the burners at least once a year or immediately if any of the following conditions occur e The smell of gas e Flames appearing mostly yellow Some yellow at the tips is OK e The grill will not get hot enough e Burners make a snapping noise e The grill heats unevenly SPIDER AND INSECT WARNING Spider and insects can nest in the burners of this or any other grill and cause the gas to flow from the front of the burner This is very dangerous condition which can cause a fire to occur behind the valve panel thereby damaging the grill and making it unsafe to operate We recommend you check the grill and remove any spiders insects and webs at least once a year to reduce this risk BEFORE CALLING CUSTOMER SERVICE If the grill does not function properly use the following checklist PROBLEM SOLUTION Grill will not light when the igniter button is e Is your gas supply turned on pushed e f this is an L P grill is there gas in your tank Check your gas level els one of your burners turned on Allow up to four seconds of gas flow to ignite e Is your igniter working You should hear a snapping sound when you press the igniter If you hear a Snapping sound can you see a spark at the electrodes Note You will need to remove your cooking grates and flavor grids to see the electrodes e Check your igniter battery and replace if needed e Check for loose wire connections to the igniter or
7. N N s ZN K N as N N NY aS N N N Ba NY Si s i LOE 7 i i Lo N N 2 f NS l NN Ps N lt lt l hN ane ae NS J i l uS EN i i CN IX l i f Y is is XS N w Se i KA ASAS i y SO Re Ne W NY Ne a NG AR N WNO N KK gt Me So ANN A J ALAA oe ee oe SF OSS KORO SS Se R A H lt i ge Sy SSeS INN FNNA de 7 NEW N E AN So AN ae UN l A NASS vi AADA NA K N Y NN ALN S gt AX NN XK N WOR EPA KKK T A W bau NON en Q A S Y Xe PN NN WN i AK RAK a gt Vi NS E E ee OL 14 Ei 1 ED Gas Requirements GENERAL INFORMATION i Never attach an unregulated gas line to the appliance Connection to an unregulated gas F l A WARNING line can cause excessive heat or fire Verify the type of gas supply to be used either Natural Gas N G or Liquid Propane L P and make sure the serial plate agrees with that of the supply Conversion kits are available separately for an additional cost which will enable you to convert your grill from L P to N G or to convert your grill from N G to L P Please see your Frigidaire dealer for more information NOTE Always have a qualified service technician perform difficult conversions or modifications For natural gas installations an installer must supply a gas shutoff valve that is easily accessible to the grill All installer supplied parts must conform to local c
8. Use amp Care Manual Assembly Instructions Included 27 Stainless Steel Outdoor Grill with Electronic Ignition Visit the Frigidaire Web Site at http www frigidaire com READ AND SAVE THESE INSTRUCTIONS Welcome Product Registration General Safety Instructions Grill Features and Components Grill Assembly Gas Requirements Pre Operation Leak Testing Lighting the Grill Using the Grill Using the Rotisserie amp Side Burners wsssssennnnnnnae Care amp Maintenance 0 ssecscseeeeees Troubleshooting Your Grrill Warranty dense enateeneceesene seeennescncesisesnessncucs Welcome amp Congratulations Congratulations on your purchase of a new grill We at Electrolux Home Products are very proud of our product and we are completely committed to providing you with the best service possible Your satisfaction is our 1 priority Please read this Use amp Care Manual very carefully It contains valuable information on how to properly maintain your new grill We know you ll enjoy your new grill and thank you for choosing our product We hope you consider us for future purchases PLEASE READ AND SAVE THESE INSTRUCTIONS This Use amp Care Manual provides specific operating instructions for your model Use your grill only as instructed in this manual These instructions are not m
9. as supplier should refill the L P tank e Do not store a spare L P gas cylinder under or near the grill e The cylinder used must include a collar to protect the cylinder valve 17 Gas Requirements CONNECTION Your grill is equipped with gas supply orifices for use only with liquid propane gas It is also equipped with a high capacity hose regulator assembly for connection to a standard 20 Ib L P cylinder 18 1 4 high 12 1 4 diameter To connect the L P gas supply cylinder See Fig 8 1 2 3 4 Make sure tank valve is in its full OFF position turn clockwise to stop Check tank valve to ensure it has proper external male threads type 1 connection per ANSI 221 81 Make sure all burner valves are in the OFF position Inspect valve connections port and regulator assembly Look for any damage or debris Remove any debris Inspect hose for damage Never attempt to use damaged or obstructed equipment See your local L P gas dealer for repair When connecting regulator assembly to the valve hand tighten the nut clockwise to a complete stop Do not use a wrench to tighten Use of a wrench may damage the quick coupling nut and result in a hazardous condition Open the tank valve fully counterclockwise Use a soapy water solution to check all connections for leaks before attempting to light the grill See next page If a leak is found turn the tank valve off and do not use the grill until a local L P ga
10. e gas supply and call your local gas gas company or the dealer from which you purchased the appliance If necessary replace the faulty part with the manufacturer s recommended replacement part A slight leak could cause a fire 19 Lighting the Grill BEFORE LIGHTING Do not attempt to EUT ie Important Before Lighting Light the grill if the i 1 Check the gas supply line for cuts wear or abrasion odor of gas is present Always keep your face and body as far away from the grill as possible when lighting GRILL BURNER LIGHTING Lighting the Grill with the Electronic Igniter 1 Make sure all control Knobs are in the OFF position 2 Open the gas supply valve located on top of your L P tank ATTENTION When turning the L P tank on make sure to open the valve very SLOWLY two 2 complete turns to ensure proper gas flow 3 Always open the hood before attempting to light 4 Push and turn one of the control knobs counterclockwise to the HIGH position and immediately press the electronic igniter button You will hear a snapping sound It may be necessary to hold the electronic igniter button for about 4 seconds See Fig 9 NOTE If the burner does not light in 4 seconds turn the knob to the OFF position and wait 5 minutes before trying again 5 Repeat above steps to light remaining burners NOTE If the grill will not light after several attempts see the troubleshooting section of t
11. eant to cover every possible condition and situation that may occur Common sense and caution must be practiced when installing operating and maintaining any appliance Please record your model and serial numbers below for future reference This information is found on the serial plate located on the back of the built in grill or on the inside of the cart door complete grill amp cart model NOTE Use only soap and water to clean the serial plate Model Number Serial Number Purchase Date Gas Type Please complete and mail in the Product Registration Card included with your grill Please retain this manual for future reference Questions 1 800 Frigidaire Register Your Product The PRODUCT REGISTRATION CARD should be filled in completely signed and returned to Electrolux Home Products North America Please attach sales receipt here for future reference 2004 Electrolux Home Products Inc All rights reserved General Safety Instructions IMPORTANT SAFETY INFORMATION Read this manual carefully before using your grill to reduce the risk of fire burn hazard or other injury Extreme care should be used because of the high temperatures produced by this appliance CHILDREN SHOULD NOT BE LEFT UNATTENDED IN AN AREA WHERE THE GRILL IS BEING OPERATED This appliance must be kept clear from combustible materials gasoline or other flammable vapors and liquids Do not allow flammable materials to come in c
12. er side burner 12 Control knob side burner 13 Front door Grill Assembly SIDE SHELF ATTACHMENT 1 Remove the side burner together with the gas hose from the front door Make sure the hose is in good condition before installing the side burner See Fig 1 2 The screws used to attach the side shelf and side burner are already screwed into the two side panels Remove the screws from the side panels See Fig 2 Align with the holes in the left side shelf and then re attach into the holes on the left side panel of the grill Repeat the above steps to install the right side burner on right side panel 5 Store extra hose inside the burner body after removing the hose cover oe Fig 1 13 Grill Assembly SIDE BURNER HANDLE ASSEMBLY 1 To assemble the side burner lid handle open the lid then cut off the plastic tie in the screw hole Install the handle in the lid as shown See Fig 3 2 Remove the two screws from the handle Align with the holes in the side burner then re attach into the holes on the stand of the handle and tighten up the screws See Fig 4 NS S N S oI N1 SK SS N N aN N BN S amp n N N 56 IN S N LN N S LON N N ns s hs T 0 ae S N S 8 g DS ON N bs N AS N is
13. etal Specks of grease can gather on the surface of the stainless steel and bake on to the surface and give a worn appearance For removal use a non abrasive oven cleaner in conjunction with a stainless cleaner NOTE Always scrub in the direction of the grain IGNITER ACCESS UNDER MAIN BURNER To remove igniter unscrew igniter push button and locking nut from front panel of the main burner and igniter will fall out through the bottom IGNITER ASSEMBLY 1 The battery spring and igniter cap must be installed before using 2 Install the battery positive side facing toward you 3 Slide spring assembly over battery 4 Screw igniter cap onto igniter MAINTENANCE GUIDELINES 1 Keep outdoor cooking gas appliance area clear and free from combustible materials gasoline and other flammable vapors and liquids 2 Donot obstruct the flow of combustion and ventilation air 3 Keep the ventilation opening s of the cylinder enclosure free and clear from debris 4 Visually check burner flames Burner flames should be blue and stable with no yellow tips excessive noise or lifting If any of these conditions exist call our customer service line 5 Clean outdoor cooking gas appliance including special surfaces with recommended cleaning agents if necessary 6 Check and clean burner venturi tubes for insects and insect nests A clogged tube can lead to a fire beneath the grill 25 Troubleshooting Your Grill a GENERAL TROUB
14. following 1 CONSEQUENTIAL OR INCIDENTAL DAMAGES SUCH AS PROPERTY DAMAGE AND INCIDENTAL EXPENSES RESULTING FROM ANY BREACH OF THIS WRITTEN OR ANY IMPLIED WARRANTY NOTE Some states do not allow the exclusion or limitation of incidental or consequential damages so this limitation or exclusion may not apply to you 2 Service calls which do not involve malfunction or defects in workmanship or material or for appliances not in ordinary household use The consumer shall pay for such service calls 3 Damages caused by services performed by servicers other than Electrolux Home Products North America or its authorized servicers use of parts other than genuine Electrolux Home Products parts or parts obtained from persons other than authorized servicers or external causes such as abuse misuse inadequate power supply or acts of God Products with original serial numbers that have been removed or altered and cannot be readily determined 5 All other warranties including implied warranties of merchantability and fitness for a particular prupose which are expressly excluded consequential or incidental damages resulting from breach of warranty which are expressly excluded 6 This limited warranty does not cover corrosion or discoloring due to lack of maintenance misuse hostile environments alterations accidents or abuse or neglect 7 This limited warranty does not cover any scratches dents corrosion or discoloring by heat abrasive and c
15. hemical cleaners nor any components used in the installation of the appliance IF YOU NEED Keep your bill of sale delivery slip or some other appropriate payment record The date on the bill establishes the SERVICE warranty period should service be required If service is performed it is in your best interest to obtain and keep all receipts This written warranty gives you specific legal rights You may also have other rights that vary from state to state Service under this warranty must be obtained by contacting Electrolux Home Products This warranty only applies in the 50 States of the U S A Puerto Rico and Canada Product features or specifications as described or illustrated are subject to change without notice In the U S A all warranties are made by Electrolux Home Products North America In Canada your appliance is warranted by Electrolux Canada Corp If you have any other questions please contact the Customer Service Hotline at 1 800 Frigidaire Because of continuing product improvements these specifications are subject to change without notice 28
16. his manual Turn the control knobs to the OFF position when not in use 20 h Lighting the Grill MATCH LIGHTING If the burner will not light after several attempts then the burner can be match lit If you have already attempted to light the burner with the igniter allow 5 minutes for any accumulated gas to dissipate Keep your face and hands as far away from the grill as possible Insert a lit extended match or lighter through the cooking grids to the burner Press the control knob and rotate left to the HIGH setting and continue to press the knob until the burner ignites Burner should light immediately quickly remove your hand to avoid getting burned If the burner does not light in 4 seconds turn the knob off wait 5 minutes and try again 21 Using the Grill i GRILL LOCATION Do not use the grill in garages breezeways sheds or any enclosed area or under overhead AAWARNING iene 4 combustible construction Never operate the grill in enclosed areas as this could lead to a carbon monoxide buildup which could result in injury or death Place the grill on a level surface Avoid moving the grill while it is operation NOTE The grill will operate best if it is not facing directly into the wind Clearance to combustible construction A minimum of 24 from the sides and back must be mainta
17. inder valve outlet and inlet connection ANSI CGAV1 Cylinders must not be stored in a building garage or any other enclosed area The L P cylinder must have an overfill protection device OPD on it The L P gas supply cylinder must be constructed and marked in accordance with the specifications for L P gas cylinders of the U S Department of Transportation DOT Cylinders Spheres and Tubes for the Transportation of Dangerous Goods L P TANK USE e When turning the L P tank on make sure to open the valve SLOWLY two 2 complete turns to ensure proper gas flow Most gas tanks now come equipped with a leak detector mechanism internal to the tank When gas is allowed to escape rapidly it shuts off the gas supply Opening the valve rapidly may stimulate a gas leak causing the safety device to activate restricting gas flow causing low flames Opening the valve slowly will ensure this safety feature is not falsely triggered e When not in use gas supply cylinder valve is to be in the OFF position e The tank supply system must be stored upright to allow for vapor withdrawal e The regulator and hose assembly must be inspected before each use of the grill If there is excessive abrasion or wear or if the hose is cut it must be replaced prior to the grill being used again e Cylinders must be stored outdoors out of the reach of children and must not be stored in a building garage or any other enclosed area e Only a qualified g
18. ined from the gas grill above and below the cooking surface to adjacent vertical combustible construction Clearance to non combustible construction A minimum of 5 clearance from the back of the grill to non combustible construction is required for the lid to fully open Storage of an outdoor gas cooking appliance indoor is permissible only if the cylinder is disconnected and removed from the appliance GENERAL RULES Do not leave the grill unattended while cooking 1 2 3 Do Make sure the grill has been leak tested and is properly located Light the grill burners using the instructions provided in this manual Turn the control knobs to desired temperature High Medium or Low and preheat the grill for 10 minutes before cooking Adjust heat settings to meet your cooking needs for desired results Allow grill to cool down wipe off any splatters or grease and clean the drip tray as needed Do not put a cover on the grill while it is still hot as it could start a fire Keep any electrical supply cords and the fuel supply hose away from any heated surfaces 22 OW Using the Rotisserie amp Side Burners Optional ROTISSERIE KIT to use with back infrared burner must be purchased separately The grill rotisserie system is designed to cook items from the back using infrared heat The rotisserie burner is an infrared type which provides intense searing radiant heat Preferred by chefs over other cooking methods thi
19. odes or in the absence of local codes with the National Electrical Code ANSI NFPA 70 National Fuel Gas Code ANSI 2223 1 All pipe sealants must be an approved type and resistant to the actions of L P gases Never use pipe sealant on flare fittings All gas connections should be made by a competent qualified service technician and in accordance with local codes and ordinances In the absence of local codes the installation must comply with the National Fuel Gas Code ANSI 2223 1 Gas conversion kits may be purchased separately When ordering gas conversion kits have the model number and the type of gas N G or L P used for your grill You can call 1 800 Frigidaire to buy the conversion kits This grill and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing of the system at test pressures in excess of 1 2 PSIG 3 5 kPa This grill must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1 2 PSIG 3 5 kPa The installation of this grill must conform with local codes or in the absence of local codes with National Fuel Code ANSI Z223 1a NATURAL GAS INSTALLATION The gas inlet supply pressure should be between 5 and 14 water column w c A step down regulator is required if the line pressure is in excess of 14 w c Inlet press
20. ontact with grate burner or hot surfaces Use only outdoors and provide good ventilation to avoid carbon monoxide build up which could result in injury or death Do not repair or replace any part of this appliance unless it is specifically recommended in this manual A qualified service technician should conduct all other service Follow the installation and servicing instructions provided with this product Have your grill installed by a qualified service technician Locate the main gas supply valve so that you know how to shut the gas off to your grill If you smell gas make sure all gas connections are tight before operation If you continue to smell gas call a qualified technician When lighting a burner always pay close attention to what you are doing and be certain you are pushing the igniter that lights the burner you intend on using Always keep your face and body as far away from the grill as possible when lighting to reduce the risk of burn Extinguish all flames and do not smoke while engaging gas and igniting the grill FOR YOUR SAFETY TESTED IN ACCORDANCE WITH ANSI Z21 58b CGA1 6b M02 STANDARD FOR OUTDOOR COOKING GAS APPLIANCES THIS GRILL IS FOR OUTDOOR USE ONLY Check your local building codes for the proper method of installation In the absence of local codes this unit should be installed in accordance with the National Fuel Gas Code No Z223 1 and the National Electrical Code ANSI NFPA No 70 If you
21. position Wait 5 seconds Then press and hold the electronic igniter button You should Hear a snapping sound If the burner does not light in 4 seconds turn the control knob to OFF and wait 5 minutes before trying again Once lit turn the control knob to the desired setting See Fig 10 If the igniter does not function the burner can be lit by holding a lit match with lighting rod to the burner while the Control knob is turned counterclockwise to HIGH See Fig 11 NOTE After the first use the stainless steel around the burner will darken This is a normal reaction of premium stainless steel to heat and is not a defect The infrared panel will also darken after initial use This is also a normal occurrence NOTE Do not operate the main burners and infrared back burner at the same time This can cause warping of the roll top grill hood SIDE BURNER LIGHTING Push and turn the control knob to the HIGH position and immediately press and hold the electronic igniter button You ll hear a snapping sound It may be necessary to hold the electronic starter button for about 4 seconds If the burner does not light in 4 seconds turn the knob to the OFF position and wait 5 minutes before trying again Repeat above steps to light remaining burners See Fig 12 MATCH LIGHTING OF THE BURNER If by chance the electronic igniter does not light the burner the burner may be lit with a match and lighting rod
22. ppliance which prove to be defective in materials or RESPONSIBILITIES OF THE CONSUMER date workmanship LIMITED 3 YEAR 2nd through 3rd Provide a replacement for any stainless steel burners Diagnostic and any transportation and labor costs WARRANTY ON years from which prove to be defective in materials or workmanship which are required because of service STAINLESS STEEL original purchase BURNERS date LIMITED LIFETIME From original date All of the provisions of the full and limited warranties Costs of the technician s travel to the home and any WARRANTY ON of purchase above and the exclusions listed below apply costs for pick up and delivery of the appliance required STAINLESS because of service PANELS Some restrictions apply NORMAL This warranty applies only to products in ordinary household use and the consumer is responsible for the RESPONSIBILITIES items listed below OFTHE CONSUMER 4 Proper use of the appliance in accordance with instructions provided with the product 2 Proper installation by an authorized servicer in accordance with instructions provided with the appliance and in accordance with all local plumbing electrical and or gas codes 3 Expenses for making the appliance accessible for servicing such as removal of trim cupboards shelves etc which are not a part of the appliance when it was shipped from the factory 4 Damages to finish after installation EXCLUSIONS This warranty does not cover the
23. s intense heat sears in the natural juices and nutrients found in quality cuts of meats Remove the warming rack from the grill when using the rotisserie to prevent warping from the intense heat of the infrared unit NOTE The rotisserie spit rod is centered between the grill hood and the burners It may be necessary to remove the grates and flavor grids when cooking larger portions of meat on the rotisserie This is by design since this configuration gives you the most possible room above and below the rod for larger pieces of meat Once lit the rotisserie burner will reach cooking temperature in 1 minute The orange red glow will even out in about 5 minutes The rotisserie motor is equipped with metal gears and is capable of turning up to 20 Ibs of food The motor is mounted on a bracket on the left side of the grill by sliding the motor over the bracket with the cord facing the back of the grill Make sure the rotisserie motor is completely seated on the bracket prior to operating Make sure the rotisserie cord is away from any hot surfaces AWARNING Electrical Grounding Instructions This appliance rotisserie motor is equipped with a three prong grounding plug for your protection against shock hazard and should be plugged directly into a properly grounded three prong receptacle Do not cut or remove the grounding prong from this plug ATTACHING THE ROTISSERIE purchased separately For bracket installation see instr
24. s dealer can make repairs To disconnect L P gas cylinder 1 Turn the burner valves off 2 Turn the tank valve off fully turn clockwise 3 Detach the regulator assembly from the tank valve by turning the quick coupling nut counterclockwise GAS FLOW CHECK 1 2 Each grill burner is tested and adjusted at the factory prior to shipment however variations in the local gas supply may make it necessary to adjust the burners The flames of the burners should be visually checked Flames should be blue and stable with no yellow tips excessive noise or lifting If any of these conditions exist check if the air shutter or burner ports are blocked by dirt debris spider webs etc 18 om Pre Operation Leak Testing GENERAL INFORMATION Although all gas connections on the grill are leak tested prior to shipment a complete gas tightness check must be performed at the installation site due to possible shifting during shipment installation or excessive pressure unknowingly being applied to the unit Periodically check the whole system for leaks and immediately check the system if the smell of gas is detected BEFORE TESTING Do not smoke while leak testing Extinguish all open flames Never leak test with an open flame Mix a solution of equal parts mild detergent or liquid soap and water TESTING 1 Turn off the burner control knobs 2 Turn the top knob of the fuel s
25. uction sheet provided with the optional rotisserie kit The motor is mounted on a bracket on the left side of the grill by sliding the motor over the bracket with the cord facing the back of the grill With the rotisserie motor in place and plugged into an electrical outlet it is now ready to operate Slide one of the meat forks onto the rod prongs facing away from the handle Push the rod through the center of the food then slide the second meat fork onto the rod prongs toward the food Center the food to be cooked on the rod then push the meat forks firmly together Tighten the thumb screws It may also be necessary to wrap food with butcher s string never use nylon or plastic string to secure loose portions Once the food is secure insert the pointed end of the rotisserie rod into the motor assembly and rest the other end on the support on the right hand side of the grill If needed remove the cooking grates for more room Turn the power switch to the On position to start the rotisserie motor 23 Pointed End of Rod a MA ia O m y rt NOTE Remove the rotisserie when not in use Store the unit indoors when not in use Remove warming shelf when using rotisserie Do not use the rotisserie in A WARNING the rain Using the Rotisserie amp Side Burners OW ROTISSERIE LIGHTING Open the lid Push and turn the control knob for the rotisserie counterclockwise to the HIGH
26. upply cylinder counterclockwise right to left two 2 rotations to open 3 Apply the soap solution to connections of the fuel supply assembly If no soap bubbles appear there is no gas leak If bubbles form at the connections a leak is detected If a leak is detected immediately turn off the gas supply tighten any leaking fittings turn gas on and repeat steps 1 3 4 Turn off the knob on the fuel supply cylinder 5 Turn on the burner control knobs for a moment to release the pressure in the hose then turn the control knobs back off 6 Wash off soapy solution with cold water and towel dry Check all gas supply fittings before each use and each time the gas supply cylinder is connected to the regulator Have a qualified service technician leak test the grill any time a part of the gas system is replaced Also it is recommended to perform a leak test at least once a year whether or not the L P gas supply cylinder has been disconnected NOTE When leak testing this appliance make sure to test and tighten all loose connections including the side burner A slight leak in the system can result in a low flame or a hazardous condition Most L P gas tanks now come equipped with a leak detector mechanism internal to the tank when gas is allowed to escape rapidly it shuts off the gas supply A leak may significantly reduce the gas flow making the grill difficult to light or causing low flames NOTE If you cannot stop a gas leak turn off th
27. ure must not exceed 14 water column 1 2 PSIG Check with your local gas utility company or with local codes for instructions on installing gas supply lines Be sure to check on type and size of run and how deep to bury the line If the gas supply line is too small the grill will not operate correctly Any joint sealant used must be an approved type and be resistant to chemical breakdown resulting from the reaction with N G NOTE The gas line connection and the gas fitting must be the same diameter Installer supplied shutoff valve not included Place the shutoff valve in an accessible location to enable the gas supply to be cut off to the unit NOTE A flexible natural gas line is not included with Frigidaire Gallery grills Natural gas flex line must be purchased separately based on the distance of your grill location from the natural gas line Please be sure to check the size of your home s natural gas line fitting to make sure you get the right size connection for your particular application If you have questions please consult your local natural gas distributor or qualified service technician 15 Gas Requirements INSTALLATION OF NATURAL GAS REGULATOR 1 The Natural Gas regulator has been attached to the manifold Attach the gas hose to the regulator as shown See Fig 5 2 Putthe gas hose through the hole on the back of the cart panel See Fig 6 3 Link a quick connect fitting to the hose by hand Quick connect
Download Pdf Manuals
Related Search