Zanussi TD4100W Electric Dryer
Contents
1. Your New Tumble Dryer This tumble dryer will give your wash that soft relaxed feel whatever the weather Extremely high quality standards both during development and manufacturing guarantee a long service life for your appliance Maximum economy in the operation of your dryer is achieved through very frugal electricity consumption and short drying times Energy saving tips To save energy we recommend that you follow these hints Try to load the maximum capacity of the machine as small loads are uneconomical Always load well spun laundry The higher the spin speed the lower the electricity consumption and the shorter the drying times Do not over dry laundry this avoids creasing and saves energy Clean the filter regularly to avoid excessive drying times and high electricity consumption Ventilate the room well The room temperature should not exceed 35 C during drying v In the interest of the environment e Materials marked with the symbol recyclable Check with your local Council or Environmental Health Office to see if there are facilities in your area for re cycling this appliance When the appliance is to be scrapped cut off the power supply cable and make the door closing device unusable to prevent young children from being trapped inside Help to keep your country tidy use authorised disposal sites for your old appliance How do we help to protect the environment We use r2. diluents or similar products Cleaning the door Periodically clean the interior part of the door to remove any fluff Regular and accurate cleaning ensures correct drying Cleaning the filter Your dryer will only function well if the filter is clean The filter collects all the fluff which accumulates during drying and it must therefore be cleaned at the end of each programme before removing the laundry with a damp cloth 10 Cleaning The filter cannot be removed Do not be alarmed by the amount of fluff It is not due to excessive wear caused by the dryer AII fabric loses fluff when drying but it goes un noticed in the air In a tumble dryer it simply collects in the filter Something Not Working Certain problems are due to lack of simple maintenance or oversights which can be solved easily without calling out an engineer Before contacting your local Service Centre please carry out the checks listed below IMPORTANT if you call out an engineer to a fault listed below or to repair a fault caused by incorrect use or installation a charge will be made even if the appliance is under guarantee Symptom The tumble dryer does not start Possible causes The door has not been closed The plug is not properly inserted in the power socket There is no current at the socket The main fuse or the fuse in the plug has blown A drying time has not been selected Drying takes too long or laundry is not dr
3. or avoided as this could cause skin burns or damages to the laundry Programme Chart Cotton and linen Selector dial up to 120 minutes Drying time in minutes for Amount laundry spun at Type of laundry Degree of drying of laundry in kg 800 900 rpm 1000 1200 rpm Cotton Towelling Store dry Shirts wardrobe dry Sheets Hand towels Tablecloths Table napkins Iron dry not completely dry suitable for ironing Synthetics Selector dial up to 80 minutes Amount of laundry Drying time in minutes for laundry in kg spun at a minimum speed of 650 rpm 50 60 30 35 Type of laundry Degree of drying Synthetics or mixed fabrics which do not require Store dry ironing Synthetics or mixed fabrics 40 50 which have to be ironed Iron dry Please see labels on items 25 30 ATTENTION Please follow the instructions on labels when drying mixed fabrics Drying times are given as a guide only Experience will soon enable you to estimate the drying time needed for your usual laundry loads Do not start by selecting a long drying time It is better to determine the required degree of dryness by gradually increasing the drying time For a mixed load cotton and synthetics for example select the time for the most delicate fibres and increase it by 10 mins Operating Sequence Before using your tumble dryer for the first time we recommend you place a few damp cloths inside the appliance and dry f
4. to install this appliance should be carried out by a qualified electrician or competent person WARNING THIS APPLIANCE MUST BE EARTHED The manufacturer declines any liability should this safety measure not be observed Before switching on make sure the electricity supply voltage is the same as that indicated on the appliance s rating plate See picture The appliance is supplied with a 13amp plug fitted In the event of having to change the fuse in the plug supplied a 13amp ASTA approved BS 1363 A fuse must be used Should the plug need to be replaced for any reason proceed as described below The wires in the mains lead are coloured in accordance with the following code Green and Yellow Earth Blue Neutral Brown Live GREEN amp YELLOW The wire coloured green and yellow must be connected to the terminal marked with the letter E or by the earth symbol or coloured green and yellow The wire coloured blue must be connected to the terminal N or coloured black 17 The wire coloured brown must be connected to the terminal marked L or coloured red Upon completion there must be no cut or stray strands of wire present and the cord clamp must be secure over the outer sheath WARNING A cut off plug inserted into a 13 amp socket is a serious safety shock hazard Ensure that the cut off plug is disposed of safely The power supply
5. 0 to 300 g 150 to 200 g Always load well spun laundry The higher the spin speed the lower the electricity consumption and the shorter the drying time DO NOT load dripping wet laundry into the dryer Roll the article in a towel or spin to remove excess water e Close poppers and zips and fasten any buttons Sort the laundry Separate synthetics from cotton linens and dry separately Remove the laundry immediately after the programme has finished Use a fabric conditioning sheet to reduce static We recommend the sheet is pinned to an article of laundry using a safety pin e Mix the load i e large and small articles e When drying large items such as sheets we recommend you periodically stop the dryer to redistribute the load DO NOT use the tumble dryer to dry the following Articles contaminated with inflammable substances e g petrol cleaning solvents cooking oil fats or hair lacquer Woollen and synthetic wool mixtures unless the item is labelled as suitable for tumble drying Very delicate articles such as silk Very large and bulky items such as duvets or sleeping bags Maintenance and You must disconnect the appliance from the electricity supply before you can carry out any cleaning or maintenance work External cleaning Use only soap and water and then dry thoroughly From time to time apply a little wax furniture cream with a soft cloth Important do not use methylated spirit
6. 125994660 ZANUSSI TUMBLE DRYER TD 4100 W INSTRUCTION BOOKLET A Important Safety Information It is most important that this instruction book should be retained with the appliance for future reference Should the appliance be sold or transferred to another owner or should you move house and leave the appliance always ensure that the book is supplied with the appliance in order that the new owner can get to know the functioning of the appliance and the relevant warnings These warnings have been provided in the interest of safety You MUST read them carefully before installing or using the appliance Installation This appliance is heavy Care should be taken when moving it tis dangerous to alter the specifications or attempt to modify this product in any way Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person Care must be taken to ensure that the appliance does not stand on the electrical supply cable Ifthe machine is situated on a carpeted floor please adjust the feet in order to allow air to circulate freely Ifthe tumble dryer is placed on top of a washing machine it is compulsory to use the stacking kit optional accessory e This tumble dryer is designed to be vented through to the open air It should have its own ventilation system which should not be joined with any other ven
7. Pordenone 39 0 434 39 4700 Sweden Stockholm 46 0 8 672 53 90 UK Slough 44 0 1753 219897 Installation Instructions It is dangerous to alter the specifications or attempt to modify this product in any way IN Care must be taken to ensure that the appliance does not stand on the electrical supply cable IN Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person Technical Specifications DIMENSIONS Height 85 cm 33 57 Width 60 cm 23 6 Depth 57 cm 22 4 POWER SUPPLY VOLTAGE 230 240 V 50 Hz TOTAL POWER ABSORBED 2650 W 13A MAXIMUM RECOMMENDED LOAD Cotton linen 5 kg 11 Ibs Synthetics 2 5 kg 5 5 Ibs DRUM VOLUME 1081 CONSUMPTIONS 3 30 kWh 5 kg store dry 2 70 kWh 5 kg iron dry C This appliance complies with the following E E C Directives 73 23 EEC of 19 2 73 Low Voltage Directive and subsequent modifications 89 336 EEC of 3 5 89 Electromagnetic Compatibility Directive and subsequent modifications 13 Positioning It is recommended that for your convenience the machine is positioned close to your washing machine Whilst drying the tumble dryer will expel a certain amount of warm very moist air and this should be removed from the room as quickly as possible to prevent condensation In an extremely well ventilated room or close to an open window this may occur naturally Howeve
8. This will allow the seal to be preserved Clean fluff filter after using tumble dryer To prevent fire risks do not use the appliance if the fluff filter is damaged Under no circumstances should you attempt to repair the machine yourself Repairs carried out by inexperienced persons may cause injury or serious malfunctioning Contact your local Zanussi Service Centre Always insist on genuine Zanussi spare parts Contents For the User Important Safety Information Installation Child Safety Use Your New Tumble Dryer Description of the Appliance The Control Panel Mains on light Time selector dial Programme Chart Operating Sequence Load the laundry Select the drying time When drying is completed Hints amp Tips on Drying Maintenance and Cleaning External cleaning Cleaning the door Cleaning fluff filter Something Not Working Service and Spare Parts Customer Care Guarantee Conditions For the Installer Installation Instructions 2 2 Technical Specifications 2 Positioning 2 Fitting the vent hose 4 Door reversal 5 Stacking kit optional accessory Electrical connection 6 6 6 7 8 8 8 8 9 10 10 10 10 11 11 11 12 Guide to use the Instruction Book The following symbols will be found in the text to guide you throughout the instructions AN Safety instructions 1 Hints and tips Environmental information 13 13 14 14 15 16 16 17
9. cable must be easily accessible after installing the machine Permanent connection In the case of permanent connection it is necessary that you install a double pole switch between the appliance and the electricity supply mains with a minimum gap of 3mm between the switch contacts and of a type suitable for the required load in compliance with the current electrical regulations The switch must not break the yellow and green earth cable at any point 4 From the Electrolux Group The world s No 1 choice The Electrolux Group is the world s largest producer of powered appliances for kitchen cleaning and outdoor use More than 55 million Electrolux Group products such as refrigerators cookers washing machines vacuum cleaners chain saws and lawn mowers are sold each year to a value of approx USD 14 billion in more than 150 countries around the world Electrolux Household Appliances Limited 2002
10. e 511 1DZ Tel 08705 727727 or visit our website at www zanussi co uk calls to this number may be recorded for training purposes Zanussi Guarantee Conditions Standard guarantee conditions We Zanussi undertake that if within 12 months of the date of the purchase this Zanussi appliance or any part thereof is proved to be defective by reason only of faulty workmanship or materials we will at our option repair or replace the same FREE OF ANY CHARGE for labour materials or carriage on condition that The appliance has been correctly installed and used only on the electricity supply stated on the rating plate e The appliance has been used for normal domestic purposes only and in accordance with the manufacturer s instructions e The appliance has not been serviced maintained repaired taken apart or tampered with by any person not authorised by us All service work under this guarantee must be undertaken by a Zanussi Service Force Centre Any appliance or defective part replaced shall become the Company s property This guarantee is in addition to your statutory and other legal rights Home visits are made between 8 30am and 5 30pm Monday to Friday Visits may be available outside these hours in which case a premium will be charged 12 Exclusions This guarantee does not cover e Damage or calls resulting from transportation improper use or neglect the replacement of any light bulbs or r
11. ecycled paper Description of the Appliance Work Top Programme chart Light ON OFF Drying Time Selector Dial Rating Plate Fluff filter Door Handle Adjustable feet 34 tn PWN 9 Side vent outlet 10 Ring nut 11 Rear vent outlet The Control Panel ZANUSSI DUAL TEMPERATURE COTON ammm SYNTHETICS emp IRON DRY STORE DRY STORE DRY Spunat 800 900 1000 1200 800 900 1000 1200 Spun at 650 kg 5 90 65 85 75 kg 2 5 35 50 30 45 55 70 50 65 IMPORTANT PLEASE READ THE INSTRUCTION BOOK BEFORE USING THIS TD 4100 W UGHT N ON OFF ON OFF ZanussiQuaury DRYING TIME Programme Chart This will help you to select the correct time for drying 2 Mains On Light This lights up when the machine starts operating and goes out at the end of the programme 3 Drying Time Selector Dial ON OFF Switch The selector dial incorporates two drying cycles one of up to 120 minutes at a high temperature for cotton and linen and one of up to 80 minutes at a low temperature for synthetic fabrics To set the machine to the selected time turn the dial clockwise until the time you want coincides exactly with the pointer NEVER attempt to turn the dial in an anticlockwise direction When selecting the drying time you should remember that it includes a 8 minute cooling phase position amp on the dial This phase should not be shortened stopped
12. emovable parts of glass or plastic Costs incurred for calls to put right an appliance which is improperly installed or calls to appliances outside the United Kingdom e Appliances found to be in use within a commercial environment plus those which are subject to rental agreements Products of Zanussi manufacture which are NOT marketed by Zanussi European guarantee If you should move to another country within Europe then your guarantee moves with you to your new home subject to the following qualifications e Ihe guarantee starts from the date you first purchased your product e Ihe guarantee is for the same period and to the same extent for labour and parts as exists in the new country of use for this brand or range of products e Ihe guarantee relates to you and cannot be transferred to another user e Your new home is within the European Community EC or European Free Trade Area e The product is installed and used in accordance with our instructions and is only used domestically i e a normal household e Ihe product is installed taking into account regulations in your new country Before you move please contact your nearest Customer Care Centre listed below to give them details of your new home They will then ensure that the local Service Organisation is aware of your move and able to look after you and your appliances France Senlis 33 0 344 62 29 29 Germany Nurnberg 49 0 800 234 7378 Italy
13. ng it firmly back into place The unused vents should now be sealed with the special snap covers provided Advice If the hose is long and the room temperature low the moisture might condense to water inside the hose This is an unavoidable natural phenomenon To prevent this water from lying in the hose or flowing back into the tumble dryer it is advisable to drill a small hole dia 3 mm in the lowest point of the hose and to place a small container below it See picture point B E E E A D P Once connected to the dryer run the vent hose to the desired outlet point ensuring that the run s overall length is less than 2 5 m and that it contains no more than two bends As to the outlet itself if you have decided on a fixed wall window grille a good local builder s merchant should be able to supply you with the necessary fittings and installation advice It is important not to connect the vent hose to for example a cooker hood or a chimney or flue pipe designed to carry the exhaust from a fuel burning appliance Note that to avoid condensation problems it is essential that the dryer be fitted with the flexible hose to carry its exhaust at least beyond the kitchen units preferable outside the kitchen 15 In order to prevent the appliance from overheating it is important that the steam exhaust is unobstructed Therefore in case of a pe
14. or approximately 20 minutes There may be dust inside a brand new tumble dryer 1 Load the laundry Open the door by pulling the door handle forwards Load the items one at a time shaking them out loosely and close the door Please check the laundry does not get caught between the door and filter 2 Select the drying time Turn the selector dial clockwise to the desired time in the high or low temperature range according to the fabrics The mains on light illuminates and the programme starts 3 When drying is completed The machine stops automatically and the mains on light goes out Open the door and take out the laundry Clean the filter after every drying programme A clean filter ensures correct functioning of the appliance i Hints amp Tips on Drying Before placing articles of laundry in your tumble dryer check the care labels to ensure they are recommended for tumble drying Care Labels you may find on your laundry NI normal drying high temperature delicate drying low temperature E do not tumble dry g may be tumble dried A Do not overload the appliance Here is a list of the approximate weight of some common laundry items Sheet Pillowcase Tablecloth Table Napkin Kitchen Towel Linen Hand Towel Hand Towel Bath Towel Bathrobe Shirt Apron 700 to 1000 g 100 to 200 g 400 to 500 g 50 to 100 g 70 to 120g 100 to 150 g 150 to 250 g 700 to 1000 g 1000 to 1500 g 20
15. r in general it is better to carry the dryer s exhaust outside via a 100 mm diameter flexible hose supplied with the machine ending either temporarily at an open window or permanently at a fixed ventilation grille fitted to an exterior wall or window The tumble dryer must be installed in a clean place where dirt does not build up Make sure there are no obstructing items or material near the air intake louvres provided at the back e g paper rags etc To keep vibration and noise to a minimum when the dryer is in use it should be placed on a firm level surface Once in its permanent operating position check that the dryer is absolutely level with the aid of a spirit level If it is not raise or lower the two adjustable feet at the front of the machine until it is The feet must never be removed Do not restrict the floor clearance through deep pile carpets strips of wood or similar This might cause heat build up which would interfere with the operation of the appliance Important When operating the tumble dryer the room temperature must not exceed 35 C as it may affect the performance of the appliance 14 Fitting the vent hose To simplify the installation there is a choice of vent outlets one at the back the others in the left and right hand side Connect the hose to whichever is the more convenient by pulling the ring nut A from the vent outlet at the back screwing it on to the hose and pushi
16. rmanent hose fitted to an exterior wall or ceiling it must have an exhaust capacity of at least 150 m h If the dryer is fitted next to kitchen units make sure that the vent hose is not squashed If the hose is partially squashed drying efficiency will be reduced resulting in longer drying times and higher energy consumption If the hose is completely squashed the safety cut outs with which the machine is fitted may operate Door reversal To make it easier to load or unload the laundry the door can be reversed This operation must be carried out by qualified personnel Operate as follows Remove the door by unscrewing the two screws 1 fastening the hinge to the cabinet Fig A Remove the safety catch 2 and the plug 3 by bending the two fastening tags Fig A im E y w P0283 A Refit the safety catch 2 and plug 3 on the door by reversing their positions Fig B Remove the plastic plate 4 by unscrewing the two fastening screws Fig A Refit the plastic plate 4 on the opposite side Fig B Refit the door by screwing in the two screws 1 which fasten the door to the cabinet Fig B 16 Stacking kit It should be possible to stack your new dryer on top of your washing machine Please contact your local Service Force Centre for further advice Electrical connection Any electrical work required
17. tilation system connected to any other appliance Child Safety This appliance is designed to be operated by adults Children should not be allowed to tamper with the controls or play with the product Pets and children have been known to climb into tumble dryers Please check your drum before use e Keep all packaging well away for children Use Do not overload the appliance see programme chart Clothes which are dripping wet should not be placed in the dryer As some bulky items such as duvets and eiderdowns should be dried in large commercial machines because of their bulk check with the manufacturer of the item if it is suitable for drying in a domestic machine even if the dry weight of the item is within the limit advised Please make sure that no gas lighters have accidentally been left in pockets of garments to be loaded into appliance Danger of explosion Never tumble dry items that have been in contact with inflammable solvents petrol methylated spirits dry cleaning fluid and the like As these substance are volatile they could cause an explosion Tumble dry only items washed with water In order to avoid danger of fires caused by excessive drying do not use appliance to dry the following items Cushions quilts and the like these items accumulate heat Items containing rubber foam or materials similar to rubber foam Leave the door slightly ajar when the appliance is not being used
18. y enough The laundry has not been spun properly The filter is clogged up The room temperature is too high The selected time or sector was not suitable for the laundry There is too much laundry inside the appliance The dryer is not correctly installed Service amp Spare Parts In the event of your appliance requiring service or if you wish to purchase spare parts please contact your local Zanussi Service Force Centre by telephoning 0870 5 929929 Your telephone call will be automatically routed to the Service Force Centre covering your post code area For the address of your local Service Force Centre and further information about Service Force please visit the website at www serviceforce co uk Before calling out an engineer please ensure you have read the details under the heading Something Not Working When you contact the Service Force Centre you will need to give the following details 1 Your name address and post code 2 Your telephone number 3 Clear and concise details of fault 4 The model and serial number of the appliance found on the rating plate see picture 5 The purchase date 11 Customer Care For general enquiries concerning your Zanussi appliance or for further information on Zanussi products please contact our Customer Care Department by letter or telephone as follows Customer Care Department Zanussi 55 77 High Street Slough Berkshir
Download Pdf Manuals
Related Search