Toshiba 57HX83 Flat Panel Television User Manual
Contents
1. WARNING Electrical Grounding Instructions 1 This grill is equipped with a three prong grounding plug for your protection against shock hazard and should be plugged directly into a properly grounded three prong receptacle Do not cut or remove the grounding prong from this plug Keep any electrical supply cord and the fuel supply hose away from any heated surfaces Remove and store the motor in a dry place when not use oN USING ROTISSERIE KIT Take off the rotisserie kit from the grill Slide off the left fork Load the meat or poultry onto the rod Restore the left fork put two forks into the meat or poultry as far as possible Make sure the meat or poultry is located in the middle of the rod Screw the wing nuts of the fork as tight as possible Wrap the food with butchers string never use nylon or plastic string to secure any loose portions if necessary 6 Restore the rotisserie kit into the motor PoON gt HEH a m TIPS OF ROTISSERIE KIT 1 If larger cuts of meat are being grilled the rod may flex this is normal 2 Remove the cooking grids for larger cuts of meat if the meat scrapes on the cooking grids during rotation 16 CARE amp MAINTENANCE m MAINTENANCE 1 Keep the grill area clear and free from combustible materials gasoline and other flammable vapors and liquids 2 Keep the holes in the three sides of the cart clear and free from debris thus ensure the flow of combustio2. 1 35 Thermocouple Bracket 1 17 Rear Burner Thermocouple 1 36 Rear Burner 1 18 Gas Valves Main Burner 4 37 Warming Rack 1 1 19 Valve Bracket GAS CONNECTION ONLY USE THE REGULATOR AND HOSE ASSEMBLY PROVIDED WITH THIS GRILL REPLACEMENT PRESSURE REGULATORS AND HOSE ASSEMBLIES MUST BE THOSE SPECIFIED BY THE MANUFACTURER This is a L P Liquefied Petroleum Gas configured grill Do not attempt to use a natural gas supply unless the grill has been reconfigured for natural gas use The installation of this appliance must conform with local codes or in the absence of local codes with the National Fuel Gas Code ANSI Z223 1 or CAN CGA B149 2 Propane Installation Code m L P tank Requirements The L P tank used with your grill must meet the following requirements 1 Measurement 12 30 5cm Diameter X 18 45 7cm Tall 2 Maximum Capacity 20lbs 9Kg 3 Constructed and marked in accordance with the specification for L P gas cylinders of the U S Department of Transportation DOT or the National Standard of Canada CAN CSA B339 Cylinders Spheres and Tubes for the Transportation of Dangerous Goods See L P tank collar for marking Be arranged for vapor withdrawal Has a collar to protect the tank valve No dent or rust A dented or rusty L P tank may be hazardous Ook m L P tank valve used must meet the following requirements i Have type outlet compatible with regulator provi
3. smoke while leak testing Never leak test with an open flame Make a soap solution with one part liquid detergent and one part water Prepare a spray bottle brush or rag to apply the solution to the connections For the initial leak test make sure the L P cylinder is full Grill must be leak tested outdoors in well ventilated area away from ignition sources such as gas fired or electrical appliances and flammable materials Keep grill away from open flames and or sparks while testing TO TEST Make sure all control knobs are in the OFF position Make sure the regulator is connected to the L P tank tightly Completely open L P tank valve by turning counter clockwise If you hear a POP sound turn gas off IMMEDIATELY it indicates a heavy leak at the connection Call your gas dealer or fire department Check every connection from the L P tank up to and including the connection to the manifold pipe assembly the pipe that goes to the burner by brushing or spraying the soapy solution on the connections If soap bubbles appear there is a leak Turn off L P tank valve IMMEDIATELY and retighten connections Open L P tank valve again and recheck Always close the L P tank valve after leak test by turning clockwise Only those parts recommended by the manufacturer should be used on the grill Substitution can void the warranty Do not use the grill until all connections have been checked and do not leak RONM gt HH
4. with insects burning smell 2 Temperature can t rise 3 Heats unevenly 4 The burners make popping noises BEFORE CALLING FOR SERVICE Inspect according to following trouble shooting before contact our service center TROUBLE SHOOTING PROBLEMS POSSIBLE CAUSE SOLUTIONS Electrode lt deposited With cooking Use clean swab and alcohol to clean residues Electrode damaged Replace sd Burner won t light after turning and pushing the Electrode wires are loose or fall off BSL A a e Wii new Slecirode knobs Orifice blocked Check the orifice for blockage the orifice for Check the orifice for blockage Wire is shorting Replace with new electrode assembly with wires Open the LP tank valve Replace LP tank valve neal cant light by Gas flow is not smooth flow is Gas flow is not smooth smooth Clear burner tubes Incorrect assembly between burner and valve y Re assemble with gas odor Turn off knobs and LP tank valve Leave lid Grease fire Grease accumulated in food open and let fire burn out Clean the grill after cooling 18 6 GRILLING TIPS The doneness of meat whether rare medium or well done is affected by the thickness to a large extent The cooking time is affected by the kind of meat the size and shape of the cut the temperature of the meat when cooking begins and the degree of doneness desired Defrost meat in the refrigerator overnight Don t use a microwave this a
5. AUTION CAUTION Indicates a potentially hazardous situation which may result in minor or moderate body injury if not followed A N WARNING FOR YOUR SAFETY Shut off the gas to the appliance Extinguish any open flame Open lid If odor continues immediately call your gas supplier or your fire department WARNING FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance An L P cylinder not connected for use shall not be stored in the vicinity of this or any other appliance INSTALLATION SAFETY PRECAUTIONS NIWARNING Do not try to install this appliance without reading the INSTALLATION SAFETY PRECAUTIONS section of this manual 1 This grill is designed to use L P gas only Only use this grill with L P gas and the regulator assembly supplied by the manufacturer This grill is supplied with a Natural Gas Conversion Kit When converting to Natural Gas a qualified Gas installer should perform all gas conversions See conversion section of this manual 2 The installation of this appliance must conform with local codes or in the absence of local codes with the National Fuel Gas Code ANSI Z223 1 or CAN CGA B149 2 Propane Installation Code 3 The L P tank used must conform with the specification for L P gas cylinders of the U S Department
6. Jackson Grills Inc warrants its products to the original purchaser only NO EXCEPTIONS This Limited Warranty does not cover any damage caused by misuse lack of maintenance hostile environments accident alterations abuse or neglect and parts installed by other manufacturers will nullify the warranty This Limited Warranty does not cover and scratches dents corrosion or discoloring by heat all stainless steel will discolor abrasive and chemical cleaners will also damage grill and grill surface Should deterioration occur to the point of non performance within the duration of the warranted coverage a replacement will be provided in the first year only This warranty extends to the repair or replacement of warranted parts that are defective in materials or workmanship provided that the product has been operated in accordance with the operation instructions and under normal conditions After the first year Jackson Grills Inc reserves the right to fully disengage all obligations with respect to this Limited Warranty by refunding the original warranted purchaser the original wholesale purchase price of the warranted parts A licensed authorized service technician or contractor must install the gas grill Installation must be done in accordance with the installation instructions included with the product Jackson Grills Inc or its parties will not be responsible for the installation labor or any other costs or expenses related t
7. ONAN 10 DISCONNECTED THE TANK AND REMOVE FROM THE GRILL IF THE GRILL IS STORED 12 SAFETY TIPS ALWAYS CHECK FOR LEAKS AFTER EVERY L P TANK CHANGE ALWAYS CHECK FOR LEAKS OF EVERY CONNECTIONS BEFORE EACH USE USE LONG BBQ TOOL TO AVOID BURNS IF ANY GREASE OR HOT ITEMS FALLING FROM THE GRILL ONTO THE VALVE REGULATOR HOSE ANYTHING CONVEYING THE GAS CLOSE THE GAS IMMEDIATELY CHECK THE CAUSE AND REMOVE THE CAUSE REPERFORM THE LEAK TEST BEFORE CONTINUING DO NOT REMOVE THE GREASE TRAY IF THE GRILL HASN T COMPLETELY COOLED CLOSE ALL CONTROL KNOBS AND L P TANK VALVE WHEN THE GRILL IS NOT IN USE NEVER MOVE THE GRILL WHILE IN USE OR STILL HOT DISCONNECTED L P TANK IN STORAGE OR BEING TRANSPORTED MUST HAVE A SAFETY CAP INSTALLED DO NOT STORE AN L P TANK IN ENCLOSED SPACES LIKE CARPORT COVERED PATIO PORCH GARAGE OR OTHER BUILDINGS NEVER LEAVE A L P TANK IN A RECREATIONAL VEHICLE OR BOAT WHICH MAY BECOME OVERHEATED BY THE SUN DO NOT STORE L P TANK INOR NEAR AN AREA WHERE CHILDREN PLAY INDOORS ANY OTHER PROBLEM SEE TROUBLESHOOTING OR CONTACT JACKSON GRILLS AT 877 942 2277 12 INSTALLER FINAL CHECK LIST At least 36 clearance maintained from combustible constructions to the sides and back of this grill There is no unprotected combustible construction over the grill All internal packaging removed Burners are sitting properly on orifices Knobs turn freely The regulator amp hose connected to
8. Y IMPORTANT DISCONNECTED THE TANK WHEN THIS GRILL IS NOT IN USE E 1 2 3 4 To disconnect L P gas tank Turn all the knobs off Turn the tank valve off fully turn clockwise to stop Detach the regulator assembly from tank valve by turning the quick coupling nut counterclockwise Install the protective cap back L P tank valve NATURAL GAS CONVERSION Tools Required to Convert this grill from Propane Gas to Natural Gas Tools not provided 1 2 Phillips screwdriver 2 9 and 7 mm wrenches 3 13 mm wrench 4 4 wrench 5 Adjustable Wrench The NG conversion kit is supplied with this grill 1 NG Orifice Main Burner AN i p 1 44 4pcs 2 NG Orifice Rotisserie burner 61 14 1pc The outdoor cooking gas appliance and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing in excess of 1 2 psi 3 5 kPa The outdoor cooking gas appliance must be isolated from the gas supply by closing its individual manual shut off valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 2 psi 3 5 kPa m MAIN BURNER CONVERSION 1 Remove the Cooking Grids and Upper Flame Tamers 2 Using a 2 Phillips Screw Driver remove the screws that hold the main burners to the firebox rear wall Use Screw Drive to remove the screws on main burner each burner has 2 screws 3 Using a 13 mm wre
9. a o DL a Quality 4 ASSEMBLY USE AND CARE MANUAL MODEL NO PG 50403SRL MODEL NAME Classic Series Built In Grill Head CERTIFIED FOR OUTDOOR USE ONLY A DANGER A WARNING If you smell gas 1 Do not store or use gasoline or other 1 Shut off gas to the appliance flammable liquids or vapors in the 2 Extinguish any open flame vicinity of this or any other appliance 3 Open lid 4 If odor continues keep away from the 2 An LP cylinder not connected for use appliance and immediately call your gas shall not be stored in the vicinity of this supplier or your fire department or any other appliance TABLE OF CONTENTS Messages to Our Users 2 Installer Final Check List 13 Important 4 Grill Lighting Instructions 13 Installation Safety Precautions 5 Operation Instructions 15 Exploded View amp Parts List 6 Care amp Maintenance 17 Gas Connections 7 Trouble Shooting 18 Natural Gas Conversion 8 Grilling TipS 19 Installation 11 Placement of Grill 19 Leaking Test 12 Limited Warranty 20 MESSAGE TO OUR USERS Thank you for purchasi
10. ad instructions before lighting 2 Open the lid during lighting 3 Simply place a lighted match between the coils on the end of the lighting rod and hold next to the burner to ignite 4 Push and turn the knob to HI position make sure the burner lights and stays lighted 5 Repeat 3 4 to light other burner Keep a spray bottle of soapy water near the gas supply valve and check the connections before each use Do not light the grill if odor of gas is present call our service center 13 A o ay S 7 FA f i H s 4 j y f 4 P A A j FLAME CHARACTERISTICS Check for proper burner flame characteristics Each burner is adjusted prior to shipment however variations in the local gas supply may take subtle necessary adjustments Burner flames should be blue and stable There should be no excessive noise or flame lifting If any of these conditions exist please call your Dealer If the flame is yellow it indicates insufficient air If the flame is noisy and tends to lift away from the burner it indicates too much air NOTE small yellow tips are ok TO LIGHT REAR BURNER OF THE GRILL THE WARMING RACK MUST BE REMOVED BEFORE LIGHTING THE REAR BURNER 1 2 3 4 AUON gt HEH Read instructions before lighting Turn all knobs to OFF then open the L P tank valve Always keep your face and body as far from the grill as possible when lighting Open lid during lighting P
11. al Gas neoprene hose REMEMBER TO LEAK CHECK ALL FITTINGS AND ORIFICES AFTER ALL OF THE CONVERSION IS COMPLETED LEAK CHECK ALL FITTINGS AND TEST FIRE ALL BURNERS TO ENSURE PROPER SAFE OPERATION 10 INSTALLATION INSTALLING CLASSIC GRILL MODEL INTO A NON COMBUSTIBLE ISLAND ONLY ALL DIMENSIONS ARE IN INCHES CLASSIC 25 9 25 17 8 75 3 17 25 24 25 24 min 20 5 af OO S SB OO we gt 5 5 min Ensure that the constructed island is well secured and the island is level in all directions Place the grill into the cut out located in the island Connect the gas line to the gas grill located on the right hand side of this grill Perform a gas leak test on this connection to ensure a gas leak is not present NOTE PLEASE ENSURE ALL PACKAGING MATERIALS HAVE BEEN REMOVED FROM ALL SURFACES 11 LEAK TESTING GENERAL Although all gas connections on the grill are leak tested at the factory prior to shipment a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment or excessive pressure unknowingly being applied to the unit Periodically check the whole system for leaks or immediately check if the smell of gas is detected ONO oOnN gt H 5 6 BEFORE TEST Make sure that all packing material is removed from the grill including the burner tie down straps Do not
12. ded 2 Have safety relief valve 3 UL listed Overfill Protection Device OPD This OPD safety feature is identified by a unique triangular hand wheel Only use tanks equipped with this type of valve as the figure shown below For your safety Ensure that the black plastic grommets of the regulator provided are in place and that the hose does not come into contact with the heat shield or the grill head Connect the regulator to the L P tank VERY IMPORTANT a THE REGULATOR SHALL INCORPORATE IN SUCH A LOCATION THAT IT WILL NOT ATTAIN A TEMPERATURE ABOVE 140 F 60 C b THE REGULATOR SHALL INCORPORATE A PRESSURE RELIEF VALVE OR OVERPRESSURE DEVICE c THE INLET OF THE PRESSURE REGULATOR SHALL BE FITTED TO CONNECT THE TYPE CONNECTION OF THE TANK VALVE PER ANSIZ21 81 Make sure tank valve is in its full off position turn clockwise to stop Check tank valve to assure it has proper external male threads type connection per ANSIZ21 81 Make sure all burner knobs are in their off position Remove the protective cap from L P tank valve Always use cap and strap supplied with valve Inspect valve connection port and regulator assembly Look for any damage or debris Remove any debris Inspect hose for damage Never attempt to use damaged or plugged equipment Contact your local L P gas dealer for repair GU Pe GOIN 6 When connect regulator assembly to the valve hand tighten nut clockwise to a posit
13. e manual and familiarize yourself with all of the features of the Jackson Grill This manual also contains important safety information and operation instructions Ensure that this manual remains handy to the barbeque for quick reference If you need to obtain replacement parts for your Jackson Grill contact your local dealer NOTE It is normal for stainless steel surfaces to discolor due to high heat given off from the barbeque burners Please take the time to fill out and return the Ownership and Registration Card below It can be mailed to Jackson Grills Inc 2945 Jacob Road Duncan B C VOL 6W4 Or Fax 1 250 715 0821 Please complete and return within 10 days Thank you Mr Mrs Ms Miss First Name Initial Last Name Street Apt City State Province Zip Postal Phone Email Date of Purchase Dealer Model Serial Comments Thank you for taking the time to fill out this Ownership and Registration Card IMPORTANT The symbols and boxes shown below explain what each symbol means Read and follow every message found in this manual II DANGER DANGER Indicates an imminently hazardous situation which will result in death or serious body injury if not followed I WARNING WARNING Warning of the possibility of serious body injury if the instructions are not followed strictly Be sure to always read and follow all of the instructions II C
14. g grease and debris Above the burners are stainless steel radiated The igniter knobs are located on the valve panel Follow the lighting instructions printed on the control panel 15 m USING THE GRILL Grilling requires high heat for searing and proper browning Most foods are cooked at the HI heat setting for the entire cooking time However when grilling large pieces of meat or poultry it may be necessary to turn the heat to a lower setting after the initial browning This cooks the food through without burning the outside Foods cooked for a long time or basted with a sugary marinade may need a lower heat setting near the end of the cooking time Make sure the grill has been leak tested and is properly located Remove any packing material Light the grill burners using the instructions in this manual Turn the control knob to HI and preheat the grill for 15 minutes Notice The grill lid is to be closed during the appliance preheat period Place the food on the grill and cook to the desired doneness Adjust heat setting if necessary The control knob may be set to any position between HI and LO NOTE The grill is designed to grill efficiently without the use of lava rocks or briquettes of any kind Heat is radiated by the stainless steel flame tamers under the stainless steel cooking grids NOTE The hot grill sears the food sealing in the juices The longer the preheat the faster the meat browns
15. grill is provided by the manufacturer pre set for 11 0 water column Unit tested and free of leaks User informed of gas supply shut off valve location naaanod DEAR CONSUMER PLEASE KEEP THIS MANUAL FOR FUTURE USE GRILL LIGHTING INSTRUCTIONS m BEFORE LIGHTING Carefully inspect the gas supply hose before turning the gas ON If there is evidence of cuts wear or abrasion it must be replaced before use the replacement hose assembly shall be that specified by the manufacturer VERY IMPORTANT ALWAYS INSPECT THE HOSE BEFORE EACH USE OF THIS GRILL TO LIGHT MAIN BURNERS OF THE GRILL 1 Read instructions before lighting 2 Turn all knobs to OFF then open the L P tank valve Always keep your face and body as far from the grill as possible when lighting 3 Open lid during lighting 4 Push and turn any control knob slowly to HI position The built in igniter will click and spark simultaneously to light the pilot and burner in sequence Turn the control knob to OFF IMMEDIATELY if the burner does not light within 5 seconds wait 5 minutes for gas to dispel then repeat the lighting procedure 5 Follow match lighting instructions if burner can t be lit after repeated 3 4 times m TOLIGHT THE MAIN BURNERS BY MATCH AS THE FIGURE SHOWN ON NEXT PAGE If the burner will not light after several attempts then the burner can be match lit Tools Lighting rod hanging behind the right door Usage 1 Re
16. ire occurs WARNING For your safety use of grill 1 Keep grill area clear and free from any flammable material 2 NEVER let children operate the grill or play near the grill 3 This grill is for outdoor use ONLY NEVER use in an enclosed area like a carport porch covered patio garage or under a surface that can catch fire 4 Do not block the ventilation holes in the four sides of the grill cart it may affect the combustion performance of the burner due to insufficient air 5 Use grill at least 36 away from any wall or surface 120 away from objects that may spark and ignite gas i e live electrical appliances pilot lights of water heaters etc 6 Do not use this grill on or under wood balconies 7 This grill is designed to use only L P gas DO NOT use lava rock briquets charcoal on it 8 NEVER light the burner with lid closed Non ignited gas accumulated inside a closed grill may cause explosions 9 Check the burner flames periodically 10 Turn off the gas supply when the grill is not in use 11 Always turn off the L P tank completely and detach from the grill before moving m TOTAL GAS CONSUMPTION Total gas consumption per hour of PG 50403SRL grill with all burners on HI Main burners 48 000 Btu hr Rear burner 7 500 Btu hr Total 55 500 Btu hr m GENERAL USE OF THE GRILL The grill burners encompass the entire cooking area and are side ported to minimize blockage from fallin
17. ith this grill 19 LIMITED WARRANTY MODEL NO PG 50403SRL Jackson Grills Inc warrants the following materials and workmanship to be free of defects for as long as you own the grill This covers the following components main stainless steel outer hood stainless steel cooking grills stainless steel outer pedestal system stainless steel handle Stainless Steel Burners and Stainless Steel cross lighters Subject to the following conditions During the first 5 years Jackson Grills will replace or repair at our option the defective parts free of charge From 6 years to lifetime Jackson Grills will provide replacement parts at 50 of the current retail price Inner stainless hood firebox Flame Diffusers and warming shelf come with a 10 year warranty During the first 5 years Jackson Grills will replace or repair at our option the defective parts free of charge From 6 to 10 years Jackson Grills will provide replacement parts at 50 of the current retail price The hardwood cart option if equipped is warranted for a period of one year Other components hose and regulator thermometer gas valves knobs fasteners igniter and electrode and all accessories will be provided free of charge during the two years of the limited warranty Limited Warranty subject to the following conditions and limitations This factory warranty is non transferable and may not be extended whatsoever by any of our representatives
18. ive stop Do not use a wrench to tighten Use of a wrench may damage quick coupling nut and result in a hazardous condition as the figure shown below 7 Open tank valve fully counterclockwise Use a soapy water solution to check all connections for leaks before attempting to light grill If a leak is found turn tank valve off and do not use grill until a local L P gas dealer can make repairs CPD HAND VEEL eS z 2 1 D l WARNING 1 Never insert any foreign objects into the valve outlet It may damage the valve and cause leak leaking gas may result in fire explosion heavy body injury or even death 2 Do not connect this grill to the self contained L P gas system of a motor home or camper trailer 3 Do not use the grill until leak tested 4 Stop and call the fire department if any leak detected 5 If you cannot stop a gas leak close the L P tank valve IMMEDIATELY call L P supplier or the fire department DANGER 1 NEVER store a spare L P tank under or near grill or in an enclosed area 2 NEVER fill the tank beyond 80 full An overfilled spare L P tank is dangerous because surplus gas may leak from safety relief valve The safety relief valve on a L P tank could activate to release gas and cause a fire 3 The spare L P tank must have safety caps installed on the L P tank outlet 4 If any gas leak found on the spare L P tank immediately go away from it and call the fire department VER
19. lways yields a juicier Use a spatula instead of tongs or a fork to turn the meat as a spatula will not puncture into the meat and let the juices come out To get the juiciest meats add seasoning or salt after the cooking is finished on each side and turn the meat only once juices are lost when the meat is turned several times Turn the meat just after the juices begin to bubble to the surface Cut off any excess fat from the meat before grilling m FOOD SAFETY Always follow the following tips to enjoy a safe and heath outdoor grilling PON TE 5 Always use hot soapy water to wash hands surfaces amp utensils after processing raw meat Always separate the raw meats from done foods to avoid cross contamination Always use clean utensils to handle the food Always cook the meat thoroughly to kill germs Use a thermometer to inspect the inner temp of the meat if necessary Place the done foods and leftovers promptly into refrigerator if eat no longer at that moment DO NOT LEAVE THE GRILL UNATTENDED WHILE COOKING PLACEMENT OF THE GRILL Clean the grill Store the grill in well ventilated dry outdoors and out of reach of children when L P tank is connected to the grill Store the grill in dry indoors ONLY after the L P tank is turned off and removed the L P tank must store outdoors out of the reach of children NEVER store the tank in a building garage or any other enclosed area Put on the vinyl cover supplied w
20. n and ventilation air is unobstructed 3 Visually check burner flames as following a Remove cooking grids and flame tamers b Light burners c Turn knobs from HI to LO Check the flame status the flame in LO position should be smaller than in HI position as figure shown below d Always check flame before each use see TROUBLESHOOTING if any abnormal status found IH s 0 m CLEANING m STAINLESS STEEL CLEANING The grill is made of stainless steel There are many different stainless steel cleaners available Always use the mildest cleaning procedure first scrubbing in the direction of the grain To touch up noticeable scratches in the stainless steel sand very lightly with dry 100 grit emery papers in the direction of the grain Specks of grease can gather on the surfaces of the stainless steel and bake on to the surface and give the appearance of rust Use an abrasive pad in conjunction with a stainless steel cleaner to remove DO NOT USE ACID DETERGENT AND OR ANTIRUST TO CLEAN THE CONTROL PANEL WITH PRINTING SUCH STRONG CLEANSER MAY CLEAN OFF THE PRINTING m COOKING AREA CLEANING The easiest way to clean the grill is to clean immediately after turning off the flame and cooking is completed Wear a barbeque mitt to protect your hand from the heat and steam Dip a brass bristle barbeque brush in tap water and scrub the hot grill Dip the brush frequently in the water Steam created as water contacts the ho
21. nch undo all of the main burner orifices from the underside of the Control Panel 3 4 After all the Propane orifices are removed from the grill place them in a safe spot away from your work area This will ensure you do not re install the Propane orifices Using an approved thread sealant replace the Main Burner Orifices with the NEW Natural Gas orifices supplied Before Reinstalling the Main Burners make sure to close the air shutter on each burner half of what it is set for propane use When reinstalling the main burners ensure that the Burner is properly placed over the Main Burner orifice and reinstall the Main Burner screw on the firebox rear wall Reinstall the flame tamers and Cooking Grids ROTISSERIE BURNER CONVERSION Using a 2 Phillips screwdriver undo the 4 screws that hold the Back Cover plate to the Inner Hood Once the Cover has been removed use a 7 mm wrench to remove the Rear Burner Orifice from the Rear Burner Place the Propane rear burner orifice with the main burner Propane orifices you removed previously Install the new rear burner orifice using the wrench Reinstall the rear burner Cover Plate using the 4 screws previously removed NOTE There is NO air adjustment required when converting the rear burner from Propane Gas to Natural Gas Remove the 3 8 flare fitting that attaches the propane hose from the Manifold block inside of the pedestal and replace it with an approved 10 Natur
22. ng your new Jackson Grill We hope you will have great enjoyment in using our fine product Do not attempt to assemble and use this grill unless you read this entire manual thoroughly Keep the manual in a handy place as it has answers for questions that may occur in your future use Please record the serial number of your grill in your owner s manual Any questions please feel free to contact our service center we will be glad to assist you please refer to this model No PG 50403SRL Classic Series whenever you contact us Thank you VERY IMPORTANT ANY PROBLEM PLEASE CONTACT OUR SERVICE CENTER AT 877 942 2277 NOTE THIS APPLIANCE IS NOT INTENDED TO INSTALL IN OR ON RECREATIONAL VEHICLES OR BOATS THIS APPLIANCE IS FOR OUTDOOR USE ONLY DEAR INSTALLER ASSEMBLER PLEASE LEAVE THIS MANUAL WITH THE CONSUMER DEAR CONSUMER PLEASE KEEP THIS MANUAL FOR FUTURE USE WARNING Failure to follow all manufacturer s instructions could result in serious body injury and or property damage CAUTION Some parts of this grill may have sharp edges especially as mentioned in this manual Wear suitable protective gloves if necessary A special message to our customers Thank you for choosing the Jackson Grill for your new gas grill This appliance is designed with quality components and we are confident that it will provide you with years of excellent operation Please take the time to read the whol
23. o the re installation of the warranted part and such expenses are not covered by this warranty Notwithstanding any provision contained in this Limited Warranty Jackson Grills Inc responsibility under this warranty is defined as above and it shall not in any event extend to any incidental consequential or indirect damages Jackson Grills Inc neither assumes nor authorizes any third party to assume on its behalf any other liabilities with respect to the sale of this product The bill of sale and proof of original ownership and serial number will be required when making any warranty claims from your authorized dealer The warranty registration card must be returned within 30 days to register your warranty Jackson Grills Inc reserves the right to inspect any parts prior to approving warranty claim Jackson Grills or its representatives shall not be liable for ANY transportation charges labor charges or duties 20
24. of Transportation DOT or the National Standard of Canada CAN CSA B339 Cylinders Spheres and Tubes for the Transportation of Dangerous Goods 4 The motor must be electrically grounded in accordance with local codes or in the absence of local codes with the National Electrical Code ANSI NFPA 70 1990 or the Canadian Electrical Code CSA C22 1 Keep the power cord of the motor away from the hot surfaces of the grill while in use Remove and store the motor in a dry place when not in use 5 This grill is safety certified for use in the United States and Canada only Never modify to use in other places Modification may cause serious body injury or property loss EXPLODED VIEW amp PARTS LIST REF DESCRIPTION QTY REF DESCRIPTION QTY 01 Rear Panel 1 20 Firebox 1 02 Cooking Grids 2 21 Prongs 2 03 Flame Tamers 4 22 Rotisserie Rod 1 04 Tube Main Burners 4 23 Shaft Collar 1 05 Rotisserie Motor 1 24 Counter Balance 1 06 Motor Bracket 1 25 Key Washers 2 07 Grease Tray 1 26 Rotisserie Handle 1 08 Knobs Main Burners 4 27 Lid Handle 1 09 Knob Seats Main Burners 4 28 Insulation Spacers 2 10 Knob Rear Burner 1 29 Name Plate 1 11 Knob Seat Rear Burner 1 30 Temp Gauge 1 12 Control Panel 1 31 Lid 1 13 Gas Valve Rear Burner 1 32 Spark Electrode Rear Burner 1 14 Manifold 1 33 Thermocouple Protection Cover 1 15 Safety Valve Rear Burner 1 34 Thermocouple 1 16 Gas Regulator
25. t grill assists the cleaning process by softening any food particles The food particles will fall and burn Never immerse a hot parts in water m GRILL BURNER CLEANING 1 Be sure the tank valve and the knobs are in the OFF position Make sure the grill is cool 2 Clean the exterior of the burner with a wire brush Clear stubborn scale with a metal scraper Clear any clogged ports with a straightened paper clip Never use a wooden toothpick as it may break off and clog the port 3 The frequency to clean the burner relies on how often you use the grill VERY IMPORTANT The orifice of the valve must be located in the center of burner section after move and clean Otherwise it may cause serious body injury and property damage Swing the burner slightly after replaced to check whether it is installed properly m GREASE TRAY CLEANING The grease tray should be emptied and wiped down periodically and washed in a mild detergent and warm water solution A small amount of sand may be placed in bottom of grease tray to absorb the grease 17 TROUBLE SHOOTING m SPIDER AND INSECT WARNING Spiders and insects can nest in the burners after storing these nest can cause fires inside the tube or beneath the grill This is very dangerous condition So always clean the burners before use after storing m WHEN TO LOOK FOR SPIDERS Inspect the burners at least once a year or immediately in case any of the following conditions occur Yellow flame
26. ush down the safety valve switch button and hold on with right hand allow the gas to reach the burner Push and turn rear burner knob slowly to HI position with left hand 3 seconds later than push down the button The built in igniter will click and spark simultaneously to light the pilot and burner in sequence Keep pushing the button for 10 seconds to allow the safety valve open Turn the control knob to OFF and release the button IMMEDIATELY if the burner does not light within 5 seconds wait 5 minutes for gas to dispel then repeat the lighting procedure Follow match lighting instruction if burner can t be lit after repeated 3 4 times TO LIGHT THE REAR BURNER BY MATCH Read instructions before lighting Open the lid during lighting Push and turn the rear burner knobs slowly to HI position then release Push down the safety valve switch button with right hand and hold on light by match with left hand Make sure the burner lights and stays lighted 14 OPERATION INSTRUCTIONS CAUTION 1 Clean your grill often Failing to do so may cause a grease fire that may damage the grill Please clean your grill frequently 2 NEVER leave the grill unattended while using 3 Do not use water to extinguish a grease fire it may cause body injury Turn knobs off and L P tank off in case grease fire occurs 4 Grease fires cannot be put out by closing the lid Turn off knobs and L P tank IMMEDIATELY if any grease f
Download Pdf Manuals
Related Search