Roper AL3132W Washer User Manual
Contents
1. non peak energy usage hours Contact your power company for the most energy efficient times Use hot water only when washing whites or heavy or greasy soils Use cold water for washing light soils Use cold rinses Adjust the water level when washing small loads Avoid rewashing by pretreating stains or heavy soils properly sorting clothes using enough detergent not overloading using proper cycles and wash times Page 2 DO NOT install or store washer where it will be exposed to the weather DO NOT tamper with controls You are responsible for making sure that your washer is installed repaired and has parts replaced by a qualified person DO NOT add gasoline dry cleaning solvents or other flammable or explosive substances to the wash water The substances give off vapors that could ignite or explode If hot water has not been used recently usually 2 weeks or longer hydrogen gas may build up in the water heater and the hot water pipes HYDROGEN GAS IS EXPLOSIVE To prevent injury or damage before using your washer turn on all hot water faucets and allow water to run for several minutes This will allow gases to escape DO NOT smoke or use any open flame near the faucet while it is open SAVE THESE INSTRUCTIONS Before You Wash 1 2 Turn all pockets inside out and empty Turn down cuffs Brush away lint and dirt Close z2. Thank you for choosing a Roper appliance This Use and Care Guide will help you operate and maintain your new quality built automatic washer Keep this Use and Care Guide in a safe place for future reference Complete the form below Have this information ready if you need service or call with a question a Copy model and serial numbers from plate see diagram on page 3 and purchase date from sales slip Keep this book and sales slip together in a handy place Model Number Serial Number Purchase Date Service Company Phone Number Please complete all of the Installation Instruction steps before attempting to operate your washer You are responsible for It is your responsibility to be sure that your washer a Is properly installed by a qualified person Is installed and leveled on a floor that can support the weight of the washer Is properly connected to a grounded electrical circuit that meets the electrical requirements Is properly connected to a water supply and drain Is used only for the job it was designed to do Is not used by children or anyone unable to operate it properly Is protected from the weather and installed where the temperature will not fall below freezing a Is properly maintained See Installation Instructions for complete information Washers Use and Care Guide S ROPER ee Home Appliances AL2121W AL3132W Contents aw a Q D Imp
3. ase and a complete description of the problem The model and serial numbers are located on a plate under the lid see illustration on page 3 If you are not satisfied with the service received contact the Major Appliance Consumer Action Panel MACAP MACAP is a group of independent consumer experts that voices consumer views at the highest levels of the major appliance industry Contact MACAP only when the dealer authorized servicer or Roper Brand warrantor have failed to resolve your problem Major Appliance Consumer Action Panel 20 North Wacker Drive Chicago IL 60606 MACAP will in turn inform us of your action Part No 3355695 Rev A 1991 Whirlpool Corporation TM Trademark of Whirlpool Corporation Printed in U S A ipo e
4. c care label directions were folowed Snags rips Follow chlorine bleach directions holes Chlorine bleach is properly used Remove sharp objects fasten hooks and eyes zippers and snaps turn synthetic fabrics inside out before washing Sharp articles are removed fasteners are fastened Rips broken threads and tears not Mend fabric before washing mended before washing Stiff harsh fabrics usually cottons Use proper amount of detergent for water hardness Do not use soap if you have hard water Water is too hard for soap or detergent used Cottons are line dried Dry cottons in dryer Twisting or tangling Load too big for washer capacity or water level Use proper load and water level DO NOT wrap items around the agitator DO NOT slip straps over agitator Items are improperly loaded Drop items in loosely DO NOT pack clothes tightly into basket Wash smaller loads of synthetic and permanent press items Use Permanent Press Cycle AL3132W This cycle includes a cool down of the wash water before the spin Load is too big for washer capacity or water level Setting allows for cool down time Unload washer or laundry basket immediately NOTE Since permanent press finishes may vary items labeled Permanent Press may require touch up Ironing Load has been left in washer or laundry ba
5. d full size loads Mixed Load Heavy Work Clothes 2 double sheets or 2 pair pants 1 king size sheet 3 shirts 4 pillowcases 3 pair jeans 6 T shirts 1 coverall 6 pair shorts 2 shirts 2 blouses 6 handkerchiefs Page 6 Drain and spin REGULAR onwal 6 CE LE HEAVY EEF OFF i QFF fx 10 PEAMANENT PRESS PULL START PUSH STOP A drain and spin may help shorten drying times for some fabrics or hand washed items by removing excess water 1 Push cycle control knob in 2 Turn clockwise to any bar located just before an OFF area on the dial as illustrated above See arrows in drawing 3 Pull cycle control knob out The washer will drain and spin Permanent Press 1 double sheet 1 tablecloth Towels 8 bath towels 8 hand towels 10 wash cloths 1 dress 1 bathmat 1 skirt 2 blouses 2 slacks 3 shirts 2 pillow cases Manual clean lint filter AL3132W Clean the lint filter after every load 1 Lift up agitator barrel 2 Wash or wipe the filter clean located in bottom of the agitator barrel The filter is not removable 3 Snap the agitator back into place NOTE On Model AL2121W lint is washed out with existing wash water If your washer drains into a tub remove any lint collected in the tub or strainer Knits Delicates 2 slacks 2 camisoles 2 blouses 4 slips 4 shirts 2 panties 4 tops 2 bras 2 dresses 2 nighties Common Washing Problems PROBLEM CHECK IF WHAT TO DO Dye t
6. d is properly sorted Separate lint givers towels from lint takers synthetics permanent press corduroys Separate synthetic items from cotton items Load is too big for capacity or Drop items in loosely DO NOT pack clothes tightly into basket water level Paper or tissue is in pocket Check pockets before washing Enough detergent is used Use more detergent Pilling is being mistaken for lint Laundering raises a surface fuzz called pilling Synthetics are more likely to pull than other fabrics Rinse is cold Cold rinses leave loads colder wetter but save money energy and cause fewer wrinkles Close lid firmly Complete cycle before opening lid Lid has been opened before spinning has completed Continued on next page Page 7 PROBLEM CHECK IF WHAT TO DO Chlorine bleach can permanently yellow some fabrics Read fabric washing label and chlorine bleach package label carefully Overall Chlorine bleach is used yellow brown or yellow Iron 1s in water heater or pipes stains Run hot water a few minutes before washing to clear lines Drain water heater occasionally DO NOT use chlorine bleach in water containing iron Use a water conditioner in wash and rinse water Iron or manganese is in water Install an iron filter Fabric is poor quality Check fabric quality before purchasing Follow fabric care label directions Fabri
7. er supply hoses are kinked Cycle control knob is set and pulled out a Open both faucets s Straighten hoses Set cycle control knob and pull out firmly Lid is closed Power cord is plugged into a live circuit with proper voltage Washer does not spin s Close lid firmly Firmly plug power cord into electrical outlet Check circuit voltage at your home s fuse circuit breaker box a Replace fuse with a time delay fuse of the correct capacity Reset circuit breaker u Household fuse has blown or circuit breaker has tripped Check if time delay fuse has been used Washer stops during a cycle a Wait a minute to see if washer starts cycle again a Firmly plug power cord into electrical outlet Check circuit voltage at your home s fuse circult breaker box s Replace fuse with a time delay fuse of the correct capacity Reset circuit breaker a Washer pauses briefly at different times in each cycle These pauses are normal Power cord is plugged into a live circuit with proper voltage Household fuse has blown or circuit breaker has tripped Check if time delay fuse has been used Washer fills and drains Cycle control knob is pointing to a s Set cycle control knob on correct number in without running number in the cycle the cycle Washer drains during a Drain hose is higher than the water s Adjust drain hose s
8. h cycle control knob in Turn as being washer safe knob clockwise to just beyond any dot on the dial See Rinse and Before leaving on vacation spin on page 6 for additional information 1 Shut off both water faucets 5 Pull knob out and allow washer to 2 Unplug power cord and turn off run for about 30 seconds to mix electric power supply antifreeze and water 6 Unplug power cord and turn off electric power supply 7 Store where washer will not freeze To use washer again 1 Flush water pipes and hoses 2 Reconnect water inlet hoses according to Installation Instructions 3 Open both water faucets 4 Plug power cord into electrical outlet 5 Clean out antifreeze by adding one cup of detergent to basket and running washer through a complete cycle Page 10 Before You Call For Service If you are having an operating problem check this chart to see what might be the cause before you call for assistance OPERATING PROBLEM CHECK IF WHAT TO DO Washer will not fill a Power cord is plugged into a live circuit Firmly plug power cord into electrical with proper voltage outlet Check circuit voltage at your home s fuse circuit breaker box a Replace fuse with a time delay fuse of the correct capacity Reset circuit breaker Household fuse has blown or circuit breaker has tripped Check if time delay fuse has been used a Both hot and cold water faucets are open a Wat
9. ippers snaps and hooks and remove pins buckles and other hard objects to prevent scratching laundry basket agitator or snagging other items Remove unwashable trim and ornaments Tie strings and sashes to prevent tangling Mend tears loose hems and seams Treat spots and stains Pre soak if necessary Reduce risk of fire electrical shock or personal injury when using your washer by follow ing basic precautions including the following a The washer must be electrically grounded See Installation Instructions Store detergent and laundry products in a cool dry place out of children s reach A locked cabinet is recommended Read and follow instructions on detergent and laundry packages Pay special attention to warnings and precautions DO NOT use chlorine bleach in the same wash as ammonia vinegar rust remover or other acids Hazardous fumes can form DO NOT machine wash glass fiber materials Small particles can stick to fabrics washed in folowing loads and cause skin irritation DO NOT use or store dry cleaning solvents kerosene or other flammable or explosive substances in or near your washer These substances give off vapors that can create a fire hazard or explosion special Model Features Water level selector AL3132W Agitator Manual clean lint filter AL3132W not shown Basket The drawings in this book may vary slightly from your washer model They a
10. ld water dissolve recommended amount of detergent in one quart 1 L of warm water before adding it to the washer or use a liquid detergent 3 CYCLE SL fx 10 PERMANENT PRESS Select wash time REGULAR NORMAL 6 gO if HEAVY EES OFF A i OFF fz10 PERMANENT RES PULL START PUSH STOP Select a wash time by stopping the washer after filling Turn cycle control knob to the number in the wash cycle you want The numbers are minutes of wash time Restart the washer To start Pull cycle control knob out The washer will agitate for a selected number of minutes Agitation can occur with the washer lid up or down The washer will pause briefly throughout each cycle These pauses are normal for washer operation To stop at any time Push cycle control knob in To restart pull cycle control knob out Page 5 Other Features Rinse and spin REGULAR NORMAL 6 SE Yo ey 10 ffY HEAVY ES A fz10 IE IAE S PULL START PUSH STOP PERMANENT PRHE Complete rinsing of fabrics washed with extra detergent may require an extra rinse and spin To set for extra rinse and spin 1 Push cycle control knob in 2 Turn knob clockwise to one of the dots on the dial as illustrated above See arrows in drawing 3 Pull cycle control knob out The washer will fill to selected level agitate drain and spin Laundry Load Guide Use highest water level for these suggeste
11. led fabrics some non colorfast colors Dry detergents can spot fade wet laundry If using cold water dissolve recommended amount of detergent in one quart 1 L of warm water before adding it to the washer or use a liquid detergent To change load size The washer wil automatically fill for highest water level when cycle control knob is turned to 14 or 10 minutes in the REGULAR HEAVY Cycle or to 6 minutes in the SHORT Cycle For smaller load sizes and a lower water fill follow these steps 1 Push cycle control knob in and turn clockwise to 14 minutes for hot water or 10 minutes for warm water in the REGULAR HEAVY Cycle 2 Pull cycle control knob out The washer will start to fill 3 When the washer reaches the desired water level push cycle control knob in and turn clockwise until it points to 6 minutes in the REGULAR HEAVY Cycle 4 Pull out cycle control knob to start the washer WATER LEVEL Select water level WATER LEVEL To set the correct water level turn the water level selector knob to the level that describes the size of your wash load The water level can be set to SMALL a few small items or LARGE a full load NOTE For best results with permanent press clothes use the LARGE water level Reduce wash time when using the SMALL water level setting Loads with only a few small items need less wash time for best results Wash cycles Regular Heavy 14 min Wash s
12. ly in the rinse part of the cycle Fabric softeners should not be mixed with other laundry products Too much fabric softener can make some items non absorbent diapers and towels If this happens use less fabric softener or do not use it every time Soaking When soaking in your washer a Always use detergent u If using chlorine bleach also add detergent Vinegar or other acids should not be used in your washer because acids attack all porcelain basket finishes and can reduce the life of your washer Use only products labeled as being washer safe Stain removal guide A WARNING Fire Hazard Never put dry cleaning solvents or fluids directly into your washer Never put items treated with solvents in your washer until they have been completely rinsed and air dried The fumes from these solvents can create a fire or explosion Treat stains when they are fresh Old or set stains may not come out Before treating check type of stain fabric label and how colorfast it is how old the stain is Use cold or warm water first Hot water can set some stains Use a bleach that is safe for the garment Dilute chlorine bleach Test stain remover products on inside seam or hidden corner of item to check colorfastness Put stained area face down on paper towel or white cloth Apply stain remover to back of stain to force the stain off the fabric instead of through it Use
13. meat tenderizer or enzyme presoaks for easier removal of some protein stains Use dry cleaning solvents in a well ventilated room For specific stain removal recom mendations ask your Cooperative Extension Service Office or consult a public utility home economist Tints and dyes a Follow package directions for tints and dyes When you are finished 1 Put chlorine bleach and detergent in the washer 2 Run through a complete cycle using hot water 3 Repeat if staining occurs on following loads NOTE Washer parts such as agitator washer lid etc can be stained by the dye color Page 9 Caring For Your Washer To keep your washer looking like new To protect your washer from Wipe up detergent bleach or other freezing spills with a soft damp cloth as they occur Install and store your washer where it Sharp or heavy objects should not won t freeze Because some water stays be put on or in your washer Check in the washer freezing can damage it If pockets for nuts bolts etc your washer iS stored Qr moved during TP Ene AWARE ntenorneeds freezing weather winterize it cleaning put 1 cup of chlorine 1 Shut off both water faucets bleach and 2 cups of detergent in 2 Disconnect and drain water inlet the washer Run through a hoses complete cycle using hot water 3 Put a quart of R V type antifreeze When removing hard water in the washer basket deposits use only cleaners labeled 4 Pus
14. o that it is higher than wash and rinse cycles or level in the washer the water level in the washer water siphons out Page 11 LIMITED WARRANTY E ROPER ee a e See ee Home Appliances LENGTH OF WARRANTY PRODUCTS COVERED WHAT WE WILL PAY FOR From date of purchase FULL ONE YEAR WARRANTY All Roper Appliances Replacement parts and repair labor to correct defects in materials or workmanship FULL FIVE YEAR WARRANTY Refrigerators Replacement parts and repair labor for Freezers the sealed refrigeration system Air Conditioners compressor evaporator condenser Dehumidifiers drier or connecting tubing which we find to be defective in materials or workmanship LIMITED 2ND 5TH YEAR Microwave Ovens Repair or replacement of magnetron WARRANTY tube which we find to be defective in materials or workmanship LIMITED 2ND 5TH YEAR Automatic Washers Repair or replacement of any part of WARRANTY the gear case assembly which we find to be defective in materials or workmanship Po WE WILL NOT PAY FOR SERVICE CALLS TO 1 Correct the installation of your appliance 2 Instruct you how to use your appliance 3 Replace house fuses or correct house wiring or plumbing 4 Replace owner accessible light bulbs Repairs when appliance is used in other than normal single family household use Pick up and delivery Your appliance is designed to be repaired in the home Damage to appliance caused by accident misuse fire flood act
15. ortant Safety Instructions Energy Saving Tips Before You Wash Special Model Features Sort the load Load the washer Using Your Washer AL2121W large capacity single speed washer AL3132W large capacity single speed washer Other Features Rinse and spin Drain and spin Manual clean lint filter Laundry Load Guide Common Washing Problems Laundry Tips Caring For Your Washer Before leaving on vacation To protect your washer from freezing __ Before You Call For Service Warranty How to get service or assistance e e e ea j NON CCSOOCNOAMOON A PWWOWMND Important Safety Instructions AWARNING Read all instructions before using your washer DO NOT wash items cleaned in washed in soaked in or spotted with gasoline dry cleaning solvents paint wax or other flammable or explosive substances in the washer The fumes can create a fire or explosion Always hand wash and air dry fabrics containing these materials DO NOT allow children to play on or inside the washer Close supervision of children is necessary when the washer is used near them Before the washer is removed from service or discarded remove the lid to prevent accidental entrapment DO NOT reach into the washer basket while it is filing with water while agitator is moving or while basket is spinning If the lid is opened while the basket is spin ning the basket will automatically stop in a few seconds Energy Saving Tips 1 o1 Use washer during
16. ransfer Load is properly sorted Separate colorfast from non colorfast items Prevent light colored items from contacting non colorfast items Unload washer immediately Gray whites dingy colors Greasy spots Load too wet after spin Load has been left in washer for extended time Load is properly sorted Separate white colored and non colorfast items Enough detergent is used Increase amount of detergent Hot water should be at least 130 F 54 C Use liquid detergent in increased amounts for water hardness and amount of soil Use a water conditioner in the wash and rinse Water is hot enough Water is too hard for soap or detergent used Install a mechanical water softener Undiluted fabric softener touches Dilute fabric softeners with 1 2 to 1 cup 125 to 250 mL warm water fabric Fabric softener added to wash water Enough detergent is used Add fabric softener only in rinse part of the cycle Use enough detergent to hold soil so it drains away with wash water Treat spots with heavy duty liquid detergent Wash in warm or hot water with extra detergent Wash more than once DO NOT dry between washings Wipe with a damp cloth or remove deposits by running a complete cycle using hot water 2 cups 500 mL of detergent and 1 cup 250 mL of chlorine bleach Soil deposits are present on basket interior or agitator Loa
17. re designed to show the different Sort items by lint givers chenille bath features of all the models covered by this towels and lint takers corduroy book Your model may not include allthe permanent press and synthetics features shown Sort the load sort by fabric and construction cottons knits and delicate items sort by color white colorfast and non colorfast Sort by amount of soil heavy normal and light Load the washer Drop items into washer loosely and evenly For best cleaning and wrinkle free results items should move freely in wash water Permanent press and synthetic knits should have more room to move in the water than towels jeans etc For specific loading recom mendations see page 6 LG Cycle control knob Model and serial number plate under lid Tub Laundry Tip DO NOT overload washer Overloading or packing can cause poor cleaning increased wrinkling excessive lint and can wear out items faster Use highest water level for the best permanent press results Page 3 Using Your Washer Set cycle water temperature and wash time REGULAR 6 PULL START PUSH STOP Water temperature and load size are selected through wash time Hot water can be selected by turning cycle control knob to 14 minutes in the REGULAR HEAVY Cycle Rinses are cold Warm water can be selected by turning cycle control knob to 10 minutes in the REGULAR HEAVY Cycle or
18. s of God or use of product not approved by us Any labor costs during the limited warranties This Roper appliance is warranted by Whirlpool Corporation Under no circumstances shall it be liable under this warranty for incidental or consequential damages and all implied warranties are limited to the same time periods stated in the express warranties for Roper Brand Appliances Some states do not allow the exclusion or limitation of incidental or consequential damages or limitations of how long an implied warranty may last so the above limitations or exclusions may not apply to you This warranty gives you specific legal rights and you may also have other rights which vary from state to state Outside the United States a different warranty may apply For details please contact your franchised Roper distributor or military exchange HOW TO GET SERVICE OR ASSISTANCE If you need service first see the Before You Call For Service section of this book If you still need service after checking this section additional help can be found if you Contact your selling dealer for the authorized servicer in your area OR Phone 1 800 44 ROPER 1 800 447 6737 between 8 00 a m and 4 30 p m Eastern Time Monday through Friday OR For further information write to Consumer Relations Dept Roper Brand Appliances 2000 M 63 North Benton Harbor MI 49022 When requesting assistance please provide the model and serial numbers date of purch
19. sket for extended time Yellow areas Body oils may have stained Make sure water is hot at least 130 F 54 C fabric usually found on the middle of pillowcases and sheets underarms of cotton clothing Increase the amount of detergent Page 8 Laundry Tips Stained or wet garments should be washed promptly Dry laundry immediately after washing to prevent wrinkling For best results when using soap detergent chlorine or all fabric bleach fabric softeners pretreatment or enzyme laundry products packaged water conditioners bluing ammonia or starch follow the package instructions Water hardness Many poor washing results can be traced to wash water hardness To check your water hardness a City water ask your city water company Well water call your Cooperative Extension Service Ask for the mineral content in grains per gallon or parts per million If your water 1s 9 or more grains per gallon or more than 153 parts per million Consider installing a water softener Use more detergent Use a packaged water conditioner Do Not use soap Fabric softeners Always dilute fabric softeners with 1 2 to 1 cup 125 to 250 mL warm water Undiluted fabric softener can stain fabrics Add fabric softener after the washer fills for the rinse part of the cycle See arrows in the illustration under Rinse and spin on page 6 Use liquid fabric softener on
20. to 6 minutes in the SHORT Cycle Rinses are cold Push in cycle control knob and turn it clockwise Stop when indicator on knob s outer ring points to the number in the wash cycle you want The numbers are minutes of wash time Wash cycles Regular Heavy 14 min Wash sturdily constructed fabrics i e cotton or heavily soiled items Regular Heavy 10 min Wash moder ately soiled fabrics Short 6 min Gently wash lightly soiled delicates and washable knits NOTE Use shorter wash times for lightly soiled loads Loads with only a few small items need less wash time for best results Page 4 2CYCLE REGULAR 6 HEAVY ol ZIRAN AL2121W Large Capacity Single Speed Washer To start Pull cycle control knob out The washer wil fill to the selected water level and water temperature Immediately after filing the washer will agitate for a selected number of minutes Agitation can occur with the washer lid up or down The washer will pause briefly throughout each cycle These pauses are normal for washer operation To stop at any time Push cycle control knob in To restart pull cycle control knob out Laundry Tip For best cleaning results use Hot wash water for normally soiled permanent press and synthetic items white and color fast cottons heavy soils and diapers Warm wash water for knits dark or non colorfast colors washable woolens moderate soil Cold wash water for lightly soi
21. turdily constructed fabrics i e cotton or heavily soiled items Regular Normal 6 min Wash moder ately soiled fabrics Permanent Press 10 min Wash moderately solled permanent press and some synthetic fabrics Cool down rinse helps to keep fabrics from wrinkling Permanent Press 6 min Wash lightly soiled permanent press and some synthetic fabrics Cool down rinse helps to keep fabrics from wrinkling REGULAR Konma AL3132W Large Capacity Single Speed Washer Select cycle and water temperature REGULAR NORMAL 6 HEAVY eS OFF To set the water temperature push in the cycle control knob and turn it clockwise to the area marked H hot W warm or C cold Set water temperature level according to fabric label or the amount of soil to be washed NOTE All rinses use cold water Start the washer by pulling out cycle control knob The washer will fill to the level you set with wash water of the selected temperature After filling stop the washer by pushing in cycle control knob Select wash time Laundry Tip For best cleaning results use Hot wash water for normally soiled permanent press and synthetic items white and color fast cottons heavy soils and diapers Warm wash water for knits dark or non colorfast colors washable woolens moderate soil Cold wash water for lightly soiled fabrics some non colorfast colors Dry detergents can spot fade wet laundry If using co
Download Pdf Manuals
Related Search