Kenmore 580.53650 Dehumidifier User Manual
Contents
1. POS NO PART NO DESCRIPTION 1 B 46871 A20034E MOTOR ASSY SINGLE 2 B 5900AD2013A FAN ASSY PROPELLER 3 B 4H02861A FAN NUT 4 B 5403A20027D CONDENSER ASSY 5 B 54214200466 EVAPORATOR ASSY 580 53650 CAUTION When ordering parts use the Kenmore part number not the position number COMPRESSOR PARTS HSITDN3 POS NO PART NO _ DESCRIPTION PO INFZU FOD A NUT TERMINAL COVER 2 3550U LO04A TERMINAL COVER 3 C G750U LO35A OL P 4 C 4986U L0016 GASKET 5 5416A90003A COMPRESSOR 6 C 1NHA0801 206 NUT HEXAGON 1 PE 4810AR4155A BRACKET WASHER B C 4830A300054 BUSHING 9 C 5211A20237B TUBE ASSY SUCTION 10 C 5211A10070E TUBE ASSY DISCHARGE TIG 5211A10085B TUBE ASSY CAPILLARY 12 3035015X THERMISTOR ASSY 132. Dehumidifier runs too much the coils temperature is below 65 F 18 C Fan noise Air is moving through the This is normal dehumidifier Bucket drain hose Check the hose if one is attached Water on floor connection may be loose Water bucket is not all the See the Removing and Emptying The Water i way in Bucket a _ REPAIR PARTS To order Parts call Toll Free Dehumidifier Model No 580 52650 800 4 MY HOME 7 800 469 4663 CAUTION Use the Kenmore part number on all orders not the ius tration number OUTER CASE PARTS AND CONTROL PART mm 2 i Ba Y a POS NO PART NO DESCRIPTION POS NO PARTNO DESCRIPTION LA 3041AD2007F BASE ASSY WELD 10 A 4H00442J CLAMP CAPACITOR 2 A 3661A30003B HOUSING ASSY SINGLE 11 A 6631A20008C CONNECTOR ASSY 3 A 30864300064 DRAIN PAN 12A 5230AD3005A FILTER AIR 4 A G600A30003C SWITCH ASSY MICRO 1S5A GAlTA20001L POWER CORD ASSY 5 A 6877A30013F LEAD WIRE ASSY 14 A 3530A10006F GRILLE FRONT 6 3090A10001U CABINET 15 A 38314200168 ESCUTCHEON 7 A 4994A20012A CONTROL BOX SINGLE 16 A 35504A30118A COVER DISPLAY B A 6871A101625 PWB ASSY MAIN 17 A 4838A20005A TANK BUCKET 9 A OCZZA20001F CAPACITOR 8A 3096AR2871H SOUND PROOF 19 A 6871A20170A PCB DISPLAY 414 580 53650 CAUTION When ordering parts use the Kenmore part number not the position number CYCLE PARTS
3. a Humidity indicator a Power Control Humidity Control Fan Speed Control and Timer Control Bucket Full indicator This light glows when the water bucket is full and needs to be emptied Power Operation starts when this button is pressed and stops when the button is pressed again Humidity Control This controls the humidity in the room e To raise the humidity setting ae To lower the humidity setting The humidity can be set within a range of 30 HH 70 RH by 5 increments Fan Speed This controls the speed of the airflow High Fan speed is set to high Low Fan speed is set to low When Fan Speed button is pressed the fan speed mode is changed Timer Control Press the Timer button to set the amount of time you want the unit to run The Timer can be set for Constant 8 hour 4 hour or 2 hour When Timer button is pressed the Timer indicator lights shift as follows Constant gt 2 hr gt 4 hr 8 hr gt Constant TO OPERATE THE DEHUMIDIFIER 1 Plug the power cord into an electrical outlet Press the power button 2 Set the Humidity Control anywhere between 30 RH and 70 RH for normal operation F you need more drier air press the se Humidity Control button if you need less moisture air press the wa Humidity Control button 3 Press the Power button to stop the unit manually 4 Press the Timer button to set the amount of time you want the unit to run At the end of that time the unit will shut of
4. prong from the power cord Grounding type wall receptacle Do not under any circumstances cut remove or bypass P the grounding prong from this plug 7 Power supply cord with 3 prong grounding plug PUTA ELECTRICAL INFORMATION The complete electrical rating of your new dehumidifier is stated on the serial plate Refer to the rating when checking the electrical requirements Be sure the dehumidifier is properly grounded To minimize shock and fire hazards proper grounding is important The power cord is equipped with a three prong grounding plug for protection against shock hazards Your dehumidifier must be used in a properly grounded wall receptacle if the wall receptacie you intend to use is not adequately grounded or protected by a time delay fuse or circuit breaker have a qualified electrician install the proper receptacie Do not use an extension cord or an adapter plug fal L D ae OBSERVE ALL LOCAL CODES AND ORDINANCES DO NOT UNDER ANY CIRCUMSTANCES REMOVE THE POWER SUPPLY CORD GROUND PRONG ELECTRICAL GROUND IS REQUIRED ON THIS APPLIANCE A 115 volt 60 Hz AG only 15A fused and properly grounded electrical supply is required A time delay fuse or time delay circuit breaker is recommended Use a dedicated circuit serving only this appliance DO NOT USE AN EXTENSION CORD RECOMMENDED GROUNDING METHOD For your personal safety th
5. Owner s Manual Manual del Propietario LLI nore 0 DEHUMIDIFIER DESHUMIDIFICADOR Model Modelo 580 53650 Fall L j E SeA Ela IONWdSS Sears Roebuck and Co Hoffman Estates IL 60179 U S A www sears com ABLE OF CONTEN TABLE OF CONTENTS crrcrsreeereseertsetesescesens 2 AUTOMATIC SHUT OFF sxe sss toasty 8 WARRANTY eneen a rE EE 2 REMOVING AND EMPTYING E 3 THE WATER BUCKET scociosierociocisninancamenti ns 8 Important Safety Instructions O see ee 3 MAINTENANCE dn deste wd wee eebaneboerlecsvrceurnuecesasaues 9 ELECTRICAL REQUIREMENTS eee 4 Grille and CASE ooo ec ccc eeseeceseceeserees 9 OPERATION a ro Aaa A 5 Air filter A Aa a debe T 9 Feaiiregte Gingiuyaroe nihii 5 Cleaning inside the Unites rrr 9 Control Panel macarena 6 General Cleaning ovenss venenenennnn 9 INSTALLING YOUR DEHUMIDIFIER 7 Water bucket cleaning 9 Defrost COntrobh essssssssiserserresesersrreseren 7 TROUBLESHOOTING vocento 10 CHOOSING THE PROPER LOCATION 7 REPAIRRARTS covevesnnnunuenennnse u ESPA OL esmas pies a reien atii lbs 14 SERVICE NUMBERS reer Back Cover WARRANTY FULL ONE YEAR WARRANTY ON DEHUMIDIFIER For one year from the date of purchase if the Dehumidifier is operated and maintained according to the owner s instructions furnished with the product Sears will repair the Dehumidifier free of charge if defective in materials or workmanship FULL FIVE YEAR WARRANTY ON SEALED REFRIGERATION SYS
6. TEM For five years from the date of purchase when this Dehumidifier is operated and maintained according to owner s instructions furnished with the product Sears will repair the sealed refrigeration system consisting of refrigerant connecting tubing and compressor motor free of charge if defective in material or workmanship WARRANTY SERVICE IS AVAILABLE BY RETURNING UNIT TO THE NEAREST SEARS SERVICE CENTER IN THE UNITED STATES This warranty applies only while this Dehumidifier is used in the United States This warranty gives you specific legal rights and you may also have other rights which vary from state to state i Sears Roebuck and Co D 817WA Hoffman Estates IL 60179 U S A SAFETY IMPORTANT SAFETY INSTRUCTIONS The safety instructions below will tell you how to use your dehumidifier to avoid harm to yourself or damage to your dehumidifier A WARNING FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance Read product labels for flammability and other warnings PGi PREVENT ACCIDENTS To reduce the risk of fire electrical shock or injury to persons when using your dehumidifier follow basic precautions including the following Be sure the electrical service is adequate for the model you have chosen d WARNING Avoid fire hazard or electric shock Do not use an extension cord or an adapter plug Do not remove any
7. f The Timer can be set for Constant 8 hours 4 hours or 2 hours 5 If you want to control the speed of airflow press Fan Speed bution Each time that the Fan Speed button is pressed the fan speed mode is shifted High gt Low gt High Note Be careful not to lose the water bucket This dehumidifier doesn t run if the water bucket is not installed property install the dehumidifier on a level floor strong i enough to support the unit with a full bucket of water For best performance allow at least 12 18 inches of alr space on all sides of the unit for good air circulation Keep all outside doors windows and other openings closed when operating the dehumidifier Humid outdoor air will add to the unit s work load install your dehumidifier in an area where the temperature will not fall below 65 F 18 C At temperatures below this the coils can become covered with frost NOTE frost occurs the unit will cycle on and off This is normal Unplug the unit or turn the unit off until the frost melts and the room temperature rises DEFROST CONTROL When the defrost contro senses frost build up on the evaporator coll it will automatically shut off the compressor The fan will continue to run to draw air across the coil and melt the frost When the coil is defrosted the compressor will automatically restart and dehurnidifying resume Use the dehumidifier in a basement to help prevent moist
8. is appliance must be grounded This appliance has a power supply cord with a 3 prong grounding plug To minimize possible shock hazard the cord must be plugged into a mating grounding type wall receptacie and grounded in accordance with the National Electrical Code ANSI NFPA 70 latest edition and all loca codes and ordinances If a mating wall receptacie is not available it is the personal responsibility and obligation of the customer to have a properly grounded 3 prong wall receptacie installed by a qualified electrician Electrical Shock Hazard Plug into a grounded 3 prong outlet Do not remove ground prong Do not use an adapter Do not use an extension cord Failure to follow these instructions can result in death fire or electrical shock f FAA 3 prong ea grounding grounding A A val plug ag eceptacie Power supply cord ES esheets FEATUR me AWARNI NG To reduce the risk of fire electric shock or injury to persons read the important SAFE instructions section before operating this appliance 1 CONTROL PANEL 2 GRILLE FRONT 3 POWER CORD 4 GABINET 5 AIR FILTER 6 WATER BUCKET Z O E QD aa OPERATION e 3 Po chin Constant AA 6 Hr BUCKET HUMIDITY EAN esn Fuit CONTROL SPEED 4 Hr a pie 2 Hr POWER NS Low STIMER CONTROL PANEL Your dehumidifier contro panel contains a Bucket Full indicator
9. tely into the outlet The fuse is blown or circuit Check the house fuse or circuit breaker box breaker is tripped _ and replace the fuse or reset the breaker Water bucket is full gt The dehumidifier automatically turns off i when this occurs Empty the bucket Bucket is not installed Make sure a bucket in the right place Dehumidifier Did nat allow enough time When first installed allow at least 3 or 4 does not dry the to remove the moisture O RIA O AO air as it should Airliow is restricted Make sure there are no curtains blinds ar f furniture blocking the front or back of the dehumidifier The Humidity Control may Press the 4 Humidity Control button to not be set low Humidity lower the humidity Doors and windows may e Check that all doors windows and other not be closed tightly openings are securely closed Clothes dryer may be blowing gt Install the dehumidifier away from the dryer moisture laden air into the room The dryer should be vented to the outside Room temperature is too The unit will not operate satisfactorily if the low room temperature is below 65 F 18 rea to be dehumidified is Check with your dealer to see if the capacity too large is adequate Doors and windows are open gt e Close all doors and windows to the outside Dehumidifier has been This is normal Frost will usually disappear Frost appears on recently turned on or room within 60 minutes
10. the bucket GRILLE AND CASE To clean the case Use water and a mild detergent Do not use bleach or an abrasive cleaner To clean the grille Use a vacuum with an attachment or brush AIR FILTER The air filter is on the back of the dehumidifier it should be checked and cleaned at least every 30 days or more often if necessary TO REMOVE Flex the filter at the lower right corner and slide the upper right side to the left Release all of the tabs and remove the filter Wash it in warm soapy water Rinse and let the filter dry before replacing it CLEANING INSIDE THE UNIT After removing the air filter clean the coil on the inside with a soft brush to remove any soft and wet soil NOTE Do not allow water to enter the electrical machine compartment through the circular opening behind the coil Do not spray the coil with a hose GENERAL CLEANING e Dust the front grille and the side panels with a soft brush or use the dusting attachment of your vacuum If cabinet paint chips you can touch up the paint with a good grade enamel to prevent rust WATER BUCKET CLEANING Every few weeks rinse the inside of the water bucket with a mild detergent to prevent growth of mold mildew and bacteria TROUBLESHOOTING Problem gt Possible Causes What ToDo ooo oces Dehumidifier The dehumidifier power e Make sure the dehumidifier plug is pushed does not start cord is unplugged comple
11. ure damage Use the dehumidifier in cooking laundry bathing and dishwashing areas that have excessive moisture Use the dehumidifier to prevent moisture damage anywhere books or valuables are stored When the bucket is full or when the bucket is not in the proper position the Bucket Full light turns on and the unit automatically shuts off Also when bucket is out of position the unit will beep 3 times The bucket must be replaced in the proper position for the dehumidifier to work The light will be on and the dehumidifier will not run if the bucket is not in the proper position REMOVING AND EMPTYING THE WATER BUCKET _ The water bucket can be emptied in one of three ways Empty the bucket manually Place the dehumidifier Atiach a garden hose to the When the bucket is full directly over drain threaded bucket drain hose remove and empty it into a The bucket has a threaded connection to carry water ta large sink or e When hose connection which canbe the drain HAND TIGHTEN ONLY finished replace it properly left open Drill a 1 4 6 4mm When being attached to the NOTE To replace the bucket to 1 2 13mm hole in the bucket drain hose connection property make sure the center of the hose connection be sure the hose doesn t kink slots on the back of bucket Once opened the hose or bend it should lie flat from are positioned correctly connection will continually the dehumidifier to the drain drain water from
Download Pdf Manuals
Related Search