Homelite HL454HP Lawn Mower User Manual
Contents
1. Mountfield oil part number MX855 is available from any Mountfield stockist or B amp Q store e Fill the fuel tank with UNLEADED petrol Use only clean fresh petrol stale fuel may contain deposits that will clog the carburettor Do not overfill the petrol level should be below the bottom of the fuel tank neck e Ensure that the spark plug lead is securely connected to the spark plug Fuel Filler Cap Handle 4 FAST ep SLOW Oil Filler Cap Air Filter Dipstick PEA Exhaust Spark Plug Figure 3 Figure 4 e Move the throttle control to the Choke positiion Figure 4 Pull and hold the Operators Presence Control OPC lever against the handle to disengage the engine brake THE ENGINE WILL NOT START OR CONTINUE TO RUN UNLESS THE OPC LEVER IS HELD AGAINST THE HANDLE e Pull the starter cord with a strong smooth pull Do not remove the pull cord from the guide e When the engine starts move the throttle control from Choke to the Fast position e Toengage the drive to the rear wheels on Self Propelled models pull and hold the clutch lever against the handle To stop the drive release the clutch lever NOTE Using the choke is usually unnecessary when starting a warm engine However in cool weather it may still be necessary to use the choke to start the engine STOPPING YOUR MOWER e Release the Operators Presence Control OPC lever this will engage the engine brake and operate the ignit2. NEVER TIP THE MOWER ONTO ITS SIDE AS THIS WILL FLOOD THE AIR FILTER WITH OIL To access the underside of the machine lift the front wheels by lowering the handle to the ground Carefully remove the mower from the carton and read these Operating Instructions An Owner s Manual for the engine is also included please read this before starting the engine HANDLE ASSEMBLY Figure 1 e Attach the bottom of the handle 1 to the holes on the side of the cutter deck Secure it using the nuts and bolts supplied 2 e Fitthe top handle 3 using the bolts provided 4 ensuring that the pull cord guide 5 is positioned correctly Pull the starter cord and fit it into the cord guide e Use the cable ties 10 to fit the OPC cable and clutch cable if fitted to the handle assembly Take care that the cables will not impair removal of the grass collector Figure 1 GRASS COLLECTOR Figure 2 e Join the top 1 and bottom 2 of the grass collector together Push the two parts firmly until they click into place all the way round e Use the screws supplied 3 to secure the pieces firmly in place e To fit the grass collector onto the mower lift the rear safety deflector flap and hook the collector onto the pegs Figure 2 STARTING YOUR MOWER Read and understand the Safety Precautions before using your mower e Put Mountfield 4 stroke or an SAE 10W 30 oil in the oil filler Figure 3 Do not overfill the oil tank capacity is 0 6 litre
3. Z WARNING PETROL IS HIGHLY FLAMMABLE AND EXPLOSIVE UNDER CERTAIN CONDITIONS e Store petrol in a cool place and only in containers specifically designed for the purpose Refuel outdoors only with the engine stopped DO NOT SMOKE while refuelling After refuelling replace the fuel tank cap and the petrol container cap securely Never remove the fuel tank cap or add petrol when the engine is hot or when it is still running If any petrol is spilt do not attempt to start the engine Move the mower away from the area clean up the spillage and allow the fumes to dissipate before starting the engine OPERATION e Donot operate the engine in a confined space Exhaust fumes contain CARBON MONOXIDE an odourless and POISONOUS gas e Mow only in daylight or good artificial light e Check the oil and fuel levels before starting the engine Disengage the engine brake and drive clutch before starting the engine Start the engine in accordance with the instructions and with feet well away from the cutter blade Do not tilt the mower when starting the engine Do not change the engine settings If adjustments are necessary contact your dealer The safety deflector flap must be in the down position if the mower is used without the grass collection bag in place Operate the machine at a comfortable walking pace never run behind the mower Avoid operating the machine on wet grass whenever possible Take care when working on slopes Mow across
4. s Stamp Dealer s Stamp bd GGP UK LIMITED Unit 8 Bluewater Estate Bell Close Plympton Plymouth Devon PL7 4JH England Part Number 171503942 0
5. the slope never up and down and exercise caution when changing direction Do not use the mower on slopes of more than 20 degrees Exercise extreme caution when reversing or pulling the mower towards you Stop the cutter blade when emptying the grass collector when crossing surfaces other than grass and when transporting the mower to and from the work area Never pick up or carry the mower when the engine is running STORAGE amp MAINTENANCE To reduce the risk of fire keep the mower and petrol storage areas free of grass leaves and grease Check the mower and grass collector regularly to ensure the machine is in a safe working condition Replace any worn or defective parts Only use genuine replacement parts Store the mower in a dry secure place out of the reach of children and well away from any fire hazard Allow the engine to cool before storage If the fuel tank has to be drained this should be done outdoors KNOW YOUR MOWER Clutch Lever Operator Presence Control OPC Lever Pull Cord Guide Throttle Control FOC Handle Securing Knob Fuel Filler Cap Oil Filler Cap Dipstick located at rear of engine Grass Collector Deflector Flap Height Adjuster Spark Plug Cutter Deck HOW TO GET MOWING Your Homelite lawnmower does not contain petrol or oil and these must be added before use Running the mower with insufficient oil can cause serious damage to the engine and will invalidate your warranty
6. Please Read These Instructions Before Using Your Mower Operating Instructions for model HL454HP amp HL454SP Lawnmowers powered by Mountfield V35 engine Product Codes 299164643 BQ 299264643 BQ These instructions are an addition to and should be read in conjunction with the Operator Manual enclosed with this mower Call our Helpline if you have any problems 0845 600 2912 Open from 9 00am to 5 00pm Monday to Saturday 10 00am to 4 00pm on Sunday Thank you for purchasing a Homelite lawnmower This machine will give you many years of safe and reliable service if operated in accordance with these instructions Please read and understand these Operating Instructions before using your mower failure to do so could result in personal injury or damage to the equipment N NEVER TIP THE MOWER ON ITS SIDE AS THIS WILL FLOOD THE AIR FILTER WITH OIL To access the underside lift the front wheels by lowering the handle until it rests on the ground SAFETY PRECAUTIONS PRECAUTIONS OAs Ave Read these Keep hands and Remove the Beware of Keep children instructions feet well away Warning spark plug lead objects that may bystanders and before using from the cutter before working be thrown up by pets away from your mower blade on the mower the blade the work area The following safety precautions must be observed at all times Please read them very carefully GENERAL e Know how to stop your mower quick
7. SL 464 TR Widht of cut 45 cm SUMEC M 150 Tested by SNCH 11 route de Luxembourg L 5230 SANDWEILER Conforms to the specifications of directives 98 37 EEC 89 336 EEC 2004 108 EC 2000 14 EC Conformity assessment procedure followed ANNEX VI Measured sound power level 95 dB A Guaranteed sound power level 96 dB A Reference to harmonised standards EN 836 EN 292 2 EN 1033 EN ISO 3767 EN ISO 14982 Sound pressure level at the ear measured in compli ance with 81 1051 EEC Viration level at the handle EN 1033 Castelfranco Veneto TV ITALY 01 10 2008 S Ferrari General Manager Feed fed feed feed feed etd eed eed Pee ee Fe fe Fe Fed ed ed fed ed etd eed fed ped fe NN pei e ed eA feed e etd eed eed Pee fe Fe ed fed ed Fed fed feed etd etd eed feed fed fe A peA eed ene Peed fee eed eed fe eed fee ed eed fe eed feed ee eed fe ed feed fe eed feed fe Peed feed ed feed fe fe fee pele pele Guarantee GGP UK Limited undertakes to provide a full guarantee against defective materials or workmanship for one year from the date of purchase If the machine is used for commercial purposes i e for hire or by contractors caravan sites or similar users this guarantee period shall be 90 days If any part or parts are found to be defective within the guarantee period GGP UK Limited via their authorised dealer will effect the repair or replacement at no charge to the owner providing that the fault is reported direct to the dealer All repai
8. connected then lift the front wheels by lowering the handle until it rests on the ground Do not tip the mower onto its side as this will flood the air filter with oil AFTER EACH USE Remove any grass pulp from the underside of the cutter deck using a non metallic instrument such as a piece of wood Take care not to damage the paintwork Examine the cutter blade for any damage A damaged blade may upset the balance of your mower and cause excessive vibration if in doubt refer to your dealer Inspect the grass collector and clean it if necessary If the mesh becomes clogged airflow will be reduced and impair grass collection The handle can be folded down to reduce the amount of storage space required Take care not to trap any of the operating cables when folding or unfolding the handle Store the mower in a clean dry area well away from any naked flames sparks or heat source LONG TERM If you are not using your mower for more than 28 days Give the machine a thorough clean paying particular attention to the underside Lubricate all moving parts At the end of the season empty the fuel tank either by running the mower out of fuel or tip the machine backwards and onto the back right wheel to drain the fuel into a suitable container Drain the carburettor by loosening the drain screw retighten the drain screw FAULT FINDING PROBLEM SOLUTION Check there is ample clean fresh fuel in the tank Engine will not start Check the cutte
9. ion safety cut out device ADJUSTING THE HEIGHT OF CUT The height of cut adjustment not only determines the length of the cut grass it also controls the airflow which carries clippings into the collector Ifthe discharge chute becomes blocked increase the airflow by raising the height of cut To prevent blockages when cutting long thick grass set the adjustment to the highest setting and cut the grass then cut it again on a lower setting Figure 5 To adjust the height of cut e stop the engine and disconnect the spark plug e putthe mower on a level surface e adjust the cutting height lever by pulling outwards and moving into the required position Figure 5 BEFORE EACH USE Always ensure that the mower is in a safe working condition Inspect the cutter blade for damage check safety devices and guards check that all nuts bolts and screws are secure Check the oil level as follows a Remove the oil filler cap and wipe the dipstick clean Figure 6 b Insert the dipstick into the filler neck and tighten down again Remove the dipstick and check the oil level oil should be at the FULL mark The oil tank capacity is about 0 6 litre or 20 fluid oz c Ifthe oil level is low add Mountfield oil part number MX855 or a SAE 10W 30 oil to the upper limit on the dipstick Do not overfill the oil level should not be above the FULL mark Fill the fuel tank with unleaded petrol Do not overfill the level should be below the bo
10. ly in an emergency Understand all the controls and how they operate e Donot allow children or anyone who is unfamiliar with these instructions to use the mower Local regulations may restrict the age of the operator e Keepchildren pets and other bystanders well away from the work area e Never put your hands feet or any implement under the cutter deck or inside the rear discharge chute The cutter blade will continue to rotate for some time after the engine is switched off STOP THE ENGINE AND DISCONNECT THE SPARK PLUG LEAD e Before carrying out any adjustments cleaning inspection or maintenance e If your mower is damaged or vibrates excessively Ensure the machine Is in a safe working condition before it is restarted e Before clearing a blockage or unclogging the discharge chute STOP THE ENGINE e Whenever you leave the mower unattended e Before refilling with petrol or oil PREPARATION e Wear sturdy footwear and long trousers when using the mower Never go barefoot or wear open sandals Avoid loose clothing that may snag on moving parts e Check the work area and remove any stones or other debris that may be thrown up by or cause damage to the cutter blade e Before use ensure that the mower is in a safe working condition Inspect the cutter blade for damage check safety devices and guards check that all nuts bolts and screws are secure e Never use the machine without a silencer or with a faulty silencer FUEL SAFETY
11. r blade is not fouling the ground preventing free rotation Check the Operators Presence Control OPC lever is fully released Engine will not stop Remove spark plug lead to stop engine using insulated gloves and refer to dealer Stop the engine and disconnect the spark plug lead using heat resistant gloves Failure to cut grass properly Check blade attachment bolt is tight Check condition of blade If seriously worn or damaged replace with a new one Stop the engine and disconnect the spark plug lead using heat resistant gloves Check and make sure there is no build up of grass inside the casing Check grass catcher is allowing air to flow through the fabric if it is clogged it should be washed carefully Failure to collect grass properly If the grass catcher is not clogged raise the height of cut to increase airflow Check to ensure the engine is running at the correct speed approximately 3000rpm If conditions are too severe to use the grass catcher remove it and work with the deflector in position spark plug lead and examine the blade assembly Refer to your local dealer CERTIFICATE OF CONFORMITY Ne eee Peed fee ee eed fe eed eee Peed ee eed Peed fe eed ea ed eed ed eed feed fe feed fed ed fed fed pe fel ed fede pe fe EC DECLARATION OF CONFORMITY The company GGP ITALY SPA Via del Lavoro 6 31033 Castelfranco V to TV ITALY Certify that the lawnmower walk behind with HL454HP type ESL 464 combustion engine HL454SP type E
12. rs must be carried out by an authorised Mountfield dealer Delivery and collection of the machine is the owner s responsibility and not covered under the terms of this guarantee This guarantee is not transferable Proof of purchase will be required in the event of a claim This guarantee does not apply to the routine replacement of parts that are subject to normal wear and tear or to normal service and maintenance parts This guarantee does not cover faults caused by neglect or misuse The engine manufacturer guarantees the engine fitted to this machine This guarantee is in addition to and does not detract from the contractual rights of the owner under Statute or common law PAA a a A a H tte teers ees eee eS he ee ee H a O E O ee PP E Ek a EL I a I AAA A On delivery of your new Homelite mower we suggest that lete the b to the right a ttatctatatatstatatatatatatetatatatatstatatatatats at you complete tne Dox to the rignt at TENENS The information for your machine is on the serial number label which is fixed on the cutter deck at the base of the handles You will be asked for these details if you have any problems or require spare parts Please keep your receipt proof of purchase will be required in the event of a claim Service Record ist Service 2nd Service Date of Service i oo l Date of Service eae P Next Service Due L Next Service Due PEE Dealer s Signature o Dealer s Signature re ee Dealer
13. ttom of the fuel tank neck MAINTENANCE Stop the engine and disconnect the spark plug lead before working on the machine DO NOT TIP THE MOWER ONTO ITS SIDE AS THIS WILL FLOOD THE AIR FILTER WITH OIL To access the underside of the machine lift the front wheels by lowering the handle until it rests on the ground CUTTER BLADE Examine the cutter blade regularly for wear or damage CLUTCH CABLE ADJUSTMENT Self Propelled model only ENGINE An engine manufacturer s Owner s Manual is supplied with your mower Please read this it provides detailed information on engine operation and maintenance Repair work other than routine maintenance should be carried out by an authorised dealer Aslightly worn blade can be re sharpened by your local dealer If the blade is damaged it should be replaced Replacement blade kits are available from your Mountfield stockist The part number for the blade kit is MS1196 If in doubt refer to your dealer or telephone 0845 600 2912 Make sure that the clutch lever is fully released Lengthen the cable adjuster by unscrewing it a couple of turns Figure 7 Engage the clutch lever and check that the rear wheels lock when the mower is pulled backwards Start the mower and ensure it does not drive when the lever is disen gaged STORAGE A little time spent on your mower after use will ensure many years of reliable mowing To access the underside of the cutter deck ensure the spark plug lead is dis
Download Pdf Manuals
Related Search