Golden Technologies LitewayTM Mobility Aid User Manual
Contents
1. hicle as this will render your warranty void Check the freewheel lever is in the locked position page 16 Check the battery charger is disconnected Check you have adjusted the seat as instructed in this manual get comfortable set the speed control dial to a low setting page 12 Make sure the road ahead is clear Switch on the vehicle page 12 Check the battery level indicator is in the green area page 12 Pull in right hand lever slowly page 13 The vehicle will now move The more you pull the lever in the faster the vehicle will go To brake release the lever If you become unsure or feel unsafe release the lever immediately As you get accustomed to the power you can increase the speed 31 Golden Liteway GL 100 Owner s Manual Revised 11 06 Diagnostics System Any fault condition of the controller or scooter will cause the Power on diagnostics LED to flash The LED light located on the faceplate of the scooter will tell you about the problem in how if flashes LED Flashes 1 time pause 1 time and pause Battery needs recharging of bad connection with battery LED Flashes 2 times pause 2 times pause Bad motor connection Check all connections between controller and motor LED Flashes 3 times pause 3 times pause Short circuit between motor and battery connection Contact authorized service facility LED Flashes 4 amp 5 times Not Used LED Flashes 6 times pause 6 times pause Controller2. s manual especially the sections on operating instructions safety guidelines maintenance and battery instructions Liteway Warranty My Golden Liteway dealer has instructed me on how to operate my scooter Signature Telephone 42 Golden Liteway GL 100 Owner s Manual Revised 11 06 LiTEWAY Owner s Manual technologies 2 aci GOLDEN Rise Roll Rest ide 401 Bridge Street Old Forge PA 18518 Phone 800 624 6374 Fax 800 628 5165 www goldentech com LitewayOM 1106
3. Possible Faults As you get used to your vehicle you will get a feel for how it behaves If something feels unusual for instance the vehicle does not accelerate or brake smoothly the brakes are not holding ona slope or the steering feels different contact your dealer immediately and explain to the technician exactly what the problem is This will help diagnose the problem 28 Golden Liteway GL 100 Owner s Manual Revised 11 06 Troubleshooting Guide This table is a guide to fault finding The fault may be a simple fix If you have any doubts contact your dealer Symptom Unit does not move Check Does the battery level indicator work when the ignition is switched on Steering is loose when driven Check Have you hit a curb or obstacle hard Are the handlebars straight when riding in a straight line Vehicle behaves erratically when driven Check Does the vehicle shudder or cutout Short range Check If the red charging lamp stays on after all night charging page 27 it could be a defective battery Solution Freewheel is engaged page 16 Batteries flat check level page 14 Check for tire damage Damaged steering contact dealer Loose seat contact dealer Possible electronic problems contact dealer Binding front wheels Binding rear wheel emergency brake owitch into freewheel and the vehicle should move easily page 16 If not contact dealer 29 Golden Liteway GL 100 Owner
4. 2 Fold down the backrest and lift off the seat can remove the under seat basket or leave it 3 Pull the seat upwards and it will release in position 4 When assembling the seat make sure the 2 The under seat basket is retained with mag seat is located correctly then turn until it nets To remove grab the basket handle and locks pull out 3 To replace locate into the same position and push in until you feel the magnets locate 20 Golden Liteway GL 100 Owner s Manual Revised 11 06 Transporting Your Scooter GOLDEN LiTEWW Step 3 Retaining Strap Step 4 Remove the Battery The retaining strap stops the steering column To remove the battery black box located at the from moving around when transporting or assem rear of the scooter pull the handle upwards bling the scooter Wrap the Velcro strap around and this will release the lock automatically The the handlebars as shown battery will slide out Remove the battery com pletely Be careful this part will be heavy 21 Golden Liteway GL 100 Owner s Manual Revised 11 06 Transporting The Vehicle Step 5 Removing the transaxle or rear wheels To make the vehicle lighter for lifting it is possible to remove the transaxle or rear wheel assembly At the rear of the vehicle are two bars Locate the lower bar and pull it towards you This releases the lock With your other hand lift the frame out of the assembly circled 22 Golden Liteway GL 100 O
5. If you have to start on an incline lean forward and apply power slowly do not start and stop Always check the battery level is high If the level drops too low the vehicle will cutout leaving you stranded Lean back in the seat when going forward downhill and turn the speed control dial to low page 12 Do not drive across a slope at an angle always drive straight up and down the slope NEVER BACK DOWN A SLOPE Turning Slow down and look in the direction you are travelling if it s a blind corner sound the horn Bad Weather If its snowing or icy stay at home Remember that ice snow and slippery surfaces such as manhole covers wet grass and drains could affect braking and steering Use caution at all times 33 Golden Liteway GL 100 Owner s Manual Revised 11 06 Frequently Asked Questions How do I clean the vehicle Use a sponge and soapy water Rinse off with water Do not use a hose What happens if have a problem with the vehicle With any problem you will have to call your dealer Your dealer is there to help you but they can only do this if you give them as much information as possible Remember correct information will get the problem fixed quicker and save you money Call the dealer and explain exactly what the problem is Remember small points help the technician to identify the problem before he calls to fix it I want to transport my vehicle but the truck is too high for me to lift the vehicle There are va
6. back down an incline Try to keep your Liteway moving when climbing an incline If you do come to a stop restart and accelerate slowly and carefully Do not try to descend or climb a slope whose gradient is greater than recommended See Specifications section Max incline 69 A WARNING IF WHILE YOU ARE DRIVING DOWN A SLOPE YOUR SCOOTER STARTS TO MOVE FASTER THAN YOU FEEL IS SAFE RELEASE THE THUMB LEVER AND ALLOW YOUR LITEWAY TO COME TO A STOP WHEN YOU FEEL THAT YOU AGAIN HAVE CONTROL OF YOUR SCOOTER PUSH THE THUMB LEVER FORWARD AND CONTINUE SAFELY DOWN THE REMAINDER OF THE SLOPE DRIVING DOWN AN INCLINE Always drive forward down any ramp low rise or incline Golden Technologies Inc does not recommend that you drive your scooter in reverse down any incline ramp curb or low rise Backing down any slope may create an unsafe situation Golden Liteway GL 100 Owner s Manual Revised 11 06 Safety RULES FOR USE AND OTHER SAFETY CONSIDERATIONS MEDICATION Always check with your physician to determine if any of the medications you are taking may affect your judgment and or your ability to operate your Liteway Also check with your physician con cerning your physical ability to operate a scooter AN WARNING DO NOT CONNECT OR ALLOW ANYONE EXCEPT AN AUTHORIZED GOLDEN TECHNOLOGIES REPRESENTATIVE TO CONNECT ANY ELECTRICAL OR MECHANICAL DEVICE TO YOUR LITEWAY UNAUTHORIZED ACCESSORIES WILL VOID THE WARRANTY AN
7. inhibited from operation Disconnect battery charger LED Flashes 7 times pause 7 times pause Throttle fault Engager levers must be in neutral centered position before venicle is turned on Paddle fault and speed pot fault Switch vehicle off center levers and switch back on LED Flashes 8 times pause 8 times pause Controller fault Check all connections LED Flashes 9 times pause 9 times pause Bad parking brake connection Check parking brake and motor connections LED Flashes 10 times pause 10 times pause Excessive voltage detected at controller Check battery connections Flashing LEDs Controller has entered Sleep mode Cycle Key Off On to reset 32 Golden Liteway GL 100 Owner s Manual Revised 11 06 Driving The Vehicle Hazards Read this before driving the vehicle Failure to do this may cause damage to yourself a third party or the vehicle Getting on and off the vehicle Stop the vehicle on a flat area Turn off the ignition and remove the key Make sure you get off the vehicle in a safe area Curbs and Obstacles Do not ride up curbs or obstructions higher than 1 On any inclines make sure you lean forward This places more weight over the front making the vehicle more stable Hills and Slopes Lean forward when going up Make sure you have enough speed to make the slope Do not stop or turn the vehicle around If you have to turn while climbing an incline keep going until you reach a level area
8. short journey If you do not use your vehicle for a prolonged period place it on charge once a week over night Always use the correct charger with the correct batteries If the batteries have been flat for a long time about two months it is recommended you con tact your dealer before charging If one or both batteries are damaged they could heat up when charging or in an ex treme case explode Do not charge the vehicle outdoors it may rain and the battery charger is not waterproof Keep the vehicle in a well ventilated area and away from any open flame Do not force the plug into the charging point page 25 Push it lightly in and turn the plug until the pins line up then push in fully Do not partially charge the batteries Allow the charger to complete its cycle These items are expensive to replace look after them 27 Golden Liteway GL 100 Owner s Manual Revised 11 06 Simple Maintenance A qualified technician should perform all necessary maintenance Unfortunately they cannot be there at all times Items you should check on a daily weekly basis Daily Visually check the machine for damage Visually check the tires for damage The tires are maintenance free and do not require inflating Check the steering column moves freely Tiller clamp is tight Seat is located correctly and locked Check the armrests are tight page 1 Batteries should be fully charged Under seat basket is secure Important
9. your dealer Speed Control Dial This controls the top speed of your scooter It is located on the outer part of the battery indicator When the dial is turned to the left this is its slowest speed As the dial is turned to the right the speed will increase to a maximum which is the highest speed Set the speed before you move off Do not adjust when the vehicle is moving Horn Press the button and the horn will sound Release and the horn will stop Ignition Switch Always remember to remove key when not in use Do not leave the ignition on when not in use especially when charging the vehicle 14 Golden Liteway GL 100 Owner s Manual Revised 11 06 Freewheel Device SAFETY INFORMATION When the vehicle is switched off the brakes are automatically engaged This is called failsafe braking If the batteries are flat the same thing happens There may be occasions where you may wish to move the vehicle without power To do this there is a freewheel device fitted The freewheel device allows the vehicle to be pushed without power To activate first locate the lever It is located on the right hand side of the rear of the vehicle when standing behind it red lever Please see page 16 Make sure the ignition is switched off Move the lever forward The vehicle can now be pushed in freewheel mode Move the lever back to engage The brake is now engaged this is the normal operating position IF YOU ARE NOT COMPLETELY SURE OF T
10. 1 Bridge Street Old Forge PA 18518 Telephone 800 624 6374 If in doubt contact the dealer For Information regarding other Golden Technologies products contact your dealer or log on to the Golden Technologies Website www goldentech com 36 Golden Liteway GL 100 Owner s Manual Revised 11 06 Warranty Lifetime Warranty The lifetime warranty includes the structural frame components listed below Main metal frame Rear frame Fork Seat post Frame welds Two Year Warranty The following parts are covered by Golden Technologies two year warranty Battery charger Controller One Year Warranty Drive train This warranty excludes the following parts Batteries Tires ABS plastic shrouds Damage caused by abuse misuse accident or negligence improper operation main tenance or storage Commercial use or use other than the products original purpose Repairs and or modifications made to any part without consent from Golden Technolo gies Labor service calls shipping and other charges incurred in repair of the product unless specifically authorized by Golden Technologies This warranty does not in clude any labor charges incurred in replacement part installation Implied warranties including those of merchantability and fitness for a particular purpose are ex cluded Liabilities for consequential damage are excluded This warranty gives you specific rights and you may also have other rights
11. D MAY CAUSE INJURY Note Please remember that while on your Golden Liteway you are a motorized pedestrian You must observe and obey all pedestrian rules and regulations for the locale in which you are riding Please use your Golden Liteway scooter often and allow it to expand the horizons of your daily life But as with all things especially motor operated vehicles observing a few rules and safety consider ations will help ensure safe scooter operation So please follow the rules below Do not turn your scooter while on an incline or decline Always keep all of your body parts within the confines of the scooter Do not hose down your scooter Always remain properly seated when operating your scooter Do not place your scooter in freewheel mode when on an incline or decline Never sit on your scooter when it is in freewheel mode Always reduce the speed of your scooter when making turns Do not operate or store your scooter where it will be exposed to rain snow mist and below freezing temperatupres Do not operate your scooter on slippery icy or salted surfaces Never charge a frozen battery Do not modify your scooter in any way that is not authorized by Golden Technologies Golden Liteway GL 100 Owner s Manual Revised 11 06 Safety RULES FOR USE AND OTHER SAFETY CONSIDERATIONS Read completely and understand this owner s manual before assembling operating transporting or disassembling your Go
12. HIS FEATURE CONTACT YOUR DEALER BEFORE OPERATING THE SCOOTER 15 Golden Liteway GL 100 Owner s Manual Revised 11 06 Freewheel Device Brakes SAFETY INFORMATION Pull the lever back to the upright position The brake is in the ON position This is the normal operating position and the vehicle will only operate with the brake on Push the lever forward to enable the vehicle to be moved without power NEVER sit on the vehicle with the lever in this position Brakes There are two braking systems The first works with the accelerator When the accelerator is released the scooter will automatically brake and bring the scooter to a stop When the scooter stops the automatic handbrake will engage This will stop the vehicle from rolling forward or backward When you start the scooter the handbrake will automatically disengage If the bat tery should lose power the brakes automatically engage 16 Golden Liteway GL 100 Owner s Manual Seat Adjustment 2d Lift armrests for access Revised 11 06 Armrest Adjustment When getting seated on the scooter lift the arm rest up When riding always have the armrest in the down position If you require more room in the width of the seat undo the black knobs as shown olide the armrests in or out to suit Tighten both knobs to clamp One on each armrest Check the knobs for tightness twice a week 17 Golden Liteway GL 100 Owner s Manual Revised 11 06
13. LiTEWAY Owner s Manual em Kise Koll Rest Rah da GOLDEN 401 Bridge Street Old Forge PA 18518 Phone 800 624 6374 Fax 800 628 5165 www goldentech com Golden Liteway GL 100 Owner s Manual Revised 11 06 Owner s Manual and Service Record Keep this manual in a safe place This document contains the information required to familiarize yourself with the vehicle Complete all the information within this document If any information is not clear contact your Dealer immediately This document must remain with the vehicle throughout its use NOTICE All Golden Technologies mobility products are sold through authorized dealers Make sure your dealer demonstrates all the features of the product prior to or when it is delivered Golden Liteway GL 100 Owner s Manual Contents IATROGUIGTION c V PO 4 5 dle pte radbdatutatut i eae adsit aua d ANN 6 9 MENAT USO SF 10 zum 11 Controls DashDOGS G aide qun i usas sab uta omo Mao ANG RD 12 Controls DFIVING CONOIS s ccce te rtr eh ca S YF 13 Controls Dashboard description essesussses 14 Freewheel d6VIOB eln deniad dia csse 15 Freewheel device brakes cccccccscceeeceeeeceeeceeeceeceeesaueeseeeeaees 16 SCL AGUS US ME sarsaran ei ee He I RR HT FAN 17 ISeVOIVITIO SCAN asgen Ye R 18 Taller adis IIO EEF YY IR detached iu ades os
14. Manual Revised 11 06 Intended Use Intended use of the vehicle This vehicle is designed to help any person that is capable of driving a motorized scooter up to the maximum recommended weight who requires a lightweight scooter that can be transported in the trunk of a car To achieve compact dimensions requires small wheels and these are not suitable for climbing large curbs or obstacles see manual for further information 10 Golden Liteway GL 100 Owner s Manual Revised 11 06 Safety Information Information Regarding Electromagnetic Interference EMI This section contains information on the possible effects of electromagnetic interference to your vehicle EMI refers to the effects electromagnetic energy might have on the control systems of your vehicle The interference could cause the brakes to release the vehicle to move by itself or damage the electronics There are generally three types or sources of electromagnetic energy 1 Hand held short range portable transceivers Examples include CB radios walkie talkies security fire and police transceivers cellular phones and other devices that transmit a signal even when not in use 2 Medium range mobile transceivers Examples include police fire ambulance and taxi transceivers 3 Long range transmitters and receivers Examples include radio and television towers and amateur HAM radios There is an immunity level that has to be met by law and your
15. Swivel Seat Optional swivel seat This option allows easy access on and off the vehicle 1 To operate locate the release lever under the seat 2 Push the lever forward as shown and the seat will release allowing it to rotate 3 Release the lever and the seat will lock auto matically N Warning 1 Do not use this device if the vehicle is on a slope 2 Always check that the seat is locked in the forward position before driving the vehicle 18 Golden Liteway GL 100 Owner s Manual Tiller Adjustment Revised 11 06 The tiller adjustment sometimes known as the handlebar adjustment allows you to alter the angle of the tiller to suit your driving style or to fold the tiller down for transporting Locate the black knob at the base of the steering column With one hand hold the tiller while unscrewing the clamp Release knob The tiller is now free to move Move the tiller to the desired position and tighten the clamp As you tighten the clamp gently rock the tiller back and forth This allows the teeth on the clamp to engage correctly Check the clamp daily to ensure it is tight 19 Golden Liteway GL 100 Owner s Manual Revised 11 06 Transporting Your Scooter To transport your scooter you may need to dismantle it Follow these step by step instructions Step 1 Preparation Step 2 Tiller 1 Turn off the ignition and remove key 1 Fold the tiller as shown on page 19 You
16. fe and easy mounting See Operation section Carefully place one foot on the approximate center of the deck and seat yourself comfortably and securely on the seat Fasten the lap belt if your scooter is so equipped Flip down the armrests GETTING OFF YOUR LITEWAY Make certain that the power is turned off and key is removed Flip up the armrest Unfasten the lap belt if your scooter is so eguipped Carefully place one foot on the ground transfer your weight to that leg and slowly come to a standing position Step away from the scooter MAXIMUM WEIGHT Your Liteway has been rated to a maximum payload includes operator and any other carry on baggage of 300 pounds Exceeding the maximum weight rating will void the warranty N WARNING EXCEEDING THE MAXIMUM WEIGHT RATING MAY ALSO RESULT IN INJURY TO YOURSELF AND TO OTHERS Golden Liteway GL 100 Owner s Manual Revised 11 06 Safety DRIVING ON AN INCLINE For maximum stability lean forward in your Liteway seat while proceeding up ramps slopes curbs or any low rise Drive with caution when attempting to negotiate any incline even handicap access ramps Always climb or descend a gradient by driving straight up or straight down the face of the slope Do not traverse or drive across the face of a gradient Do not attempt to negotiate an incline that is covered with snow ice cut or wet grass leaves or any other slippery material Do not
17. hnical Information Regarding Electromagnetic Interference EMI The intensity of interference from electromagnetic energy is measured in volts per meter v m which refers to the strength of the electrical source voltage as it relates to the distance away from the object being considered in meters Resistance of a scooter wheelchair to certain EMI intensity is commonly called its immunity level 20 volts meter is a generally achievable and useful immu nity level against interference from radio wave sources the higher the immunity level the greater protection Your scooter has been tested and found to meet the required immunity level from Electromagnetic Interference 20v m the intensity of interference from electromagnetic energy WARNING Even with the immunity level of 20 volts meter certain precautions must be followed to ensure your scooter wheelchair will not be affected by outside electromagnetic sources oee page 11 of this manual for additional information 40 Golden Liteway GL 100 Owner s Manual Revised 11 06 Technical Specification Odo aa GL 100 LONOU ee EY 41 YA Ae in DH E 22 Jide CH YR Foam filled non pneumatic uie MU ca ETHER BS Ii FYR A YNYR Y YR 9 NM VETOMIE GS AD ACI EE O O RI TH aus ume FER HF 300 Ibs MEERE tats RYNG NY FAAN FN YN Y gach tn ERCH ER NY NT FFY HAN ET FRAU FA EF HRN 4 mph Ground Glearsliee exc
18. idio a dubium OMIM MM RF RH HD 3 WODR ANS MR mem 32 Gau IU Raa ene ee eT ne Rese ITE 21 Ibs BaAUc mie dA ON DEN CEN 19 Ibs menm i o M T RED T Te 39 Ibs Poar AT VN GI ERREUR 25 lbs Total weight including batteries cccccccecceeccececeeceeeseeeceeeceecaeecseeceesaeecseeceesaeesaeeeensaees 104 Ibs Wisi cB 8 6 MEET ETE Yes wicieigeniexvie obdleniese c ON Yes DAKOS RT NT Em Electro mechanical Guo t I M Off board Rear wheel Drive seesesseseeem GG LLE mmm Sealed transaxle motor 24V DC i sn ue RENT T 45 amp programmable MV UL HM s gt n gies IY O O YO era TW TRIN FN NW FI FN Y CW RR NN FN Limited lifetime Wa Uy HClO elgo dcm 2 years Waan CIN UME the tnd atresia ae 1 year 41 Golden Liteway GL 100 Owner s Manual Revised 11 06 scooter Warranty Card Please mail this document to Golden Technologies Inc Warranty Registration Office 401 Bridge Street Old Forge PA 18518 Please fill in your Liteway information below This information will be useful in the event that you ever need to contact Golden Technologies concerning your scooter Model serial Number Date of Purchase Body Color Options Your Golden representative or dealer Name Company Address Please indicate your understanding of your Golden Liteway by completing the following information have read and fully understand My Golden Liteway owner
19. lden Liteway Always operate your Golden Liteway with thought care and safety Do not attempt to use your Liteway on an escalator Always use in an elevator Do not carry passengers under any circumstances Do not mount or dismount your Golden Liteway unless the brake is engaged Make certain that the key is removed before mounting or dismounting your scooter Do not back your Golden Liteway down an incline or across an uneven surface Make certain that the seat is locked in the forward position before operating your Liteway Always come to a full stop before changing direction from forward to reverse or from reverse to forward Do not operate your Liteway where you could not safely or legally walk Do not climb ramps or curbs that exceed your scooter s capacity Always approach curbs and inclines straight on Be aware of and careful near mechanical pinch points for example when mating rear car riage to the front frame especially when assembling and disassembling your scooter See As sembly Disassembly section Never sit on your Liteway when it is being transported Do not operate your vehicle if it is not functioning properly Use caution when driving on soft or uneven surfaces such as grass and gravel Also use caution on decks where there is no railing Never drive on the roadway except when you must cross the street Never back up or down a step or curb Never operate your Liteway while you are under the influence of alcoh
20. ol NWARNING TURNING TOO SHARPLY AROUND A CORNER CAN CAUSE THE SCOOTER TO TIP AVOID THIS DANGER AT ALL TIMES BY STEERING A WIDE ARC AROUND CORNERS AND OBSTACLES ALSO TO AVOID THE RISK OF TIPPING REDUCE SPEED BEFORE NEGOTIATING ANY TURNS For emergency stopping turn off scooter key scooter will stop Golden Liteway GL 100 Owner s Manual Revised 11 06 Safety Information Read this manual thoroughly before driving or operating the vehicle Every mobility scooter operates differently Do not assume they are the same If you have any doubt about the content of this manual contact your dealer immediately Read the instructions contained within this document maintain the vehicle and ensure it is serviced regularly Within this manual there are important safety notices They are clearly marked on the appropriate pages Make sure that you understand these notices If you have any doubt contact your dealer 2006 Golden Technologies Inc No liability is assumed with respect to the use of any information contained in this publication While every precaution has been taken in the preparation of this publication Golden Technologies assumes no responsibility for errors of omissions nor is any liability assumed for damages resulting from the use of information contained in this publication This publication as well as the operational details described herein is subject to change without notice Golden Liteway GL 100 Owner s
21. protective cover is set in the green closed position This keeps water out 25 Golden Liteway GL 100 Owner s Manual Revised 11 06 Battery Charging Correct battery charging prolongs the life of your batteries Connection Instructions When you receive your vehicle the batteries are only partially charged fully charge before use preferably over night Place your machine in an area that is dry and well ventilated Make sure a 110 120 volt outlet is nearby Check that the vehicle is switched off and the key removed Check that the main switch is off Never connect or disconnect the charger with the main switch on Connect the charger to the battery page 25 Connect the plug and switch on the charger The power illuminates red when switched on The charger light changes to green when charged Turn off the main switch and remove the plug from the battery when fully charged Do not leave the charger plugged in with the power off This will discharge your battery You can charge your battery on or off the vehicle To remove the battery see page 21 26 Golden Liteway GL 100 Owner s Manual Revised 11 06 Charging Batteries The batteries are the lifeblood of your vehicle Their characteristics can change depending on charging temperature usage and other factors Listed below are guidelines to prolong their life Charging Your Batteries After using your vehicle always charge it at the end of the day even after a
22. reet Old Forge PA 18518 Phone 570 451 7477 Fax 570 451 7494 otop by our website 24 hours a day www goldentech com Golden Liteway GL 100 Owner s Manual Revised 11 06 INTRODUCTION Your Golden Liteway is a battery operated personal mobility vehicle Please exercise caution and consideration when you are operating it Driving your Liteway carefully and thoughtfully will help en sure your personal safety and the safety of other people Note Before learning to operate your Liteway have your Golden Technologies representative deter mine if it is advisable for you to practice getting on and off your Liteway and operating it in the pres ence of an attendant BEFORE GETTING ON YOUR LITEWAY READ COMPLETELY AND UNDERSTAND THIS OWNER S MANUAL BEFORE ASSEMBLING OP ERATING TRANSPORTING OR DISASSEMBLING YOUR GOLDEN LITEWAY Check to be certain that the Key is removed See Operation section in this manual This will eliminate the possibility of accidentally activating the thumb lever controls and causing injury to you or to others Check to be certain that your Liteway brake handle is in the engaged position See the Disas sembly section in this manual Flip up the armrests N WARNING WHEN GETTING ON OR OFF YOUR LITEWAY DO NOT PUT MOST OR ALL OF YOUR WEIGHT ON THE EDGE OF THE DECK DOING SO MAY CAUSE THE SCOOTER TO TIP GETTING ON YOUR LITEWAY Make certain that the key is removed Position the seat for sa
23. rging up correctly is the full charge light coming on after charing Is the steering tight or is it loose when turning Is there any play in the steering Has anything come loose Does the vehicle perform as well as it did when it was new Are there noises or rattles that were not there before 38 Golden Liteway GL 100 Owner s Manual Revised 11 06 Technician s Checklist CHECKLIST Initial diagnostic road test Wheel bearings wear and lubricate Wheel alignment Speed dial works correctly Wear or damage to tires or wheels Bodywork fixtures Throttle play and adjustment Battery box contacts and release mechanism Steering bearing adjust as required Seat mounting Revolving seat mechanism locates correctly Transaxle mountings are tight Handlebar alignment Motor brush wear Motor speed check Transaxle play Electromagnetic brake operation Freewheel operation Frame for damage or cracks Important Note for the Technician General corrosion Ask if the customer is satisfied with the product All operational controls work correctly Please report all comments directly to Battery condition and charger operation Tighten all nuts and bolts Golden Technologies Technical Services Final road test Telephone 800 624 6374 Clean vehicle Customer road test If you have any comments please include them 39 Golden Liteway GL 100 Owner s Manual Revised 11 06 Technical Information Regarding EMI Important Tec
24. rious techniques to loading the vehicle into a car It depends on what type of vehicle you own Make sure your dealer has demonstrated the easiest way of doing this Can I fit weatherproofing such as a canopy Yes but remember if you alter the vehicle in any way it will void your warranty Be aware that enclosed canopies can affect the handling of the vehicle in strong winds 34 Golden Liteway GL 100 Owner s Manual Revised 11 06 Additional Information How long will my batteries last and what range can I expect Battery life and range depend on many things but a rough guide to batteries are e Keep them charged do not let the batteries run completely flat If they are flat charge them up e The life of a battery depends upon the number of cycles the battery goes through f you carry out these simple instructions your batteries will have a longer life Range can be affected by many things such as e Temperature e Faulty or worn batteries e Faulty charger e Type of terrain e Weight of the person Important rule Always use the correct charger with the correct batteries How long should I keep my vehicle before I change it Keep it as long as it suits your needs Remember vehicles of any type become more expensive to maintain the older they get 35 Golden Liteway GL 100 Owner s Manual Revised 11 06 Additional Information If you lose your Owner s Manual replacement copies are available from Golden Technologies 40
25. rld We at Golden Technologies know that you have chosen a scooter that will give you years of dependable operation and will also enhance the quality of your life by providing you with the mobility to experience a more active daily lifestyle Please read understand and follow all of the instructions and suggestions in this manual before you operate your Liteway for the first time The safe use of your new scooter is very important and starts with you Your new Liteway is user friendly and designed for maximum maneuverability in even the tightest spaces If you feel uncomfortable with your new Liteway or do not understand the instructions presented in this owner s manual or if for any reason you do not feel capable of performing the activities neces sary to assemble disassemble operate or maintain your Liteway please contact the home health care dealer you purchased this scooter from or contact Golden Technologies Technical Support Ser vices at 800 624 6374 Golden Technologies Inc cannot be held responsible for personal injury or property damage resulting from the unsafe or the improper use of any of our broad range of health and personal mobility prod ucts Please fill out and mail the enclosed warranty registration card We at Golden Technologies would appreciate hearing about your experience with your new Liteway scooter Please mail your warranty card to Golden Technologies Inc Warranty Registration Office 401 Bridge St
26. s Manual Revised 11 06 Additional Safety Information Carrying Weight on the Vehicle Child Safety Handlebars Do not carry or attach anything to the This product is designed to be operated by handlebars Anything attached to the handlebars will adults Children should not be allowed to affect the control of the vehicle tamper with the controls or play on the vehicle Floor Area Use the under seat basket for storage Do not carry children as passengers only Do not use the floor area The product is designed for single person use only Other Items Only fit approved products or accessories Keep all packaging well away from children 30 Golden Liteway GL 100 Owner s Manual Revised 11 06 Driving The Vehicle Read this before driving the vehicle Whether or not this is your first mobility vehicle read these guidelines as all vehicles differ oe I 11 12 Failure to do this may cause damage to yourself a third party or the vehicle Check the weather forecast Make sure you are wearing suitable clothing whether your jour ney is long or short lf you are taking medication check with your doctor or physician that your ability to control the vehicle will not be impaired Do not drink alcohol and drive it s the law Only use the vehicle for the purpose it s intended for Do not drive though deep water trans port more than one person tow other vehicles or carry excess weight Do not modify the ve
27. scooter has been tested to the required level For a full technical explanation see page 39 in this document N WARNING Even though your vehicle meets the requirements it is recommended that you follow certain precautions 1 Do not operate hand held transceivers such as CB radios or mobile phones while the vehicle is switched on 2 Be aware of transmitter towers such as television and radio stations Avoid getting close to them If your vehicle starts to operate by itself switch it off and call your dealer Report all faults of this type to Golden Technologies Golden Liteway GL 100 Owner s Manual Revised 11 06 Liteway Operation Before driving your vehicle it is important to familiarize yourself with the controls Do not attempt to drive the vehicle before reading the rest of this manual Battery Level Speed Control Dial Red indicator light See battery indicator page 14 PULL FOn FORWARD REVERSE AND CS E L o T b T Ignition key 12 Golden Liteway GL 100 Owner s Manual Revised 11 06 Controls Driving Controls Accelerator SAFETY NOTICE pm Finger control lever YR y PN d n a Photo shows thumb actuators fitted Finger Thumb control The Liteway is equipped with the unique feature of finger thumb control This allows you to operate the accelerator using either your thumb or finger whichever is more comfortable To operate turn on the igni
28. tion Finger Control pull in the right hand lever and the machine moves forward The more you pull the lever the faster the scooter goes To brake release the lever Again the faster the lever is released the quicker you will stop To reverse pull in the left lever Do not pull both levers at once CAUTION Thumb Control optional forward reverse controls are reversed Right hand side is reverse and left hand side is forward 13 Golden Liteway GL 100 Owner s Manual Revised 11 06 Dashboard Controls Description Description of Dashboard Controls Battery Indicator This instrument shows the level of charge in the batteries When in the green area the batteries are fully charged When in the yellow area the batteries need recharging and when in the red area the batteries urgently need recharging Note When the vehicle is climbing a steep incline or starting off the level may drop momentarily this is normal Red indicator lamp When the ignition is switched on a red light appears in the left hand corner of the battery indicator When the light is constant the vehicle is ready to go If the light flashes there is a problem The lamp will flash if the accelerator lever is pulled in at the same time you in switch on the ignition or the vehicle is in freewheel See pages 15 amp 16 Check to see if the freewheel is engaged turn off the ignition and switch it on again The lamp should show a stable light If it stills flashes con tact
29. uere Dau ids 19 Transporting the vehicle ccccscccecceeeceseceeeceeseeeseeeseeenaes 20 23 Assembly of the transaxle eeeeeeeeeeeeeeeeeennee 24 Bauern ChargiN O eT 25 27 oimbple Tnalltenaliee s sectas cotta I tv E NN ES t 20 Troubleshoolingrdgulde u ee aged aoa p permanent oth e tapas 29 Additional safety information ccccccccccseceeeeeeeeeseeeeeeeseeeeseeeas 30 DAVNOG vehicle stan T e 31 DIAGNOSUCS SVSIQITIG s creat yedeasienecciaiemnccnstuanetae santa rosa o 32 Driving the vehicle NAZAMAS ccccccecceeeseeeeeeeeeeseeeaeeeaeeseeeaes 33 Frequently asked questions ccccecceeceseceeceeeeeeceeteeseeeeeeeaees 34 Additonal InforttiatlQli ae ee utet e nares dica nequ passe a teen 35 36 Guarantee and Warranty cccccccceccceeeceeeceeceseceeeeeeeseeesaeeseas 37 visse 38 Technician S CrebKlISE assai nta oxi aS 39 Technical information regarding EMI ssssee 40 Technical SDeclllCallOli ases se sque pasada tent endi eiu pac Eu ver FY 41 Warranty Card dealer information sssss 42 Revised 11 06 Golden Liteway GL 100 Owner s Manual Revised 11 06 INTRODUCTION Congratulations on the purchase of your new Golden Liteway scooter The Liteway combines cut ting edge technology with attractive designs that are also highly functional in today s wo
30. which vary from state to state To obtain warranty parts and service you must have a warranty registration card filed with Golden Technologies Contact your Golden Technologies authorized dealer for service The warranty period commences on the purchase date from the seller dealer If the product is rented or otherwise not sold to the consumer the warranty commences on the invoice date from Golden Technologies Warranty from original vendor may apply 37 Golden Liteway GL 100 Owner s Manual Revised 11 06 Servicing This section covers maintenance 1 This vehicle is designed for minimum maintenance However it is recommended that a competent technician service the vehicle once a year If the vehicle is used constantly we recommend a twice yearly maintenance 2 Make sure the technician stamps this manual on completion for all servicing carried out on this vehicle Keep all receipts for servicing and repairs with this handbook This may add value when selling the vehicle 3 When the vehicle is due for its annual service make sure you report any concerns you have preferably when you book the service see points to look out for below 4 On completion of the service always test the vehicle before the technician leaves and make sure you are Satisfied with the work carried out Points to look out for Are there any strange noises from the wheels or does the frame creak when going over rough ground Are the batteries cha
31. wner s Manual Revised 11 06 Transporting The Vehicle The transaxle is now separated from the frame The vehicle is shown fully dismantled for transportation When lifting the unit use the bar to lift ar rowed Be careful this part is heavy Make sure the contacts are not damaged circled 23 Golden Liteway GL 100 Owner s Manual Revised 11 06 Assembly of the Transaxle or Rear Wheel Assembly Lift the frame over the forks Line up the pins When assembling the vehicle after transporting and lower the frame When both sets are locat first assemble the transaxle or rear wheel as ed push the frame down You will hear a click sembly Place the assembly as shown next to as the assembly locks If the transaxle is not the frame The fork has to locate into the pins located correctly the vehicle will not operate as shown The pins are marked in red Assemble the remaining sections in reverse SAFETY NOTICE order of dismantling 24 Golden Liteway GL 100 Owner s Manual Revised 11 06 Battery Charging T h yr 5 mc W m L The charging socket is located in the rear The battery charger has a small LED light as of the battery box Slide away the protec shown When the charger is connected and tive cover and push in the round silver plug switched on it will show a red lamp When the When the vehicle is charged remove the battery is charged the LED light will change to plug check the
Download Pdf Manuals
Related Search