Fisher-Price M5130 Motorized Toy Car User Manual
Contents
1. Plug the charger into a standard wall outlet Remove the rear bumper cover Notes Use the charger only in a wall outlet Do not plug the charger into a ceiling outlet If the power flow to the wall outlet is controlled by a switch make sure the swtich is ON The power indicator on the charger does not indicate the charge status of your battery The power indicator allows you to see that there is power from the wall outlet to the charger Before first time use charge the battery for at least 18 hours Never charge the battery longer than 30 hours Recharge the battery after each use of your vehicle for at least 14 hours Do not charge the battery longer than 30 hours Once the battery is charged disconnect the charger connector from the battery connector Unplug the charger from the wall outlet The battery is now ready to be installed in your vehicle Please see Battery Installation on page 15 for detailed instructions on installing your battery If your battery 6 Volt Battery is already installed in your vehicle simply re connect the battery connector and motor harness connector and replace the Lift to remove the battery from the battery compartment bumper cover battery retainer Charger Connector Battery Connector Plug the battery connector into the charger connector M5130pr 0920 ASSEMBLY AN WARN NG Arrow Points to Front End Children can be harmed by small parts2. To Sto pO FCC STATEMENT M e Your vehicle has a patented electronic braking system that automatically stops the vehicle when your child releases the United States Only go button f f Make sure your child is comfortable with steering the vehicle This equipment has been tested and found to comply with the and automatically knows how to stop limits for a Class B digital device pursuant to part 15 of the FCC rules These limits are designed to provide reasonable protection against harmful interference in a residential installation This equipment generates uses and can radiate radio frequency energy and if not installed and used in accordance with the instructions may cause harmful interference to radio communications However there is no guarantee that interference will not occur in a particular installation If this equipment does cause harmful interference to radio or television reception which can be determined by turning the equipment off and on the user is encouraged to try to correct the interference by one or more of the following measures Reorient or relocate the receiving antenna Increase the separation between the equipment and receiver Consult the dealer or an experienced radio TV technician for help NOTE Changes or modifications not expressly approved by the manufacturer responsible for compliance could void the user s authority to operate the equipment 5130 0920 LIMITED WARRANTY NI Bum
3. sharp edges and sharp points in the vehicle s Steering unassembled state or by electrical items Care should be taken in unpacking and assembly of the vehicle Children should not handle parts including the battery or help in assembly of the vehicle Steering Column Front End of Vehicle V 7 Straight End of Steering Column Za Sa Remove the tape that is attached to the steering wheel and the Hooked End of vehicle frame Steering Column e Position the steering wheel so that the arrow points to the front end of the vehicle e Fit the steering wheel onto the end of the steering column Steering Linkage Lift the front end of the vehicle Fit the straight end of the steering column through the upper hole in the steering linkage and out through the hole in the vehicle body Fit the hooked end of the steering column through the lower hole in the steering linkage Lower the front end of the vehicle cap nut with a hammer to secure it to the steering column Hint You may need the help of another adult to support the other end of the steering column Pull on the cap nut to be sure it is secure 5130 0920 F ASSEMBLY Steering Wheel Cover e Fit and snap the steering wheel cover into the center of the steering wheel Action Sounds Cover Position the actions sounds cover so that the two tabs are down Fit the key knob into the righ
4. East Aurora New York 14052 U S A 2007 Mattel Inc All Rights Reserved PRINTED IN MEXICO M5130pr 0920
5. battery is equipped with a built in thermal fuse The thermal fuse is a self resetting safety device which automatically trips and shuts down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your finger from the button and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shut downs do not overload the vehicle by exceeding the 40 Ibs 18 kg maximum weight capacity or by towing anything behind the vehicle Avoid severe driving conditions such as driving up slopes or running into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse in a battery continually trips under normal driving conditions please contact your local Power Wheels Authorized Service Center For the location of the Authorized Service Center nearest to you visit us on line at www powerwheels com or call 1 800 348 0751 Important Notes Your new battery must be charged for at least 18 hours before you use it in your vehicle for the first time We recommend that you start charging your battery before beginning assembly of your new vehicle The battery must be upright while charging The charger is not a toy Do not short circuit the battery You do not need to remove the battery from your vehicle to recharge it Before charging the battery examine
6. please visit us on line at www powerwheels com or call 1 800 348 0751 Contact your local waste management officials for other information regarding the environmentally sound collection recycling and disposal of lead acid batteries If you live in the State of Florida or the State of Minnesota it is prohibited by law for anyone to throw away lead acid batteries in the municipal waste stream RIDING HAZARD WARNING Prevent Injuries and Deaths Direct Adult Supervision Required Never Ride at Night Keep Children Within Safe Riding Areas These areas must be Away from swimming pools and other bodies of water to prevent drownings Generally level to prevent tipovers Away from steps cars steep inclines roads and alleys Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 1 one rider at a time SAFE DRIVING RULES J Teach Safety Rules to Children While children can quickly develop the skill necessary to drive this vehicle it is important to remember that their judgment skills are still very immature Unsupervised driving by children can lead to serious injury Before children use this vehicle an adult should carefully evaluate the driving area as well as the children s skill level and ability to drive this vehicle safely Children are not always able to recognize or anticipate hazards even when the
7. insert a slotted screwariver into the slot at the top of the action sounds box Pull to remove the action sounds box Flatten the T end of one of the seat belts Insert the end of the seat belt through one of the slots in the seat Pull up on the seat belt to be sure it is secure Repeat this procedure to assemble the other seat belt to the seat M5130pr 0920 11 ASSEMBLY Motor Harness e Fit the motor harness into the groove in the vehicle floorboard as shown Turn the vehicle over so that the bottom is facing up Insert two 8 x 3 4 screws through the slots in the vehicle bottom and into the seat Tighten the screws e Place the seat onto the vehicle floorboard as shown e Insert two 8 3 4 screws through the seat and into the floor board Tighten the screws 72 M5130pr 0920 DECORATION G Proper label application will help to keep the labels looking their best When applying labels keep the following guidelines in mind Wash your hands before applying the labels Before applying the labels wipe the surface of the vehicle with a clean dry cloth to remove any dust or oils Place the labels exactly as shown in the illustrations For best results avoid repositioning a label once it has been applied to the vehicle After applying a label rub the label firmly with a clean dry cloth to make sure the label is adhered to your v
8. be done by adults only A child could be injured by the electricity involved in charging the battery Never lift or carry the battery by the wires or connector This can damage the battery and possibly cause a fire resulting in serious injury Lift and carry the battery by the case only Read the safety instructions on the battery Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part HOT motors Handle carefully RIDING HAZARD WARNING Prevent Injuries and Deaths Direct Adult Supervision Required Never Ride at Night Keep Children Within Safe Riding Areas These areas must be Away from swimming pools and other bodies of water to prevent drownings Generally level to prevent tipovers Away from steps cars steep inclines roads and alleys Riding Rules Make sure children know and follow these rules for safe driving and riding Always sit on the seat Always wear shoes Only 1 one rider at a time CAUTION In the unassembled state this package contains small parts Adult assembly is required Use the charger in dry locations only M5130pr 0920 3 c PARTS f you experience a problem with this product or are missing a part please call us at 1 800 348 0751 rather than return this produ
9. the battery case for cracks and other damage which may cause sulfuric acid electrolyte to leak during the charging process If damage is detected do not charge the battery or use it in your vehicle Battery acid is very corrosive and can cause severe damage to surfaces it contacts Do not charge the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you charge your battery Use only a Power Wheels 6 volt 4 0 Amp Hr charger input 120 VAC with an output of 6 VDC 2 4W 400 mA to charge your Power Wheels 6 volt 4 0 Amp Hr battery Adults Note Regularly examine the charger for damage to the cord plug housing or other parts that may result in the risk of fire electric shock or injury In the event of any damage do not use the charger until the damage has been properly repaired Please call 1 800 348 0751 f your battery is old and will not accept a charge do not leave it in the vehicle Always remove a dead battery from the vehicle M5130pr 0920 7 BATTERY CHARGING IMPORTANT The battery must be removed from your vehicle for the initial charge in order to complete assembly After assembly is complete you do not need to remove the battery from your vehicle to recharge it POWER byFisher Price Bumper Cover Battery Retainer Loosen the screw in the rear bumper cover battery retainer
10. AC KY llt POWER WHEELS Please read this manual and save it with your original sales receipt Tool needed for assembly Phillips Screwdriver not included Use only with a Power Wheels 6 Volt 4 0 Amp Hr Rechargeahle Battery Built in Thermal Fuse and a Power WheelsG 6 Volt 4 0 Charger both included Action sounds box requires three alkaline AAA LR03 batteries for sound operation batteries not included Product features mayvary from the picture above _ oe 2007Viacom International Inc All Rights Reserved Nickelodeon Nick The Backyardigans and all related titles logos and characters are trademarks of Viacom International Inc OaS ante with AssemblyjInstructions MN M5130 TABLE OF CONTENTS I 0 T mu 0 n I Be Vehicle UT OS MI ECC Statement nn nn n Problems and Solutions Guide e C T ETT T TT D Warnings and e a saree reine 19 ISTE NS Decoration TN TT E BattenyalstallatlOT a TTE TT TT IMPORTANT INFORMATION Your new vehicle requires adult assembly Please set aside at least 30 minutes for asse
11. D N WARNING e Battery can fall out and injure a child if vehicle tips over Always use battery retainer e PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury Never allow children to charge the battery Battery charging must be done by adults only A child could be injured by the elec tricity involved in charging the battery Never lift or carry the battery by the wires or connector This can damage the battery and possibly cause a fire resulting in serious injury Lift and carry the battery by the case only Read the safety instructions on the battery Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage or excessive wear is detected do not use the charger or the battery until you have replaced the worn or damaged part BATTERY CHARGING E A CAUTION Use the charger in dry locations only About Thermal Fuses Your Power Wheels 6 volt 4 0 Amp Hr
12. SE SOLUTION Vehicle runs sluggishly Undercharged battery Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the battery connector is tightly plugged into the charger connector and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Battery needs charging Be sure to charge the battery after each use Battery is old and will not Even with proper care a rechargeable battery does not accept full charge last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace only with a Power Wheels 6 Volt 4 0 Amp Hr battery and built in thermal fuse Do not substitute parts Vehicle is overloaded Make sure you do not overload the vehicle by allowing more than one rider at one time exceeding the 40 Ib maximum weight capacity or by towing objects behind the vehicle If the vehicle is overloaded the built in thermal fuse in the battery may trip and automatically shut down operation for approximately 25 seconds Adjust the driving conditions to prevent repeated automatic shutdowns Driving conditions are too stressful Use only on generally level ground Sometimes the vehicle doesn t Loose wire or connector Check all wires around
13. ct to the store Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded Metal parts have been coated with a lubricant to protect them during shipment Wipe all metal parts with a paper towel to remove any excess lubricant Vehicle Frame with Steering Wheel Assembly Steering Wheel Steering Column Taped to the Vehicle Frame Action Sounds Action Sounds Box 2 Seat Belts Box Cover M5130pr 0920 Sounds Key e p Action Sounds Knobs 2 2 Steering Wheel Cap 6 Volt Charger 354 Cap Nut 1 WAWW 8 3 4 Screw 6 Ont 6 Volt 4 0 Amp Hr Battery 6 x 3 3 Screw 2 Located in storage area in rear bumper Note Tighten and loosen all screws with a Phillips screwdriver Do not over tighten the screws For your convenience we have included extra fasteners Part Not Shown Label Sheet 2 All Fasteners Shown Actual Size 5130 0920 D PARTS PICTURE f h 2 4 NON 7 s D x 2777 C S pad f 2 Rear Bumper Cover 2 r Sounds Knob 354 Cap Nut 6 Volt 4 0 Amp Hr Charger E IE Key Knob 6 x 3 8 Screw 2 6 Volt 4 0 Amp Hr Battery Action Sounds Box 8 x 3 4 Screw 6 Vehicle Frame ER B Flag Steering Wheel Cap Seat Part Not Shown Steering Wheel LE E Seat Belt 2 Label Sheet 2 Action Sounds Box Cover EE Steering Column S M5130pr 0920 ELECTRICAL HAZAR
14. d be stored if the vehicle is used indoors inside or under a protective cover Remember to charge the battery at least once per month while your vehicle is not in regular use Drive Forward e Avoid operating the vehicle in wet or snowy conditions and do not spray the vehicle with a hose Do not wash the vehicle with soap and water Water or moisture in the motors or electrical switches can cause them to corrode and could cause switch or motor failure e Avoid operating the vehicle on sand loose dirt or gravel Sand loose dirt or gravel in the motors or electrical switches can a cause them to jam and could cause switch or motor failure The vehicle can be wiped down with a soft dry cloth For a V 5 shiny finish you can wipe plastic parts with non wax furniture polish applied to a soft cloth Do not use automotive wax Do 5 not use soap and water or spray the vehicle with a hose Press and hold this button to move forward yes i To ensure that your vehicle stays in good operating order we Press and hold the go button on the steering wheel recommend that you periodically have your vehicle checked by The vehicle drives forward at a maximum of 2 mph a Power Wheels authorized service center For the location of the authorized service center nearest you please visit us on line Hint Be sure your child presses and holds the center of the go at www powerwheels com or call 1 800 348 0751 button for power
15. develops avoid contact with the leaking acid and place the damaged battery in a plastic bag See information below for proper disposal If acid comes in contact with skin or eyes flush with cool water for at least 15 minutes and call a physician If acid is internally ingested give water milk of magnesia or egg whites immediately Never give emetics or induce vomiting Call a physician Charge a new battery for at least 18 hours before first use Never charge the battery longer than 30 hours Overcharging or undercharging the battery may shorten battery life and decrease vehicle running time After the first charge recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Charge the battery after each use regardless of how long the vehicle was used The battery must be upright while charging Do not allow the battery to run down completely before charging Charge the battery before storing the vehicle Charge the battery at least once per month even if the vehicle has not been used Leaving the battery in a discharged condition will ruin it Always remove an exhausted battery from the vehicle Battery leakage and corrosion can damage the vehicle Do not store the battery on a surface such as a kitchen counter top which could be damaged by the acid contained inside the battery Take precautions to protect the surface on which you store the battery Do
16. e the battery longer than 30 hours Check all wires and connectors Make sure the battery connector is tightly plugged into the charger connector and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Do not charge the battery longer than 30 hours If you suspect that your battery is damaged as a result of overcharging contact your local Power Wheels authorized Service center They can test the battery for you Even with proper care a rechargeable battery does not last forever Average battery life is 1 to 3 years depending on vehicle use and use conditions Replace only with a Power Wheels 6 Volt 4 0 Amp Hr battery and built in thermal fuse Do not substitute parts The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your finger from the button and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 40 Ib maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center PROELENMNIS AND SOLUTIONS GUIDE PROBLEM POSSIBLE CAU
17. ehicle Start at the center of a label and smooth towards the outer edges to remove air bubbles RIGHT REAR VIEW M5130pr 0920 13 DECORATION FRONT LEFT SIDE M5130pr 0920 BATTERY INSTALLATION H IMPORTANT Use only a Power Wheels 6 volt 4 0 Amp Hr battery and built in thermal fuse Use of any other battery will damage your vehicle Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels 6 volt 4 0 Amp Hr charger before operating your vehicle for the first time Charge the battery for at least 14 hours after each use of the vehicle Never charge the battery longer than 30 hours Failure to follow these instructions may damage your battery and will void your warranty Motor Harness Connector Battery Connector Plug the battery connector into the motor harness connector Note If the battery connector will not plug into the motor Bumper Cover v harness connector turn it over and try again Do not force the Battery Retainer battery connector into the motor harness connector Loosen the screw in the rear bumper cover battery retainer as shown Remove the rear bumper cover battery retainer Replace the rear bumper cover battery retainer and tighten the screws Place a Power Wheels 6 volt 4 0 Amp Hr battery upright in the battery compartment as shown M5130pr 0920 15 j BATTERY CARE AND DISPOSAL Care If a battery leak
18. iagnosis and repair M5130pr 0920 PROBLEMS AND SOLUTIONS GUIDE PROBLEM Vehicle was running but Loose wires or loose connectors suddenly stopped Tripped thermal fuse Short run time Less than 1 hours per charge Undercharged battery Overcharged battery Battery is old and will not accept full charge Tripped thermal fuse M5130pr 0920 POSSIBLE CAUSE SOLUTION Check all wires and connectors Make sure the battery connector is tightly plugged into the motor harness con nector and that there are no loose wires around the motors The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your finger from the button and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 40 Ib maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charg
19. ing it does not mean that it is not accepting the charge There are no sounds from the If you pressed the buttons while installing Remove the action sounds box from thr vehicle and action sounds box batteries you may have temporarily re install the batteries DO NOT press the buttons while stopped the electrical function of the installing batteries sounds box The batteries may be dead or weak Remove the action sounds box from the vehicle and replace the batteries with three new alkaline AAA LROS batteries If after reviewing the Problems and Solutions Guide the vehicle still fails to operate please contact your nearest authorized service center M5130pr 0920 Before first time use you must charge the battery 1 hours Charge the battery immediately after each use Charge the battery once a month even if the vehicle is not used or stored Do not return your vehicle to the store CONSUMER ASSISTANCE Call toll free 1 800 348 0751 US amp Canada only M F 9AM to 7PM SAT 11AM to 5PM EST service fisher price com Write to us at Fisher Price Consumer Relations 636 Girard Avenue East Aurora New York 14052 Hearing impaired consumers using TTY TDD equipment please call 1 800 382 7470 Or contact your local independently owned and operated Power Wheels9 Authorized Service Center For the location nearest you visit us on line at www powerwheels com Fisher Price Inc a subsidiary of Mattel Inc
20. mbly You must charge your battery for 18 30 hours before you use your vehicle for the first time We recommend that you start charging your battery before beginning assembly Please see Battery Charging beginning on page 7 for detailed instructions Read this manual carefully for important safety information and operating instructions before using your vehicle Keep this manual for future reference as it contains important information This vehicle is designed for use on asphalt and other hard surfaces on generally level terrain and by children 12 36 months of age Use this vehicle ONLY outdoors Most interior flooring can be damaged by riding this vehicle indoors Fisher Price will not be responsible for damage to the floor if the vehicle is used indoors This vehicle has adjustable play seat belts Please note that the adjustable seat belts are designed to be a play feature only and do not function as protective safety restraints To prevent damaging the motors and gears do not tow anything behind the vehicle or overload it Do not exceed the maximum weight capacity of 40 Ibs 18 kg e f you have any questions about your Power Wheels vehicle please call our toll free service lines at 1 800 348 0751 from 9 AM to 7 PM EST Monday through Friday and 11 AM to 5 PM Saturday EST Trained customer service representatives are available to take your call in English or French Habla Espa ol Si usted tiene alguna preg
21. not store the battery in temperatures above 75 F or below 10 F Use only a Power Wheels 6 volt 4 0 Amp Hr battery Remember to charge the new battery for at least 18 hours before first use Prevent the battery from moving freely inside the battery compart ment Always use the battery retainer to secure the battery in the battery compartment Examine the battery charger and their connectors for excessive wear or damage each time you charge the battery If damage is detected do not use the charger or the battery until you have replaced the worn or damaged part 16 M5130pr 0920 Disposal Z5 XX e Your Power Wheels battery is a non spillable sealed lead acid battery They must be recycled or disposed of in an environmentally sound manner Do not dispose of a lead acid battery in a fire The battery may explode or leak Do not dispose of a lead acid battery in your regular household trash The incineration landfilling or mixing of sealed lead acid batteries with household trash is prohibited by law in most areas Protect the environment by not disposing of this product with household waste 2002 96 EC Check your local authority for recycling advice and facilities Europe only Return an exhausted battery to a federal or state approved lead acid battery recycler such as a Power Wheels authorized service center or a local seller of automotive batteries For the authorized service center location nearest to you
22. ou Tripped thermal fuse The built in thermal fuse may trip and shut down operation of the vehicle if the vehicle is overloaded or the driving conditions too severe Once a fuse has tripped remove your finger from the button and wait approximately 25 seconds before operating the vehicle again To avoid repeated automatic shutdowns do not overload the vehicle by exceeding the 40 Ib maximum weight capacity or by towing anything behind the vehicle Do not drive up hills or run into fixed objects which can cause the wheels to stop spinning while power is still being supplied to the motors If a thermal fuse continually trips contact your local Power Wheels authorized service center Loose wires or loose connectors Check all wires and connectors Make sure the battery connector is tightly plugged into the motor harness connector and that there are no loose wires around the motors Dead battery If your battery is old or if you have not followed Battery Care instructions your battery may be dead If you are unsure whether or not the battery are dead you can have it tested at your local Power Wheels authorized Service center Electrical switch damage The electrical switches can become corroded due to exposure to water or moisture or can jam due to loose dirt sand or gravel Contact your local Power Wheels authorized service center for diagnosis and repair Motor damage Contact your local Power Wheels authorized service center for d
23. per to Bumper Limited Warranty One year limited warranty from the date of purchase on the Power Wheels vehicle Six month limited warranty on the 6 volt battery For the original purchaser this one year limited warranty covers the Power Wheels ride on vehicle purchased from Power Wheels against defects in materials and workmanship The six month limited warranty applies only to the 6 volt battery included by Power Wheels with the original purchase of the vehicle This warranty covers normal use and does not cover the Power Wheels vehicle or battery if damaged by unreasonable use neglect accident abuse misuse improper service or other causes not arising out of defects in materials or workmanship Evidence of any attempt at consumer repair will void this warranty THIS WARRANTY DOES NOT COVER AND IS INTENDED TO EXCLUDE ANY LIABILITY ON THE PART OF POWER WHEELS WHETHER UNDER THIS WARRANTY OR IMPLIED BY LAW FOR ANY INDIRECT OR CONSEQUENTIAL DAMAGES FOR BREACH OF WARRANTY SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION SO THIS LIMITATION MAY NOT APPLY TO YOU Should you need service or assistance with your vehicle during the warranty period do not return the vehicle to the store Power Wheels has provided a nationwide network of authorized service centers If there is not an authorized service center in your area please visit us on line at www powerwheels com or call Consumer Relations for information 1 800 348 0751 This
24. ries of different types alkaline standard carbon zinc or rechargeable nickel cadmium Insert batteries as indicated inside the battery compartment Remove batteries during long periods of non use Always remove exhausted batteries from the product Dispose of batteries safely Do not dispose of this product in a fire The batteries inside may explode or leak Never short circuit the battery terminals Use only batteries of the same or equivalent type as recommended Do not charge non rechargeable batteries Remove rechargeable batteries from the product before charging f removable rechargeable batteries are used they are only to be charged under adult supervision 10 M5130pr 0920 ASSEMBLY F Action Sounds Box Action Sounds Box Cover e Fit the action sounds box to the action sounds box cover With the flag pointing toward the tront ef the e Wrap the cover flaps around the action sounds box as shown eh M iL Turn the flag pole so that the flag is toward the back of the seat Insert two 8 x 3 4 screws through the flag pole and into the back of the seat as shown Tighten the screws Action Sounds Box Seat Belt Insert the bottom tabs on the action sounds box into the slots in the inside of the front end of the vehicle e Push the action sounds box to snap the action sounds box into place Q Hint To remove the action sounds box when replacing batteries
25. sing the vehicle to slip 9 Do not allow your child to drive up steep inclines The motor may stop and the vehicle could roll backwards at an unsafe speed 10 Never put anything near any moving parts Rotating parts such as motors gear boxes and wheels can snag fingers hair etc causing serious injury Do not allow operation of the vehicle when it is on its side or in an upside down position Do not operate the vehicle near flammable vapors gasoline paint thinner acetone liquid wax etc The vehicle s electrical switches like most electrical switches emit an internal spark when first turned on or turned off The presence of flammable liquids or vapors could cause an explosion or a fire Keep all flammable products in tightly sealed containers and away from the vehicle 12 Do not allow a child to operate the vehicle without direct adult supervision To prevent unsupervised use of the vehicle disconnect the motor harness from the battery when the vehicle is not in use 1 a k M5130pr 0920 17 K VEHICLE OPERATION VEHICLE CARE L e Check all screws cap nuts and their protective coverings IMPORTANT Use this vehicle ONLY outdoors Most interior regularly and tighten as required Check plastic parts on a floor ing can be damaged by riding this vehicle indoors regular basis for cracks or broken pieces Fisher Price will not be responsible for damage to the floor e During snowy or rainy weather the vehicle shoul
26. t hole in the action sounds box cover as shown Fit the sounds knob into the left hole in the action sounds box cover as shown e Insert a 6 3 8 screw through the back of the action sounds box cover and into each knob Tighten the screws IMPORTANT Do not press the buttons on the action sounds box when installing the batteries i 1 5V x 3 tA ume Loosen the screw in the action sounds box battery compart ment door Remove the battery compartment door Insert three AAA LR03 alkaline batteries as indicated inside the battery compartment Hint We recommend the use of alkaline batteries for longer battery life Replace the battery compartment door and tighten the screw Test to be sure the action sounds box functions correctly Press the buttons and listen for sounds If there are no sounds simply remove and replace the batteries Make sure you do not press the buttons while replacing the batteries When sounds become faint or there are no sounds at all it s time for an adult to change the batteries Protect the environment by not disposing of this X product with household waste 2002 96 EC Check your local authority for recycling advice mmmm facilities Europe only Battery Safety Information In exceptional circumstances batteries may leak fluids that can cause a chemical burn injury or ruin your product To avoid battery leakage Do not mix old and new batteries or batte
27. the motors and all connectors to run but other times it does make sure they are tight Motor or electrical switch damage Contact your local Power Wheels authorized service center for diagnosis and repair M5130pr 0920 PROELENIS AND SOLUTIONS GUIDE PROBLEM POSSIBLE CAUSE SOLUTION When the button is pressed Loose wire or connector Check all wires around the motors and all connectors the vehicle won t run without to make sure they are tight a push Dead Spot on motor Contact your local Power Wheels authorized service center for diagnosis and repair Battery s thermal fuse constantly Damaged battery Contact your local Power Wheels authorized service trips but the vehicle is not center for diagnosis and repair overloaded nor the driving conditions too severe Loud clacking or grinding Broken gears Contact your local Power Wheels authorized service noise from a motor gearbox center for diagnosis and repair Charger gets warm during use It is normal for some chargers to get No action required warm during use and is not reason for concern Some chargers do not If your charger does not get warm during use get warm during use it does not mean that it is not working properly Battery makes a sizzling or It is normal for some batteries to No action required gurgling noise when charging make noise and swell slightly while charging and is not reason for concern If your battery does not make noise or swell slightly during charg
28. unta 6 necesita asistencia llame gratis 1 800 348 0755 para los Estados Unidos Tenemos representantes que hablan espa ol para atender su llamada e For your convenience Power Wheelse maintains an Authorized Service Center Network with more than 300 independently owned and operated authorized service centers nationwide The authorized service centers will repair or replace parts under warranty at no extra charge and can perform non warranty repairs for a minimal charge To find the authorized service center nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 To register your vehicle please visit us on line at www powerwheels com 5130 0920 WARNINGS AND CAUTIONS B ELECTRICAL HAZARD WARNING Battery fall out and injure a child if vehicle tips over Always use battery retainer PREVENT FIRE Never modify the electrical system Alterations could cause a fire resulting in serious injury and could also ruin the electrical system Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury Use of Power Wheels components in products other than Power Wheels vehicles could cause overheating fire or explosion The battery must be handled by adults only The battery is heavy and contains sulfuric acid electrolyte Dropping the battery could result in serious injury Never allow children to charge the battery Battery charging must
29. warranty gives you specific legal rights and you may also have other rights which may vary from state to state PLEASE SAVE YOUR ORIGINAL SALES RECEIPT M5130pr 0920 PROBLEMS AND SOLUTIONS GUIDE IMPORTANT If you experience a problem with your vehicle first check the Problems and Solutions Guide below If you still experience a problem please contact Power Wheels Consumer Relations toll free at 1 800 348 0751 between 9 AM and 7 EST Monday through Friday and 11 AM to 5 PM EST Saturday Or contact your local Power Wheels authorized service center For the location nearest you please visit us on line at www powerwheels com or call 1 800 348 0751 PROBLEM POSSIBLE CAUSE SOLUTION Vehicle does not run Undercharged battery Charge the battery A new battery should have been charged for at least 18 hours before using the vehicle for the first time After first time use recharge the battery for at least 14 hours after each use Never charge the battery longer than 30 hours Check all connectors Make sure the battery connector is tightly plugged into the charger connector and that the charger is plugged into the wall Make sure power flow to the wall outlet is ON Charger is not working There is no sure way to tell if your charger is working unless you have a volt meter If you suspect there is a problem with your charger contact your local Power Wheels authorized service center They can test your charger for y
30. y have been taught about them There is no acceptable substitute for direct adult supervision Teach appropriate safety rules to your child before allowing Operation of this vehicle These rules should also be reviewed with neighborhood children or other playmates who want to drive this vehicle Riding Rules Make sure children know and follow these rules for safe driving 1 Always sit on the seat 2 Always wear shoes 3 Only 1 one rider at a time A child who is not sitting on the seat or who is standing on the vehicle could fall off cause a tip over or block the driver s view A child could be seriously injured 4 Do not allow any child to drive the vehicle in the street or near moving motorized vehicles 5 Do not allow any child to drive near bodies of water such as pools or creeks obstructions such as furniture low tree limbs or play equipment or drop offs such as stairs or decks 6 Do not allow any child to drive the vehicle in the dark A child could encounter unexpected obstacles and have an accident Operate the vehicle only in the daytime or a well lit area 7 Do not allow your child to drive on sloped or inclined surfaces Restrict your child s driving to generally level ground ONLY 8 Do not allow your child to drive down or across a steep slope The vehicle may gain unsafe speed even if the button is released to stop The vehicle may tilt and tip over The wheels could lose traction cau
Download Pdf Manuals
Related Search