Dacor dct365 Cooktop User Manual
Contents
1. Ty 1 3 cm 3 4 cm 3 4 cm 19 9 22 49 0 a 33 She 84 6 cm Side View Front View 11 32 Product Dimensions 4 Front of cooktop Power Vs male NPT Front of unit cord in gas inlet 1 4 4 cm Chassis Vs male 1 la 2 NPT gas inlet 4 4 cm 5 1 cm Power cord 42 106 7 cm long Top panel overhang Gas inlet protudes Y 1 3 cm from bottom Utility Locations Utility Dimensions dacor 3 Installation Specifications Electrical Requirements Gas Supply Requirements WARNING To prevent an electric shock hazard the power supply must meet the specifications stated below It is the own er s responsibility to make sure that the electrical service meets electrical requirements and that the electrical outlet has been properly installed by a licensed electrician e The cooktop is supplied with a factory installed 42 inch long power cord with a three prong grounding elec trical plug It is connected to the chassis at the bot tom right rear corner see Chassis Bottom Diagram below lt must be connected to a dedicated grounded three prong electrical outlet installed by a licensed elec trician e The electrical installation including minimum supply wire size and grounding must be done in accordance with National Electric Code ANSI NFPA 70 and local codes and ordinances A copy of this standard may be obtained from National Fire Protection A2. putty on flexible gas line connections Test the gas lines for leaks as instructed before use Do not use a flame to check for leaks The maximum gas supply pressure to the regulator must never exceed pounds per square inch p s i or 3 5 kPa The cooktop and shut off valve must be disconnected from the gas supply piping system during any pres sure testing exceeding p s i 3 5 kPa The cooktop must be isolated from the gas supply piping system by closing the shut off valve to the cooktop during any gas supply piping system pres sure testing equal to or less than p s i 3 5 kPa For LP gas installations the LP gas tank must have its own high pressure regulator in addition to the pressure regulator supplied with the cooktop Attach the gas pressure regulator included with the cooktop to the cooktop pipe nipple inlet For tight installations the regulator may be installed upstream from the pipe nipple anywhere between the shut off valve and the cooktop For best performance minimize gas pressure loss by attaching the regulator as close as possible to the cooktop gas inlet Complete connection of the gas supply to the cooktop by installing a minimum 74 flexible gas line not includ ed between the pressure regulator and the shut off valve Check for gas leaks Turn all cooktop control valves to the OFF position Turn on the gas supply valve and check all lines and connections for leaks using a soap and
3. towels or bulky cloth as pot holders Do not use the cooktop to heat sealed containers The container and contents may explode causing personal injury If the cooktop is near a window do not use long cur tains as window treatment The curtains could blow over the cooktop and create a fire hazard Non stick coatings when heated can be harmful to birds Remove birds to a separate well ventilated room when operating the cooktop IMPORTANT This appliance is equipped with a three prong grounding plug for your 19 protection against possible 3 electric shock hazards Plug it i ow only into a dedicated grounded three prong electrical outlet It is the responsibility of the customer to make sure the proper type of outlet is installed Do not under any circumstances Cut or remove the third ground prong from the power cord Use an adapter plug Use an extension cord Use a power cord that is frayed or damaged Connect to an electrical outlet with a ground fault interrupter GFI Installation Specifications WARNING Observe all governing codes and ordinances during planning and installation Contact your local building department for further information Product Dimensions All tolerances 1 16 1 6 mm unless otherwise noted 2 5 1 cm countertop to cooking surface a Le 4 10 2 cm chassis height Rear Front overhang overhang 1 3 AN 17 39 1 11 5 1 3 0 cm
4. EVER PICK UP A FLAMING PAN you may be burned DO NOT USE WATER including wet dish cloths or towels a violent steam explosion may result Safety Symbols and Labels R y Use a fire extinguisher ONLY if DANGER Immediate hazards that WILL result in severe personal injury or death e The Important Safety Instructions and warnings in these instructions are not meant to cover all possible problems and conditions that can occur Use common sense and caution when installing maintaining or oper ating this or any other appliance e Always contact the Dacor Customer Service Team about problems and conditions that you don t under stand See Customer Service Information You have a Class ABC extinguisher and you already know how to operate it The fire is small and contained in the area where it started The fire department is being called WARNING You can fight the fire with your back to an exit WARNING WARNING NEVER use this appliance as a space heater to heat or warm the room Doing so may result in carbon monoxide poisoning and overheating of the appliance Hazards or unsafe practices that COULD result in severe personal injury or death CAUTION Hazards or unsafe practices that COULD result in minor personal injury or property damage DANGER IMPORTANT If you smell gas WARNING WARNING NEVER cover any slots holes or passages on the cooktop and cooktop chassis Doing so blocks air flow thr
5. ation Customer Service Information If You Need Help Product Data Label If you have questions or problems with installation contact The product data label contains the model and serial your Dacor dealer or the Dacor Customer Service Team For number information and the electrical and gas supply repairs to Dacor appliances under warranty call the Dacor requirements Distinctive Service line Whenever you call have the model Itis attached to the chassis on the bottom of the unit and serial number of the appliance ready The model and serial number are printed on the product data label Front of unit Dacor Customer Service Phone 800 793 0093 U S A and Canada Monday Friday 6 00 a m to 5 00 P M Pacific Time Web site www Dacor com Dacor Distinctive Service repairs under warranty only Phone 877 337 3226 U S A and Canada Monday Friday 6 00 a m to 4 00 p m Pacific Time All specifications are subject to change without notice Dacor assumes no liability for changes to specifications 2010 Dacor all rights reserved Important Safety Instructions Important Information About WARNING Safety Instructions TO REDUCE THE RISK OF INJURY TO PERSONS IN THE EVENT OF A RANGE TOP GREASE FIRE a SMOTHER FLAMES with a close fitting lid cookie sheet or metal tray then turn off the burner BE CAREFUL TO PREVENT BURNS If the flames do not go out immediately EVACUATE AND CALL THE FIRE DEPARTMENT N
6. ax 33 0 cm e Access to the underside of the cooktop for service and inspection purposes e Clearance inside the cabinet to allow for proper hold Combustible down bracket installation s rface to rear To allow access to the utilities and cooktop bottom a fixed shelf should not be installed below the cooktop See the fol lowing pages for countertop cutout dimensions See cutout dimensions See cutout dimensions 1 Measured from the cooking surface top of cooktop grate 2 If installing with an overhead vent hood also check the hood specifications for minimum required clearances 3 Not applicable for cabinets more than a horizontal distance of 5 Y 14 0 cm from edge of cooktop Allow 6 7 8 17 5 cm from cutout edge Minimum Required Clearances Around the Cooktop A Minimum A Recommended 36 91 4 cm 42 106 7 cm dacor 5 Installation Specifications Cutout Dimensions All tolerances 1 16 0 1 6 mm 0 unless otherwise noted Vertical combustible surface gt TT wr combustibles below cooktop chassis 1 5 8 min LAS RE Minimum distance to combustible side 4 1 cm wall above countertop both sides Minimum P 3 8 3 cm 195 8 49 9 cm 33 5 8 85 4 cm 6 7 g 17 5 cm Countertop Cutout Dimensions 6 dacor Installation Instructions Installing the Cooktop Hold down brackets 2 Grates 3 Burner sets 5 Gas pressure re
7. dacor arcani pregati masi Installation Instructions Distinctive Series Cooktop Model DCT365 Part No 106927 Rev A Table of Contents Important Safety Instructions inn 1 Installation Instructions rriii 7 Important Information About Safety Instructions 1 Verify Package Contents nennen snnnnnnnn san 7 General Safety Precautions 2 Installing the Cooktop senessnsnenneennennennneenennnn 7 Installation Specifications uunuensnnnennnnnnnnnennnnnnnnnnnnnnnnnn 3 Connecting the Gas Line i 7 Product DIMENSIONS 3 Installing the Burner Components 8 Electrical Requirements nennen 4 Verifying Proper Operation nennen 9 Gas Supply Requirements nennen 4 Installation Checklist nennen 10 Cabinet and Countertop LayouUt 5 Wiring Diagram iiin 11 Before You Begin Important e Installer In the interest of safety and to minimize problems read these installation instructions completely and care fully before you begin the installation process Leave these installation instructions with the customer e Customer Keep these installation instructions for future reference and the local electrical inspector s use NOTE Dacor is not responsible for service required to correct a faulty install
8. ee inside cover for location Dacor is not responsible for the cost of correcting problems caused by a faulty installation OFF gt HIGH LOW position position SimmerSear Control Knob Center OFF gt HIGH position LOW position Standard Burner Control Knob dacor 9 Installation Instructions Installation Checklist WARNING To ensure a safe and proper installation the follow ing checklist should be completed by the installer to ensure that no part of the installation has been over looked Proper installation is the responsibility of the home owner The importance of proper installation of your Dacor cooktop cannot be overemphasized Ll Is the electrical outlet for the cooktop grounded and located according to these instructions and in accor dance with all applicable electrical codes See page 4 Ll Is the gas service for the cooktop located and installed according to these instructions and in accordance with all applicable codes See page 4 El Has the gas supply inlet pressure been measured to ensure that it does not exceed the maximums stated in these instructions See page 4 El Is the cooktop secured using the provided hold down brackets See page 7 L Is the cooktop connected to the gas supply according to these instructions and in accordance with all appli cable codes Did the installer check the gas supply for leaks See page 7 Ll Are the burners and grates proper
9. gulator provided The regulator must be installed in the gas line that runs from the cooktop gas inlet to the gas shut off valve e The regulator inlet female accommodates a 3 4 gas line It can also accommodate a 1 2 gas line using the included reducer The inlet to the cooktop itself is equipped with a Y male NPT fitting The cooktop gas connection is located on the bottom of the cooktop in the back right corner as you face the front of the unit See the Chassis Bottom Diagram on this page DCT365S NG DCT365S LP Gas type Natural gas Manifold 5 Water 10 Water pressure column column Min gas supply pressure 6 Water 11 Water column column Max gas supply 1 2 p s i 1 2 p s i pressure Total connected 0 25 Amp 0 25 Amp load 30 VVatts 30 VVatts Circuit 120 Vac 120 Vac requirement 60 Hz 15 Amp 60 Hz 15 Amp Gas and Electrical Requirements The gas supply pressure for testing the regulator setting shall be at least 1 inch water column 249 Pa above the specified manifold pressure The electrical and gas data on this page is for reference only Ifthe above data does not agree with the product data label use the data on the product data label Installation Specifications Allow a minimum 4 6 mm clearance between the Cabinet and Counterto La out bottom of the cooktop chassis and all combustible sur WARNING faces including the upper edge of a drawer installed below
10. gulator with Y to Y reducer Stainless steel cleaner WARNING Verify that the power supply meets the specifications on page 4 before proceeding To prevent damage to the gas pressure regulator install it only after the cooktop is mounted in its per manent position CAUTION Do not over tighten the hold down bolts Over tight ening the hold down bolts may result in improper operation of the dual gas burners Do not use a hardening compound or caulk to perma nently seal the cooktop into place The cooktop must be readily removable if service is required Removal of sealant to service the unit will be performed at the customer s expense Lower the cooktop into the cutout Slide it forward as far as possible and center it side to side Secure the cooktop to the countertop using the two 2 provided hold down brackets as shown bracket mounting holes both sides SERS N Gas inlet Hold Down Bracket Installation Verify Package Contents Connecting the Gas Line e WARNING Verify that the gas supply meets specifications before connection See page 4 Do not install the cooktop without also installing the included gas regulator Do not use the cooktop with out the regulator installed Ensure that the arrow on the regulator points in the direction of the gas flow towards the cooktop Do not apply excessive pressure when tightening gas connections and fittings Do not use Teflon tape or plumber s
11. he risk of fire electric shock serious injury or death when using this appliance follow basic safety precautions including the following WARNING Read the accompanying use and care manual com pletely before operating this appliance Keep packaging materials away from children Plastic sheets and bags can cause suffocation If you receive a damaged product immediately con tact your dealer or builder Do not install or use a damaged appliance This cooktop must be properly installed and ground ed by a qualified installer according to these instal lation instructions prior to use The installer should show the customer the location of the gas shut off valve and the power cord so that they know where and how to turn off the gas supply and disconnect power to the cooktop Do not use this appliance in combination with a sur face countertop ventilation system Dacor strongly recommends the installation of a range hood in con junction with this appliance Do not install repair or replace any part of the cooktop unless specifically recommended in the liter ature accompanying it A qualified service technician should perform all other service Before servicing or installing this cooktop make sure that the gas supply is turned off at the gas supply valve and that the power plug is disconnected from the electrical outlet Disconnect the power plug from the electrical outlet before cleaning Clean this appliance only in the
12. ly installed according to these instructions See page 8 O Has proper operation been verified Ll Has the warranty been activated on line or the warranty card filled out completely and mailed 10 dacor VViring Diagram VVARNING Label all wires prior to dis connection when servicing Verify proper operation controls VViring errors can cause improper and after servicing dangerous operation 120 Vac 60 Hz power supply IGNITERS FL LIGHT MC LIGHT T FR LIGHT W T RR LIGHT Wiring Diagram DCT365 dacor 11 12 dacor dacor ee The Life of the Kitchen American Made Dacor e 600 Anton Blvd Suite 1000 Costa Mesa CA 92626 e Phone 800 793 0093 e Fax 626 403 3130 e www Dacor com
13. manner specified in the use and care manual Only use the cooktop for cooking tasks expected of a home appliance as outlined in the literature accom panying it This cooktop is not intended for commer cial or laboratory use DO NOT TOUCH THE SURFACES OF THE COOKTOP DURING OR IMMEDIATELY AFTER USE Do not operate this appliance if the power cord is damaged Turn the knobs to the OFF position prior to removing them from the valve stems To avoid a fire hazard do not hang flammable or heat sensitive objects over the cooktop Do not climb on any part of the appliance 2 dacor WARNING Do not leave children alone or unattended in the area around the cooktop Do not allow children to play with the controls or touch other parts of the cooktop Do not store items of interest to children on top of or above the cooktop Children could be burned or injured while climbing on the appliance Clean the cooktop thoroughly before operating it for the first time Make sure that all the cooktop parts are dry before lighting a burner Keep flammable items such as paper cardboard plastic and cloth away from the burners and other hot surfaces Do not place such items on the cooktop Do not allow pot holders to touch hot sur faces or gas burners Do not wear loose or hanging apparel while using the cooktop Do not allow clothing to come into con tact with the cooktop and surrounding areas during and immediately after use Do not use
14. onds turn the knob to the off position Wait for at least 5 minutes to allow any gas to dissipate then repeat the test Once the burner lights rotate the control knob counterclockwise from HIGH to LOW to adjust the flame height progressively On the SimmerSear burner only the center of the burner should be lit when the knob is in the low position e When the unit is installed properly the flame will be steady It will also have a sharp blue inner cone that will vary in length proportional to the burner size The flame will be reduced by the Smart Flame feature under the grate fingers to increase grate life Normal Flame Appearance NOTE If the cooktop does not operate properly follow these troubleshooting steps Verify that power and gas are supplied to the cooktop Check to make sure that the power plug is connected to the electrical outlet and that power is turned on at the circuit breaker panel or fuse box Check to make sure that the burner parts are properly seated If the burner continues to spark after ignition without stopping have a licensed electrician check the electri cal outlet for proper grounding or reversed polarity Repeat the above burner ignition test If the appliance still does not work contact Dacor Distinctive Service at 877 337 3226 Do not attempt to repair the appliance yourself If you need service be sure to have the model and serial numbers available when you call S
15. ough the cooktop and may cause carbon monoxide poisoning Aluminum foil linings may also trap heat causing a fire hazard Keep all slots holes and passages clear of grease and grime Do not use or light any appliance Do not touch any electrical switch or use any electri cal devices including the telephone in your building From a neighbor s phone immediately call the gas supplier Follow the gas supplier s instructions CALIFORNIA PROPOSITION 65 WARNING The burning of gas cooking fuel generates some by products that are on the list of substances which are known by the State of California to cause cancer or reproductive harm California law requires businesses to warn customers of potential exposure to such substances To minimize exposure to these substances always operate this unit according to the use and care manual ensuring you provide good ventilation when cooking with gas If you cannot contact the gas supplier call the fire department DANGER IMPORTANT Do not store or use combustible flammable or explosive vapors and liquids such as gasoline on or in the vicinity of this or any other appliance Also keep items that could explode such as aerosol cans away from the cooktop Do not store flammable or explosive materials in adjacent cabinets or areas including above and below the cooktop READ AND SAVE THESE INSTRUCTIONS dacor 1 Important Safety Instructions General Safety Precautions To reduce t
16. rner cap bottom shown Fit hole in burner ring over igniter CAUTION Top of igniter is sharp Standard Burner Assembly 2 large 2 small Installation Instructions Veritying Proper Operation WARNING Make sure that power to the electrical outlet is turned off at the circuit breaker panel or fuse box and that the gas is turned off at the gas supply valve before proceeding The cooktop must be properly grounded at all times when electrical power is applied Prior to operating the cooktop read the accompanying use and care manual carefully 1 Make sure all the cooktop burner controls are in the OFF position Connect the power cord to the electrical outlet Turn on power to the electrical outlet at the circuit breaker panel or fuse box Push down and turn the left front burner control knob slowly counterclockwise to the HIGH posi tion The corresponding burner indicator light should come on Verify that the burner igniter sparks then return the knob to the OFF position Repeat for all of the remaining HIGH control knobs position Turn on the gas supply valve Perform the following ignition test for all of the burners one at a time e Push down and turn the control knob slowly coun terclockwise to the HIGH position All of the burner igniters will spark lt may take up to 4 seconds for the burner to ignite at which time the igniters will stop sparking If ignition does not occur within 4 sec
17. ssociation 1 Batterymarch Park Quincy MA 02269 9101 The correct voltage frequency and amperage must be supplied to the electrical outlet according to the product data label located on the bottom of the chassis See the Gas and Electrical Requirements table on this page for reference Be certain to locate the electrical outlet so that the power cord may be easily disconnected if the unit requires service Front of unit Chassis Bottom Diagram 4 dacor Be certain that the cooktop being installed is correct for the gas service being provided natural gas or LP gas Also if operating the cooktop at an altitude above 4000 ft 1219 m make sure it is equipped for high altitude operation e Units equipped for LP operation have LP in the model number listed on the product data label See the Chassis Bottom Diagram for label location e Units equipped for high altitude operation have an H at the end of the model number listed on the product data label Check your local building codes for the proper method of installation In the absence of local codes this appliance should be installed in accordance with the National Fuel Gas Code ANSI Z223 1 NFPA 54 An external manual shut off valve must be installed between the gas inlet and the cooktop for the purpose of turning on or shutting off gas to the appliance e The cooktop comes from the factory with a regulator in the shipping carton Use only the re
18. the cooktop Failure to meet or exceed the maximum and mini N mum dimensions clearances stated in these instruc tions may result in a fire hazard S S Follow the countertop manufacturer s instructions regarding the minimum corner radius use of heat Ya 6 mm reflective tape reinforcement of corners etc mimimum clearance 35 Y _ ss to combustible e Carefully check the location where the cooktop will be 394 89 0 Cm s ffac installed For best performance the cooktop should be placed away from drafts that may be caused by doors Allows for clearance between hold down brackets windows and heating and air conditioning outlets Under Cabinet Clearances e This appliance is to be used in conjunction with a suit e The gas supply piping gas shut off valve and the elec able vent hood trical outlet must be located so that they do not inter All tolerances 1 16 1 6 mm 0 fere with the cooktop when it is installed If installing another appliance in the cabinet below allow for the routing of gas and electrical service behind it unless otherwise noted A The installation must allow for the following Combustible overhead e Access to the gas shut off valve and regulator when cabinets the unit is installed e Access to the electrical outlet when the cooktop is in place The 42 106 7 cm power cord must be able to reach the electrical outlet 13 m
19. water solution or a gas leak detector Turn the gas supply off dacor 7 Installation Instructions Installing the Burner Components WARNING e Never attempt to operate the cooktop with any of the burner parts removed Do not attempt to adjust the burner air mixture set tings All adjustments are preset at the factory 1 Remove the burner rings burner caps and grates from their shipping packages 2 Assemble the burners as shown Match the burner parts to the correct size and type of burner When installing the burner components make sure they are centered Twist each piece back and forth slightly until it drops completely into place The burners will not operate properly unless all of the burner pieces are properly seated 3 Gently set the grates on top of the spill tray Make sure that the rubber feet are positioned in the dimples Each grate is different Orient them as shown Each grate has a slot on the bottom that matches up with a notch on the spill try The slots on the grates all go toward the back of the cooktop Inner burner cap bottom shown Outer burner cap Burner ring Line up indentations on bottom of burner ring with pins on top of base Burner base SimmerSear Burner Assembly center of cooktop 8 dacor Burner base Left grate curved fingers Slot on bottom Right grate curved fingers on right SimmerSear burner a Rec Standard burner Bu
Download Pdf Manuals
Related Search