Ariston WMG 829 Washer User Manual
Contents
1. QI Q QO N N ch 1 C 1 1 2 Freezer version control panel Access to Food Categories button Service alarms button Service alarms indicator light Manual defrost UP button Set temperature Category selection DOWN button HACCP alarms button Display Compressor status indicator light Power supply status indicator light Power ON OFF button D O NO OO N C 1 2 INITIALSWITCH ONAND TEMPERATURE ADJUSTMENT The appliance features an ON OFF switch for activating it Turn on the appliance by pressing the ON OFF button To set the chamber temperature follow these steps Example of setting press and hold SET DOWN button for 5 seconds switch on the appliance the SET TEMPERATURE value appears on the display confirm the set temperature the Unit of Measure Indicator light starts flashing 7 To change the SET temperature press SET DOWN button or MANUAL DEFROST UP button within 15 seconds press SET DOWN button or MANUAL DEFROST UP button or To store the new set value wait until it stops flashing to exit the program To store the new set value wait until it stops flashing to exit the program If a selection is not made after 15 seconds the last value dis played will be confirmed automatically and the chamber tem perature display is restored Here below the temperature range for the appliances 171 71 gallons 650 It a2. 650 litres remote unit 1 door 2 Y doors Gross capacity 171 71 gallons 650 External dimensions Width 29 53 750 mm Depth with door closed 31 89 810 mm Depth with door open 57 60 1463 mm Height 80 71 2050 mm Compartment dimensions Width 23 62 600 mm Depth 26 18 665 mm Height 26 10 26 10 663 663 mm Rack dimensions 20 87 x25 59 530x650 mm Power supply 20V single phase 60Hz Internal temp range a 28 F 50 F 2 C 10 C Internal temp range b 7 6 F 8 6 F 22 C 13 C Max room temp 109 4 F 43 C Total current absorbed 5A Refrigerant capacity R404A 1 1408 W Refrigerant capacity R404A 2 916 W No and type of defrosts min 1 every 12 hours x max 30 At room temperature 104 F 40 C 1 At room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 9 94 F 23 3 C Automatic by means of electronic board Recommended condenser unit mod CAJ2446Z Compressor power Hp 3 4 Max dist cond unit vert refr m 15 Max ht diff cond unit vert refr m 3 Suction pipe cross section mm inside 0 12 7 Delivery pipe cross section inside 0 9 5 distances require condenser units with greater power Refrigerator model 369 84 gallons 1400 litres re
3. C BLED ALIMENTATION LONGUEUR 137 79 3500 mm PRISE TYPE SCHUKO C DESAG E DE L QUIDOS DE LA C MARA DI METRO de 0 69 pulg 17 5 mm I CABLE DE ALIMENTACI N de 137 79 pulg 3500 mm DE LONGITUD ENCHUFE TIPO SCHUKO INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE SCH MA D INSTALLATION DIAGRAMA DE INSTALACION REFRIGERATOR FREEZER 369 84 gallons 1400litres2 R FRIG RATEUR CONG LATEUR369 84gallons 1400 TEMPERATURES litres 2 TEMPERATURES FRIGORIFERO CONGELATORE 369 84 galloni 1400 FRIGOR FICO CONGELADOR de 369 84 galones 1400 litri2 TEMPERATURE litros 2 TEMPERATURAS FRONT VIEW VISTA FRONTALE VUE DE FACE SIDEVIEW VISTA LATERALE VUE DE C T VISTA VISTAFRONTAL LATERAL H a 311 mm y Si 80 45 64 2050 mm 12 1 64 5 29 32 150 mm 3 15 64 52 19 32 L 3 15 64 35 62 21 39 64 6 3 8 59 1 16 31 57 64 1500 mm 22104 14 4 5 3 5 mm T TOP VIEW VISTA SUPERIORE VUE DU DESSUS VISTASUPERIOR 57 19 32 E A 1463 mm C OUTLET FOR DRAINING OFLIQUIDSFROMCHAMBER DIAMETER0 69 17 5mm I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SCHUKO TYPE PLUG C PILETTA PER LO SCARICO LIQUIDI DELLA CELLA DIAMETRO 0 69 17 5 I CAVOD ALIMENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO C BONDE POURL EVACUATION DES
4. 3500 mm PRISE TYPE SCHUKO C DESAGUE DE L QUIDOS DE LA C MARA DI METRO 0 69 17 5 mm I CABLEDE ALIMENTACI N de 137 79 pulg 3500 mm DE LONGITUD ENCHUFE TIPO SCHUKO INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE SCH MA D INSTALLATION DIAGRAMA DE INSTALACION 369 84 gallons 1400 It FREEZER CONG LATEUR de 369 84 gallons 1400 litres CONGELATORE 369 84 galloni 1400 litri CONGELADOR de 369 84 galones 1400 litros FRONT VIEW VISTA FRONTALE VUE DE FACE SIDE VIEW VISTA LATERALE VUE DE C T VISTA VISTA FRONTAL LATERAL 12 1 4 311 mm 80 45 64 2050 5 29 32 150 mm 3 15 64 52 19 32 I _ _ 3 15 64 3 57 64 2 _ 2139 64 _ 6 3 8 82 mm 1336 mm 59 1 16 1500 mm 82mm 99mm 549mm 31 57 64 810mm 102 mm TOP VIEW VISTA SUPERIORE VUE DU DESSUS VISTA SUPERIOR 57 19 32 s 1463 I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SCHUKO TYPE PLUG I CAVOD ALIMENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO I CABLE D ALIMENTATION LONGUEUR 137 79 3500 mm PRISE TYPE SCHUKO I CABLE DE ALIMENTACI N de 137 79 pulg 3500 mm DE LONGITUD ENCHUFE TIPO SCHUKO INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE REFRIGERATOR 171 71 gallons 650 litres 2 2DOORS 2 TEMPERATURES FRIGORIFERO 171 71 galloni 650 litri 2 Y PORTE 2 TEMPERA
5. After making the connection and with the appliance running check that the rated level does not fluctuate by 10 The connection must be made with cable of a suitable amperage and voltage The manufacturer will accept no liability for any damage or injury resulting from the violation of the above rules or of the current electrical safety standards in the country where the appliance is used B 1 6 WATER CONNECTION The machine has a drainage outlet where any liquids in the chamber collect for drainage Connect the chamber drain outlet C only for refrigerator models to be found on the bottom of the appliance and closed with a plug to a drain The drain outlet diameter is 0 69 17 5 it is therefore advisable to connect it to a drain pipe of 0 69 17 5 mm Note the drain must be siphoned to an open drain in order to prevent any back flow from the sewage system from reaching the piping inside the chamber 43 C 1 OPERATIONS and USER INSTRUCTIONS 1 1 CONTROL PANELS refer to fig 1 2 3 4 1 1 1 Refrigerator version control panel Access to Food Categories button High humidity ON OFF button High humidity indicator light Service alarms button Service alarms indicator light Manual defrost UP button Set temperature Category selection DOWN button HACCP alarms button Display Compressor status indicator light Power supply status indicator light Power ON OFF button
6. 20 TOP VIEW VISTA SUPERIORE VUE DU DESSUS VISTASUPERIOR 57 19 32 1463 mm C OUTLET FOR DRAINING OFLIQUIDSFROMCHAMBER DIAMETER0 69 17 5mm I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SCHUKO TYPE PLUG C PILETTA PER LO SCARICO LIQUIDI DELLA CELLA DIAMETRO 0 69 17 5 I CAVOD ALIMENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO C BONDE POURL EVACUATION DES LIQUIDES DE LA CELLULE DIAM TRE 0 69 17 5 mm I C BLED ALIMENTATION LONGUEUR 137 79 3500 mm PRISE TYPE SCHUKO C DESAG E DE L QUIDOS DE LA C MARA DI METRO de 0 69 pulg 17 5 mm I CABLE DE ALIMENTACI N de 137 79 pulg 3500 mm DE LONGITUD ENCHUFE TIPO SCHUKO 21 DIAGRAMFORPOSITIONINGOFPIPESFORREMOTEUNIT APPLICABLE FOR REMOTE CABINETS 550 650 OR FOR REMOTE CABINETS 1200 1400 WITH TWO TEMPERATURES SCHEMA POSIZIONAMENTO DEI TUBI PER GRUPPO REMOTO VALIDO PER ARMADI REMOTI 550 650 OPPURE PER ARMADI REMOTI 1200 1400 A DUE TEMPERATURE OUT 040 N 04 A TUBO DI ASPIRAZIONE DIAMETRO ESTERNO 6 mm B TUBO DI MANDATA DIAMETRO ESTERNO 10 mm A SUCTION PIPE OUTSIDE DIAMETER 6 mm B DELIVERY PIPE OUTSIDE DIAMETER 10 mm 22 SCHEMA DEMISE EN PLACE DES TUYAUX POUR GROUPE DISTANCE VALABLE POUR LES ARMOIRES PREDISPOSEES POUR GROUPE A DISTANCE 550 650 OU POUR LES ARMOIRES 1200 1400 A DEUX TEMPERATURES PREDISPOSEES POUR GROUPE A DISTANCE ESQUEMA DE POSICIONAMENTO DOS TUBOS PARAO GRUPO REMOTO VALIDO PARA ARMARIOS REMOTOS550
7. 33 GiS Loading the product uu un uu al edt Page 45 Giulio Detroit tt ate qu N 46 46 1 7 1 a Q iii Giese deed eee Page 46 127 2 EE Page 46 7 35 Page 47 G 17 4 Service alams EE Page 47 Git Aatmi managements uu uu os Page 47 1 7 6 alamo turis nani dpi Page 48 0 1 7 Troubleshooting ra Page 48 D 1 ROUTINE MAINTENANCE Page 48 D 1 1 Cleaning the cabinet and accessories u Page 48 0 1 2 Cleaning the chamber e da n Page 48 0 1 3 Precautions in the event of prolonged Page 48 D 2 MAINTENANCE TO BE PERFORMED BY TRAINED PERSONNEL ONLY 49 D 2 1 Periodic cleaning Of condenser UU Page 49 0 2 2 Replacing the control panel bulb Page 49 0 2 3 Replacing the power supply cable Page 49 D 3 TROUBLESHOOTING Page 49 D 3 1 Quick troubleshooting goude u Page 49 DA WASTE DISPOSAL AND DEMOLITION Page 49 4 A EEAO e lO E T A A Page 49 0 4 2 Pr
8. 58 42 1484 mm Rack dimensions 20 87 x15 75 530x400 mm Power supply 120V single phase 60Hz Internal temp range 11 2 F 5 F 24 C 15 C Max room temp 109 4 F 43 C Current absorbed 15A Refrigerant charge R404A model 2 doors 0 892 lbs 405 y Refrigerant charge R404A model 4 doors and energy saving 0 815 lbs 3709 Refrigerant capacity R404A 1 2535 W Refrigerant capacity R404A 1319 W No and type of defrosts min 1 every 12 hours x max 30 At room temperature 104 F 40 C 1 At room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation tem perature 9 94 F 23 3 C Automatic by means of electronic board Refrigerator model 171 71 gallons 650 litres 2 12 doors 2 temperatures Gross capacity 171 71 gallons 650 litres External dimensions Width 29 53 750 mm Depth with door closed 31 89 810 mm Depth with door open 57 60 1463 mm Height 80 71 2050 mm Compartment dimensions Width 23 62 600 mm Depth 26 18 665 mm Height 26 10 26 10 663 663 mm Rack dimensions 20 87 25 59 530x650 mm Power supply 120V single phase 60Hz Internal temp range a 28 F 50 F 2 C 10 C Internal temp range b 28 F 50 F 2 C 10 C Max room temp 109 4 F 43 C Total current absorbed 10A Refrigerant cha
9. At room temperature 104 F 40 C 1 At room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation tem perature 9 94 F 23 3 C ASHRAE PERFORMANCE room temperature 89 6 F 32 C dew point 129 92 F 54 4 C and evaporation tem perature 44 96 F 7 2 C Automatic by means of electronic board Refrigerator model 369 84 gallons 1400 litres 2 tempera tures energy saving Gross capacity 369 84 gallons 1400 litres External dimensions Width 59 05 1500 mm Depth with door closed 31 89 810 mm Depth with door open 57 60 1463 mm Height 80 71 2050 mm Compartment dimensions Width 23 62 23 62 600 600 mm Depth 26 18 665 mm Height 56 69 56 69 1440 1440 mm Rack dimensions 20 87 25 59 530x650 mm Power supply 120V single phase 60Hz Internal temp range a 28 F 50 F 2 C 10 C Internal temp range b 28 F 50 F 2 C 10 C Max room temp 109 4 F 43 C Total current absorbed 12A Refrigerant charge R134a a 0 529 Ibs 240 g Refrigerant charge R134a b 0 529 Ibs 240 g Refrigerant capacity R134a 1 396 W Refrigerant capacity R134a 841 W No and type of defrosts min 1 every 24 hours x max 30 At room temperature 104 F 40 C 1 At room temperature 89 6 F 32 C dew point 131 F 55 C and evaporat
10. a transpallet or fork lift truck to lift appliances Inserting the forks under the pallet lift the appliance and carry it to the place of installation making sure that the load is balanced WARNING during handling do not push or pull the unit it may tip over or be damaged B 1 1 2 Disposing of the packing Packing materials should be disposed of in accordance with the binding laws in the country where the appliance is to be used Recyclable plastic parts are marked as follows polythene outer wrapping instructions booklet bag polypropylene straps polystyrene foam corner pads tb PS 5 pressed board protective surround elements B 1 2 POSITIONING Install the equipment taking all the safety precau tions required for this type of operation also respecting the relevant fire prevention instruc tions Place the appliance in a ventilated room and away from heat sources such as radiators or air condi tioning systems in order to allow the cooling of the refrigerating unit components Never cover the condenser not even temporarily as this may jeopardise the operation of both the condenser and the appliance Make sure to position the appliance taking into consideration the space needed for door opening Pay particular attention to levelling of the floor on which the appliance stands in order to ensure its optimal operation level the appliance otherwise its operation
11. to SERVICE ALARMS press open Press the SERVICE ALARM stored in the electronic board If the elec button for 4 seconds now the display shows the first SERVICE S is brok di fad ALARM stored in the electronic board for example b1 door EIERE 89 Low chamber temperature button to display the next pg Low evaporator temperature tronic board has not stored other SERVICE ALARMS the dis play shows If nothing is pressed within 5 seconds we go out from SERVICE ALARMS C 1 7 5 ALARM MANAGEMENT HOW LONG ARE THE ALARMS RECORDED Whenever a high chamber temperature alarm occurs the Until you have seen the complete alarms list recorded After display shows the label TEMP and the buzzer is activated that they will remain stored till a new alarm occurs the reset will be automatic HOW TO KNOW IF AN ALARM HAS OCCURRED To reset the buzzer press the button for 1 blinking led of alarm button buzzer ON sound alarm second Whenever a type b service alarm occurs the display shows the label code of the alarm and the buzzer is activated Whenever a type E service alarm occurs the display shows the label code of the alarm and the buzzer is activated IT IS NECESSARY CONTACT TECHNICAL ASSISTANCE HOW CHECK THE ALARMS To reset the buzzer press the button for 1 until the second 47 C 1 7 6 HACCP ALARM RESET The maximum number of high chamber temperatu
12. under the supervision of a factory trained installer WARNING Theunit must be installed by personnel who are qualified to work with electricity and plumbing Improper installation can cause injury to personnel and or damage to the appliance The unit must be installed in accordance with applicable codes SAVE THESE INSTRUCTIONS 35 A 1 GENERAL INFORMATION A 1 1 FOREWORD The purpose of this manual is to provide the necessary informa tion for the correct installation operation use and maintenance of the appliance Consequently the manual and all the technical documentation enclosed with the appliance must be kept with the appliance at all times so that they can be consulted by the technician or end user It is important to inform the appliance user about regu lations concerning safety during and after installation Read the instructions in the manual carefully before carrying out any operation whatsoever on the appliance as they give impor tant information about the standards and rules governing its installation and safe use Improper installation adjustment alteration service or maintenance can cause property dam age injury or death Failure to observe the instructions in this manual when carrying out any operations on the appliance will relieve the manufacturer of all liability The manufacturer also declines any responsibility in the event of problems caused by the use of non original spare parts No part of this manual
13. 650 OU PARA ARMARIOS REMOTOS 1200 1400 DEDUAS TEMPERATURAS VANO SUP d 795 A TUYAU D ASPIRATION DIAM TRE EXT RIEUR 6 mm B TUYAU DE REFOULEMENT DIAM TRE EXT RIEUR 10 mm A TUBO DE ASPIRACI N DI METRO EXTERIOR 6 mm B TUBO DE DESCARGA DI METRO EXTERIOR 10 mm DIAGRAMFORPOSITIONINGOFPIPESFORREMOTEUNIT APPLICABLE FOR REMOTE CABINETS 550 650 WITH TWO TEMPERATURES OR FOR CABINETS 1200 1400 WITH SMALL CELL COMPARTMENT 350 SCHEMA POSIZIONAMENTO DEI TUBI PER GRUPPO REMO TO VALIDO PER ARMADI 550 650 A DUE TEMPERATURE OPPURE PER ARMADI 1200 1400 CON CELLETTA VANO 350 465 B A DUT 040 N 06 A SUCTION PIPE OUTSIDE DIAMETER 6 mm B DELIVERY PIPE OUTSIDE DIAMETER 10 mm A B TUBO DI ASPIRAZIONE DIAMETRO ESTERNO 6 mm TUBO DI MANDATA DIAMETRO ESTERNO 10 mm 23 SCH MA DE MISE EN PLACE DES TUYAUX POUR GROUPE DISTANCE VALABLE POUR LES ARMOIRES 550 650 A DEUX TEMPERATURES OU POUR LES ARMOIRES 1200 1400 AVEC PETITE CELLULE COMPARTIMENT 350 ESQUEMA DE MONTAJE DE LOS TUBOS PARA GRUPO REMOTO VALIDO PARA ARMARIOS 550 650 DE DOS TEMPERATURAS O PARA ARMARIOS 1200 1400 CON CAMARA PEQUENA COMPARTIMIENTO 350 VANO SUP 795 A TUYAU D ASPIRATION DIAM TRE EXT RIEUR 6 mm B TUYAU DE REFOULEMENT DIAM TRE EXT RIEUR 10 mm A TUBO DE ASP
14. E room temperature 89 6 F 32 C dew point 129 92 F 54 4 C and evaporation tem perature 44 96 F 7 2 C Automatic by means of electronic board Fish refrigerator model 369 84 gallons 1400 litres 1 door 2 doors 2 temperatures energy saving Gross capacity 369 84 gallons 1400 litres External dimensions Width 59 05 1500 mm Depth with door closed 31 89 810 mm Depth with door open 57 60 1463 mm Height 80 71 2112 mm Compartment dimensions Width 23 62 23 62 600 600 mm Depth 26 18 665 mm Height 56 69 26 10 26 10 1440 663 663 mm Rack dimensions 20 87 x25 59 530x650 mm Power supply 120V single phase 60Hz Appliance total power 490 W 390 W Internal temp range a 28 F 50 F 2 C 10 C Internal temp range b 28 F 50 F 2 C 10 C Max room temp 109 49 43 C Total current absorbed 12 of refrigerant R134a R134a Refrigerant charge 0 595 0 529 105 270 g 240 g Refrigerant capacity 526 W 396 W Refrigerant capacity 1137 W 841 W Defrost power 450 W 450 W No and type of defrosts min 1 every 24 hours x max 30 At room temperature 104 F 40 C 1 At room temperature 89 6 F 32 C dew point 131 F 55 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 6 F 32 C dew point 129 92 F 54 4 C and evaporation tem perature 44 96 F 7 2 C Automatic by means of electronic board
15. EMENT DES ALIMENTS CORRECT CARGA CORRECTA DE LOS ALIMENTOS IBN W CLEANING THE CABINET HOUSING AND ACCESSORIES PULIZIA DEL MOBILE E DEGLI ACCESSORI NETTOYAGE DE L APPAREIL ET DES ACCESSOIRES LIMPIEZA DEL ARMARIO Y ACCESORIOS Fig 8 Fig 10 ESPACES FONCTIONNELS ESPACIOS FUNCIONALES wu 092 6 001 Fig 12 Questa pagina e stata lasciata bianco intenzionalmente This page has been intentionally left blank Cette page est intentionnellement laiss e blanche Diese Seite wurde absichtlich leer gelassen Esta pagina ha sido dejada en blanco de manera intencional Denna sida har avsiktligt lamnats tom Tama sivu on tarkoituksella tyhja Denne side er med vilje efterladt blank Denne siden er med hensikt blank 32 TABLE OF CONTENTS SAFETY INSTRUCTIONS Page 35 A 1 GENERAL INFORMATIONN Page 36 Foreword WE Page 36 A 1 2 Intended use and limitations AN Page 36 O Cl a u nu Sup uta uu s aha usus s dag saa Su Sa Page 36 A 1 4 General safety rules AE Page 36 A 1 5 Customers responsibilities Page 36 1 6 Data plate POSItION vecina talado Aiden ee Page 36 A 1 7 Physical safety features hazards u a Page 36 A 1 8 Immediate inspect for shippin
16. HUKO TYPE PLUG C PILETTA PER LO SCARICO LIQUIDI DELLA CELLA DIAMETRO 0 69 17 5 I CAVOD ALIMENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO C BONDE POURL EVACUATION DES LIQUIDES DE LA CELLULE DIAM TRE 0 69 17 5 mm I C BLED ALIMENTATION LONGUEUR 137 79 3500 mm PRISE TYPE SCHUKO C DESAG E DE L QUIDOS DE LA C MARA DI METRO de 0 69 pulg 17 5 mm I CABLE DE ALIMENTACI N de 137 79 pulg 3500 mm DE LONGITUD ENCHUFE TIPO SCHUKO INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE REFRIGERATOR FREEZER 369 84 gallons 1400litres 1 DOOR 2 1 2 DOORS 2 TEMPERATURES FRIGORIFERO CONGELATORE 369 84 galloni 1400 litri 1 PORTA 2 2 PORTE 2 TEMPERATURE FRONT VIEW VISTA FRONTALE VUE DE FACE VISTA FRONTAL SCHEMA D INSTALLATION DIAGRAMA DE INSTALACION R FRIG RATEUR CONG LATEUR369 84 gallons 1400 litres 1 PORTE 2 2 PORTES 2 TEMPERATURES FRIGORIFICO CONGELADOR de 369 84 galones 1400 litros 1 PUERTA 2 MEDIAS PUERTAS 2 TEMPERATURAS SIDE VIEW VISTA LATERALE VUE DE COTE VISTA LATERAL H 12 1 4 311 mm Si 80 45 64 2050 VU 12 1 64 l 5 29 32 150 mm 3 15 64 52 19 32 L 3 15 64 3 57 64 21 39 64 6 3 8 82 mm 1336 82mm 99mm 549 mm 102 mm 59 1 16 i 31 57 64 J 1500 mm 10 mm _ 14 4 5 29 1 2 14 4 5 3 5 mm To mm 35 mm
17. ICONTROLLOVERSIONE FRIGORIFERO PANEL DE CONTROL DE REFRIGERADOR 1 2a 3a 4 7 8 9 MANUAL COMPRESSOR POWER SUPPLY DEFROST STATUS STATUS lt e ACCES HIGH HUM SERVICE TEMPERATURE HACCP POWER ON OFF FOOD 2 ON OFF ALARMS CATEGORY ALARMS SELECTION PRINT 7 DAYS E 3 1 Access to Food Categories button 1 Bouton ACCESS TO FOOD CATEGORIES 2 High humidity ON OFF button 2 Bouton HIGH HUMIDITY ON OFF 2a High humidity indicator light 2 T moin lumineux HIGH HUMIDITY 3 Service alarms button 3 Bouton SERVICE ALARMS Service alarms indicator light T moin lumineux SERVICE ALARMS 4 Manual defrost UP button 4 Bouton MANUAL DEFROST UP 5 Set temperature Category selection DOWN button 5 Bouton TEMPERATURE CATEGORY SELECTION 6 HACCP alarms button DOWN 7 Display 6 Bouton HACCP ALARMS 8 Compressor status indicator light 7 Affichage 9 Power supply status indicator light 8 T moin lumineux COMPRESSOR STATUS 10 Power ON OFF button 9 T moin lumineux POWER SUPPLY STATUS 10 Bouton ON OFF 5 2 1 Accesso al pulsante per le categorie degli alimenti 1 Acceso al bot n de categor as de alimento 2 Pulsante ON OFF elevata umidit 2 Bot n High humidity ON OFF 2 Spia elevata umidita 2a Luz indicadora de alta humedad 3 Pulsante allarmi di servizio 3 Bot n de alarmas de servicio 3a Spia allarmi di servizio 3a Luz indicadora de alarmas de
18. INSTALLATION OPERATING AND MAINTENANCE INSTRUCTIONS ISTRUZIONIDIINSTALLAZIONE FUNZIONAMENTO E MANUTENZIONE INSTRUCTIONS D INSTALLATION D UTILISATION ET DE MAINTENANCE INSTRUCCIONES DE INSTALACI N USO Y MANTENIMIENTO HEAVY DUTY SMART VERTICAL REFRIGERATOR FRIGORIFERO VERTICALE HEAVY DUTY SMART REFRIGERATEUR VERTICAL HEAVY DUTY SMART FRIGOR FICO VERTICAL HEAVY DUTY SMART USA Page 33 49 IT Pagina 50 67 FR Page 68 85 ES P gina 86 104 D d 4 d DOC NO 5957 409 02 us VERSION 3 2007 10 Listed TION INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE 171 71 gallons 650 It REFRIGERATOR FRIGORIFERO 171 71 galloni 650 litri FRONT VIEW VISTA FRONTALE VUE DE FACE VISTA FRONTAL SCHEMA D INSTALLATION DIAGRAMA DE INSTALACION R FRIG RATEUR de 171 71 gallons 650 litres FRIGOR FICO de 171 71 galones 650 litros SIDE VIEW VISTA LATERALE VUE DE COTE VISTA LATERAL 12 1 4 311mm th 80 45 64 2050 mm 14 49 64 5 29 32 12 1 64 375mm 150 mm 305 mm 3 15 64 23 5 64 3 15 64 3 57 64 2139 64 6 3 8 82 mm 586 mm 82mm 99 mm 549mm 162 mm 29 17 32 31 57 64 750mm 810 TOP VIEW VISTA SUPERIORE VUE DU DESSUS VISTA SUPERIOR 28 11 32 720mm 57 19 32 L o D 1463 mm 3 35 64 90 mm C OUTLET FOR DRAINING
19. IRACI N DI METRO EXTERIOR 6 mm B TUBO DE DESCARGA DI METRO EXTERIOR 10 mm DIAGRAMFORPOSITIONINGOFPIPESFORREMOTEUNIT SCHEMA DEMISE ENPLACE DES TUY AUX POUR GROUPE APPLICABLE FOR CABINETS 1200 1400 DISTANCE VALABLE POUR LES ARMOIRES 1200 1400 SCHEMA POSIZIONAMENTO DEI TUBI PER GRUPPO REMO ESQUEMA DE MONTAJE DE LOS TUBOS PARA GRUPORE TO VALIDO PER ARMADI 1200 1400 MOTO V LIDO PARA ARMARIOS 1200 1400 ESQUEMA DE POSICIONAMENTO DOS TUBOS PARA GRUPO REMOTO VALIDO PARA ARMARIOS 1200 1400 870 B40 DI 040 B P gt Y 000804 00000 190 120 310 S z Ir x LJ SUCTION PIPE OUTSIDE DIAMETER 6 mm A TUYAU D ASPIRATION DIAMETRE EXTERIEUR 6mm B DELIVERY PIPE OUTSIDE DIAMETER 10 mm B TUYAU DE REFOULEMENT DIAMETRE EXTERIEUR 10mm A TUBODIASPIRAZIONE DIAMETRO ESTERNO 6 mm TUBO DE ASPIRACI N DI METRO EXTERIOR 6 mm B TUBO DI MANDATA DIAMETRO ESTERNO 10 mm B TUBO DE DESCARGA DIAMETRO EXTERIOR 10 mm 24 REFRIGERATOR VERSION CONTROL PANEL PANNEAU DECOMMANDE VERSIONREFRIGERATEUR PANNELLOD
20. LIQUIDES DE LA CELLULE DIAM TRE 0 69 17 5 mm I C BLED ALIMENTATION LONGUEUR 137 79 3500 mm PRISE TYPE SCHUKO C DESAG E DE L QUIDOS DE LA C MARA DI METRO de 0 69 pulg 17 5 mm I CABLE DE ALIMENTACI N de 137 79 pulg 3500 mm DE LONGITUD ENCHUFE TIPO SCHUKO INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE FISH REFRIGERATOR 369 84 gallons 1400 litres 1 DOOR 2 1 2 DOORS 2 TEMPERATURES FRIGORIFERO ITTICO 369 84 galloni 1400 litri 1 POR 2 2 PORTE 2 TEMPERATURE FRONT VIEW VISTA FRONTALE VUE DE FACE VISTAFRONTAL SCH MA D INSTALLATION DIAGRAMA DE INSTALACION R FRIG RATEUR POISSON 369 84 gallons 1400 litres 1 PORTE 2 Y2PORTES 2 TEMPERATURES FRIGORIFICO DE PESCADO de 369 84 galones 1400 litros 1 PUERTA 2 MEDIAS PUERTAS 2 TEMPERATURAS SIDE VIEW VISTA LATERALE VUE DE COTE VISTA LATERAL H Cours Contes SC 311 R 80 45 64 2050 MM 12 1 64 5 29 32 305mm 150 mm 3 15 64 52 19 32 L 3 15 64 3 57 64 21 39 64 6 3 8 82mm 1336 82mm 99mm 549 mm 162 mm 59 1 16 31 57 64 1500 mm _ 14 4 5 29 1 2 14 4 5 _ 3 5 mm 150 mm T35 mm TOP VIEW VISTA SUPERIORE VUE DU DESSUS VISTA SUPERIOR 57 19 32 E 1463 mm C OUTLET FOR DRAINING OFLIQUIDSFROMCHAMBER DIAMETER0 69 17 5mm I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SC
21. MENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO I CABLE D ALIMENTATION LONGUEUR 137 79 3500 mm PRISE TYPE SCHUKO I CABLEDE ALIMENTACI N de 137 79 pulg 3500 mm DE LONGITUD ENCHUFE TIPO SCHUKO INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE 369 84 gallons 1400 It REFRIGERATOR FRIGORIFERO 369 84 galloni 1400 litri FRONT VIEW VISTA FRONTALE VUE DE FACE VISTA FRONTAL SCHEMA D INSTALLATION DIAGRAMA DE INSTALACION R FRIG RATEUR de 369 84 gallons 1400 litres FRIGOR FICO de 369 84 galones 1400 litros SIDE VIEW VISTA LATERALE VUE DE COTE VISTA LATERAL 1 A 12 1 4 311mm D Ki Dh 80 45 64 2050 mm 12 1 64 _ 5 29 32 305 mm 150 mm EER Je U 3 15 64 52 19 32 3 15 64 3 57 64 21 39 64 6 3 8 gt lt gt 82 mm 1336 mm 82 mm 99mm 549mm 102 mm 31 57 64 59 1 16 810 mm 1500 mm TOP VIEW VISTA SUPERIORE VUE DU DESSUS VISTA SUPERIOR 57 19 32 1463 mm C OUTLET FOR DRAINING OF LIQUIDS FROM CHAMBER DIAMETER0 69 17 5mm I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SCHUKO TYPE PLUG C PILETTAPER LO SCARICO LIQUIDI DELLA CELLA DIAMETRO 0 69 17 5 I CAVOD ALIMENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO C BONDEPOURL VACUATION DES LIQUIDES DE LA CELLULE DIAM TRE de 0 69 pulg 17 5 I C BLED ALIMENTATION LONGUEUR 137 79
22. NEL ONLY Non routine maintenance tasks must be performed by an AUTHORIZEDSERVICE AGENT USE APPROPRIATE SAFETY GEAR GLOVESANDMASK WHENCARRYING OUTANY MAINTENANCEOPERATION Lg ATTENTION donottouch the appliance if hands and or feet are wet Before performing any cleaning or maintenance disconnect the appliance from the electrical source and carefully unplug the appliance Do not remove safety guards Wear protective gloves when cleaning the condenser Do not use scissors screwdrivers and sharp objects on the cooling circuit D 2 1 PERIODIC CLEANING OF CONDENSER Periodic cleaning of the condenser unit depends on the fre quency of use of the appliance The condenser must be cleaned periodically to ensure the efficient operation of the appliance and its continued high performance over time It is DANGEROUS AND UNADVISEABLE to remove the safety guards It is advisable to thoroughly clean the condenser slits of the refrigerating unit at least once a month in a dusty envi ronment or once every three months in a closed and clean environment The condenser can be cleaned with a brush provided the bristles are not made of steel or a material that can compromise good operation or a vacuum cleaner to re move the dirt Take maximum care not to bend the condenser fins as this would cause a reduction in the heat exchange Do not use pointed objects as they may damage the condenser ATTENTION the condenser is installed on the top of the ap
23. OFLIQUIDSFROMCHAMBER DIAMETER0 69 17 5mm I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SCHUKO TYPE PLUG C PILETTA PER LO SCARICO LIQUIDI DELLA CELLA DIAMETRO 0 69 17 5 I CAVOD ALIMENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO C BONDE POURL EVACUATION DES LIQUIDES DE LA CELLULE DIAM TRE 0 69 17 5 mm I C BLED ALIMENTATION LONGUEUR 137 79 3500 mm PRISE TYPE SCHUKO C DESAG E DE L QUIDOS DE LA C MARA DI METRO de 0 69 pulg 17 5 mm I CABLE DE ALIMENTACI N de 137 79 pulg 3500 mm DE LONGITUD ENCHUFE TIPO SCHUKO INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE 171 71 gallons 650 It FREEZER CONGELATORE 171 71 galloni 650 litri FRONT VIEW VISTA FRONTALE VUE DE FACE VISTAFRONTAL 5 29 32 150 23 5 64 3 15 64 3 15 64 Va Ca 3 57 64 SCH MA D INSTALLATION DIAGRAMA DE INSTALACION CONG LATEUR de 171 71 gallons 650 litres CONGELADOR de 171 71 galones 650 litros SIDE VIEW VISTA LATERALE VUE DE COTE VISTA LATERAL 12 14 311mm th 80 45 64 2050 mm I _ 21 39 64 6 3 8 82 mm 586 mm 29 17 32 750mm 82mm 28 11 32 720mm 57 19 32 1403 mm 3 35 64 90mm 99 mm 549 mm 162 mm 31 57 64 810 mm VISTA SUPERIORE VUE DU DESSUS VISTASUPERIOR I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SCHUKO TYPE PLUG I CAVOD ALI
24. RECORDED starting and ending time and date of the alarm are shown by a rolling label TEMP 78 8F 26C Start 17 05 10 10 99 End To have access to recorded HACCP alarms press button for 4 seconds now the display shows HISt and then AL_1 symbol of the alarm this shows the last maximum chamber temperature alarm stored in the PCB button to display the value of last maxi mum chamber temperature alarm Now in the display we see TEMP 78 8F 26C type and value of maximum chamber temperature alarm Start time and date starting date and time of alarm display shows End time and date ending date and time of alarm C 1 7 4 SERVICE ALARMS LIST Type b service alarms Door is open Microswitch is broken Reset HACCP memor The condenser is dirty maximum chamber temperature alarm If nothing is pressed Condenser fan is broken within 10 seconds we exit from HACCP section Missing power supply HOW TO CHECK THE OLD ALARMS Wrong plug positioning E service alarms 1 Sensor short circuited amp Sensor is broken or disconnected HOW LONG ARE THE ALARMS RECORDED Forever or better until the memory is out of space maximum Sensor short circuited number of recorded alarms 99 Sensor is broken or disconnected C 1 7 3 SERVICE ALARMS ES Sensor short circuited pe Sensor is broken or disconnected Sensor short circuited To have access
25. RISE TYPE SCHUKO C DESAG E DE L QUIDOS DE LA C MARA DI METRO de 0 69 pulg 17 5 mm I CABLE DE ALIMENTACI N de 137 79 pulg 3500 mm DE LONGITUD ENCHUFE TIPO SCHUKO INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE REFRIGERATOR 369 84 gallons 1400 litres 2 TEMPERATURES FRIGORIFERO 369 84 galloni 1400litri2 TEMPERATU RE FRONT VIEW VISTA FRONTALE VUE DE FACE VISTA FRONTAL SCHEMA D INSTALLATION DIAGRAMA DE INSTALACION R FRIG RATEUR 369 84 gallons 1400 litres 2 TEMP RATURES FRIGOR FICO de 369 84 galones 1400 litros 2 TEMPERATURAS SIDE VIEW VISTA LATERALE VUE DE COTE VISTA LATERAL SE 311 mm Si 80 45 64 2050 mm 12 1 64 5 29 32 150 mm E U 3 15 64 52 19 32 L 3 15 64 3 57 64 71 e 678 82mm 1330 62mm 99mm 549 mm 162 mm 59 1 16 1500 mm 31270 14 4 5 29 12 14 45 375 mm 750mm 375 mm TOP VIEW VISTA SUPERIORE VUE DU DESSUS VISTASUPERIOR 57 19 32 77 1463mm C OUTLET FOR DRAINING OFLIQUIDSFROMCHAMBER DIAMETER0 69 17 5mm I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SCHUKO TYPE PLUG C PILETTA PER LO SCARICO LIQUIDI DELLA CELLA DIAMETRO 0 69 17 5 I CAVOD ALIMENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO C BONDE POURL EVACUATION DES LIQUIDES DE LA CELLULE DIAM TRE 0 69 17 5 mm I
26. Refrigerator model 171 71 gallons 650 litres remote unit 1door 2 1 2 doors Gross capacity 171 71 gallons 650 External dimensions Width 29 53 750 mm Depth with door closed 31 89 810 mm Depth with door open 57 60 1463 mm Height 80 71 2050 mm Compartment dimensions Width 23 62 600 mm Depth 26 18 665 mm Height 26 10 26 10 663 663 mm Rack dimensions 20 87 25 59 530x650 mm Power supply 20V single phase 60Hz Internal temp range a 28 F 50 F 2 C 10 C Internal temp range b 7 6 F 8 6 F 22 C 13 C Max room temp 109 4 F 43 C Total current absorbed 5A Refrigerant capacity R134A 1 1251 W Refrigerant capacity R134A 2 578 W No and type of defrosts min 1 every 24 hours 30 At room temperature 104 F 40 C At room temperature 89 6 F 32 C dew point 131 F 55 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 6 F 32 C dew point 129 92 F 54 4 C and evaporation temperature 44 96 7 2 Automatic means of electronic board Recommended condenser unit mod GP 12TE Compressor power Hp 3 8 Max dist cond unit vert refr m 15 Max ht diff cond unit vert refr m 3 Suction pipe cross section mm inside 0 6 Delivery pipe cross section mm inside 0 10 Greater distances require condenser units with greater power 39 Freezer model 171 71 gallons
27. TURE FRONT VIEW VISTA FRONTALE VUE DE FACE VISTA FRONTAL 14 49 64 i 375mm 5 29 32 150 mm J 3 15 64 23 5 64 3 15 64 82 mm 586 82mm L 29 17 32 J 750 MM A 28 11 32 720 mm Q 57 19 32 1463 mm K 3 35 64 90 mm SCHEMA D INSTALLATION DIAGRAMA DE INSTALACION REFRIGERATEUR 171 71 gallons 650 litres 2 gt 5 2TEMP RATURES FRIGOR FICO de 171 71 galones 650 litros 2 MEDIAS PUERTAS 2TEMPERATURAS SIDE VIEW VISTA LATERALE VUE DE COTE VISTA LATERAL 12 1 4 311 mm A e 80 45 64 2050 mm v 12 1 64 305 mm d L en gt 3 57 04 21 39 64 6 3 8 mm 549 mm 102 mm L 31 57 64 810mm TOP VIEW VISTA SUPERIORE VUE DU DESSUS VISTA SUPERIOR C OUTLET FOR DRAINING OFLIQUIDSFROMCHAMBER DIAMETER0 69 17 5mm I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SCHUKO TYPE PLUG C PILETTA PER LO SCARICO LIQUIDI DELLA CELLA DIAMETRO 0 69 17 5 I CAVOD ALIMENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO C BONDE POURL EVACUATION DES LIQUIDES DE LA CELLULE DIAM TRE 0 69 17 5 mm I C BLED ALIMENTATION LONGUEUR 137 79 3500 mm PRISE TYPE SCHUKO C DESAG E DE L QUIDOS DE LA C MARA DI METRO de 0 69 pulg 17 5 mm I CABLE DE ALIMENTACI N de 137 79 pulg 3500 m
28. TURE REFRIGERATOR FREEZER VERSION PANNELLO DI CONTROLLO VERSIONE FRIGORIFERO CONGELATORE 2 TEMPERATURE Fare riferimento alla pag 24 8 N e 8 3 O B Access to Food Categories button Service alarms button Service alarms indicator light Manual defrost UP button Set temperature Category selection DOWN button HACCP alarms button Display Compressor status indicator light Power supply status indicator light Power ON OFF button a 1 2 2 3 4 5 6 7 8 9 Accesso al pulsante per le categorie degli alimenti Pulsante degli allarmi di servizio Spie allarmi di servizio Pulsante superiore sbrinamento manuale Pulsante inferiore Impostazione temperatura Selezione categoria Pulsante allarmi HACCP Display Spia stato compressore Spia stato alimentazione Pulsante ON OFF 28 P OO N N OO t PANNEAUDECOMMANDE VERSION R FRIG RATEUR CONG LATEURA 2TEMP RATURES PANEL DE CONTROL DE FRIGORIFICO CONGELADOR DE2TEMPERATURAS 1 2 3 6 7 8 a Q Fig 4 1 Bouton ACCESS TO FOOD CATEGORIES 2 BoutonSERVICEALARMS 2a T moin lumineux SERVICE ALARMS 3 Bouton MANUAL DEFROST UP 4 Bouton TEMPERATURE CATEGORY SELECTION DOWN Bouton HACCP ALARMS Affichage T moin lumineux COMPRESSOR STATUS T moin lumineux POWER SUPPLY STATUS Bouton ON OFF OO Jo o Acceso al bot
29. allarmi di servizio Pulsante superiore sbrinamento manuale Pulsante inferiore Impostazione temperatura Selezione categoria Pulsante allarmi HACCP Display Spia stato compressore Spia stato alimentazione 0 Pulsante ON OFF D D D b k P G N N ch D D ON t PANNEAU DE COMMANDE VERSION R FRIG RATEUR 2TEMP RATURES PANEL DE CONTROL DE FRIGOR FICO DE 2 TEMPERATURAS 1 2 38 4 7 8 9 u Fig 3 1 Bouton ACCESS TO FOOD CATEGORIES 2 BoutonHIGH HUMIDITY ON OFF 2a T moin lumineux HIGH HUMIDITY 3 BoutonSERVICE ALARMS 3a T moin lumineux SERVICE ALARMS Bouton MANUAL DEFROST UP 5 Bouton TEMPERATURE CATEGORY SELECTION DOWN Bouton HACCP ALARMS T moin lumineux COMPRESSOR STATUS T moin lumineux POWER SUPPLY STATUS Bouton ON OFF A 90 rd OH o S Acceso al bot n de categor as de alimento Bot n High humidity ON OFF Luz indicadora de alta humedad Bot n de alarmas de servicio Luz indicadora de alarmas de servicio Bot n Manual defrost UP Bot n Set Category DOWN Bot n de alarmas HACCP Indicador Luz indicadora de estado del compresor Luz indicadora de estado del suministro el ctrico Bot n de encendido apagado ON OFF D D O QI P G OO N N CONTROLPANEL 2 TEMPERA
30. bility Before making any electrical connections to this appliance check that the power supply is adequate for the voltage amperage and phase requirements on the rating plate The customer also must provide a grounded electrical line cord of suitable capacity for the input specified on the data plate 36 A 1 6 DATA PLATE POSITION The data plate with all the appliance specifications is located on the refrigeration unit compartment at the top right hand side There is also a plate bearing the appliance s PNC code and serial number located underneath the logo A 1 7 PHYSICAL SAFETY FEATURES HAZARDS The appliance has no sharp or projecting parts DANGER DO NOT REMOVE There are guards on the units to prevent access to components which require air movement A1 8IMMEDIATEINSPECT FOR SHIPPING DAMAGE The container should be examined for damage before and during unloading The freight carrier has assumed responsi bility for its safe transit and delivery If damaged equipment is received either apparent or concealed a claim must be made with the delivering carrier Apparent damage or loss must be noted on the freight bill atthe time of delivery The freight bill must then be signed by the carrier representative Driver If the bill is not signed the carrier may refuse the claim The supplier can supply the necessary forms A request for inspection must be made to the carrier within 15 days if there is concealed damage or loss that is n
31. cial plastic caps B 1 5ELECTRICAL CONNECTION When making the electrical connection carefully comply with the information on the dataplate The appliance works on 120V 1ph 60Hz cautow Connection to the electrical mains must be carried out in accordance with current regulations and the standards re quired by the National Electric Code NEC 70 Please check Connection to the main power must be carried out in accord ance with binding rules and standards Before connecting make sure that The line cord has an efficient grounding connection and the main power frequency corresponds to that stated on the data plate If you have doubts on the efficiency of the grounding connection have the circuit checked by a qualified technician The appliance must be connected to the main power with a permanent connection In order to protect the appliance from possible overloads or short circuits a fused disconnect switch or a main circuit breaker customer furnished MUST be installed in the elec tric supply line for the appliance It is recommended that this switch circuit breaker have lockout tagout capability Before making any electrical connections to this appliance check that the power supply is adequate for the voltage amperage and phase requirements on the rating plate The customer also must provide a grounded electrical line cord of suitable capacity for the input specified on the data plate
32. could be mised Use the height adjustable feet to make sure the appliance is level and at the same time check that the door closes properly For trouble free operation of the appliance it is recommended that a gap of at least 19 68 500mm be left between the appli ance and the ceiling Should the appliance be installed in rooms where there are corrosive substances chlorine etc it is advisable to go over all the stainless steel surfaces with a cloth coated with vaseline oil in order to form a protective film The maximum ambient temperature at which the appliances may operate is 109 4 F 43 C 667001 Note the power plug should accessible even after having placed the appliance in its final position for installation 42 B 1 3 REVERSING OPENING OF DOORS Fig 5 Single door refrigerated cupboards are normally supplied with right opening When changing to left opening proceed as follows disconnect from the power supply open the control panel loosening the 2 screws located be tween the panel and the door undo the 2 screws fixing bracket A and the screw fixing hinge B Detail 1 remove the door the hinge B and the component E then reverse their assembly remove the lower bracket D refitting it in the special seat on the opposite side Detail 2 position the door on the lower bracket D position the upp
33. d High RU average humidity reading with ambient temperature 109 4 F 43 C chamber temperature 35 6 F 2 C R H 80 With button released Low RU average humidity reading with ambient temperature 109 4 F 43 C chamber temperature 35 6 F 2 C R H 66 C 1 5 LOADING THE PRODUCT Food must be evenly distributed inside the chamber away from the door and back wall in order to allow proper circulation of air weg jf O C CO tooo cm i o t oogt ue A COCO I There is a sticker inside the chamber indicating the maximum level of loading A Cover or wrap food before placing it in the refrigerator avoid putting hot foods or steaming liquids inside Do not leave the door open longer than necessary when putting in or taking out products It is advisable to keep the keys in a place accessible only to authorized personnel In order to avoid the use of the appli ance by non authorized people it is advisable to lock it C 1 6 DEFROSTING Automatic defrosting The appliance is equipped with an automatic defrost function This function is indicated by the dEFr indicator light Defrost water is routed to a bowl from where it evaporates automatically Manual d
34. d initial startup should be performed by a qualified installer Unless the installation instructions for this product are followed by a qualified service technician a person experienced in and knowledgable with the installation of commercial equip ment then the terms and conditions on the Manufacturer s Warranty will be rendered void and no warranty of any kind shall apply EE IFINDOUBTPLEASECONTACTLOCAL SERVICE KIC AGENCY A the operations described below should be carried out in com pliance with current safety regulations with reference both to the equipment used and the operating procedures CAUTION IMPORTANT before moving the appliance make sure that the load bearing capacity of the lifting equipment to be used is suitable for the weight of the appliance B 1 1 REMOVING THE PACKAGING B 1 1 1 Removing the packaging and handling Cut the straps and remove the protective film taking care not to scratch the sheet metal if scissors or blades are used Remove the top in cardboard the polystyrene corners and the vertical protection pieces For appliances with stainless steel cabi nets carefully remove the protective film without tearing it to avoid leaving glue stuck to the surface Should this happen remove the traces of glue with a non corrosive solvent rinsing it off and drying carefully Itis advisable to go over all the s steel surfaces with a rag soaked in vaseline oil in order to form a protective film Use
35. dimensions Width 23 62 600 mm Depth with door closed 26 18 665 mm Depth with door open 47 24 1200 mm Height 83 15 2112 mm Compartment dimensions Width 21 26 540 mm Depth 21 65 550 mm Height 58 42 1484 mm Rack dimensions 20 87 x15 75 530x400 mm Power supply 120V single phase 60Hz Internal temp range 11 2 F 5 F 24 C 15 C Max room temp 109 4 F 43 C Current absorbed 10A Refrigerant capacity R404A 1 1823 W Refrigerant capacity R404A 2 1196 W No and type of defrosts min 1 every 12 hours x max 30 At room temperature 104 F 40 C 1 At room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 9 94 F 23 3 C Automatic by means of electronic boar Recommended condenser unit mod GP14TE Compressor power Hp 1 Max dist cond unit vert refr m 15 Max ht diff cond unit vert refr m 3 Suction pipe cross section mm inside 12 7 Delivery pipe cross section mm inside 0 9 5 Greater distances require condenser units with greater power Refrigerator freezer model 369 84 gallons 1400 litres 1 door 2 1 2 doors 2 temperatures energy saving Gross capacity 369 84 gallons 1400 litres External dimensions Width 59 05 1500 mm Depth with door closed 31 89 810 m
36. efrosting The defrost cycle can be activated manually by pressing the MANUAL DEFROST UP button for 5 seconds During this function the dEFr indicator light stays on C 1 7 ALARMS C 1 7 1 General description We have available in the electronic board 2 types of alarm system the HACCP the SERVICE ALARMS The HACCP stores and manages the MAXIMUM CHAMBER HIGH TEMPERATURE ALARMS The SERVICE ALARMS stores and manages all the alarms available in the electronic board except the chamber high temperature alarm C 1 7 2 HACCP ALARM CONDITIONS the display shows an alarm by the label TEMP pushing you get information on maximum temperature time and date day month and year whwn alarm occured There are two possible situations a the alarm is running b the alarm has occured a the alarm is running 77 25 Temperature F C 68 20 59 15 50 10 41 5 Critical temperature HOW TO CHECK IT display rolling label i e TEMP 78 8F 26 buzzer sound alarm ON WHAT IS RECORDED date are shown by a rolling label TEMP 78 8F 26C Start 17 05 10 10 99 End b the alarm has occured 77 25 Temperature F C 68 20 59 15 50 10 41 5 Critical temperature 16 00 17 00 18 00 19 00 20 00 21 00 22 00 HOW TO CHECK IT display is showing the label TEMP buzzer sound alarm ON WHAT IS
37. er bracket A between the door and the top of the equipment screwing the fixing bolts before tightening the screws align the door with respect to the side of the unit operating the lower and upper brackets and checking correct fitting of the seal on all sides of the unit e then tighten the bracket fixing bolts reconnect the power supply B 1 4 REVERSING OPENING OF HALF DOORS Fig 6 Single door refrigerated cupboards are normally supplied with right opening When changing to left opening proceed as follows disconnect the power supply open the control panel loosening the 2 screws located be tween the panel and door undo the 2 fixing screws of bracket and the fixing screw of hinge B e remove the door remove the middle bracket F and remove the bottom door e remove the lower bracket A refitting it on the opposite side in the special seat position the bottom door on the lower bracket A e fix the middle bracket F position the top door on the middle bracket F fix the upper bracket between the door and the roof of the unit screwing the fixing bolts before tightening the screws align the door with the side of the cabinet by moving the lower and upper brackets checking correct fitting of the seal on all sides of the cabinet e then tighten the bracket fixing bolts Note After carrying outthe above operations close the holes on the unit with the spe
38. er having carried out the checks de scribed above contact the service center giving e the nature of the defect e the PNC production code of the appliance e the Ser No serial number of the appliance Note the code and the serial number are indispensable to be able to trace the type of appliance and the date of manufacture PNC 726356 Ser No 44600010 Be E g PNC 726356 Ser No 44600010 726356 Heavy Duty cabinet R134a 44600010 manufactured in 2004 week 46 10th item D 4 WASTE DISPOSAL AND DEMOLITION D 4 1 WASTE STORAGE At the end of the appliance s working life make sure it is dis posed of properly Make sure you remove the doors before scrapping the appliance Special waste materials can be stored temporarily while await ing processing for disposal and or permanent disposal In any event the binding environmental protection laws in the country of use must be observed D 4 2 PROCEDURE FOR PRELIMINARY DISMANTLING OF THE APPLIANCE All countries have different legislation provisions laid down by the laws and the authorized bodies of the countries where demolition takes place are therefore to be observed In general terms the refrigerator must be taken to a special ized collection demolition center Dismantle the refrigerator and group the components together according to their chemical characteristics plastic parts are marked with letters identifying the material Bear in mind that the compre
39. g damage Page 36 2 TECHNICAL DATA uuu Page 36 A 2 1 Materials and fluids Page 36 A 2 2 Dimensions performance and CONSUMPTION coooccccnoncccnoncnnnananonanononnnnnnnnarononana nano Page 36 Bal INSTALLATION J J J Page 41 B 1 1 Removing the packaging U U Page 41 B 1 1 1 Removing the packaging and handling Page 41 B 1 1 2 Disposing of the packing lt lt lt Page 41 B 12 Positioning so aici ee ot dee a Page 42 B 1 3 Reversing opening of the doors U uu uu u Page 42 B 1 4 Reversing opening of half doors 2 Page 42 8 1 5 u u u uuu u a SA Qusa Page 43 1 6 Water connection u a Page 43 C 1 OPERATIONS and USER INSTRUCTIONS Page 43 G Control panels el Page 43 C 1 1 1 Refrigerator version Control panel a Page 43 C 1 1 2 Freezer version control panel A Page 43 C 1 2 Initial switch on and temperature Page 43 C 1 3 Storage using catergories button Page 45 C 1 4 High humidity ON OFF upon Page 45
40. ion temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 6 F 32 C dew point 129 92 F 54 4 C and evaporation tem perature 44 96 F 7 2 C Automatic by means of electronic board Refrigerator freezer model 369 84 gallons 1400 litres 2 tem peratures energy saving Gross capacity 369 84 gallons 1400 External dimensions Width 59 05 1500 mm Depth with door closed 31 89 810 mm Depth with door open 57 60 1463 mm Height 80 71 2050 mm Compartment dimensions Width 23 62 23 62 600 600 mm Depth 26 18 665 mm Height 56 69 56 60 1440 1440 mm Rack dimensions 20 87 25 59 530x650 Power supply 120V single phase 0Hz Internal temp range a 28 F 50 F 2 C 10 C Internal temp range b 11 2 F 5 F 24 C 15 C Max room temp 109 4 F 43 C Total current absorbed 16A Refrigerant charge R134a a 0 529 lbs 240 g Refrigerant charge R404A b 0 551 lbs 250 g Refrigerant capacity R134a R404A 1 396 W 1721 W Refrigerant capacity R404A 2 882 W Refrigerant capacity R134a 841 W No and type of defrosts min 1 every 12 hours x max 30 At room temperature 104 40 1 At room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation tem perature 9 94 F 23 3 C ASHRAE PERFORMANC
41. m Depth with door open 57 60 1463 mm Height 80 71 2112 mm Compartment dimensions Width 23 62 23 62 600 600 mm Depth 26 18 665 mm Height 56 69 26 10 26 10 1440 663 663 mm Rack dimensions 20 87 x25 59 530x650 mm Power supply 120V single phase 60Hz Appliance total power 490 W 390 W Internal temp range a 28 F 50 F 2 C 10 C Internal temp range b 11 2 F 5 F 24 C 15 C Max room temp 109 4 F 43 C Total current absorbed 16A Type of refrigerant R134a R404A Refrigerant charge R134a R404A 0 595 Ibs 0 551 Ibs 270 g 250 g Refrigerant capacity R134a R404A 526 W 1721 W Refrigerant capacity R404A 882 W Refrigerant capacity R134a 1137 W Defrost power 450 W 450 W and type of defrosts min 1 every 12 hours x max 30 At room temperature 104 F 40 C 1 At room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation tem perature 9 94 F 23 3 C ASHRAE PERFORMANCE room temperature 89 6 F 32 C dew point 129 92 F 54 4 C and evaporation tem perature 44 96 F 7 2 C Automatic by means of electronic board 41 B 1 INSTALLATION WEAR PROTECTIVE GLOVES WHEN UN PACKINGANDINSTALLING THEAPPLIANCE Read these instructions carefully before at tempting installation Installation an
42. m DE LONGITUD ENCHUFE TIPO SCHUKO INSTALLATIONDIAGRAM SCHEMA D INSTALLAZIONE REFRIGERATOR FREEZR 171 71 gallons 650litres 21 2 DOORS 2 TEMPERATURES FRIGORIFERO CONGELATORE 171 71 galloni 650 litri 2 PORTE 2 TEMPERATURE FRONT VIEW VISTA FRONTALE VUE DE FACE VISTA FRONTAL Doade ebe e OU 5 29 32 150 mm 3 15 64 23 5 64 3 15 64 82 mm 586 mm 82 mm 29 17 32 50mm 28 11 32 120 51 19 32 ch 1403 mm 3 35 64 90 mm SCH MA D INSTALLATION DIAGRAMA DE INSTALACION R FRIG RATEUR CONG LATEUR 171 71 gallons 650 litres 2 2 PORTES 2 TEMP RATURES FRIGOR FICO CONGELADOR de 171 71 galones 650 litros 2 MEDIAS PUERTAS 2 TEMPERATURAS SIDE VIEW VISTA LATERALE VUE DE C T VISTA LATERAL 12 1 4 311 mm 1 y fh 80 45 64 2050 mm b SI 3 57 64 21 39 64 6 3 8 99 mm 549 mm 102 mm 31 57 64 810mm TOP VIEW VISTA SUPERIORE VUE DU DESSUS VISTA SUPERIOR C OUTLET FOR DRAINING OFLIQUIDSFROMCHAMBER DIAMETER0 69 17 5mm I POWER SUPPLY CABLE LENGTH 137 79 3500 mm SCHUKO TYPE PLUG C PILETTA PER LO SCARICO LIQUIDI DELLA CELLA DIAMETRO 0 69 17 5 I CAVOD ALIMENTAZIONE LUNGHEZZA 137 79 3500 mm PRESA TIPO SCHUKO C BONDE POURL EVACUATION DES LIQUIDES DE LA CELLULE DIAM TRE 0 69 17 5 mm I C BLED ALIMENTATION LONGUEUR 137 79 3500 mm P
43. may be reproduced A 1 2 INTENDED USE AND LIMITATIONS This appliance has been designed for the refrigeration and preservation of foodstuffs Any other use is to be considered improper ATTENTION these appliances are not suitable for installation outdoors and or in environments subject to natural elements rain direct sunlight etc The manufacturer declines all liability for any improper use of the product A 1 3TESTING Our appliances have been designed and optimised with labo ratory testing to give high performance and efficiency The product has gone through 100 testing and is ready for use The certificates guaranteeing that the tests visual inspection electrical test functional test have been passed are included with the appliance and are included in specific enclosures section D 5 A 1 4 GENERALSAFETY RULES The appliance is manufactured in compliance with the following directives Hygiene ANSI NSF7 Safety ANSI UL 471 CAN CSA 22 2 No 120 M91 Current regulations in force are applicable For models A RH06RE1FEU RH06FE1FEU RH14RE2FEU RH14FE2FEU RH14DD2FU RH14DFD2FU RH14DD3U RH14DFD3U RH06RE2HU RH06FE2HU RH14RE4HU RH14FE4HU A 1 5CUSTOMER S RESPONSIBILITIES A fused disconnect switch or a main circuit breaker customer furnished MUST be installed in the electric supply line for the appliance It is recommended that this switch circuit breaker have lockout tagout capa
44. mote unit 2 doors 4 1 doors Gross capacity 369 84 gallons 1400 litres External dimensions Width 23 62 600 mm Depth with door closed 26 18 665 mm Depth with door open 47 24 1200 mm Height 83 15 2112 mm Compartment dimensions Width 21 26 540 mm Depth 21 65 550 mm Height 58 42 1484 mm Rack dimensions 20 87 x15 75 530x400 mm Power supply 120V single phase 60Hz Internal temp range 11 2 F 5 F 24 C 15 C Max room temp 109 4 F 43 C Current absorbed 10A Refrigerant capacity R134A 1 1401 W Refrigerant capacity R134A 2 640 W No and type of defrosts min 1 every 24 hours x max 30 At room temperature 104 F 40 C 1 At room temperature 89 6 F 32 C dew point 131 F 55 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 6 F 32 C dew point 129 92 F 54 4 C and evaporation temperature 44 96 F 7 2 C Automatic by means of electronic board Recommended condenser unit mod GP14TE Compressor power Hp 3 8 dist unit refr m 15 Max ht diff cond unit vert refr m 3 Suction pipe cross section mm inside 9 5 Delivery pipe cross section inside 6 35 Greater distances require condenser units with greater power 40 Freezer model 369 84 gallons 1400 litres remote unit 2 doors 4 1 2 doors Gross capacity 369 84 gallons 1400 litres External
45. n de categor as de alimento Bot n de alarmas de servicio Luz indicadora de alarmas de servicio Bot n Manual defrost UP Bot n Set Category DOWN Bot n de alarmas HACCP Indicador Luz indicadora de estado del compresor Luz indicadora de estado del suministro el ctrico Bot n de encendido apagado ON OFF D O O QI N REVERSING OPENINGOF THEDOORS INVERSIONEAPERTURA DELLEPORTE 1 INVERSION DU SENS D OUVERTURE DES PORTES CAMBIO DE DIRECCION DE APERTURA DE LAS PUERTAS DET 2 Fig 5 29 REVERSING OPENINGOF HALFDOORS INVERSIONDUSENSD OUVERTUREDESDEMI PORTES INVERSIONEAPERTURA DELLE MEZZE PORTE INVERSION DEL SENTIDO DE APERTURA DE LAS ME DIAS PUERTAS 1 Fig 6 INCORRECTDISTRIBUTIONOF FOOD CARICONONCORRETTO DEGLIALIMENTI CHARGEMENTDESALIMENTSINCORRECT CARGAINCORRECTA DELOS ALIMENTOS Fig 7 CLEANING OF THE CONDENSER PULIZIA PERIODICA DEL CONDENSATORE NETTOYAGE PERIODIQUE DU CONDENSEUR LIMPIEZA PERI DICA DEL CONDENSADOR Fig 9 FUNCTIONALSPACES SPAZI FUNZIONALI CORRECT DISTRIBUTION OF FOOD CARICO CORRETTO DEGLI ALIMENTI CHARG
46. n lumineux POWER SUPPLY STATUS Bouton ON OFF Accesso al pulsante per le categorie degli alimenti Pulsante degli allarmi di servizio Spie allarmi di servizio Pulsante superiore sbrinamento manuale Pulsante inferiore Impostazione temperatura Selezione categoria Pulsante allarmi HACCP Display Spia stato compressore Spia stato alimentazione Pulsante ON OFF D P OQ N N ch E Oh O G N ch E 26 Acceso al bot n de categor as de alimento Bot n de alarmas de servicio Luz indicadora de alarmas de servicio Bot n Manual defrost UP Bot n Set Category DOWN Bot n de alarmas HACCP Indicador Luz indicadora de estado del compresor Luz indicadora de estado del suministro el ctrico Bot n de encendido apagado ON OFF CONTROL PANEL 2 TEMPERATURE REFRIGERATOR VERSION PANNELLO DI CONTROLLO VERSIONE FRIGORIFERO 2 TEMPERATURE 1 2a 38 4 7 8 9 RIRS B Access to Food Categories button High humidity ON OFF button High humidity indicator light Service alarms button Service alarms indicator light Manual defrost UP button Set temperature Category selection DOWN button HACCP alarms button Display Compressor status indicator light Power supply status indicator light Power ON OFF button Accesso al pulsante per le categorie degli alimenti Pulsante ON OFF elevata umidit Spia elevata umidit Pulsante allarmi di servizio Spia
47. nd 369 84 gallons 1400 It Refrigerator models Position MIN 28 2 C Position MAX 50 F 10 G 44 171 71 gallons 650 It and 369 84 gallons 1400 It Freezer models Position MIN Position MAX 8 F 22 G 9 13 C 1 3STORAGE USING CATEGORIES BUTTON By selecting the CATEGORY of food to be preserved the ap pliance creates the right balance between temperature and humidity in the chamber for optimum preservation of the par ticular product stored For Refrigerator models there are 4 pre set categories CATEGORY n 1 red meat CATEGORY n 2 cheese and meat dishes CATEGORY n 3 fruit and vegetables CATEGORY n 4 drinks For Freezer models there are 2 pre set categories CATEGORY n 1 frozen food CATEGORY n 2 ice cakes Keeping button pressed down will display the selected cat egory if NONE is displayed this means that the function is disa bled To select the category press MANUAL DEFROST UP or SET DOWN button 45 once selected if a selection is not made after 5 seconds the last category displayed will be confirmed automatically and stored C 1 4 HIGH HUMIDITY ON OFF BUTTON only for Refrigerator models HIGH HUMIDITY ON OFF button can be pressed to make the appliance operate with a high humidity level An indicator light comes on when the high humidity function is selected With button presse
48. ocedure for preliminary dismantling of the appliance Page 49 D 5 ENCLOSED DOCUMENTS Page 49 34 SAFETY INSTRUCTIONS To reduce the risk of fire electrical shock or injury when using your appliance please follow these basic precautions particularly the following Read all instructions before using your appliance This manual does not cover every possible condition and situation that may occur Use common sense and caution when installing operating and maintaining this appliance FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER SIMILAR APPLIANCE The installation of this unit must conform to local codes or in the absence of local codes to all National Codes governing plumbing sanitation safety and good trade practices BEFORE SERVICING DISCONNET THE ELECTRICAL SERVICE AND PLACE ARED TAG AT THE DISCONNECT SWITCH TO INDICATE WORK IS BEING DONE ON THAT CIRCUIT NOTICE CONTACT YOUR AUTHORIZED SERVICE COMPANY TO PERFORM MAINTENANCE AND REPAIRS NOTICE Using any parts other than genuine factory manufactured parts relieves the manufacturer of all warranty and liability NOTICE Manufacturer reserves the right to change specifications at any time without notice WARNING The appliance warranty is not valid unless the appliance is installed started and demonstrated
49. ot apparent until after the equipment is uncrated The carrier should arrange an inspection Be certain to hold all contents plus all packing material Under no circumstances should a damaged appliance be returned to the manufacturer without prior notice and written authorization A 2 TECHNICAL DATA A 2 1 MATERIALS AND FLUIDS USED All areas designed to come into contact with food are in steel or covered in non toxic plastic material An HFC refrigerant in compliance with current legal standards is used in the refrig erating units The type of refrigerant gas used is stated on the data plate A 2 2 DIMENSIONS PERFORMANCE AND CONSUMPTION Refrigerator model 171 71 gallons 650 litres 1 fully insulat ed door 1 fully insulated door energy saving 2 Y fully insulated doors Gross capacity 171 71 gallons 650 litres External dimensions Width 23 62 600 mm Depth with door closed 26 18 665 mm Depth with door open 47 24 1200 mm Height 83 15 2112 mm Compartment dimensions Width 21 26 540 mm Depth 21 65 550 mm Height 58 42 1484 mm Rack dimensions 20 87 x15 75 530x400 mm Power supply 120V single phase 60Hz Internal temp range 28 F 50 F 2 C 10 C Max room temp 109 4 F 43 C Current absorbed 6A Refrigerant charge R134a 0 529 lbs 240 y Refrigerant capacity R134a 396 W Refrigerant capacity R134a 2 841 W No and type of defrosts min 1 every 24 hours x max 30 9 At room tempera
50. pliance Do not clean the appliance with jets of water D 2 2 REPLACING THE CONTROL PANEL BULB To replace the light bulb under the control panel proceed as follows disconnect from the power supply remove the light bulb protective cover loosening the self tapping screw replace the bulb with one of the same wattage or equal to that indicated on the rating plate replace the protective cover connect to the power supply D 2 3 REPLACING THE POWER SUPPLY CABLE To replace the power supply cable proceed as follows disconnect from the power supply remove the electrical wiring protective cover replace the power supply cable refit the protective cover reconnect to the power supply D 3 TROUBLESHOOTING D 3 1 QUICK TROUBLESHOOTING GUIDE In some cases faults can be remedied easily and quickly Below there is a list of possible faults and remedies A The appliance does not start check that the plug is properly inserted into the socket check that there is voltage at the socket B The internal temperature is too high check the thermostat setting check for a heat source in the vicinity check that the door closes properly C The appliance is excessively noisy check that the appliance is standing level A lopsided appliance could set off vibrations check that the appliance is not touching other appliances or parts which could resonate If the defect persists aft
51. rd Refrigerator model 369 84 gallons 1400 litres 2 fully insu lated doors 2 fully insulated doors energy saving 4 1 2 ful ly insulated doors Gross capacity 369 84 gallons 1400 litres External dimensions Width 23 62 600 mm Depth with door closed 26 18 665 mm Depth with door open 47 24 1200 mm Height 83 15 2112 mm Compartment dimensions Width 21 26 540 mm Depth 21 65 550 mm Height 58 42 1484 mm Rack dimensions 20 87 x15 75 530x400 mm Power supply 120V single phase 60Hz Internal temp range 28 F 50 F 2 C 10 C Max room temp 109 4 F 43 C Current absorbed 12A Refrigerant charge R134a 0 771 lbs 350 g Refrigerant capacity R134a 1 525 W Refrigerant capacity R134a 2 1137 W No and type of defrosts min 1 every 24 hours x max 30 At room temperature 104 F 40 C 1 At room temperature 89 6 F 32 C dew point 131 F 55 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 6 F 37 32 C dew point 129 92 F 54 4 C evaporation tem perature 44 96 F 7 2 C Automatic by means of electronic board Freezer model 369 84 gallons 1400 litres Gross capacity 369 84 gallons 1400 litres External dimensions Width 23 62 600 mm Depth with door closed 26 18 665 mm Depth with door open 47 24 1200 mm Height 83 15 2112 mm Compartment dimensions Width 21 26 540 mm Depth 21 65 550 mm Height
52. re alarms recordable is 99 Whenever the memory is full and a b2 alarm occurs or at the end of the year it is necessary to reset the memory in the following way press the appears button until the label HiSt will keep pressed together the buttons until the display shows RES C 1 7 7 TROUBLESHOOTING GUIDE problems which can be solved immediately LABEL PROBLEM ACTION The door is open or microswitch is broken HACCP memory is full High temperature of condenser Power failure Check the door if it s ok contact technical assistance center Reset HACCP memory Check the condenser if it s clean or uncovered contact technical assistance center Check the power supply if it s ok contact technical assistance center 48 D 1 ROUTINE MAINTENANCE Routine maintenance tasks can be performed by non special ised personnel When performing maintenance please follow the instructions closely and take great care to The manufac turer declines any responsibility for injury sustained from unsafe acts A ATTENTION donottouch the appliance if hands and or feet are wet Before performing any cleaning or maintenance disconnect the appliance from the electrical source and carefully unplug the appliance Itis DANGEROUS AND UNADVISEABLE to remove the safety guards AND IS NOT REQUIRED for routine mainte nance Wear protective gloves Do not use scissors screw driver
53. rge R134a a 0 462 lbs 2109 Refrigerant charge R134a b 0 396 lbs 180 g Refrigerant capacity R134a 260 W 260 W Refrigerant capacity R134a 2 556 W 556 W No and type of defrosts min 1 every 24 hours x max 30 At room temperature 104 F 40 C 1 At room temperature 89 6 F 32 C dew point 131 F 55 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 6 F 32 C dew point 129 92 F 54 4 C and evaporation tem perature 44 96 F 7 2 C Automatic oy means of electronic board Refrigerator freezer model 171 71 gallons 650 litres 2 Y doors 2 temperatures Gross capacity 171 71 gallons 650 External dimensions Width 29 53 750 mm Depth with door closed 31 89 810 mm Depth with door open 57 60 1463 mm Height 80 71 2050 mm Compartment dimensions Width 23 62 600 mm Depth 26 18 665 mm Height 26 10 26 10 663 663 mm Rack dimensions 20 87 25 59 530x650 Power supply 120V single phase 0Hz Internal temp range a 28 F 50 F 2 C 10 C Internal temp range b 7 6 F 8 6 F 22 C 13 C Max room temp 109 4 F 43 C Total current absorbed 12A Refrigerant charge R134a a 0 462 lbs 210 g Refrigerant charge R404A b 0 275 lbs 125 g Refrigerant capacity R134a R404A 1 260 W Refrigerant capacity R404A 2 717 W Refrigerant capacity R134a 556 W No and type of defrosts min 1 every 12 hours x max 30
54. s and sharp objects on the cooling circuit D 1 1 CLEANING THE CABINET AND ACCESSORIES Before using the unit clean all the internal parts and accessories with warm water and either neutral soap or products that are over 90 biodegradable in order 7 to reduce the emission of pol lutants into the environment then rinse and dry thoroughly Do not use solvent based detergents e g trichloro ethylene or abrasive powders for cleaning Coat the metal panels with protective vaseline oil D 1 2 CLEANING THE CHAMBER To clean the chamber remove the plug from the drain outlet and let the water flow into the drain It is advisable to clean the chamber every week increasing this frequency according to appliance use D 1 3 PRECAUTIONS IN THE EVENT OF PROLONGED DISUSE If the appliance is not going to be used for a long period take the following precautions e switch the appliance off using the ON OFF button e disconnect the circuit breaker installed upline of the appli ance remove all food from the chamber and clean the interior and the accessories e leave the door ajar so that air can circulate inside the cham ber preventing the formation of unpleasant odors and mold all the stainless steel surfaces vigorously with a cloth slightly dampened with vaseline oil so as to cover them with a protective film e make sure that the premises are aired regularly D 2 MAINTENANCE TO BE PERFORMED BY TRAINED PERSON
55. servicio 4 Pulsante superiore sbrinamento manuale 4 Bot n Manual defrost UP 5 Pulsante inferiore Impostazione temperatura 5 Bot n Set Category DOWN Selezione categoria 6 Bot n de alarmas HACCP 6 Pulsante allarmi HACCP 7 Indicador 7 Display 8 Luz indicadora de estado del compresor 8 Spia stato compressore 9 Luz indicadora de estado del suministro el ctrico 9 Spia stato alimentazione 10 Bot n de encendido apagado ON OFF 10 Pulsante ON OFF 25 FREEZER VERSION CONTROL PANEL PANNEAU DE COMMANDE VERSION CONGELATEUR PANNELLO DICONTROLLO VERSIONE PANEL DE CONTROL DE CONGELADOR CONGELATORE MANUAL DEFROST ACCESS T SERVICE TEMPERATURE FOOD CATEGORIES ALARMS CATEGORY SELECTION PRINT 7 DAYS REPORT COMPRESSOR SUPPLY STATUS STATUS HACCP POWER ON OFF ALARMS E 3 Access to Food Categories button Service alarms button Service alarms indicator light Manual defrost UP button Set temperature Category selection DOWN button HACCP alarms button Display Compressor status indicator light Power supply status indicator light Power ON OFF button 2 E 1 OO N N o O O Q P G N N 1 Bouton ACCESS FOOD CATEGORIES Bouton SERVICE ALARMS T moin lumineux SERVICE ALARMS Bouton MANUAL DEFROST UP Bouton TEMPERATURE CATEGORY SELECTION DOWN Bouton HACCP ALARMS Affichage T moin lumineux COMPRESSOR STATUS T moi
56. ssor contains lubricant oil and coolant which can be recycled and that the refrigerator components are classed as special waste that cannot be disposed of as urban waste Make the appliance unusable by cutting off the power supply cable and removing the door and or locking mechanisms in order to avoid the risk of anyone becoming trapped inside DISMANTLING OPERATIONS MUST BE CARRIED OUT BY QUALIFIED PERSONNEL D 5 ENCLOSED DOCUMENTS Set of test and inspection documents e Wiring diagram 49 Installation diagram
57. ture 104 F 40 C 1 At room temperature 89 6 F 32 C dew point 131 F 55 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 6 F 32 C dew point 129 92 F 54 4 C and evaporation temperature 44 96 F 7 2 C Automatic by means of electronic board Freezer model 171 71 gallons 650 I 1 fully insulated door Gross capacity 171 71 gallons 650 External dimensions Width 23 62 600 mm Depth with door closed 26 18 665 mm Depth with door open 47 24 1200 mm Height 83 15 2112 mm Compartment dimensions Width 21 26 540 mm Depth 21 65 550 mm Height 58 42 1484 mm Rack dimensions 20 87 x15 75 530x400 mm Power supply 0Hz 120V single phase Internal temp range 11 2 F 5 F 24 C 15 C Max room temp 109 4 F 43 C Current absorbed 12A Refrigerant charge R404A model 1 door 0 595 lbs 270g Refrigerant charge R404A model 2 doors and energy saving 0 551 Ibs 250 g Refrigerant capacity R404A 1721 W Refrigerant capacity R404A 882 W No and type of defrosts min 1 every 12 hours x max 30 At room temperature 104 F 40 C t At room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 14 F 10 C 2 ASHRAE PERFORMANCE room temperature 89 96 F 32 2 C dew point 129 92 F 54 4 C and evaporation temperature 9 94 F 23 3 C Automatic by means of electronic boa
Download Pdf Manuals
Related Search