en-us Use and care manual Dryer
Contents
1. All installation and grounding are in compliance with all local regulations and or other applicable regulations and requirements Failure to install maintain and or operate the dryer according to the manufacturer s instructions may result in injury and or damage To avoid floor damage and mold growth do not let spills or splashout cause standing water around or under the appliance see the installation instructions in this manual for grounding requirements Electrical Connections Page 13 The IMPORTANT SAFEGUARDS and WARNINGS oresented in this manual do not cover all possible conditions that may occur Common sense caution and care must be exercised when installing maintaining or operating the dryer Always contact your dealer distributor service agent or the manufacturer about any problems or conditions that you do not understand Follow the Safety Information in the INSTALLATION such as INSTRUCTIONS and the OPERATING INSTRUCTIONS A IMPORTANT SAFETY INSTRUCTIONS READ AND SAVE THESE INSTRUCTIONS WARNING WARNINGS FOR CHILDREN e Do not allow children to play on or in the appliance Close supervision of children is necessary when the appliance is used near children e Make sure to utilize all child lock safety features of your appliance and be sure to turn the appliance Off when not in use e Appliances are not intended for use by children however when children become old enough to operate t2. Read these installation instructions completely and carefully before starting to install your new dryer The information contained can save you time and effort and will helo to ensure optimum performance of your new dryer Be sure to observe all warnings and cautions WARNING amp WARNING RISK OF FIRE ELECTRIC SHOCK OR INJURY TO PERSONS e To reduce the risk of fire electric shock or injury to persons read the Important Safety Instructions at the beginning of this manual before installing or operating this appliance e Clothes dryer installation must be performed by a qualified installer according to these instructions and according to all local codes In addition to the installation and safety information in this manual the local water and electrical power suppliers services may have special requirements A CAUTION e Dryer is heavy Do not lift it by yourself use additional helo and care when lifting and positioning e If in doubt have the appliance installed and connected by an authorized technican e Take care to not damage the appliance Do not hold on to protruding parts e g door when lifting e Do not install the appliance outdoors or in an area exposed to freezing condtions e If freezing conditions exist where appliance is located all drain water must be removed from hoses sumps pumps etc These installation instructions are intended for use by qualified installers In addition to these
3. Laundry is too wet Drying time too long Lint filter is dirty Insufficient supply of air Air inlet possibly blocked Ambient temperature higher than 95 F 25 C Program does not start Program ending time has been Finished in remaining selected and activated time is displayed Program does not start Childproof look is activated symbol light up Ambient temperature greater than The selected program does not suit Solution s Check drain hose Maintenance of drain hose Page 27 Check drain hose connection conditions Check the drain hose be sure that it is on the dryer securely with the clamp in place may need to replace the drain hose if leaking continues Level the dryer Leveling the dryer Page 14 Clean the heat exchanger seal Cleaning the heat exchanger Page 26 Ventilate the room Load the laundry Loading the laundry Page 23 Use time program Program selection table Page 18 Check the loaded laundry If it is dry open the door remove laundry and turn program selector to Off Close the door until a click is heard Do not exceed the maximum load for selected pro gram Remove items of laundry immediately after the end of the program hang them up and pull into shape Turn program selector to Off Program selection table Page 18 Remove items of laundry immediately after the end of the program and turn the program selector to Off Use another dry
4. amp WARNING ELECTRIC SHOCK e Do not pull on the power cord to unplug the dryer e Protect the power cord from physical damage such as being twisted kinked pinched or walked on for example e DO NOT use an extension cord or an adapter to connect the dryer to the power supply e Make sure The power cord fits into the outlet receptacle The home s internal power supply circuit wire size is sufficient and electrically grounded e The outlet receptacle used to power the dryer must be connected to an Individual 30 amps Branch Circuit e Do not cut remove or bypass the grounding prong on the power cord end e Do not modify the plug provided If the plug will not fit into the outlet receptacle have it inspected by a qualified electrician e The power cord must only be replaced by a qualified technician or licensed electrician to help avoid a fire electric shock hazard Replacement power cords are available through our Customer Service department e Use only a UL listed 30 amps power cord e Do not reuse old power cord e Do not make a sharp bend or crimp wiring or conductors at connections e Use only a 4 wire conductor power cord when the appliance is installed in a mobile home recreational vehicle in a new branch circuit installations or where the local codes do not permit grounding through the neutral amp WARNING ELECTRIC SHOCK To reduce the risk of electrical shock e Only pull out the main cab
5. 2 cccccceeeeceeeeeenseeseeenseeeeeeeseesseenseesees 28 VEO CC IION seseris aE E naaa ONNE 28 Troubleshooting see acssonscnnnvcaiinet suisaintceestuausnreuiadensurectond meres 28 STATEMENT OF LIMITED PRODUCT WARRANTY 30 Bosch Clothes Dryer mestititucesecccncaneiasitesveatintsemianousaaeonean 30 Additional information on products accessories replacement parts and services can be found at www bosch home com and in the online shop www bosch eshop com Questions 1 800 944 2904 www bosch home com 1901 Main Street Suite 600 Irvine CA 92614 We look forward to hearing from you Important information Purchase information Please take a moment to record the following basic information about the purchase of your new Bosch dryer This information will be helpful in the event you need to contact Customer Service or would like to order accessories or replacement parts for your dryer The E Nr model number and the FD serial number are found on the rating plate label The model number includes the slash and a two digit number eg 01 Please be sure to include the final 2 digit number when filling in your model number This helos make sure any parts you may need are correctly matched to your specific machine Date of Purchase _ _ Where Purchased E Nr FD gt Z o S S o o provides production date ex WTB86202UC7 01 ex FD 930490007 Customer service Your dryer does not require any speci
6. T20 torx at locations N and PE 13 Tighten the strain relief screw ensuring the power cord cannot be pulled out of the connection box but not so tight as cut the power cord insulation 14 Reinstall the connection box cover making sure all wires are routed so they do not touch any part of the enclosure and are secure 15 Reinstall the appliance top cover as previously described in 2 point above Integrated electrical receptacle This appliance is equipped with a 208 240V 15A receptacle for use ONLY with Bosch washer listed below A CAUTION Do not use this receptacle to power any other device If any other electrical device is plugged into this receptacle Bosch will assume no liability A CAUTION Use integrated electrical receptacle only for these Bosch washer listed WAP24200UC WAP24201UC WAP24202UC WAS24460UC WAS20160UC WAE20060UC Leveling the dryer Importance of leveling the dryer It is important that your dryer is level and that all four dryer feet press with equal pressure against the floor This will helo assure the quietest most vibration free use of your dryer To adjust the dryer feet 1 Install the dryer on a level and solid surface preferably in a corner of a room If the floor is uneven or not level adjust the dryer feet as required to level the dryer Do not place anything under the dryer feet to help level the dryer Extend the dryer feet no more than is ne
7. cotton or blended fabric for freshing up or airing of items of laundry that have been worn for a short period ore dried multi layered sensitive fabrics made of acrylic fibres ore dried multi layered sensitive fabrics made of acrylic fibres cotton fabrics for drying in higher temperatures to keep them more hygienic Programs max Type of laundry For laundry which is load up to Standard programs Cotton Damp full load bed linen and table linen towels to be ironed Cotton Dry full load bed linen underwear cotton socks not to be ironed Cotton Extra Dry full load Perm Press Damp 1 2 load rich fibers lingerie not to be or only lightly ironed Perm Press Dry 1 2 load shirts blouses sports clothing not to be ironed Perm Press Extra Dry 1 2 load multi ply Quick Dry 1 4 load needs to be dried quickly Woolens 1 3 load woollen fabrics suitable for washers fabrics become fluffier but not dry Delicates 1 4 load Air fluff No heat 1 3 load all type of fabrics of time Timed program 40 hot 1 3 load or separate small items of laundry also for subsequent drying Time Dry 1 3 load or separate small items of laundry also for subsequent drying Special programs Sanitary 1 2 load Jeans 1 2 load fabrics made from jeans denim Heavy Duty full load Tip For best results it is recommended to load the drum depending on the fabric type e full load Cottons and Linens e 1 2 load Permanent Press Synthetic Blends and poly Knits e
8. flammable or explosive substances as they give off vapors that could ignite or explode Before the appliance is removed from service or discarded remove the door to prevent children from playing or hiding inside Also remove the power cord plug Do not allow anyone to climb lean or hang on any part of the dryer including any protruding components such as the appliance door or a pullout shelf Do not reach into the appliance if the drum is rotating Do not tamper with the controls Do not repair or replace any part of the appliance or attempt any service unless specifically recommended in the user manual or in published user repair instructions that you understand and have the skills to carry out Do not use fabric softeners or products to eliminate static unless recommended by the fabric manufacturer Always unplug the dryer from the power supply before attempting any service Disconnect the power cord by grasping the plug not the cord To reduce the risk of fire clothes cleaning rags mop heads and the like which have traces of any flammable substance such as vegetable oil cooking oil petroleum based oils or distillates waxes fats etc must not be placed in the dryer These items may contain some flammable substance s even after washing which may smoke or catch fire by itself Do not place items exposed to cooking oils in your dryer Items contaminated with cooking oils may contribute to a chemical reaction that co
9. hazardous threatening or treacherous locale surroundings or environment in any such event if you request Bosch would still pay for labor and parts and ship the parts to the nearest authorized service provider but you would still be fully liable and responsible for any travel time or other special charges by the service company assuming they agree to make the service call Extended Limited Warranty LENGTH OF EXTENDED LIMITED WARRANTY 2 year Limited Warranty from date of Purchase SCOPE OF EXTENDED LIMITED WARRANTY Bosch will repair or replace free of charge any printed circuit boards drive motor or component part of the drive motor that proves defective under conditions of normal home use during the first two years from the date of purchase labor charges excluded Out of Warranty Product Bosch is under no obligation at law or otherwise to provide you with any concessions including repairs pro rates or Product replacement once this warranty has expired Warranty Exclusions The warranty coverage described herein excludes all defects or damage that are not the direct fault of Bosch including without limitation one or more of the following 1 use of the Product in anything other than its normal customary and intended manner including without limitation any form of commercial use use or storage of an indoor product outdoors use of the Product in conjunction with air or water going vessels 2 any party s
10. instructions the installation must comply with e for the United States National Electrical Code ANSI NFPA7O and latest editions of the State and Municipal and or local regulations e for Canada Canadian Electrical Code C22 1 and the latest editions of the Provincial Municipal and or local regulations Before installing the dryer Unpacking the appliance A CAUTION Remove the appliance packaging carefully to prevent damage to the surfaces After removing the packaging immediately remove any objects from the drum Check the dryer for transportation damage Do not connect a dryer which is visibly damaged If in doubt contact your dealer Waste disposal Disposal of Packaging Materials After unpacking your new appliance dispose of the protective packaging materials in an environmentally friendly way Ask your dealer or inquire with your local authority regarding currently acceptable means of disposal A WARNING WARNINGS FOR CHILDREN Do not let children play with packaging and associated parts to avoid risk of choking or suffocation Disposal of Your Old Appliance Your old appliance can be recycled if it is no longer to be used Prior to disposing of your old appliance observe the following precautions to reduce safety risks amp WARNING TO AVOID RISK OF INJURY OR DEATH DO THE FOLLOWING e after unplugging the old appliance remove the electric power cord and dispose of properly e
11. to activate the lighting Environmentally friendly use of your dryer Page 7 Press any button to activate the lighting Clean lint filter Cleaning the lint filter Page 25 Press the Start Pause button to reset the displayed indication and then press Start Pause button again to reset the appliance if necessary Heat exchanger dirty 28 Clean heat exchanger Cleaning the heat exchanger Page 26 Press the Start Pause button to reset the displayed indication and then press Start Pause button again to reset the appliance if necessary Problem The Check drain indi cator light up Water has not drained completely Possible cause s Drain hose is blocked Drain hose is leaking is not screwed on the tight at both ends or rubber not placed in hose Water is leaking out Dryer is not leveled The heat exchanger seal is dirty Program terminates shortly after starting 41 F 5 C Laundry is not loaded Load too small for selected pro gram Loaded laundry dry The door opens by itself Creasing The door not closed properly Laundry load exceeded Unsuitable program selected Drying result is not sat Warm laundry may feel damper isfactory laundry feels than it really is too damp the load Dryness level is not adjusted Fine layer of limescale on the humidity sensors Program termination e g main power supply failure door open or maximum drying time reached
12. to you in Bosch s sole discretion for an additional charge All removed parts and components shall become the property of Bosch at its sole option All replaced and or repaired parts shall assume the identity of the original part for purposes of this warranty and this warranty shall not be extended with respect to such parts Bosch s sole liability and responsibility hereunder is to repair manufacturer defective Product only using a Bosch authorized service provider during normal business hours For safety and property damage concerns Bosch highly recommends that you do not attempt to repair the Product yourself or use an un authorized servicer Bosch will have no responsibility or liability for repairs or work performed by a non authorized servicer If you choose to have someone other than an authorized service provider work on your Product THIS WARRANTY WILL AUTOMATICALLY BECOME NULL AND VOID Authorized service providers are those persons or companies that have been specially trained on Bosch products and who possess in Bosch s opinion a superior reputation for customer service and technical ability note that they are independent entities and are not agents partners affiliates or representatives of Bosch Notwithstanding the foregoing Bosch will not incur any liability or have responsibility for the Product if it is located in a remote area more than 100 miles from an authorized service provider or is reasonably inaccessible
13. willful misconduct negligence misuse abuse accidents neglect improper operation failure to maintain improper or negligent installation tampering failure to follow operating instructions mishandling unauthorized service including self oerformed fixing or exploration of the appliance s internal workings 3 adjustment alteration or modification of any kind 4 a failure to comply with any applicable state local city or county electrical plumbing and or building codes regulations or laws including failure to install the product in strict conformity with local fire and building codes and regulations 5 ordinary wear and tear spills of food liquid grease accumulations or other substances that accumulate on in or around the Product and 6 any external elemental and or environmental forces and factors including without limitation rain wind sand floods fires mud slides freezing temperatures excessive moisture or extended exposure to humidity lightning power surges structural failures surrounding the appliance and acts of God In no event shall Bosch have any liability or responsibility whatsoever for damage to surrounding property including cabinetry floors ceilings and other structures or objects around the Product Also excluded from this warranty are scratches nicks minor dents and cosmetic damages on external surfaces and exposed parts Products on which the serial numbers have been altered defa
14. 1 3 load Wool Mixed 18 terry towels kitchen towels hand towels bed linen underwear cotton socks e 1 4 load Delicates Silk Program settings At the factory initial settings are pre set for all cycles You can change some program settings as follows Time Dry Available only for Time programs Program selection table Page 18 can be selected from minimum 20 minutes to maximum 3 hours in 10 minute steps Dry Level The dryness levels e g Cotton Dry can be increased in 3 levels The laundry is made drier Default setting 0 selectable values 0 1 2 3 Additional options Low Heat Reduced temperature for delicate fabrics e g polyacrylic polyamide or elastane with longer drying time Observe the care information or symbols on the textiles tickets Wrinkle Block To prevent the laundry from creasing the dryer drum rotates at specific intervals following the drying program standard setting for this function is 1 hour If the Wrinkle Block button is pressed this function is extended to 2 hours The laundry remains loose and fluffy until it is removed The laundry should be removed at the latest after this time has elapsed After setting the Dry Level for a program it is also retained for other programs until it is changed again Finished in Before the program start the program end Finished in time can be pre selected in one hour steps up to a maximum of 24 h h hour Press
15. TS SO THE ABOVE LIMITATIONS MAY NOT APPLY TO YOU THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE No attempt to alter modify or amend this warranty shall be effective unless authorized in writing by an officer of BSH How to Obtain Warranty Service To obtain warranty service for your Product you should contact the nearest Bosch authorized service center BSH Home Appliances Corporation 1901 Main Street Irvine CA 92614 800 944 2904 31 BOSCH AANA AAA T et Ma yw bosch home com 2012 BSH Home Appliances ae
16. U S Metric U S Metric Inches cm Inches cm Do not operate the dryer at temperatures above 95 F Power Cord 42 106 7 60 152 4 35 C or below 41 F 5 C Low temperatures affect l Drain Hose 16 193 55 139 7 the drying process and may prolong the drying times Facing the front of the dryer The installation surface floor must be level and iai n structurally sound Using the bubble level and the height Minimum clearances adjustable feet installed on the appliance level the Closet Stacked appliance side to side and front to back Appliance dimensions Closet Stand alone shown or Side by Side Label Dimension U S Metric Inches cm A Both Sides 0 6 1 5 B Top 6 3 16 C Rear 25 6 2 D Front 2 4 6 E amp F are minimum area size E Top Vent 63 sq 404 sq F Bottom Vent 63 sq 404 sq Vent spacing is actual not minimum dimensions G oF 94 H 26 66 eo 8 6 K 29 73 0 Under counter Preferred Front of the appliance fully open No doors or coverings Minimum opening dimensions A 23 8 in 60 5 cm B 23 8 in 60 5 cm C 33 5 N 85 cm Under counter Less Desirable lf front of the appliance is covered ventilation openings must be installed E amp F are minimum area sizes E 63 sq in 404 sq cm F 63 sq in 404 sq cm G amp H actual spacing dimensions for min open area sizes G 3 in 7 6 cm H 14 In 35 6 cm Installation Instructions SAVE THESE INSTRUCTIONS Introduction
17. al care other than the maintenance and care mentioned in this manual If you have a problem with your dryer please consult Troubleshooting Page 28 This may save you money If a technician comes out to advise you of information that is in the Troubleshooting table you may be charged even if your dryer is still under warranly If service becomes necessary contact your dealer or installer or an authorized service center Do not attempt to repair the appliance yourself Any work performed by unauthorized personnel may void the warranty If you are having a problem with your dryer and are not pleased with the service you have received please follow these steps 1 Contact your installer or the Authorized Service Contractor in your area and explain to them why you are not satisfied This will usually correct the problem 2 If after working with your installer or service technician the problem still has not been resolved to your satisfaction please let us Know either by writing to us at BSH Home Appliances 1901 Main Street Suite 600 Irvine CA 92614 or calling us at 1 800 944 2904 When writing or calling please have the following information available e E Nr model number example WIB86202UC 01 e FD serial number example 9304 90007 e Date of Original Purchase receipt required e Date Problem Occurred e Explanation of Problem lf writing please also include a daytime telephone number and a copy of t
18. ater turned to the vertical Off position Before using the dryer for the first time 1 Read these operating instructions carefully 2 Check that the supply voltage corresponds with the voltage specifications on the rating plate on the dryer see top rear side of the dryer and or rating plate label inside of the dryer door 3 Remove all objects from the drum Close the maintenance flap 4 Check the dryer for visible damage If damage found contact your dealer 5 Wipe the inside of the drum with a damp cloth 6 Check heating system Check heating system Page 15 7 If the dryer does not work switch the dryer to Off Look in the Troubleshooting section of the operating instructions and find the fault Troubleshooting Page 28 Temporary disconnection of the dryer Operate your dryer only when you are at home If you intend going on vacation or are not using your dryer for an extended period of time you should 1 Turn off the circuit breaker 2 Pull out the power supply plug if possible 3 Clean the lint filter Using the program selector to choose a drying cycle NOTICE f you have activated the childproof lock you must deactivate it before you can set a program Use the program selector to select the desired drying cycle Turns in both directions The machine is switched on 2 1 In the display area the cycle duration for the selected program appears Program selection For optimu
19. bols and what they mean before proceeding A WARNING WARNING This indicates that death or serious injuries may occur as a result of non observance of this warning A CAUTION CAUTION This indicates that minor or moderate injuries may occur as a result of non observance of this warning NOTICE This indicates that damage to the appliance or property may occur as a result of non observance of this warning Tip This symbol is used to draw the user s attention to important matters A IMPORTANT SAFETY INSTRUCTIONS READ AND SAVE THESE INSTRUCTIONS WARNING When properly cared for your new appliance has been designed to be safe and reliable Read all instructions carefully before use These precautions will reduce the risk of burns electric shock fire and injury to persons When using laundry appliances basic safety precautions must be followed including those in the following pages Examine the appliance after unpacking it In the event of transport damage do not plug it in WARNING TO REDUCE THE RISK OF FIRE ELECTRIC SHOCK SERIOUS INJURY OR DEATH WHEN USING YOUR DRYER FOLLOW BASIC PRECAUTIONS INCLUDING THE FOLLOWING Bosch dryers are provided with an Operating Care and Installation Instruction manual Read and understand all instructions before using the dryer Do not dry articles that have been previously cleaned washed soaked or spotted with gasoline dry cleaning solvents other
20. ced or removed service visits to teach you how to use the Product or visits where there is nothing wrong with the Product correction of installation problems you are solely responsible for any structure and setting for the Product including all electrical plumbing or other connecting facilities for proper foundation flooring and for any alterations including without limitation cabinetry walls floors shelving etc and resetting of breakers or fuses TO THE EXTENT ALLOWED BY LAW THIS WARRANTY SETS OUT YOUR EXCLUSIVE REMEDIES WITH RESPECT TO PRODUCT WHETHER THE CLAIM ARISES IN CONTRACT OR TORT INCLUDING STRICT LIABILITY OR NEGLIGENCE OR OTHERWISE THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES WHETHER EXPRESS OR IMPLIED ANY WARRANTY IMPLIED BY LAW WHETHER FOR MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR OTHERWISE SHALL BE EFFECTIVE ONLY FOR THE PERIOD THAT THIS EXPRESS LIMITED WARRANTY IS EFFECTIVE INNO EVENT WILL THE MANUFACTURER BE LIABLE FOR CONSEQUENTIAL SPECIAL INCIDENTAL INDIRECT BUSINESS LOSS AND OR PUNITIVE DAMAGES LOSSES OR EXPENSES INCLUDING WITHOUT LIMITATION TIME AWAY FROM WORK HOTELS AND OR RESTAURANT MEALS REMODELLING EXPENSES IN EXCESS OF DIRECT DAMAGES WHICH ARE DEFINITIVELY CAUSED EXCLUSIVELY BY Bosch OR OTHERWISE SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES AND SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG IMPLIED WARRANTY LAS
21. cessary The more the feet are extended the more vibration the dryer will experience Start with the dryer feet turned all the way in and adjust each foot as necessary Use a bubble level to check the top of the dryer to make sure It is level side to side and front to rear Press down on each corner of the dryer top to make Sure the dryer does not wobble There should be no give or movement All four dryer feet should press equally against the floor This is just as important as the dryer being level to prevent vibration Check heating system 1 2 3 Check that the drum is empty Close the dryer door Switch the dryer to Extra Dry and then press the Start Pause button After 3 5 minutes press the Start Pause button and open the door e lf the interior of the dryer feels warm the dryer has been connected properly Switch the dryer to Off e lf the dryer does not work switch the dryer to Off Look in the Troubleshooting section of this user manual and find the fault Preparing to transport the dryer step by step 1 Pull out power supply plug Place any accessories in the drum Close the door and secure with adhesive tape ocrew the height adjustable feet of the dryer into the oa fF GW N Rotate the program selector to Off housing to prevent them from being damaged during transportation 15 Getting to know your appliance Control panel Drying status dy damp r
22. changer Page 26 23 e f Check drain indicator lights up check the drain hose and its connection Maintenance of drain hose Page 27 3 If required select Low Heat by pressing the button Additional options Page 19 4 If required select Wrinkle Block by pressing the button Additional options Page 19 Tip The estimated remaining time will be updated Indicator of program sequence The dryer uses an electronic control system A moisture sensor continuously checks the moisture in the laundry Drying ends automatically as soon as the selected degree of dryness has been reached The drum continues to rotate at specific intervals for one hour to prevent creasing The current state of the process and level reached during the program sequence Is indicated by indicator lights dry damp regular Drying status dry damp regular Check drain x ms U Childproof lock You can secure the dryer against inadvertent changing of the set functions To do this activate the childproof lock after cycle start To Activate Deactivate press Start Pause for approx 5 seconds In the display field you will see the C symbol light indicating the childproof lock is active NOTICE The childproof lock will remain activated until the next cycle start even after switching the machine off You must deactivate the childproof lock before the next cycle and if necessary activate it again after starting the cycle Si
23. ecting program settings and additional options you can adjust the drying process still better to suit the items you are drying The settings can be selected and deselected depending on the cycle progress Drying status dry damp regular Ce Check drain Ea 7 jhe tt eee DU I ss Dry Finished Low Wrinkle Signal Level in Heat Block The indicator lamps of the buttons light up if the setting is active For Time Dry Finished in Low Heat Wrinkle Block and Signal the settings are not retained after the appliance is switched off Program settings Page 19 Additional options Page 19 For Dry Level the setting is retained after the appliance is switched off Dry Level Page 19 Loading the laundry amp WARNING RISK OF EXPLOSION Do not dry the laundry that has ever been in contact with solvents oil wax grease or paint e g hair styling products nail varnish remover stain remover cleaning solvent etc 1 Check lint filter The filter should be cleaned after or before every drying process Cleaning the filter reduces the drying time and saves energy Cleaning the lint filter Page 25 2 Load the laundry into the drum and close the door Tip If the door has not been closed properly the dryer will not start Tips After loading close the door carefully so as not to trap any items between the door and the rubber seal The door should close until a click is hea
24. efects or other reproductive harm SAVE THESE INSTRUCTIONS Keep These Instructions for Future Reference In case of change of ownership manual should be conveyed with the dryer About this manual These operating and installation instructions apply to more than one model of dryer Illustrations used may show details that differ from your particular model Read your user manual It contains valuable information about safety installation and operation of your new appliance This can save your time make It easier to correctly install and use your dryer and improve your overall satisfaction with your new appliance Special features e A distinctive feature of your dryer is low energy consumption e An easy operation philosophy a variety of customized drying programs and solid touch and feel make this appliance a user friendly assistant in your household e Load adjust matches power consumption to each cycle according to the amount of laundry sensed in the drum and the type of fabric The load adjust function runs automatically to keep energy consumption as low as possible Environmentally friendly use of your dryer Your new Bosch dryer is designed to use energy ina highly efficient way to helo reduce operating costs conserve resources and protect the environment To save energy money and time Bosch recommends the following e Drain the laundry thoroughly Before drying spin the laundry thoroughly in the washi
25. egular On nn Start Perm Press Extra Dry Off Cotton Extra Dry ry b Pause alee roy 2 Perm Press Dry e Cotton Dry req se ee ea iced et ies Low Wrinkle Signal Perm Press Damp Cotton Damp p Heat pa Heavy Duty Sanitary Delicates Jeans Timed program Quick Dry 40 hot Air fluff No heat Woolens Time Dry Time Dry Dry Level Finished in Program Selector Changing the program settings selecting a program and switching on off Indicator lamp lights up if the setting is active turns in both directions Low Heat Wrinkle Block Signal Display area for settings and information Additional option settings Indicator lamp lights up if the setting is active Start Pause e starts or pauses the selected cycle e indicator lamp on steady cycle running can be paused e indicator lamp blinking settings can be changed cycle can be started door is closed childproof lock is active cycle is in Pause mode 16 Display area Check drain Cleanin req 8 Drying cycle status sequence Childproof lock indicator Cleaning required indicator A Digit Display e Finished in time adjustable in 1h h hour steps to 24h e program duration 3 00 Laundry Preparing the laundry NOTICE Damage to the appliance fabrics Foreign objects e g coins paper clios needles nails may damage the laundry or components in the dryer Therefore note the following tios when
26. en us Use and care manual ri BOSCH Register your new Bosch now www bosch home com welcome Welcome to Your New Dryer Congratulations on your selection of a new Bosch dryer for your laundry needs We are confident you will enjoy the Superior performance and reliability Please do not hesitate to contact our Customer Service department if you have any questions or comments with your new dryer Thank you for choosing Bosch Visit our web site at www bosch home com for more information and to view a selection of our products Table of contents Important information ccceesceeeeeeeeeeeeeeeeeeeeeeeeeeeeeeeeees 4 P rchase Morato cicraceacntaneracicarcedtoneesiuatwaesesaveaatecceectcons 4 Customer SEFV CE stctinasnidssansyenennutiadedinteendatsestnaantdcceletotiaweutivons 4 Your dryer is intended for ccccccsssseeeeseesseeeeeeeseesees 5 Importance and meaning of symbols cccceeeeeeeees 5 IMPORTANT SAFETY INSTRUCTIONS nniniinnnnnnsnnsnnnnnn 6 Introduction to your new dryer ssssssssssnnnnnnnnnnnnnnnnnnnnn 7 Standard features and helpful information wo 7 Peca Tedre ae nen mane enn weer A T Environmentally friendly use of your dryer wees T Dimensions and clearances required c seeeeee 8 Installation for best performance iceeeeceeeceeeseseeeeeeeeeeeeeees 8 Appliance GIMENSIONS cscccscicdasravvacnnedcseuensacsovescmvecsaenncdeanent 8 Length of power cord and drain NOSE sesss
27. eseeseeeseenseeeeeeeneeseoees 19 EOW FAC a E ates scanueaiuets alana ca steauesesececeet 19 Wrinkle LOCK ss nsctucsosaasestenaustardcacteatasdanelaeinativaboumuionnentachoues 19 Operating Instructions ccccceeeeeseeeeeeeeeeeenseeeseeees 20 OU DON Y Ol resect ctceeecncaciinien cence eee anicosessmseecesen 20 Before using the dryer for the first time wee 21 Temporary disconnection of the dryer nesssssssrsss 2 Using the program selector to choose a drying cycle 21 Program selection vicccccccccccccccccecsceeueeueuuseeeseeeeeeesseseeseeaaaees 22 Selecting program settings and additional options 22 MOAI TMC laundiy srca 23 SLAIN Me DOGANI socrii iri 23 Indicator of program Sequence nesssssrrrrrrrrrrrrrrsssesseee 24 MMC GOO TOCK ssansrnii aaa 24 Selecting a different program esssssrrrrrrssrsrsrrrrrrrrrrn 24 Cancel Progra anasinin nean aaaea a 24 PrO O I ea E ote 24 Removing laundry switching the appliance off 24 IGM seecesioe eect en sere E A E E 24 Cl aning and care cuca iesiedsuvdadoewesanaceuvdntuiesintwoseraineds 25 Cleaning the housing and control panel we 25 Cleaning the lint fiter woo ccesscesseseeeeeeeeseeseseeeeesseeas 25 Cleaning the heat exchanger oo cccesssseeseeeesesssessees 26 Cleaning the moisture SENSOSS cccecceesssseeeeeeeeseeesseeeees Of Cleaning the lint filter area wo cccccceeeeeeeeesesseesesssens Of Maintenance of drain NOSE eesssssssssssssrrrrrirrrrrrrrrrsssssssee Of Troubleshooting 2
28. gnal For switching the buzzer on and off press the Signal button The Buzzer indicates program end if it is activated Other alarms are not influenced by this option 24 Selecting a different program If you have inadvertently started the wrong program you can change this as follows 1 Press Start Pause 2 Select another program 3 Press Start Pause The new drying cycle starts from the beginning Cancel program If required you can cancel the selected program 1 Press Start Pause 2 Rotate the program selector to Off Program end End appears in the display area the Start Pause button indicator lamp is off and the regular indicator lights up After the program end rotate the program selector to Off Removing laundry switching the appliance off 1 Open the door and remove the laundry 2 Turn the program selector to the Off position Appliance is switched off and dryer light goes out 3 Clean lint filter Cleaning the lint filter Page 25 4 Close the door Tip If at the end of the drying cycle the display does not light the energy saving mode is active To see diplay e g press any button Environmentally friendly use of your dryer Page 7 Cleaning and care amp WARNING RISK OF EXPLOSION Never use solvents or highly flammable liquids for cleaning A CAUTION Incorrect cleaning may damage the dryer Do not spray with a water jet Do not use scouring agents o
29. he appliance it is the responsibility of the parents or legal guardians to ensure they are instructed in safe practices by qualified persons Introduction to your new dryer A WARNING RISK OF FIRE ELECTRIC SHOCK OR INJURY To reduce the risk of fire electric shock or injury to persons read the IMPORTANT SAFETY INSTRUCTIONS of this manual before installing or operating this appliance IMPORTANT SAFETY INSTRUCTIONS Page 6 Standard features and helpful information Thank you for choosing Bosch for your laundry appliance needs Please read and follow the use and care important safety instructions and troubleshooting information contained in this manual Please retain this manual for future reference This dryer complies with UL 2158 A Electric Clothes Dryers Standard features e sensor controlled auto cycles e 15 4 Ib 7 kg large drum capacity for regular cotton loads e Large door opening 180 opening angle Quality tested Each dryer which leaves our factory has undergone a thorough performance test and is in full working condition Web Site Visit our web site at www bosch home com for more information and to view a selection of our products e Keep all laundry aids including detergents bleach fabric softener etc out of the reach of children WARNING STATE OF CALIFORNIA PROPOSITION 65 WARNINGS This product contains chemicals Known to the State of California to cause cancer birth d
30. he sales invoice When calling Customer Service please be ready to provide the model number E Nr and FD number This information will help provide the best support for your dryer Additional information is available at our website www bosch home com Your dryer is intended for e Only for household use and in a non commercial e Recommended operating conditions environment Ambient temperature 41 95 F 5 35 C e Household use only for drying washable textiles Relative humidity under 95 e he dryer can be operated by people with reduced e Installation by qualified installers ohysical sensory or mental capabilities and by people with little experience or knowledge if they are supervised or were trained by a responsible person e Children may not do any laundry without supervision e Keep pets away from the dryer Read the use and set up instructions and all other information included with the dryer and act accordingly e Installation in accordance with all regulatory requirements if in doubt have the appliance installed by a specialist familiar with these requirements Keep documents for future use Importance and meaning of symbols Important safety information is contained in this manual and on the warning labels located on your dryer standard symbols and headings are used to identify areas where you should take precautions to avoid injury or damage Please take a moment to become familiar with each of these sym
31. ho it Applies to The limited warranty provided by BSH Home Appliances Corporation Bosch in this Statement of Limited Product Warranty applies only to the Bosch Clothes Dryer Product sold to you the first using purchaser but strictly conditioned on the Product having been purchased 1 for your normal household non commercial use and has in fact at all times only been used for normal household purposes any commercial use or setting of the Product automatically voids the warranty 2 new at retail not a display as is or previously returned model purchased directly by the end user consumer and not for resale or commercial use and 3 within the United States or Canada and has at all times remained within the country of original purchase The warranties stated herein apply only to the first purchaser of the Product and are not transferable Bosch reserves the right to request proof of purchase at the time any warranty claim is submitted to confirm that the Product falls within the scope of this limited product warranty The warranty is automatically void if the Product was a display model sold as is tampered with a damaged or scratch and dent model or a previously returned model a free give away charitable donation or contest prize Limitation for Third Party Accessories Third party accessories other than those shipped with your Bosch appliance and any consequential damages resulting there from are not cove
32. ing program or in addition select the time program Program selection table Page 18 Use Dry Level to adjust the dryness level Dry Level Page 19 Clean the moisture sensors Cleaning the moisture sensors Page 27 see the problem s mentioned in this table Spin laundry at higher speed in the washing machine before drying Switch off the dryer and switch on again Clean lint filter Cleaning the lint filter Page 25 Ensure that air can circulate Do not obstruct the air inlet on the front of the dryer Ventilate the room Drying cycle will begin at proper time to complete at the selected Finished in time Deactivate Childproof look gt Childproof lock Page 24 29 Problem Possible cause s One or more indicator Lint filter or and heat exchanger is lights are flashing dirty Installation Conditions are not fine Fault in program sequence or mal function Power failure Solution s Clean lint filter or and heat exchanger see solution of the problem s in this table above Check the installation conditions Electrical Connections Page 13 switch off the dryer allow it to cool down switch back on and restart the program Remove laundry from the dryer immediately and Spread out This allows the heat to dissipate Be care ful as the door the drum and the laundry may be hot STATEMENT OF LIMITED PRODUCT WARRANTY Bosch Clothes Dryer What this Warranty Covers amp W
33. le by the plug and never by the cable as this could damage it e Never touch or hold the main plug with wet hands e Never unplug the main plug during operation A WARNING ELECTRIC SHOCK Improper connection of the ground may result in electric shock Have the appliance checked by a qualified technician or licensed electrician if you are in doubt as to whether the dryer has been properly grounded Grounding Instructions This appliance must be electrically grounded In the event of malfunction or breakdown grounding will reduce the risk of electric shock by providing a path of least resistance for electric current This appliance is equipped with a cord that has an equipment grounding conductor and a grounding plug The plug must be plugged into an appropriate outlet that is properly installed and grounded in accordance with all local codes and ordinances lf a ground fault circuit breaker is used ensure It has this symbol KX This symbol guarantees compliance with all current regulations SAVE THESE INSTRUCTIONS Connecting a 3 wire power supply cord The power cord must meet the following requirements e 208 240 volt rated minimum e 30 amps e ype SRDT or DRT UL 2158A 13 1 Unplug the current power cord being used from the outlet receptacle 2 To disconnect and or reconnect a new power cord you must remove the top cover of the appliance as Shown below A Remove the two 20 torx head
34. lug out of the socket 3 Call customer service Customer service Page 4 Troubleshooting If you encounter a problem it often will merely be something minor Before you call customer service consider the suggestions and Instructions below NOTICE The troubleshooting items listed below can help you resolve minor issues with your dryer quickly and without the necessity of waiting for a service call Service calls for issues that could have been solved by using this table may not be covered under the warranty Please rule out any of these issues before calling customer service Solution s Insert main plug correctly A fuse of power supply is tripped Replace switch on fuse Press Start Pause button nate Start Pause button not pressed Press Start Pause button Door not closed properly Check if laundry is caught in the door address the issue Close the door until a click is heard Ambient temperature below 41 F 570 Program not selected Increase room temperature Your dryer is intended for Page 5 Rotate the program selector to desired program The display panel light Energy saving mode is activated ing and indicator lights go out Start Pause indicator light flashes The display panel switches off ished in option is activated The Cleaning req indi Lint filter dirty cator light up sleep mode after setting the Fin Program selection table Page 18 Press any button
35. m drying results your dryer offers several program groups and additional options select the required drying program from the program table according to the examples Program selection table Page 18 Automatic programs There are automatic programs for different types of textiles regular cotton permanent press The program sequence of automatic programs is controlled by sensors The duration of the program depends on the measured degree of moisture in the laundry and on the selected degree of dryness e g Cotton Dry or Cotton Extra Dry e Regular Cotton Cotton Extra Dry ZA Cotton Dry Cotton Damp J Delicates Quick Dry SE Woolens e Permanent Press Perm Press Extra Dry Off Perm Press Dry Perm Press Damp Special programs The programs Sanitary Jeans Active Wear AntiShrink Super Quick 15 min Towels Mixed and Heavy Duty depending on model are made for special application cases Details Program selection table Page 18 off FAAN Sanitary Heavy Duty J Jeans 22 Time programs Time programs run at specific temperatures Suitable for prie dried multi ply delicate textiles or individual small items Also for subsequent drying Program settings Page 19 Timed program 40 hot Time Dry Air fluff No heat Selecting program settings and additional options By sel
36. n hose connection Occasionally the moisture sensors have to be cleaned i conditions because a fine layer of transparent buildup is deposited on the sensors To clean ihe mocu sensors NOTICE i Check drain indicator still lights up after the i maintenance you should contact customer service or 1 Open the door your local dealer 2 The deposit on the sensors can easily be removed by wiping the sensors the two bars next to the lint filter with a cloth and a little white vinegar of Troubleshooting Introduction NOTICE Before doing maintenance work or trying to rectify a problem by yourself rotate the program selector to Off The program will not continue running when the power Supply has been restored Desired program must be selected again and start button pressed A WARNING RISK OF INJURY TO SKIN The door the drum and the laundry may be hot amp WARNING RISK OF ELECTRIC SHOCK EXPLOSION HAZARD Repairs or replacement of parts should be carried out by authorized technicians only Determing the Problem Problem Dryer does not start Start Pause indicator light does not illumi Possible cause s inserted correctly Main plug not inserted at all or not Before calling the customer service check whether you can rectify the fault yourself by means of the following table If a fault cannot be rectified or a repair is required 1 Set program selector to the Off 2 Pull the mains p
37. ng machine Use the highest possible spin speed for the type of laundry Higher spin speeds reduce the drying time and the energy consumption e Use optimum load e Air inlet on the dryer Utilize the maximum amount of laundry for the Do not cover or allow any articles items to restrict the appropriate cycle However do not exceed loads air inlet on the front of the dryer e Clean filter e Energy saving mode Clean the lint filter before or after each drying process The display panel lighting goes out after a few minutes gt Cleaning the lint filter Page 25 and Start Pause flashes To activate the display press any button Energy saving mode is not activated if a program is running Dimensions and clearances required Installation for best performance Label Dimension U S Metric ATON Inches cm a a Width 23 6 60 DO NOT INSTALL THE DRYER b Depth to front of door 25 63 5 e outdoors C Height minimum 33 2 84 3 e in an environment with dripping water Height maximum 34 86 4 e near flammable materials J Side clearance 16 406 e in rooms which are at risk of frost 3 door open 180 e in rooms which may contain gas or other fuels e e Depth door open 90 42 9 109 e on carpets The dryer should be installed in an open area with no Length of poe cord and drain hose restrictions to ambient air for the best drying results To Left To Right Space allowances to fully open the door should also be considered
38. pplied max 39 in A CAUTION Do not over tighten plastic ties pinching or Causing a restriction in the drain hose Maximum height of drain is 39 in 100 cm e Sink Drain Pipe Attach and secure drain hose as shown below in picture F Use a standard hose clamp available from your local hardware store 2 Place drain hose assembly into standpipe as shown in picture B NOTICES e Sink Basin or Floor drain e Examples shown are for reference only Not all fittings If using the elbow supplied on the hose re position connectors nuts brackets ties etc are supplied to elbow closer to the drain end of hose and fasten with accommodate every application the plastic ties as shown in picture C e Ensure there are no kinks or crimps along the entire lenght of hose 12 e lf installed in an upper floor of a multi story building the dryer should be installed on a drained floor to orevent water damage to lower floors in the event of a leak Electrical Connections Power Cord The attached power cord is a standard 4 wire dryer cord and is UL approved and listed in the USA and Canada It meets the following requirements e 208 240 volt rated minimum e 30 amps e Type SRDT or DRT UL 2158A NOTICE f your specific installation requires a 3 wire power cord follow the installation instructions for such in the next section of this manual ALL ELECTRICAL CONNECTIONS AND CIRCUITS
39. preparing your laundry e Empty all pockets to ensure no loose debris coins keys other hard objects and cigarette lighters are placed in the dryer drum The drum must be empty prior to drying e Close any fasteners such as zippers hooks and eyelets that could cause laundry to catch or become entangled Button up covers Tie cloth belts apron strings etc together or use a laundry bag e Remove any foreign objects or non washable parts Time Dry 4 and Dry Level X indicators 6 Indicator lamps for additional option settings Low Heat Wrinkle Block and Signal Check drain indicator e Always dry very small items Such as socks and handkerchiefs and underwired bras together with large items of laundry or in a laundry bag Sorting the laundry Check the care labels on each laundry item prior to drying They provide valuable information as well as limitations about the temperature of drying process Choose an appropriate drying cycle Do not dry the following textiles in the dryer e air tight textiles e g rubberized e delicate fabrics silk synthetic curtains e oil stained laundry Drying tips e To ensure a uniform drying result sort the laundry according to fabric type and drying program e Do not over dry easy care laundry risk of wrinkling Allow laundry to finish drying in the air e Do not iron laundry immediately after drying Place the laundry in a pile for a short while Residual moistu
40. r all purpose cleaners Do not use steam cleaners Cleaning the housing and control panel Wipe the housing and fascia with a soft cloth and soapy water only Wipe the drum door seal and inside of the door with a damp cloth only NOTICE Do not clean with a water jet Remove detergent and cleaning agent residue immediately During drying water may occassionally accumulate between the window and the seal This does not affect the proper operation of your dryer Cleaning the lint filter A dirty filter extends the drying time and increases energy consumption The filter should be cleaned before or after each drying process If the Cleaning req indicator lights up during a drying program clean the filter immediately Tip The program interrupts automatically To clean the lint filter 1 Switch off the dryer Rotate the program selector to Off A CAUTION The inside of the door heats up during the drying process The drum the door and the laundry may be hot 2 Open the door 3 Pull out filter 29 6 Close the filter and re insert it 7 Close the door NOTICE The filter should be rinsed once a year under warm running water The filter must be dried thoroughly before being replaced Cleaning the heat exchanger The heat exchanger requires periodic cleaning recommended once per month under normal drying conditions The frequency of cleaning depends on the amount and t
41. rd Foreign objects left in the drum may damage laundry Before inserting any laundry check to make sure no foreign objects are in the drum Recommended Load Size Recommended maximum load size can be found in the program selection table in this manual Program selection table Page 18 Load the laundry Place laundry in the empty drum Put each piece of laundry into machine separately For best results the laundry to be dried must be sorted according to type of laundry and desired degree of drying Program selection table Page 18 Sorting the laundry Page 17 Dry Level Page 19 Starting the program 1 Rotate program selector to the desired program select the program which corresponds to the laundry in the dryer from Program selection table Program selection table Page 18 The Start Pause indicator light starts flashing 2 Press the Start Pause button Indicator lamp lights up and the cycle starts During the cycle the display area indicates the estimated remaining time and after starting the drying cycle the cycle duration and the symbols for the cycle progress are flashing gt Display area Page 17 NOTICES e lf you want to protect the cycle against inadvertent adjustment select the Childproof lock Childproof lock Page 24 e f Cleaning req indicator lights up clean the lint filter and or heat exchanger Cleaning the lint filter Page 25 Cleaning the heat ex
42. re will then be distributed uniformly e Knitted fabrics e g T shirts jerseys often shrink when tumble dried for the first time Do not use the Extra Dry program 17 Do not dry woolens in the dryer They may however be refreshed by using the Woolens program starched laundry is not always suitable for dryer starch leaves behind a coating that reduces the drying e When washing laundry that is to be tumble dried afterwards use the correct amount of fabric softener as specified in the manufacturer s instructions For pre dried multi layered fabrics or small individual effect items of laundry use the Time program Program selection table Page 18 Also suitable for subsequent drying Program selection table T shirts sports shirts dresses trousers overalls underwear bed linen and table linen towels T shirts sports shirts overalls terry bathrobes and terry bed linen particularly thick or multi ply trousers dresses skirts shirts blouses leggings sports clothing with synthetic bed linen and table linen track suits anoraks blankets not to be ironed thick or laundry made of synthetic fibres cotton or blended fabrics for example that the values may differ from the those specified depending on the type of fabric mixture of laundry to be dried residual moisture in the fabric and loading capacity remove fabrics once the program has ended and allow to dry lingerie made of synthetic fibres
43. red by this warranty This limitation expressly includes the implied warranties of merchantability and fitness for a particular purpose which are also expressly excluded with respect to third party accessories other than those shipped with your Bosch appliance Use of third party accessories other than those shipped with your Bosch appliance does not void this warranty on any other part and all other provisions of this warranty remain in effect Please make sure to return your registration card while not necessary to effectuate warranty coverage it is the best way for Bosch to notify you in the unlikely event of a safety notice or product recall 30 How Long the Warranty Lasts Bosch warrants that the Product is free from defects in materials and workmanship for a period of three hundred sixty five days 365 days from the date of purchase The foregoing timeline begins to run upon the date of purchase and shall not be stalled tolled extended or Suspended for any reason whatsoever Repair Replace as Your Exclusive Remedy During this warranty period Bosch or one of its authorized service providers will repair your Product without charge to you subject to certain limitations stated herein if your Product proves to have been manufactured with a defect in materials or workmanship If reasonable attempts to repair the Product have been made without success then Bosch will replace your Product upgraded models may be available
44. remove the door or permanently disable the door lock to prevent children from being locked inside Parts provided with your dryer Back side of the dryer power cord with plug drain hose connected to the dryer elbow to form the hose to fit the drain Dryer drum contents A literature pack and drain hose pack are shipped in the dryer drum Be sure to remove these items before using the dryer drain hose pack contents e 2 plastic ties for securing drain hose e plastic connector e summary of drain hose installation instructions literature pack contents e User manual e Warranty NOTICE f any parts are missing please notify your dealer immediately Accessories for your appliance Pedestal The dryer can be mounted on a special pedestal for easier loading and unloading Pedestal item number WMZ 20500 Stacking kits The dryer can be stacked on a Bosch washer of the same dimensions to save space stacking kits without a shelf WTZ20410 stacking kits with a shelf WTZ11400 Accessories can be purchased from customer service or your local dealer Customer service Page 4 Installation step by step 1 Unpack the dryer 2 Remove all objects from the dryer drum 3 Check the dryer for visible damage 4 Position the dryer near the installation location 5 Disconnect the power cord and drain hose from their clios on the back of the dryer A CAUTION Do not disconnect the drain hose from
45. screws B Push the top cover toward the rear of the appliance and lift up 3 Open the connection box toward the rear of the appliance by removing the T20 torx head screw fastening the cover 4 Remove the 4 wire power cord as supplied A Remove the 3 Philips screws 2 labeled L and one labeled N B Remove the green grounding screw PE T20 torx NOTICE Be careful not to drop the screws into the dryer 5 Loosen the strain relief clamp screw Philips head on rear of the connection box 6 Pull the old power cord out of the connection box 7 Install the new power cord back through the strain relief clamp NOTICE Ensure the strain relief clamp has not been moved and its clamping screw s are outside the rear of the connection box 8 Ensure the terminal ends are long enough and are formed bent so that no part of them wires or 14 terminal ends come in contact with connection box enclosure NOTICE Use only open end spade lugs 9 Ensure the terminal ends are long enough and are formed bent so they will align with the terminal block fastening locations screw holes 10 Reinstall the 2 terminal block screws Philips head at locations L as shown below 11 If the ground wire shown below from N to PE is not part of the 3 wire cord assembly you have it must be obtained purchased separately and it must be installed 12 Install the last terminal block screw Philips and 1 grounding screw
46. scssccscsss 8 MINIMUM clearances wiccecccccccccccccccceccceueseeeeeeuessusueeuueeeeeeaeeeaas 8 Installation Instructions ccceeeeeeeeceeeeeeeenseeneeeneeaes 10 OCU ON eenean E S 10 Before installing the dryer nesssssssssssssrsrsrrrrrrrrrrrrrreressens 10 Waste disposal waz sacdecsestegevavenvate iid Nae TaN ENN 10 Parts provided with your dryer essssessssseesrrrrrrrrrrrrrrersssees 11 Accessories for your appliance esssssssrcrrrirrs 11 Installation step DY Step sssssssscccrccccrererrn 11 Electrical CONNECTIONS ssssssesssrrrrrrrsssrrrrnrrrrrrsrrrrrrrrrreeserens 13 Leveling the dryer ce 14 Ghneck heating SYSTEMI stectsdscacecaerevecensictncdorreiottenecdesiecendane 15 Preparing to transport the dryer step by step 15 Getting to know your appliance ccccsesseeeees 16 SOLOING erne a Ea 16 Display area essssssssesrrrnrrrrrrrrrnnrrnnnnuurrrnunrnnnnrnrnnrnnnnnnenessnns 17 ENON e ceccatnevewexewoccycecdatacessucecdecvecesesae 17 Preparing the laundiy seeccracectsoiauncunditicuetcucnccenmoncnbleeasadeswess 17 Sorting the laundry cesterneuareustietnachetstamseusineseetactiaidianessestnets 17 Ban sii o E E EA AE A A 17 Program selection table cssssccsessseeseeeseeeseeeesees 18 Program settings ssssssnnnnsnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnnn na 19 MNG DIY secu niseuasintianatestnsd OEE TNE REEE 19 PD gara E T Dee sb EO dine bees 19 ISM I E E AA 19 Additional options cccccssssssee
47. the Finished in button until the desired setting is displayed NOTICE The cycle duration is included in the set Finished in time After the start the pre selected drying time e g 8h is displayed and counted down until the drying cycle begins Then the cycle duration e g 2 30 hours minutes is displayed 19 Operating Instructions amp WARNING RISK OF FIRE ELECTRIC SHOCK OR INJURY To reduce the risk of fire electric shock or injury to persons read the Important Safety Instructions and Operating Instructions before operating this appliance Your new dryer Control panel display area program selector Drum with interior light depending on model The light up after the door is opened and after the program starts and switches off automatically Open the door Close the door 20 Lint filter Air inlet 6 Open the maintenance flap amp WARNING BEFORE INSTALLING OR USING YOUR DRYER Read and follow all installation and operating instructions Check the machine Never start a damaged machine Contact your customer service Customer service Page 4 Check to be sure your household electrical system voltage and the voltage specifications on the dryer rating plate correspond Check to be sure the dryer drain hose is installed properly Turning the dryer on and off The rotating Program Selector turns the dryer on as drying cycle is selected and off when the selector is l
48. the sump pump connection at the bottom of the dryer Ensure the drain hose remains connected to sump pump outlet NOTICE Do not reuse an old or different drain hose Only use the drain hose included with the dryer 11 6 Connect the outlet end of the drain hose to a Standpipe or other drain inlet Examples are shown below A CAUTION APPLIANCE DAMAGE COULD OCCUR IF DRAIN WATER FLOWS BACK INTO THE APPLIANCE In all drain conditions scenarios or connections Ju must S Secure hose and or elbow as shown below Basin D e The drain water from the hose is free flowing and or floor E not obstructed allowing adequate water flow e Drain opening is not sealed in any way and ventilated enough not to cause a back siphon e The end of the drain hose does not protrude into the pumped out or standing water e Be sure to follow all local codes and regulations in draining the condensate water to a suitable drain NOTICE Examples shown are for reference only Not all fittings connectors nuts brackets ties etc are supplied to accommodate every application Examples of connections e Plumbing box or Standpipe connection For most plumbing box installations with adjacent washer the plastic eloow supplied with the dryer will not be used and must be removed from the dryer drain hose 1 Fasten the dryer drain hose to the washer drain elbow as shown in picture A Secure with plastic ties Su
49. uld cause a load to catch fire Do not use heat to dry articles containing foam rubber may be labeled latex foam or similarly textured rubber like materials Foam rubber materials can ignite by spontaneous combustion Keep flammable materials and vapors gasoline away from the dryer Clean lint filter before or after each load The interior of the machine should be cleaned periodically by qualified service personnel Do not install or store the dryer where it will be exposed to the weather Hoses and internal parts may be damaged if exposed to freezing temperatures Do not use the dryer if it has a worn power cord or loose plug The dryer must only be used for its intended purpose Always follow the fabric care instructions recommended by the clothing manufacturer Do not operate the dryer if parts are missing or broken Do not sit on top of the dryer To reduce the risk of fire or electrical shock DO NOT use an extension cord or an adapter to connect the dryer to the electrical power supply Use the integrated socket only for listed appliances Always check pockets and remove any objects Cigarette lighters are particularly hazardous Do not operate the dryer if any guards and or panels have been removed Do not bypass any safety devices Do not operate this dryer until you are sure that he dryer all services water power drain etc has been installed according to the Installation Instructions
50. ype loads being dried To clean the heat exchanger 1 If the dryer is hot run on Air fluff No heat program to allow the dryer to cool down 2 Residual water may escape place an absorbent cloth under the maintanance flap 26 3 Unlock the maintanance flap and open it completely 5 Pull out the heat exchanger cap 6 Remove the heat exchanger NOTICE Do not damage the heat exchanger Clean with warm water only Do not use hard sharp edged objects 7 Rinse the heat exchanger and the cap on all sides with a jet of water to completely remove all of the fluff 8 Remove any fluff from the seals on the dryer and heat exchanger 9 Allow the cap and the heat exchanger to dry fully 10 First insert the heat exchanger then the cap 11 Turn back both locking levers NOTICE Use white vinegar only Clean the moisture sensors once a month Cleaning the lint filter area Over time fluff from the drying process collects in the lint filter area 12 Close the maintanance flap until it locks into position This fluff can be easily removed using your vacuum cleaner at least once a month 13 Look in the Troubleshooting table also to reset the maintenance indication Troubleshooting Page 28 Maintenance of drain hose Cleaning the moisture sensors If Check drain indicator lights up check the drain hose it may be kinked or bent and or the drai
Download Pdf Manuals
Related Search