Gasoline Inverter Generator
Contents
1. BU BU FUSE DC Winding gt R BU BU Y klo BL R BL R R E gt J O BL BL BL i W J j P BL ma BU IE O Main Winding l BL Y G R R i BL aE I ECONOMIC SWITCH r INVERTER CELL R t I BL Q J d BL l a BL Ves Jf Er PILOT oa GR 1 BU w BL H YIG Vy E 20 OVERLOAD Ww a w f BL 80 AL aP y LOW OIL Oil Sensor BL OO ih Engine Switch Ignition Winding wr e i Spring Winding BL 6 G i High Pressure Spark Wrap idae EE EE PAINA TK NA A Plug BL BLACK BR i BROWN a a 4 n a oh E G GREEN Ww 4 WHITE YELLOW o ORANGE P PURPLE Y G YELLOW GREEN GR GRAY PI PINK Gasoline Inverter Generator2. calculate the charging time in accordance with the table e The specific gravity for the fully charged battery shall be within 1 26 to 1 28 It is recommended to check it every hour b Connect between the DC output socket and the battery terminals using the charging leads The leads shall be connected making sure of the and polarity c The DC circuit protector is to be set to ON after confirming the connection if the protector is in OFF position 1 30 Battery Capacity 1 30AH20HR 1 26 2 35AH 20HR 3 47AH 20HR 1 22 1 18 5 1 14 1 10 1 06 0 2 4 6 8 10 Charging Time HR Be sure the economy control switch is turned off while charging the battery 12 Gasoline Inverter Generator i 1 Turn off the power switch of the electric apparatus or disconnect any electric st oppIng devices t h 2 Turn the engine switch to OFF position gt 3 Turn the fuel lever to OFF 2 n 0 n a 4 Turn the fuel tank cap air vent knob clockwise until it is finger tight ENGINE SW OFF 13 Gasoline Inverter Generator PERIODIC MAINTENANCE m d N t N d N C 0 Regular maintenance is most important for the best performance and safe operation chart PRE OPERATION INITIAL INITIAL INITIAL INITIAL REMARKS CHECK 1MONTH 3MONTHS I 6 MONTHS 12 MONTHS DAILY Q
3. Add oil as necessary E N G N E 1 Remove oil filler cap and check the engine oil level If oil level is below the lower level line refill with suitable oil to upper level line Do not screw in the oil filler cap when checking oil level 3 Change oil if contaminated 4 Oil capacity 1 0 liters 5 Recommended engine oil API Service SJ 8 Gasoline Inverter Generator 25 C SAE 10W SAE 30 or 10W 30 or 10W 30 or 10W 40 or 10W 40 32 F operation check e The generator has been shipped without engine oil Fill with oil or it will not start e Do not tilt the generator when adding engine oil This could result in overfilling and damage to the engine STARTING T H F e Before starting the engine do not connect the electric apparatus ENGINE e Turn the economy control switch to the OFF position 0 Gasoline Inverter Generator Open the fuel tank air vent to the ON position Turn the fuel cock lever to the ON position Turn the engine switch to the ON position Turn the choke lever to the WX position Not necessary if the engine is warm app Nm m Pull the starter handle slowly until resistance is felt This is the Compression point Return the handle to its original position and pull swiftly Do not fully pull out the rope After starting allow the starter handle to return to its original position while still holding th
4. with an air vent knob to stop fuel flow The air vent knob must be turned counterclockwise from the tightened position This will allow fuel to flow to the carburetor and the engine to run When the engine is not in use tighten the air vent knob clockwise until it is tight enough to stop fuel flow 6 Gasoline Inverter Generator The fuel cock is used to supply fuel from the tank to the carburetor FUEL COCK H 2 lt H v S v O H v 2 9 gt S A v S e n 3 6 pre oper ation check e Add the fuel more than 2 liters for the first time to use this machine e Pre operation checks should be made each time the generator is used Make sure there is sufficient fuel in the tank If fuel is low refill with unleaded automotive gasoline Be sure to use the fuel filter screen on the fuel filter neck Recommended fuel Unleaded gasoline rr e rr aA PQ PN Fuel tank capacity 5 1 liters AR e Do not refill tank while engine is running or hot e Close fuel cock before refueling with fuel e Be careful not to admit dust dirt water or other foreign objects into fuel e Do not fill above the top of the fuel filter or it may overflow when the fuel heats up later and expands e Wipe off spilt fuel thoroughly before starting engine e Keep open flames away from the fuel tank C H F C K Make sure the engine oil is at the upper level of the oil filler hole
5. Gasoline Inverter user manual Gener ator table of contents Preface Introduction sunne jotnene banen page 3 Safety Infor mat ion Exhaust fumes are poiso das wee page 4 Fuel is highly flamma oe ie E EEE BD ee e4 safety P Precautions rik Function pre perio C Check Oper ation Starting the Engine sisaning a gag aaa ng aa ada asana negen nng anna paged Periodic Maintenance Troubleshooting page 17 O nn wa Sec ion i ur ir ing Diagr AM ee preface B f ef Thanks for buying the Gasoline Inverter Generator another high quality machine Introduction from our company To get the most out of your purchase please read the manual before using the Inverter We ask you to please read this manual carefully beforehand in order to familiarize yourself with this product and after reading please store this instructional manual for future reference Failure to follow the proper protocols listed in the manual may cause personal injury to the operator or damage to equipment In this manual the icon Note should be paid with special attention 3 Gasoline Inverter Generator Safety information f U 1 Never operate the engine in a closed area or it may cause unconsciousness and flammable and poisonous death within a short time Operate the engine in a well ventilated area Always turn off the engine when refueling Never refuel while smoking or in the vicinity of an open f
6. OHRS 50HRS 100HRS 300HRS Spark Check condition adjust gap and O Plug clean Replace if necessary Oil Replace O Oil Filter Clean Oil Filter O Air Filter Clean Replace if necessary O Fuel Filter Clean fuel filter Replace if O necessary Choke Check choke operation Valve Check and adjust when engine O Clearance is cold Fuel Line Check fuel hose for crack or damage Replace if necessary Exhaust Check for leakage Retighten or System replace gasket if necessary Check muffler screen O Clean replace if necessary Carburetor Check choke operation Cooling System Check fan damage O Starting System Check recoil starter operation Idle speed Check and adjust engine idle speed O Fittings Check all fittings and fasteners oO Fasteners correct if necessary Crankcase Check breather hose for cracks or O breather damage Replace if necessary Generator Check the pilot light comes on 1 4 Gasoline Inverter Generator engine oil replacement Gem Oy Gres a Place the machine on a level surface and warm up the engine for several minutes Then stop the engine and turn the fuel cock knob to OFF Turn the fuel tank cap air vent knob clockwise Loosen the screw and remove the cover Remove the oil filler cap Place an oil pan under the engine Tilt the generator to drain the oil completely Replace the generator on a level surface Add engine oil to the upper level Install the oil filler cap Install the cover and t
7. and muffler will be very hot after the engine has been run S C 0 n e Avoid touching the engine and muffler while they are still hot with any part of your body or clothing during inspection or repair 1 Remove the cover 2 Remove the muffler screen 3 Use the flathead screw driver to pry the spark arrester out from the muffler 4 Remove the carbon deposits on the muffler screen and spark arrester using a wire brush 5 Install the muffler screen 6 Install the cover A n n A 1 Fuel systems No fuel supplied to combustion chamber W 0 N t e No fuel in tank Supply fuel 5 t d t Fuel in tank Fuel tank cap air vent knob to ON fuel cock knob to ON e Clogged fuel line Clean fuel line e Clogged carburetor Clean carburetor 2 Engine oil system Insufficient e Oil level is low Add engine oil 3 Electrical systems Poor spark e Spark plug dirty with carbon or wet Remove carbon or wipe spark plug dry e Faulty ignition system Consult dealer 17 Gasoline Inverter Generator 4 Compression insufficient e Worn out piston and cylinder Consult dealer pn nn generale ee a wont produce power STORAGE Long term storage of your machine will require some preventive procedures to guard against deterioration d r d n 1 Remove the fuel tank cap drain the fuel from the fuel tank 2 Remove the cover drain fuel from the carburetor by loosening the drain screw 0 n n 0 1 Re
8. e handle Grasp the carrying handle firmly to prevent the generator from falling over when pulling the recoil starter 6 Warm up the engine 7 Turn the choke lever back to the operating position 8 Warm up the engine without a load for a few minutes ENGINE SWITCH US in 1 AC APPLICATION D C t C Check the AC pilot lamp for proper voltage e Turn the economy control switch to the ON position power Turn off the switch es of the electrical appliance s before connecting to the generator e Insert the plug s of the electrical appliance s into the receptacle 10 Gasoline Inverter Generator e Be sure the electric apparatus is turned off before plugging in e Be sure the total load is within the generator rated output e Be sure the socket load current is within socket rated current e The economy control switch must be turned to OFF when using electric devices that require a large starting current such as a compressor or a submersible pump 2 OVERLOAD INDICATOR LIGHT The overload indicator light comes on when an overload of a connected electrical device is detected the inverter control unit overheats or the AC output voltage rises The electronic breaker will then activate stopping power generation in order to protect the generator and any connected electric devices The AC pilot light green will turn off and the overload indicator light red will turn
9. ighten the screw Be sure no foreign material enters the crankcase Do not tilt the generator when adding engine oil This could result in overfilling and damage to the engine Clean the oil filter every other 100hr Maintaining an air cleaner in proper condition is very important Prevent dirt to be filter induced through improper installation improper servicing or inadequate elements damages and wears out engines Keep the machine always clean SONDRE au Oil Filter Remove the cover Remove the air filter cover and element Wish the element in solvent and dry Oil the element and squeeze out excess oil The element should be wet but not dripping Insert the element into the air filter Install the cover 15 Gasoline Inverter Generator The engine should never run without the element excessive piston and or cylinder wear may result C A d n 1 Remove the cover 2 Check for discoloration and remove the carbon h n 3 Check the spark plug type and gap 4 Install the spark plug 5 Install the cover adjust ing Spark pl ug Standard electrode color Tan Color Standard Spark Plug CR4HSB NGK Spark Plug Gap 0 6 0 7 mm 0 024 0 028 in f 0 1 Remove the fuel tank cap and filter U 2 Clean the filter with solvent If damaged replace t A n k 3 Wipe the filter and insert it 16 Gasoline Inverter Generator mut fl er e The engine
10. lame Take care not to spill any fuel on the engine or muffler when refueling SANG GJ If you swallow any fuel inhale fuel vapor or allow any to get in your eyes see your doctor immediately If any fuel spills on your skin or clothing immediately wash with soap and water and change your clothes 6 When operating or transporting the machine be sure it is kept upright If it tilts fuel may leak from the carburetor or fuel tank a n n a 3 n 1 Place the machine in a place where pedestrians or children are not likely to touch the machine MU f f 2 Ma 2 Avoid placing any flammable materials near the exhaust outlet during operation b h 3 Keep the machine at least 1 m 3 ft from buildings or other equipment or the E 0 engine may overheat 4 Avoid operating the engine with a dust cover Be sure to carry the generator only by its carrying handle 6 Put the machine on the flat ground for the machine eliminating heat freely ev t f 0 n C 1 Never operate the engine in rain or snow 2 Never touch the machine with wet hands S 0 C 3 Be sure to ground earth the generator prevention 4 Gasoline Inverter Generator LE Use ground earth lead of sufficient current capacity Diameter 0 12mm 0 005 in ampere EX 10 Ampere 1 2mm 0 055 in C 0 N N AC t 0 n 1 Avoid connecting the generator to commercial power outlet rules 2 Avoid connecting the generator in parallel with any other generat
11. move the spark plug pour in about one tablespoon of SAE 10W30 or 20W40 motor oil into the spark plug hole and reinstall the spark plug Use the recoil starter to turn the engine over several times with ignition off Pull the recoil starter until you feel compression Stop pulling Clean exterior of the generator and apply a rust inhibitor Store the generator in a dry well ventilated place with the cover place over it AD The generator must remain in a vertical position 18 Gasoline Inverter Generator specifications Type Inverter Generator AC Voltage 240V 2 Frequency 50Hz Max Output 3 2 Kva 0 8cos 4 4 kVA 0 8cos Rated Output 2 2 kVA 3 0 KVA Power Factor 1 0 DC Output 12V 8 3A FANSEN or keg Type Air cooled 4 cycle OHV Gasoline BorexStroke mmxmm 52 4x57 8 57 4x57 8 Displacement 124 6cc 149 5cc Max Output 3 5KW 5500rpm 4 0KW 5500rpm Fuel Regular Automobile Gasoline Fuel tank Capacity 5 7 liters 9 eee Se Free 100 Load N en min 50 Load 50 Load Lubricating Oil SAE 10W30 Lubricating Oil Capacity 0 9 liter Starting System Recoil Starter Ignition System TO Spark Plug Type A7RTC or CR5HSB NGK Be Net dimensionLxWxH 565x320x470 6 Overall dimension LxWxH 595x355x510 Net Weight 28 Kg 29 Kg i Dry Weight 31 Kg 32 Kg 19 Gasoline Inverter Generator wiring diagram
12. on but the engine will not stop running After twenty seconds the overload indicator light red turns on and power generates again if still overload the overload indicator light red turns off and no power generates in the event of overloaded three times the engine will stop automatically When the overload indicator light comes on and power generation stops proceed as follows gt ENGINE SWITCH e OFF a Turn off any connected electric devices and stop the engine b Reduce the total wattage of connected electric devices within the application range c Check for blockages in the cooling air inlet and around the control unit If any blockages are found remove d After checking restart the engine 11 Gasoline Inverter Generator e The generator AC output automatically resets when the engine is stopped and then restarted e The overload indicator light may come on for a fews econds at first when using electric devices that require a large starting current such as a compressor or a submergible pump However this is not a malfunction 3 DC APPLICATION option This usage is applicable to 12V battery charging only a Charging instruction for battery e Disconnect the leads for the battery e Make the battery fluid filler cap loose e Fill distilled water to the upper limit if the battery fluid is in low level e Measure the specific gravity of the battery fluid by using the hydrometer and
13. or control function DESCRIPTION 1 Economy control switch 2 Engine switch 3 Fuel tank 4 Spark plug 5 Muffler 6 Carrying handle 7 Choke lever 8 AC pilot light 9 Overload indicator light 10 Oil warning light 11 AC receptacle 12 DC receptacle 13 Ground earth terminal 14 Fuel filter 15 Fuel tank cap 16 Recoil starter 17 Fuel cock 18 Oil filler cap 19 Air filter cover OG D Gasoline Inverter Generator OIL WARNING SYSTEM ENGINE SWITCH ECONOMY CONTROL SWITCH DC CIRCUIT BREAKER FUEL TANK CAP AIR VENTKNOB When the oil level falls below the lower level the engine stops automatically Unless you refill with oil the engine will not start again The engine switch controls the ignition system ON run Ignition circuit is switched on The engine can be started OFF stop Ignition circuit is switched off The engine will not run D amp ON ENGINE SWITCH amp STOP When the economy control switch is turned ON the economy control unit controls the engine speed according to the connected load The results are better fuel connection and less noise D ON ECONOMY SWITCH T a OFF The DC circuit protector turns off automatically when the load exceeds the generator rated output Reduce the load within the specified generator rated output if the DC circuit protector is turned off The fuel tank cap is provided
Download Pdf Manuals
Related Search