Home
Free Access Temperature (& Humidity) Chamber
Contents
1. Free Access Temperature amp Humidity Chamber PFL PFU Series mim S Extension of the AR Series lineup with a new free access chamber design Possibility of cable ports on both right and left side and optimized user friendly features make the Free Access chamberthebestsolutionforyourtesting Fwovariationsforthismodef PFEtype 40 to 100 C150 20 to 98 rh and PFU type 40 100 C 150C Utility Both side easy access The instrumentation panel has been moved to the door allowing easy access to specimen through cable ports located on both sides of the equipment Connection of cables for voltage impression or specimen measurements is now made easier thanks to the free access Optimized volume Not only the move of the instrumentation panel to the front door reduces the chambers width but the exhaust of the refrigerator now located on the ceiling allows to save the space initially needed on the rear side Wider control range and better control accuracy for temperature and humidity The use of a refrigeration system equipped with an electronic auto expansion valve featuring step less control allows accurate temperature and humidity control over a wide range The lower limits being 10 C for temperature control and 20 RH for humidity control at 70 to 85 C High specimen heat load compensation at low temperature The use of a refrigerator bigger than the
2. 100 1 150 C 3 0 rh Temperature heat up 40 to 100 rate 40 to 150 within 50min Temperature pull 20 to 40 within 40min down rate 20 to 40 within 45min Allowable heat load 600W running at 30 Q Exterior material 18 Cr stainless steel plate hairline finish n c Interior material 18 8 Cr Ni stainless steel plate 2B polish n j Insulation Chamber Rigid polyurethane foam 150 Rigid polyurethane foam amp glass wool Door glass wool Refrigeration system Mechanical single stage refrigerator system air cooled condenser S Refrigerator Hermetically sealed rotary compressor a 2 Refrigerator capacity 2 2kW n g Expansion mechanism Electronic auto expansion valve system Coder Plate fin cooler also functions as dehumidifier Heater Nichrome strip wire heater Humidifier 18 12 2 5 Cr Ni Mo stainless steel sheated heater surface evaporating system Chamber air circulator Sirocco fan Fittings Viewing window W180mm x H260mm heat generator incorporated Cable port 1 D 50mm 1 on each side chamber lamp fluorescent integrating hour meter Time signal 2 points Casters with adjuster feet power cord 200V type only Water supply system Pump out system n Tank capacity 15L stationary 5L portable type xe 15 Water quality Conductivity 0 1 to 10 u S cm Inside capacity L 306 Dimensions Inside dimensions W600 x H850 x D600 Outside dimensions W800 x H1820 x D1291 Weight Kg 360 Power
3. PFU H Shelves steel wire PFU only ceceeeee ees 2 Resin coated surface 550x567mm Cartridge fUSEC ccc cece ccc e cece eee ea eeseaeeeeeaeeeees 1 set Users manual o5c5saek ce acaaseas see ocacece cee eaeee sane 1 set lt PFL only gt Wick 24 pieCeS ccceeeee eee 1 box 10 11 Emergency stop switch Stops the chamber immediately Cable port Additional cable ports to allow the connection of the specimen to electric cables etc e OM 25mm e OM 50mm e 100mm Flat cable equipped with rubber plug Cable port rubber plug The additional silicon sponge rubber plug e 25mm e 50mm e 100mm e Flat cable Shelf and shelf brackets Standard shelf and shelf brackets can be added as required Communication function Connects the chamber to a personal computer enabling operation control of the chamber RS 485 as default e GP IB e RS 232C Paperless recorder portable type Records temperature of each section such as the temperature inside the chamber Temperature type Temperature range 100 to 200 C Number of inputs Temperature 1 5 more channels can be turned ON Data saving cycle 5 sec External recording media CF memory card 128MB Language support ENG JPN Temperature and humidity type Temperature range 100 to 200 C Humidity range O to 100 rh Number of inputs Temperature 1 Humidity 1 4 more channels can be t
4. nd temperature humidity operations Easy cleaning of the condenser filter The condenser filter on the left side of the chamber can be removed and reinstalled for easy cleaning Door including closing prevention feature Safety for the user is improved by including a system of safety catch on the door hinges resulting in door opening stop at 60 and 120 Use of HFC to protect the global environment The refrigerant used for the refrigerator is an HFC which causes no damage to the ozone layer and thus complies with the measures for ozone layer protection specified by the Montreal Protocol Paperless recorder Option The paperless recorder allows data saving on memory card compact flash As the Free Access Temperature and Humidity Chamber has its instrumentation panel located on the door it is necessary to use a portable type recorder Variety of options for multiple testing With a wider temperature humidity control range and optimized capacity the Free Access chamber can offer more possibilities than the standard Platinous K Series Options can be chosen to meet various testing purposes Connected chambers With long viewing window Control Operation 775 at e EA x Variety of program settings _ On a 6 5 TFT screen up to 20 program patterns can be stored in memory 1 pattern consisting of 99 steps patterns can be linked This touch screen panel allows graphic of
5. nic auto expansion valve system Plate fin cooler Nichrome strip wire heater 18 12 2 5 Cr Ni Mo stainless steel sheated heater surface evaporating system Sirocco fan Viewing window W180mm x H260mm heat generator incorporated Cable port I D 50mm 1 on each side chamber lamp fluorescent integrating hour meter Time signal 2 points Casters with adjuster feet power cord 200V type only 306 W600 x H850 x D600 W800 x H1820 x D1291 360 Leakage breaker for power supply AC200 220 380 400V Boil dry protector PFL only Refrigerator overload relay Air circulator temperature switch SSR overload and short circuit protecting circuit breaker Electrical parts compartment door switch Thermal fuse Control circuit overload and short circuit protection fuse Overload relay for condenser heat exhaust fan Compressor temperature switch Reverse prevention relay Refrigerator high pressure switch High Low absolute temperature and humidity alarms Built into temperature humidity controller Burn out circuit Built into temperature humidity controller Watchdog timer Built into temperature humidity controller Specimen power supply control terminals Overheat protector Cable port plug 50mm silicon rubber 2 Brackets 18 8 Cr Ni Stainless steel 68 4 Shelves 18 8 Cr Ni Stainless steel 0055 2 550x567mm PFL or
6. one of traditional Platinous chamber type 3 allows a greater heat load compensation to 600W at 30 C and 320W at 40 C lon Migration evaluation The Free Access chamber can be combined with ESPEC lon Migration Evaluation System sold separately in order to perform a precise evaluation of ion migration Prevention of water Wick pan Stationary tank Condenser filter Q condensation dripping from the wick pan and water splashes The wick pan arm and drain are integrated so that any condensation forming in the wick pan is contained to prevent from dripping Additionally an automatic water feed system is used to prevent water splashes caused by pressure fluctuations Cartridge tank makes water supply easier Both a stationary tank and a cartridge tank are used for water supply A window located on the panel allows to check the amount of water remaining in the tank An alarm buzzer is also triggered when the cartridge is empty In the meantime the water is charged from the stationary to the chamber Water can be added even while the system is operating Automatic supply drain function of humidification water The drain switch in AUTO mode can supply or drain the water inside the humidification tray depending on the operation status As a result during pull down at temperatures below 0 C manual draining of the tray is unnecessary The AUTO function can be used during both temperature a
7. supply Maximum current A Temperature amp humidity control system Operating temperature Performan ce uol ONISUOD wajsAs uonesbiujay Coder Heater Humidifier Temperature amp humid range Temperature amp humid fluctuation Temperature amp humid uniformity Temperature heat up rate Temperature pull down rate Allowable heat load Exterior material Interior material Insulation Refrigeration system Refrigerator Refrigerator capacity Expansion mechanism Chamber air circulator Fittings Inside capacity L Dimensions Weight Kg Inside dimensions Outside dimensions AC200V 3 3W 50 60Hz AC220V 30 3W 60Hz AC380V 30 3W 50Hz AC400V 3 3W 50Hz 200V 18 0 220V 17 0 380V 12 7 400V 12 2 Balanced Temperature Control System BTC 0 to 40 40 to 100 40 C to 150 0 3 0 3 40 to 100 C 0 5 100 1 to 150 C 0 5 0 5 40 100 C 0 75 100 1 150 C 40 to 100 40 to 150 within 50min 20 to 40 within 40min 20 to 40 within 45min 600W running at 30 18 Cr stainless steel plate hairline finish 18 8 Cr Ni stainless steel plate 2B polish Chamber Rigid polyurethane foam 150 Rigid polyurethane foam amp glass wool Door glass wool Mechanical single stage refrigerator system air cooled condenser Hermetically sealed rotary compressor 2 2kW Electro
8. the patterns trend graph display and many other features Specimen temperature control function provides accurate testing option Uses a temperature control sensor X 1 to monitor and control the temperature of the P instrumentation specimen Direct setting of the Relative Humidity The Relative humidity can be directly set in rh the set values are displayed on screen Built in Timer function The built in timer function enables the chamber to be started or shut down automatically at a preset time A timer operation can be set for month date day of the week and time Various safety functions Numerous safety functions and safety devices are provided including an overheat protector that allows to set an overheating range as well as upper and lower temperature limit alarm functions Power supply AC200V 39 3W 50 60Hz AC220V 30 3W 60Hz AC380V 39 3W 50Hz AC400V 30 3W 50Hz Maximum current A 200V 26 0 220V 25 0 380V 13 2 400V 12 6 Temperature amp humidity control system Balanced Temperature amp Humidity Control System BTHC Operating temperature 0 to 40 Temperature amp 40 to 100 20 to 98 rh humid range 40 C to 150 20 to 98 rh Temperature amp 0 3 humid fluctuation 2 5 rh 0 3 40 to 100 C 0 5 100 1 to 150 C 2 5 rh Performanc Temperature amp 0 5 humid uniformity 3 rh 0 5 40 100 C 0 75
9. urned ON Data saving cycle 5 sec External recording media CF memory card 128MB Language support ENG JPN Water supply Water circuit for pure water supply eWater supply unit B De ionizing cartridge system pipe for water supply to water circuit eWater supply unit C Direct water connection Temperature recorder digital SRJ25 e 100 to 200 C e 6 dots Portable type Temperature and humidity recorder digital 50 to 150 C 0 to 100 rh 100mm 6 dots SRJ12 Temp 5 Thermocouple JIS T Humidity 1DC to 5V Digital type Free power supply AC100V to AC240V Specimen temperature control terminal A thermocouple to measure specimen temperature is attached to the specimen and connected to the specimen temperature input terminal located in the optional panel on the door
Download Pdf Manuals
Related Search
Related Contents
Jenn-Air Dishwasher W10596272A User's Manual ft ambixel limon NEAT-406 - Vox Technologies TRITTON Warhead 7.1 Wireless Surround Headset Manual - Thea Render Conexión y configuración de un CDP con inversores Fronius educational end user license agreement for plastic scm software ディスク式フィーダ DF200H 取扱説明書 iPORT NTx-GigE External Frame Grabber User Guide votre téléviseur est-il compatible avec la norme de protection hdcp Copyright © All rights reserved.
Failed to retrieve file