UV Manual 2005
Contents
1. Lu Uu Remove the filters bowls from the filter housing head and remove the filter cartridges Fill the filters bowls one half full with chlorine bleach and screw the bowls back onto the filter housing head Turn on the water supply Turn on every tap in the water system of the building both inside and outside Run the water until the smell of chlorine is evident in the farthest tap At this time shut off the taps and let the system sit idle for 60 minutes STANDARD SYSTEMS While the UV lamp remains on open all taps in the water system to flush out the chlorine approximately 15 minutes When all chlorine is flushed from the system and while the UV lamp remains on shut off the water supply and reinstall the filter cartridges in the filter housings Turn on the water supply Test water for contaiminants 00 6000 VVARNING This Simple Procedure must be performed after installation of the UV system and whenever the UV system is shut down or inoperative for any reason whatsoever CONTACT INFO ACCESSORIES Wyckomar UV Purification Systems Maintenance Procedures Ultraviolet Lamp Replacement The UV lamp located in the purification chamber will operate effectively for approximately 1 year under normal conditions The lamp will still light after that period but maximum UV light penetration may fall below the prescribed safety level o oo e H Caution t is required that2. 00000 CONTACT INFO ACCESSORIES u Wyckomar UV Purification Systems Filter Maintenance and Troubleshooting Important Do not use filter with water that is microbiologically unsafe or of unknown quality without adequate disinfection before or after the unit An activated carbon cartridge Taste Odour may contain a small amount of carbon fines very fine black powder A new cartridge should be flushed with sufficient water after installation to remove the fines before using the water dN ONILLAS NOLLOTGOMLN Each time that you use vvater from your filtered vvater tap for drinking or cooking purposes it is recommended that you run the tap for at least 10 seconds prior to using the water This is important if the water tap is not used daily Certain types of harmless bacteria will attack cellulose material Cartridges containing cellulose may seem to disintegrate produce a musty or moldy odour or form a black precipitate due to the bacteria If you notice any of the above problems while using the cellulose media cartridges switch to a synthetic media cartridge or consult the manufacturer SW3 1SAS QHVONVIS This replacement cartridge has a limited service life Changes in taste colour and flow of the water being filtered are signals that replacement of the cartridge is or soon may be necessary CAUTION The filter must be protected against freezing Failure to do so may result in cracking of the filter and water
3. 21 wan Wyckomar UV Purification Systems Changing Filter Cartridges Turn off the water supply to filter Depress pressure release button if present to relieve pressure in filter housing Unscrew housing with spanner wrench Note When opening filter housing it is common for the O ring Gasket to lift out of the housing and stick to cap me a o a me z a 3 2 Lu N Remove used cartridge and discard Rinse out housing and fill approximately 1 3 full of water Add about 2 to 3 teaspoons of bleach and scrub thoroughly with brush or sponge Rinse thoroughly Remove O ring Gasket from sump and wipe grove and O 41 ring clean Lubricate O ring Gasket with a coating of food grade silicone grease Place O ring Gasket back in place and press O ring down into the groove with fingers or place gasket on rim of sump STANDARD SYSTEMS Note Make sure O ring Gasket is seated level to maintain proper seal If O ring Gasket appears damaged replace at this time Insert a new cartridge into the sump making sure that it slips down over the sump standpipe Screw the sump onto the cap and handtighten DO NOT OVERTIGHTEN Make sure that the cartridge slips over the cap standpipe Turn on the water supply slowly to allow housing to fill with water Depress the pressure release button if present to release trapped air from the filter Check for leaks before leaving installation
4. CTS 16 5 UV250 Chamber 8 29 1 Lamp Extension Spring Plastic Cap Lamp Connector End Washer End Bushing Concave Cap End Conical Spring 3 4 NPT 3045S inlet outlet Port OONDUARWN oo CO CO CO CO KOO m b m r gt a e m un un o 2 m un e o 2 gt 4 Zz TI o 15 wan Wyckomar UV Purification Systems UV 700 Exploded diagram amp Parts List Z o m a o a 3 s l E un STANDARD SYSTEMS Part No Description 4 BE 425 1 Articool Ballast 10 5 Set Screw Quartz Compression Nut Quartz Domed Sleeve 22x25x895 3 Quartz Sleeve Seal 2 211 RL 40 867T5 Lamp RL 40 867T5 11 6 Glass Disc Seal Lamp O ring 2 113 Vievvport Outer Bushing Glass Viewport Disc Viewport Inner Bushing Viewport Compression Nut UV700 Chamber Lamp Extension Spring Plastic Cap Lamp Connector End Washer End Bushing Concave Cap End Conical Spring 3 4 NPT 3045S inlet outlet port 000 Ov Ui NU uo o r Ae N q qo Qo Qo A o Q9 Q9 q Qo N OTA UT CONTACT INFO ACCESSOR ES u Wyckomar UV Purification Systems UV 1 200 Exploded diagram amp Parts List z 2 s zi o z Uu 2 SW3 1SAS AYYANYLS Part No Description BE 800L 1 Articool Ballast 10 5 Set Screvv Quartz Compression Nut Quartz Domed Sleeve 22x25x895 3 Quartz Sleeve Seal 2 211 RL 84 893T5 Lamp RL 84 893T5 11 6 Glass Disc Se
5. leakage CAUTION AU filtration systems contain other parts that have a limited service life Exhaustion of the service life of those parts ofter cannot be easily detected Commonly it is only after leakage has been observed or water damage has occurred that one is made aware that the service life has been exhausted gt a m ca O 2 rri o Z gt C x 23 4Wyckomar UV Purification Systems IMPORTANT NOTICE To prevent costly repairs or possible water damage we recommend that the bowl or sump of all plastic housings be replaced periodically every 5 years for clear sumps amp every 10 years for opaque sumps z 4 a o 2 me 2 a 5 s N Sediment and Carbon Filter Cartridges are available from the manufacturer STANDARD SYSTEMS Be sure to replace filter cartridges on a regular basis to ensure proper operation of your UV disinfection system CONTACT INFO ACCESSORIES 24 u Wyckomar UV Purification Systems UV Monitor dN ONILLAS NOLLOTGOMLN SW3 1SAS 5 The optional VVyckomar UV Monitor is designed to monitor the effective UV disinfection light available inside the UV chamber The UV Monitor vvill measure true 254 nm germicidal light in real time and sound an alarm if the system develops a problem An optional solenoid valve may be connected to the UV monitor to stop the water flow when the system is not functi
6. First Name z o 2 e o a 2 E n Street Address City Province State Postal Code Zip Country STANDARD SYSTEMS Phone Number Date of Purchase email Address Product Model Number Product Serial Number Purchased From This unit in installed 3 in a residential building iz n a commercial business mn on a municipal vvater supply m on a private vvell CONTACT INFO ACCESSOR ES 28 VVyckomar means chemical free VVyckomar nc has been manufacturing Chemical free Ultra Violet VVater Purification and Filtration systems since 1978 Currently vve sell our products in more than 25 countries around the globe Our products are very friendiy to the environment by reducing or eliminating the need for chemical based water disinfection systems For information on distribution opportunities including our internet affiliate netvvork please contact our sales department sales wyckomaruv com
7. Installation and Maintenance Manual Models UV 1 UV 250 UV 700 UV 1200 UV 1500 UV 3000 and UV 5000 mu Wyckomar UV Purification Systems CAUTION WARNING The ballast and all electrical connections MUST be mounted and installed above the water lines to prevent the possibility of electrical shock in case of a water leak See Preparing to Install your System on page 4 Read this entire User Manual before attempting to install your UV system Read and follow ALL safety precautions Keep this Manual in a safe place for future reference Unit Serial Number Date of Purchase Please keep your sales receipt as proof of purchase Wyckomar UV Purification Systems How to use this manual Congratulations on purchasing a Wyckomar UV purification system Please read through the installation procedures and follow all safety warnings when setting up your system Wyckomar Inc manufactures several sizes of UV purification systems however they all operate on the same principle Basic installation is the same for most units Refer to the exploded diagrams for replacement parts Table of Contents Z 2 J c is z z z c Section 1 ntroduction Table of Contents Page 1 Hovv Ultraviolet vvater purification vvorks Page 2 How your Wyckomar UV Water Purifier works Page 3 Section 2 Setting up your Wyckomar UV Water Purifier Page 4 us Preparing to install your system Safety Precautions Pa
8. O ACCESSOR ES Wyckomar UV Purification Systems TAA Z Typical Installation preparing to install 15 Installing Pre Filter set dN ONILLAS NOILINGOYLNI SWALSAS GYVAONVLS Installing the UV unit Completed Installation with Pre Filter set and UV gt a a m Nn o 2 m N a o gt A z T o u Wyckomar UV Purification Systems Preparing to install your system Wyckomar purifiers are designed to be installed either at the main water supply line or at point of use In some installations particularly where plumbing is old the water may become re contaminated in the pipes between the purifier and the faucet In such cases be sure to follow instructions under Disinfecting Your Water Wyckomar purifiers are designed to be installed vertically and work best when mounted in this position However in cases with space restrictions the unit may be mounted horizontally Important Clearance above the unit for lamp changes should be equal to the length of the purifier SETTING UP INTRODUCTION Caution The ballast and all electrical connections must be mounted and installed above water lines to prevent the possibility of electric shock in the case of a water leak A grounded electrical outlet is required GCFI is preferred STANDARD SYSTEMS The manufacturers warranty is only applicable when prefiltered water is used Prefilters to 5 micron remove sediment particles tha
9. al Lamp O ring 2 113 Vievvport Outer Bushing Glass Vievvport Disc Vievvport Inner Bushing Viewport Compression Nut UV1200 Chamber Lamp Extension Spring Plastic Cap Lamp Connector End Washer End Bushing Concave Cap End Conical Spring 1 0 NPT 3045S inlet outlet port 000 Ov Ui MU uo o r o s N q Q Qo Qo qo 4 Qo Qo co q x Qo AA z homo 5 OANI 12V1NO2 S411055422V 17 z Lm a o a 2 o 2 E un STANDARD SYSTEMS CONTACT INFO ACCESSORIES Wyckomar 18 UV Purification Systems UV 1 500 Exploded Diagram amp Parts List 2 c Part No BE 800L 1 10 5 8 53 8 4 1 4 2 RL 110 1197T5 RQS 1181 11 6 11 3 8 52 8 50 8 12 8 9 8 10 8 11 7 15GL 8 5 316CTS44 5 2 Description Articool Ballast Set Screvv Quartz Compression Nut Large Blue Cap Lamp Connector Lamp RL 110 119715 Quart Open Sleeve 22x25x1181 Glass Disc Seal Lamp O ring 2 113 Quariz Sleeve Seal 2 211 End Bushing End VVasher 1 0 NPT 316SS Inlet Outlet Ports Viewport Copmression Nut Viewport Outer Bushing Viewport Inner Bushing Glass Viewport Disc UV1500 Chamber Mounting Feet Part No 4 BE 800L 1 10 5 8 40 8 301 11 10 RL 100 1197T6 RQS 1190 11 324 8 30 8 302 8 28 8 10 7 15GL 8 9 8 23 11 6 8 11 8 303 4 2 Description Articool Ballast Set Screvv Black End Cap Quartz Compression Nut Lamp O ring 19x6 L
10. amp RL 100 1197T6 Quartz Open Sleeve 32x36x1190 Quart Sleeve Seal 2 324 End Flange Threaded End Bushing 1 1 2 NPT 316 SS inlet port port Viewport Outer Bushing Glass Viewport Disc Viewport Compression Nut Mounting Feet Glass Disc Seal 2 113 Viewport Inner Bushing UV3000 Chamber Lamp Connector z z o c s d o z ce 1 z c SW3 LSAS 04 15 OANI 12V1NO2 S411055422V wand Wyckomar UV Purification Systems UV 5000 Exploded Diagram amp Parts List z 2 o 2 e o a 2 E n STANDARD SYSTEMS Part No Description 4 BE 800L 1 Articool Ballast 10 5 Set Screw 8 51 Quartz Compression Nut RL 110 1197T5 Lamp RL 110 1197T5 11 6 Quartz Disc Seal Lamp O ring 2 113 11 3 Quartz Sleeve Seal 2 211 RQS 1181 Quartz Open Sleeve 22X25X1181 8 5 316 SS CTS44 UV5000 Chamber 8 11 Viewport Inner Bushing Viewport Compression Nut Viewport Outer Bushing Large Blue Cap End Bushing End Washer 2 NPTX1 2 inlet oulet ports Chamber Joiner Tube Glass Viewport Disk CONTACT INFO ACCESSORIES Wyckomar UV Purification Systems Filter Sets Filter Sets are available in standard 10 inch and 20 inch configurations We HIGHLY recommend a 5 micron sediment and a carbon filter be installed ahead of the UV unit in order to ensure proper UV operation dN ONILLAS NOILONGOYLNI SW3 1SAS GYVAGNVLS gt e Q m ua un o 2 m 5 gt z
11. ge 4 E Important Considerations Page 5 Typical Installation Page 6 Fa Disinfecting Your Water System Page 10 n Maintenance Replacing UV Lamp and Quartz Page 11 4 Section 3 Standard Units Exploded Views Page 14 2 Section 4 Accessory Products Page 21 n Filter Sets and Cartridges Page 24 UV Monitor Page 24 Section 5 Contact Information Page 28 Wyckomar contact info Page 30 Warranty Registration Card Page 30 Page 31 Copyright Copyright by Wyckomar Inc 2005 No part of this manual may be reproduced or transmitted in any form without the expressed written permission of Wyckomar Inc Notice Although Wyckomar has attempted to ensure the accuracy of the content of this manual it is possible that this document may contain technical inaccuracies typographical or other errors Wyckomar assumes no liability for any error in this publication and for damages whether direct indirect incidental consequential or otherwise Wyckomar provides this publication as is without warranty of any kind either express or implied but not limited to implied warranties of merchantability or fitness for any particular purpose The published information in the manual is subject to change without notice Wyckomar reserves the right to make changes in the product design and layout without notification to its customers OJNI 12V1NO2 S411055422V wan Wyckomar UV Purification Systems How Ultraviolet Water Purification Works Wyckomar Ultravio
12. ifier Works Untreated water enters the lower portion of the purification chamber and flows through the unit in an upward circular path The spiraling movement assures the maximum irradiation of the fluid and prevents larger particles from blocking the treatment of microorganisms The purification chamber contains the ultraviolet light producing lamp In operation the lamp emits a bluish glow which is visible in the view port window on the side of some units WARNING DO NOT LOOK AT THE UV LIGHT DIRECTLY If your unit does not have a view port operation of the UV light is confirmed by a green LED indicator lamp As long as the appropriate indicators are glowing the unit is working properly An alarm will sound when the UV lamp is not functioning When the the alarm is sounding the lamp must be replaced for the unit to operate properly To Power Source Treated water OUT UV Lamp Untreated water IN 2 A o nn m z a SWALSAS 0 5 OJNI 12V1NO2 S414055422V u Wyckomar UV Purification Systems XAN D x o 5 va et o 5 Uu et m lt o lt Nn er D 3 SAFETY PRECAUTIONS READ and FOLLOW all safety precautions SAVE these instructions Never Expose your eyes directly to UV light kK 5 a o a 5 o 2 F N This UV system is designed for indoor use only Do Not use this UV system where it may be exposed t
13. let UV Purifiers utilize the proven principle of ultraviolet light radiation to eliminate or reduce unacceptable levels of microorganisms in water and other liquids Ultraviolet light energy destroys bacteria viruses fungi spores algae and other such contaminants which are pathogenic to humans other animals and plants Ultraviolet purification is a completely natural non chemical environmentally safe technique which adds nothing to and removes nothing from such as trace minerals the water He 5 a o a 2 a 5 o z Lu un Factors affecting UV Purification The Wyckomar UV Purifier is guaranteed to eliminate microbiological contamination only if the physical qualities of the infulent water supply are as follows STANDARD SYSTEMS Turbidity Suspended Solids Turbidity must be 1 0 TU at the time of disinfection There must be a 5 micron or less sediment prefiltration system installed before the UV system Total Hardness Sum of Calcium amp Magnesium Must be 10 gpg grains gallon of hardness before pretreatment is required Tannins amp Colour There must be 2 0 ppm before pretreatment is required Iron Must be 0 3 ppm Manganese Must be 0 05 ppm If your water quality parameters do not meet these criteria please contact the manufacturer for pretreatment recomendations CONTACT INFO ACCESSORIES Wyckomar UV Purification Systems How your Wyckomar UV Water Pur
14. lug the purifier from the electrical outlet z O z a o a ua With the Allen key provided loosen the two set screws that secure the top cap containing the electrical cord Remove the cap and carefully set aside Remove the white lamp pin connector from lamp end Remove the UV lamp carefully from the UV unit Loosen and remove the retaining nut Caution Quartz sleeve will be stuck to the o ring inside the retaining nut STANDARD SYSTEMS Carefully remove the quartz sleeve from the UV chamber Wipe the quartz sleeve with an alcohol wipe being careful not to touch the sleeve with your fingers Reassemble using a clean cloth to hold the quartz sleeve Guide the quartz sleeve gently into the UV chamber and screw the retaining nut down until snug to secure seal Insert the replacement lamp into the quartz sleeve Gently push the lamp pin connector against the pins at the end of the lamp Complete the reassembly of the UV purifier o s 0000 o CONTACT INFO ACCESSOR ES INTRODUCTION SETTING UP STANDARD SYSTEMS ACCESSORIES CONTACT INFO UV Purification Systems Troubleshooting Guide 5 zenb a ejday SuLI 0 a ejday SULI O o ejday suid dwe uo oJn28Ss SI J03129UuUOD pue dwe a3lUM 383 494 9863 0A 1ndino y u uO SI 3451 403621pul yey 42949 o el day a2e daJ 10 42345 99e da4 10 42345 J03e n823J Se210A L e3su uonnjos 24n32eJJ ZENO Aj
15. o the elements Protect the unit from freezing at all times ELECTRIC SHOCK HAZARD This UV system is installed near water take all necessary precautions Other than where noted in this manual DO NOT attempt repairs yourself but contact the factory or authorized dealer for repair service STANDARD SYSTEMS Only connect this UV system to a properly grounded outlet A GFCI circuit is recommended Installation of a quality surge suppressor is highly recommended Ensure installation is in compliance with all local laws regulations and codes DO NOT operate the UV system is power cord plug or any component appears to be damaged or if the unit has been dropped or damaged in any way Inspect the UV system after installation DO NOT plug in the system if there is water on any part s that are not intended to be wet This system system is to be used ONLY for its intended use of potable water disinfection DO NOT use attachments not approved by the manufacturer as this may cause problems with the UV system CONTACT INFO ACCESSORIES Wyckomar UV Purification Systems TA e Preparing to install your system IMPORTANT CONSIDERATIONS Ensure there is adequate clearance at the lamp end of the unit in order to safely remove the UV lamp from the chamber Space required is at least the length of the UV chamber If a water softener or other treatment device is installed or planned for your UV unit should be loca
16. oning properly Installation instructions are supplied with the UV Monitor gt a rri ca Uu O 2 m o o z gt C 25 UV Purification Systems z a o 2 me Z 5 o s N Please contact the manufacturer or your local dealer for all replacement parts Please save this manual for future reference STANDARD SYSTEMS CONTACT INFO ACCESSORIES 26 UV Purification Systems Uesg Q Yon Contact and Warranty Information Congratulation on purchasing a Wyckomar UV purification system We want you to be satisified with your product and with our service If you need to contact a Wyckomar Customer Service Representative please have your product model number and serial number ready For warranty service ship defective product proof of purchase indicating date of purchase and a letter describing the problem to Wyckomar Inc P O Box 611 111 Malcolm Road Guelph Ontario CANADA N1H 6L3 Telephone 1 800 419 5162 519 822 1886 Fax 519 763 6580 Email sales wyckomaruy com Web Site www wyckomaruv com FOR THIS WARRANTY TO BE EFFECTIVE WHEN MAKING A WARRANTY CLAIM YOU MUST INCLUDE YOUR PROOF OF PURCHASE RECEIPT INDICATING THE DATE OF PURCHASE Wyckomar Inc warrants to the first purchaser of the UV unit that the UV reactor chamber will be free from faulty material and or workmanship for a period of 5 years from date of purchase Ballasts UV Monito
17. rs and UV Lamps carry a one year pro rated warranty from date of purchase Wyckomar Inc s liability during the warranty period is limited to the repair and or replacement of the part s which prove to be defective in material and or workmanship under normal use Shipping handling and service costs are the responsibility of the purchaser The defective part or unit must be returned to Wyckomar at the purchaser s expense The warranty is not transferable and is the only warranty authorized by Wyckomar Inc Any other warranty or guarantee implied or offered will not be honored by Wyckomar Inc This warranty is void if in the opinion of Wyckomar Inc that the product failure was caused by misuse abuse accident or improper installation Do not install systems out of doors in the elements All units are for indoor use only in a dry location As a result of this warranty Wyckomar Inc is not responsible for any damages injuries or losses whatsoever including those incurred during installation repair or replacement as well as incidental or consequential damages 27 dN ONILLAS NOLLOTGOMLN SW3 1SAS QHVONVIS gt C C m un wn o 2 m un Y z gt c Z pu O wan Wyckomar UV Purification Systems VVarranty Registration Card Please fill out your Wyckomar Product Registration Card and return it to the manufacturer Alternatively you may email the information to salesewyckomaruv com Last Name
18. sadoid payeas Ou 8uLI Q SULI O payde4D JO dAl DaJaq jsejjeg d le aaiqvajaq dwe AN 9A29Jeq UMO Q Seu asnj JexeaJg 3 mno JO pajoeuuoosip pJoo aut S110A OZ AOQE JO AO Q 60210A 3ndul 15 ziJenb 3e yeaq 3081 OU yim due An eqno call Wyckomar Inc for technical assistance If problem persists 1 800 419 5162 or 519 822 1886 3 1 u Wyckomar UV Purification Systems UV 1 Exploded diagram amp Parts List lt z o 2 e o a i o L N STANDARD SYSTEMS Part No Description 4 BE 425WP 1 Ballast 10 5 Set Screw 8 51 Quartz Compression Nut RL 12 254T5 Lamp RL 84 893T5 11 3 Quartz Sleeve Seal 2 211 11 6 Quartz Disc Seal Lamp O ring 2 113 RQD 269 Quartz Dome Sleeve 22X25X269 8 2 1 2 304 9 UV1 Chamber 8 29 1 Lamp Extension Spring 4 1 Plastic Cap Lamp Connector End Washer End Bushing Concave Cap End Conical Spring 174 NPT 3048S inlet outlet Port WOONKDUKRWN gt NA VUNA 0 EN q Q co co CONTACT INFO ACCESSORIES 14 wan Wyckomar UV Purification Systems 250 Exploded diagram amp Parts List dN ONILLAS NOILINGOYLNI SWALSAS GUVGNVLS Part No Description 4 BM 425 1 Articool Ballast 10 5 Set Screw 8 51 Quartz Compression Nut RL 23 436T5 Lamp RL 23 436T5 11 3 Quartz Sleeve Seal 2 211 11 6 Quartz Disc Seal Lamp O ring 2 113 RQD 438 Quartz Dome sleeve 22x25x438 8 2 1 2 316
19. t reduce the effectiveness of the UV lamp or potentially damage the unit If a water softener or other treatment device is installed or planned for your purifier should be located closest to the faucet Install your Wyckomar purifier indoors in a protected area The temperature should not fall below 4 deg C 40 deg F and avoid conditions with high humidity to prevent condensation on the purification chamber Ideal temperature conditions range from 9 deg C to 29 deg C Use Teflon tape liberally on all pipe connections that thread into plastic Do not use any other sealants N m oz N N Lu E o LL z x 2 UV Purification Systems 0000 Installation and Operation Note the direction of water flow in the supply line to which the unit is being connected Refer to the appropriate exploded diagram for your unit and check to see that you have all the necessary fittings Parts List 4 screws 1 Allen key wrench 1 alcohol wipe 1 quartz dome or sleeve 1 UV lamp w o rings on each end Take the plastic cap off the unit and remove the black nut from the end of the unit Gently slide the quartz dome with the lamp into unit Do not put fingerprints on glass Be sure the black o ring is secure inside the black nut when you screw it back onto the end of the unit to seal it Turn nut until snug IMPORTANT Do not over tighten Connect the white 4 pin electrical connec
20. ted closet to the faucet ie last in the treatment chain Refer to Typical Installation diagram Use Teflon tape liberally on all pipe connections DO NOT use any other sealant This UV system is designed to be installed vertically and works best when installed in thisposition Electrical connection end MUST be at the top Unit may be installed horizontally if absolutely necessary Ensure ballast unit is installed above water line to prevent electrical hazard In order to ensure proper UV disinfection all systems must have a 5 micron sediment filter in front of the UV unit Standard Wyckomar filter sets include a 5 micron sediment filter and a carbon filter to remove additional contaminants dN ONILLAS NOLLOTQOMLNI SWALSAS QHVONVIS gt C C m un un O 22 m o o Z gt C u Wyckomar UV Purification Systems A e S Typical Installation Preparing to install EEN Product amp System Configuration amp Flow Diagram z o 2 e o a k m N Water Pipe Cod was Pipe 2 Power Supply amp UV Montor mv Valve ih LT p e Optional B Sclaned Valve Shut Oit l 5 Micron Sidement Filletrs STANDARD SYSTEMS EUV Chamber Valve Optional Drain Note the location and layout of a typical UV system installation CONTACT INF
21. the lamp be changed every 12 months after installation regardless of apparent condition of the lamp Unplug the purifier from the electrical outlet Note It is not necessary to turn off the water supply With the Allen key provided loosen the two set screws that secure the top cap containing the electrical cord Remove the cap and carefully set aside Remove the lamp connector located at the cord end of the lamp by gently wiggling and pulling away from the Carefully slide the UV lamp out of the quartz sleeve and discard Insert the replacement lamp into the quartz sleeve Do not touch the lamp with your hands fingerprints will prevent the system from working properly If the lamp is touched clean with an alcohol wipe Gently push the lamp connector against the pins at the end of the new lamp Make sure that all electrical components are dry before replacing the top cap Secure the cap with the setscrews Plug in the power cord The lamp should be operating at this time To confirm that your new lamp is working correctly check your models light indicator z o A N m Q c SWALSAS QMVYONVLS OJNI 12V1NO2 S414055422V u Wyckomar UV Purification Systems Maintenance Procedures Cleaning and replacing the Quartz Dome Sleeve Important If water turbidity is a problem it is advisable to clean the quartz sleeve when replacing the lamp Turn off the water supply and unp
22. tor Replace the plastic cap and gently tighten setscrews with the Allen key wrench supplied Unit is now ready to install Shut off the main water supply valve Fasten unit to wall in using the white clips and screws provided Install new plumbing if you are installing a solenoid valve or pre filters make sure the arrows on the filter set points in the direction of water flow When new plumbing is installed a seal should be attached to the closed by pass if installed This seal should not be broken unless water is required during emergency or shutdown periods See Disinfecting Your Water System Plug power into an appropriate power source outlet a power surge suppressor is strongly recommended Open main valve to water source Open valve on either side of purifier by pass valve should remain closed You should hear a rush of water entering the unit Turn on any faucet to start the flow of water through the unit df ONILLAS NOLLOTGOMLN SW3 1SAS GUYVGNVLS gt o e m un un o 22 m un e o 2 gt Z wan Wyckomar UV Purification Systems Disinfecting your vvater system After installing the UV unit your vvater system must be disinfected beyond the UV unit itself The follovving steps must be taken to accomplish this important task Turn off the water supply to the UV unit and make sure that the by pass valve is closed Turn on the UV unit z o 2 e o a z a
Download Pdf Manuals
Related Search