M-Series User Manual (Prism Medical) - Rev
Contents
1. Signature of Testing Officer sisi CE Marking Declaration of Conformity Registered Manufacturer No CA003907 Prism Medical hereby declares that the M Series Mobile Lift range meets the provisions of the European Union Council Directive 2007 47 EEC concerning medical devices and are classified as Class 1 devices in accordance with that Directive o Prism Medical M 330 o Prism Medical M 400 We hereby certify that the products listed above are manufactured labelled and packaged in accordance with the provisions of Directive 2007 47 EEC and conform in all aspects to the specification s relevant to them at the time of despatch and are CE marked in accordance with Directive 2007 47 EEC Signed For Prism Medical UK Freeway Division M Series User Manual Rev 10JAN2012 Page 21 PRISM MEDICAL SUU 8 Prism Medical 201 1 9 0 Guarantee The M Series Mobile Lift Range GUARANTEE This lift has been carefully manufactured in Great Britain or US to exceed all rel evant British and American Standards Particular attention and care has been exercised in all stages of design and build Quality control throughout manufacture is to the highest standards and we are proud to guarantee this quality product When used correctly and serviced in accordance with recommendations this lift will give many years of trouble free service Prism Medical will subject only to the conditions set out below replace free of charge2. CHECK THE HANDSET LEAD HAS NOT BEEN PULLED FROM THE CONTROL BOX SOCKET OR WIRES DAMAGED e CHECK THE ACTUATOR LEAD IS FIRMLY CONNECTED INTO THE ACTU LOG S SOCKET AND THE LEAD IS CORRECTLY INSERTED IN THE CONTROL BOX If the above checks prove unsuccessful contact the service department of your nearest PRISM MEDICAL APPROVED AGENT 7 2 Service Maintenance Any works performed on the M series mobile lift must be in accordance with the specifications detailed in the test requirements of 15010535 7 3 Cleaning Disinfection and Sterilisation The M Series lift has an anti microbial coating This does not replace the need to clean and maintain the lift unit e Routine cleaning the exterior of the lift can be wiped over with a damp cloth containing a mild soap solution e Disinfection and Sterilisation the exterior of the lift should only be disinfected and sterilised using Isopropyl alcohol Dampen a cloth with isopropyl alcohol and wipe down the entire exterior of lift DO NOT USE ABRASIVE MATERIALS DO NOT IMMERSE THE LIFT UNIT M Series User Manual Rev 10JAN2012 Page 20 PRISM MEDICAL ee Prism Medical 201 1 8 0 Test Certificate M Series Mobile Lift TEST CERTIFICATE Safe Working Load 330 Pounds Il 400 Pounds LI Model M 330 O M 400 O EISE NEE This Test Certificate confirms that the above numbered lift has been fully tested in ac cordance with the tests specified in BS EN 10535 and has conformed fully therewith
3. Lift Type B M Series User Manual Rev 10JAN2012 Page 17 PRISM MEDICAL N au Prism Medical 2011 6 4 M 330 Main Assembly Components Main Assembly 410065 SSES EE M6 x 1 mm SHBS See 5 m Merter lees EE EECHER EE a bu 510079 ees merum Label Emm Seer 1 Acteisg Assembly r HIII 1 EE i6 GU Cable Ch Extra Large 1 35Hi Changer Led Snap Lend 1 3509 UEGmweGhe 19 510004 A S N amp Dstelabel J II L 20 51005 MISOSWLIabl 1 0 00 0 0 0 L 31 300000 Meb eCamyBarAsy 3Hedk 1 tem sold separately 150 refers to the lift capacity in Kg M Series User Manual Rev 10JAN2012 Page 18 PRISM MEDICAL gem Prism Medical 2011 6 5 M 400 Main Assembly Components Main Assembly Es E 2 Seenote for Loctite use RT NE item sold separately 175 refers to the lift capacity in Kg M Series User Manual Rev 10JAN2012 Page 19 PRISM MEDICAL gem Prism Medical 2011 7 0 Troubleshooing Maintenance 7 1 Troubleshooing If the lift will not operate e ENSURE THE BATTERY IS CHARGED AND THAT IT ISAT TACHED CORRECTLY TO THE CONTROL BOX e ENSURE THAT STOP BUTTON IS IN THE OUT POSITION e MAKE SURE THE CHARGING LEAD IS DISCONNECTED FROM THE MAINS POWER SUPPLY e
4. ee Prism Medical 201 1 1 0 ASSEMBLY INSTRUCTIONS M Series Mobile Lift Range 1 1 Initial Assembly 1 Remove carefully from the box Boom Mast assembly Base unit with legs attached Base Unit Battery pack charging lead Hand set control Document wallet Boom Mast assembly Battery Pack Handset Control SAFETY NOTE Some of the parts are heavy and will need to be lifted with care Heavier items may need two people for assembly PA Place base unit on level floor surface and lock rear casters 3 Remove boom mast assembly from packaging Continued M Series User Manual Rev 10JAN2012 Page 3 PRISM MEDICAL ee Prism Medical 2011 1 0 ASSEMBLY INSTRUCTIONS M Series Mobile Range 1 1 Initial Assembly Cont d 4 Carefully take boom mast assembly and slide bottom of mast into base socket as shown in the pictures below Ensure that the mast is fully down and fully engaged SAFETY NOTE Possible finger trap Keep fingers away from end of mast when fitting to base unit 5 When the mast is fully engaged into the base locate the mast locking knob and side securing knob and tighten by hand firmly 6 Check the emergency stop button red button located on the controller is in the out position I e out 7 Fit the hand control unit to the hand control socket located on the base of the control unit NOTE The hand control unit can only be fitted in one orientation into its socket Do not us
5. in all directions and that it is se curely attached to the boom o Examine the sling hooks on the spreader bar for excessive wear o Raise and lower the lift by operating the handset if the lift makes a bleeping sound DO NOT USE as it needs to be charged o Ensure the lift is off charge before use and all leads are fully engaged into their sockets o Make sure the mast is fully engaged and the locking nut is fully tightened o Examine slings for fraying or other damage DO NOT use sling with fraying or damage to the suspension straps or tears in the body of the sling 5 2 Warning Notes Your M Series Lift lift has been manufactured and tested to exceed BS EN 10535 2006 This does not mean that it can be used without care ALL OPERATORS should have read the operating instructions and appreciate this warning section 1 ALLLIFTS are less stable on sloping surfaces A 5 degree slope is the maxi mum permitted and then only with great care 2 ALL LIFTS are less stable when the load is at maximum height 3 ALLLIFTS are less stable when the load is swinging 4 ALL LIFTS are dangerous to the person being carried when used recklessly or pushed at speed 5 DO NOT allow water to enter hand set or battery control box or use the lift out side in wet conditions M Series User Manual Rev 10JAN2012 Page 15 PRISM MEDICAL 7 AAI UU 8 Prism Medical 201 1 6 0 TECHNICAL SPECIFICATION 6 1 Dimensions amp Weights Model Speci
6. ERTED TO o THE NEW READING FOR ACTUATOR REPLACEMENT o THE NEW BATTERY REPLACEMENT DATE THE LIFT IS NOW READY FOR USE PLEASE READ THE OPERATING INSTRUCTIONS CAREFULLY M Series User Manual Rev 10JAN2012 Page 5 PRISM MEDICAL Prism Medical 201 1 2 0 LIFT FEATURES 2 1 Batteries Re Charging the Batteries An audible warning will sound when the batteries need charging and a visual LCD at the bottom of the control box will display one bar A fully charged lift will display four bars Do not continue to use the lift beyond the lifting opera tion in progress at the time the warning first sounds Two 12V batteries are located within the power pack They are charged through a figure of eight shaped socket in the base of the control unit When charging is re quired the mains lead is plugged into a wall outlet and the socket into the base of the control box Fitting removing mains lead to Image showing the green power ON light and the amber CHARGE light from Control Box NOTE Emergency Stop Button must be in OUT position when charging 1 Fit the mains power lead to the small figure of eight shaped socket in the base of the control unit 2 Plug the charged main plug into a suitable mains outlet and switch the main supply ON 3 The ON light on the control box will be green to show that the power is reaching the control box The Charge light will illuminate amber initially to show that the
7. M Series Mobile Lift PRISM MEDICAL User Manual 45 Progress Parkway Maryland Heights MO 63043 USA Toll Free 1 800 265 0677 CN 1 866 891 6502 US e mail info prismmedicalltd com website www prismmedicalltd com M Series User Manual Rev 10JAN2012 Page PRISM MEDICAL ee Prism Medical 2011 Table of Contents M Series Mobile Lift Range 1 0 Assembly Instructions 1 1 Initial Assembly 3 1 2 Setting the Actu Log Optional Feature Sold Separately D 2 0 Lift Features 2 1 Batteries Re Charging 6 2 2 Emergency Stop Button 7 2 3 Emergency Lowering Raising 7 2 4 Control Box Overview 8 2 5 Handset 9 2 6 Kick Tip Bar 10 2 7 Sling Guide 11 2 8 Sling Types 11 3 0 Operating instructions 3 1 To Change the Leg Width 12 3 2 Positioning 12 3 3 Raising amp Lowering 12 4 0 Safety precautions 4 1 Do s amp Don ts 13 5 0 Safety Checks 5 1 Daily Check List 15 5 2 Warning Notes 15 6 0 Technical Specification 6 1 Dimensions amp Weights 16 6 2 Maximum lifting Height amp leg width 17 6 3 Electrical detail 17 6 4 M 400 Main Assembly Components 18 6 5 M 330 Main Assembly Components 19 7 0 Troubleshooing Maintenance 7 1 Troubleshooing 20 7 2 Service Maintenance 20 7 3 Cleaning amp Sterilisation 20 8 0 Test certificate 21 9 0 Guarantee 22 10 0 Testing and service record 10 1 Initial Information 23 10 2 Service record History 24 M Series User Manual Rev 10JAN2012 Page 2 PRISM MEDICAL
8. all mechanical parts found to be defective due to manufacturers defect for a period of twenty four months from the date of purchase CONDITIONS To be observed to preserve the warranty 1 The equipment must be used at all times in accordance with the instructions provided 2 he equipment must be serviced at intervals of not more than twelve months by a Prism Medical approved service agents 3 The dates of service must be recorded in the service record contained in this log book 4 Damage occurring owing to misuse abuse or accidental damage is not covered o Batteries are restricted to a 90 day warranty from Date of Purchase where applicable a six monthly inspection M Series User Manual Rev 10JAN2012 Page 22 PRISM MEDICAL O PSUUU E e we Prism Medical 201 1 10 0 Service Record History 10 1 Initial Information Complete the following section on Purchase and Service Information as soon as this equipment is supplied Use the service record history to record to any completed service and repairs Ensure that the service record is signed and dated each time it is used Be sure to have this piece of equipment serviced on a regular basis 6 monthly where applicable PURCHASE INFORMATION Product Name Prism Medical M Series Mobile Lift Model M3300 M4000 Date of Purchase Serial Purchased From Address City Postal Code Telephone No Comments SERVICE INFORMATION Contact the fol
9. ave reached desired level simp ly release button and lift will stop in that position M Series User Manual Rev 10JAN2012 Page 12 PRISM MEDICAL O 7D A S 8 Prism Medical 201 1 4 0 SAFETY PRECAUTIONS A 4 1 Do s and Don ts E Please read and follow the safety precautions listed below The operation and the use of the Prism Medical M series Mobile Lift is straightforward These basic safety precau tions will help make lifting operations easy and trouble free ALWAYS plan your lifting operations before commencing ALWAYS carry out the DAILY CHECK LIST next section before using the lift ALWAYS read this manual and familiarise yourself with the operating control and safety features of the lift before lifting a patient DO NOT use a sling unless it is recommended for use with the lift ALWAYS check the sling is suitable for the particular patient and is of the correct size and capacity NEVER use a sling which is frayed or damaged ALWAYS fit the sling according to the instructions in the user manual ALWAYS check that the safe working load of the lift is suitable for the weight of the patient ALWAYS carry out lifting according to the instructions in the user manual NEVER disconnect or bypass a control or safety feature because is seems easier to operate the lift NEVER force an operating or safety control Forcing will only strain or damage the lift and may compromise safety DO NOT lift a patient whilst the brak
10. batteries are receiving a charge 4 The amber light will go out once the batteries are fully charged Charging is automatic and will fully charge the batteries over a period of eight to twelve hours NOTE Batteries should be kept on charge when lift is not in general use This ensures ready availability of lift and prolongs battery life The internal charger in the control box will not allow the batteries to overcharge In accordance with battery manufacturers recommendations all batteries should be fully charged for twenty four hours every four months if in storage or not in regular use DO NOT use the lift when the mains lead is connected to the wall EE DO NOT expose the battery or control box to water T To return the lift to service switch OFF the mains supply and re move the plug from the socket outlet The charger lead can either be removed from the control box and stored separately or left in sit on the lift with the mains plug resting on the plug bracket The lift is now ready for use M Series User Manual Rev 10JAN2012 Page 6 PRISM MEDICAL A HU e mg Prism Medical 201 1 2 2 Emergency Stop Button During all operations and at all times the stop button should be in the out position In the unlikely event of a failure of the handset control it is possible that the electric actuator either continues to lift or continues to lower This may be overridden by pressing the Emergency stop button to stop the actuat
11. designs combined with the use of modern materials and technology which produces comfort security support and dignity for the user and aids correct application of the sling by the carer The range of slings are equally suitable for Mobile and Ceiling track lifts All our slings are produced in the UK or North America and are designed and tested to the 15010535 standard They are manufactured in an accountable quality controlled ISO facility Contact your local representative for more information M Series User Manual Rev 10JAN2012 Page 11 PRISM MEDICAL Prism Medical 201 1 3 0 OPERATING INSTRUCTIONS M Series Mobile Lift Before use you should familiarise yourself with use of the lift the procedure for opening closing the leg sections and raising and lowering the lift including emer gency stop lower and raise functions Appropriate training in lifting and handling pro cedures should be undergone by any person operating a mobile lift or sling for their own and the clients safety and comfort These instructions are designed to cover the method of using of the Prism Medical mobile rather than good manual handling practice 3 1 To Change the Leg Width The legs on the base unit of the M Series Mobile lift are electrically operated The leg positioned is adjusted by pressing the appropriate button on the handset Lifting manoeuvres can be completed with the legs in any position 3 2 Positioning 1 Fit person to be lifted with a su
12. e o 6 Month Inspection o Repair o Yearly Inspection Other Signature Page 27 PRISM MEDICAL A Prism Medical 2011 M Series User Manual Rev 10JAN2012 NOTES Page 28 PRISM MEDICAL oe Prism Medical 2011 PRISM MEDICAL Disclaimer While every effort has been made to ensure the accuracy of information contained in this user manual no liability can be accepted by Prism Medical for any errors or omissions Prism Medical operates a policy of continuous improve ment Specifications and other data are subject to change without notice 45 Progress Parkway Maryland Heights MO 63043 USA Toll Free 1 800 265 0677 CN 1 866 891 6502 US e mail info prismmedicalltd com website www prismmedicalltd com M Series User Manual Rev 10JAN2012 Page 29 PRISM MEDICAL Prism Medical 2011
13. e force to introduce the hand control plug into its socket The plug when correctly inserted should be pushed firmly home 8 Fit the battery pack to the control box making sure that it clicks into position 9 Fit the Actu log onto the bracket of the lift and insert the jack plug of the Actu log into the actuator socket located at the base of the control box The indicator label will identify the correct socket 10 Plug the actuator jack plug into the Actu log 11 Ifthe Actu log details are not completed on the Actu log the Actu log has not been set Therefore you need to Set the Actu log see section Setting the Act log If the Actu log label is completed check the Actu log reading does not exceed the reading in box C Note The Actu log is an optional feature that can be purchased M Series User Manual Rev 10JAN2012 Page 4 PRISM MEDICAL Prism Medical 201 1 ASSEMBLY INSTRUCTIONS 1 2 Setting The Actu log Optional Feature Sold Separately Complete box with the replacement figure of the actuator FREEWAY Actu log H In order to set the correct display number on the me Actu log for actuator replacement it is necessary to calculate the number of minutes that equate to the life of the lift A To do this 1 Ensure the actuator is completely down by pressing the down button on the handset until no further movement is detected Then carefully time a full cycle of the actuator i e from bottom limit up to top li
14. e lift must be kept as wide as possible to maintain its overall stability DO NOT place hand s on the actuator while it is extending or lowering The lift has features which improve its electromagnetic immunity but immnunity from interference cannot be guaranteed For best performance keep transmitting devices cell phones amp hand held radios away from the lift Other Symbols Used This symbols is used to point out instructions and information related to work place safety where injury may occur if the information is disregarded or ignored Follow these instructions be careful and attentive at all times Warning symbol against pinch point on the actuator Body Weight 4 TYPE B APPLIED PART Class I Equipment electrical equipment in which protection against electric shock E does not rely on basic insulation only TK Alternating current Direct current M Series User Manual Rev 10JAN2012 Page 14 PRISM MEDICAL D A HUE Prism Medical 201 1 5 0 SAFETY CHECK LIST The following checks are those recommended by Prism Medical and are supplementary to requirements that may be applicable for current Lifting and Handling and other health and Safety regulations 5 1 Daily Check List The following checks should be carried out daily before using the lift o Make sure the lift moves freely on its casters o Make sure that leg opening and closing is functions correctly o Check the spreader bar for free movement
15. es on the rear castor are in the on position unless lift ing from the floor NEVER attempt to manoeuvre the lift by pushing or pulling on the mast boom or patient as the lift may become unstable and may tilt and tip over ALWAYS Push and Pull the lift by using the handle provided ALWAYS lower the patient to the lowest comfortable position before transfers If moving the patient over short distances ensure that the patient is at the lowest position possible to help maintain the lift s stability DO NOT push a loaded lift at speeds which exceed a slow walking pace Transport position for safe handling during transport with the lift Move Forward of Backward with Handle provided DO NOT move sideways with the lift Continued M Series User Manual Rev 10JAN2012 Page 13 PRISM MEDICAL UU 8 Prism Medical 201 1 SAFETY PRECAUTIONS AN DO NOT push the lift over uneven or rough ground particularly if loaded DO NOT attempt to push or pull a loaded lift over a floor obstruction which the casters are unable to ride over easily DO NOT bump the lift down steps loaded or unloaded this will damage the casters DO NOT attempt to negotiate a loaded lift on a slope ALWAYS apply the brakes when parking a lift NEVER use mobile lifts in a shower NEVER charge an electric lift in a bathroom or shower room YOUR lift is for patient lifting DO NOT use it or allow it to be used for any other purpose The base of th
16. fication M330 M400 Maximum Lifting Height Minimum Lifting Height Internal Leg Closed 320 620 Overall Length 1140 240 Spreader Bar at Max Reach Reach at Max Height Reach at Min Height Turning Radius Legs Open External Width Legs Open Internal Width Legs Closed External Width 72 Legs Closed Internal Width 320 Overall Height of Legs Ground Clearance Maximum Weight Capacity Front win Castors Rear Braked Castors Weights Mast amp Boom inc all fixings Base Assembly Assembled Unit Battery Normal Operating Conditions Temperature 10 40 C Relative Humidity 30 75 RH Atmospheric Pressure 700 to 1060 hPa Shipping Storage Conditions Temperature 40 to 70 C Relative Humidity 10 100 RH Atmospheric Pressure 500 to 1060 hPa M Series User Manual Rev 10JAN2012 Page 16 PRISM MEDICAL gem Prism Medical 2011 TECHNICAL SPECIFICATION 6 2 Maximum lifting Height amp leg width M330 M400 6 3 Electrical detail Electrical Specifications Batteries 2 x 12 volt rechargeable sealed lead acid Battery capacity 2 9 ampere hours Charger Input U In 100 240Vac 50 60Hz In Max 400 mA 37 53 VA Charger Output 27 4 29 0Vdc 9 0 8A U Out 24Vdc max 250VA Duty Cycle 1096 use 909 rest Int 1096 Max 2 min 18min Electric shock protection Charger Class 11 Lift Internal Power Source Degree of Shock protection Charger Type B
17. ignature Company Remarks amp Action Taken M Series User Manual Rev 10JAN2012 Page 26 PRISM MEDICAL Oe Prism Medical 201 1 Service Record History Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken M Series User Manual Rev 10JAN2012 Complete this section after each service repair inspec tion and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection Other Signatur
18. itable sling Instruction should be taken in the fitting of slings to ensure maximum safety and comfort A full assessment should be carried out by a qualified person and carers should be trained in the correct use See sling safety 2 Select lift leg position required Position lift near person to be lifted It is rec ommended to position the lift on a slight angle to prevent the legs from hitting the pon Assuming you are lifting on a level surface never use the brakes on the lift This allows the lift to align its self before lifting Ensure ALL sling loops are attached over the safety hooks on carry bar NOTE It is recommended to only use the brakes when carrying out lifts on off the floor OR for when the lift is not in use amp on charge 3 3 Raising amp Lowering 3 loraise a person press handset button marked with upward facing arrow When the sling straps become taut before the lift is commenced check the straps are secure in position over the hooks of the carry bar before continuing the lift When the desired height has been reached release button and lift will Stop 4 When moving a person use the mast push handle and walk with the lift NEV ER pull or twist at arms length this can cause injury to the carer 5 When desired position is reached position the lift on a slight angle ready for lowering 6 To a lower person press and hold handset button marked with downward facing arrow and lift will descend When you h
19. lowing company for service Company Address City Postal Code Telephone No Comments M Series User Manual Rev 10JAN2012 Page 23 PRISM MEDICAL A HH 8 Prism Medical 201 1 10 2 Service Record History Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Companv Remarks amp Action Taken M Series User Manual Rev 10JAN2012 Complete this section after each service repair inspec tion and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection Other Signature o 6 Month Inspection o Repair o Yearly Inspection Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature
20. mergency lowering buttons See previous section The actuators for the raising lowering and the leg spreading are connected using jack plugs into the bottom of the control box Raising and lowering actuator is connected via the Actu log See Actu log section LCD Display The onboard LCD display shows the actual battery capacity and indicates when the battery is in need of charging The display also shows that the lift is charging once it has been correctly connected to a mains supply Power ON MN LCD Display Indicator Charging Indicator OH CHARGE Handset Connection Mains Connection L1 Actu Log Connection L2 Leg Actuator Connection M Series User Manual Rev 10JAN2012 Page 8 PRISM MEDICAL Prism Medical 201 1 2 5 Handset The M series range of mobile lifts benefit from the latest technology available for use in patient lifts The handset operates 4 functions on the lift unit They are 1 Raises the lift 2 Lowers the lift 3 Opens the legs on the base unit 4 Closes the legs on the base unit The handset is attached to the control box via a curly flexible cable that is secured in place with a bayonet type fitting The curly flex is designed to give the greatest number of options for carer positioning without having a trailing cable around the patient The back of the handset has a large magnetic section that enables the user to posi tion the handset anywhere on the mast or boom whils
21. mit and immediately down Do not time any time in which the actuator is not in motion 2 The safe life of the actuator is 40 000 multiply this by the reading you have just taken in instruction 1 Example o One full cycle takes 1 minute Manufacturer gives 40 000 cycles as life of actu ator Actu log actuator reading for replacement is therefore 1 x 40 000 40 000 Write 40 000 in box C o One full cycle takes 45 sec Manufacturer gives 40 000 cycles as life of actua tor 45 divided by 60 to turn seconds into minutes x 40 000 30 000 Actu log therefore is marked in box C as 30 000 Battery replacement New batteries for the Actulog are available with a new label to attach to the unit The battery replacement date is shown on the Actu log when you receive the unit In order to preserve a continuous record of actuator use the battery should be replaced at the service before the battery is due to require replace ment Battery life is 3 years BEFORE REPLACING THE BATTERY 1 Make a note of the Actu log reading 2 Replace the battery A soldering iron will be required 3 Apply the new label Deduct the reading of the Actu log before the battery was replaced from the number on the original label Write the resultant figure on the new label completing all other boxes as above IN THE EVENT OF A BATTERY NOT SUPPLIED BY PRISM MEDICAL OR FREEWAY BEING USED AND A NEW LABEL NOT BEING AVAILABLE IT IS ESSENTIAL THAT THE USER IS AL
22. nspection o Repair o Yearly Inspection Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Page 25 Signature PRISM MEDICAL e Prism Medical 201 1 Service Record History Complete this section after each service repair inspec tion and or maintenance Photocopy additional pages as required Service Type o Periodic Inspection o Monthly Inspection 36 Month Inspection o Repair o Yearly Inspection o Other Completed By Printed Name Signature Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection o 6 Month Inspection o Repair o Yearly Inspection o Other Completed By Printed Name Signature Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection o 6 Month Inspection o Repair o Yearly Inspection o Other Completed By Printed Name Signature Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection o 6 Month Inspection o Repair o Yearly Inspection o Other Completed By Printed Name Signature Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection 36 Month Inspection o Repair o Yearly Inspection o Other Completed By Printed Name Signature Company Remarks amp Action Taken Service Type o Periodic Inspection o Monthly Inspection o 6 Month Inspection o Repair o Yearly Inspection o Other Completed By Printed Name S
23. o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature Page 24 PRISM MEDICAL A Prism Medical 201 1 Service Record History Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken Service Type a Periodic Inspection o Monthly Inspection Completed By Printed Name Company Remarks amp Action Taken M Series User Manual Rev 10JAN2012 Complete this section after each service repair inspec tion and or maintenance Photocopy additional pages as required o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month Inspection o Repair o Yearly Inspection o Other Signature o 6 Month I
24. or To re set the button after it has been pressed simply twist it slightly clockwise and the button will spring out wards Emergency Stop Button THE LIFT WILL NOT OPERATE WITH THE STOP BUTTON PUSHED IN 2 3 Emergency Lowering raising Manual emergency lowering is facilitated by turning the emergency lowering ring clockwise The ring is situated at the top of the actuator where the actuator connects to the mast NZ Twist Clockwise to Lower Electrical emergency lowering is facilitated by pressing the emergency lowering button that is situated on the front of the control box thin item like a ball point pen will be required to press this button as it is recessed in the case Emergency Lowering Button M Series User Manual Rev 10JAN2012 Page 7 PRISM MEDICAL ee Prism Medical 201 1 2 4 Control Box Overview The control box has been specially developed for patient lifts and the complete sys tem is medically approved and contains a series of features that meet the pa tients needs for a safe and comfortable transfer e g soft start function for raising and lowering The control box has an integral charger and so removes the issues of lost or damaged chargers The lift is connected to the mains via a mains lead that is made from a curly flex to give a greater length of cable without the need for trailing cables on the floor See the section Re charging the batteries The control box has Integral e
25. t attending to the patient Clear and easy to understand button diagrams enable ease of use for the caregiver M Series User Manual Rev 10JAN2012 Page 9 PRISM MEDICAL O ASUU e mg Prism Medical 201 1 2 6 Foot Bar The M Series mobile lift range has a foot bar situated at the rear of the base unit to help facilitate the clearing of door thresholds and to help raise the front end when loading the lift into a vehicle for transport The bar also protects the casing under which the motor is situated that operates the leg opening mech anism The bar has a not slip surface to maintain grip whilst being used The bar can also be used to aid the movement of the lift on difficult surfaces where the lift doesn t move freely M Series User Manual Rev 10JAN2012 Page 10 PRISM MEDICAL 7 HU m Prism Medical 201 1 2 7 Sling Guide On the boom of every lift there is a sling sizing guide for the Prism Range of slings This facilitates easy identification of the available slings in a multi use environment The M Series can also be used with a variety of Waverley Glen Slings SIZE XX LARGE LARGE MEDIUM SMALL JUNIOR CHILD SLING SIZING GUIDE Hygiene Velcro Hygiene Buckle The Prism range of slings are the result of many years of experience in assessment and clinical expertise combined with input from professional workers and users of slings As a result the range is a collection of subtly unique
Download Pdf Manuals
Related Search