OSO Accu 50R
Contents
1. Utstedt Oslo 17 august 1993 Forandringer forbeholdes Subject to changes without notice Garantibestemmelser Garanti OSO rustfrie trykktanker garanteres fri for material og eller fabrikasjonsfeil i 10 r fra kj psdato El utstyr og ventiler garanteres i 2 r OSO leverer ny eller reparert del fraktfritt til kunde forutsatt at defekt del leveres fraktfritt OSO innen 2 uker Garantivilk r 1 Ved salt kloridholdig vann over 50 mg CI I m anode monteres f r vann p fylles Ved salt kloridholdig vann over 250 mg CI 1 bortfaller garantien 2 Montasje og service er forskriftsmessig utf rt se montasjeanvisning og vann p fylles f r str m tilkobles 3 Dersom varmtvannsberederen ikke er i jevnlig bruk fra monteringstidspunkt m den gjennomspyles med rent vann pne varmtvannskranen i minst 15 min minst n gang i uken de 4 f rste ukene etter installasjon 4 Ved kalkholdig vann over 5dh garanteres ikke el kolben Levetiden forlenges hvis termostat stilles p maks 65 C eller kalkoppl ser monteres 5 Feil grunnet feilaktig montasje reparasjon frost overtrykk overspenning lynnedslag eller utsettelse for saltdannende prosesser dekkes ikke av garantien 6 Originale OSO reservedeler m benyttes Laboratorievurdering av evt skade kan bestilles MONTASJE VIKTIG 1 Berederen skal monteres i rom med sluk Vannstopp ventil med f ler m ellers monteres 2 Benkberedere skal i tillegg til pkt 1 h2. When filling water breathe the vessel through the 22 connection on top of unit Electrical connection All connection and service to the electrical components in this product RE and RCE models is to be performed by an autho rized electrician All electric cables going into this product must be fitted with an approved cord ancorage Always fill unit with water before connecting the power supply Annual check up When the system is installed check all connections for leaks Repeat after approx one week in service then check annually The function of the safety valve must be checked annually by opening the valve to ensure water flows freely Turn knob on safety valve counterclockwise until water flows continue counterclockwise until valve snaps shut Important The safety valve outlet must never be plugged or blocked Electric service Shut off power supply Remove el box lid and tighten all connections Check electric cables for damage Refit el box lid before power supply is turned on If any damage to electrical components is discovered contact approved electri cian and replace damaged parts with original spare parts Electrical connection Standard from factory 230V 3 ph Can be upgraded to 400V 3 ph All internal wiring is factory fitted If necessary the power output can be reduced by removing jumper s in accordance with the table below All service to electrical components ts to be performed by authorized electrician
3. 3x3 Heat storage w el 2430 x 680H 4x1 15 mm 12 22 mm 501 417kg OG cots SORE 100 9 kW 3x3 Heat storage w el 2430 x 1210H 4x1 15mm 1 2 22mm 1001 22kg 0 24 801 1201 50RE 300 15 kW 3x5 Heat storage w el 580 x 1650H 4x5 4 215mm 1 2 22mm 2871 63kg 0 58 801 1281 50RC 300 coil 2 6m Heat storage w coil 580 x 1650H 4x5 4 15 mm 3 4 1 2 22mm 2871 70kg 0 58 801 1182 SORCE 100 9kW coil 0 7m Heat storage w coil el 430 x 1210H 4x1 215mm 3 4 1 2 22mm 100i 27kg 0 24 801 1311 50RCE 300 15kW coil 2 6m Heat storage w coil el 580 x 1650H 4x5 4 15 mm 3 4 1 2 22mm 2871 72kg 0 58 801 1312 Forandringer forbeholdes Subject to changes without notice Unpacking and installation gt lt Important Read instructions before filling the unit Unpacking Place unit on its back Remove cardboard box Safety valve 3 bar is factory fitted to 15 mm connection near the bottom Installation and pipe fitting Place the unit upright and level Use supplied adjustable feet the 50 and 100 I units are NOT fitted with adjustable feet but can be fitted to a wall wall bracket is supplied All pipe fitting and electrical connection must be done by authorized installer Connection dimensions See table on previous page An overflow pipe should be connected to the expansion valve Important Fill the vessel with water before connecting electrical power RE and RCE models Otherwie the guarantee Is void
4. coil electric reheater elements RCE only factory fitted Connections are the same as 50R above Safety valve 3 bar fac tory fitted Supplied as 100 and 300 litres units RC only 300 Technical data see table below Insulation All units are insulated by 40 mm mineral wool covered by a white epoxy coated steel outer jacket Electric element banks 5ORE and 50RCE are equipped with an electric reheater element bank near the top of the vessel the 50 and 100 litres units is fitted with a 9 kW 3x3 element bank while the 300 litres unit is fitted with a 15 kW 3x5 element bank More info regarding element banks on page 6 10 year warranty r E I The stainless steel pressure vessel has a 10 year warranty remai ning parts 2 years The product is 100 recyclable SORC 300 SORCE 100 300 Spare parts Prod name Type Description Part no RGK 1 3 kW Electric element short For RE 50 and 100 RCE 100 801 5042 RG 1 5 kW Electric element standard For RE 300 and RCE 300 801 5012 TSL 30 60 C Thermostat preset 45 C For all units 801 5892 SV 3 bar Safety valve For all units 840 5007 Technical data Conn Conn Conn Sensor Top Prod name vol kW Suited for Diam x H mm flow ret drain coil pocket conn Volume Weight M Prod no 50R 100 Storage for hp 2430 x 1210H 4x1 15 mm 1 2 22mm 1001 20kg 0 24 801 1205 50R 300 Storage for hp 2580 x 1650H 4x5 4 215mm 1 2 22mm 2871 53kg 0 58 801 1203 50RE 50 9 kW
5. 145026 03 50R 01 2014 o lt o gt Vik NAMN TG n R R RE RC E RCE s 2 u SIA gt RI a h RCE 5 IS 1d RCE p E gt MOTWATER MADE IN NORWAY Installert av Installed by Aut r rlegger Plumber Tel Dato date Aut elektriker Electrician Tel Dato date Bruker er informert og mottar denne anvisning User is informed and handed this document Dato date OSO Accu 50 serie varianter Akkumulatortanken ker gangtiden for varmepumpen og bedrer dermed effektiviteten og levetiden Varianter med el ettervarmer kan ogs benyttes som en frittst ende varmekilde f eks i kombi nasjon med OSO FIX MX pumpesentral be om egen brosjyre eller se www oso no Alle 50 serie er godkjent for 10 bar trykk Accu 50R akkumulatortank uten el ettervarming Beregnet for akkumulering for varmepumpe 100 I 4x1 tur retur anslutninger oppe nede 300 l 4x5 4 tur retur anslutninger oppe nede 1 stk 22 mm toppstuss for lufting samt en l5mm avtapnings stuss nede i front 1 2 f lerlomme i siden oppe Sikkerhetsventil 3 bar fabrikkmontert Leveres i volum 100 og 300 liter Tekniske data se tabell Accu 50RE akkumulatortank med el ettervarmer Beregnet for akkumulering for varmepumpe med elektrisk et tervarming Anslutninger som 50R over se ogs tabell nederst p siden Sikkerhetsventil 3 bar fabrikkmontert Leveres i volu
6. Selectable effect output Factory fitted gt 9 0kW 15 0 kW Remove jumper gt 7 5kW 12 5 kW Remove jumper 1 2 36 0 kW 10 0 kW Remove jumper 1 2 G gt 4 5 kW 7 5 kW Power supply only to element 33 0 kW 5 0 kW Remove jumper 1 230V 1 ph gt 1 5 kW 2 5 kW Forandringer forbeholdes Subject to changes without notice Installation suggestions gt lt Central heating Central heating Peer Perr E 100 Heat pump 50RE 50 ma mm O ANN a fa 4 gt Central heating Central heating 00 J Heat pump Peer rrr errr errr ers Central heating Central heating E 100 100 Heat pump Heat pump sorc PVD SORCE PR o The OSO Accu 50 series can be fitted in many configurations Above is shown a few examples ty D Sj faa me iT INTERNKONTROLL ATTEST Herved bekreftes at A S OSO OSO Hotwater A S tilfredsstiller kravene til et godt arbeid med Helse Milj og Sikkerhet Denne attesten gjelder f lgende virksomhetsomr der Produksjon og salg av Varmtvannsberedere Attest Nr 001
7. a vanntett spillbakke og ha adkomst som sikrer tilgang til ventiler og elektrisk utstyr 3 Inng ende KV trykk b r ha maxtrykk p 6 bar Hvis h yere m trykkreduksjon ventil monteres 4 Sikkerhetsventilens overl psr r skal v re frostfritt uavstengbart og minst 18 mm innv med fall til sluk NB F lgeskadeansvar gjelder kun n r dette er fulgt OSO anbefaler at montering utf res av aut r rlegger GENERELL BRUK VIKTIG Dette apparat er ikke ment for bruk av personer inkludert barn med reduserte fysiske eller psykiske evner eller mangel p erfaring og kjennskap til apparatet med mindre de har blitt gitt instruksjoner eller oppl ring vedr rende bruk av apparatet av en person som er ansvarlig for deres sikkerhet Barn b r observeres og instrueres til ikke leke med apparatet Guarantee Guarantee Unvented hot water cylinder The OSO stainless steel inner vessel is guaranteed against material defect or manufacturing faults for a period of 10 years from the date of purchase All other parts including but not limited to factory fitted electrical elements damage caused by lime scale excluded thermostats and valves are guaranteed against material defects or manufacturing faults for 2 years from the date of purchase In the event of a replacement component being required OSO Hotwater will supply such part s free of charge and freight paid on condition that the defective component is delivered fright paid to OSO Hotwater within 2
8. is not fed with water from a private supply The OSO unvented cylinder has not been modified in any way other than by OSO Hotwater and is only used for the storage of potable water No factory fitted parts have been removed for unauthorised repair or replacement Defects caused by frost excess pressure salt dehardner process trancient voltage lightning strikes or incorrect installation repair or use are not covered by this warranty A labora tory evaluation of possible defects can be ordered by the user however the user must pay for this where the above mentioned conditions have not been fulfilled Evidence of the purchase date and the date of supply must also be submitted with your claim This guarantee does not confer any rights other than those expressly set out above and does not cover any claims for consequential loss or damage This guarantee Is offered as an extra benefit and does not affect your statutory rights as a consumer so EI N E IMPORTANT WHEN FITTING UNIT 1 The water heater should be installed in a room equipped with gully Otherwise a water shut off valve with sensor must be fitted 2 Maximum cold water inlet pressure is 6 bar A pressure reduction valve must be fitted if necessary 3 The overflow pipe from the safety valve must have an inner diameter of at least 18 mm and must be led to a gully at a declining angle if possible Please note Manufacturer responsibility for any consequential damage only applies when the ab
9. ker pa elementene se nedenfor All tilkobling og arbeid med elektriske komponenter skal utf res av autorisert elektriker fekt Fabrikkmontert 39 0kW 15 0 kW A VIKTIG A Fjern lask gt 7 5 kW 12 5 kW Fjern lask O 36 0 kW 10 0 kW Fjern lask M 94 5 kW 7 5 kW El tilforsel kun til kolbe 1 33 0 kW 5 0 kW Fjern lask 1 230V 1 f gt 1 5kW 2 5 kW Ved elektrisk tilkobling av varmtvannsbereder skal gjeldende versjon av NEK 400 f lges ved nyinstallasjon av bereder med 2 kW eller h yere m autorisert elektriker s rge for fast montasje Forandringer forbeholdes Subject to changes without notice Koblingsforslag ge 3 Varmeanlegg E 00 i 100 ae SORE 50 PV 12 i peenddanaaadAtAAAGGHAGSHNSSSANNONNGOEEEENSG ENGS Er ppm b 3 Varmeanlegg J Varmeanlegg Too j Varme pumpe 50R PV 12 EETTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTT ee Varmeanlegg I Varmeanlegg KV Varme pumpe li fan mm W SORCE T PVI2 mm INTERNKONTROLL ATTEST Herved bekreftes at A s OSO OSO Hotwater A S tilfredsstiller kravene til e
10. m 50 100 og 300 I Accu 50RC og RCE akkumulator med coil og el ettervarmer Beregnet for akkumulering for varmepumpe Innebygget rustfri coil og el ettervarmer kun RCE fabrikkmontert Anslutninger som 50R over se ogs tabell nederst p siden Coilanslutning 3 4 tur ret Sikkerhetsventil 3 bar fabrikkmontert Leveres i volum 100 og 300 I RC kun 300 I Isolasjon Alle er isolert med 40 mm milj vennlig mineralull Glava kledd med epoxylakkert hvit st lmantel El sentraler SORE og 50RCE er utstyrt med en el sentral for ettervarming plassert h yt oppe i tanken 50 amp 100 I volum har 9 kW 3x3 sentral mens 300 I volum har 15 kW 3x5 sentral montert For mer info om el sentraler og koblingsskjemaer se side 3 10 rs garanti Trykktanken i rustfritt st l har hele 10 rs garanti mot material eller produksjonsfeil El utstyr og ventiler har 2 rs garanti Bere r deren avgir ingen skadelige utslipp hverken i drift eller under produksjonen og hele produktet kan resirkuleres 100 SORC 300 SORCE 100 300 Reservedeler Prod navn Type Beskrivelse NRF varenr RGK 1 3 kW Element kort For RE 50 og 100 RCE 100 801 5042 RG 1 5 kW Element standard For RE 300 og RCE 300 801 5012 TSL 30 60 C Termostat preset 45 C For alle 801 5892 SV 3 bar Sikkerhetsventil For alle 840 5007 Tekniske data Ansl Ansl Ansi F ler Ansi Best nr ca I kW Passer for DiaxHmm _ tur ret avt coil lomme luf
11. ove statements has been followed OSO recommends that the water heater is fitted by authorized personnell GENERAL USE IMPORTANT This appliance is not intended for use by persons including children with reduced physical sensory or mental capabilities or lack of experience and knowledge unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety Children should be supervised to ensure that they do not play with the appliance OSO HOTWATER AS OSO HOTWATER EXPORT AS OSO HOTWATER UK Ltd OSO Norway Export Industriveien 1 P O Box 112 N 3300 Hokksund Norway OSO UK E15 Marquis Court Team Valley Trading Estate Gateshead Tyne amp Wear NE11 ORU United Kingdom Tel 47 32 250000 gt Fax 47 32 25 00 90 N EXP Web www oso no www osohotwater com E mail oso oaso no exportQosohotwater com UK Web www osohotwater co uk E mail sales uk oso hotwater co uk technical uk oso hotwater co uk UK tel Sales 0191 482 0800 Technical 0191 482 7049 Fax 0191 491 3655
12. t godt arbeid med Helse Milj og Sikkerhet Denne attesten gjelder f lgende virksomhetsomr der Produksjon og salg av Varmtvannsberedere Attest Nr 001 Utstedt Oslo 17 august 1993 Forandringer forbeholdes Subject to changes without notice OSO 50 series models Se The buffer vessel reduces heat pump cycling thus improving both the efficiency and the lifespan Models with electric reheater ele ments can also be used as a separate heat source for instance in combination with the OSO FIX MX control centre All 50 series are designed for up to 10 bar water pressure SOR buffer vessel without electric reheater Suited for heat accumulation from heat pump 100 I 4x1 flow return connections top bottom 300 l 4x5 4 flow return connections top bottom A 22 mm breathing end piece on top in addition to a g15mm drain near the bottom A 1 2 sensor pocket is fitted near the top Safety valve 3 bar factory fitted Supplied as 100 and 300 litres units Technical data see table below SORE buffer vessel with electric reheater Suited for heat accumulation from heat pump with electric re heating Connections are the same as 50R above Safety valve 3 bar factory fitted Supplied as 50 100 and 300 litres units Technical data see table below 5ORE 50 50R 100 300 50RC and RCE buffer vessel with built in coil and electric reheater Suited for heat accumulation from heat pump Built in stainless steel
13. teres i rom med sluk NB Fyll tanken med vann f r str m settes p gjelder RE og RCE modellene ellers bortfaller garantien Ved fylling luftes tanken via 22 mm luftestuss i toppen El montasje All tilkobling og arbeid med elektriske komponenter skal utf res av autorisert elektriker Gjeldende verson av NEK 400 skal f lges ved installasjon Alle kabler til produktet skal monteres med passende og godkjent strekk avlaster Se ogs elkoblingsskjema nedenfor NB Fyll alltid vann f r str m settes p ellers bortfaller garantien rlig kontroll etterkontroll N r anlegget er ferdig montert sjekk at alle koblinger er tette Gjenta etter ca 1 ukes drift Sjekk deretter rlig Sikkerhetsventilens funksjon skal testes rlig ved pne ventilen og kontrollere at vannet renner fritt Vri rattet mot klok ken til vannet flommer steng ved vri videre mot klokken til ventilen stenger NB Sikkerhetsventilers utl p m ALDRI plugges eller blokkeres El kontroll Steng str mtilf rselen demont r el lokk og ettertrekk alle koblinger Sjekk ledninger for skader og mangler Mont r el lokket igjen f r str mmen settes p Ved skade p ledninger eller elektriske komponenter kontakt autorisert elektriker og bytt ut med originale reservedeler El kobling Kan omkobles til 400V 3fas Standard fra fabrikk 230V 3fas Alle interne ledninger er ferdig koblet fra fabrikk Om nskelig kan effekten reduseres ved klippe fjerne las
14. ting Volum Vekt M NRF nr 50R 100 Akk for vp 430x1210H 4x1 15 mm PS 22mm 1001 20kg 0 24 801 1205 50R 300 Akk for vp 580 x 1650H 4x5 4 615mm 1 2 22mm 2871 53kg 0 58 801 1203 50RE 50 9 kW 3x3 Varmeakk m el 430x 680H 4x1 15 mm 1 2 22mm 501 17kg 0 16 801 1199 50RE 100 9 kW 3x3 Varmeakk m el 430 x 1210H 4x1 15 mm 1 2 22mm 1001 22kg 0 24 801 1201 SORE 300 15 kW 3x5 Varmeakk m el 580x1650H 4x5 4 15 mm w2 22mm 2871 63kg 0 58 801 1281 50RC 300 coil 2 6m Varmeakk m coil 580 x 1650H 4x5 4 15 mm 3 4 1 2 22mm 2871 70kg 0 58 801 1182 SORCE 100 9kW coil 0 7m Varmeakk el coil 430x1210H 4x1 15 mm 3 4 12 22mm 1001 27kg 0 24 801 1311 SORCE 300 15kW coil 2 6m Varmeakk el coil 580x1650H 4x5 4 15 mm 3 4 172 22mm 2871 72kg 0 58 801 1312 Forandringer forbeholdes Subject to changes without notice Utpakking og installasjon NB Les bruksanvisningen fer berederen fylles Inntransport og utpakking Legg berederen pa rygg Fjern emballasjen Sikkerhetsventil 3 bar er fabrikkmontert pa 15 mm stuss nede Oppstilling og r rtilkobling Berederen monteres i lodd og vater benytt medf lgende justerbare ben 50 amp 100 I er ikke utstyrt med stillben men kan evt henges p vegg benytt medf lgende veggbrakett R r og el montasje anbefales utf rt av autorisert installat r Anslutningsdimensjoner Se tabell p side 2 Det anbefales at produktet mon
15. weeks of written notice being given to OSO Hotwater of the defect Such replacement parts shall be guaranteed under the terms of this guarantee to the unexpired period of the aforementioned 2 year period This warranty is conditional upon the OSO cylinder being installed in compliance with the OSO Installation amp Maintence Instructions all current legislation codes of practice and regula tions governing the installation of unvented hot water cylinders in force at the date of installation and provided that 1 The water supply to the cylinder shall be in accordance with European Council Directive 98 83 EC at the date of installation and not be fed from a private water supply Pay special attention to Chloride content Max 250 mg l Sulphate content Max 250 mg l Combination Chloride sulphate Max 300 mg in total 2 The OSO cylinder is serviced and maintained every 12 months Invoices for the maintenance work should be kept as proof of regular maintenance Care should be taken of the invoices as they serve as the guarantee certificate for the cylinder The OSO cylinder is filled with water before turning the electricity supply on to the heater elements If the newly fitted water heater is not in regular use then it must be flushed through with fresh water for at least 15 minutes open at least one hotwater tap once per week during a period of at least 4 weeks The mains water supply complies with EU standards current at the date of installation and
Download Pdf Manuals
Related Search