TRAC Line Hauler User Manual
Contents
1. INSTALLATION AND OPERATING INSTRUCTIONS LINE HAULER T10250 TRAC Line Hauler Pot Puller If you have any questions or difficulty installing this product TRAC is here to help First READ THIS MANUAL If you still need help call us from 9 am to 4 pm central time Monday Friday 615 462 6224 Note At this time we provide Phone Support in English only INSTALLATION AND OPERATING INSTRUCTIONS LINE HAULER Please read and save these instructions Read carefully before attempting to assemble install operate or maintain the product described Protect yourself and others by observing all safety information Failure to comply with instructions could result in personal injury and or property damage Retain instructions for future reference Unpacking When unpacking inspect carefully for any damage that may have occurred during transit Make sure any loose fittings bolts etc are tightened before putting unit into service SPECIFICATIONS Rated Line Pull 110 Ib 49 9kg Motor 12v DC Permanent Magnet Output 300W Gear Reduction Ratio 53 1 Line Speed 127 150 ft min 39 46m min Current 3 4 no load to 30 stall Amps Power Cable 10 Gauge AWG splice to 8 gauge wire for runs over 6 ft 2 m Mounting Bolt Pattern M8x45mm alternative is 5 16 x 1 3 4 or length required for application Overall Dimensions 23 6 Lx 13 W x 8 7 H 60 x 33 x 22cm Net Weight 18 9 Ib 8 5kg G2. Motor over heating e Running time is too long e Allow to cool down periodically Motor running but e Overloaded e Remove some load start motor after 15 suddenly stops 20 seconds PARTS If ordering a part provide the product model as well as the part number PART DESCRIPTION Gear Motor Screws not shown Arm Stop Screw Plastic Arm Clip TRAC Line Puller Limited Warranty This limited warranty is provided by TRAC Outdoor Products Co TRAC to the original consumer purchaser purchaser of the TRAC Line Hauler This limited warranty is not transferable to any other party TRAC will at its option repair or replace any part s of the TRAC Line Hauler which may be found by TRAC to be defective within two 2 years of purchase TRAC will pay the shipping charge to the purchaser for any part s which may be shipped by TRAC For warranty repair or replacement the purchaser must provide dated proof of purchase and notify TRAC of the request for warranty service The purchaser will notify TRAC by email at info TRAC Outdoor com or by phone at 615 462 6224 for warranty service TRAC will attempt to provide parts needed to repair the Line Puller If the Line Hauler is to be returned to TRAC purchaser will be provided a Return Goods Authorization RGA to include with any return for warranty service which will be shipped at the purchaser s expense to the address provided The purchaser must use reasonable care in maintenance and operation
3. ENERAL SAFETY INFORMATION Throughout this manual potential safety hazards will be noted with the following terms Please read and understand these terms before operating the product A WARNING A CAUTION Warning indicates a potentially hazardous situation Caution indicates a potentially hazardous situation that that COULD cause death or serious injury if the MAY cause minor or moderate injury if the warning is warning is ignored ignored It may also mean hazard that will only cause damage to property This notation is also used to alert you against unsafe practices SAFETY ISSUES The TRAC Line Hauler is a powerful piece of machinery It is important that you understand the basics of its operation and specifications so that when you need to use it you can use it with confidence and safety In this manual is a list of components of your Line Hauler and their use You should practice using your Line Hauler before you head to the water A WARNING USE CAUTION KEEP FINGERS AWAY FROM MOVING PARTS e Do NOT exceed rated capacity shown above e Intermittent use only Allow Line Hauler to cool between uses e Do NOT use Line Hauler to pull or move people in any way e Failure to heed these warnings may result in personal injury and or property damage e Use gloves to protect hands when handling the rope e TRAC Line Hauler is designed and made for intermittent use and should not be used in constant duty applications ASSEMBLY amp MO
4. UNTING 1 Drill 4 holes on the shipboard where you want to mount your TRAC Line Hauler use the mount as a template and attach with supplied screws M8x45mm 2 Slide the Line Hauler in the mounting plate locking it with a drop nose lock pin 3 Insert arm into frame hinge in first Attach Arm Stop Screw into top of frame Stop Screw is in bag with swivel pulley 4 Strip ends of your battery wire and insert into the butt splices on the end of the supplied connector Crimp butt splice to attached wire Heat butt splice insulation to seal to wire Make sure red is positive and black is negative 5 To attach rope feed the rope over the nylon wheel 1 around the lower inside pulley 2 and around the stainless rope wheel 3 From this point you have the option of pulling the rope straight down or looping the rope around the lower double pulley again for more traction 6 Pulling in your traps will require you to keep tension on the line and to pull the end of the rope 7 Start motor Put tension on rope lift trap pot l ZTA wws6 SL wwot 09 T aj ee a a 45 r a m a I I I I I I l I I I oi j NE I I ZTA Before routing rope tilt Arm up and slide into frame Insert lock pin ROPE PATH A CAUTION Batteries contain gases which are flammable and explosive Wear eye protection during installation and remove
5. all jewelry Do not lean over battery while making connections LINE HAULER ACCESSORIES YOU WILL NEED not included e Gloves for handling rope e Rope length according to your needs e Battery Wire from plug to battery e Trap type according to your needs MAINTENANCE 1 Periodically remove all dirt or corrosion and always keep clean and dry 2 Donot attempt to disassemble the gear box Email or call our customer service department at info trac outdoor com or 615 462 6224 3 The gearbox has been lubricated using a high temperature lithium grease and is sealed at the factory No internal lubrication is required TROUBLESHOOTING Symptom Possible Causes Corrective Action Motor does not turn on Switch assembly not connected 1 Check switch assembly all the way into properly the connector Loose battery cable connections 2 Tighten nuts on all cable connections Defective switch assembly 3 Replace switch assembly Defective motor 4 Check for voltage at armature port with switch pressed If voltage is present replace motor Water has entered motor 5 Allow to drain and dry Run in short bursts without load until completely dry Motor runs but sheave e Bonder on the bearing may be e Add or replace it does not turn missing or broken Motor runs slowly or e Insufficient current or voltage e Battery weak recharge without normal power e Loose or corroded battery cable connections Clean tighten or replace
6. of the product in accordance with this manual Failure to follow the instructions in the manual will void the warranty This warranty covers defects in material or workmanship of the TRAC Line Hauler This warranty does not cover failure that results from misuse improper installation accident abuse neglect modification or improper maintenance There is no other express warranty Implied warranties including those of merchantability and fitness for a particular purpose are limited to two 2 years from the date of purchase Any damage to watercraft resulting from proper or improper use of this TRAC Line Hauler is not covered under this warranty Costs of installation or repair by service centers or marine repair facilities are not covered by this warranty This is the exclusive remedy and any liability for any and all incidental or consequential damages or expenses whatsoever is excluded Some states do not allow limitations on how long an implied warranty lasts or do not allow exclusion or limitation of incidental or consequential damages the above limitations may not apply to you This limited warranty gives you specific legal rights and you may also have other rights which vary from state to state TRAC Outdoor Products Company 251A Mayfield Drive Smyrna TN 37167 www trac outdoor com info trac outdoor com 615 462 6224
Download Pdf Manuals
Related Search